2002 Dodge Durango
Problems, recalls and owner-reported issues
Suspension is the leading concern among 434 owner complaints filed for this model year. This is the 11th highest complaint count among 25 Durango model years with reports.
Of the 2002 reports, 38 involved a crash and 13 involved a fire. 40 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Suspension, front, hubOct 20, 2008
SKF IS RECALLING 2,805 HUB UNITS, PART NO. BR930361, SOLD AS A SERVICE PART FOR 1997-2004 DODGE DAKOTA VEHICLES AND 1999-2003 DODGE DURANGO VEHICLES EQUIPPED WITH 2-WHEEL DRIVE & REAR AXLE ABS. DUE TO A SPECIFICATION ERROR, THE ROTOR PILOT FOR THE HUB UNIT MAY BE TOO LONG. THIS RESULTS IN THE WHEEL TO NOT BE SEATED FULLY AGAINST THE HUB FLANGE FACE DURING MOUNTING.
IMPROPER SEATING OF THE WHEEL CAN RESULT IN EXCESSIVE VIBRATION, BRAKE ROTOR NOISE, DIFFICULTY REMOVING THE WHEEL AFTER INSTALLATION AND OPERATION OF THE VEHICLE, AND POSSIBLY WHEEL-END SEPARATION DURING VEHICLE OPERATION. SHOULD WHEEL-END SEPARATION OCCUR, THE DRIVER COULD LOOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH.
SKF WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE HUB UNITS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 5, 2008. OWNERS MAY CONTACT SKF VSM NORTH AMERICA CUSTOMER SERVICE AT 1-800-644-8999.
Campaign 08E064000 on NHTSA.gov
Power train, automatic transmission, lever and linkage, column shiftDec 4, 2007
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Campaign 07V555000 on NHTSA.gov
Electrical systemSep 7, 2006
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FRONT BENCH SEATS ONLY, IF FLUID IS SPILLED FROM THE FLOOR MOUNTED CUP HOLDER, AN UNUSED CONSOLE POWER OUTLET CONNECTOR LOCATED UNDER THE SEAT MAY BECOME CONTAMINATED.
THIS MAY ALLOW DEVELOPMENT OF A HIGH RESISTIVE SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
DEALERS WILL INSPECT THE CONSOLE WIRING CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT ADDITIONAL FLUID FROM CONTAMINATING THE CONNECTOR FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2006. OWNERS MAY CONTACT DAIMLER CHRYSLER AT 1-800-853-1403.
Campaign 06V339000 on NHTSA.gov
Engine and engine coolingMar 15, 2006
CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS WERE MANUFACTURED FROM APRIL 20, 1999, THROUGH SEPTEMBER 23, 2004. THESE ASSEMBLIES WERE MANUFACTURED AS REPLACEMENT EQUIPMENT FOR CERTAIN DODGE PICKUP TRUCKS AND SUVS. A SMALL PIECE OF MATERIAL FROM THE TUBE WALL COULD BE SUCKED INTO THE ENGINE THROTTLE BODY, WHICH COULD CAUSE THE THROTTLE TO BECOME JAMMED IN THE OPEN POSITION.
A JAMMED OPEN THROTTLE COULD CAUSE UNINTENDED ACCELERATION OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH OR INCREASED STOPING DISTANCES WHEN BRAKING.
K&N WILL PROVIDE OWNERS WITH A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS. THE RECALL BEGAN ON APRIL 20, 2006.
Campaign 06E024000 on NHTSA.gov
Suspension, front, control arm, upper ball jointDec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 04V596000 on NHTSA.gov
Visibility, windshield wiper/washerMay 5, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 04V216000 on NHTSA.gov
Representative owner complaints
434 reports, newest first.
Structure, Visibility/wiper, Jul 18, 2012
PURCHASED A USED 2002 DODGE DURANGO WITH 70K MILES. VEHICLE WAS UNDER LIMITED WARRANTY. DRIVERS POWER WINDOW FELL INTO THE DOOR AT HIGHWAY SPEED, NEARLY CAUSING AN ACCIDENT JUST FROM THE SHOCK. WENT TO DEALERSHIP, WAS TOLD IT WAS AN ELECTRICAL ISSUE, SO NOT UNDER WARRANTY. TOOK IT TO A PRIVATE MECHANIC, $500 TO REPLACE THE REGULATOR. A FEW MONTHS LATER, PASSENGER SIDE FAILS, TOOK IT TO A DIFFERENT DEALERSHIP, WAS TOLD IT WAS A PLASTIC PULLEY THAT FAILED, WOULD HAVE BEEN UNDER WARRANTY, BUT MY WARRANTY JUST EXPIRED. ANOTHER $500. DRIVER SIDE FAILED AGAIN A FEW MONTHS LATER, STARTED CALLING DODGE AND COMPLAINING, NOTHING THEY COULD DO THEY SAID. LEARNED HOW TO REPLACE MYSELF, 3 TIMES DRIVERS SIDE REAR REGULATOR, 2 TIMES PASSENGER REAR REGULATOR, 3 TIMES DRIVERS FRONT, 2 TIMES PASSENGER FRONT. NOW THREE ARE BROKEN AGAIN, THE REPLACEMENT PART IS THE SAME PLASTIC JUNK. I AM TIRED OF REPLACING THEM. DODGE HAS TOLD ME THAT IT HAS BEEN TO LONG AND THEY WILL NOT BE ABLE TO ASSIST ME, BUT CAN SELL ME THE PARTS...AGAIN.. I HAVE BEEN TOLD THAT COLD WEATHER, SLAMMING THE DOORS, OVER USE OF WINDOWS, COULD ALL BE CONTRIBUTING ISSUES. IN OTHER WORDS, HUMAN ERROR. THIS IS NOT THE CASE IN MY GARAGED FULL LEATHER SHOWROOM QUALITY VEHICLE. GOOGLE DODGE WINDOW REGULATORS, YOU WILL FIND PAGES OF COMPLAINTS. WISH I WOULD HAVE BOUGHT A CAR THAT DOESNT NEED TO BE AT 86 DEGREES CONSTANTLY, THAT COULD GO DOWN A BUMPY ROAD, THAT I COULD ROLL DOWN THE WINDOWS MORE THAN TWICE A DAY (BECAUSE THAT IS WHAT THEY RECOMMEND), COULD SHUT THE DOORS WITHOUT FEAR OF SLAMMING THEM, DIDNT HAVE TAPE ON THE WINDOWS TO HOLD THEM UP, COULD GO THROUGH A DRIVE THROUGH WITH MY DOOR CLOSED, AND DIDNT COST ME OVER $3000 IN WINDOW PARTS. THIS IS A SAFETY ISSUE AS YOU WILL FIND IF YOUR GOING DOWN THE HIGHWAY AND YOUR WINDOW INSTANTLY FALLS INTO YOUR DOOR. SHAME ON DODGE FOR NOT MAKING THIS ISSUE RIGHT. *TR
Exterior lighting, Apr 27, 2012
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT ALL OF THE LIGHTS ON THE VEHICLE FLICKERED ON AND OFF SPORADICALLY. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER OR A MECHANIC, BUT BELIEVED THAT THE FAILURE WAS SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 02V322000). THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE 160,000.
Engine and engine cooling, Mar 27, 2012
VEHICLE LOOSES OIL PRESSURE OFTEN AND TIMING CHAINS AND GEARS FROM FACTORYARE NO GOOD! *TR
Engine and engine cooling, Mar 14, 2012
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. WHILE DRIVING APPROXIMATELY 10 MPH AND APPROACHING A TRAFFIC STOP, THE VEHICLE STALLED WITHOUT WARNING. THE ENGINE WAS RESTARTED AND THE VEHICLE RESUMED NORMALLY. THE FAILURE RECURRED WHENEVER THE ENGINE WAS IDLED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FAILURE WAS CONTRIBUTED TO THE IDLE AIR CONTROL VALVE, WHICH WAS REPLACED. THE FAILURE CONTINUED TO OCCUR AFTER THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
Suspension, Feb 8, 2012
STARTED HEARING NOISES UNDER MY GAS, BRAKE PEDALS. BIG KNOCKING NOISES. FOUND OUT ABOUT A RECALL THAT MY TRUCK NEEDED REGARDING THE BALL JOINTS THAT COULD CAUSE THEM TO BRAKE AND LOSE THE TIRES. WHEN TO THE DEALERSHIP AND WAS TOLD THAT I HAD PASSED THE MILEAGE OF 100,000, AND WOULD HAVE TO PAY OUT OF POCKET. IT WAS ONLY 2463 MILES OVER. I THOUGHT RECALLS DON'T HAVE A TIME LIMIT TO GET FIXED? SO NOW I HAD TO FIND A CAR SHOP TO FIX BOTH BALLJOINTS, ON BOTH SIDES. TO TOP IT OFF THE RIGHT SIDE NEEDED A NEW HUB ACCESSORY REPLACED ALSO THAT I AGAIN HAD TO PAY ON MY OWN. WHY ARE SO MANY THINGS GOING WRONG NOW? AND BY READING ONLINE I'M NOT THE ONLY ONE WITH THESE SAME ISSUES. *TR
Electrical system, Exterior lighting, Feb 8, 2012
DRIVING TO SCHOOL IN THE MORNING, ALL LIGHTS INSIDE AND OUT STARTED FLICKERING. TURNED THEM OFF, BUT THE HEADLIGHTS STAYED ON HIGHBEAMS THE WHOLE TIME WHILE STILL FLICKERING. ALARM ALSO STOPPED WORKING. ON THE DRIVE BACK THE HIGHBEAMS STAYED ON AGAIN THE WHOLE TIME EVEN WHEN ITS ON OFF SWITCH. INSIDE LIGHTS WON"T STAY ON. WHEN I TURN THE CAR ON THE DARN LIGHTS WILL NOT TURN OFF. DOING MY RESEARCH IT SEEMS THAT ITS THE CTM, AND ALOT OF PEOPLE HAVE HAD THAT EXPERIENCE. I HAVE 3 CHILDREN, WHAT IF MY LIGHTS FLICKER OFF AGAIN AND CAUSE AN ACCIDENT? *TR
Power train, Jan 27, 2012, fire
TRANSMISSION AND POWER TRAIN BROKE. PIECES OF IT WERE LATER FOUND ON THE ROAD. TRANSMISSION MELTED AND CAUGHT FIRE, AND LATER THE WHOLE VEHICLE WAS ENGULFED IN FLAMES AND SMOKE. BY THE TIME FIREFIGHTERS HAD ARRIVED , THE WHOLE VEHICLE FRONT WAS BURNT DOWN. THE VEHICLE WAS TOTALED. *TR
Engine and engine cooling, Jan 22, 2012, crash
I WAS COMING DOWN A DRIVEWAY FROM A STORE AND I ATTEMPTED TO STOP BEHIND ANOTHER VEHICLE WHEN I APPLIED MY BRAKES AND MY DURANGO LUNGED FORWARD TOWARDS THE OTHER VEHICLE AND IT DID IT TWICE BUT THE SECOND TIME I HAD BOTH MY FEET ON THE BRAKES AND I HIT THE OTHER VEHICLE.I HAVE NEW TIRES AND BRAKES AND ALSO THE PAVEMENT WAS WET BUT IT DID NOT SLIDE. IT WAS LIKE THE ACCELERATOR STUCK OR SOMETHING. MY WORRY IS THAT I COULD HIT A PEDESTRIAN NEXT TIME THIS HAPPENS. I HAD NO DAMAGE TO MY DURANGO BUT THERE WAS DAMAGE TO THE OTHER VEHICLE. THIS IS THE FIRST ACCIDENT I'VE HAD IN YEARS AND I HAD A GOOD DRIVING RECORD UNTIL NOW. *TR
Power train, Jan 9, 2012
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE VEHICLE COULD NOT BE SHIFTED OUT OF PARK. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS CONTACTED AND CONFIRMED THAT THE VIN DID NOT QUALIFY FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 07V555000 (POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 178,433.
Engine and engine cooling, Dec 24, 2011, fire
WHILE DRIVING A BURNING ODOR COULD BE DETECTED FROM INSIDE THE CABIN. SO I PULLED OVER TO CHECK THE ENGINE AND NO IMMEDIATE PROBLEM COULD BE SEEN. AFTER DRIVING FOR TWO BLOCKS I NOTICE THAT THE ODOR WAS GETTING STRONGER AND SMOKE WAS COMING FROM THE ENGINE. I PULLED OVER ONCE MORE OPEN THE HOOD. UPON FURTHER INSPECTION I NOTICE FLAME AT THE FIRE WALL WITHIN SECONDS THE WHOLE ENGINE COVERED IN FLAMES. *TR
Electrical system, Visibility, Dec 12, 2011
WHILE STOPPED AT AN INTERSECTION, THE AIR CONDITIONER/HEATER BLOWER MOTOR CEASED TO OPERATE IN ALL RANGES EVEN THOUGH THE A/C WAS ON AND THE COMPRESSOR CLUTCH WAS ENGAGED. ON INSPECTION, IT WAS OBSERVED THAT THE FIRST TWO PINS OF THE RESISTOR BLOCK WERE MELTED AS WAS THEIR CORRESPONDING SOCKETS IN THE PLUG. FURTHER, THE WIRING AT THE PLUG WAS SEVERELY OXIDIZED AND THE INSULATION WAS MELTED BACK. I REPLACED THE PLUG ASSEMBLY AND RESISTOR BLOCK. THE RESISTOR BLOCK HAD BEEN REPLACED THREE YEARS PRIOR WHEN THE LOWEST BLOWER SETTING CEASED TO OPERATE. INTERNET ACCOUNTS OCCUR FREQUENTLY ON THIS ISSUE. THIS CREATES A COLD WEATHER HAZARD AS THE DEFROSTER WILL CEASE TO OPERATE CREATING A DANGEROUS OPERATING CONDITION. TOTAL COST OF REPAIR MATERIALS WAS APPROXIMATELY $125.00. *TR
Electrical system, Visibility, Nov 14, 2011
BEGINNING OCTOBER OF 2010 MY HEATER WENT OUT IN MY 2002 DODGE DURANGO. WE REPLACED THE WIRING HARNESS, THE RESISTER, AND THE BLOWER MOTOR. THE CONNECTION BETWEEN THE RESISTER AND THE WIRING HARNESS, CONTINUES TO MELT THE FIRST TWO PRONGS. IN RESULT THE HEATER SLOWLY GOES OUT ONE SETTING AT A TIME, AS WELL AS NO HEAT, JUST COOL AIR BLOWS IN THE REAR. AFTER REPLACING ALL THREE PARTS IT WORKS FOR ABOUT A MONTH BEFORE EVERYTHING STARTS TO FRY AGAIN. AFTER SPENDING A $100.00/MO FOR REPLACEMENT PARTS AND THE EXPENSE OF SERVICE, I'M EXTREMELY FRUSTRATED AND BROKE. AFTER MUCH RESEARCH ON THE INTERNET I COME TO FIND THAT I AM NOT THE ONLY ONE WITH THIS COMPLAINT. GOING WITHOUT A HEATER OR DEFROST IN THE MIDDLE OF WINTER IN MINNESOTA IS NOT AN OPTION, ESPECIALLY WITH LITTLE CHILDREN AND IT GOES OUT AS YOUR STOPPED AT A LIGHT AND YOUR WINDOW FOGS UP AND CAN'T SEE A THING. I HOPE WITH MUCH CONSIDERATION THAT THIS MATTER COULD BE ATTENDED TOO. *TR
Engine and engine cooling, Sep 15, 2011
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE OVERHEATED WHILE DRIVING 30 MPH. THERE WAS COOLANT LEAKING FROM THE RESERVOIR AND THE TEMPERATURE ERRATICALLY RACED TO HOT. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THEY REPLACED THE THERMOSTAT AND THE RADIATOR PRESSURE CAP. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THAT THERE WERE NO RECALLS FOR THE FAILURE AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 86,000.
Engine and engine cooling, Aug 9, 2011
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT WAS DRIVING 25 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING, APPROXIMATELY EIGHT TIMES. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC FOR DIAGNOSTIC TESTING BUT THE MECHANIC WAS UNABLE TO PRODUCE ANY FAILURE CODES. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 114,000.
Power train, Jul 1, 2011
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT SHE WAS UNABLE TO SHIFT THE VEHICLE INTO PARK, BUT WAS ABLE TO REMOVE THE KEY FROM THE IGNITION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 07V555000 (COMPONENT: POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 130,000.
Electrical system, May 16, 2011
TL*THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT ALL OF THE VEHICLE INTERIOR LIGHTS, THE INSTRUMENT PANEL LIGHTS, THE WINDSHIELD WIPERS AND THE POWER LOCKS WERE NOT WORKING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE COMPUTER MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 107,305.
Suspension, Apr 28, 2011
FRONT END MAKES A REALLY BAD NOISE BACKING UP AND THEN GOING FORWARD. SOUNDS AS IF THERE IS A POPPING NOISE GOING ON AND RIPPLING EFFECT SUCH AS..EXAMPLE IF YOU PUT A CLOSE PIN ON A BICYCLE TIRE TO GET IT TO MAKE NOISE. I'VE HAD IT LOOKED AT BY A DEALER AND A GARAGE AND BOTH SEEM TO CANT ANY THING WRONG WITH IT .THIS HAS BEEN GOING ON FOR THE LAST 3 YEARS NOW....CAN IT BE THE BALL JOINTS? *TR
Wheels, Apr 28, 2011
HAD TO MAKE A SUDDEN STOP AND ABS SYSTEM WAS DANGEROUSLY SLOW TO ENGAGE, RELEASE AND RE-ENGAGE. BRAKE PEDAL WENT ALL THE WAY DOWN TO THE FLOOR AND BARELY STOPPED BEFORE HITTING VEHICLE IN FRONT OF ME. HAVE REPLACE ALL CALIPERS AND PADS BOTH FRONT AND BACK. STILL HAVING PROBLEMS ...I DRIVE DAILY BACK AND FORTH TO WORK AND MOST OF THE TIME I HAVE TO START BRAKING WAY BEFORE I GET TO A STOP. *TR
Suspension, Mar 18, 2011, crash
REAR LEFT AXEL FELL OFF MY DODGE DURANGO AND CAUSED AN ACCIDENT. I WAS TRYING TO GET CHRYSLER TO GIVE ME A COPY OF THE INSPECTION THAT WAS DONE BY A INSPECTOR HIRED BY AND WAS DENIED. THIS MODEL OF SUV HAS HAD WHEEL PROBLEMS IN THE PAST AND I WANTED TO BE SURE IT WAS NOT A DEFECT. I WAS TOLD THE INFORMATION IS PROPRIETARY AND I WOULD LEGAL DOCUMENTATION TO GET THE INSPECTORS REPORT. THE CASE #"S ARE: [XXX] AND [XXX]. I ALSO SAVED ALL EMAILS REGARDING THIS PROBLEM. I CAN EMAIL THEM TO YOU OR MAIL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Power train, Mar 8, 2011
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE WOULD EXHIBIT AN ABNORMAL RUMBLING. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES BUT WAS NEVER ABLE TO DUPLICATE THE FAILURE. MOST RECENTLY, THE CONTACT WAS INFORMED BY THE DEALER THAT THE FAILURE WAS CAUSED BY THE REAR DIFFERENTIAL, AFTER THE WARRANTY WAS EXPIRED. THE CONTACT BELIEVED THE FAILURE TO BE AN EXTREME SAFETY ISSUE BECAUSE THE VEHICLE COULD HAVE SLAMMED TO A STOP IN A DANGEROUS SITUATION AND THE MANUFACTURER DENIED THE FAILURE UNTIL AFTER THE WARRANTY EXPIRED. THE FAILURE AND CURRENT MILEAGE WAS 62,000.
Suspension, Feb 10, 2011
TL*THE CONTACT OWNS A 2002 DODGE DURANGO. WHILE DRIVING APPROXIMATELY 10 MPH THE CONTACT HEARD A GRINDING NOISE. THE PASSENGER SIDE OF THE VEHICLE DROPPED TO THE GROUND AND THE TIRE CAME OFF OF THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TECHNICIANS STATED THAT THE SUSPENSION FRONT CONTROL ARM UPPER BALL JOINT HAD SEPARATED. THE TECHNICIANS ALSO STATED THAT THE FRONT CONTROL ARM UPPER BALL JOINT, SWAY BAR, BRAKE PADS, SUSPENSION CROSS BAR, WHEEL, BRAKES AND CALIPERS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THERE WAS A RECALL NHTSA CAMPAIGN ID NUMBER: 04V596000 (SUSPENSION FRONT:CONTROL ARM:UPPER BALL JOINT) BUT THE DEALER INFORMED HER THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS CONTACTED AND STATED THEY WOULD COVER A PORTION OF THE REPAIRS BUT THEY COULD NOT COVER THE ENTIRE COST. THE APPROXIMATE FAILURE MILEAGE WAS 142,299. UPDATED 02/18/11 *BF PHOTOS INCLUDED UPDATED 12/06/2011 *LN
Power train, Air bags, Feb 1, 2011
TL*THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED IT ROLLED AWAY AND CRASHED INTO THE SIDEWALK. THE DRIVER AND PASSENGER AIR BAGS DEPLOYED. THE VEHICLE WAS DRIVEN TO A LOCAL MECHANIC. THE VEHICLE WAS EXAMINED BY AN ENGINEER WHO WAS UNABLE TO DIAGNOSE A FAILURE CODE, OR RECREATE THE REASON WHY THE VEHICLE ROLLED OUT OF THE PARK POSITION. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 141,000.
Electrical system, Dec 3, 2010
I HAVE A 2002 DODGE DURANGO SPORT WITH 123K MILES. I WAS DRIVING 70 MPH ON THE FREEWAY, WHEN MY CAR COMPLETELY SHUT DOWN....I.E. POWER STEERING, POWER BRAKES, EVERYTHING. DUE TO THE FACT THAT I COULD HARDLY TURN OFF THE ROAD I WAS NEARLY REAR ENDED BY AN 18 WHEELER. I HAD 2 SMALL CHILDREN IN THE VEHICLE WITH ME, AND IT WAS ONE OF THE MOST TERRIFYING EXPERIENCES OF MY LIFE. I HAVE READ ONLINE THOUSANDS OF PEOPLE HAVING THE SAME ISSUES, WHICH ARE APPARENTLY THE PCM IS TOO CLOSE THE ENGINE WHICH CAUSES THE VEHICLES INSTRUMENTS TO SHUT DOWN. I FIND THIS A MAJOR REASON TO INVESTIGATE THIS ISSUE. DOES CHRYSLER/DODGE NEED A WHOLE FAMILY TO DIE IN ONE OF THEIR VEHICLES BEFORE THEY DECIDE TO ISSUE A RECALL? THIS IS A VERY SERIOUS ISSUE THAT THE NHTSA NEEDS TO INVESTIGATE BEFORE, IF IT HASN'T HAPPENED YET, SOMEONE GETS KILLED. *TR
Suspension, Power train, Nov 22, 2010
TL*THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT WHILE DRIVING 10-15 MPH, HE HEARD A NOISE. WHEN THE VEHICLE WAS TAKEN TO LOCAL REPAIR SHOP, THE CLUTCH PACK RETAINING CLIP ON THE REAR DIFFERENTIAL WAS REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000. UPDATED 1/21/11 *CN THE CLUTCH PACK RETAINER FAILED AND HAD TO BE REPLACED AS WELL AS THE ENTIRE REAR DIFFERENTIAL POST UNIT. UPDATED 03/23/11
Suspension, Engine and engine cooling, Air bags, Oct 26, 2010
TL*THE CONTACT OWNS A 2002 DODGE DURANGO. THE AIR BAG LIGHT AND THE CHECK ENGINE REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE AIR BAG FAILURE. THE DEALERS DIAGNOSIS LOCATED THE FAILURE TO THE AIR BAG SENSOR ELECTRICAL WIRES. NO CODES WERE DISPLAYED REGARDING THE CHECK ENGINE LIGHT. THE VEHICLE WAS TAKEN TO A TIRE GARAGE, BECAUSE THE FRONT TIRES FELT UNSTABLE WHILE DRIVING. THE TIRE MECHANIC STATED THE FRONT HUB CAP CAUSED THE VEHICLE TO FEEL UNSTABLE WHILE DRIVING. THE VEHICLE WASN'T REPAIRED. THE MANUFACTURER WILL BE CONTACTED. THE FAILURE MILEAGE WAS 21,000 AND THE CURRENT MILEAGE WAS 73,000.