2023 Chevrolet Tahoe
Problems, recalls and owner-reported issues
Engine is the leading concern among 222 owner complaints filed for this model year. This is the 16th highest complaint count among 26 Tahoe model years with reports.
Of the 2023 reports, 3 involved a crash. 1 person was injured.
What owners report most often
Recalls and investigations
Fuel system, diesel, storage, tank assemblySep 18, 2025
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.
A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.
Campaign 25V619000 on NHTSA.gov
Engine and engine cooling, engine, hard parts internal/mechanicalApr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Engine failure increases the risk of a crash.
Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Campaign 25V274000 on NHTSA.gov
Service brakes, hydraulic, brake fluid low warning, lampSep 12, 2024
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Campaign 24V674000 on NHTSA.gov
Suspension, rearSep 20, 2023
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
Campaign 23V642000 on NHTSA.gov
Exterior lighting, lighting control module, softwareDec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Campaign 22V903000 on NHTSA.gov
Representative owner complaints: engine
137 reports, newest first. Show all
Engine, May 22, 2025
Feels like the transmission is slipping. When I step on the gas it makes a jerking/ tugging motion like its pulling backwards and feels as though it has no power. It’s gotten progressively worse now over 10k miles and I should not have any engine problems with a new car. This happens every time I drive it. The problem is not fixing itself it’s getting worse by the day.
Engine, May 20, 2025
Engine performance issues, engine hesitation, abnormal shifting, and reduced propulsion. Interior dash and radio illumination goes black. Blinkers fail to work; no sound comes from the radio and speakers. Mirrors fail to tuck after command given to do so.
Engine and engine cooling, May 6, 2025
The contact owns a 2023 Chevrolet Tahoe. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and referred the contact to the NHTSA Hotline. The contact had not experienced a failure. VIN tool confirms parts not available.
Engine, May 5, 2025
I was driving on Highway and system said engine oil hot. 10 seconds later the engine stopped. Could not get it restarted as I moved over to the shoulder. Had vehicle towed and engine was seized. 28,000 miles on vehicle.
Engine and engine cooling, May 5, 2025
The contact owns a 2023 Chevrolet Tahoe. The contact received notification of NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); however, the part to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that while driving at various speeds, the vehicle suddenly decelerated and briefly lost automotive power, before the vehicle regained normal functionality, with the check engine warning light illuminated. The vehicle was not repaired. The manufacturer was made aware of the issue. The approximate failure mileage was 60,000. VIN tool confirms parts not available.
Engine and engine cooling, May 2, 2025
The contact owns a 2023 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, there was an abnormal tapping sound coming from the engine compartment, which became extremely loud while accelerating. Upon arriving at the intended destination, the vehicle stalled and was unable to restart. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the crankshaft, resulting in damage to the engine. The contact was informed that the engine needed to be replaced. The contact also stated that a similar failure occurred in July 2024, and the engine was replaced. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); the VIN was included, but parts were not yet available. The manufacturer was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 23,000.
Power train, Electrical system, Engine, Apr 30, 2025
I filled my car up with gas and turned it on and it started shaking. Several warnings popped up on the dashboard screen including, Service ESC, Service traction control, And forward collision system unavailable. My cruise control was disabled I had to hold my foot at an angle to keep the speed at 45-50 mph, Causing it to take 10 hours for me to get home from Austin to Dallas. The check engine light was on the entire time and flashed for the last hour to hour and a half. I was unable to pull over at that time because it was dark And I was in the middle of nowhere by myself. The next day I turned my car on.The only thing on was the check engine light, Is , however , around 1 pm that day it Started doing the same thing. I drove it from My patient's house in allen To galleria chevrolet in Dallas. They told me my battery was too low to run diagnostics and I needed to replace it. So I bought a battery and brought it to them. They replaced the Next morning And told me there were no codes showing up so There was nothing wrong with my car and it was a fluke. Exactly one week later the same thing happened to my car. I called the dealership and they Hao it toewd to the service dept. After I repeatedly called them to check on the status of my car, they told me it was the fuel injector #1. They then were able to apply for a loaner car for me as I am a hospice nurse. These are same exact issues that the GM 6.2 L engines are having with the recall they just announced. I have a 5.3 L engine. I am afraid to put my kids in my car. Please help get GM to take responsibility for this!
Engine, Apr 25, 2025
First was engine shutoff while driving up a windy highway. No warning just shutoff. Second time was catastrophic engine failure. Was told by dealership lower end issue and will require entire motor replacement.
Engine, Apr 21, 2025
The contact owns a 2023 Chevrolet Tahoe. The contact stated while driving at approximately 45 MPH, there was an abnormal sound coming from the engine compartment before the vehicle stalled. The contact stated that the check engine warning light was illuminated. The vehicle was towed to a dealer to be diagnosed. The vehicle was not yet diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 31,000.
Engine, Apr 20, 2025
2023 Tahoe with 6.2L gas engine at 29k miles suffered a complete engine failure on a major road at 60mph with no prior warning. We were lucky to be able to get it out of the road safely but it stranded my family. It’s currently at GM dealer waiting for an engine replacement.
Power train, Engine, Apr 14, 2025
Engine replacement at 13,260 miles due to thrown rods in cylinders 7 and 8 in September 2023. The vehicle is currently at the dealership again at 32,000 miles due to transmission issues. No ETA on replacement parts. Up to date on all maintenance and oil changes.
Power train, Engine, Apr 10, 2025
The contact owns a 2023 Chevrolet Tahoe. The contact stated while driving 25 MPH, the transmission unexpectedly downshifted with the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that the transmission valve body had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 30,000.
Engine, Apr 9, 2025
We were driving on the highways, we had to break and the car shut off, we barely made it to the side of the road and the car would not turn over, start, or go in to neutral, which was very unsafe. Had to have it drug on the tow truck since it wouldn’t go to neutral and at the dealer it had 17 codes. The engine seized and they are having to order a new engine.
Electrical system, Engine, Apr 8, 2025
While driving on the highway at high speed, my vehicle suddenly shut down and went into neutral. After a few minutes of trying to start it, it started and I was able to drive it home. The following day, on my way to the dealership for an inspection, while driving on a busy street, it shut down again. This time, it wouldn't restart, and I had to call the police and a tow truck to have it towed to the dealership. I was freaking out as I had my daughter inside the car with me. At that point, the vehicle had around 26,000 miles. The dealership inspected it and determined the engine was faulty and needed to be replaced. After the engine was replaced, the vehicle seemed fine, but recently, I've been experiencing problems again. The car struggles to start when it shuts off during stops, using the auto shut-off feature, and there's an intermittent hard shifting issue. It feels like the engine is failing again or maybe the transmission, but I've been told that unless the dealership can replicate the issue when I bring it in, they can't do anything. I'm concerned about being stranded on the road again, especially since my daughter is always with me. The vehicle’s engine and mechanical components don’t seem reliable, and I no longer feel safe driving it. However, I have no other option as it is my daily car for work and everything else. I’ve asked for an extended warranty from the dealership after the engine replacement, but I was told GMC doesn’t offer one for this issue. I’ve seen others on social media report similar problems, and I want to share my experience, as I’m just one of many customers facing this issue.
Engine, Apr 5, 2025
Engine: Power lost and engine shut down. Yes, it is available for inspection. Warning Lamps: Engine lamp came on: [XXX] [XXX] Engine shut down while driving. While bring my Grandson, home from school. I was on the ramp to exit the interstate, at the stop sign I lightly touched my brakes because I was going very slow, nothing was coming when I accelerated the engine totally shut down in between both lanes on a state highway. All of the warning lamps on the dashboard were lighting up and blinking, all of the alerts were making noises, no power and I had no control of the vehicle, then the “press start signal” came on, I had to quickly place from drive to park, and then press the start button to crank the vehicle. While this was going on my Grandson asked me in a startled voice “what’s happening”. Scary is not the word “I saw my life and his life flash before my eyes” with my Grandson in the vehicle. That’s a [XXX] of a feeling that you never want to experience. Then he said “this is nothing but a tin can ”. All of my family calls this vehicle a “Tin Can”! This was a very dangerous situation that could have been life-threatening or death. The problem has not been reproduced. Dealership sent a GM Field Service Engineer to inspect vehicle on 3/18/25. I have had many problems with this vehicle that cannot be diagnosed. Engineer test drove twice and scanned for codes before and after test drives. His findings: no codes found, was unable to reproduce power loss, and loose negative terminal on battery post tightened. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Apr 4, 2025
Spun rod bearing
Engine, Apr 3, 2025
The engine stoped running at about 50mph. Beatty Chevrolet in Knoxville TN has car Suddenl deceleration no brake lights and stuck on curvy [XXX] Engine is lockedup and Beaty ordered a new engine with gm approval Beaty Chevrolet inspected the engine The only message was push start again. The service dept rep said this is rare but had 5 6.2l engines affected at his shop. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Apr 3, 2025
At approximately 19.000 miles when the car sits for an extended period of time, at the first start up, blue smoke comes from the exhaust tail pipe. Brought it to the dealer and they said that, that was normal. With the issues they are having with the engines, I wanted this to be noted, because blue smoke is indicative of either bad piston rings or bad valve seals. This should not be happening on a vehicle with 19,000 miles and have oil changes at every 3000 miles.
Engine, Apr 2, 2025
We were driving on a busy interstate in Knoxville, TN on a Sunday. We were 2 hours from home and my 2023 Tahoe basically went into limp mode while I was in the fast lane and the check engine light came on. No warning in advance. The speed reduced, which backed traffic up, and put me and my 4 children in danger. We finally got off the interstate and the vehicle had to be towed in to the nearest dealership. I had a friend drive us to enterprise where they put us in a Jeep Grand Wagoneer. On Monday, I received a call from the dealership stating they had good and bad news. The good news was the repair is covered by warranty but the bad news was it will be 2-3 months before they can get the part. The part is on back order and several people are waiting ahead of me. The said part is a valve body for the engine/transmission. The dealership also informed me that warranty will not cover a non-GM vehicle and that they will only pay for a rental up to 44.00/day. It’s not my fault the part is on back order, nor that enterprise gave me a non-GM vehicle. Also, I have a family of 6, which is why I have a Tahoe and I cannot be put in a small sedan. My children play sports, we have upcoming vacation, and quite frankly, I didn't pay 90,000.00 for a vehicle to be placed in a vehicle that I don’t feel is safe for my family. If I had wanted a sedan, I would have bought one. GM should take better care of their customers, especially when something is like this is not the customers fault!!! I have contacted GM and have been told I will be called back by a supervisor each time I talk to someone. This is unacceptable!!
Engine, Mar 30, 2025
I was driving on [XXX] thru Atlanta to meet my husband in Adairsville, Georgia, and my car started squealing like a belt was squealing and then it started making a loud knocking noise and shut off I was able to get it to the shoulder to see what was going on, when I realized it was in the motor I was about half a mile to the next exit as I did not feel safe being on the side of the road managed to make it to the truck stop after it cut off several times just imagine if someone was close behind me when my Tahoe kept shutting off it could have been a very bad accident called gm roadside assistance and had vehicle towed to nearest dealer they couldn’t look at it so my husband loaded it into the back of his lowboy trailer and took it to hometown dealer where I bought it from Tahoe only had 22599 miles on it and I paid over 90k for this I feel like we should be compensated for this and the downtime of not knowing when I will get it back INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Mar 29, 2025
2023 with 34,000 miles on the 6.2 engine. Shutoff while driving. Engine is bad and will need to be replaced. GM should be forced to do a recall
Engine, Mar 24, 2025
Started having an issue a few weeks ago with the vehicle shutting off while driving for no reason without warning causing a very serious safety concern. This issue seemed to stop until one Saturday when i started the vehicle i noticed a small tick. This ticking sound continued to grow. The vehicle then shut off again with warning while driving. 7 days had gone by since the first episode. When I started the vehicle again there was a very pronounce rapping and it sounded like parts inside the motor were coming apart. When I arrived home i called Onstar. They did a diagnostic twice and said the motor was not showing any codes and running perfect. I had it towed from my house and upon inspection the motor is blown with 10,000 miles
Engine, Mar 20, 2025
Engine failure due to rod bearing failure, without warning at 16,500k miles. It is available for inspection if needed. Currently is at dealership waiting for new engine. The vehicle shut off while driving at 40mph forcing me to have to stop in the middle of a roadway without any shoulders or turn offs. The problem was diagnosed and confirmed by a certified Chevrolet dealership. The failed engine will be sent to GM by the dealer. There were no warning lights prior to this incident or after.
Engine, Mar 20, 2025
The contact owns a 2023 Chevrolet Tahoe. The contact stated that upon starting the vehicle, there was an abnormal sound coming from the engine compartment. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the dealer, who then determined that the sound was the lifters tapping. The contact was informed that all 16 lifters needed to be replaced. The vehicle was repaired, but the failure reoccurred. The vehicle was taken to a different dealer, who also diagnosed the vehicle and determined that the failure was with the lifters, and informed the previous dealer might not have been repaired the vehicle properly. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 28,000.
Power train, Engine, Mar 17, 2025
Traveling down the highway at 65 MPH the engine/transmission started bucking and you could hear the rear wheel lock up. The vehicle then would not shift and reduced the speed to 55MPH. Check engine light came on. Chevrolet is telling me the valve body needs to be replaced but keep driving it because it is on national backorder. After doing some research GM is hiding the issue and keeps installing faulty valve bodies. The GM fix is that they programmed the transmission to reduce speed when it notices excessive wear. GM is not standing behind the issue as it has been like pulling teeth to get a loaner vehicle.