2021 Volkswagen Tiguan
Problems, recalls and owner-reported issues
Engine is the leading concern among 141 owner complaints filed for this model year. This is the 7th highest complaint count among 17 Tiguan model years with reports.
Of the 2021 reports, 2 involved a crash. 2 people were injured.
What owners report most often
Recalls and investigations
Back over prevention, sensing system, cameraJul 20, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Golf GTI, Jetta GLI, Jetta NF, Arteon FL, Tiguan LWB, 2022 Taos, Jetta PA, Tiguan PA, 2021-2022 Atlas Cross Sport, and Atlas FL vehicles. The manufacturing process of the eMMC memory module in the infotainment system may cause the rearview camera image not to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A rearview camera that does not display an image reduces the driver's rear view, increasing the risk of a crash.
Dealers will update the infotainment software, free of charge. Owner notification letters are expected to be mailed September 16, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 91DV.
Campaign 22V514000 on NHTSA.gov
Structure, bodyApr 6, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan and 2018-2021 Tiguan long wheel base (LWB) vehicles. Due to incorrect installation instructions, the accessory rear hatch spoiler may be insufficiently attached to the vehicle.
An insufficiently attached spoiler may separate from the vehicle, becoming a road hazard and increasing the risk of a crash.
Dealers will replace the spoiler, free of charge. Owner notification letters were mailed June 3, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 66N5.
Campaign 22V226000 on NHTSA.gov
SuspensionMar 23, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2022 Tiguan, Taos, and 2021 Tiguan long wheel base (LWB) vehicles. A second notice will be sent once remedy parts become available. The left or right rear suspension knuckles may corrode, crack, and break.
A broken rear suspension knuckle can cause a loss of stability, increasing the risk of a crash.
Dealers will inspect and, if necessary, replace one or both rear suspension knuckles, free of charge. Owner notification letters were mailed June 13, 2022. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42L8.
Campaign 22V176000 on NHTSA.gov
SeatsFeb 1, 2021
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Volkswagen Tiguan Long Wheelbase and Jetta vehicles. Bolts may be missing from the front seat tracks.
The seat can move front and back without restriction if bolts are missing, increasing the risk of injury during a crash.
Volkswagen will notify owners, and dealers will inspect the front seat tracks and, as necessary, install the bolts, free of charge. The recall began February 18, 2021. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 72L6.
Campaign 21V038000 on NHTSA.gov
Back over prevention, sensing system, cameraNov 18, 2020
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 Atlas Cross Sport, Tiguan LWB, Jetta NF, Jetta GLI, Golf GTI, Atlas FL and Arteon vehicles. The rear view camera could malfunction during an ignition cycle, leading to a black screen or infotainment system freeze. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
A black or frozen rear view image reduces the driver's visibility when reversing, increasing the risk of a crash.
Volkswagen will notify owners, and dealers will update the infotainment system software, free of charge. The recall began December 11, 2020. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 91BB/91BC.
Campaign 20V716000 on NHTSA.gov
Representative owner complaints: engine
56 reports, newest first. Show all
Engine and engine cooling, Dec 18, 2025
The contact owns a 2021 Volkswagen Tiguan. The contact stated that while driving at an undisclosed speed, the contact's dad who was following behind the vehicle noticed oil splashing onto the front windshield of his vehicle. The contact's dad then noticed while the contact was driving uphill, oil was splashing out of the oil pan. In addition, the contact's dad noticed smoke coming out of the exhaust. The check engine and PCV warning lights were illuminated. The vehicle was driven to the shoulder of the road. The vehicle was inspected, and the contact's dad noticed that the oil pan was completely empty. The vehicle was towed to an independent mechanic, where it was diagnosed with a cracked oil pan. The contact was informed that the oil pan, gasket, and filter needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that while driving at an undisclosed speed, the contact's dad noticed the oil splashing underneath the vehicle again. The vehicle was driven to the shoulder of the road. The vehicle was inspected, and the contact noticed that oil was spilling out onto the road. The oil pan was empty. The vehicle was towed back to the independent mechanic. The independent mechanic contacted the dealer. The independent mechanic was informed that this was a known failure with the vehicle. The independent mechanic was informed that the failure was that the PCV valve had either failed or was clogged. The independent mechanic was informed that the failure normally occurred between 60,000-100,000 miles. The contact was informed that the failure might recur after the repair, however there was no recall for the failure. The vehicle was being repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 93,000.
Engine, Dec 16, 2025
The 2021 Tiguan, R-Line that I own now requires a new engine after roughly 70,000. The engine is no longer under warranty, According to the VW Dealership, this is what is wrong with the engine - Based on our observations and diagnostic review, we have determined that damage to the rotating assembly was caused by the presence of one or more metal objects entering the engine. This type of foreign-object intrusion can lead to significant internal impact, which is consistent with the damage we found during our assessment. Also, if you do a search on Reddit and other public forums, there are a lot of 2021 VW Tiguan's with similar issues.
Power train, Electrical system, Engine, Nov 16, 2025
I’ve had my Volkswagen Tiguen since 2021 fresh off the lot. I have been the only owner of the car at about 30,000 miles my head gasket blew, causing the engine to go into default after weeks in the dealer. They replaced the head gasket and stitched it up, the head gasket blew again at this point I was still under warranty so they agreed to replace the engine. It drove fine after the engine was replaced this year 2025. I started to have a whole host of problems. It began to jerk and hesitate at acceleration. My engine light came on with continuous jerking upon acceleration for weeks until I started to lose power in my engine. I couldn’t go over 50 60 mph. I would always pull the car over power it off and power it back on just to see if it would change and it didn’t do much I had a local mechanic add oil to each tire also drain the engine, which had shards of metal in it. And basically stitch the car back together until we can figure out the bigger issues. It’s only been a day since the oil was added to each tire. I had a very violent jerk of the engine, which made it feel and sound like I blew a tire I got out to look at the tire and it was just fine. It was the backfire of the engine going into the exhaust that caused such the violent jerk. Happy that no one was on the road. If somebody was behind me it would’ve easily been an accident. Most of these dealerships know exactly what’s going on and have been avoiding the big conversation of what to do next they rather just replace and Band-Aid these things into the consumer just gives up. I have two small children and this is the only means of transportation. I’m fearful that I’ll be stuck with a car note for a car. I can’t drive.
Engine, Nov 14, 2025
Check engine light came on with excessive oil leaking from engine. Dealer inspected and diagnosed the PCV/Oil separator had failed, multiple valve stem seals had failed, and valve stem guides were worn causing excessive crankcase pressure. Dealer recommended cylinder head replacement. Vehicle has been at the dealer a month with the cylinder head on backorder and no timeline for resolution. Dealer indicated thousands of cylinder heads in the queue, with tens of units being distributed per month.
Engine, Oct 14, 2025
2021 Volkswagen Tiguan, Approximately 40,000 miles Date of failure: Oct 12th, 2025 Component(s): Engine, Powertrain, Vehicle Speed Control, Throttle body Description of the problem: My 2021 Volkswagen Tiguan experienced a complete engine failure despite having multiple prior service visits for engine-related issues while it was still under warranty. During the warranty period, I brought the vehicle to Grand Junction Volkswagen (Grand Junction, CO) several times for problems including: * Excessive oil consumption * “Check coolant” warning light turning on * EPC (Engine Power Control) mode activating and loss of power The dealership performed an oil consumption test and told me the results were “normal,” but they did not address the coolant light or EPC issues, stating these conditions were within normal limits. The same problems continued after each visit. At approximately 40,000 miles, the engine failed completely while driving, leaving the vehicle inoperable and creating a significant safety risk. The vehicle had to be towed. Volkswagen is now denying liability, claiming the vehicle is out of warranty, even though the same engine problems were documented repeatedly while it was still under warranty. I have opened a case with Volkswagen of America Customer Care (Case #07085098), but there has been no resolution so far. Safety concern: This issue poses a serious safety hazard. The vehicle can lose power suddenly and stall while in motion, which could lead to a crash or leave occupants stranded in unsafe conditions.
Engine, Oct 1, 2025
Subject: Complaint Regarding 2021 Volkswagen Tiguan – Premature Engine Failure at 46,000 Miles To Whom It May Concern, I am filing a complaint regarding my 2021 Volkswagen Tiguan (VIN: [XXX] ) which suffered a catastrophic engine failure at only 46,000 miles. •I purchased the vehicle used in August 2023 through CarMax Auto Finance. •At the time of failure, the car had fewer than 50,000 miles and had been properly maintained. •Despite the extremely low mileage, Volkswagen has refused to cover the repair under warranty because the vehicle is slightly past the 4-year time limit. I believe this is unfair and unreasonable. A major component such as the engine should not fail this early, and a vehicle sold under these conditions is not fit for its ordinary purpose. Because of this premature failure, I was left with no functional car but still obligated to pay the outstanding loan balance. This has caused severe financial hardship and forced me to dispose of the vehicle below value. Requested Action: 1.That Volkswagen cover or reimburse the cost of the engine replacement, OR 2.Provide financial relief toward the remaining auto loan balance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Engine, Sep 23, 2025
I purchased about 4 months ago with about 139,000 miles on it. The vehicle now has 142,000 miles and is experiencing excessive oil consumption—approximately 0.9 quarts per 600 miles. VW seems to be pushing this off and as I try to use my extended warranty I purchased when I got the car, AUL has asked for an engine tear down. VW knows about this issue, as it is internally a known issue for this model, yet they are unwilling to help. At time of purchase, this issue was not disclosed to me, as such had it been, I would not have chosen this car.
Electrical system, Engine, Sep 2, 2025
Upon starting my 2021 Volkswagen Tiguan, the vehicle immediately went into "limp" mode and the check engine light and EPC light came on. The vehicle would not drive over 18 mph. The car was towed to a close by Volkswagen dealership and checked for codes using a multipoint inspection. The report came back with a throttle body issue (Multipoint inspection report attached). The throttle body was replaced and the vehicle was taken for a 15 mile test drive. During the drive, the same problem occurred. After the drive, 34 codes were found in VWs report. I have also attached the report to this complaint. The technicians at the VW dealership didn't understand the problem, so they opened up communication with Volkswagen in Germany. The Volkswagen engineer advised the dealership to replace the wire harness. After the wire harness was replaced, the car has no more issue (although it has only been 5 days since), which cost $2314.54 in total. There is a class action lawsuit in the state of New Jersey (Case [XXX]) against Volkswagen Group of America that states "VW is aware of concerns involving faulty wire harnesses"... affecting 2019-2022 Volkswagen Atlas, Golf, Jetta, TIGUAN, and Taos. Thank God that this happened to my vehicle with the car was at rest and not traveling at a high rate of speed that could have been fatal. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Aug 25, 2025
The contact owns a 2021 Volkswagen Tiguan. The contact stated that while driving approximately 55 MPH, the check engine warning light illuminated. The vehicle was not diagnosed or repaired. The contact stated that on three separate occasions, while the vehicle was parked, the contact observed oil on the ground underneath the vehicle. The vehicle was then taken to a dealer, and oil was discovered under the vehicle. The vehicle was diagnosed, and determined that the breather failure caused the crank case pressure to enter the system, causing the upper timing gasket and seal to be compromised and leak oil. The contact was informed that the oil separator timing cover, CAM magnets, and oil pan needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was approximately 50,000.
Engine, Aug 20, 2025
VW dealership diagnose by 2021 VW Tiguan with a cracked oil pan and timing cover. The cause was from excessive oil pressure from a failed PCV valve which cracked the plastic oil pan causing excessive oil leak. This occurred driving on the highway and the ECP light on the dash came on with a message "max epinine rpm 3000". Vehicle quickly slowed down and was extremely sluggish to maintain a safe speed with other traffic. Dealer was able to see cracked oil pan and oil leak from timing chain cover and read error codes pointing to the issue. Can physically see crack in oil pan. Oil spilled out from oil pan onto ground when tow truck moved it. Dealer produced a video of the issue and visual see the cracked oil pan and leaking timing chain cover. ECP light and engine max speed error was displayed while driving on the highway. From my understanding, basically the PCV valve fails and it over pressurizes the crankcase. It can cause the gaskets to fail causing leaks or the oil pan to crack which in our case the oil pan cracked.
Engine and engine cooling, Jul 29, 2025
The contact owns a 2021 Volkswagen Tiguan. The contact stated while driving at an undisclosed speed, the contact noticed blue smoke coming out of the exhaust pipe. There was no warning light illuminated. Additionally, the contact stated that the vehicle was experiencing excessive oil consumption. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 46,000.
Engine, Jul 15, 2025
At only 38,200 miles the dealership found shards of metal in my engine. The only solution is to replace the entire engine and my car just passed its warranty 5 months ago. I have kept up to date with services and driven the car responsibly. There is also another 2021 VW Tiguan owner in my town and her car did the same thing at only 29,000 miles! She was still under warranty so the engine was replaced but she now states that it burns through oil at a concerning rate. One day the engine like just turned on, then the car goes into a “limp” mode and doesn’t exceed 3000RPM.
Engine, Fuel/propulsion system, Jul 1, 2025
At about 60,000 miles a VW dealer told me it was normal for VWs to use oil. Now at 80,000 I have a $2,000+ bill b/c the PCV is faulty and the timing cover has failed. I did NOT get a low dngine oil warning, but mechanic says panic wait it was low ( oil change 4,000 miles ago). This could have led to a seized engine on the interstate. I am upset to learn this is a common problem with this vehicle. It is an expensive repair. From other posters I fear this is not the end of the problem. VW should recall this part .
Engine, Jun 19, 2025
The lower oil pan cracked due to excess pressure in the engine from a broken oil air vent. This is a very common issue in VW tiquans, that VW knows about but doesn't recall. The faulty air oil vent leads to cracked lower oil pans and oil dumps that can damgae the engine and creates dangerous driving situations.
Engine, Apr 22, 2025
volkswagen vehicles have a real serious problem that can cause your car fails in the middle of the road, and it is the oil separator. A failing oil separator can lead to poor engine performance and potential damage. It will cause a massive oil leak that will damage others' engine components, and the car can stop working at any moment, and it can be a dangerous situation. The most affected vehicles are Volkswagen tiguan. Please investigate this problem because a lot of people are dealing with this dangerous situation.
Engine and engine cooling, Engine, Apr 8, 2025
The contact owns a 2021 Volkswagen Tiguan. The contact stated while driving 65 MPH, the accelerator pedal was depressed, and the vehicle failed to respond. The contact stated that the vehicle was losing power and was unable to drive uphill. The contact also stated the engine was consuming an excessive amount of oil; however, the dealer had informed her that the oil consumption was normal. The check engine and electronic power control (EPC) warning lights were illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the turbo cylinder and timing chain needed to be replaced. The local dealer was contacted; however, the vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 200,000.
Engine, Apr 7, 2025
My 2021 Tiguan suddenly lost power causing my wife and daughter to be stranded. Car was not drivable and lost both oil and power. Towed to VW dealer and was diagnosed with a faulty pcv/oil separator causing excessive crankcase pressure. This party failed once car warranty was over costing almost $2000. Prior to the car stranding them they had to drive at less than 25 MPH on the Long Island expressway. oil was leaking from the upper timing cover seals. VW Dealer removed and replaced oil pan with gasket, pov and upper timing cover seals. filled o i l to correct level,road tested vehicle and rechecked and no leaks at this time. All this damage occurred by no fault of our own. I have learned thru my research that this is a common problem on the VW Tiguans. All has been repaired and replaced as you can see from the receipt attached. Prior to the party failing multiple lights lit up on the dashboard forcing my wife to pull over and get out of. harms way until someone could come and get her.
Engine, Mar 25, 2025
Engine oil light came on and car was down about 2 quarts of oil AGAIN. Car was last serviced as noted below VW service 11/22/2024 Mileage in 62086 Mileage out 62087 (what kind of test drive was this, less than a mile) ?? 2021 VW Tiguan Service Advisor 413 Montpelier VW 802-223 -3434 ____________________________________________________________ A C/S: Check Engine light is no CEL Default 1000 CP606.33 1.1 06M-906-517-E VALVE 32.67 2.1 06Q-103-495-B SEPARATOR 93.74 3.2 06l—103-583-C GASKET130.06 4.1 06L-103-483-a GASKET 77.20 PARTS: 333.67 LABOR: 606.33 OTHER: 00.00 TOTAL line A $940.00 620000 P04F000; EVAP system high pressure purge line performance Checked purge valve and found oil in line, due to a defective crankcase breather and causing an oil leak, replaced crankcase breather, replaced the EVAP purge valve and replaced the upper timing cover gaskets, cleared code cleaned oil off engine and test drove. ________________________________________________________________ B. Multipoint Inspection MPI Default 1000 CVP Parts 00 labor 000 other 000 total line B 0000 C. Customer states oil change done on 11/17- checked oil and was extremely low and had to add oil, please advise. Recommend Maint 1000 CP000 Parts 00 labor 00 other 000 total line C 000 D. Customer states tires pressure always on and off, please advise 01 Recommend Main 1000 CP000 Parts 000 labor 000 other 000 total line D 000
Engine, Mar 17, 2025
There was an issue with excessive oil consumption. In as little time as I have owned this vehicle I have had to top my oil off between oil changes because my low oil light had came on. I then, over the winter got a check engine light, it threw code P24D6 which pertained to the oil leak and/or seperating. I then noticed that on my driveway, I have some oil from my car. I paid a mechanic $200 to fix this plastic drain that according to the mechanic doesnt reseal.
Electrical system, Engine, Fuel/propulsion system, Dec 3, 2024
11/19/2024 Check engine light came on while I was driving. Got home, checked oil and it was down about a quart. Oil had just been changed on 10/17/2024. Only approximately 1800 miles put on vehicle since last oil change. Vehicle was at approximately 62,000 miles. Also tire pressure light always on. Scheduled appt with VW dealer. Dealer invoice states "P04F000 Checked Purge valve and found oil in line, due to Defective crankcase breather, and causing an oil leak, replaced crankcase breather, replaced the EVAP purge valve and replace the upper timing cover gaskets. cleared oil off engine and test drove". the engine could have blown while I was driving this, I had no previous warning signs and since the dealer says the Defective crankcase breather, thinking they should be fixing this issue and not charging the customer. Total cost of repair $960.02.
Engine, Nov 9, 2024
Pcv valve on my car went and caused seals to leak in my engine. This has caused oil to leak onto my exhaust system which poses a fire hazard according to the dealership. Car should not be driven. Many many complaints about this issue of the PCV valve failing have been discovered online. Worried about my car catching fire if I drive it
Engine and engine cooling, Oct 8, 2024
The contact owns a 2021 Volkswagen Tiguan. The contact stated that the vehicle was leaking oil. There were no warning lights illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined that the valve cover needed to be replaced. The vehicle was repaired, but the failure recurred. There was gray smoke coming from the vehicle. The vehicle was taken back to the local dealer, where it was diagnosed that the valve stem seals needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, but no additional assistance was provided. The failure mileage was approximately 53,000. The VIN was not available.
Power train, Engine, Sep 2, 2024
PCV Failure causing the timing cover to leak oil and causing the oil pan to crack. This is a known issue with VW TSI engines. This PCV is a major issue not only causing the damage above but others are having to replace the rear main seal and crank case because of this. It's now in the shop for the next week and I'm out of a vehicle for the next week. This is not the only problem I've had with this vehicle. The last problem I had was the housing unit of the overhead lights, sunroof controls and sos when hanging down and broke out of nowhere. The plastic melted and cracked. It was replaced but was not put back together properly. There are now gaps where it should be tightly sealed. The glove comparent arm is broken. There are wheel bearings issues too we are trying to pin point the issue. The hits keep coming and the car is just a money pit.
Engine, Aug 2, 2024
We were driving to Mci airport. We felt car jerk. Was able to continue driving. Got off at exit. Pulled over looked under hood, didn’t see anything. Pulled away felt it pulling back. Was able to make it home at just 60 miles an hour. The care would hesitate and jerk if going up slight hill or accelerating. Took to shop. They said it was pvc valve. Which caused crack in oil pan as well as timing chain cover. It also coated under car in oil. I did some research and this seems to be a fairly common issue. Same issue and results. Some of them had less miles than mine but most were around the range. I think if you investigated these engines no matter what vehicle Vw put them in you will find a common thread. I would appreciate your research and feedback in this matter. Thank you
Engine and engine cooling, Engine, Jun 3, 2024
The contact owns a 2021 Volkswagen Tiguan. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive. The low oil level warning light was illuminated. The vehicle was towed to an independent mechanic, who observed a crack in the oil pan. The vehicle was repaired, but the failure reoccurred. The vehicle was towed back to the independent mechanic, who then diagnosed a failure with the engine. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 50,000. The VIN was not available.