2002 Volkswagen Jetta
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 711 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Jetta model years with reports.
Of the 2002 reports, 32 involved a crash and 71 involved a fire. 75 people were injured and 10 people died.
What owners report most often
Recalls and investigations
Engine and engine cooling, engineMar 7, 2014
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Campaign 14E007000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Exterior lighting, brake lights, switchFeb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V063000 on NHTSA.gov
Exterior lighting, brake lights, switchMay 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 06V183000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchDec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 04V584000 on NHTSA.gov
Exterior lighting, brake lights, switchFeb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 04V096000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slipJan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
THIS CAN RESULT IN A FIRE.
DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 02V031000 on NHTSA.gov
Representative owner complaints
711 reports, newest first.
Air bags, Jul 5, 2012, crash
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT WAS DRIVING 35 MPH AND CRASHED INTO THE REAR OF A PRECEDING VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED INJURIES AS A RESULT. THE VEHICLE WAS TOWED FROM THE SCENE AND WAS NOT INSPECTED FOR THE FAILURE NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE AND THE CURRENT MILEAGE WAS 91,000.
Steering, Jun 6, 2012
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, HE LOST CONTROL OF THE STEERING AND WAS UNABLE TO MANEUVER THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 5,074. THE VIN WAS UNAVAILABLE.
Electrical system, Apr 27, 2012
MY 2002 VW JETTA TDI HAS MANY ELECTRICAL PROBLEMS. THE ONE THAT MIGHT BE A SAFETY FACTOR IS THE MICRO SWITCHES IN THE DOOR LATCHES. THE DOORS WITH FAULTY SWITCHES DON'T KNOW IF THERE OPEN OR CLOSED. WHEN OPEN THE SAFETY LIGHT ON THE DOOR DOES NOT COME ON TO ALERT ONCOMING VEHICLES THAT A DOOR IS OPEN. IF THE SWITCH STAYS ON WHEN THE DOOR IS CLOSED, THE DOME LIGHTS STAY ON UNTIL THE BATTERY IS DEAD. THE CAR DIES IN THE FREEWAY WHEN RUNNING, IT MIGHT BE AFFECTING THE COMPUTER NOW. THIS HAS TO BE RECALL ITS A SAFETY ISSUE. *TR
Exterior lighting, Apr 26, 2012
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THERE WAS AN ABNORMAL TICKING COMING FROM UNDER THE DASHBOARD. THE CONTACT TOOK THE VEHICLE TO A MECHANIC AND WAS TOLD THAT TURN SIGNALS AND HAZARD SWITCH WAS FAILING AND NEEDED TO BE REPLACED. THE MECHANIC ADVISED THE CONTACT THAT THERE WAS A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 04V584000 (EXTERIOR LIGHTING: HAZARD FLASHING WARNING LIGHTS: SWITCH). THE CONTACT SPOKE WITH THE MANUFACTURER AND WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 170,000.
Electrical system, Air bags, Apr 19, 2012
WHEN BACKING OUT OF MY DRIVEWAY MY DRIVERS SIDE AIRBAG DEPLOYED FOR NO REASON. I DIDN'T HIT ANYTHING. NOW THE ENGINE STARTS THEN STALLS. ALL DASH LIGHTS ARE NOW OUT. *JS
Seats, Mar 29, 2012, fire
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE HEATED SEATS BEGAN TO SPARK AND BURNED A WHOLE IN THE SEAT. THE SEATS WERE REPAIRED UNDER A PREVIOUS MANUFACTURER'S RECALL, BUT THE FAILURE RECURRED. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT THE CONTACT WAS DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 145,000.
Seats, Feb 21, 2012, fire
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE HEATED SEAT WARMER BURNED THROUGH THE SEAT AND THE PANTS OF THE CONTACT. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 125,000.
Power train, Jan 24, 2012
TRANSMISSION FAILURE RESULTING IN INABILITY TO SHIFT ABOVE THIRD GEAR WITHOUT ALLOWING THE CAR TO WARM UP FOR 20+ MINUTES. SOMETIMES THE TRANSMISSION WILL SLIP OUT OF GEAR AND THE CAR WILL LOSE ALL POWER FROM THE ENGINE. (RPMS DROP TO 0, CAR WILL COAST). *TR
Power train, Jan 24, 2012
I HAVE A 2002 JETTA & IN NOVEMBER 2011, I BEGAN EXPERIENCING ISSUES WITH THE AUTOMATIC TRANSMISSION. IT ONLY OCCURS WHEN THE CAR IS COLD & AFTER WARMING UP, THE ISSUES GO AWAY. UPON STARTING THE VEHICLE, THE CAR SHIFTS HARD BETWEEN THE 1ST, 2ND & 3RD GEARS. IT REVS UP BETWEEN EACH GEAR THEN JUMPS TO THE NEXT GEAR. I TOOK IT INTO ONE VW DEALER SERVICE SHOP WHO TOLD ME THAT THERE WERE SEVERAL ISSUES, THAT THE TRANSMISSION WAS SLIPPING, I HAD A VACUUM LEAK & THE CB BOOT IS SPLIT. THE TRANSMISSION WOULD NEED TO BE COMPLETELY REPLACED COSTING ME $5811.56 (PARTS AND LABOR). THE CAR HAS 103,508 MILES. I TOOK THE CAR TO ANOTHER VW DEALER SHOP TO GET A SECOND OPINION AND THEY RAN TEST AND SAID THAT THERE WAS NOTHING WRONG. FRUSTRATED WITH THE VW SERVICE SHOPS, I DECIDED TO TAKE IT TO A TRANSMISSION REPAIR - THEY STATED THAT SINCE THIS WAS A SEALED TRANSMISSION I WOULD NEED TO HAVE IT REBUILT WHICH WOULD COST $2,500-$3,500. WHO KNOWS IF THIS WILL ACTUALLY CORRECT THE ISSUE SINCE NOBODY CAN PINPOINT WHAT IS WRONG OR DIAGNOSE THE ISSUE! I RESEARCHED IT ONLINE, AND COUNTLESS '02 JETTA OWNERS ARE EXPERIENCING THE EXACT ISSUES. THERE ARE SEVERAL FORUMS AND COMPLAINT BOARDS REGARDING VW AND THEIR HANDLING OF THIS TRANSMISSION PROBLEM = HTTP://GETSATISFACTION.COM/VOLKSWAGEN/TOPICS/JETTA_2002_MAJOR_TRANSMISSION_ISSUES_ANYONE_ELSE AND ALSO MANY ON NHTSA. WHAT IS IT GOING TO TAKE TO GET VW TO ADMIT THAT THEY HAVE A FAULTY TRANSMISSION IN THEIR 2002 JETTAS. THIS NEEDS TO BE RECALLED. I LOVED MY CAR UP UNTIL NOW, BUT THE SERVICE AND THEIR ATTENTION TO THE CUSTOMERS ISSUES IS MAKING ME SECOND GUESS EVER OWNING A VOLKSWAGEN. IT FRUSTRATES ME THAT NOBODY FROM THIS HUGE CORPORATION WILL ADMIT THAT THEY'VE SOMEHOW DROPPED THE BALL WITH THE TRANSMISSION. THIS DESERVES TO BE RECALLED SINCE IT IS NOT AN ISOLATED INCIDENT AND IS IN NOT FAULT OF THE OWNER. THANK YOU FOR YOUR ATTENTION TO THIS! *TR
Power train, Jan 21, 2012
THE CAR BEGAN TO SLIP OUT OF GEAR. EVEN THOUGH THE GAS PEDAL WAS PRESSED, THE CAR WOULD NOT ACCELERATE. THE MECHANIC SAYS THE TRANSMISSION FLUID IS BURNT OUT WHICH INDICATES AN INTERNAL TRANSMISSION PROBLEM. REPAIR ESTIMATES BETWEEN 3500 AND 4000. *TR
Power train, Jan 18, 2012
AT A COLD START, CAR IS SLUGGISH GOING INTO 2ND GEAR. SOUNDS LIKE THE ENGINE IS REVVING UP AT ACCELERATION, BUT IT WILL GO NO FASTER THAN 10 MPH!! ALSO I CANNOT REVERSE! THE CAR MUST BE WARM (190 TEMP) IN ORDER TO REVERSE AND SHIFT PROPERLY! IVE READ OF OTHER VWS WITH SIMILAR PROBLEMS. *TT
Power train, Jan 4, 2012
ON COOL DAYS (APPROXIMATELY 40 DEGREES FAHRENHEIT AND BELOW), THE AUTOMATIC TRANSMISSION STARTS OUT IN EMERGENCY RUNNING MODE IN THIRD GEAR. IF CAR WARMS UP SUFFICIENTLY, THE IGNITION CAN BE TURNED OFF AND RESTARTED TO GET THE TRANSMISSION TO WORK CORRECTLY. I HAVE READ MANY BOARDS WHERE PROBLEMS VERY SIMILAR TO THIS SEEM WIDESPREAD AND MANY HAVE BEEN FORCED TO DO COSTLY REPAIRS. A RECALL MAY BE NECESSARY FOR THIS ISSUE. *TR
Electrical system, Latches/locks/linkages, Dec 31, 2011
DRIVER SIDE LOCK SWITCH, UNABLE TO LOCK MY 02 JETTA WITH REMOTE KEY. INTERIOR LIGHT ON THE DRIVER DOOR CONSTANTLY STAYS ON. *KB
Power train, Dec 30, 2011
THE TRANSMISSION STARTED SLIPPING AND SHIFTING HARD BETWEEN 2ND AND 3RD. THIS OCCURRENCE IS DUE TO A FAULTY TRANSMISSION CONTROL UNIT AND TRANSMISSION SOLENOID. IF NOT PROPERLY TAKEN CARE OF THIS MIGHT CAUSE A TRANSMISSION FAILURE AND ULTIMATELY A TRANSMISSION CRASH. THIS MEANS A NEW TRANSMISSION AND THE COST CAN RANGE FROM 3000-7000 DOLLARS. THIS HAS HAPPENED TO MANY VW OWNERS. ESPECIALLY VOLKSWAGENS BETWEEN 2001-2003. *KB
Electrical system, Seats, Dec 17, 2011, fire
WHILE DRIVING HOME AT NIGHT, MY SON AND I SMELLED SMOKE. WE EXITED THE VEHICLE, CHECKED UNDER THE HOOD, BUT FOUND NOTHING. WE CONTINUED HOME AND PARKED IN THE GARAGE. STILL SMELLING SMOKE, WE RE-INSPECTED THE VEHICLE, BUT WERE UNABLE TO DETERMINE AN ORIGIN OR ANY VISIBLE EVIDENCE. BOTH SEAT HEATERS WERE ON DURING THE DRIVE HOME, BUT THE SEATS SHOWED NO VISUAL SIGNS OF DAMAGE AFTER PARKING. NEXT MORNING WE OPENED THE VEHICLE TO DISCOVER THE CABIN WAS FILLED WITH SMOKE WITH AN APPROXIMATE 1?HOLE BURNED UP THRU THE PASSENGER SEAT ON THE LOWER RIGHT BOLSTER. APPARENTLY THE SEAT HEATER INITIATED A THERMAL EVENT WHICH ERUPTED IN A SEAT FIRE AFTER WE TURNED OFF THE IGNITION AND PARKED THE CAR IN THE GARAGE. FORTUNATELY, THE FIRE DID NOT ENGULF THE VEHICLE OR IT COULD HAVE CAUGHT OUR HOME ON FIRE, RESULTING IN POSSIBLE INJURY OR DEATH TO MY FAMILY. I BELIEVE WE DODGED A BULLET BECAUSE THE SEAT FIRE DID NOT SUSTAIN ITSELF AND ENGULF THE VEHICLE. VW HAS AGREED TO REPAIR THE BURNED SEAT AT THEIR EXPENSE AND MAKE A MITIGATION REPAIR. HOWEVER, VW HAS DECLINED MY REQUEST TO COVER ANY SIMILAR MITIGATION REPAIR TO THE OTHER SEAT. IN OCTOBER 2004, THE NHTSA ODI CONCLUDED THAT ?DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE? BUT ?SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.? THE ODI STATED THE INVESTIGATION DID NOT CONCLUDE THAT A SAFETY-RELATED DEFECT DOES NOT EXIST AND THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. (EA04010) EVIDENCE AND REPORTS INDICATE THAT SEAT HEATER CAUSED THERMAL EVENTS IN BOTH DRIVER AND PASSENGER SEATS IN THE VW JETTA HAVE BEEN AN ISSUE FOR NEARLY 10 YEARS NOW. NEAR MISSES CONTINUE TO OCCUR. I BELIEVE THAT A SEAT FIRE IS A SIGNIFICANT SAFETY CONCERN. I WOULD ENCOURAGE THE NHTSA TO RE-EXAMINE THE CIRCUMSTANCES TO DETERMINE IF FURTHER ACTION IS WARRANTED. *TR
Power train, Dec 4, 2011
MY 2002 VW JETTA GLX (AUTOMATIC) HAS SEVERE TRANSMISSION PROBLEMS. WHEN ACCELERATING, IT HESITATES AND THEN POPS INTO GEAR JERKING THE CAR. THIS IS VERY ALARMING AND DANGEROUS, ESPECIALLY WHEN I AM ON THE ROAD WITH OTHER VEHICLES AROUND ME. I ALMOST HAD SEVERAL ACCIDENTS DUE TO TRYING TO PULL OUT IN TRAFFIC BUT THE TRANSMISSION IS SO UNRELIABLE AND SLIPS THEREBY CAUSING ME TO STALL IN ONCOMING TRAFFIC. THEN, TODAY THE CAR WOULD NOT GO INTO REVERSE OR NEUTRAL AT ALL. I'VE SEEN SO MANY TRANSMISSION COMPLAINTS ABOUT THIS YEAR'S MODEL AND IT IS SO UNFAIR FOR THE CONSUMER TO BE RESPONSIBLE FOR THIS EXPENSIVE REPAIR. *TR
Power train, Nov 21, 2011
THE AUTOMATIC TRANSMISSION-WHEN SHIFTED INTO D-LAGS FOR A FEW SECONDS AND THEN THE CAR LUNGES FORWARD-TRANSMISSION SHIFTS IN AN ODD MANNER-CAR ONLY HAS 43000 MILES ON IT-ORIGINAL MILES-. *TR
Power train, Vehicle speed control, Nov 19, 2011
WHILE DRIVING THE CAR AT 35MPH THE TACHOMETER WILL INCREASE AND DECEASE AT 2000RPM'S AND CAR WILL SLIGHTLY INCREASE AND THEN DECREASE IN SPEED. THERE IS A JERKING BETWEEN 3RD AND 4TH GEAR. ALSO THERE IS A SLIGHT DELAY OF MOVEMENT FROM PARK TO REVERSE. BOTH ARE SAFETY HAZARDS WHILE ON STREETS WITH TRAFFIC. *TR
Power train, Nov 7, 2011
AUTOMATIC TRANSMISSION WHEN COLD WILL HESITATE OR NOT CATCH AT ALL WHEN PUTTING INTO DRIVE. PUTTING THE CAR INTO 1ST, THEN MOVING IT TO DRIVE WILL USUALLY WORK. SHUDDERS WHEN COMING TO STOP AFTER HEATING UP AT TIMES. MECHANIC SAYS IT NEEDS A TRANSMISSION REBUILD AT $3000. FAILURE OF TRANSMISSION CONTROL MODULE AND CASCADING TO THE MASTER CONTROL MODULE CAUSED THE TRANSMISSION NOT TO LEAVE THE PARK POSITION, THAT TOW AND REPAIR WAS $300 ABOUT 30 DAYS AGO. THERE ARE HUNDREDS OF COMPLAINTS ON THE INTERNET ABOUT THIS TRANSMISSION FAILING REPEATEDLY, A FAULTY DESIGN. WE NEED A RECALL FROM VOLKSWAGEN TO FIX THIS DESIGN FAILURE. *TR
Power train, Electrical system, Nov 3, 2011, crash
2002 VOLKSWAGEN JETTA. CONSUMER WRITES TO EXPRESS DISCONTENT REGARDING REPAIRS AT LOCAL DEALER *TGW THE CONSUMER STATED THREE DAYS AFTER RETRIEVING THE VEHICLE FROM THE DEALER, FOR MAINTENANCE WORK, THE VEHICLE BROKE DOWN ON THE HIGHWAY. THE PROBLEM WAS DETERMINED TO BE THE ALTERNATOR. *JB THE CONSUMER STATED HE WAS INVOLVED IN A HIT-AND RUN ACCIDENT IN WHICH THE REAR END IMPACT CAUSED DAMAGE TO THE TRANSMISSION. THE CONSUMER STATED EVEN THOUGH THE VEHICLE WAS REPAIRED, HE CONTINUED TO EXPERIENCE PROBLEMS WITH THE TRANSMISSION. UPDATED 12/08/11
Power train, Oct 18, 2011
I BOUGHT THIS CAR WITH 108000 MILES ON IT, I BEGAN HAVING PROBLEMS WITH THE CAR SHIFTING FROM 2ND TO 3RD; HOWEVER NOW IT HAS BEEN GETTING WORST. I HAVE DONE TONS OF RESEARCH AND THE ISSUES SEEMS TO BE A ISSUE THAT IS MORE OF A RECALL ISSUE THAN JUST ONE CARE ISSUE. I ALSO DO NOT LIKE HOW VW OF AMERICA IS JUST FLUFFING IT OFF LIKE IT IS ALL THE OWNERS FAULTS. I ALSO HAVE READ THAT MANY PEOPLE HAVE PAID FOR THE TRANSMISSIONS TO BE REPLACED AND OR FIXED FOR OVER 5K AND THE ISSUE COMES UP AGAIN, IT WOULD BE NICE IF SOMEONE WOULD TAKE AND LOOK INTO THIS ISSUE BECAUSE MANY OF US BOUGHT THE CAR BECAUSE THEY LIKED VW AND WILL SOON BE GETTING RID OF THEM AS WELL AS NO LONGER BUYING FROM VW DUE TO VW IGNORING OUR COMPLAINTS. *TR
Engine and engine cooling, Oct 17, 2011, fire
WE WERE TRAVELING 70 MPH ON A HIGHWAY IN OUR 2002 VOLKSWAGEN JETTA WAGON (GLS 1.8T) WHEN, WITHOUT WARNING, AN LOUD "POOF" SOUND WAS HEARD, THE CAR LOST ALL POWER, AND WE SMELLED BURNING PLASTIC. THE CAR REGAINED POWER, THEN A SECOND "POOF" SOUND WAS HEARD, AND THE POWER FLICKERED IN THE CAR, AT WHICH POINT THE CAR BEGAN FILLING WITH SMOKE. WE ROLLED DOWN THE WINDOWS, PULLED OVER TO THE SHOULDER, AND EVACUATED THE VEHICLE. WE PULLED OUT WHAT BELONGINGS WE COULD, BUT RETREATED FROM THE CAR ONCE FLAMES APPEARED ON THE DRIVER'S SIDE INTERIOR. APPROXIMATELY 1 MINUTE LATER, THE ENTIRE CAR WAS ENGULFED IN FLAMES AND WAS A TOTAL LOSS. WE ARE THANKFUL TO HAVE ESCAPED WITH OUR LIVES. HERE ARE THE SPECIFICS OF OUR VEHICLE: MODEL:JETTA TRIM:GLS BODY STYLE:4 DOOR WAGON ENGINE:1.8L I4 20V MPFI DOHC TURBO TRANSMISSION:AUTOMATIC. *TR
Power train, Oct 7, 2011
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE BEGAN TO DECELERATE AND JERK FORWARD. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTICS. THE TECHNICIAN STATED THAT THERE COULD HAVE BEEN A COMPUTER OR TRANSMISSION FAILURE. THE TECHNICIAN THEN ADVISED THAT THE TRANSMISSION WOULD HAVE TO BE TAKEN APART TO LOCATE THE SOURCE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.
Power train, Sep 23, 2011
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. THE CONTACT STATED THAT THE TRANSMISSION WOULD JERK AS SOON AS THE VEHICLE WAS STARTED. THE CONTACT MENTIONED THAT THE FAILURE RECURRED FOUR TIMES AND HE HAD TO REPLACE THE TRANSMISSION ONCE PRIOR TO THE MOST RECENT FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE TRANSMISSION WAS DEFECTIVE AND NEEDED TO BE REPLACED AGAIN. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFERED ANY ASSISTANCE SINCE THE VEHICLE WAS OUT OF WARRANTY. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 120,000.
Fuel system, Gasoline, Jun 20, 2011
THE FUEL GASKET DECIDED TO CRACK ON THE TOP OF THE SENDING UNIT THAT SENDS DIESEL TO THE ENGINE. IT FILLED THE TOP AND SPILLED DOWN OVER THE TANK ONTO THE CONCRETE. $250 REPAIR FOR THE GASKET + LABOR NOT AT A DEALERSHIP. IT'S PROBABLY A FIRE HAZARD AND VW SHOULD RECALL THE GASKETS.