2016 Chevrolet Tahoe
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 257 owner complaints filed for this model year. This is the 14th highest complaint count among 26 Tahoe model years with reports.
Of the 2016 reports, 17 involved a crash and 1 involved a fire. 13 people were injured.
What owners report most often
Recalls and investigations
Power train, transfer case (4-wheel drive)Do not drive until repairedMay 7, 2026
General Motors, LLC (GM) is recalling certain 2026 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, and GMC Sierra 1500, Yukon, and Yukon XL vehicles with four-wheel (4WD) or all-wheel drive (AWD), and certain 2015-2020 Suburban, Escalade, Escalade ESV, Yukon, Yukon XL, and Tahoe vehicles. A component missing from the drivetrain transfer case may cause the front and/or rear wheels to lock up without warning to the driver.
Front or rear wheel lockup increases the risk of a crash.
Owners are advised not to drive their vehicle until the remedy is completed. Dealers will inspect and, if necessary, replace the transfer case assembly, free of charge. Owner notification letters were mailed May 18, 2026. Owners may contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020 or Cadillac customer service at 1-800-333-4223. GM's number for this recall is N262557620. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 7, 2026.
Campaign 26V289000 on NHTSA.gov
Seat belts, frontApr 8, 2021
General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.
GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.
Campaign 21V245000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, wheel speed sensor/tone ringOct 24, 2019
General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.
Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.
GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.
Campaign 19V761000 on NHTSA.gov
Service brakes, hydraulic, power assist, vacuumSep 6, 2019
General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.
As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.
GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.
Campaign 19V645000 on NHTSA.gov
Seat belts, frontMay 3, 2018
General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 1500 and Tahoe Police Pursuit and Special-Service vehicles. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.
If the pretensioner cable becomes fatigued or breaks, the driver may not be properly restrained in the event of a crash, increasing their risk of injury.
GM will notify owners, and dealers will replace the pretensioner cable and seat side-shield, free of charge. The recall began June 19, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18156.
Campaign 18V291000 on NHTSA.gov
Air bags, frontalJul 10, 2017
General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.
Campaign 17V437000 on NHTSA.gov
Air bags, frontalSep 8, 2016
General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.
A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.
GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.
Campaign 16V651000 on NHTSA.gov
Suspension, front, control armDo not drive until repairedApr 28, 2016
General Motors LLC (GM) is recalling certain model year 2016-2017 Chevrolet Silverado 1500 and 2016 Cadillac Escalade, Cadillac Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Sierra, GMC Yukon and GMC Yukon XL vehicles. The front upper control arms may have inadequate welds near the control arm bushing.
Inadequate welds may allow the control arm to separate from the bushing, compromising steering and increasing the risk of a crash.
GM will notify owners, and dealers will replace the left and right front upper control arms and realign the vehicle, free of charge. The recall began on May 18, 2016. Until the repairs have been made, owners are advised not to drive their vehicles. Owners may contact Chevrolet customer service at 1-800-222-1020, Cadillac customer service at 1-800-458-8006, or GMC customer service at 1-800-462-8782. GM's number for this recall is 42190.
Campaign 16V256000 on NHTSA.gov
Representative owner complaints
257 reports, newest first.
Chest clip, Buckle, Harness, Apr 14, 2025
Summary: The straps on this car seat came loose with a firm pull with my baby already buckled in. Description: On Saturday April 5th, we place our baby in the Britax One4Life ClickTight All-In-One Car Seat. My husband had our baby fully buckled in with the straps tightened when for some reason (thank goodness he did), he gave the straps a pretty firm pull (not holding the strap release lever down) and they loosened up. We were very shocked that this could happen. I also tested it as well and had the same result. This concerning because with a forceful pull on the car seat straps, they came loose. If we had been in some sort of collision and were unaware of this issue, the force of an accident certainly would have loosened the straps which could have had a lethal outcome ever for a minor collision. Because we weren't sure why this was happening with this car seat. We ordered a new car seat from a different manufacturer due to this safety concern. On Monday April 7th I called Britax twice to see if I could get an answer as to why this may be happening. I could not get a live person so I left a voicemail. I also scheduled an appointment for a video call on Wednesday the 9th in an attempt to contact someone. I was able to speak with someone on Wednesday the 9th. The person I spoke with asked me to check if there was any debris under the button to release the strap. with her on the call, I shook the car seat upside down, and vacuumed under the release button. Once that was done, the straps did function again as expected, not loosening with a firm pull. The representative did mention that she had seen this issue before with something even as minor as sand getting stuck under the button. If you have kids, you know how impossible it is to keep car seats completely clean. The seats get dirty from kids being at parks, daycare, in their own back yard, eating snacks, etc.. I believe this is a design flaw of this car seat and it needs to be investigated for safety.
Other or unspecified, Service brakes, Forward collision avoidance, Apr 1, 2025
-MALFUNCTION---WHILE DRIVING, WHEN I PRESS THE BRAKES TO COME TO A STOP, IT SEEMS AS IF THE BRAKES CATCH BUT THEN RELEASES AND THEN CATCHES AGAIN. AS IT RELEASES, IT CONTINUES TO ROLL. VEHICLE IS AVAILABE UPON REQUEST. -SAFETY RISK--- BECAUSE THE BRAKE RELEASES AND/OR EVENTUALLY NOT CATCH AT ALL, THIS IS UNSAFE BECAUSE I CAN ROLL INTO TRAFFIC -REPRODUCED AND/OR CONFIRMED--- I HAVE BROUGHT MY VEHICLE TO A SERVICE CENTER TO REPAIR A RECALL AND WAS TOLD TO THAT THE ISSUE SHOULD BE RESOLVED ONCE THE RECALL WAS COMPLETE. THE ISSUE WAS TEMPORARILY RESOLVED FOR APPROXIMATELY ONE MONTH OR SO, AND NOW IT IS BACK TO BREAKING AND RELEASING. -ONE CAN ONLY ASSUME THAT THE VEHICLE AND/OR ITS COMPONENTS HAVE BEEN INSPECTED GIVEN THAT I BROUGHT THE VEHICLE TO THE SERVICE CENTER, STATED THE ISSUE, AND WAS TOLD THAT THE ISSUE SHOULD BE RESOLVED AFTER IT HAS BEEN SERVICED. -THERE WERE NO WARNING LAMPS, MESSAGES, OR OTHER SYMPTOMS OF THE PROBLEM PRIOR TO THIS ISSUE.
Service brakes, Feb 25, 2025
Brake vacuum pump
Fuel/propulsion system, Jan 31, 2025
Fuel pump went bad and needed to be replaced.
Engine, Jan 31, 2025
Lifters were stuck and ruined the cam shaft. All lifters and cam shaft replaced
Power train, Jan 31, 2025
Transmission fell to metal shavings being found in the pan and oil filter when checked
Power train, Engine, Electrical system, Jan 29, 2025
The contact owns a 2016 Chevrolet Tahoe. The contact stated that while driving approximately 50-55 MPH, the vehicle started to shudder. The contact stated that the odometer was moving erratically. The contact stated that the engine overheated quickly. There were no warning lights illuminated. The contact was stranded on the side of the road. The vehicle was towed to the local dealer, where it was diagnosed that the torque converter was faulty and there were metal shavings inside the engine. The vehicle was repaired, but the failure recurred. While driving at 35-45 MPH, the vehicle was shuddering and overheated. The vehicle was towed back to the local dealer, where it was diagnosed that the engine needed to be replaced. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 112,000.
Power train, Jan 24, 2025
The contact owns a 2016 Chevrolet Tahoe. The contact stated while driving 70 MPH, the vehicle hesitated upon depression of the accelerator pedal. There was no warning light illuminated. The contact stated that the vehicle downshifted to first gear and the failure persisted. The contact shifted to neutral(N) and coasted to the nearest dealer. A diagnostic test was performed by the dealer, and it was discovered that the clutch plates were damaged. The vehicle was diagnosed with transmission failure and the contact was provided an estimate for the repair. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was 110,481.
Power train, Service brakes, Dec 11, 2024
I bought my Tahoe from Dan Vaden Chevrolet in Savannah, GA with approx 58k miles. At around 88k miles I noticed the transmission hesitated when putting into reverse or drive from the park position. I had my transmission fluid changed at 70k and 100k miles. Now, at 112k miles, it has significantly gotten worse with shuddering between gears 1-3 and jerking when in reverse. Major hesitation when accelerating at any speed and high pitched whining noises that randomly happen, even after putting it in park and turning it off. Also, my ABS and Stabilitrak lights will illuminate and then go off every few days. As well as another random icon that randomly comes and goes. This Tahoe is now unsafe to drive but it’s the only transportation I have. I already missed a radiator replacement recall by 1,500 miles and had to pay for that out of pocket. Now Chevrolet isn’t recalling this transmission when it has over 190 complaints on this website alone, and thousands of others on other online forums. What will it take for the manufacturer to do the right thing? Will someone have to die in order for this to become an issue they stop ignoring? We have all spent money we worked hard to earn and deserve a vehicle that’s safe for our families.
Forward collision avoidance, Lane departure, Dec 11, 2024
When driving the dash panel all arrows go to zero, disconnects cruise and just about everything else on your list above. We have had it to the dealer many times over three months and I am concerned that when the system drops out my safety devices that it says check will not work if I’m in a collision.The list is to long to list. Our local Chevrolet dealer is George Nahas in the Villages Florida. Please help
Steering, Electrical system, Service brakes, Dec 3, 2024
Driving down the freeway at 75 mph and the headlight started flickering any time I would use my blinker. 5 minutes later the car automatically breaks hard all by itself along with the dash lights going off and the doors locking and unlocking. 3 days later driving in town taking a hard left suddenly I get alerts on the dashboard saying, "parking assist off" and "stabilitrak" then suddenly my steering wheel JERKS VIOLENTLY all the way to the right. This happened 2x when I am driving!!! It is available for inspection upon request. If this steering wheel malfunction happens to someone driving down an interstate someone could die. It just happened yesterday so I have not gotten it in to be looked at yet. There was zero warning it all happens suddenly and out of nowhere.
Electrical system, Nov 29, 2024
The stabilitrak light comes on and the whole vehicle shuts off, this happens while driving and turning, the entire vehicle loses power. I have had it inspected at the dealer, they said it’s normal. This is a continuous problem. When it shuts off I have no stealing breaks or anything. This put my life, my children’s life and fellow travelers lives at risk. Something is wrong with this yrs vehicle and I don’t know what it is.
Suspension, Power train, Nov 13, 2024
Transmission down shifts into gears,causing vehicle to stall out in traffic
Other or unspecified, Service brakes, Oct 18, 2024
The brake vacuum pump is bad. It was hooked up to solious and that's the codes it's throwing. Out of no where while driving on the highway my brake pedal became very stiff and difficult to push down. I could barely stop in time off the exit. Now when the truck is in Drive it doesn't even move. When you do go u have to put all your might into pressing the brake down to stop. Even then the pedal won't go down. Very dangerous especially since I had my [XXX] daughter with me. Very scary situation. I looked up recall for VIN but I have 0. Which is weird because there's a recall on 2016 chevy tahoes for this exact symptoms and part. Now I did go to [XXX] and found a recall under my Vin and also a warranty for this part under my Vin. Why doesn't it list a recall for me INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Other or unspecified, Oct 16, 2024
The touch screen glitches. While traveling depending on maps I can't safely drive and follow the screen.
Electrical system, Oct 15, 2024
Several months back I took my car in to my local dealer for a recall and asked them about what was going in with my navigation and radio because when I'm driving the navigation system will deter from my destination that I put in and then start flipping through radio stations on its own and will not let me change or control it at all.
Forward collision avoidance, Oct 15, 2024
I have had several incidents this past couple months where my forward collision red light indicator will go off for no reason while driving. This literally scares me to brake when I shouldn't have to. Very annoying.
Air bags, Oct 15, 2024
Most the time my passenger airbag will not detect someone sitting there. However, when it does, it will shut off and on.
Service brakes, Oct 7, 2024
I called my local Chevrolet dealership to get the recalled on my Tahoe fixed and they can’t fix the recall for a full month. I’m very concerned because it’s a recall on the vacuum pump so it affects my brakes. My truck is a daily driver so I will have to gamble for a month on the streets and pray the brakes don’t get any worse.
Steering, Electrical system, Engine, Sep 25, 2024
On 4 plus occasions, the steering wheel would lock up, I would get warnings that the stabilitrak, the park assist was disabled. The engine shut off. This happens during driving.
Power train, Sep 17, 2024
I was driving to drop 3 out of my 4 children off at school when the transmission failed and started slipping and completely died in the middle of the road. The road is an extremely busy highway in our town. I turned the car off and back on and it went into forward gear just enough for me to get onto the shoulder. My children and myself were put into danger due to the transmission failing on a busy highway. I have had the car inspected by a mechanic. There is metal shavings all in the bottom of the transmission pan. There were no signs, and no warning lamps on the dash.
Service brakes, Sep 10, 2024
Increased breaking effort, vehicle didn’t and currently doesn’t allow me to stop as quickly as needed Aligns with recall number: 19V645000
Service brakes, Hydraulic, Service brakes, Air, Electronic stability control (ESC), Aug 22, 2024
The contact owns a 2016 Chevrolet Tahoe. The contact stated that while operating the vehicle, the stabili-trak, ABS and traction control warning lights remained illuminated, and the vehicle would not immediately stop while depressing the brake pedal. The vehicle was taken to an independent mechanic who diagnosed the vehicle and determined that the ABS module and ABS pump were faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were not notified of the failure. The failure mileage was 150,000.
Fuel/propulsion system, Jul 3, 2024
While driving up a hill on a road trip the vehicle felt as if it wouldn't speed up when pressing on the accelerator- this was short lived. Upon parking in the driveway after the trip my husband noticed a fuel smell coming from the rear driver side of vehicle. The next day it was difficult to start and fuel smell was even more pronounced. As it was the weekend we did not drive it and waited to contact the dealer on Monday. Drove the vehicle to the dealership to have the smell diagnosed and while the engine was running and vehicle was in park, fuel began pouring out underneath. There were NO warning lights whatsoever. Fortunately our granddaughter had just been taken back to her parents as she had previously been in the vehicle! This could have caught fire!!! The vehicle is currently at the dealership and a leak in the fuel line has been diagnosed and is scheduled for repair as soon as the part comes in.
Electrical system, May 30, 2024
There’s a modulator in the rear end of my SUV that has been melting near exhaust every since purchased had taken to the dealership it was purchased from and also back to a Chevrolet dealership. At the time my warranty was still on vehicle at both places was told I will have to cover cost. This issue is very defective afraid of a fire being caused. I have small children and this matter needs to be addressed as soon as possible. The dealership states to just tuck it in keep a way from exhaust pipe which is dangerous and impossible to keep away when driving.