2003 Chevrolet Malibu
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 611 owner complaints filed for this model year. This is the 16th highest complaint count among 26 Malibu model years with reports.
Of the 2003 reports, 37 involved a crash and 4 involved a fire. 26 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Electrical system, ignitionJul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
Campaign 14V400000 on NHTSA.gov
Fuel system, other, storage, tank assembly, pressure relief devicesMar 12, 2007
CERTAIN DELPHI FUEL PRESSURE REGULATORS, P/NOS. FP10020-11B1, FP10026-11B1, AND FP10027-11B1, SOLD AFTER JANUARY 9, 2007, AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE UNIVERSAL PRESSURE REGULATORS (UPR) WERE PRODUCED WITHOUT AN O'RING AND RETAINER.
FUEL MAY LEAK, POSSIBLY RESULTING IN A FIRE.
DELPHI WILL NOTIFY OWNERS AND REPLACE THE UPR FREE OF CHARGE. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS CAN CONTACT DELPHI AT 877-411-8770.
Campaign 07E021000 on NHTSA.gov
Vehicle speed control, accelerator pedalNov 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 124, 'ACCELERATOR CONTROL SYSTEMS.' IN HOT AMBIENT CONDITIONS, THE ACCELERATOR PEDAL ARM MAY STICK AT THE ATTACHMENT TO THE BRACKET AND NOT RETURN TO THE ENGINE IDLE POSITION WHEN THE OPERATOR LIFTS HIS FOOT FROM THE ACCELERATOR PEDAL.
FAILURE TO RETURN TO IDLE COULD RESULT IN A VEHICLE CRASH.
DEALERS WILL INSPECT THE ACCELERATOR PEDAL ARM AND REPLACE THE ACCELERATOR AND BRAKE PEDAL ASSEMBLY WITH A NEW ASSEMBLY, IF NECESSARY. THE RECALL BEGAN ON DECEMBER 20, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Campaign 04V528000 on NHTSA.gov
Representative owner complaints: exterior lighting
31 reports, newest first. Show all
Service brakes, Hydraulic, Exterior lighting, Nov 19, 2003
2003 CHEVROLET MALIBU HAVE PROBLEMS WITH ROTORS.*MR THE CONSUMER WAS ALSO TOLD THE VEHICLE HAD A DEFECTIVE BRAKE LAMP SWITCH WHICH CAUSED PARTS TO ACTUALLY MELT BECAUSE THE BRAKES STAYED ENGAGED WHILE DRIVING. ONE MONTH LATER THE VEHICLE WAS BACK TO EXPERIENCING THE SAME PROBLEM, THE CONSUMER STATED WHEN HE ATTEMPTED TO MAKE A U-TURN, THE TIRE DID NOT TURN THEY GRABBED THE ROAD AND SAT THERE JUST BENDING THE PRESSURE OF THE TURN AND THE VEHICLE BUCKED. *JB *NM
Exterior lighting, Oct 10, 2003
WITH THE INCREASED BRIGHTNESS OF HEADLIGHTS IT IS VERY DIFFICULT TO SPOT FRONT TURN SIGNALS AT NIGHT WHEN THEY ARE PLACED ADJACENT TO THE LOW BEAM LAMP. PLEASE CONSIDER MANDATING THAT SIGNAL LAMPS MUST BE AT LEAST THREE INCHES FROM THE EDGE OF THE LOW BEAM'S REFLECTOR. *LA
Exterior lighting, Sep 30, 2003
HEADLIGHTS IN MY 2003 CHEV MALIBU CONTINUALY STAY FOGGED UP WITH WATER INSIDE THE LENS AND CHEVY IS AWARE OF THE PROBLEM. I THINK IT COULD CAUSE POTENTIAL PROBLEMS WITH THE LIGHTS WORKING PROPERLY.
Service brakes, Hydraulic, Exterior lighting, Aug 22, 2003
CHEVROLET 2003 MALIBU - THE CAR WAS LEASED IN MARCH 2003. THE BRAKES WERE FAILING AND THE CAR WAS TAKEN BACK TO THE DEALER. THEY COULD NOT DETECT ANY PROBLEMS SINCE NO LIGHTS CAME ON IN THE CAR. THE PROBLEM OCCURRENCE IS UNPREDICTABLE. BRAKES BECOME VERY HARD AND CAR DOESN'T STOP, STEERING WHEEL VIBRATES, CAR DOES NOT ACCELERATE, CONSUMES A LOT OF GAS. PROBLEM DETECTED WAS BRAKE PEDAL REMAINED DOWN EVEN WHEN IT WASN'T BEING USED. THE CAR WAS BROUGHT BACK TO THE DEALER THREE TIMES BEFORE THE DEFECT WAS DETECTED BY THE SERVICE MANAGER. THE CAR WAS REPORTEDLY REPAIRED (READJUSTED SWITCH FOR PROPER RELEASE OF BRAKE, REPLACED FT PADS AND ROTORS DUE TO EXCESS HEAT ON FT BRAKES), BUT AFTER A WEEK, THE PROBLEM REPRESENTED ITSELF. THE CAR IS NOW (8/21/03) AT THE DEALER FOR REPAIR (4TH TIME IT GOES IN). THE MANUFACTURER CUSTOMER SERVICE IS GIVING ME A DIFFICULT TIME ADMITTING THAT THE CAR HAS A SERIOUS DEFECT. THEY ARE TRYING TO CONVINCE ME THAT THE SYMPTOMS THE CAR PRESENTS MAY NOT SIGNIFY THAT THE PROBLEM IS THE SAME. I TOTALLY DISAGREE BECAUSE, IT IS THE SAME PROBLEM. MY HUSBAND AND I WERE ALMOST KILLED ON THE NJ TURNPIKE DUE TO THIS PROBLEM. I HAVE ASKED THEM TO TAKE BACK THE CAR BUT I HAVE HAD LITTLE SUCCESS. I AM HOPING THAT THIS COMPLAINT WILL SPARK AN INVESTIGATION. THE DEALER MENTIONED THAT THIS EXACT PROBLEM WAS FOUND ON THE AVALANCHE MODELS.*AK
Exterior lighting, Aug 11, 2003
THE DESIGN OF THE AUTOMATIC LIGHT CONTROL FOR THE HEADLAMPS SUBJUGATES THE RESPONSIBILITY STATE LAW PLACES ON THE VEHICLE OPERATOR. THE OPERATOR CERTANTLY CAN _CHOOSE_ TO ALLOW A AUTOMATIC SYSTEM TO OPERATE THE LIGHTS IF THEY WANT TO, HOWEVER SHOULD NOT BE FORCED TO USE IT IF THE OPERATOR IS NOT COMFORABLE WITH THE WAY THE AUTOMATIC SYSTEM OPERATES. ADDITIONALLY, THE AUTOMATIC LIGHTING SYSTEMS CAN ONLY DETERMINE WHEN AMBIENT LIGHTING CONDITIONS _MAY_ REQUIRE LIGHTING BUT _CANNOT_ DETERMINE OTHER SPECIFIC WEATHER-RELATED CONDITIONS WHEN THE LAWS OF MY STATE ALSO MANDATE VEHICLE LIGHTING BE USED. MOST NOTABLY, THE AUTO SYSTEM DOES NOT ALWAYS "KNOW" WHEN IT'S FOGGY, RAINING OR SNOWING DURING DAYLIGHT HOURS, APPLYING LIGHTING SOMETIMES IN THOSE CASES, BUT NOW ALWAYS. OR BEGINNING WITH THE LIGHTS ON, THEN THEY GO OFF, THEN ON AGAIN, THEN OFF AGAIN DURING A TRIP WHEN THE LIGHTS SHOULD REMAIN ON CONTINOUSLY. THIS OFTEN OCCURS WITHOUT ANY INDICATION TO THE OPERATOR THAT THESE CHANGES IN STATUS OF THE LIGHTS ARE OCCURING. IN FACT, WITH DRLS LIT IN THE FRONT, THE NORMAL VISUAL QUEUE THAT THE LIGHTS ARE OUT THAT ONE WOULD EXPECT IS ABSENT (THE DRLS LOOK LIKE HEADLIGHTS) AND IT'S TOO BRIGHT OUT TO TELL IF THE DASH LIGHTS ARE ON OR NOT. IN MY OPINION, THIS IS A SAFETY ISSUE THAT NEEDS TO BE ADDRESSED. GM SHOULD RETROFIT THE MALIBU'S WITH TOTAL OVERRIDE OF THE AUTO SYSTEM (COMPLETE DISABLE OF THE AUTO LIGHTS AND DRLS) FOR THOSE OWNERS THAT REQUEST IT.
Exterior lighting, Apr 16, 2003
I HAVE A CHEVROLET MALIBU AND THE TURN SIGNALS DON'T WORK AT ALL TIMES. *NLM