2002 Volkswagen Jetta
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 711 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Jetta model years with reports.
Of the 2002 reports, 32 involved a crash and 71 involved a fire. 75 people were injured and 10 people died.
What owners report most often
Recalls and investigations
Engine and engine cooling, engineMar 7, 2014
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.
Campaign 14E007000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Exterior lighting, brake lights, switchFeb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 07V063000 on NHTSA.gov
Exterior lighting, brake lights, switchMay 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Campaign 06V183000 on NHTSA.gov
Exterior lighting, hazard flashing warning lights, switchDec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 04V584000 on NHTSA.gov
Exterior lighting, brake lights, switchFeb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 04V096000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slipJan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
THIS CAN RESULT IN A FIRE.
DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Campaign 02V031000 on NHTSA.gov
Representative owner complaints
711 reports, newest first.
Power train, Jul 20, 2010
AT 70000 MILES, JETTA GLS SEDAN WITH AUTOMATIC TRANSMISSION STOPPED BEING ABLE TO SHIFT INTO REVERSE AND STARTED REVVING HARD BETWEEN 1ST AND 2ND. DEALERSHIP CLAIMS NO KNOWLEDGE OF THE PROBLEM, THOUGH THESE FORUMS ARE FULL OF REPORTS OF SIMILAR PROBLEMS. AFTER A SERIES OF EXPENSIVE TESTS (400$ TOTAL) DEALERSHIP RECOMMENDS A NEW TRANSMISSION TO THE TUNE OF 5000$, WHICH IS APPROXIMATELY 70% OF THE CAR'S BLUE BOOK VALUE. DESPITE THE NUMEROUS COMPLAINTS VW REFUSES TO ACKNOWLEDGE THE ISSUE OR COMPENSATE THOSE WHO HAVE EXPERIENCED IT. *TR
Air bags, Jun 28, 2010
WAS DRIVING ALONG A GRADED DIRT ROAD WHEN PASSENGER SIDE AIRBAG AND SIDE CURTAIN AIRBAG DEPLOYED SUDDENLY. THERE WAS NO SIDE IMPACT WHATSOEVER, AND WAS NOT ABLE TO DETERMINE ANY CAUSE OF AIRBAG DEPLOYING. TWO PASSENGERS IN THE CAR SUFFERED TEMPORARY RINGING IN THEIR EARS AND HEADACHES, BUT NO SIGNIFICANT INJURIES OCCURRED, THANK GOODNESS. HAVE CONTACTED DEALER FOR INFORMATION ABOUT REPAIRS, BUT NOTHING HAS BEEN DONE TO FIX IT YET. *TR
Visibility, Jun 28, 2010
TL* THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. WHILE DRIVING AT 60 MPH, THE DRIVER SIDE POWER WINDOW REGULATOR COLLAPSED. THE CONTACT SPOKE WITH THE DEALER WHO ADVISED THE FAILURE WAS NOT A RECALL ITEM AND REPAIRS WOULD BE AT THE OWNER'S' EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 20,000 AND THE FAILURE MILEAGE WAS 19,995.
Power train, Apr 27, 2010
I HAVE ALWAYS FOLLOWED THE RECOMMENDED SERVICE SCHEDULE FOR MY CAR. THE OWNER MANUAL DOESN'T MENTION REPLACING THE TRANSMISSION FLUID FOR THE LIFE OF THE CAR. THE CAR HAS 69500 MILES. THREE DAYS AGO WHILE DRIVING UPHILL I ACCELERATED BUT THE CAR DID NOT PICK UP SPEED WHILE THE RPM WENT CONSIDERABLY HIGHER (6000 RPM). I WENT TO SEE MY MECHANIC (A CERTIFIED VW MECHANIC) WHO SAID THAT THE TRANSMISSION WAS SLIPPING AND NOT DOWNGRADING AS IT SHOULD AND I SHOULD CONSIDER CHANGING THE TRANSMISSION FLUID AS A POSSIBLE REMEDY. HE EXPLAINED THAT A TRANSMISSION FLUID LEVEL COULD BE THE CAUSE. HE ALSO SAID THAT SINCE THE TRANSMISSION IS "SEALED" IT WAS ALL HE COULD DO TO TRY TO REMEDY THE PROBLEM. HOW CAN A "SEALED" TRANSMISSION THAT REQUIRES NO MAINTENANCE BE LOW IN FLUID ? HE DID CHANGE THE TRANSMISSION FLUID AND TOLD ME THAT THE FLUID WAS ALMOST AS DARK AS COFFEE, AN INDICATION THAT THERE WAS AN ISSUE INSIDE THE TRANSMISSION. AFTER CHANGING THE FLUID THE PROBLEM DID NOT GO AWAY AND GRADUALLY GOT WORSE. THREE DAYS LATER MY TRANSMISSION IS EXTREMELY NOISY AND I CAN ONLY RUN THE CAR IN "MANUAL"MODE IN ORDER TO CHANGE THE GEARS. I CAN NO LONGER ACCELERATE IN 4TH OR 5TH GEAR AND JUST USE THEM WHILE CRUISING (AT A MAXIMUM SPEED OF 45 MPH. VW HAS A 60000 MILES WARRANTY ON THE POWER TRAIN BUT A QUICK SEARCH ON GOOGLE REVEALED THAT A LOT OF 2002 JETTA OWNERS HAD THEIR TRANSMISSION GO BAD AROUND 70000 TO 85000 MILES. VW USED TO HAVE 100000 MILES WARRANTY AND REDUCED IT TO 60000, JUST BELOW THE MILEAGE AT WHICH THE TRANSMISSION SEEM TO BREAK DOWN. I SUSPECT THAT THEY KNOW THEIR TRANSMISSIONS ARE DEFECTIVE AND CUT DOWN THE WARRANTY IN ORDER NOT TO HAVE TO BEAR THE FINANCIAL BURDEN OF A DEFECTIVE DESIGN. CONSIDERING THE NUMBER OF 2002 JETTA OWNER THAT HAVE HAD TO REPLACE THEIR "SEALED" TRANSMISSION AROUND 70000 IT SEEMS TO INDICATE A TREND OR AT LEAST A KNOWN PROBLEM WITH THE PART. I AM NOW LEFT WITH CHANGING THE TRANSMISSION AT A COST OF AROUND $5000. PLEASE INVESTIGATE. *TR
Service brakes, Hydraulic, Exterior lighting, Mar 30, 2010
I HAVE A 2002 VOLKSWAGEN JETTA AND I HAVE A BRAKE LIGHT SWITCH ISSUE (BRAKE LIGHT STAYS ON AND A DCT(P0571) IS SET) THAT WAS DESCRIBED IN THE RECALL/REPLACEMENT, BUT THE VIN GROUP THAT THIS APPLIES TO IS 3VW---9M-YM000089 TO 3VW---9M-2M053565, AS YOU CAN SEE, MINE IS JUST OUT SIDE THE HIGH VIN. THE VIN RANGE SHOULD BE READDRESSED TO INCLUDE ALL 2002 MODEL JETTAS WITH CRUISE CONTROL. THANK YOU FOR YOUR PROMPT ATTENTION TO THIS MATTER. *TR
Vehicle speed control, Mar 9, 2010
SITTING AT A LIGHT, FOOT ON CLUTCH PEDAL AND FOOT ON BRAKE PEDAL CAR ENGINE BEGAN RACING. PUT IN NEUTRAL AND PUT EMERGENCY BRAKE ON AND PUMPED GAS PEDAL, DID NOT GET IT TO STOP. TURNED KEY OFF AND REMOVED KEY, CAR RACED TO FULL AEND STAYED THERE UNTIL ENGINE STOPPED, ABOUT A MINUTE. CAR WAS TOWED TO REPAIR SHOP. *TR
Seats, Feb 24, 2010, fire
I TURNED ON MY SEAT WARMER ON THE DRIVER SIDE AND AFTER A WHILE A BURNT SMELL WAS NOTICE. I COULD NOT FIND THE ORIGIN UNTIL I WENT TO A STORE AND TRIED TO PAID. I TOOK MY WALLET OUT AND IT WAS STUCK TO MY PANTS. THE WALLET HAD THE MYSTERIOUS SMELL. I WENT BACK TO THE CAR AND THE SEAT HAD A BIG BURNT HOLE ON THE LEATHER SEAT. IF I HAD NOT HAD MY COAT AND WALLET ON THE LEFT SIDE I COULD HAVE BEEN ELECTROCUTED OR CAUGHT FIRE. *TR
Service brakes, Hydraulic, Engine and engine cooling, Feb 17, 2010
ABS WARNING LIGHT AND CHECK ENGINE LIGHT LIT UP IN 2002 JETTA. *TR
Electrical system, Feb 11, 2010
VEHICLE SHUT DOWN WHILE DRIVING TWICE, COULD RESULT IN CAR BEING DISABLED WHILE DRIVING AT ANY SPEED ANY WHERE BECOMING A VERY DANGEROUS SITUATION FOR THE DRIVER AND AN OBSTACLE ON THE ROAD FOR OTHER DRIVERS TO TRY TO AVOID. VOLKSWAGEN DEALERSHIP ISOLATED THIS TO A FAULTY HARNESS CONNECTING THE ALTERNATOR TOTHE FUSE LOCATED ON TOP OF THE BATTERY. THE HARNESS AND THE FUSE BOX HAD TO BE REPLACED. THE DEALERSHIP SAID THIS PROBLEM IS ONLY COMMON TO VW BEATLES AND VW JETTA, BECAUSE THEY SAID THE CAR WAS 2002 IT WAS OUT OF WARRANTY NOT COVERED. I WAS MORE CONCERNED OF THE SAFETY OF LIFE AND PROPERTY THIS PROBLEM WOULD CAUSE. I FILED A COMPLAINT WITH THE ATTORNEY GENERAL JOHN KROGERS OFFICE IN OREGON, THEY SENT ME A LETTER STATING THEY HAD FORWARDED THIS COMPLAINT TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMIN IN WASHINGTON DC . I TRIED TO CONTACT THEM BY PHONE, THEY ASKED IF I HAD A CONFIRMATION # . I HAVEN'T AS OF YET RECEIVED A LETTER OR PHONE CALL. *TR
Engine and engine cooling, Jan 22, 2010
I RECENTLY PURCHASED A 2002 VW JETTA AND JUST FOUND OUT THAT THE CATALYTIC CONVERTER NEEDS REPLACEMENT. I WAS VERY SURPRISED WHEN MY MECHANIC INFORMED ME HE HAS SEEN MANY 2002 JETTAS WITH THIS PROBLEM. HE SAID IT WAS RELATED TO A PROBLEM WITH A BAD COIL THAT WAS PART OF A RECALL AND CAUSED THE CATALYTIC CONVERTERS TO FAIL ABNORMALLY FAST. I AM VERY DISAPPOINTED THAT IT APPEARS VW KNOWS ABOUT THIS ISSUE AND IS IGNORING THE ISSUE. THE REPAIR COSTS MORE THAN $1000 AND I AM UNABLE TO PASS STATE INSPECTION WITHOUT GETTING IT DONE. *TR
Exterior lighting, Jan 15, 2010
TURN SIGNALS AND HAZARD LIGHTS ONLY WORK INTERMITTENTLY. THERE WAS A RECALL ISSUED FOR A CERTAIN NUMBER OF 02 JETTAS, BUT APPARENTLY NOT FOR THIS PARTICULAR VIN NUMBER. *TR
Power train, Dec 14, 2009
THE WASTE GATE AIR FLOW SYSTEM TO THE TDI MALFUNCTIONS CAUSING DECREASE IN ENGINE COMPRESSION. THIS PROBLEM IS PERSISTENT AND OCCURS WHEN SHIFTING FROM 4TH GEAR TO 5TH AT AN RPM OF 3000 TO 3500. THIS COULD LEAD TO A DANGEROUS SITUATION WHEN PASSING A VEHICLE, THE VEHICLE COULD LOSE 50% OF ITS POWER AND SHOULD AN ON COMING VEHICLE BE PRESENT IT COULD LEAD TO A SERIOUS ACCIDENT. THIS IS A PERSISTENT PROBLEM AND THE ONLY WAY TO RESET THE WASTE GATE IS TO TURN OFF THE IGNITION AND RESTART THE ENGINE WHERE THE PROBLEM GOES AWAY UNTIL THE NEXT OCCURRENCE. VW WAS INFORMED OF THE PROBLEM AND THEY ACKNOWLEDGE AWARENESS OF THE PROBLEM BUT SINCE THE VEHICLE IS OUT OF WARRANTY THEY CANNOT REPLACE THE WASTE GATE. COST OF REPAIR - $850.00 FOR THE WASTE GATE ONLY. *TR
Power train, Dec 13, 2009
I HAVE SPENT OVER 9000.00 SINCE 2004 ON REPAIRS ON MY VW JETTA. I COMPLAINED TO THE AUTHORIZED REPAIR SHOP THAT MY CAR HAD TO WARM UP WHEN IT WAS 90 DEGREES OUTSIDE FOR IT RUN WITHOUT SLOWING DOWN AND ALMOST STOPPING. I TOOK MY CAR IN HAD BUSHINGS REPLACED AND THEY SAID MY TEMPERATURE SENSOR NEEDED REPLACING. WHEN I GOT THE CAR BACK I WAS HAVING THE SAME PROBLEM. I TOOK THE CAR BACK NOW THEY ARE SAYING THAT I NEED A VALVE BODY REPLACED TO THE TUNE OF $1600.00. EVEN THEN THERE IS NO GUARANTEE THE PROBLEM WILL BE FIXED. THE OTHER OPTION IS TO GET A NEW TRANSMISSION REPLACED FOR $3500.00. I HONESTLY THINK ALL OF THESE CARS ARE LEMONS AND I WOULD NEVER BUY ANOTHER VOLKSWAGEN PRODUCT IN MY LIFE. *TR
Engine and engine cooling, Power train, Dec 12, 2009
OUR VOLKSWAGEN JETTA DEVELOPED TRANSMISSION ISSUES JUST AFTER THE WARRANTY PERIOD RAN OUT. THE TRANSMISSION JERKS AT LOW SPEEDS, WHEN YOU HIT THE ACCELERATOR. MECHANICS HAVE SAID THERE IS NO SAYING WHEN THIS WILL CONK OUT. THE WATER PUMP ALSO CONKED OUT RECENTLY. REPLACING THE TRANNY IS ABOUT $6000. REPLACING THE WATER PUMP COST US AROUND $900. I HEAR DEALERSHIPS CHARGE A LOT MORE FOR THIS SERVICE. THE VOLKSWAGEN JETTA IS TOO EXPENSIVE A CAR, FOR IT TO HAVE SUCH POOR QUALITY. HOPE SOMEONE CAN HELP MAKE THEM PAY FOR RIPPING CUSTOMERS OFF IN THIS WAY. THIS OUTRAGEOUS. *TR
Seats, Dec 10, 2009, fire
PASSENGER LEATHER SEAT CAUGHT FIRE WHILE HEATED SEAT WAS ON. BURNED A HOLE IN THE SEAT AND ELECTRICAL SMOKE WAS PLUMING OUT OF THE HOLE. THIS HAS ONLY OCCURRED ONCE BECAUSE IT HAS NOT BEEN USED SINCE. THE FAILURE HAS NOT BEEN CORRECTED. *TR
Air bags, Dec 8, 2009
SIDE CURTAIN AND SEAT AIRBAG DEPLOYED WHILE DRIVING AT 35-40 MPH. NO DAMAGE TO THE CAR OTHER THAN THAT CAUSED BY THE AIRBAGS DEPLOYING. NO POTHOLES IN THE SMOOTH PAVED ROAD NEAR THE INTERSECTION OF FL SR70 AND US301. NO DEBRIS IN THE ROAD OR ANY REASON FOR THE AIRBAGS TO HAVE DEPLOYED. DRIVER RECEIVED WELT AND BRUISES ON THE RIBS FROM THE SEAT AIRBAG. *TR
Electrical system, Nov 18, 2009
TL*THE CONTACT OWNS A 2002 VOLKSWAGEN JETTA. WHILE DRIVING 55 MPH THE VEHICLE LOST POWER AND DECREASED SPEED TO 10 MPH. HE WAS ABLE TO AVOID A CRASH AND DRIVE ONTO THE EMERGENCY LANE. HE WAS ALSO ABLE TO DRIVE THE VEHICLE TO HIS RESIDENCE. THE DEALER STATED THAT THE IGNITION COIL CAUSED THE VEHICLE TO LOSE POWER. THE MANUFACTURER STATED THERE WERE NO RELATED RECALLS. THE FAILURE AND THE CURRENT MILEAGES WERE 52,000. UPDATED 03/01/10 *BF THE CONSUMERS DAUGHTER HIT THE FRONT SEAT AND SUSTAINED A BLODDY NOSE. UPDATED 09/16/10
Vehicle speed control, Nov 17, 2009
WHEN THE GAS PEDAL ON A JETTA 2002 4 CYL 1.9L DIESEL TURBO IS DEPRESSED QUICKLY VERSUS SLOWLY, THE ENGINE WILL RACE, I.E. RPMS WILL INCREASE, WITH NO CORRESPONDING CHANGE IN THE VEHICLE'S SPEED. IT APPEARS THAT THE SENSOR ATTACHED TO THE PEDAL IS NOT FUNCTIONING AS DESIGNED. I STOPPED AT A NON VW DEALER TO SEE IF I COULD GET THE PROBLEM CORRECTED. THEY COULD NOT CORRECT THE PROBLEM. I WILL BE GOING TO A VW DEALER ON NOV 18. THE PROBLEM CAN BE POTENTIALLY FATAL IF I NEED TO ACCELERATE QUICKLY TO AVOID A DANGEROUS SITUATION OR MERGE SAFELY FROM AN ON RAMP INTO TRAFFIC TRAVELING AT 60 MPH. *TR
Electrical system, Nov 14, 2009
BATTERY CONTINUES TO DRAIN OVER NIGHT. CHANGING BATTERIES DID NOT SOLVE THE PROBLEM. ONLINE FORUM POINTS TO RADIO DRAINING THE BATTERY. PULLING FUSE AND RESETTING RADIO TENDS TO STOP THE PROCESS, BUT THEN IT RETURNS AFTER A COUPLE OF DAYS. *TR
Engine and engine cooling, Oct 29, 2009
2002 VW JETTA 2.0 STOPPED AND SPUTTERED ON MAIN HIGHWAY BECAUSE OF IGNITION COIL FAILURE. THE CAR HAS 7500 MILES AND VW ACKNOWLEDGES THE PROBLEM FOR 1.8 LITER ENGINES BUT NOT FOR 2.0 LITER. THEY ARE RECALLING 90000 1.8 CARS BUT ARE CHARGING $600 FOR THE 2.0 FIXES. SURELY, THEY BOUGHT THEM FROM THE SAME SUPPLIER. *TR
Seat belts, Oct 6, 2009
MY SON WAS IN HIS HIGH BACK BOOSTER SEAT WHEN THIS HAPPENED. HE WAS IN THE REAR DRIVERS SIDE SITTING WITH HIS SEAT BELT ON. WE CAME HOME AFTER GROCERIES AND I ASKED HIM TO GET INSIDE THE HOUSE WHILE I WAS UNLOADING THE CAR. HE HEARD HIM CRYING, SO I WENT TO HIM TO FIND OUT THAT HE WAS LOCKED IN HIS SEAT BELT AND THE SEAT BELT WAS LOCKED. LUCKILY THE SEAT BELT WAS NEAR HIS WAIST NOT NECK. I CALLED MY HUSBAND AND TRYING TO UNLOCK THE SEAT BELT AND TRIED TO GET HIM OUT. COULD NOT DO ANYTHING, LIFTED HIM A BIT AND REMOVED HIS CARSEAT, THINKING IT WOULD LOOSEN UP, EVEN THAT RETRACTED BACK. AFTER 1 HOUR OF STRUGGLE, WE FINALLY HAD TO CUT THE SEAT BELT WITH A SCISSORS. HIS WAIST WAS TWISTED IN THE BELTS AND HE HAD BRUISES ON HIS WAIST. SO SAD THAT THIS LOCKING TECHNOLOGY WORKS SO BADLY. THIS HAS CAUSED SO MUCH PAID TO ALL OF US SEEING HIM CRY AND GOT STUCK. *TR
Power train, Sep 19, 2009
I BOUGHT MY 2002 VW JETTATDI IN 2004, DURING ROUTINE MAINTENANCE I DESCRIBED A HESITATION IN THE TRANSMISSION. THEY CHECKED THE TRANSMISSION FLUID AND SAID IT WAS "BURNED" AND REPLACED IT. I ASKED HOW IT GOT THAT WAY AND WAS TOLD SOMETHING GOT HOT IN THERE. THAT WAS IT. SEVERAL YEARS LATER AND ONE MORE CHANGING OF THE TRANSMISSION FLUID BECAUSE IT WAS BURNED, THE CAR WOULDN'T AUTOMATICALLY SHIFT INTO 4TH GEAR AND WOULD HESITATE AND SURGE FORWARD. THE MECHANIC REPLACED A SENSOR THAT TELLS THE CAR TO SHIFT INTO 4TH. IT WAS FINE FOR TWO WEEKS THEN, WHILE DRIVING 55 MPH ON THE HIGHWAY, THE CAR JOLTED LIKE I HAD HIT SOMETHING (WHICH I DID NOT BECAUSE I LOOKED)AND DECELERATED QUICKLY. I IMMEDIATELY PULLED OVER AND FROM THAT POINT ON THE CAR WOULD GO UP TO 20 - 30 MPH THEN BUCK AND DECELERATE TO 5 MPH. IT KEPT REPEATING THIS AS I TRIED TO ACCELERATE. 1ST GEAR AND REVERSE DIDN'T WORK AT ALL. WHEN THE CAR WAS BEING LOADED TO BE TOWED THE FRONT WHEELS WOULD NOT ROLL BACKWARDS WITH THE CAR IN NEUTRAL AND THE E BRAKE OFF. THE TRANSMISSION COMPANY SAID THE TRANSMISSION HAD MELTED DOWN INSIDE. AND IT WILL COST $4000.00 TO REBUILD THE TRANSMISSION. THE WAY THIS HAPPENED WAS VERY DANGEROUS; FORTUNATELY I WAS NOT PASSING ANOTHER CAR OR THAT THERE WERE NO CARS DIRECTLY BEHIND ME OR PULLING OUT TO CROSS TRAFFIC. *TR
Engine and engine cooling, Sep 18, 2009
I BOUGHT A 2002 VOLKSWAGEN JETTA GLS FROM A USED CAR DEALER LAST APRIL. I HAVE HAD A COUPLE PROBLEMS THAT I THOUGHT WAS UNIQUE TO MY SPECIFIC CAR, HOWEVER, AFTER HOURS OF RESEARCH I'VE FOUND THAT NUMEROUS OTHER JETTA OWNERS ARE HAVING SOME OF THE SAME PROBLEMS. 1. THE VEHICLE SMELLS LIKE CRAYONS 2. THE HEATER STOPS WORKING AND ONLY BLOWS OUT HOT AIR. 3. THE ENGINE EATS OIL AND HAS A PROBLEM WITH SLUDGE. THIS IS INAPPROPRIATE AND NO ONE IS TAKING ANY RESPONSIBILITY OR HAS A REMEDY FOR THESE PROBLEMS. I'M AFRAID THE FUMES FROM THE VEHICLE MAY BE TOXIC AND AM UNABLE TO GET RID OF THE CAR. *TR
Electrical system, Sep 9, 2009
1. 2002 VW JETTA WAGON ELECTRICAL SYSTEM FAILURE ON EXPRESSWAY CAUSED VEHICLE TO STOP & UNABLE TO START 9/6/09. VEHICLE TOWED TO DEALER. 2. VW DEALER FAILURE DESCRIPTION, WIRE HARNESS CORROSION CAUSED RESTRICTION IN POWER FLOW IN LINE WHICH CAUSED ALTERNATOR TO OVERWORK AND OVERHEAT WIRE HARNESS AND FUSE PANEL. THIS EXTENSIVE ENOUGH TO CAUSE MELTING OF BOTH WIRE HARNESS AND FUSE PANEL OVER TOP OF BATTERY. 3. VW DEALER REPAIR AND REPLACE WIRE HARNESS AND FUSE BODY. 4. VW CUSTOMER CARE TOOK INFORMATION ON MY COMPLAINT ABOUT DEFECT AND POTENTIAL SAFETY ISSUE BUT WOULD DO NOTHING REFERRING ME BACK TO THE DEALER. MY QUESTION WAS WHY DID VW HAVE SUCH A DEFECT WHERE THERE WAS NO FUSIBLE LINK THAT WOULD FAIL FIRST PREVENTING THE EXTENSIVE DAMAGE THAT OCCURRED. *TR
Power train, Sep 5, 2009
2000 TO 2002 VOLKSWAGEN TIPTRONIC OWNERS NOT PROVIDED CORRECT INFORMATION REGARDING THE TRANSMISSION SERVICING SCHEDULING. VOLKSWAGEN STATES THAT THE TRANSMISSION IS A "SEALED" UNIT AND THEREFORE SERVICE IS NOT NEED UNLESS LEAKS ARE VISIBLE. KNOWING THIS, I DID NOT TRY TO DO TRANSMISSION SERVICE ON MY CAR WHEN IT REACHED ABOUT 86,000 MILES. - GEARS SLIP FROM 1ST TO 2ND AT COLD STARTS AND JERKS AT 3RD GEAR. I HAVE TO WARM THE VEHICLE IN 10 MINUTES TO GO BACK TO NORMAL OPERATING MODE. - TODAY I WAS TAKING MY WIFE AND MY 1-YEAR OLD DAUGHTER TO LAKE GEORGE NY FROM QUEENS NY FOR A HOLIDAY WEEKEND. THE CAR SUDDENLY SLIPPED FROM 5TH TO 4TH GEAR WHILE WE ARE DRIVING 65 MPH. HOWEVER, I DID NOT FIND THE PROBLEM UNTIL I NOTICED THAT OUR SPEED ALMOST FEELS THE SAME EVENTHOUGH I DEPRESS THE PEDAL A LITTLE LOWER. I PLACED IT ON MANUAL MODE AND THE CAR SHIFTED FINE. WE PULLED OVER AT THE REST AREA AND FOUND OUT THAT THERE IS A TRANSMISSION FLUID LEAK. WE COULD HAVE HAD AN ACCIDENT IF THE GEAR WOULD HAVE SLIPPED TO 2ND; ALMOST LIKE SLAMMING THE BREAKS WHILE DOING 65 MPH. - TOMORROW, I WILL HAVE VW REPAIR SHOP DIAGNOSE THE PROBLEM. MOST LIKELY IS THE TRANSMISSION CONTROL UNIT OR THE TRANSMISSION SOLENOIDS. - SIMILAR ISSUES IN DSG TRANSMISSION WAS REPORTED AT "GOOD MORNING AMERICA" ON AUGUST 28 2009. - PLEASE SEE SIMILAR TIPTRONIC OWNER'S COMPLAINTS ON THIS FORUM: VWVORTEX.COM. THIS IS A PUBLIC WEB FORUM AND NO PERSONAL INFORMATION IS PROVIDED. *TR