2023 Chevrolet Tahoe

What owners report most often

1. Engine119
2. Power train45
3. Electrical system38
4. Service brakes20
5. Engine and engine cooling18
6. Other or unspecified16
7. Forward collision avoidance12
8. Fuel/propulsion system12

Recalls and investigations

1. Fuel system, diesel, storage, tank assemblySep 18, 2025

   General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.

   A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.

   Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.

   Campaign 25V619000 on NHTSA.gov

2. Engine and engine cooling, engine, hard parts internal/mechanicalApr 24, 2025

   General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

   Engine failure increases the risk of a crash.

   Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

   Campaign 25V274000 on NHTSA.gov

3. Service brakes, hydraulic, brake fluid low warning, lampSep 12, 2024

   General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

   Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

   The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.

   Campaign 24V674000 on NHTSA.gov

4. Suspension, rearSep 20, 2023

   General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.

   A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.

   Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.

   Campaign 23V642000 on NHTSA.gov

5. Exterior lighting, lighting control module, softwareDec 8, 2022

   General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

   DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.

   The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.

   Campaign 22V903000 on NHTSA.gov

Representative owner complaints

222 reports, newest first.

1. Engine, Fuel/propulsion system, Jul 13, 2026

   I was a victim to the L87 Engine Loss of Propulsion recall. On June 19, 2025, my engine was replaced as it failed all test. After getting a new engine, I have had 5 engine misfires and the dealership blamed it on faulty gas. Now my 2023 Chevrolet Tahoe that I trust to drive my two toddlers around, is at the dealership for a flashing engine light. Even after the engine was initially “remedied”, the new engine continues to fail and I have lost trust in having a safe and reliable vehicle.

2. Electrical system, Engine, Jul 6, 2026

   We had car checked due to strange and erratic shifting in less than a year of owning. Then took in for recall, they stated it was fine and performed the remedy with higher grade oil. Still had issues and took to another dealership to look at and they stated it was fine as well. About 2 months later while I was driving it was hesitating and would kind of buck and when I was about to turn on to a busy road it just stopped. I couldn’t do anything at all, the entire car was locked up. The tow truck driver couldn’t even get it into neutral to tow. Dealership said it’s the engine and it needs to be completely replaced.

3. Other or unspecified, Engine, Jun 29, 2026

   Space does not allow for a complete statement. However, here is a summary. I purchased my 2023 Tahoe on 07/19/23. On 07/27/23, the check engine light came on. Since then, there have been approximately 8-9 instances where the check on. Each time I took the vehicle in for service, however, the check engine light kept coming back on. There have been 2 instances in 2026 where the vehicle would not start, and then the check engine light came on. A Chevrolet dealer service advisor told me that this is a known issue with GM and Chevrolet; however, no remedy has been found yet.

4. Visibility/wiper, Jun 16, 2026

   Following a GM-initiated over-the-air (OTA) software update on May 18, 2026, my vehicle's windshield wipers became permanently inoperable — stuck in the "on" position with no ability to turn them off. This is not a gradual mechanical failure or wear-and-tear issue. The malfunction began immediately and directly as a result of a software update pushed by General Motors. Because the wipers cannot be controlled, I have been forced to remove the wiper fuse to make the vehicle driveable. This means I am currently operating a vehicle without functional windshield wipers — a federally mandated safety system. I want to be clear: this unsafe condition was caused entirely by a GM software update, not by any action or negligence on my part.

5. Engine and engine cooling, Fuel system, Gasoline, Power train, Jun 12, 2026

   The contact owns a 2023 Chevrolet Tahoe. The contact stated that while driving at 40 MPH, a warning message advising to reduce acceleration was displayed, the Check Engine warning light illuminated, and the vehicle stalled. The contact was able to pull over safely. The contact stated that the failure was recurrent. The dealer was notified of the failure and diagnosed the vehicle with a valve failure. No further information was available. The manufacturer was notified of the failure. The failure mileage was approximately 57,000.

6. Service brakes, Jun 7, 2026

   It has not been inspected yet but will call the dealer tomorrow morning since I just this vehicle on Friday

7. Engine, May 28, 2026

   Total engine failure.

8. Engine, May 26, 2026

   While traveling at 55mph yesterday, I experienced a full engine failure which shut the car off fully while traveling on a single lane double yellow road. I was able to coast to a secure location. The car will not start or go into neutral. There were no warning lights that occurred at any time prior to the failure. This all occurred while on vacation 2 hours away. I previously went to the dealership for the recommended "fix" for the recall but that obviously did not solve the problem. This was an extremely unsafe situation for me and my family. I also encountered towing costs and significant loss of time. In addition, the car is at a dealership over 2 hours from my home. Chevrolet should be held accountable well beyond a recall notice which didnt solve the problem.

9. Engine, May 15, 2026

   Chevy Tahoe with 6.2 V-8 engine started making noise. Started rattling. Taken to dealership where I bought it. Oil changed found metal in the oil engine making all sorts of noise. Diagnosed to engine failure. New engine is ordered . It’s been 2 weeks and I am number 5 In order for engine replacement at the dealership

10. Engine, May 13, 2026

    Engine failure while driving to [XXX] from [XXX] . Mobile mechanic indicated a likely spun bearing. Less than 24,000 miles. Was stranded in [XXX] and delivered vehicle to local Chevrolet dealership same day as incident. It’s been over a month with no repair eta. Incurred significant travel and accommodation costs, with receipts available, due to the disruption. GM had thus far refused to confirm any reimbursement of expenses. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

11. Engine and engine cooling, Power train, May 12, 2026

    The contact owns a 2023 Chevrolet Tahoe. The contact stated that while driving at 75 MPH, the vehicle shut off without warning. Due to the failure, the contact used excessive force to steer the vehicle off to the shoulder of the highway where the vehicle was then towed to a dealer. After the vehicle remained in the dealer's possession for over a week, the vehicle was diagnosed with an engine failure. The contact was then informed that the vehicle was placed under recall NHTSA Campaign Number: 25V274000 (Engine) and that the engine would be replaced. Despite the engine repair, the contact stated that an abnormal, rattling sound would emit from the vehicle upon start of the engine. In addition, the contact stated that the vehicle would violently jerk upon depression of the accelerator pedal while at a complete stop. The failure started intermittently; however, the contact stated that overtime the failure became more persistent. The vehicle was taken to the dealer where they claimed that the transmission was four quarts low on transmission fluid; they then informed the contact that they could not guarantee that remedy would repair the failure. The contact stated that failure improved; however, she would still experience a slight hesitation upon depression of the accelerator pedal. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 39,000.

12. Other or unspecified, May 10, 2026

    Two years in a row my car leaked a significant amount of water through every light button any hole in the ceiling. It also leaked all over the center counsel while driving and came through the foot pedals all over my feet and the entire floor of the vehicle while driving. The value of my car has been destroyed and Chevrolet is not taking this seriously. They have told me they will only replace the roof liner and half the carpet. They are not acknowledging the potential damage done to the electrical system and the overall value of the car from bad smells that have been caused by dirty water soaking the entire interior. My car is ruined and it should be replaced.

13. Engine, May 9, 2026

    Oil consumption- 1-3 qts low between oil change intervals at 5000k No burning or oil smoke.

14. Power train, Engine, Apr 30, 2026

    Engine stopped while driving 70 mph down the highway and the car shifted into neutral. Had to cost to side of the road. Took car into dealership and even though the car was certified safe drive and the engine had no issues 5 months ago, I was told the engine was now locking up. The engine failed despite using the higher viscosity oil that chevy recommended. These greedy cunts at chevy placed me and my family's lives in danger to save a buck; they knew that the engines would fail and instead of replacing the engines, they put thicker oil in the cars to hopefully get the cars past warranty.

15. Engine, Fuel/propulsion system, Forward collision avoidance, Apr 28, 2026

    The car has cut off three time while at stoplights. I can get it restarted but the dealership cannot duplicate it even though there are codes in the system. Also the automatic braking will randomly stop when it shouldn’t and it is a hard braking.

16. Power train, Apr 28, 2026

    Transmission has had a failure to shift problem on several occasions resulting in deceleration and a decreased ability to accelerate. This has occurred on most occasions at highway speeds while passing a vehicle causing a very unsafe condition. Dealer has evaluated and determined the transmission valve body is defective and needs replaced. Upon researching the problem, many similar GM vehicles are experiencing the same issue

17. Power train, Engine, Fuel/propulsion system, Apr 25, 2026

    The engine randomly shut off while driving down the interstate and wouldn’t start back up. The car had the recall “remedy” done to it. Inspection and thicker oil. The only warning I got was to restart the engine after it shut off. My safety was compromised by breaking down on a main interstate coming through Memphis with no emergency lane to pull over in.

18. Electrical system, Engine, Apr 23, 2026

    2023 Tahoe Z71 had recently been put in the shop, and evaluated for engine failure recall. Dealership/GM deemed it failed test for replacement, we were given 0W40 oil and sent back out, this last weekend we had catastrophic engine failure while operating at 50+MPH.

19. Engine, Apr 22, 2026

    On April 10th, while traveling approximately 7 hours from home on a very busy highway in [XXX] , my 2023 Chevrolet Tahoe (6.2L engine) suffered a complete and catastrophic engine failure, requiring a full engine replacement. The vehicle had to be towed and I was left stranded with no transportation. Prior to this failure, I had brought the vehicle to an authorized GM dealership for a recall inspection specifically related to the 6.2L engine on September 9, 2025 with 36,162 miles. The dealership technician inspected the vehicle and informed me that my engine was not defective and cleared it. Shortly after that inspection, the engine suffered a total failure at 46,6xx miles on the vehicle. I am currently leasing this vehicle at approximately $1,100 per month and have been without the vehicle for an extended period while it sits awaiting repair. GM customer care has been contracted and has indicated they cannot move forward with a buyback claim because the BBB is not taking my case because the vehicle is older then 2 years old which I know is a false legal claim. This is a serious safety concern, a catastrophic engine failure at highway speed poses significant risk to vehicle occupants and others on the road which appears consistent with other reported failures. I am aware that NHTSA has opened Recall Query RQ26001 investigating the adequacy of GM's remedy under recall 25V-274. My experience is consistent with the 36+ complaints that triggered this investigation, engine failure occurring after an authorized dealer performed the recall inspection and cleared the vehicle. I am requesting this complaint be added to the RQ26001 investigation file. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

20. Engine, Apr 21, 2026

    As I was driving down the tollway in Dallas going 75 miles an hour, my engine completely shut down and went into neutral in rush hour traffic. I had to slowly get over from being in the left lane as my car was slowing and slowing. I was able to get over on the side of the tollway as cars zoomed past me. By the grace of God, I didn't get hit. Once it was towed, the service department confirmed that it is my engine that shut down and the entire engine needs to be replaced. Now the problem is they cannot find an engine or parts to fix it. No warning came on at all before this happened. Very dangerous situation.

21. Engine and engine cooling, Apr 17, 2026

    The contact owns a 2023 Chevrolet Tahoe. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The oil was changed at the local dealer. After 24 hours, the engine was blown after driving approximately 50 miles. No warning lights were illuminated. While accelerating from a stoplight, there was an abnormal squealing noise from the drivebelt. The vehicle was taken back to the local dealer, and the contact was informed that the flywheel was hitting the camshaft and changing the oil had disturbed the function of the vehicle. The vehicle was not fully diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 14,945.

22. Engine, Apr 8, 2026

    We were driving down the highway at around 77 miles per hour. I noticed that the vehicle chimed as though I initially got into it and needed to start the engine. I saw the dashboard asking me to start the engine. I attempted to start it while we were coasting to a stop, but it wouldn't start. I was able to barely get out of the lane of travel and avoid a collision. I tried to turn off the vehicle and turn it back on but it would not start. It would not even turn over. The vehicle eventually cannibalized the battery because it would never shut off.

23. Power train, Electrical system, Apr 7, 2026

    At less than 50,000 miles, my alternator went out and had to be replaced, causing the battery to need to be replaced also. Now, at only 51,000 miles, my transmission is having problems and causing the vehicle to jerk when shifting. This vehicle has had regular maintenance performed by a combination of dealers and certified service centers since it was purchased brand new. I have never had this much trouble with a vehicle and am very concerned about it's overall safety and integrity, given the severity of the problems for something that is not old and does not have high mileage.

24. Engine, Apr 5, 2026

    Passed a truck in 2023 Chevy Tahoe on a two lane highway and the Tahoe would not accelerate. It switched into neutral and would not run. This was a major safety issue. There was a semi truck behind me that could have run over me and my family. Luckily there was wide open area next to the road that I coast into. Truck was towed to a dealership out of state while we were on vacation.

25. Engine, Apr 3, 2026

    My wife just picked up our 4 year old from daycare. She just merged onto I-81N and the vehicle shut off on her at highway speed during rush hour! A message on the dashboard said "Please restart vehicle". She managed to pull the Tahoe off onto the shoulder, but couldn't get it started. She remained in the vehicle with my daughter and called 911 to request a state police vehicle park behind her so that she wouldn't be hit by any passing traffic. I (her husband) met her on the side of the highway and we tried starting it with a battery booster pack to no avail. We called a tow truck and had the car towed to the dealership that we purchased the vehicle from. They confirmed that the motor was indeed locked up and needs to be replaced. This vehicle already underwent the 6.2L recall test and "PASSED". It was running the 'remedy' 0W-40 oil. This is COMPLETELY UNACCEPTABLE.