2023 Chevrolet Tahoe
Problems, recalls and owner-reported issues
Engine is the leading concern among 222 owner complaints filed for this model year. This is the 16th highest complaint count among 26 Tahoe model years with reports.
Of the 2023 reports, 3 involved a crash. 1 person was injured.
What owners report most often
Recalls and investigations
Fuel system, diesel, storage, tank assemblySep 18, 2025
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.
A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.
Campaign 25V619000 on NHTSA.gov
Engine and engine cooling, engine, hard parts internal/mechanicalApr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Engine failure increases the risk of a crash.
Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Campaign 25V274000 on NHTSA.gov
Service brakes, hydraulic, brake fluid low warning, lampSep 12, 2024
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Campaign 24V674000 on NHTSA.gov
Suspension, rearSep 20, 2023
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
Campaign 23V642000 on NHTSA.gov
Exterior lighting, lighting control module, softwareDec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Campaign 22V903000 on NHTSA.gov
Representative owner complaints: engine
137 reports, newest first. Show all
Engine, Mar 17, 2025
Vehicle broke down on 12/1/2024. Had it towed to the nearest dealership. Dealership claimed that gasoline was pumped into the tank. We knew that wasn't the case. I called the store we last used for fuel and spoke to the manager. She was able to pull my wife up on surveillance and verified that she pumped diesel fuel from a "diesel fuel only" pump on 11/21/24. We also verified that the fuel in the holding tank at the store was actual diesel fuel. My wife purchased 23.45 gallons of diesel fuel. The tank size on this Tahoe is a 24 gallon tank. We had burned half of this fuel before the vehicle broke down. We also verified that no one else had complained about the fuel from the store. Dealership said it needed a new engine. We had it towed to another dealership for a second opinion, but they couldn't verify what happened because the 1st dealership had cleaned out the fuel system. I called GM but they won't help because they are going off what the 1st dealership claimed. Vehicle is still under power train warranty, but they won't fix it. This vehicle left us stranded on the side of the road. Insurance was called and a representative did go and look at the Tahoe. He called back and said that the issue does not fall within our policy.
Engine, Forward collision avoidance, Mar 12, 2025
First the front collision warning systems kept coming on and off. Then the engine died on the highway and I had to restart. I drove a little further and it died again and would not restart. I had it towed to the dealer and they are telling me the engine has seized and needs to be replaced. I have 40,000 mile and the car is 2 years old. It was very dangerous to have the car die twice while at speed on the highway.
Electrical system, Engine, Mar 8, 2025
Repeated issues with the infotainment system had to be replaced 3 times to date. The motor blew at 49,000 miles 3 weeks ago. The replacement motor is on back order and it is very difficult to get a loaner vehicle, not to mention having to make a payment on the vehicle that I don’t have to use.
Engine, Mar 6, 2025
Traveling in left lane of [XXX] . Vehicle screen went black and car lost all power. No warning lights. Vehicle towed and inpected by GM dealership and determined that the vehicle needed a new engine. Vehicle maintenance records confirmed proper maintenance was done. Vehicle only 13 months old. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Engine, Mar 5, 2025
I was driving my 2023 Tahoe on the interstate, in the far left lane. I had my wife and 2 kids in the car. Suddenly I noticed the air turned off and the dashboard screen went blank. I noticed that the car was now in neutral and the accelerator was not providing any response. I put on my hazards and started to merge across 7 lanes of highway without using brakes because we were going up a hill. We lost momentum in the second to last lane and could not move. The Tahoe then switched to park and the electrical system kept shutting off and rebooting. This also resulted in the hazard lights turning off for brief moments in time, so it was not effectively alerting other travelers of our dysfunction. (This repeated for the next 30 minutes until the battery died.) During that 30 minutes we were stuck in the lane with traffic buzzing around both sides of us honking and people screaming at us. My wife and 2 young children were upset and crying from the commotion. Poluce and emergency response team arrived, flagged traffic and drug the vehicle off the road.car was stuck in Park, with no ability to move to neutral. So tire rubber was smeared across the last 2 lanes and into the right shoulder. Later a tow truck arrived and hauled to dealership. The car had ~11,000 miles and bought the vehicle 2 months ago. This should not happen with new cars.
Electrical system, Exterior lighting, Engine, Mar 5, 2025
When we first purchased our 2023 Tahoe the engine was making a tiking noise we took it back and they told us it was because it was brand new time past engine always needs oil when we drive it u have to press gas pedal it also has electrical problems back camera turns on and off . Brake sensors don’t work . I almost had a bad car accident due to the engine that it had stop because it said reduced power while I was on a highway . I lost my son 3 yrs ago in a car wreck . I don’t want no more accidents so please help me figure some out with my Tahoe . I also went to dealership and they directed me to a manager . Manager never help never called back or nothing we bought truck at friendly Chevrolet
Engine, Mar 4, 2025
Engine, (6.2 liter V8), quit without warning at highway speed, nearly causing head-on collision. Engine wouldn't re-start and needed to be towed to dealership on flatbed truck. Vehicle also wouldn't shift into neutral requiring it to be dragged onto flatbed. Chevy dealer states new engines are on backorder with no expected repair date.
Other or unspecified, Engine, Mar 3, 2025
While slowing for a red light my vehicle shut off, completely powered off. I had to press the ignition start button to turn it back on. I pulled to the side of the road, then two messages flashed on the dash screen, Service Transmission and Service Brake Assist. I called and scheduled a vehicle service at a local Chevrolet service center. After the service center evaluated my vehicle (in their possession for 72 hours) they stated there were no diagnostic findings and they could not replicate the issue. A vehicle randomly shutting off with no identifiable or repairable issue is a public safety concern.
Engine, Mar 3, 2025
I was driving in the fast lane and all of a sudden my car went into neutral. Thankfully, my children were not in the car and I was able to merge over safely to the side of the freeway. after as I barely pulled off the car completely shut off. I tried to turn back on several times but would not start back up. I had my Tahoe towed to the dealership, and they told me the engine seized up and was a failed engine. Dealership ended up ordering another engine and it was missing some sort of plug that failed and had to replace again!
Engine, Feb 26, 2025
The contact owns a 2023 Chevrolet Tahoe. The contact stated that while driving 70 MPH, the vehicle lost motive power and stalled without warning. The contact was able to coast over to the side of the road. No warning lights were illuminated prior to the failure; however, the check engine warning light illuminated after the failure and remained illuminated. The contact attempted to restart the vehicle; however, the vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed with engine failure. The vehicle was not repaired and remained with the dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 49,566.
Engine, Feb 24, 2025
The contact owns a 2023 Chevrolet Tahoe. The contact stated while driving 70 MPH, the vehicle lost motive power. The contact attempted to restart the vehicle; however, the vehicle failed to start. Additionally, the contact stated that the failure had occurred on a busy highway. The vehicle was towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 28,000.
Engine, Feb 19, 2025
Our engine (v8 6.2 liter) failed with out warning while my wife was driving. She said that while driving all of a sudden the dash started flashing telling her to restart the engine. The car just started shutting down. She had to immediately pull off into the median and barely made it out of the fast lane when the car stopped. She was so close to the fast lane that there wasn’t enough room for a person to stand without being hit. We had our Tahoe towed to the closest dealer thinking maybe it was an alternator. The dealer confirmed it was a failed engine and that our vehicle is the third vehicle on their lot with the same failed engine. All of the failed engine vehicles have right at 40 k miles plus or minus 1k miles. The only problem that we had noticed before the failure, happened that morning when I took the Tahoe to fuel up for my wife prior to her leaving. I noticed the engine cranked slow for a second before it started. I thought maybe the battery is just getting weak and that as she drove it that day, it would charge the battery. The exact failure as I understand it from the technician is “ the 5th cylinder failed in the lower half of the engine.” Apparently this is failing because the bearings weren’t properly seated during manufacturing.
Engine, Feb 17, 2025
On Sunday January 12, I was driving the vehicle on the highway with my cruise control on. The engine started missing the speed dropped a bit as the cruise control would not hold the speed. A mile or so later the vehicle engine started knocking with a metallic sound. I pulled over at the next exit and stopped at a store to look at the engine. There was nothing loose and a deep metallic knocking coming from the engine block, so I shut off the vehicle and called OnStar. At no time did any warning lights or other indicators come on. The gauges were normal. They/OnStar indicated I should not drive the vehicle, and they will tow to nearest Chevy Dealer for service and give me a $50 credit to take a Lyft to local airport to get a rental car. I was almost 4 hours away from home as I was travelling. After a week of turmoil with the local dealership I was told the vehicle needs a new engine. There is no ETA on the new engine as GM has to build it and has parts shortages. This was 5 weeks ago. I have been driving a rental since and there is still no indicate from the dealership about what happened or why. The vehicle is a 2023 and still under warranty but I am having to pay for the rental and request reimbursement which hasn't happened to date. There is very little information available, and I am in no man's land without a vehicle, so I have an open ended rental situation.
Engine, Feb 17, 2025
The vehicle shut off on the expressway causing a very dangerous situation. After several attempts it would not start again. I had to have the vehicle towed to the dealer and they advised me the engine has seized up. Most likely they told me the engine blew and will need replacing.
Power train, Other or unspecified, Engine, Feb 14, 2025
While driving the vehicle, the transmission stopped shifting and the engine shut off. There was no warning.
Engine, Feb 13, 2025
Fuel module failure. Tahoe stalled while on highway at normal speed of 55 mph. Near miss accident. Very dangerous, could have resulted in injury or fatality. Tahoe had to be towed to Chevy dealer, caused major problems. Tahoe only had 24,000 miles at time of incident.
Engine, Feb 13, 2025
The contact owned a 2023 Chevrolet Tahoe. The contact received notification of NHTSA Campaign Number: 24V674000 (SERVICE BRAKES, HYDRAULIC). The contact stated that while driving 70 MPH, the vehicle lost motive power and stalled. There was no warning light illuminated. The contact was unable to coast over to the side of the road. There were no warning lights illuminated. The contact stated that the vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired and remained with the dealer. The manufacturer was notified of the failure. The failure mileage was approximately 82,000.
Engine, Feb 3, 2025
6.2l engine catastrophic engine failure with appt 17,000 miles on odometer. Kendall Chevrolet of marysville Washington has new engine on back order.
Service brakes, Engine, Feb 3, 2025
1st incident- Engine had a bad lifter and cam shaft with 46,000miles. When this happened I was going through a railroad crossing, if the failure was bad enough and locked the engine up I would have been stuck on the tracks with my family. This issue could cause the motor to lock up if the lifter or cam shaft had a more serious failure. Dealer confirmed the lifter and cam shaft were bad and replaced. the engine had a vibration 2 weeks before the failure but the dealership could not identify or duplicate the issue. Vehicle was in the shop for 35 days to repair. 2nd incident- Parking brake and brake system locked up and would not release until the vehicle was reset. Scheduled vehicle to be towed in and the brakes locked up again while loading the vehicle to tow. Dealer is still troubleshooting the issue after 5 days. Errors on screen "Forward Collision System unavailable, Brake system failure 43mph top speed, Service steering column lock, service traction control, Service ESC, Service Brake Pad Monitor" If this happened while on the highway it had the chance to cause a serious wreck.
Engine, Feb 2, 2025
With 63,000 miles the vehicle experienced catastrophic engine failure on a freeway. This resulted in loss of power with no ability to get the vehicle to a safe location. It was determined that the #7 crankshaft bearing was the cause of failure and the compete engine was replaced as a result.
Electrical system, Engine, Feb 1, 2025
Traveling on the interstate late at night in the winter with my family, which includes small children, a clicking noise began but then went away. No diagnostic lamps came on, everything seemed fine, vehicle responded appropriately. Moments later, on a remote stretch of interstate, we lost power and the engine shut down. The vehicle would not turn back on. We were stranded in the dark on a freezing night.
Engine, Jan 29, 2025
On [XXX] while driving on the highway near Wash DC engine stopped, went to neutral. Would not start again. OnStar towed vehicle to Koons Chevrolet GMC Tyson in Vienna VA. 703 448 7221. On Tuesday [XXX] Koons Service Dept. looked at vehicle and determined that it was a thrown bearing and needed a new engine. There are 28,712 miles on vehicle. You can inspect if desired. Our safety was extremely compromised. We were on a 5 lane highway in the left hand lane going 65. Engine quit and we had to coast to the far right lane in heavy tra]c. We almost got hit several times on the maneuver and rear ended on the side of the road from oncoming vehicles while waiting for a tow. Dealer has work order to repair the vehicle. Vehicle was not inspected by the manufacturer that we know of, nor the police or insurance representatives. Only inspected by the dealership. The Service Department said the parts are on a "Galactic backorder" which means they do not know when they will come in. GM will not repurchase the vehicle or tell me when the vehicle can be repaired. Will not provide any compensation until the issue is resolved, which is unknown and could be months. It is an extreme financial hardship for me to cover my rental car (taxes and insurance for the rental car are not covered) and continue to pay the car payment and the insurance on a car that is not available to me. My case number with GM is [XXX]. GM has sent me to three representatives. Jonathan Phone Number: 1-866-790-5600 Extension: 5927263 (Chevrolet Customer Assistance) Tomorra (866) 790-5600, extension 524688 (supervisor) Janet (866) 790-5600, extension 5910608 (part delay department) None of the reps have given me any assistance with my situation. They just kick me down the chain to someone else that cannot assist me. I simply need my car fixed, loan payed off or a repurchase for the original value of my car so I can purchase another vehicle. Can you direct me to any assistance? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Power train, Electrical system, Engine, Jan 29, 2025
After getting gas just outside of Pueblo Colorado on [XXX] I was entering [XXX] and luckily I was in the right lane when all of a sudden no power to the vehicle. I was able to make it by inches in the clear on the shoulder of the road. Being [XXX], I had trouble crawling over the console through the passenger side of the vehicle because I could not safely see the traffic on the interstate to exit the vehicle on the driver side. The state police could not come to assist us with any type of traffic control because of other accidents. The BNSF railroad has a mutual aid pack with them when needed in an emergency situation. They were able to come assist us with the red lights for traffic control, and the tow truck arrived and was able to flatbed the vehicle to a GM Chevy dealership. The tow truck also delivered our 26 foot travel trailer to the nearby campground. If it wouldn’t have been for the BNSF police this could’ve been horrendous accident because of the traffic. I have never been in a more scary situation as with the 2023 Tahoe built by a major corporation and being as unsafe as it is. I have been told the engine needs to be replaced because the bearings failed with metal fragments found in the oil pan. GM has been aware of this problem with the 6.2 engine for many years and has never done anything. Is it gonna take people getting killed on the highway to get something done. Sent from my iPad INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Jan 29, 2025
I was driving down the interstate and with the no warning the vehicle would not accelerate any longer and tried to coast onto the exit. Totally stopped blocking all traffic on the exit. Could not crank the engine or at least put in to neutral to push out of the road. Had it towed to dealership and they said motor had seized up, connecting rod bearing seized on crankshaft causing extensive metal contamination throughout engine. Wanted GM to buy back the vehicle but would not. Only replaced the engine.
Engine, Jan 27, 2025
Main bearing failure on my 6.2L at 17,000 miles. Starting making knocking noise, and within two miles it died and wouldn’t restart. No check engine light or warning lights. Blew a 40 amp fuse. Once replaced started but knocked and died. Dealership determined spun main causing internal engine failure. Motor replaced. Started making internal engine noise again like almost a spark knock type noise or rattle under acceleration. Has 32k miles on it now and bring into dealer next week for issue. Engine was on back order and took over a month to get.