2023 Chevrolet Tahoe
Problems, recalls and owner-reported issues
Engine is the leading concern among 222 owner complaints filed for this model year. This is the 16th highest complaint count among 26 Tahoe model years with reports.
Of the 2023 reports, 3 involved a crash. 1 person was injured.
What owners report most often
Recalls and investigations
Fuel system, diesel, storage, tank assemblySep 18, 2025
General Motors, LLC (GM) is recalling certain 2021 Cadillac Escalade, 2021, 2023-2024 Chevrolet Tahoe, and 2022 and 2024 GMC Yukon vehicles equipped with a 6-cylinder diesel engine. The original fuel tank may have been replaced with an incorrect fuel tank, which can allow fuel to leak in a rollover crash.
A fuel leak in the presence of an ignition source increases the risk of a vehicle fire.
Dealers will inspect for the correct fuel tank and replace it, if necessary, free of charge. Owner notification letters were mailed November 5, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252512770. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 18, 2025.
Campaign 25V619000 on NHTSA.gov
Engine and engine cooling, engine, hard parts internal/mechanicalApr 24, 2025
General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.
Engine failure increases the risk of a crash.
Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.
Campaign 25V274000 on NHTSA.gov
Service brakes, hydraulic, brake fluid low warning, lampSep 12, 2024
General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."
Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.
The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.
Campaign 24V674000 on NHTSA.gov
Suspension, rearSep 20, 2023
General Motors, LLC (GM) is recalling certain 2023 Cadillac Escalade, Escalade ESV, Chevrolet Suburban, Chevrolet Tahoe, GMC Yukon, and Yukon XL vehicles. The rear suspension outer control arm bolts may not have been properly heat-treated, which can cause the bolts to break.
A broken suspension bolt can result in misalignment of the rear wheel, increasing the risk of a crash.
Dealers will replace both rear suspension outer control arm bolts, free of charge. Owner notification letters were mailed November 14, 2023. Owners may contact Chevrolet customer service at 1-800-222-1020; Cadillac customer service at 1-800-458-8006; and GMC customer service at 1-800-462-8782. GM's number for this recall is N232415910.
Campaign 23V642000 on NHTSA.gov
Exterior lighting, lighting control module, softwareDec 8, 2022
General Motors, LLC (GM) is recalling certain 2020-2023 Cadillac CT4 and CT5; 2021-2023 Buick Envision; and 2022-2023 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles. The daytime running lights (DRLs) may not deactivate when the headlights are on. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
DRLs that do not deactivate as intended may result in a glare, reducing visibility, and increasing the risk of a crash.
The body control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed January 23, 2023. Owners may contact GMC customer service at 1-888-988-7267, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N222386380. This recall expands previous recall number 22V-827.
Campaign 22V903000 on NHTSA.gov
Representative owner complaints
222 reports, newest first.
Engine, Back over prevention, Forward collision avoidance, Dec 17, 2025
While Driving to my appointments via the freeway, all of a sudden the vehicle slowed down, I noticed most of the warning lights were on including the check engine light that was blinking. I Happened to be near a GMC dealership which previously did repair work on my vehicle and left it with their service center for a diagnostic inspection. A week later my service advisor contacted me with their Vehicle condition report that my vehicle had camshaft and internal engine group issues. He quoted repairs but recommended replacing the engine. Repair or engine replacement $21,296.51. Six months before this issue I had the same issue the warning lights and it resorted in replacing the brake control cylinder. Once repaired no issues/messages or symptoms with my vehicle until this current engine problem/replacement.
Steering, Electrical system, Service brakes, Dec 17, 2025
The car was parked totally normal, went into a store, then came out to start it and when it was put in drive every light on the dash came on and gave a warning for “brake system failure top speed 43 mph” “service traction control” “service esc” “service steering column lock” “service brake pad monitor” “trailer brakes disabled service required”. Shut the vehicle off and restarted with same results. Brakes were inoperable and almost hit the car parked in front of me. Let the car shut down for a couple hours came back and started it and now everything acts normal except there is a Check engine light. Haven’t read the codes yet but am making an appointment at the dealer for warranty work.
Steering, Electrical system, Vehicle speed control, Dec 10, 2025
The car presented steering lock column issues with repair lights on at 50 miles. Since then, they have repaired the system numerous times and replaced that system fully twice. They also replaced the manual start system and six other pieces of the car over 18 visits to two different Chevy dealerships. The car still reduces speed and stops acceleration, has electric issues in the windows, lights and gate etc.
Service brakes, Dec 5, 2025
Vehicle suddenly lost breaking power while driving . The vehicle system shows Antilock Braking System issues. Losing Break power while driving has serious consequences
Service brakes, Forward collision avoidance, Dec 4, 2025
On 12/3/2025, I moved my car in the driveway at 11:15am EST without any issue. At 6pm EST, myself and 2 young daughters got into the car to head out an hour away. As I went to drive away, I stepped on the brake and the car did not immediately stop…the brakes failed and came to a rolling stop. At that moment all types of warning and lights lit up the dashboard. I placed the car in park exactly where it was in the driveway and left it. I also tried to select the Ebrake and it would not engage. I called the dealer first thing the next morning as that had been closed at the time it happened. I was told to bring it in and not to drive it so nobody in my car or else would be at risk. The car was towed at my expense to the dealer. When I got in touch with the dealer that afternoon to get a status. They advised the believe the BCM needed to be updated because it seem to not be communicating properly but wanted to keep it over night to retest it before they sent me home with it. Going to point out several things…thankfully I had not left my house, as I live on a mountain and should that have happened while descending it could have been catastrophic. No warning or anything that the brakes would fail! According to records it shows the did a recall update back in Feb 2025 regarding the BCM- however, how are we sure it truly was fixed or was defective. GM/Chevy needs to take accountability for this defect and safety hazard that could result in death. In reading forums, I am not the only one this has happened to
Engine, Nov 3, 2025
I dont believe the correct fix is changing Oil Viscocity
Engine, Nov 2, 2025
I bought this 2023 Chevy Tahoe rst brand new from the dealer and about a few months of owning it I noticed that the truck was needing oil before the next oil change. It’s as if it was consuming itself. This continues for month until last week when the truck died on me. I was able to jump start and everything worked fine for a day. The next day things got worse. I was on the highway and truck started shaking and giving off all kinds of codes. I took it to dealer and they said I needed a new battery but that there was also an engine problem. I bought a new battery and none of the messages on dash resolved like I was told. The truck is u drivable motor is knocking and was even making loud popping sounds. Of course my truck just hit 64,000 miles so gm is saying I’m out of warranty. I should not be having these types of issues on an almost brand new truck that I’ve owned 2 years. Engine light is flashing and dealer said this means major issue.
Engine, Oct 29, 2025
The idler pulley was squealing. Dealership I took it to said this was the 3rd one they've had to replace in the last few days.
Power train, Engine, Oct 29, 2025
2nd Powertrain failure in 4 months in 2023 Tahoe with 6.2L engine. The first being the Camshaft and lifters failing at highway speeds, which was repaired. The second issue the engine seized while on a tollway going approx 70 MPH with my spouse, children, and family in the vehicle. We were able to coast to the shoulder while waiting on a tow truck. Because of the engine being seized, the Tahoe is waiting on the engine to be replaced. While we wait, we were told they have no loaner vehicles and there are no GM rental vehicles available with who they contract through. Having a 2023 leased vehicle fail twice in 4 months with children in the vehicle is unacceptable and brings to question the safety and reliability of the vehicle moving foreward.
Power train, Oct 19, 2025
I was driving on an interstate when the vehicle check engine light came on and it went into limp mode causing the vehicle to go into low speed in the middle of traffic. Check engine light code P0747
Other or unspecified, Oct 13, 2025
While driving down the road, we heard what sounded like a gunshot into our vehicle! I pulled over and my top panoramic sunroof had exploded! There was no “point of impact” - no rock or falling debris, we were only going 45mph. It blew up and left fracture lines throughout the sunroof glass from the explosion. I just bought this car less than a month ago from the dealership (used but only 33k miles).
Service brakes, Oct 10, 2025
While driving my Tahoe on the highway at normal speeds approximately 65mph. I tried to exit freeway and my brakes were unresponsive. At this moment i began to allow the vehicle tto slow down on its own. I was able to safely exit the highway and the dealer ship was right off the exit. at low sppeeds i could push the brake pedal all the way down and acchieve some braking capability.
Electrical system, Engine, Oct 4, 2025
The engine in my vehicle has experiences major failures in valve flap adjusters, multiple valve failures, valve cover issues, and over consumption of oil by over a quarter in a week and a half of average driving. My safety was put at risk because the engine failure resulted in traction control malfunctions while going 70 mph up hill on a major interstate. This led to extreme shaking which did not stop until slowing down to below 15 mph. Luckily I was a mile from an exit and was able to coast off the road quickly; it was decent enough weather, and I was less than 5 miles from my destination so I could creep between 15-30 mph to not exacerbate traction control alarms. That slow mph did back up traffic behind me. As far as I am aware the problem was likely reproduced by the dealership service tech, which led to their recommendation to replace the whole engine. They do not consider it to be covered by any warranty anymore. The engine may be in their possession still, but I am unsure. There were zero warning lights/prompts from the vehicle that anything was going wrong prior to the shaking and loss of traction control at high speed. The dealer service team suggested that my high miles led to the engine failure. I do highway driving with it and have followed all manufacturer recommendations for oil changes, and even more frequent changes with OEM oil since about 80k miles. I do not think this engine should have failed at this amount of mileage. I made note of oil consumption around 95k miles and measured oil loss regularly. It was a little less than a quart every 2K to 3k miles which manufacturer states is within spec so I would top off oil. A year ago it had a TCM wire replaced after burning in half. 3 weeks ago I also had to replace the entire turbo. The wire rendered my car unable to go in gear. The turbo failure put me into limp mode. I think the turbo failure was a sign of a deeper issue that went undiagnosed.
Electrical system, Oct 2, 2025
On several occasions while operating the vehicle during inclement weather the windshield wipers intermittently stopped working. Restarting the vehicle several times did not remedy the problem. Once the vehicle was parked for a while the wipers started working again. This vehicle has been to the dealership regarding this issue numerous times and sent back in service with a message from the technician, could not duplicate the complaint.
Electrical system, Oct 2, 2025
On several occasions while operating the vehicle during inclement weather the windshield wipers intermittently stopped working. Restarting the vehicle several times did not remedy the problem. Once the vehicle was parked for a while the wipers started working again. This vehicle has been to the dealership regarding this issue numerous times and sent back in service with a message from the technician, could not duplicate the complaint.
Power train, Sep 18, 2025
While traveling on [XXX] approximately 20 miles west of Rawlins WY the vehicle entered “limp mode” causing us to drive at an unsafe slow speed. The transmission caused a check engine light to activate which was confirmed by a service technician in Rawlins with a PO747 code show on his OBD2 scanner. The problem was confirmed by the servicing dealer in Lincoln NE. The transmission was inspected by the servicing dealer. They replaced the valve body and fasteners approximately 1 1/2 months later. The problem first occurred at the time of the incident and I had no prior warning. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Sep 10, 2025
on [XXX] we bought our 2023 Tahoe High Country from Jeff Gordon Cheverolet in Wilmington NC. In April 2025 a recall was announced on our car for engine failure. In June of 2025 we received a letter stating that a fix for the recall was to have an inspection done. If passed, then an oil change and new cap would be done. This was completed. on [XXX], I was on the highway accelerating to get up the speed, when I heard a loud pop noise. Then i heard loud knocking coming from my engine, the check engine light came on with the traction light as well. The car then had sluggish acceleration and would not accelerate but would have high than normal RPMS and rev when trying to accelerate. I knew then that I had engine failure. I was able to get the car to a safe place and called the dealership right away. They got it towed to Marine Chevy since it was closer. The next day they did an inspection on the vehicle and said the camshaft and lifters were broken and had to be replaced. I said I would need a new engine replaced due to the damage and recall. I was told it would not be under recall because it was the top and not bottom. They said the GM refused the new engine but would not tell me if it was the General Manager or General Motors that refused. I called and texted multiple times asking for pictures. They refused to send me any until 9/9 after multiple attempts. They only sent me one of the rods and rocker arms showing a rod bent and stated it was the lifters. still no pictures of the camshaft broke or lifters. These problems already have multiple class action lawsuits out for this particular engine failure. I was told the recall would still be on the engine even after the repair, I can still have engine failure. I refuse to pay the money for this car to continue to be in the shop due to a bad engine that was put in these models. I also have a case open with General Motors for replacing the engine as well and they are refusing to help. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine, Sep 9, 2025
When i asked Kunez Lake Geneva, Wi. When the engine recall would be taken care of. I was told that GMC has to order the recall first. Then when asking about the process of inspecting. They informed me they would listen to the motor and decide if it was effected or not. I paid $82k for this vehicle. I find that listening to the motor isnt a thorough way of inspection. After they deem the motor ok. There going to put higher viscosity oil & an oil cap. What if something happens in the future. Is my familys life safety not important? Summary General Motors has decided that a defect which relates to motor vehicle safety may exist in certain 2021 – 2024 model year Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, and GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with the 6.2L V8 gas engine (RPO L87). The connecting rod and/or crankshaft engine components in these vehicles may have manufacturing defects that can lead to engine damage and engine failure. Safety Risk If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. Remedy Dealers will inspect and, as necessary, replace the engine. Vehicles that pass inspection will be provided a higher viscosity oil, which will also require a new oil fill cap, an oil filter replacement, and an owner’s manual insert.
Other or unspecified, Aug 27, 2025
I purchased a brand-new 2023 Chevrolet Tahoe. One of the key reasons for choosing this vehicle was its built-in safety and connectivity features, including the OnStar system. I also pay more than $50/month for an OnStar subscription, trusting that the service would provide essential safety functionality. Recently, the OnStar system in my vehicle stopped working. I received no warning, no service bulletin, and no notice from GM or OnStar of thhe failure or that this was a known issue. Upon diagnosis, I was informed that the OnStar module had failed and would need to be replaced—at a cost of $822 out of pocket. OnStar is a core safety feature that GM actively promotes as part of the vehicle’s value and security. For such a critical system to fail in a vehicle that is barely two years old is unacceptable. I believe this constitutes a product defect that GM/OnStar should be held accountable for, especially since multiple consumers are reporting similar issues on public forums. Most of all I had no indication in the vehicle of the failure; there was no check engine or issue light indicating a failure. When I called onstar the only explanation I got was that I should have noticed that the onstar light was out. That’s not sufficient for a safety item you expect to work like the breaks.
Electrical system, Other or unspecified, Engine, Aug 25, 2025
At a stoplight vehicle wanted to stall out Motor was shaking
Power train, Aug 21, 2025
Torque converter needed to be replaced, and then a week later still had the same shuttering and loss of power and the valve body needed to be replaced. Got it back and it still is shuddering and hard shifting.
Steering, Service brakes, Aug 11, 2025
I was driving down [XXX] in LaPuente and every light on my dash lit up and I attempted to Exit freeway and my brakes would not work so I waited for car to slow down and luckily I was near by the Puente hills Chevrolet dealer. Also my steering wheel was very lose and it felt that I couldn’t steer well. I pulled into dealership and had to push my brakes all the way to the floor board just for Tahoe to stop. Dealer said that there was various communication codes which they said vehicle would have to stay due to safety issues. My vehicle has been at dealer for 3 days so far INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Engine and engine cooling, Aug 1, 2025
The contact owns a 2023 Chevrolet Tahoe. The contact received notification of NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The local dealer was made aware of the issue and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Engine, Aug 1, 2025
My vehicle’s engine has been recalled since June. The dealer refused to inspect because there is no remedy to replace the engine. I have complained since I purchased the vehicle of noises that I’ve heard. I am hearing more noises, and I am increasingly getting more scared every day to drive my vehicle. I will not put myself nor my family in harms way I can get into an accident. I am afraid to drive the vehicle. I am not taking any chances of hurting anyone else or my family or potentially have a fatal accident. two months of driving around scared I will not drive my truck anymore. I am beyond upset that there is no remedy for this and that it is not taken seriously. Something needs to be done regarding my situation and all others. The vehicle was sold, most likely knowing that this was a problem. GM needs to make good on this problem before people get killed. I would like them to buy back my vehicle, I am sure I qualify for a full re-purchase. I called GM. They will get back to me in five business days. I cannot emphasize how afraid I am to drive my vehicle and I paid $110,000 for this vehicle.
Engine and engine cooling, Jul 31, 2025
See attached document for complaint.