2002 Dodge Durango
Problems, recalls and owner-reported issues
Suspension is the leading concern among 434 owner complaints filed for this model year. This is the 11th highest complaint count among 25 Durango model years with reports.
Of the 2002 reports, 38 involved a crash and 13 involved a fire. 40 people were injured and 3 people died.
What owners report most often
Recalls and investigations
Suspension, front, hubOct 20, 2008
SKF IS RECALLING 2,805 HUB UNITS, PART NO. BR930361, SOLD AS A SERVICE PART FOR 1997-2004 DODGE DAKOTA VEHICLES AND 1999-2003 DODGE DURANGO VEHICLES EQUIPPED WITH 2-WHEEL DRIVE & REAR AXLE ABS. DUE TO A SPECIFICATION ERROR, THE ROTOR PILOT FOR THE HUB UNIT MAY BE TOO LONG. THIS RESULTS IN THE WHEEL TO NOT BE SEATED FULLY AGAINST THE HUB FLANGE FACE DURING MOUNTING.
IMPROPER SEATING OF THE WHEEL CAN RESULT IN EXCESSIVE VIBRATION, BRAKE ROTOR NOISE, DIFFICULTY REMOVING THE WHEEL AFTER INSTALLATION AND OPERATION OF THE VEHICLE, AND POSSIBLY WHEEL-END SEPARATION DURING VEHICLE OPERATION. SHOULD WHEEL-END SEPARATION OCCUR, THE DRIVER COULD LOOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH.
SKF WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE HUB UNITS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 5, 2008. OWNERS MAY CONTACT SKF VSM NORTH AMERICA CUSTOMER SERVICE AT 1-800-644-8999.
Campaign 08E064000 on NHTSA.gov
Power train, automatic transmission, lever and linkage, column shiftDec 4, 2007
ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Campaign 07V555000 on NHTSA.gov
Electrical systemSep 7, 2006
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH FRONT BENCH SEATS ONLY, IF FLUID IS SPILLED FROM THE FLOOR MOUNTED CUP HOLDER, AN UNUSED CONSOLE POWER OUTLET CONNECTOR LOCATED UNDER THE SEAT MAY BECOME CONTAMINATED.
THIS MAY ALLOW DEVELOPMENT OF A HIGH RESISTIVE SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
DEALERS WILL INSPECT THE CONSOLE WIRING CONNECTOR FOR CORROSION, CLEAN AS REQUIRED, AND INSTALL A CAP TO PREVENT ADDITIONAL FLUID FROM CONTAMINATING THE CONNECTOR FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 30, 2006. OWNERS MAY CONTACT DAIMLER CHRYSLER AT 1-800-853-1403.
Campaign 06V339000 on NHTSA.gov
Engine and engine coolingMar 15, 2006
CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS WERE MANUFACTURED FROM APRIL 20, 1999, THROUGH SEPTEMBER 23, 2004. THESE ASSEMBLIES WERE MANUFACTURED AS REPLACEMENT EQUIPMENT FOR CERTAIN DODGE PICKUP TRUCKS AND SUVS. A SMALL PIECE OF MATERIAL FROM THE TUBE WALL COULD BE SUCKED INTO THE ENGINE THROTTLE BODY, WHICH COULD CAUSE THE THROTTLE TO BECOME JAMMED IN THE OPEN POSITION.
A JAMMED OPEN THROTTLE COULD CAUSE UNINTENDED ACCELERATION OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH OR INCREASED STOPING DISTANCES WHEN BRAKING.
K&N WILL PROVIDE OWNERS WITH A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS. THE RECALL BEGAN ON APRIL 20, 2006.
Campaign 06E024000 on NHTSA.gov
Suspension, front, control arm, upper ball jointDec 21, 2004
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 04V596000 on NHTSA.gov
Visibility, windshield wiper/washerMay 5, 2004
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Campaign 04V216000 on NHTSA.gov
Representative owner complaints
434 reports, newest first.
Visibility, Aug 10, 2010
TL*THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT THE BLOWER MOTOR RESISTOR WAS DEFECTIVE. THE CONTACT REPLACED THE PART THREE TIMES AND IT ALSO AFFECTED THE WIRING HARNESS. THE WIRING HARNESS WAS BEING REPLACED BY THE OWNER. THE FAILURE CAUSED THE AIR CONDITIONER FAN TO MALFUNCTION. DODGE WAS AWARE OF THE FAILURE BUT THERE WERE NO RELATED RECALLS. THE FAILURE MILEAGE WAS APPROXIMATELY 42,000. THE CURRENT MILEAGE WAS APPROXIMATELY 96,000.
Steering, Suspension, Aug 3, 2010
I WAS MAKING A RIGHT HAND TURN AND THEN AN IMMEDIATE LEFT AT ABOUT 10MPH I HEARD A POP ON DRIVER'S SIDE FRONT WHEEL AND THEN LOST CONTROL OF MY CAR. I WAS ABLE TO REGAIN CONTROL OF MY CAR BUT IT WOULD NOT TURN TO THE LEFT I WAS ABLE TO GET THE CAR TO SIDE OF THE ROAD EVEN THOUGH STEERING WAS EXTREMELY DIFFICULT. I CHECKED THE TIRE IT WAS FULLY INFLATED BUT THE TOP OF TIRE WAS TILTED OUT AT THE TOP I COULD NOT DRIVE THE VEHICLE ANY MORE DUE STEERING DIFFICULTIES. I CALLED A TOW TRUCK AND HAD THE CAR TOWED TO MECHANIC. I WAS TOLD BY TOW TRUCK OPERATOR AND THE MECHANIC THAT THE UPPER BALL JOINT ON ARM HAD SEPARATED FROM THE ARM CAUSING ME TO LOSE CONTROL OF THE CAR. A FRIEND STATED THAT DURANGO HAD BEEN RECALLED FOR THIS ISSUE. I CONTACTED MY MECHANIC AND HE IN TURN CONTACTED DODGE. HE WAS INFORMED THAT THERE WAS NO RECALL FOR MY CAR. I CHECKED YOUR WEBSITE AND SAW THAT OTHER DURANGO HAD IN FACT BEEN RECALLED FOR THIS EXACT ISSUE. I CONTACTED DODGE AND WAS ALSO INFORMED THAT THERE WAS NOTHING THEY COULD DO BECAUSE MY DURANGO WAS NOT A PART OF THE RECALL. I HAD MY MECHANIC FIX THE UPPER BALL JOINT. I HAD THEM CHECKED THE UPPER BALL JOINT ON THE OTHER SIDE AND IT WAS ALSO COMING OUT. I HAD TO PAY TO HAVE BOTH UPPER BALL JOINTS REPLACED ON THE FRONT END OF MY CAR. *TR
Suspension, Power train, Jul 22, 2010
THE FRONT SUSPENSION IS HAVING MULTIPLE PROBLEMS, MY 02 DURANGO HAS BEEN THROUGH 2 PREVIOUS CV JOINTS ON THE DRIVER'S SIDE AND 1 PREVIOUS ON THE PASSENGER SIDE, AND NOW BOTH HAVE FAILED ONCE AGAIN. DRIVER'S SIDE FRONT HUB ASSEMBLY/BEARING HAS GONE BAD FOR 2ND TIME, ALSO THE UPPER & LOWER BALL JOINTS HAVE GONE BAD FOR THE 2ND TIME EACH. I NEED 2 NEW LOWER BACK BUMPERS FOR THE UPPER CONTROL ARM (BOTH FRONT). MY VEHICLE NOW HAS 103K MILES. AT APPROXIMATELY 60K MILES THE FRONT PROPELLER SHAFT WENT BAD AND ONCE REPLACED, IT SOMEHOW PUT A HOLE IN THE Y - PIPE FOR THE EXHAUST, AND THAT MUST BE REPLACED AS WELL, I WAS TOLD THE NEW/AFTERMARKET SHAFT WERE SLIGHTLY LARGER TO ACCOMMODATE THE POWER, THUS WHICH TOOK THE SPACE. ALL OF THIS WILL BE QUITE EXPENSIVE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Vehicle speed control, Jul 8, 2010
TL*THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED THAT ONE MONTH AGO THE RPMS INCREASED TO 2000 WHILE THE VEHICLE WAS IN PARK AND RECURRED WHEN IT WAS IN DRIVE. THE VEHICLE ACCELERATED WITHOUT DRIVER INTENT EVEN WHEN HIS FOOT WAS ON THE BRAKE PEDAL. THE CONTACT WAS ADVISED THAT THE THROTTLE SENSOR NEEDED TO BE CLEANED WHICH TEMPORARILY CORRECTED THE FAILURE. CHRYSLER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 99, 687.
Engine and engine cooling, Jun 22, 2010
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED WHEN DRIVING BELOW 50 MPH WITH THE AIR CONDITIONING ACTIVATED, THE VEHICLE WOULD CONTINUOUSLY OVERHEAT. THE CONTACT STATED THE HEAD GASKET WAS DEFECTIVE AND CAUSING THE FAILURE BUT THE VEHICLE WAS NOT DIAGNOSED BY THE DEALER. THE DEALER ADVISED THE VEHICLE WOULD NEED TO BE DIAGNOSED AT THE OWNER'S EXPENSE BEFORE ANY REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 90,000.
Service brakes, Hydraulic, Jun 7, 2010
CONTINUED PROBLEM WITH BRAKING SYSTEM. HAVE HAD BRAKES REPLACED THREE TIMES IN 80K MILES. ONCE THE BRAKES SEIZED ON THE ROAD ( WAS STOPPED BY TROOPER DUE TO SMOKE) AND HAD TO BE TOWED. RECENTLY SIMILAR, PRECURSOR SYMPTOMS TO SEIZING BEGAN AGAIN, THEY WERE CONFIRMED BY MY DEALERSHIP AND THE ENTIRE FRONT BRAKING SYSTEM HAD TO BE REPLACED. THIS IS THE SECOND DODGE TRUCK/VAN THAT I HAVE OWNED THAT HAS HAD THIS PROBLEM. MY PREVIOUS VEHICLE HAD TO BE TOWED THREE TIMES AFTER THE BRAKES SEIZED. SEEMS TO AFFECT TRUCKS/VANS WITH 16" DIA WHEELS SINCE I HAVE OWNED OTHER CHRYSLER PRODUCTS WITHOUT THIS PROBLEM. THE MAINTENANCE MANAGER'S RESPONSE TO MY COMPLAINT ABOUT THE FOURTH MAJOR BRAKING PROBLEM WITH THIS VEHICLE WAS "NO CAR IS PERFECT". I FULLY UNDERSTAND THAT NOTHING IS PERFECT, BUT IF YOU CAN'T GET THE BRAKING SYSTEM RIGHT YOU SHOULDN'T BE SELLING CARS. IN MY MIND THAT'S THE BRAKING SYSTEM IS THE NUMBER ONE SAFETY PRIORITY ON A VEHICLE. *TR
Exterior lighting, May 25, 2010
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. THE CONTACT STATED WHILE STOPPED IN TRAFFIC WITH THE BRAKES ENGAGED, THE BRAKE LIGHTS WERE NOT ILLUMINATED. THERE WERE NO WARNING LIGHTS ILLUMINATED INDICATING THE BRAKE LIGHTS HAD FAILED. THE CONTACT STATED HE HAD EXPERIENCED THE FAILURE AT LEAST FOUR TIMES AND THE TAIL LIGHT ASSEMBLY WAS REPLACED EACH TIME. THE FAILURE WOULD OCCUR DUE TO THE BRAKE LIGHTS BECOMING TOO HOT AND SOFTENING THE PLASTIC LENS. THIS WOULD CAUSE THE ELECTRICAL CONTACT WITH LAMP TERMINALS . THE FAILURE MILEAGE WAS 35,000 AND THE CURRENT MILEAGE WAS 121,458. UPDATED 8/2/10 *CN UPDATED 08/09/10*JB
Suspension, Service brakes, Hydraulic, Electrical system, Apr 20, 2010, crash
I WAS IN AN ACCIDENT BECAUSE THE 2002 DODGE DURANGO'S BRAKES DID NOT WORK AND THE ABS AND BRAKE LIGHT CAME ON. THIS WAS THE SCARIEST THING I HAVE EVER EXPERIENCED. I HAVE HAD IT CHECKED BY AUTO ZONE, DODGE DEALER, LOCAL MECHANIC...AND NO ANSWERS. THE BRAKES LITERALLY WENT TO THE FLOOR. I HAVE 3 CHILDREN AND HAVE NO OTHER CHOICE BUT TO DRIVE THIS DEATH TRAP. I HAVE ALSO HAD PROBLEMS WITH THE BALL JOINTS/ ELECTRICAL ISSUES. I HAD THE ABS FUSE PULLED, BUT NOT SURE IF THIS IS A SOLUTION. HAS THERE BEEN OTHER COMPLAINTS OF BRAKE FAILURE IN THESE VEHICLES. *TR
Engine and engine cooling, Equipment, Apr 6, 2010
WHILE DRIVING HOME ON MARCH 12, 2010 MY 2002 DODGE DURANGO SLT BEGAN TO OVERHEAT AND IT SHUT DOWN ON ME. I CALLED AND HAD MY CAR TOWED TO A MECHANIC WHO INSPECTED THE CAR. HE STATED THE ENGINE WILL NEED TO BE REPLACED DUE TO THE OIL SLUDGE WHICH CAUSED THE ENGINE TO OVERHEAT LEADING TO ENGINE FAILURE. PRIOR TO THIS INCIDENCE THE MAINTENANCE WAS WELL DONE AND THERE WAS NO SIGNALS WHICH WOULD HAVE ALARMED ME THAT A PROBLEM WAS OCCURRING. IT IS ALARMING TO ME SEE THOUSANDS OF OTHER CONSUMERS WHO HAS EXPERIENCED THE SAME PROBLEM WHICH GOES TO SHOW THAT MY INCIDENT WAS NO AN ISOLATED ONE. *TR
Service brakes, Hydraulic, Traction control system, Mar 10, 2010
I HAVE A 2002 DODGE DURANGO. IT HAS REAR ANTILOCK BRAKES. I HAVE HAD NUMEROUS CLOSE CALLS IN HARD STOP SITUATIONS WHERE THE WHEELS LOCK UP AND THE VEHICLE SLIDES FORWARD. I HAVE TAKEN IT TO A BRAKE SPECIALIST WHO AGREED AFTER A TEST RIDE THERE WAS A SERIOUS PROBLEM BUT SAID I NEEDED TO GET THE DEALER INVOLVED. I HAVE TAKEN IT TO SEVERAL DODGE DEALERS OVER A PERIOD OF ABOUT FOUR YEARS. THEY HAVE MADE SEVERAL RECOMMENDATIONS TO WHICH I HAD THE SERVICE DONE AND IT MADE NO DIFFERENCE. NOW THEY KEEP TELLING ME THERE IS NOTHING WRONG. I GOT DODGE REGIONAL INVOLVED LAST YEAR. THEY TOLD ME TO TAKE IT BACK TO THE DEALER AND HAVE THEM CHECK IT OUT. THE DEALER SAID THAT THE ABS WAS ENGAGING EARLY BUT DID NOTHING TO CORRECT THE PROBLEM. I RECENTLY REACHED DODGE REGIONAL AGAIN. HE SAYS HE TALKED TO THE SERVICE MANAGER AT THE DEALERSHIP WHO TOLD HIM THEY RECOMMENDED THE ROTORS BE REPLACES AND I REFUSED. I TOLD HIM THAT WAS A LIE THAT I HAD THE ROTORS AND PADS REPLACED. DODGE REGIONAL SAID THERE WAS NOTHING HE COULD DO TO HELP. HE SAID THE SERVICE MANAGER RECOMMENDED I BRING THE CAR IN FOR INSPECTION AGAIN AT ANOTHER $90. I TOLD HIM I REFUSE TO KEEP PAYING THESE FEES TO HAVE THEM TELL ME THERE'S NOTHING WRONG. I THEN PUT IN A CALL TO THE SERVICE MANAGER AT THE DEALER AND LEFT HIM A DETAILED MESSAGE ASKING HIM TO PLEASE RETURN MY CALL. HE NEVER RETURNED MY CALL. I HAVE ATTEMPTED TO REACH DODGE REGIONAL FOR THE LAST FEW DAYS AND HIS PHONE JUST RINGS WITH NO VOICEMAIL PICKING UP. I AM OUT OF IDEAS AND PATIENCE. I LOVE MY VEHICLE BUT IT IS A SEVERE HAZARD. IT SEEMS AS THOUGH ONCE AGAIN NOTHING WILL HAPPEN UNTIL SOMEONE IS KILLED OR SERIOUSLY INJURED BEFORE ANYTHING GETS DONE. I HAVE PLENTY OF DOCUMENTATION WITH MY COMPLAINTS TO THE DEALERS AS BACKUP. I HOPE SOMEONE THERE CAN HELP ME GET THIS PROBLEM RESOLVED. BY THE WAY, I KNOW ANOTHER PERSON WHO HAS THE SAME YEAR DURANGO AS ME AND SHE COMPLAINS OF THE SAME PROBLEM. *TR
Electrical system, Mar 6, 2010
EXTERIOR LIGHTS, INTERIOR LIGHTS, WIPERS, ALARM AND FAB STOPPED WORKING. THE CAR WOULD START, THE TURN SIGNALS WOULD WORK. IT JUST STOPPED WORKING ALL OF A SUDDEN. DEALERSHIP FOUND NOTHING WRONG AND SAID THE COMPUTER HAD RESET IT SELF. NOW IT IS DOING IT AGAIN. HAS HAPPENED TWICE. GOOD THING IT WASN'T AT NIGHT. HAVE TO TAKE IT BACK IN. *TR
Steering, Suspension, Equipment, Feb 25, 2010
I JUST FOUND OUT TODAY THAT I WILL NEED TO INSTALL A COMPLETELY NEW SET OF FRONT WHEEL BEARINGS, TIE RODS AND BALL JOINTS AFTER FACTORY RECALL. ACCORDING TO REPAIR SHOP THEY INSTALLED THE SAME FAULTY COMPONENTS TO REPLACE THE ONES THAT WERE RECALLED. I WAS TOLD THEY SHOULD HAVE INSTALLED THE CORRECT UNITS WITH GREASE FITTINGS, THEY DID NOT. GOING TO COST $980.00 TO REPAIR. *TR
Electrical system, Jan 28, 2010
PROBLEM 1. WHEN ENGINE IS WARM THE INSTRUMENT CLUSTER STARTS FLASHING ON AND OFF, ALSO ALL WARNING LIGHTS. IF THE ENGINE IS TURNED OFF A NO BUS SHOWS IN THE ODOMETER, VEHICLE WILL NOT START UNTIL THE PCM FEELS COOL TO THE TOUCH. THIS PROBLEM OCCURS DAILY TWO OR MORE TIMES PROBLEM 2. THE PASSENGER SEAT BELT UNBUCKLES BY ITSELF. THIS OCCURS EVERY DAY TW*
Engine and engine cooling, Equipment, Jan 12, 2010
I AM MAKING A COMPLAINT ABOUT THE 2002 DODGE DURANGOS. THE OIL PRESSURE KEEPS GOING LOW AND NOW THE ENGINE HAS BLOWN. IT WAS NOT TIME FOR AN OIL CHANGE AND WE KEEP OUR OIL CHANGED AS WE ARE SUPPOSE TO. THIS WOULD BE THE SECOND ENGINE WE WOULD HAVE PUT IN THIS VEHICLE BUT THE FIRST TIME IT WAS STILL COVERED UNDER THE MANUFACTURES WARRANTY AND WAS PAID FOR BY THEM BUT NOW THE WARRANTY HAS EXPIRED. *TR
Engine and engine cooling, Dec 9, 2009
TL* THE CONTACT OWNS A 2002 DODGE DURANGO. WHILE DRIVING 15 MPH THE VEHICLE STALLED WITHOUT ANY PRIOR WARNINGS. HE COULD NOT RESTART THE VEHICLE. HE CONTACTED THE MANUFACTURER AND THE DEALERSHIP , BUT WAS NOT PROVIDED WITH ANY ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED TO-DATE. THE CURRENT AND FAILURE MILEAGES WERE 141,016.
Electrical system, Jul 13, 2009
WHEN IT IS HOT OUTSIDE THE 2002 DODGE DURANGO WILL NOT START. THE VEHICLE WILL ALSO LOSE POWER WHILE DRIVING DOWN THE ROAD AT 70 MILES PER HOUR, NO BRAKES, AND NO STEERING. THIS ALSO HAPPENS AFTER THE ENGINE IS HOT. SOME FUSES ON THE DRIVERS SIDE DASH COMPARTMENT CAN BE REMOVED AND PUT BACK IN (SAME FUSES, NOT BLOWN) AND THE VEHICLE WILL START. *TR
Suspension, Jul 3, 2009
WHEN I PURCHASED THIS CAR I HAD CONCERNS THAT IT HAD EITHER BEEN IN A ACCIDENT OR A FLOOD. I WROTE TO THE ATTORNEY GENERALS OFFICE, AND ASKED TO CANCEL MY CONTRACT BECAUSE I FELT THAT I HAD BEEN DECEIVED. I FELT THAT THERE WEREN'T ANY OTHER OPTIONS FOR ME, I WAS NOW STUCK WITH A LEMON, AND I HOPED AND PRAYED THAT THE CAR WOULD LAST UNTIL I COULD AFFORD TO PAY FOR IT. WHEN I PURCHASED TIRES , I WAS INFORMED THAT THE BALL JOINTS HAD COMPLETELY SHREDDED THE INSIDES OF MY TIRES ON THE FRONT END, AND HAD TO BE REPLACED IMMEDIATELY . I CONTACTED A DODGE DEALERSHIP AND WAS INFORMED THAT THE UPPER BALL JOINTS ON THE FRONT-END WERE RECALLED, AND REPLACED IN 2004, WHICH WAS TWO YEARS BEFORE I PURCHASED THE CAR IN 2006. I FEEL THAT SINCE DODGE HAS HAD THIS CAR ON MORE THAN TWO OCCASION BECAUSE OF THE FRONTEND, (THE DEALERSHIP WHICH REPAIRED THE CAR AFTER ACCIDENT HAS LOST THEIR LICENSE TO SERVICE DODGE VEHICLES) I WAS REGULARLY USING THIS VEHICLE TO DRIVE MY KIDS TO SCHOOL. I AM A SINGLE PARENT, AND CAN'T AFFORD TO HAVE THEIR DEFECT CORRECTED. I AM AFRAID TO DRIVE THE DURANGO LONG DISTANCE.. I HAVE WRITTEN A LETTER OF COMPLAINT WITH THE CHRYSLER OFFICE IN MICHIGAN, BUT HAVE NOT RECEIVED A RESPONSE. I HAVE ALSO ATTEMPTED TO REACH THE CUSTOMER SERVICE LINE WITH NO RESULTS. *TR
Electrical system, Jun 24, 2009
REAR WINDSHIELD WIPER RUNS ON AND ON AND ON....THEN SHUTS OFF, THEN WILL GO ON AGAIN EVEN IF YOU USE FOB TO UNLOCK DOORS! HEADLIGHTS NOW DON'T GO ON WHEN DESIRED, OR WILL STAY ON EVEN AFTER YOU TURN CAR OFF. FOUND THAT OTHERS WITH THIS YEAR & MODEL DURANGO HAVE SIMILAR PROBLEMS. ISSUE IS CTM (CENTRAL TIMER MODULE) WHICH SHOULD BE REPLACED AND NOT BY THE CONSUMER SO VERY OFTEN - BUT COULD CAUSE HAZARDOUS DRIVING CONDITIONS IF IT GOES WHEN YOU NEED TO USE THE LIGHTS. *TR
Steering, Apr 29, 2009
I WAS DRIVING MY 2002 DODGE DURANGO DOWN THE STREET AND ALL OF A SUDDEN MY STEERING COLUMN LOCKED ON ME. I COULD NOT TURN OR STEER THE VEHICLE. IT TOOK EVERY OUNCE OF STRENGTH TO FINALLY MOVE THE VEHICLE TO THE SIDE OF THE ROAD AND I AM A PRETTY BIG GUY. TOOK IT BACK TO THE DEALER WHERE I PURCHASED IT AND AFTER EXAMINING IT THEY TOLD ME THAT THE RACK AND PINION WAS SHOT. I JUST PURCHASED THE VEHICLE ABOUT 3 MONTHS AGO SO THEY TOLD ME IT WAS NO LONGER COVERED UNDER WARRANTY. I ENDED UP HAVING THEM REPLACE THE RACK AND PINION STEERING AND IT COST BE ABOUT $600.00. ITS A GOOD THING I WASN'T ON THE HIGHWAY GOING 65MPH WHEN THIS OCCURRED. *TR
Engine and engine cooling, Apr 25, 2009
EXHAUST MANIFOLD BOLTS KEEP BREAKING ON THE RIGHT AND LEFT REAR SIDES OF MY ENGINE. THIS HAS HAPPENED THREE TIMES SINCE I BOUGHT MY 2002 DODGE DURANGO 4.7 ENGINE. MY LOCAL DODGE DEALER TOLD ME THIS WAS A DESIGN FLAW BY DODGE AND THEY KNOW IT BUT WON'T DO ANYTHING TO FIX THIS PROBLEM. THIS CREATES AN EXHAUST LEAK THAT CAN SEND EXHAUST FUMES INTO THE PASSENGER COMPARTMENT THAT COULD CAUSE DEADLY PROBLEMS. *TR
Power train, Mar 23, 2009
TL*THE CONTACT OWNS A 2002 DODGE DURANGO. THE VEHICLE WOULD NOT RESPOND WHEN THE CONTACT ATTEMPTED TO SHIFT INTO PARK. HE HAD TO SHIFT INTO REVERSE IN ORDER TO TURN OFF THE VEHICLE. HE APPLIED THE EMERGENCY BRAKE TO KEEP THE VEHICLE FROM ROLLING AWAY. TO START THE VEHICLE, HE HAD TO SHIFT INTO NEUTRAL AND APPLY THE EMERGENCY BRAKE AGAIN TO KEEP THE VEHICLE FROM ROLLING AWAY. HE BELIEVED THERE MAY HAVE BEEN AN ISSUE WITH THE TRANSMISSION AND TOOK THE VEHICLE TO A LOCAL MECHANIC. THEY COULD NOT DETERMINE THE CAUSE OF THE FAILURE; HOWEVER, THEY STATED THAT IT WAS NOT DUE TO THE TRANSMISSION. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V555000 (POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT). NO REPAIRS HAVE BEEN MADE. THE CURRENT AND FAILURES MILEAGES WERE LESS THAN 69,000.
Engine and engine cooling, Mar 17, 2009
TL*THE CONTACT OWNS A 2002 DODGE DURANGO. WHILE DRIVING APPROXIMATELY 30 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE STALLED UNEXPECTEDLY. THERE WERE NO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE ENGINE RESTARTED ON THE FIRST ATTEMPT AND RESUMED NORMAL OPERATION. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING, BUT THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC ON A SEPARATE OCCASION FOR THE SAME FAILURE, BUT THERE WERE NO RESOLUTIONS. CURRENTLY, THE VEHICLE IS BEING DIAGNOSED AT THE AUTHORIZED DEALER. THE CONTACT IS WAITING ON A RESPONSE TO DETERMINE THE CAUSE OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE UNAVAILABLE. THE CURRENT MILEAGE WAS 100,000.
Electrical system, Mar 14, 2009
TRUCK QUIT RUNNING AND WAS INTERMITTENT AT HIGHWAY SPEED AND THEN QUIT FOR 10-15 MINUTES. *TR
Electrical system, Mar 11, 2009
RESISTOR THAT CONTROLS HEATER BLOWER SPEED FAILED NUMEROUS TIMES. ELECTRICAL CONNECTOR THAT CONNECTS POWER TO RESISTOR ALSO FAILED TWICE. WHEN CONNECTOR FAILED, EVIDENCE OF SIGNIFICANT ELECTRICAL ARCING BETWEEN CONTACTS AND SMOLDERING FIRE. DEALER SERVICE/PARTS CLAIMS PROBLEM MIS DUE TO ORIGINAL BLOWER MOTOR HAVING EXCESS CURRENT DRAIN, SO I REPLACED BLOWER MOTOR WITH NEW DEALER PART. PROBLEM RE-OCCURRED WITH MELTING OF CONNECTOR. FIVE RESISTORS AND TWO CONNECTORS. HIGH POTENTIAL FOR UNDER-DASHBOARD FIRE AT CONNECTION. *TR
Electrical system, Mar 9, 2009
THIS PAST WEEK (MARCH 1, 2009) AS MY FAMILY AND I WERE DRIVING TOWARDS OUR FAMILY VACATION, MY 2002 DURANGO STARTED TO MAKE SOME STRANGE NOISES AND ACTIONS. MY WIPERS BEGAN TO ACTIVATE AND WOULD NOT STOP, MY PANEL LIGHTS FLICKERED ON/OFF MAKING SOME CLICKING SOUNDS. ALL THIS OCCURRED WHILE I WAS DRIVING. WHEN I GOT A CHANCE, I TURN OFF THE CAR AND RESTARTED IT. IT STOPPED THE WIPERS FROM BEING ON BUT IT ALSO STOPPED MY ELECTRIC WINDOWS, EXTERIOR LIGHTS, INTERIOR LIGHTS, WIPERS, ALARM AND FAB FROM WORKING. THE CAR WOULD START, THE TURN SIGNALS WOULD WORK BUT ALL PREVIOUSLY MENTIONED ITEMS WOULD NOT WORK. WHEN I ARRIVED TO MY DESTINATION, MY FRIENDS AND I LOOKED AND TESTED SOME FUSES TO NO AVAIL. THE NEXT DAY WE CONTINUE TO TEST FUSES AND MODULES AND NOTICED THAT BY TAPPING A MODULE BOX NEXT TO THE LEFT DRIVER DOORS AND ADJACENT TO THE BRAKE WOULD MAKE THE INTERIOR LIGHTS ON/OFF. I PURCHASED THE PART CALLED THE 'TIME AND THEFT MODULE PART NO. 56049073AK. THE PART WAS ORDERED FROM THE DEALER, WE REPLACED IT AND IT SEEMED TO HAVE SOLVED THE PROBLEM. NOW THE INCONVENIENCE WAS TO HAVE THE KEY FAB REPROGRAMMED SO THAT IT CAN LOCK/UNLOCK THE DOORS AND ACTIVATE THE SECURITY ALARM. THIS WAS ANOTHER COST THAT CAN ONLY BE DONE AT THE DEALER. THE PURPOSE OF THIS COMPLAINT IS SO THAT OTHER DODGE DURANGO OWNERS AND THE NHTSA CAN SEE IF THIS SHOULD BE A RECALL AND FIND OUT IF ANY OTHER DRIVERS HAVE HAD SIMILAR PROBLEMS. AGAIN, MY CONCERN IS THAT LIGHTS WENT OUT, WIPERS INTERMITTENTLY ON/OFF, ETC. IF AT NIGHT, I ASSURE YOU THAT MY FRUSTRATION WOULD HAVE BEEN MUCH HIGHER. *TR