2002 Volkswagen Jetta
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 711 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Jetta model years with reports.
Of the 2002 reports, 32 involved a crash and 71 involved a fire. 75 people were injured and 10 people died.
What owners report most often
Recalls and investigations
Engine and engine cooling, engineMar 7, 2014
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Campaign 14E007000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Exterior lighting, brake lights, switchFeb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V063000 on NHTSA.gov
Exterior lighting, brake lights, switchMay 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 06V183000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchDec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 04V584000 on NHTSA.gov
Exterior lighting, brake lights, switchFeb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 04V096000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slipJan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
THIS CAN RESULT IN A FIRE.
DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 02V031000 on NHTSA.gov
Representative owner complaints
711 reports, newest first.
Air bags, Jan 13, 2004, crash
I WAS INVOLVED IN AN ACCIDENT IN MY 2002 VOLKSWAGEN JETTA GLI. THE REASON I PURCHASED THE CAR WAS BECAUSE OF HOW SAFE THEY WERE SUPPOSED TO BE. THEY HAVE AIRBAGS THAT COME FROM THE SIDES OF THE SEATS, DOWN FROM THE HEADLINER, AND FROM THE DASH. I HIT A CEMENT WALL AND TOTALED MY CAR, AND NONE OF THE AIRBAGS WENT OFF. NOBODY WAS INJURED, BUT THE AIRBAGS SHOULD HAVE STILL DEPLOYED.
Seats, Jan 8, 2004, fire
CONSUMER STATED WHILE TRAVELING AND WITHOUT ANY INDICATION NOTICED SMOKE COMING FROM UNDER DRIVER'S SEAT, CAUSING CONSUMER'S JACKET TO CATCH ON FIRE. CONSUMER PULLED VEHICLE OVER, AND NOTICED A BURNT HOLE IN SEAT. *AK
Seats, Jan 7, 2004
VEHICLE CAME EQUIPPED WITH SEAT HEATERS. THE LEFT DRIVER'S SIDE SEAT GOT VERY HOT WHEN THE HEATER WAS ON. THIS RESULT IN CONSUMER BEING BURNT. *AK
Service brakes, Hydraulic, Air bags, Jan 6, 2004, crash
WHILE DRIVING 45 MPH DRIVER APPLIED BRAKES AND PEDAL WENT TO THE FLOOR. THIS CAUSED THE VEHICLE TO SKID INTO A TREE. BOTH AIR BAGS DID NOT DEPLOY. *AK
Seats, Jan 6, 2004
CONSUMER INSTALLED A DRIVER'S SIDE SEAT WARMER. IT BEGAN TO SMOLDER AND BURN A WHOLE IN THE DRIVER'S SIDE SEAT.*AK
Air bags, Jan 3, 2004
I OWN A 2002 VW JETTA THAT I HAVE HAD NUMEROUS PROBLEMS WITH. THE MOST RECENT INCIDENT OCCURRED ON DECEMBER 29, 2003. MY PASSENGER SIDE PANEL AIR BAG DEPLOYED WHILE I WAS DRIVING. THERE WAS SOMEONE IN THE PASSENGERS SEAT AND I AM THANKFUL THAT HE WAS NOT INJURED. THE DEALER HAS HAD MY CAR FOR 5 DAYS NOW. THEY ARE WAITING FOR VW TO INVESTIGATE BECAUSE THEY DON'T SEE HOW THE AIRBAG COULD DEPLOY ON ITS OWN. THERE IS SOME REAR DAMAGE THAT IS OVER A YEAR OLD AND THEY ARE TRYING TO RELATE THE AIRBAG ISSUE WITH THE OLD DENTS. I DON'T FEEL SAFE IN MY VW AND I CERTAINLY DON'T TRUST IT. *AK
Seats, Dec 29, 2003
I TURNED MY HEATED SEAT ON AND 5-7 MINUTES INTO THE DRIVE I NOTICED A BURNING SMELL AND REALIZED MY SEAT WAS REALY HOT. I TURNED THE HEATED SEAT OFF AND BURNING STOPPED. UPON VISUAL INSPECTION I NOTICED A HOLE BURNT INTO SEAT AND A SINGED DIME SIZED MARK ON MY COAT. I HAVE BEEN WITHOUT MY CAR NOW FOR 24 DAYS AND I AM STILL WAITING FOR THE PART TO GET IN THE COUNTRY. *AK
Power train, Dec 23, 2003
MY VEHICLE WAS REPURCHASED BY VWOA (VOLKSWAGEN OF AMERICA) FROM THE FIRST OWNER FOR A RECALL PROBLEM. WHEN I PURCHASED THIS VEHICLE IT CAME WITH AN ALL INCLUSIVE 12 MONTH/12,000 MILE WARRANTY AND THEN THE REST OF THE 4 YEAR/50,000 MILE WARRANTY. AT 11,700 MILES THE CLUTCH STARTING STICKING AND WOULDN'T SHIFT, THE CAR ALSO WOULD GO TO HIGH RPMS WHEN ACCELERATING, EVEN IF ONLY A LITTLE. THE NEXT DAY, I GOT OUT TO GET GAS AND I SMELLED BURNING. I LOOKED UNDER THE HOOD AND I COULD TELL SOMETHING WAS BURNT. I CALLED VW FIRST THING MONDAY MORNING AND HAD IT TOWED TO THEM. THEY TOLD ME THAT THE CAR "MAY BE" UNDER WARRANTY. I HAVE A DOCUMENT THAT CLEARLY STATES THAT IT IS. THEY CONTACTED THEIR SERVICE REP, FRED HINGLE, AND WAS TOLD THAT IF IT WAS NOT "WEAR AND TEAR" THAT IT WOULD BE COVERED. WELL VW TORE THE CAR APART, AND AFFIRMED THAT IT MUST BE WEAR AND TEAR, DO TO THE BURNT CLUTCH AND FLYWHEEL. AFTER THIS I DID SOME RESEARCH AND FOUND THAT MANY PEOPLE AT MYVWLEMON.COM HAVE HAD PROBLEMS WITH THE CLUTCH GOING OUT AT 9,000 TO 26,000 MILES, INCLUDING CAR AND DRIVER GUIDE, WHO TEST DROVE THE JETTA AND HAD THE CLUTCH GO OUT AT 26,000 MILES, AND THESE ARE PROFESSIONAL DRIVERS! THEY TOLD ME THE REPAIRS WOULD TOTAL 1551.00 DOLLARS ALMOST 10% OF WHAT I PAID FOR THE CAR. MR. HINGLE THE CORPORATE REP REFUSES TO SPEAK WITH ME. I BELIEVE THE CLUTCH USED IN THIS MODEL AND YEAR IS INDEED DEFECTIVE AND VWOA REFUSES TO DISCLOSE IT.
Air bags, Dec 21, 2003
WHILE DRIVING ON I 75 S FROM CHATTANOOGA, I HEARD A LOUD POP AND SAW SMOKE. THINKING A TIRE HAD BLOWN, I PULLED OVER. I REALIZED THE PASSENGER SIDE AIRBAGS HAD DEPLOYED. TRIPLE A TOOK THE CAR TO THE DEALERSHIP AS I WAS TERRIFIED TO DRIVE IT. IT HAS BEEN TWO WEEKS AND I STILL HAVE NOT GOT MY CAR BACK OR EVEN BEEN TOLD IF THEY WILL FIX IT. THE DEALER IS HAVING TO E MAIL PICTURES TO VW TO SHOW THAT NO DAMAGE WAS DONE. THEY ARE SAYING A SENSOR WENT OFF. NO DOUBT! IT IS OBVIOUS TO ME AND MY WITNESSES THAT THIS IS A MANUFACTURE DEFECT THAT SHOULD BE COVERED. I HAVE RESEARCHED AND FOUND THAT I AM NOT THE ONLY PERSON THIS HAS HAPPENED TOO. I PLAN TO INVESTIGATE IT FURTHER TO FIND OUT WHAT CAN BE DONE, BEFORE SOMEONE IS KILLED IN A JETTA. *AK
Power train, Dec 19, 2003
WHILE DRIVING AT 40 MPH TRANSMISSION LOCKED UP. AS A RESULT, DRIVER SUSTAINED A CERVICAL STRAIN INJURY. *AK
Seats, Dec 16, 2003
I WAS DRIVING AND NOTICED MY HIP HAD AN ITCH. I ITCHED IT AND IT SORT OF WENT AWAY. THE NEXT DAY THE SAME THING HAPPENED, BUT I TOUCHED THE SEAT IN MY CAR, AND THAT IT WAS REALLY, REALLY HOT. I STOPPED AND LOOKED, AND THE LEATHER WAS A BIT DEFROMED, AND I NOTICED A BURNING SMELL. THE HEATING ELEMENTS IN MY 2002 VW JETTA TDI WERE OVERHEATING, AND COULD HAVE CAUGHT ME OR THE CAR ON FIRE. I AM GONG TO THE DEALER TO HAVE IT LOOKED AT IN 2 DAYS. *AK
Tires, Dec 10, 2003
ALL FOUR TIRES EXPERIENCED TREAD SEPARATION. THE CONSUMER IS CONCERNED THAT MAY CAUSE A SEVERE BLOWOUT WHILE DRIVING. *AK *NLM SERVICE MANAGER NOTED HE HAS SEEN OTHER FAILURES LIKE THESE AND THERE MAY BE A TREND. *PH
Seats, Dec 5, 2003
WHILE DRIVING UNDER 55 MPH CONSUMER NOTICED THAT THE DRIVER'S SEAT WAS BECOMING TOO HOT. CONSUMER PARKED THE VEHICLE AND DISCOVERED THAT THE HEATING UNIT BURNED A HOLE IN THE LEATHER SEAT AND IN CONSUMER'S PANTS. THE VEHICLE WAS TAKEN TO THE DEALER, WHO INFORMED THE CONSUMER THAT A NEW SEAT HEATER WAS NEEDED.*AK WHILE DRIVING CONSUMER NOTICED THAT THE DRIVER'S SEAT WAS BECOMING TOO HOT. CONSUMER PARKED VEHICLE AND DISCOVERED THAT THE HEATING UNIT HAD BURNED A HOLE IN THE LEATHER SEAT AND IN THE CONSUMER'S PANTS. VEHICLE WAS TAKEN TO THE DEALER WHERE CONSUMER WAS INFORMED THAT THE SEAT HEATER NEEDED TO BE REPLACED.*MR
Seats, Dec 5, 2003
MY ELECTRONICALLY HEATER DRIVER SEAT OF MY 2002 VW JETTA OVERHEATED AND BURNED MY SEAT CUSHION. *JB
Seats, Dec 3, 2003, fire
VEHICLE'S SEAT HEATER CAUGHT ON FIRE.*MR CONSUMER SMELLED BURNING AND ROLLED DOWN THE WINDOW ABOUT THREE INCHES DUE TO THE RECENT FOREST FIRES. SHE THEN FELT A BURNING SENSATION, LOOKED DOWN AND SAW A 6-8" FLAME COMING UP HER LEFT SIDE. SHE WAS BURNED AS WELL AS HER CLOTHING AND SEAT. CONSUMER PULLED OVER TO THE SIDE OF THE ROAD. PICTURES WERE SENT TO NHTSA VIA EMAIL. *PH
Seats, Dec 3, 2003, fire
THE CONSUMER SMELLED SMOKE WHILE TRAVELING WITH THE DRIVER'S SIDE SEAT HEATER ON. THE CONSUMER OPENED THE DRIVER'S SIDE WINDOW AND THE DRIVER'S SEAT CAUGHT ON FIRE AND BURNED THE CONSUMER. *AK *SCC *JB
Seats, Dec 1, 2003
THE FRONT DRIVERS SEAT OF MY 2002 VW JETTA SEDAN GOT EXTREMELY HOT WHILE I WAS SITTING ON IT CAUSING THE LEATHER SEAT TO START TO BURN AND MY BUTTOCKS TO BURN SLIGHTLY AS WELL.*AK
Service brakes, Hydraulic, Engine and engine cooling, Electrical system, Visibility, Structure, Equipment, Nov 29, 2003
I HAVE A 2002 1.8T VOLKSWAGEN JETTA - I HAVE EXPERIENCED NUMEROUS FAILURES. 1)RADIO HAS FAILED TWICE - IN EACH INSTANCE FAULT WAS TRACED TO A FUSE - FOLLOWING RADIO FAILURE I EXPERIENCED REPEATED DEAD BATTERIES UNTIL THE RADIO WAS REPAIRED. 2) ABS FAILURE DETECTED WHEN I WAS GETTING MY RADIO FIXED THE SECOND TIME 3)VEHICLE HAS FAILED TO START ON TWO OCCASIONS - I WAIT A MINUTE AND TRY AGAIN - IT WORKED 4)MY WINDOW FELL INTO THE DOOR 5)I EXPERIENCED AN ACTIVATION OF NUMEROUS ENGINE FAULT LIGHTS THAT RESET FOLLOWING ENGINE RESTART 6)THE COATING ON INTERIOR DOOR HANDLE SURFACES PEELS OFF EASILY 7)THE CHROME RING AROUND THE SHIFT KNOW IS PEELING. *AK
Seats, Nov 25, 2003, fire
VOLKSWAGEN JETTA GLS 2002 THE HEATED SEAT ON THE DRIVER'S SIDE STARTED TO SMOKE DUE TO FAULTY WIRING. *LA
Seats, Nov 25, 2003
FRONT LEFT (DRIVER'S SIDE) SEAT MATERIAL SPLIT ON THE SEAM HOLDING THE FRONT MATERIAL TO THE SIDE MATERIAL. DIRECTLY UNDER THE SPLIT IS A METAL BRACKET THAT IS NOT PADDED. THIS BRACKET LIKELY CAUSED THE SEAM TO SEPARATE. VOLKSWAGEN OF AMERICA (VOA) HAD ME BRING THE VEHICLE IN TO ONE ONTO VOLKSWAGEN FOR INSPECTION. REPAIR OR REPLACEMENT WAS DENIED BY THE SERVICE MANAGER (CARL SCHIDZICK) DENIED THE CLAIM BECAUSE I WAS BEYOND THE 12,000 MILE WARRANTY. THE VOA REGIONAL SERVICE MANAGER WHOSE NAME WAS REFUSED TO ME BACKED UP THE DEALER AND REFUSED REPAIR/REPLACEMENT. VOA WOULD NOT PROVIDE A COPY OF THEIR REPORT, WOULD NOT PROVIDE CONTACT INFORMATION FOR THE REGIONAL SERVICE MANAGER AND WOULD NOT ALLOW ANY APPEAL. THEY SAID THEY HAVE RECEIVED NO COMPLAINTS REGARDING SEAT MATERIAL FAILURE ON JETTAS. IF THE SEPARATION HAD OCCURRED BEFORE 12,000 MILES THEY SAID THEY WOULD HAVE REPAIRED OR REPLACED THE ITEM. MY NEW CAR SEAT COVER BLOCKS DEPLOYMENT OF THE SIDE AIRBAG. *LA
Power train, Electrical system, Nov 24, 2003
EPC WARNING LIGHT CAME ON WHILE DRIVING. WHEN THIS OCCURRED, TAIL LIGHTS AND BRAKE LIGHTS WERE NOT FUNCTIONING. WHEN I ARRIVED AT MY DESTINATION I PARKED MY CAR AS USUAL. WHEN I RETURNED TO MY CAR, IT STARTED, BUT I COULD NOT SHIFT OUT OF PARK. I CALLED THE ROADSIDE ASSISTANCE NUMBER. THEY INSTRUCTED ME TO HIT THE BRAKE WITH MY FOOT AS HARD AS POSSIBLE. THIS ALLOWED ME TO SHIFT OUT OF PARK. THEY ALSO SUGGESTED THAT I TAKE MY CAR TO THE DEALER AS SOON AS POSSIBLE FOR SERVICE. *LA
Visibility, Nov 24, 2003
THE POWER WINDOW CONTROLS STOPPED FUNCTIONING AND CAUSED ALL FOUR WINDOWS NOT TO GO DOWN, THEREFORE THE DOORS HAD TO BE MANUALLY LOCKED. THE DEALER FOUND THAT THE COMFORT CONTROL CENTER MODULE HAD TO BE REPLACED. VOLKSWAGEN AGREED TO PAY HALF THE REPAIR COST. *AK NLM
Seats, Nov 18, 2003
WITHIN 30 SECONDS OF STARTING VEHICLE AND TURNING ON THE SEAT WARMER CONSUMER SMELLED SMOKE, AND FELT A BURNING SENSATION ON THE LEGS. DRIVER'S SIDE SEAT HEAT COIL BURNED OUT THROUGH THE SEATS UPHOLSTERY. CONSUMER TURNED SEAT WARMER OFF BEFORE BURN INJURIES WERE SUSTAINED.*AK *NLM
Air bags, Nov 12, 2003
WAS DRIVING 15-20 MPH, WHEN THE VEHICLE RAN OVER A POTHOLE. THE SIDE AIR BAGS DEPLOYED INADVERTENTLY. THE MANUFACTURER AND THE DEALERSHIP WERE CONTACTED. CONSUMER DIDN'T TAKE THE VEHICLE TO DEALERSHIP TO HAVE MECHANIC CHECK. PLEASE PROVIDE FURTHER INFORMATION. *PH
Seats, Nov 10, 2003
THE DRIVER'S SIDE SEAT HEATER OVERHEATED AND BURNT A HOLE THROUGH DRIVER'S PANTS, BUT DIDN'T BURN THE DRIVER'S LEG. *AK