2015 Chevrolet Tahoe
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 662 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 Tahoe model years with reports.
Of the 2015 reports, 30 involved a crash and 2 involved a fire. 18 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Seat belts, frontApr 8, 2021
General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.
GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.
Campaign 21V245000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, wheel speed sensor/tone ringOct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Campaign 19V761000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuumSep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
Campaign 19V645000 on NHTSA.gov
Steering, electric power assist systemSep 7, 2018
General Motors LLC (GM) is recalling certain 2015 Chevrolet Silverado 1500, Tahoe and Suburban, GMC Sierra 1500 and Yukon, and Cadillac Escalade vehicles. Electric power steering (EPS) assist may be lost momentarily, followed by a sudden return of EPS assist.
If EPS assist is lost and then suddenly returns, the driver may have difficulty steering the vehicle, especially at low speeds, increasing the risk of a crash.
GM will notify owners, and dealers will update the EPS module software, free of charge. The recall began October 12, 2018. Owners may contact Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020 and GMC customer service at 1-800-462-8782. GM's number for this recall is 18289.
Campaign 18V586000 on NHTSA.gov
Seat belts, frontMay 3, 2018
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 1500 and Tahoe Police Pursuit and Special-Service vehicles. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
If the pretensioner cable becomes fatigued or breaks, the driver may not be properly restrained in the event of a crash, increasing their risk of injury.
GM will notify owners, and dealers will replace the pretensioner cable and seat side-shield, free of charge. The recall began June 19, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18156.
Campaign 18V291000 on NHTSA.gov
Air bags, frontalJul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Campaign 17V437000 on NHTSA.gov
Air bags, frontalSep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Campaign 16V651000 on NHTSA.gov
Electrical system, ignitionOct 9, 2015
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra trucks manufactured January 24, 2014, to February 26, 2014, 2015 Chevrolet Suburban vehicles manufactured February 12, 2014 and Chevrolet Tahoe vehicles manufactured February 6, 2014, to February 13, 2014. In the affected vehicles, the ignition lock actuator may bind, making turning the key difficult or causing the ignition to get stuck in the "Start" position.
If stuck in the "Start" position, the ignition may suddenly snap back into the "Accessory" position, causing a loss of engine, steering, and braking power, increasing the risk of a vehicle crash. If the vehicle is in a crash, the air bags may not deploy, increasing the risk of occupant injury.
GM will notify owners, and dealers will replace the ignition lock housing, free of charge. The recall began on November 20, 2015. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 15573.
Campaign 15V640000 on NHTSA.gov
Steering, electric power assist systemNov 10, 2014
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Silverado, Suburban, Tahoe, GMC Sierra, and Yukon XL vehicles, equipped with electric power steering (EPS). Due to a problem with the EPS module, the affected vehicles may experience a sudden loss of power steering assist during vehicle operation.
An unexpected loss of power steering increases the risk of a crash.
GM will notify owners, and dealers will replace the power steering assist motor kit, free of charge. The recall began on November 17, 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14743.
Campaign 14V719000 on NHTSA.gov
Air bags, side/windowJul 23, 2014
General Motors LLC (GM) is recalling certain model year 2015 Chevrolet Suburban, Suburban LTZ, Tahoe, Tahoe LTZ, GMC Yukon, and Yukon XL Denali vehicles manufactured on May 13, 2014. The affected vehicles were assembled with a roof rail air bags (RRAB) that were not reinforced at the points were the bags contact the hardware used to attach the roof carrier.
During deployment, the RRAB may be punctured or torn by the roof carrier hardware, reducing its performance and increasing the risk of occupant injury in the event of a crash.
GM will notify owners, and dealers will replace the roof carrier attaching hardware, free of charge. The recall is expected to begin in early September 2014. Owners may contact GM customer service at 1-800-222-1020 (Chevrolet) or 1-800-462-8782 (GMC). GM's number for this recall is 14359.
Campaign 14V451000 on NHTSA.gov
Power train, transfer case (4-wheel drive)Jun 27, 2014
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra vehicles, and model year 2015 GMC Yukon and Chevrolet Suburban and Tahoe vehicles. In the affected vehicles, an electrical signal short may cause the transfer case to shift to neutral without the driver's input.
If the transfer case switches to neutral while the vehicle is parked and the parking brake is not in use, the vehicle may roll away increasing the risk of injury to bystanders. If the transfer case switches to neutral while the vehicle is being driven, the vehicle would lose drive power, increasing the risk of a crash.
GM will notify owners, and dealers will re-program the software in the transfer case control module, free of charge. The recall began in early August 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14192.
Campaign 14V374000 on NHTSA.gov
Electrical system, softwareJun 6, 2014
General Motors LLC (GM) is recalling certain model year 2014-2015 Chevrolet Silverado and GMC Sierra, and 2015 Chevrolet Tahoe and Suburban vehicles equipped with a base radio and an internal amplifier. The radios in the affected vehicles may become inoperative, and as a result, there would be no audible chime to notify the driver if the door is opened with the key in the ignition or no audible seat belt warning indicating the seat belts were not buckled. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 114, "Theft Protection and Rollaway Prevention," and 208, "Occupant Crash Protection."
Without an audible indicator, the driver may not be aware that the driver's door is open while the key is in the ignition, increasing the risk of a vehicle rollaway. Additionally, there would be no reminder that the driver's or front seat passenger's seat belt is not buckled, which could increase the risk of injury in a crash.
GM will notify owners, and dealers will update the radio software, free of charge. The recall began on July 2, 2014. Chevrolet owners may contact GM's customer service at 1-800-222-1020. GMC owners may contact GM's customer service at 1-800-462-8782. GM's number for this recall is 14315.
Campaign 14V301000 on NHTSA.gov
Steering, linkages, tie rod assemblyDo not drive until repairedMay 14, 2014
General Motors LLC (GM) is recalling certain model year 2014 Chevrolet Silverado vehicles manufactured May 23, 2013, through March 25, 2014, 2014 GMC Sierra vehicles manufactured May 25, 2013, through March 31, 2014, and 2015 Chevrolet Tahoe vehicles manufactured January 29, 2014, through March 27, 2014. In the affected vehicles, the tie rod threaded attachment may not be properly tightened to the steering gear rack.
An improperly tightened tie rod attachment may allow the tie rod to separate from the steering rack, resulting in a loss of steering, increasing the risk of a vehicle crash.
GM notified all owners, and dealers will inspect the inner tie rods to make sure that they are correctly tightened, replacing the steering gear, as necessary, free of charge. The recall began on May 14, 2014. Owners may contact General Motors customer service at 1-800-222-1020 (Chevrolet), or 1-800-462-8782 (GMC). GM's number for this recall is 14204. NOTE: Owners are advised not to drive their vehicles until they have been inspected and repaired. Owners should contact GM to have their vehicles towed to the dealership.
Campaign 14V246000 on NHTSA.gov
Power train, automatic transmission, cooling unit and linesMar 31, 2014
General Motors LLC (GM ) is recalling certain model year 2014 Chevrolet Silverado Light Duty Regular Cab, Double Cab, and Crew Cab 1500 series and model year 2015 Suburban and Tahoe; GMC model year 2014 Sierra Regular Cab, Double Cab, and Crew Cab 1500 Series and model year 2015 Yukon and Yukon XL vehicles equipped with a 6-Speed Automatic Transmission (feature code MYC). The subject vehicles may have a transmission oil cooler line that is not securely seated in the fitting.
If the line is not securely seated and transmission oil leaks from the fitting, the oil could contact a hot surface and cause a vehicle fire.
GM will notify owners, and dealers will inspect the transmission oil cooler line connection and repair the vehicles, as needed, free of charge. The recall began on May 19, 2014. Owners may contact Chevrolet at 1-866-694-6546 or GMC owners may contact GMC at 1-866-996-9463. GM's number for this recall is 14121.
Campaign 14V152000 on NHTSA.gov
Representative owner complaints: fuel/propulsion system
52 reports, newest first. Show all
Fuel/propulsion system, Mar 19, 2026
The failure is believed to have originated in the fuel delivery system, specifically the check valve in the low-pressure fuel feed jumper line at the engine. This valve failed to seat properly, allowing high-pressure pulses to travel back into the low-pressure side of the system. This malfunction caused the S-shaped portion of the fuel feed line near the tank to vibrate excessively against its mounting clip. This constant friction wore through the line, resulting in an active fuel leak. All damaged components remain on the vehicle and are available for inspection upon request. The safety of the driver, passengers, and the public is at immediate risk due to a severe fire hazard. Because the leak is located near the fuel tank and undercarriage, gasoline is being released where it could be ignited by road sparks, static electricity, or exhaust heat. A fuel leak of this nature threatens a catastrophic fire that could result in vehicle loss or personal injury. The problem has been confirmed via a physical inspection that matches the symptoms documented in a GM Service Bulletin (Recall - High Pressure Fuel Pump Leakage). While the vehicle has not yet been subjected to a formal tear-down by a dealer due to the danger of driving it with a leak, the visual evidence at the exact location specified in manufacturer documentation confirms the failure. To date, the vehicle has not been inspected by the manufacturer, police, or insurance representatives. Prior to the leak, the primary symptoms were an audible rattling and ticking noise from the engine bay and underside, characteristic of the pressure pulses described in the TSB. There were no warning lamps or dashboard messages, as the mechanical wear on the exterior of the fuel line occurred outside the scope of the vehicle’s onboard diagnostic sensors.
Fuel/propulsion system, Dec 26, 2025
Vehicle cranked longer than usual, noticed slight smell of fuel. After arriving home noticed fuel smell was very strong and a puddle of raw fuel under vehicle. Fuel line appears to have rubbed/vibrated against the frame of the vehicle causing the line to rupture. Date of incident 12-26-2025. No MIL or warning messages were present. The vehicle has not been inspected by anyone other than myself for this incident. I feel this issue could have resulted in serious injury or death of my entire family and possibly others on the road. The vehicle has not been modified in anyway and is in OEM configuration. We will have to have the vehicle repaired but will document as best we can. I would like to add that after a quick internet search I found this to be a common issue so I was amazed there was no recall on our Tahoe. Thank you.
Fuel/propulsion system, Aug 6, 2025
I am leaking fuel from the fuel lines connected to the fuel tank. I can smell the fumes inside of the cab. I also can see the fuel leaking under the driver seat.
Fuel/propulsion system, Jul 12, 2025
Fuel line leak. After researching it appears there was a safety recall for this in the 2015 Chevy Tahoe.
Fuel/propulsion system, Apr 30, 2025
I’ve had to have the fuel line replaced 3 times because of fuel leaks.
Power train, Engine, Fuel/propulsion system, Feb 22, 2025
While driving multiple times the vehicle has completely lost power or almost died in the middle of the roadway. It has been taken to the dealership multiple times and they are reporting transmission and catalytic converter issues, however these issues were present at 20,000 miles and taken back to the dealership to be fixed. This is now a reoccurrence of issue and the dealership refused to warranty or fix the reoccurring issue. Loss of power while driving and random acceleration have occurred and almost caused accidents on multiple occasions
Power train, Vehicle speed control, Fuel/propulsion system, Sep 13, 2024
Recently I've noticed that when I try to accelerate or take off from stop it does not pick up speed as use to. My engine rpms rise but speed is getting less and less. I've also noticed my transmission temperature is staying between 190-200 degrees which gm has already had recalls over pertaining to this style transmission having issues due to high heat. Vehicle has always had maintenance kept up with and never abused. Have taken to local shop since warranty ran out several times for inspection of transmission well my complaints in regards and have fluid done. Recently I've noticed fluid is needing to be replaced more frequently due to losing viscosity from overheating and being burnt, has the familiar and similar smell of toast being burnt. This is a 2016 Tahoe ltz w just over 200k, yes in some ways a lot but considering the cost of vehicle new/age/synthetic fluids and everything it seems to me the transmission should last longer especially considering it's been maintained. These new vehicles are outrageous and the transmissions are very expensive as well, considering these same transmissions have had recalls from GM I'm a little aggravated and frustrated on how some can and can't. I'm familiar and aware they say it's per manufacturing plant and particular models but confused as to how if the transmission that has had recalls for overheating doesn't comply to all the transmissions that are same type, I think it's bogus n a way not to be responsible for accepting failures n having to replace all parts so gm says it only happened here n with these parts. I guarantee you if someone would take a look at gm shipping and papers they would see it. If a 2016 4l60e had problems it's more than likely all of them in that year had all same parts so therefore all acceptable to failure, its not like transmission maker chose different parts to send to different plants or this get that no thats just b.s. so there not responsible for all of them so they pick plant with most failures
Fuel/propulsion system, Jul 15, 2024
The high pressure fuel pump may leak resulting in fuel odor and increased evaporative emissions. The engine may also fail to start or provide less power when driven due to insufficient fuel pressure. Recall came out on February 2015 Bulletin No.: 14858 Part Number: 12626354 Description Intake Manifold Gasket 12618337 Intermediate Fuel Feed Pipe 8/V8 Engine 12625817 Fuel Pump SERVICE PROCEDURE
Fuel/propulsion system, Mar 6, 2024
Fuel line has a hole in it from rubbing against the frame this is the 2nd time I've had to repair the fuel line in the 3.5 years I've had the vehicle
Engine, Fuel/propulsion system, Dec 16, 2023
I was constantly smelling a strong odor of gas coming from the inside/outside of my 2015 Chevy Tahoe. When I purchased the vehicle in 10/23 everything appeared fine. I researched the internet to determine what the problem could be & found dozens of similar situations. People saying the fuel line rubs the undercarriage of the vehicle causing a pin hole size in the fuel line causing it to leak gas. Currently my vehicle is in the shop and the problem is TBD.
Fuel/propulsion system, Oct 6, 2023
The high pressure fuel line from the fuel pump to engine sustained a pinhole leak over the fuel tank. Fuel leaked over top of tank and ran down front drivers side front of tank. Discovered the leak after noticing strong fuel odor inside vehicle. Took to shop. The fuel line is installed as so it will rub undercarriage of vehicle. This is what happened to mine. This is a factory install and the lines are doomed to fail because of this. The excessive contact rubs holes into the lines. This seems to be a common problem with the 2015, according to my research. There are hundreds of these same complaints with this year listed all over repair sites on the internet. I believe this needs looked into, as flammable fuel leaking suddenly can be a hazard.
Fuel/propulsion system, Sep 7, 2023
Gas leaking out of my vehicle. First noticed it right after pumping gas then started smelling a strong odor of gasoline!
Fuel/propulsion system, Jul 26, 2023
STARTED SMELLING GAS FUMES. NOTICES GAS DRIPPING FROM UNDER VEHICLE LEAVING PUDDLE UNDER VEHICLE DRIVERS SIDE. SAFETY DUE TO GAS LEAK UNDER VEHICLE. BROUGHT TO BALISE CHEVROLET SPRINGFIELED MASSACHUSETTS. LEAK CONFIRMED FROM TOP OF TANK. REMOVED FUEL TANK AND FOUND THAT THE FEEDING HOSE HAS A HOLE DUE TO IT RUBBING ON THE TANK RECOMMENDED REPLACING FUEL SENDING UNIT, RING AND HOSES DUE TO MILEAGE. WHICH IS ONLY 114088. FUEL PUMP, MODULE UNIT RING, 2 HOSES REPLACED. THERE WERE NO WARNING LAMPS, MESSAGESOR OTHER SYMPTOMS PRIOR TO FAILIURE.
Fuel/propulsion system, Jul 11, 2023
The fuel tank is leaking from the top of the tank.
Fuel/propulsion system, May 26, 2023
Leaking fuel from the in-line on top of gas tank. Very dangerous and alarming that this is a known issue and you choose to set back doing nothing. It’s the same exact problem that everyone is talking about so it’s be nice to be reimbursed for the parts or repair or something
Fuel/propulsion system, Apr 25, 2023
2015chevy Tahoe LT fuel pump rattle cause fuel line to rattle. Service Bulletin Bulletin No.: 17-NA-304 Date: February, 2020 Subject: Brand: Cadillac Chevrolet TECHNICAL Ticking, Rattle and/or Buzzing Noise Heard from inside Passenger Compartment, Possible Fuel Leak Model: Escalade Escalade ESV Model Year: from VIN: Engine: L86 L86 L83 L83 L83, L86 L83, L86 Transmission: to from to Suburban Tahoe 2015 Yukon Models Yukon XL Models 2020 GMC Involved Region or Country North America, Middle East, Europe, Russia, Chile, Columbia, Ecuador and Peru. Condition 1 Some customers may comment on the following condition: • Arattlingand/ortickingnoisethatmaybelouderinsidethevehiclethanoutside. ⇒ The noise may be picked up at the back of the left valve cover, and/or underneath the vehicle near middle of the driver’s door. ⇒ This noise will be noticeable at idle, most noticeable in the 700-900 RPM range. ⇒ The noise may also sound like a lifter tick. ⇒ This may also be called a fuel line buzz or ringing noise. • Whiletherattleisoccurring,theS-shapeportionofthefuelfeedline,rightinfrontof the tank, will be vibrating / rattling. Condition 2 Some customers may comment on a fuel leak. Diagnosis that the fuel leak is originating from the fuel feed line at the molded-in clip on top of tank. Cause The rattling, ticking noise may be caused by the check valve in the low pressure fuel feed jumper line at the engine not fully seating, allowing pressure pulses from the high pressure side back into the low pressure side of the fuel system. These pressure pulses could cause the S-shaped portion of the fuel feed line, in front of the tank, to vibrate and/or rattle If the S-shaped portion of the fuel line rattles over a period of time, the fore-aft motion in the line could result in wear. This wear could result in a fuel leak where the line is secured into the molded-in clip on the tank.
Fuel/propulsion system, Mar 23, 2023
I bought the vehicle from Dan Cummins dealership and a few months later started to smell gasoline got it checked vehicle replaced the gas line it was leaking
Fuel/propulsion system, Jan 23, 2023
The fuel feed hose that tracked on top of the gas tank rubs against a portion of the tank and a pinhole sized hole gets created. Anytime the vehicle is on or fuel pump pressurizes the line, fuel is sprayed all beneath the vehicle. Gm has made a “fix” to the line by adding a shroud to the updated part. Part number 84200271 is the updated part. I contacted Martin Chevrolet in crystal lake Illinois and was advised since my vehicle was out of warranty nothing was covered. Spraying fuel due to bad engeeniering is as unsafe as it gets.
Fuel/propulsion system, Dec 30, 2022
Came home and could smell gas. Had just filled up so ignored it. Next day, just pulling into driveway, husband could see gas pouring out the bottom below the drivers seat area.. fuel line split. Had to have it towed to dealership and paid nearly a grand to get that repaired. Warranty wouldn’t cover it..
Fuel/propulsion system, Dec 18, 2022
Safety Hazard. Fuel feed line is leaking from top of gas tank and running down beside tank, which can lead to vehicle fire or explosion.
Fuel/propulsion system, Nov 8, 2022
Gas leak at line due to rubbing-FIRE HAZARD
Fuel/propulsion system, Oct 19, 2022
Fuel line at tip of gas tank is leaking. I see dozens of complaints online for others who say gas line to close to chassis, plastic and rubbing and causing a leak. I see some caused fires?
Fuel/propulsion system, Aug 23, 2022
Starting on August 13, 2022, my 2015 Chevrolet Tahoe exhibited a harder than normal start condition prior to a drive of approximately 80 miles home from visiting a relative. The car drove normally on that trip. After that return home I parked the subject vehicle in the garage and emptied it of my belongings. I noticed a fairly strong gasoline smell and inquired with my wife if perhaps she had re-fueled our other vehicle and experienced any over fill. Shed said no, so I left the garage open to see if it would air out of the fuel smell. It did through the course of the afternoon so I closed the garage that evening. The next morning (August 14, 2022) we had an event to get to in the morning and were planning to take the subject vehicle. The vehicle again had a hard start issue and within 10 seconds of starting I could smell fuel while inside the vehicle with the windows up. I immediately stopped the ignition and looking under the subject vehicle. I saw gas flowing down the side of the fuel tank from above and dripping on the floor at a rapids rate of 2-3 drops per second. This continued for about 5-10 minutes gradually slowing down since the the ignition had been shut off and as the fuel pressure in the system was reduced. By the end there was a puddle of fuel about 1 ft in diameter on my garage floor under the vehicle. From that point and after any strong gasoline vapor smell had subsided, I decided the vehicle needed to be moved from the garage and parked on the street. I parked it on the street and decided I would take it to Marty Feldman Chevrolet immediately early in the morning of August 15, 2022, while roads were less busy. There was no warning light or indication prior to the leak. In some quick research, I found several concerns related to fuel line abrasion and fuel pump leaks/failures. Marty Feldman Chevrolet diagnosis/repair costs are documented in this complaint. Components are available for inspection.
Fuel/propulsion system, Aug 6, 2022
Fuel supply line coming out of gas tank is leaking. Looked up on internet and found this to be a very common occurrence, with several pictures of Tahoe's sitting on the side of the road on fire. This is such a common issue on 2015 models that GM should recall and fix. We can't wait for a recall, I know that takes a lot of time. The Tahoe is my wife's ability to get to work and home, as she is the breadwinner in our family, I am on SSDI for total disability. We need someone or some organization to step up and assist us in getting this problem fixed and since it is a design flaw resulting in a serious safety issue, GM should be held responsible for the repair. Local mechanic found the problem after wife smelled strong odor of gasoline in garage where vehicle is parked, which happens to be directly below our bedroom, thus if a fire started in garage, with my health and mobility problems, we might not be able to escape. This is a serious problem, common with this model and I'm sure you've heard about it several times, please help us.
Fuel/propulsion system, Jul 25, 2022
Fuel smell outside of the vehicle. About 3 months ago one part was replaced. Now the smell is back. Vehicle is at the mechanic so they can investigate further.