2003 Chevrolet Tahoe
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 534 owner complaints filed for this model year. This is the 4th highest complaint count among 26 Tahoe model years with reports.
Of the 2003 reports, 21 involved a crash and 9 involved a fire. 18 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Wheels, hubDec 17, 2007
CERTAIN FEDERAL-MOGUL REPLACEMENT WHEEL HUB ASSEMBLIES WITH THE BRAND NAMES: NATIONAL, CARQUEST P/NOS. 515020, 515021, 515025, 515053, 515054, 515059, AND 515060, SHIPPED BETWEEN JANUARY 23, 2006, AND DECEMBER 20, 2007, SOLD FOR LIGHT DUTY AND MEDIUM DUTY TRUCKS. THE INBOARD RETENTION NUT USED TO MAINTAIN HUB BEARING ASSEMBLY CAN LOOSEN RESULTING IN AN ABS LIGHT INDICATION, NOISE, AND/OR WHEEL SEPARATION.
WHEEL SEPARATION CAN RESULT IN A VEHICLE CRASH.
FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND WILL REPLACE THE HUB ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2008. OWNERS CAN CONTACT FEDERAL-MOGUL TOLL-FREE AT 877-489-6659.
Campaign 07E106000 on NHTSA.gov
Fuel system, gasolineMay 19, 2006
CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.
THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
Campaign 06E043000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Seat belts, rear/otherApr 22, 2005
ON CERTAIN CREW CAB PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE 2ND ROW CENTER OCCUPANT SEAT BELT ROUTING MAY MAKE IT DIFFICULT TO POSITION THE LAP PORTION OF THE SAFETY BELT LOW AROUND THE HIPS OF OCCUPANTS, ESPECIALLY SMALLER OCCUPANTS, SEATED IN THIS POSITION. APPROPRIATE USE OF A CHILD SEAT OR BOOSTER SEAT, AS RECOMMENDED FOR SMALL CHILDREN, DOES IMPROVE THE FIT CONDITION FOR THIS USER GROUP. IN ADDITION TO INSTRUCTIONS ON PROPER INFANT AND YOUNG CHILD RESTRAINT (WITH CHILD SEATS OR BOOSTERS), SPECIAL VERBIAGE FOR RESTRAINING OLDER CHILD IS INCLUDED IN THE OWNER'S MANUAL. ALSO, THE SUGGESTED SEAT BELT FIT/ROUTING FOR ADULTS, IRRESPECTIVE OF SEATING POSITION, IS DESCRIBED IN THE OWNER'S MANUAL TEXT.
A LAP PORTION OF THE SEAT BELT ROUTING THAT IS NOT LOW AND SNUG ON THE HIPS CAN ALLOW THE LAP BELT TO RIDE UP ON AN OCCUPANT'S ABDOMEN INSTEAD OF FITTING LOW AROUND THEIR HIPBONES, AND THEREFORE, CAN EXPOSE THEM TO MORE RISK OF ABDOMINAL AND INTERNAL ORGAN INJURY.
DEALERS WILL CUT OPEN THE GUIDE LOOP, REMOVE A PORTION OF THE LOOP, AND THEN THE REMAINING TWO SIDES SHOULD BE FOLDED OVER AND SECURED WITH A RETAINER FREE OF CHARGE. THE RECALL BEGAN ON JULY 21, 2005. OWNERS MAY CONTACT CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR HUMMER AT 1-800-732-5493.
Campaign 05V163000 on NHTSA.gov
Service brakes, hydraulicFeb 4, 2004
CERTAIN SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND PASSENGER VANS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, ?PASSENGER CAR BRAKE SYSTEMS.? SOME OF THESE VEHICLES WERE PRODUCED WITH AN OUT-OF-SPECIFICATION BRAKE HYDRO-BOOST HOUSING RELIEF VALVE BORE.
CONSEQUENTLY, THE VALVE O-RING SEAL MAY FRACTURE. STEERING EFFORTS MAY BE SLIGHTLY INCREASED WHILE BRAKING OR PARKING. UNDER CERTAIN DRIVING CONDITIONS, A FRACTURED SEAL MAY REQUIRE A SLIGHT INCREASE IN THE APPLIED BRAKE PEDAL EFFORT TO ACHIEVE THE SAME VEHICLE DECELERATION RATE AS PRIOR TO THE SEAT FRACTURE.
DEALERS ARE TO REPLACE THE HYDRO-BOOST RELIEF VALVE. THE RECALL BEGAN ON JUNE 18, 2004. OWNERS SHOULD CONTACT CADILLAC AT 1-866-982-2339; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; OR HUMMER AT 1-866-486-6376.
Campaign 04V045000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Structure, body, door, hinge and attachmentsFeb 6, 2003
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 214, "SIDE IMPACT PROTECTION." THESE VEHICLES ARE BUILT WITH FOUR WELDS ON THE REAR DOOR UPPER HINGE. ON SOME OF THESE VEHICLES, ONE OR TWO OF THE WELDS MAY NOT BE TO SPECIFICATION.
AS A RESULT, THE DOOR STRENGTH MAY BE DEGRADED DURING A SIDE IMPACT VEHICLE CRASH.
DEALERS WILL INSPECT THE WELDS ON THE LEFT REAR DOOR UPPER HINGE. IF A WELD IS FOUND OUT-OF-SPECIFICATION, A BOLT WILL BE INSTALLED TO SECURE THE HINGE. OWNER NOTIFICATION BEGAN FEBRUARY 17, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, OR GMC AT 1-800-462-8782.
Campaign 03V037000 on NHTSA.gov
Representative owner complaints: service brakes
112 reports, newest first. Show all
Air bags, Seat belts, Service brakes, Feb 21, 2021
WELL MY AIR BAG LIGHT STAY ON NEVER GOES OVER AND MY DRIVER SEAT BELT DOES NOT EVEN LOCK AT ALL. THEN I KEEP HEAR THIS POPPING NOISE THAT COME FROM HUB AND SHOCKS AND NOTHING ON MY DASH WORKS 1ST IT STARTED OFF BY I COULDNT SEE WHAT GEAR I WAS IN. MY DRIVER SEAT U PUSH THE BUTTON TO GO FORWARD IT MOVES THE SEAT BACK. MY HEAT BLOWER HAS SOMETHING WRONG WITH AND IT HAS SOMETHING TO DO WITH THIS PURPLE WIRE ON THE FLOOR BORED. NOW MY TRUCK CANT GET ON THE FREE WAY BECAUSE EVERY THIME I GET ON THE FREEWAY AND ON THE FREE WAY FOUR MORE THEN 10-15 MIN MY TRUCK JUST SHUTS OFF. MY HEATED SEATED ONLY STAY ON FOR 1 TO 2 MIN AND THEN KEEPS SHUTTING OFF. MY BACK SEATS DONT LET DOWN AT ALL. THEN AT THE BOTTOM OF MY TRUCK WHERE THE OIL PAN IS FOR SOME REASON THERE IS ALWAYS ALOT OF OIL ALL OVER AT THE BOTTOM LIKE SOMEONE JUST DIP MY TRUCK IN A BIG BOWL OF OIL. THEN WHEN MY IGNITION WHERE THE YELLOW BLACK AND RED WIRE GO TO THE TOP OF MY IGNITION THE BLACK PLUG IS REAL LOSE AND CAN'T REPLACE AT ALL. AND WITH EVERYTHING ON NOW WITH MY INCOME IM ALREADY OUT OF $5,000 ALREADY FOR PARTS AND LABOR THIS IS MU ONLY CAR I HAVE AND I REALLY NEED MY CAR RIGHT NOW DONT HAVE MONEY TO GO BUY A NEW TRUCK OR CAR. I REALLY NEED MY TRUCK IT MEAN ALOT TO ME.
Service brakes, Aug 14, 2019
DESCENDING A GRADE APPROACHING A T INTERSECTION BRAKE PEDDLE WENT NEARLY TO FLOOR. CAUSE WAS A SEVERELY RUSTED REAR BRAKE LINE. THIS LINE IS ROUTED ABOVE THE LEFT FRAME RAIL IN A NEARLY INACCESSIBLE AREA, SO THE NOTION THAT THIS IS AN OWNER MAINTENANCE ISSUE IS GARBAGE.
Service brakes, Apr 17, 2018, crash
EXITING FROM THE EXPRESSWAY WITH TRAFFIC LIGHT ABOUT 20 YARDS AWAY, CARS WERE STOPED DUE TO RED LIGHT AND I AM COMING DOWN HILL EXITING. APPLYING THE BREAKS AND THE PADDLE GOES TO THE FLOOR, I REAR ENDED THE VEHICLE ON THE FAR RIGHT .
Service brakes, Oct 3, 2017
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHILE DRIVING DOWN AN INCLINE AT APPROXIMATELY 10 MPH, THE BRAKES FAILED AND THE VEHICLE ACCELERATED TO APPROXIMATELY 30 MPH. THE VEHICLE STOPPED AT THE END OF THE ROAD ON A FLAT AREA ON ITS OWN. THE CONTACT ALSO STATED THAT THE BRAKE PADS, ROTORS, AND MASTER CYLINDER WERE REPLACED APPROXIMATELY ONE YEAR AGO IN AUGUST OF 2016 BY AN INDEPENDENT MECHANIC. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AGAIN. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.
Vehicle speed control, Service brakes, Feb 27, 2017
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. THE CONTACT STATED THAT THE CRUISE CONTROL WAS INOPERABLE. THE ABS AND THE PARKING BRAKE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 172,000.
Service brakes, Feb 7, 2017, crash
WHILE DRIVING THE BRAKES TOTALLY FAILED. PEDAL WENT TO THE FLOOR WITH NO BRAKES AT ALL. VEHICLE HAD TO RUN OFF THE ROAD AND STOP USING THE EMERGENCY BRAKE. AS SOON AS THE BRAKE PEDAL WAS PUSHED IT WENT TO THE FLOOR AND THEN WARNINGS LIGHT TO SERVICE ABS STARTED FLASHING AND BEEPING. THERE WAS NO WARNING PRIOR TO THE FAILURE OF THE BRAKE SYSTEM. AFTER THE VEHICLE WAS TOWED WE FOUND THAT THERE WAS NO BRAKE FLUID AND A LARGE RUPTURE WAS FOUND IN THE BRAKE LINE ON THE DRIVERS SIDE TOWARDS THE FRONT OF THE DRIVERS SIDE DOOR.
Service brakes, Jan 12, 2017
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHEN THE VEHICLE WAS STARTED, THE BRAKE PEDAL TRAVELED TO THE FLOOR. THE CONTACT EXITED THE VEHICLE AND NOTICED BRAKE FLUID ALL OVER THE DRIVEWAY. THE CONTACT INSPECTED UNDER THE VEHICLE AND DISCOVERED THAT THE BRAKE LINE WAS CORRODED AND LEAKING FLUID. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED BY THE DEALER OR AN INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.
Service brakes, Jan 9, 2017
I HAVE AN 03 TAHOE Z71 200000 MILE AND BRAKE LINES ARE RUSTED OUT, NOW I HAVE READ OVER SEVERAL HUNDRED COMPLAINTS ON THIS VEHICLE RANGING FROM 40000 MILE ALL THE WAY UP TO 280000 MILE, EVEN COMPLAINTS BACK TO WHERE THIS TRUCK WAS A FEW YEARS OLD, WHY ARE YOU STILL ALLOWING GM TO MASS PRODUCE THESE VEHICLES WITH NO PUNISHMENT WITH FAULTY BRAKE LINES. THERE WHERE 2015 MODEL SILVERADO'S, AND TAHOE WITH THIS ISSUE. DEMAND A RECALL ON THIS ISSUE PLEASE.
Service brakes, Oct 28, 2016
WHILE BRAKING A LITTLE HARDER THAN NORMAL TO AVOID HITTING A DEER, THE BRAKE LINE JUST BELOW THE DRIVERS AREA BLEW AND THE BRAKES WENT TO THE FLOOR AND THE SERVICE ALARMS WENT OFF ON THE DASH. I WAS GOING DOWN HILL AT THE TIME BUT STILL HAD ENOUGH BRAKE TO STOP. I WAS GOING ABOUT 35 MPH AT THE TIME OF FAILURE.
Service brakes, Jun 20, 2016
FRONT BRAKE LINE BLEW OUT JUST AS I WAS PULLING IN MY DRIVEWAY.I BOUGHT THE TRUCK USED IN JULY OF 2015 THE BRAKE LINES RUSTED AND PEELING
Service brakes, Apr 6, 2016
I WAS ON THE HIGHWAY WHEN I HAD TO SLAM ON MY BRAKES AND THE PEDAL JUST WENT TO THE FLOOR I HAD NO BRAKES AT ALL. I WAS FORCED TO STEER INTO THE DITCH TO AVOID A COLLISION. AFTER HAVING THE TRUCK TOWED HOME I DISCOVERED A BRAKE LINE HAD POPPED DUE TO RUST. I UNDERSTAND THIS IS AN ONGOING PROBLEM WITH THESE VEHICLES
Service brakes, Apr 1, 2016, crash
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHILE DRIVING 60 MPH IN RAINY WEATHER, THE BRAKES WERE ABRUPTLY APPLIED TO AVOID A COLLISION. THE BRAKES DID NOT RESPOND AND THE CONTACT SWERVED TO AVOID CRASHING INTO THE REAR OF ANOTHER VEHICLE. THE CONTACT CRASHED INTO A DITCH. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED. THE CONTACT WAS NOT INJURED. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 68,000.
Service brakes, Feb 27, 2016
METAL BRAKE LINE UNDER TRUCK BURST . LOOKS LIKE IT RUSTED THROUGH. ALL OTHER LINES RUSTED ALSO. VEHICLE WAS PARKED IN DRIVEWAY.
Service brakes, Jan 25, 2016
DRIVING ON ICY ROAD ANTI LOCK BRAKES ACTIVATED AND BRAKE LINE RUPTURED, ADN WAS NOT ABLE TO STOP.
Service brakes, Dec 30, 2015
HARD METAL BRAKE LINE FAILURE DURING EMERGENCY, HIGH PEDAL PRESSURE, STOP. NO INJURIES. THE VEHICLE WAS UNABLE TO AVOID ENTERING AN INTERSECTION, AS THE LEAD CAR. BRAKING WAS FIRM, BEFORE PEDAL DESCENDED STEADILY TOWARD THE FLOOR. PUMPING PROVIDED SOME FRICTION, BUT WAS UNABLE TO RESTORE A MINORITY OF THE SYSTEM'S CAPACITY. THE FAILURE WAS A HOLE DEVELOPED IN THE LINE, ALONG ITS PATH TO THE PASSENGER FRONT BRAKE CALIPER. THE BRAKE LINES SHOWED ALARMING CORROSION LEVELS, WHICH WHILE POTENTIALLY UNDERSTANDABLE FOR A 13 YEAR OLD NORTHEAST OUTDOOR WINTER TRUCK, WAS A SYMPTOM OF CATASTROPHIC POTENTIAL. *JS
Service brakes, Dec 30, 2015
TL* THE CONTACT OWNS A 2003 CHEVROLET TAHOE. WHILE TOWING A 6000 POUND TRAILER AND DESCENDING DOWN A HILL AT APPROXIMATELY 20 MPH, THE VEHICLE SUDDENLY EXPERIENCED CATASTROPHIC BRAKE FAILURE. THE VEHICLE WOULD NOT STOP OR SLOW DOWN WHEN THE BRAKES WERE APPLIED. THE CONTACT WAS ABLE TO DRIVE INTO A FIELD TO EVENTUALLY STOP THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 60,000.
Service brakes, Oct 9, 2015
MY WIFE WAS DRIVING OUR 2003 CHEVY TAHOE TO THE DOCTOR'S OFFICE WITHOUT ANY WARNING BRAKES TOTALLY WENT OUT, GOD MUST HAVE BEEN WATCH OVER HER BECAUSE THIS COULD HAVE BEEN DEADLY, THANK GOD FOR EMERGENCY BRAKES. GM STATE THAT THE VEHICLE WILL STOP WHEN THE BRAKE LINE GIVE AWAY WILL THAT BULL [XXX]! THIS IS THE SECOND VEHICLE THAT WE HAVE HAD BRAKES LINE GO OUT ON FIRST MY 2002 CHEVY SILVERADO WITH 41000 MILES ON IT AND NOW OUR 2003 CHEVY TAHOE WITH APPROXIMATELY 90'000 BOTH WITHIN A WEEK OF ONE OTHER. ALSO MY STEPSON HAS A 2006 CHEVY SILVERADO THAT THE BRAKES WENT OUT ON TWO WEEKS AGO IS A HOSPITAL PARKING LOT THAT WAS ALMOST DEVASTATING. *TR INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Service brakes, Sep 7, 2015
FIRST INCIDENT OCCURRED 9/05/2014. SECOND INCIDENT OCCURRED 09/06/2015. FIRST INCIDENT BRAKE LINE WAS RUSTED AND FLUID POOLED UNDER TRUCK. BRAKE LINE BROKE IN DRIVEWAY. SECOND INCIDENT THE BRAKE LINE WAS RUSTED AND THE TRUCK WAS DRIVING 20MPH WITH CHILDREN IN THE CAR ON A BUSY STREET. THERE WERE NO BRAKES TO BE USED.
Service brakes, Aug 8, 2015
RUSTED BRAKE LINES RESULTING IN FAILURE OF BRAKING SYSTEM. BRAKE LINES SHOULD LAST LONGER THAN THE SERVICE LIFE OF THE VEHICLE. HENCE NO BRAKE LINES SHOULD EVER BE MADE OUT OF STEEL. ESPECIALLY ON ON A SYSTEM AS CRITICAL AS THE BRAKING SYSTEM. THIS FAILURE COULD HAVE COSTED ME MY FAMILY. THE THE ETHICAL THING FOR ANY COMPANY TO DO. IS RECTIFY THE PROBLEM. I REALLY DON'T UNDERSTAND WHY THIS WOULD BE AN ISSUE. WE ARE TALKING ABOUT THE BRAKING SYSTEM ON A VEHICLE THAT BY ITSELF WEIGHS 5,000 POUNDS. WITHOUT A TRAILER OR ANY PAYLOAD ATTACHED TO IT.MANY OF PEOPLE HAVE NOT BEEN AS FORTUNATE AS MYSELF. THE VEHICLE IS. OTHERWISE IN EXCELLENT CONDITION. TO THIS DAY.IF FAULTY IGNITION SWITCHES GET RECALLED IT'S COMMON SENSE TO RECALL A BRAKE ISSUE. ESPECIALLY SINCE THE BRAKES TOTALLY FAIL WITHOUT ANY WARNING. I HAVE BEEN BUILDING CARS SINCE I WAS A KID.AND THIS IS A FIRST. TO SEE A BRAKE LINE BURST. BECAUSE OF THE CORROSION. IF GM DOESN'T WANT TO RECALL THESE VEHICLES. THE AT LEAST LET THE OWNERS BUY THE PARTS AND GM INSTALL THEM. AND FOR GM TO STATE THAT THIS A NORMAL WEAR AND TEAR ISSUE. WHEN WAS THE LAST TIME ANYBODY THOUGHT TO CHECK FOR RUSTED OUT BRAKE LINES WHEN. THEY WERE CHANGING THE OIL OR DOING A TUNE UP .OR CHANGING BRAKE PADS OR TIRES. THOSE ARE NORMAL WEAR AND TEAR OWNER MAINTENANCE ISSUES. MY 2004 FORD F350 HAS 220 THOUSAND MILES. RUNS GREAT TO BUT THE BRAKE LINES AREN'T ROTTING OUT OF THE VEHICLE. WHAT GM IS CLAIMING IS A EXTREMELY WEAK ARGUMENT. THANKS FOR YOUR TIME.
Service brakes, Jun 12, 2015
BRAKE FAILURE CAUSED BY CORRODED BRAKE LINES. INCIDENT OCCURRED AT BOAT RAMP, COULD HAVE EASILY LOST TRUCK IN WATER. MASTER CYLINDER NEARLY EMPTY AND NO INDICATION OF ISSUE PRIOR TO FAILURE. THE TRUCK GIVES WARNING WITH LOW WASHER FLUID BUT NOT BRAKE FLUID? MECHANIC REPAIRING BROKEN LINES, BUT HOW SOON UNTIL ANOTHER HAS ISSUE?
Service brakes, May 30, 2015
BRAKE LINES RUSTED OUT AND LEAKED FLUID RESULTING IN BRAKE FAILURE
Service brakes, Apr 28, 2015
WAS BACKING UP TO PARK AND BRAKE LINE RUPTURED SENDING BRAKE PEDAL COMPLETELY TO THE FLOOR. I WAS ABLE TO SAFELY PARK THE CAR. WHEN I CHECKED ON IT LATER THERE WAS A PUDDLE OF BRAKE FLUID BY THE BACK DRIVER SIDE TIRE. UPON EXAMINING THE BRAKE LINES A VISIBLE RUPTURE COULD BE SEEN BEHIND THE BACK DRIVER SIDE TIRE. THE BRAKES LINES HAD COMPLETELY RUSTED OUT. THANK GOODNESS I WAS ALREADY GOING SLOW DON'T WANT TO IMAGINE IF I WAS ON THE HIGHWAY AND NEEDED TO STOP. *TR
Service brakes, Mar 2, 2015
STOPPED AT MAILBOX TO COLLECT MAIL. BRAKED, PUT VEHICLE IN PARK. STEPPED ON BRAKE PEDAL TO PLACE VEHICLE IN DRIVE, FELT 'POP' SENSATION IN THE PEDAL. BRAKE PEDAL WENT TO FLOOR. UPON VISUAL INSPECTION, AT LEAST ONE LINE HAS RUPTURED. *TR
Service brakes, Jan 27, 2015
1) 12/23/2014 - SITTING IN PHARMACY RX DRIVE-THRU WITH FOOT ON BRAKE. WITHOUT WARNING, BRAKE PEDAL WENT TO FLOOR. ASSESSED PROBLEM AND DETERMINED BRAKE LINE FEEDING REAR BRAKES BURST FROM CORROSION. FIXED BRAKE LINE NEXT DAY. 2) 1/27/2015 - IRONICALLY, SITTING IN FAST-FOOD DRIVE-THRU. EXACT SAME AS ABOVE OCCURRED. DETERMINED ALL 4 BRAKE LINES LEADING TO THE FRONT OF VEHICLE WERE SPLIT AND CORRODED CAUSING LOSS OF FLUID AND FULL BRAKING CAPABILITY. I WAS FORTUNATE (AND LUCKY) THAT I WAS AT A STAND STILL EACH TIME THIS HAPPENED. COULD HAVE BEEN CATASTROPHIC IF I HAD BEEN TRAVELING AT ANY SPEED. ESPECIALLY WITH THE SIZE AND WEIGHT OF THIS VEHICLE. *TR
Service brakes, Jan 14, 2015
THIS IS THE FIRST OF THREE (3) OCCASIONS THAT A METAL BRAKE LINE ON THIS VEHICLE HAS RUPTURED. THE RESULTS WERE AN IMMEDIATE AND COMPLETE BRAKE FAILURE. I HAVE TO LET THE VEHICLE COAST TO A STOP WHILE USING THE EMERGENCY BRAKE TO ASSIST. I LIVE IN A RURAL AREA SO IN ALL THREE TIMES I WAS VERY LUCKY THAT WERE LIGHT OR NO TRAFFIC. *TR