2002 Ford Escape
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,070 owner complaints filed for this model year. This is the 13th highest complaint count among 26 Escape model years with reports.
Of the 2002 reports, 68 involved a crash and 108 involved a fire. 45 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleJan 9, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2001-2002 ESCAPE VEHICLES MANUFACTURED FROM OCTOBER 22, 1999, THROUGH JULY 19, 2002, EQUIPPED WITH A BRAKE MASTER CYLINDER RESERVOIR CAP THAT COULD LEAK BRAKE FLUID. IF BRAKE FLUID LEAKS FROM THE CAP, IT COULD COME IN CONTACT WITH THE ANTILOCK BRAKE SYSTEM (ABS) MODULE WIRING HARNESS CONNECTOR.
CORROSION CAN DEVELOP IN THE ELECTRICAL CONNECTOR LEADING TO MELTING, SMOKE OR A FIRE.
DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER RESERVOIR CAP AND THE ABS ELECTRICAL SYSTEM WILL BE MODIFIED. AN INTERIM LETTER WAS MAILED ON JANUARY 20, 2012. DUE TO A PARTS DELAY, HOWEVER, THE REMEDY MAY NOT BE AVAILABLE CURRENTLY. IF PARTS ARE NOT AVAILABLE, FORD WILL INSTRUCT OWNERS TO PARK THEIR VEHICLES OUTSIDE UNTIL SUCH TIME AS PARTS BECOME AVAILABLE. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. THIS RECALL CAMPAIGN IS RELATED TO 07V-156.
Campaign 12V005000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Apr 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V165000 on NHTSA.gov
Representative owner complaints: power train
115 reports, newest first. Show all
Power train, Sep 28, 2010
PURCHASED VEHICLE WAS USED AROUND TOWN FOR 4 DAYS ON THE FORTH DAY DROVE ON HWY WAY AT 65 MPH THE OVERDRIVE LIGHT CAME ON FLASHING CAR FAILED TO SHIFT OUT OF GEAR. PULLED OFF ROAD TURNED OFF. FOUND CAR LEAKING AUTOMATIC TRANSMISSION FLUID AND WOULD NO LONGER GO INTO GEAR ONCE IT HAD BEEN SHUT OFF. IS CURRENTLY AT TRANSMISSION SHOP THE ARE ATTEMPTING TO FIND WHAT THE ISSUE IS. VEHICLE IS A 2002 FORD ESCAPE. *TR
Power train, Sep 9, 2010
TRANSMISSION FAILURE AT 104,000 MILES. *TR
Power train, Aug 16, 2010
MY 2002 FORD ESCAPE HAD TO HAVE A TRANSMISSION REPLACED. AT 74,000 MILES IT WAS BLOWN. I HAD IT TOWED TO A REPAIR SHOP AND ASKED FOR HIS OPINION. IT WAS BLOWN. HE CALLED ABOUT A REPLACEMENT AND WAS TOLD THE DEALER KEPT MANY REPLACEMENTS FOR 2002 ESCAPES BECAUSE OF FAILURES. I BOUGHT FORD BECAUSE I ALWAYS LOVED AND BOUGHT FORDS. BUT 3,3300.00 LATER, FORD HAS A PROBLEM. THE CAR RUNS BETTER NOW AND EVEN GETS 5 MILES PER GALLON BETTER ON GAS. FORD HAS A PROBLEM AS COUNTLESS PEOPLE HAVE EXPRESSED. *TR
Power train, Aug 9, 2010
TL*THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT SATED THAT THE TRANSMISSION FAILED. THE CONTACT STATED THAT THE TRANSMISSION DID NOT SHOW SIGNS OF SLIPPING BEFORE IT FAILED. THE VEHICLE WAS INSPECTED BY A CERTIFIED TECHNICIAN WHO STATED THAT THE CORE OF THE TRANSMISSION HAD FAILED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 130,000.
Service brakes, Hydraulic, Power train, Vehicle speed control, May 1, 2010, fire
2002 FORD ESCAPE WAS RECALLED FOR SEVERAL REASONS. SOMETHING WITH THE POWER TRAIN, THE CRUISE CONTROL, THE ABS SYSTEM..... FINALLY IT CAUGHT ON FIRE. THE ENGINE WAS MELTED. FIRE AND POLICE DEPARTMENT GOT THERE. CONTACTED FORD AND THEY JUST SAID WE WILL RECORD YOUR CALL ON YOUR PROFILE. DON'T UNDERSTAND HOW LIVES AND PROPERTY HAVE BEEN LOST AND FORD DOESN'T DO ANYTHING ABOUT IT. *TR
Power train, Mar 3, 2010
I AM VERY UNHAPPY. I GOT IN MY 2002 FORD ESCAPE THIS MORNING AND WENT TO PUT IT IN REVERSE AND THE SHIFTER BROKE OR SOMETHING IT WAS ROLLING I HAD TO PUT ON BRAKES I HAVE NEVER EVEN HEAR OF SOMETHING LIKE THIS HAPPENING AND I LOOK ON THE INTERNET AND ITS ALL OVER THE INTERNET HOW DEFECTIVE IT IS. I AM A 50 YEAR OLD SINGLE WOMEN SO I AM SURE IT WAS NOTHING I HAVE DONE. WHAT IS GOING TO BE DONE ABOUT THIS PROBLEM IT COULD BE A DANGEROUS SITUATION IF THEY WERE IN THE PARKING LOT OF A PUBLIC PLACE!!!!!!! *TR
Power train, Oct 29, 2009
2002 FORD ESCAPE 4X4 55,000 MILES WHILE DRIVING 70 MPH ON RT 95 THE CAR SUDDENLY APPEARED TO HAVE GONE INTO NEUTRAL, ALTHOUGH IT WAS STILL IN DRIVE. LUCKILY WE WERE ABLE TO MAKE IT TO THE SIDE OF THE ROAD 100 MILES FROM HOME. THE CAR WOULD NOT MOVE IN ANY GEAR AND NOW REQUIRES A NEW TRANSMISSION. THERE WERE NO PREVIOUS TRANSMISSION PROBLEMS AND NO WARNINGS THAT ANYTHING MIGHT BE WRONG. *TR
Power train, May 8, 2009
TL*THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 20-30 MPH ON NORMAL ROAD CONDITIONS, THE ENGINE STALLED WITHOUT WARNING. IMMEDIATELY, THE CONTACT SHIFTED INTO NEUTRAL AND RESTARTED THE ENGINE. THE VEHICLE WAS ABLE TO RESUME NORMAL OPERATION. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND REMAINED LIT UNTIL THE ENGINE WAS TURNED OFF. THE FAILURES OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING, BUT THE FAILURES COULD NOT BE DUPLICATED. ON TWO SEPARATE OCCASIONS, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR IDENTICAL FAILURES, BUT THERE WERE NO RESOLUTIONS. THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 04V165000 (POWER TRAIN; AUTOMATIC TRANSMISSION; CONTROL MODULE), ALTHOUGH THE FAILURES WERE IDENTICAL. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND CURRENT MILEAGE WAS 70,000.
Engine and engine cooling, Power train, Feb 16, 2009
WHILE DRIVING, USUALLY FIRST THING IN MORNING, THE RPM'S WILL REV UP TO APPROX. 2000. THE VEHICLE BECOMES HARDER TO STOP... *TR
Power train, Sep 15, 2008
TL*THE CONTACT OWNS A 2002 FORD ESCAPE. IMMEDIATELY AFTER PURCHASING THE VEHICLE IN AUGUST OF 2002, IT BEGAN STALLING AND LOST ALL POWER. THE CONTACT RECEIVED A RECALL NOTICE IN APRIL OF 2004 FOR NHTSA CAMPAIGN ID NUMBER 04V165000 (POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE). SHE TOOK THE VEHICLE TO A LOCAL DEALER AND RECEIVED HER FREE REPAIR. IN AUGUST OF 2008, THE FAILURE RECURRED. WHILE DRIVING APPROXIMATELY 10-20 MPH, THE VEHICLE STALLED AND LOST ALL POWER; HOWEVER, IT WAS ABLE TO BE RESTARTED. ON AUGUST 11, 2008, WHILE BACKING OUT OF THE DRIVEWAY AT AN UNKNOWN SPEED, THE VEHICLE LOST POWER. THE CONTACT LOST CONTROL OF THE VEHICLE. THE FAILURE RECURRED TWO ADDITIONAL TIMES THE SAME DAY. THE VEHICLE WAS TAKEN TO A LOCAL DEALER AND A COMPLETE DIAGNOSTIC TEST WAS PERFORMED; HOWEVER, NO FAILURES COULD BE FOUND. THE MANUFACTURER STATED THAT SINCE THEY ALREADY REPAIRED HER VEHICLE, THEY WERE NOT LIABLE FOR ANOTHER REPAIR. THE CURRENT MILEAGE WAS 51,007 AND FAILURE MILEAGE WAS 200.
Engine and engine cooling, Power train, Aug 12, 2008
MY FAMILY AND I WERE DRIVING ALONG THE INSTERSTATE WITH CRUISE CONTROLL SET AT 75 MPH. WE WERE GOING UP A SMALL HILL AND ABOUT TO GO INTO THE PASSING LANE. THE CAR SOUNDED LIKE THE TRANSMISSION SLIPPED IN OVER DRIVE AND THE RPMS WENT THROUGH THE ROOF. WE WERE ABLE TO COAST TO THE SIDE OF THE ROAD. WE TURNED THE VEHICLE OFF FOR SERVERAL MINUTES AND THEN TURNED IT BACK ON. THE OIL PRESSURE LIGHT FLICKERED ON AND OFF AND THE ENGINE MADE A HORRIBLE SCREECHING NOISE. WE CHECKED THE OIL AND IT WAS FULL. THE CAR HAD TO BE TOWED TO THE MECHANIC WERE HE THEN INFORMED US THAT THE CAR NEEDED A NEW ENGINE. HE STATED THE THE CATALYTIC CONVERETED HAD GONE OUT CAUSING THE ENGINE TO FAIL. THE CAR ALSO WILL NEED A NEW TRANSMISSION. THE TOTAL COST TO FIX THIS IS AROUND $8000.00. I CONTACTED FORD TODAY TO TELL THEM WHAT HAD HAPPENED AND THEY STATED THAT THERE WAS NOTHING THEY COULD DO SINCE THE CAR HAD NOT BEEN SERVICED AT A FORD SERVICE STATION CONSISTANTLY SINCE THE CAR WAS FIRST PURCHASED AND THAT THEY HAVE HAD NO OTHER SIMILIAR COMPLAINTS WITH THIS VECHILE. AFTER RESEARCHING ONLINE I HAVE FOUND MANY SIMILAR COMPLAINTS WHERE EVER ONE HAS SEEMED TO CONTACT FORD AND THEY SAY THE SAME THINGS TO THEM. I ALSO HAVE HAD SOME SMALLER PROBLEMS WITH THIS VEHICLE LIKE THE ENGINE LIGHT GOING ON AND THE EMERGENCY BREAK LIGHT GOING ON AND BROUGHT THEM IN TO THE SHOP AND HAVE HAD TO REPLACE THE SENSORS. RIGHT NOW I AM NOT ABLE TO REPLACE THE VEHICLE DUE TO FINICIAL REASONS.
Power train, Apr 19, 2008
VEHICLE WILL NOT SHIFT INTO ANY GEAR EXCEPT PARK. *TR
Power train, Mar 25, 2008
TRANSMISSION FAILURE, APPARENTLY A RECURRING PROBLEM WITH THE FORD 2001-2004 ESCAPE SUV. THIS ONE IS A 2002 AND DID NOT LEAVE ME STRANDED, I MANAGED TO GET IT TO THE DEALERSHIP. OTHERS (HUNDREDS++) ON THE WEB WERE STRANDED ON MAJOR HIGHWAYS. *TR
Engine and engine cooling, Fuel system, Gasoline, Power train, Electrical system, Vehicle speed control, Equipment, Feb 20, 2008
TL*THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE DRIVING 60 MPH, THE ACCELERATOR PEDAL WENT DOWN TO THE FLOOR AND WOULD NOT RELEASE. THE CONTACT WAS ABLE TO PLACE THE VEHICLE INTO SECOND GEAR. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE CRUISE CONTROL CABLE FAILED AND JAMMED THE THROTTLE COVER. THE TRANSMISSION BECAME DAMAGED WHEN THE CONTACT SHIFTED INTO REVERSE GEAR. THE MANUFACTURER MAY NOT BE ABLE TO ASSIST. ON NOVEMBER 25, 2007, THE VEHICLE WAS TAKEN TO THE DEALER DUE TO REVERSE. THE DEALER CLEANED THE THROTTLE BODY, FLUSHED THE INJECTORS, AND CLEANED THE UPPER INTAKE GASKET AND SPARK PLUGS. THE FUEL FILTERS, COIL BOOTS, AND IGNITIONS WIRES WERE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 62,000. THE CONSUMER STATED THE BATTERY LIGHT COMES ON WHILE DRIVING, REPLACE FUEL FILTER, AND A/C IS NOT BLOWING COLD. UPDATED 03/31/08 *TR
Power train, Jan 3, 2008
TL*THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE WOULD LOOSE POWER WHEN AT A STOP. IN ADDITION, SHE WAS UNABLE TO DEPRESS THE BRAKES UNLESS THE IDLE WAS LOW. THE DEALER REPLACED THE ALTERNATOR AND THE BATTERY ON TWO OCCASIONS; HOWEVER, THE FAILURE CONTINUED TO OCCUR. THERE IS A RECALL FOR THE POWER TRAIN: AUTOMATIC TRANSMISSION: CONTROL MODULE (NHTSA CAMPAIGN ID # 04V165000) HOWEVER, THE MANUFACTURER STATED HER VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 100,000 AND CURRENT MILEAGE WAS 107,447.
Power train, Dec 3, 2007
THIS WILL BE THE SECOND TIME I HAVE TO REPLACE THE BRAKE PADS AND ROTORS, NOT TO MENTION THAT FROM DAY ONE MY WHEELS HAVE BEEN COVERED IN BLACK DUST FROM THE BRAKES, AND IM TOLD THIS IS NORMAL. THE MAJOR PROBLEM HAS BEEN THE TRANSMISSION. I CAN NOT TELL YOU HOW MANY TIMES I'VE TAKEN IT IN TO BE LOOKED AT AND CALLED AND COMPLAINED TO FORD WITH NO HELP AT ALL. SINCE DAY ONE (MY CAR WAS BRAND NEW) THE AUTOMATIC TRANSMISSION MADE NOISES AS THOUGH IT WAS STUCK WHEN IT SHOULD BE SMOOTHLY SHIFTING GEARS. EACH TIME I TOOK IT IN NOONE HEARD ANYTHING...UNTIL MY WARRANTEE WAS UP THEN THINGS WERE HEARD. LETS SEE I'VE PAID FOR ENGINE FLUSHES, SPARK PLUG CHANGES, FLUID CHECKS, RESET CALIBRAITONS, I'VE NEVER MISSED AN OIL OR FILTER CHANGE AND IT PROGRESSIVELY IS GETTING WORSE. I'VE READ LOTS OF OTHER COMPLAINTS FROM FORD OWNERS REGARDING THE SAME PROBLEM. SO IF WE ALL ARE HAVING THE SAME ISSUE, WHY ISN'T FORD HELD ACCOUNTABLE TO FIX THIS??????? *TR
Power train, Nov 13, 2007
VEHICLE TRANSMISSION FAILED AT 75,000- WE HAD TAKEN THE VEHICLE IN 2 SEPARATE OCCASIONS THE FIRST YEAR OF OWNERSHIP CONCERNING THE TRANSMISSION BUT WAS ADVISED NOTHING WRONG. *TR
Power train, Nov 1, 2007
BEGINNING OF 2006, I PURCHASED MY USED 2002 FORD EXPLORER. AROUND 70,000 MILES, ABOUT 9 MONTHS LATER, THE ROARING NOISE IN THE REAR WAS UNBEARABLE. I PUT ALL NEW TIRES,I PUT ALL NEW BRAKES THINKING THIS WAS CAUSING THE NOISE. FINALLY I WENT ONLINE TO FIND THE MANY, MANY COMPLAINTS ABOUT THE REAR END NOISE. I CALLED FORD CUSTOMER SERVICE AND THEY SAID THERE WAS NO RECALLS, EVEN THOUGH THERE ARE MANY COMPLAINTS ON THIS ISSUE, BECAUSE IT IS NOT CONSIDERED A SAFETY ISSUE. THEY SUGGESTED I HAVE IT DIAGNOSED AT A FORD DEALERSHIP. ON 10/20/07, I HAD THIS DIAGNOSIS DONE, AND WAS TOLD IT WAS THE REAR AXLE DIFFERENTIAL AND WAS ADVISED NOT TO DRIVE, OR DRIVE AS LITTLE AS POSSIBLE BECAUSE IT COULD CEASE UP WHILE DRIVING, AND CAN BE A SAFTEY ISSUE IF UNIT FAILS. THE COST OF THIS REPAIR, PARTS AND LABOR IS ABOUT $1200. IS FORD WAITING FOR THIS TO CEASE UP, CAUSING INJURIES OR DEATHS BEFORE THEY DEEM IT A SAFTEY ISSUE, AND RECALL THESE VEHICLES FOR REPAIR. I CANNOT AFFORD TO REPAIR MY VEHICLE AT THIS TIME AND NEED MY VEHICLE. *TR
Power train, Oct 29, 2007
TRANSMISSION FAILURE AFTER 4 YEARS AND 10 MONTHS AT 64,000 MILES. *TR
Power train, Oct 23, 2007
WHILE ATTEMPTING TO SHIFT FROM REVERSE TO DRIVE, THE GEAR SHIFTER ON THE COLUMN BROKE IN 1/2 WHILE PASSING INTO THE NUETRAL POSITION. BROKEN PIECE IN POSSESSION. TRUCK WAS THEN STUCK IN NUETRAL WITH SHIFTER HANGING BY A WIRE. FOUND 2ND 2002 EXPLORER AT DEALER # 2 WITH GEAR SHIFTER BREAKING IN 1/2. *TR
Power train, Oct 6, 2007
I BOUGHT A USED 2002 FORD ESCAPE 2 MONTHS AGO AND IT WAS CARFAXED AND ALL AND NOTHING WAS WRONG. THREE WEEKS AGO THE ENGINE WOULD STALL OUT WHEN I STARTED THE VEHICLE OR WHEN I WAS DRIVING, I THOUGHT IT WAS BAD GAS, SO I FIXED IT. THEN IT HAPPENED AGAIN AND I THOUIGHT IT WAS THE BATTERY, SO I FIXED IT. I WAS FRUSTRATED AND WHEN IT HAPPENED AGAIN ON OCT. 3RD, 2007 IN THE MIDDLE OF A 7 LANE HIGHWAY. I WAS SCARED AND UPSET, AND I ENDED UP TAKING IT IN AGAIN! WE FOUND OUT THAT THERE IS A RECALL ON 2002 FORD ESCAPES WITH 3.0L V6 ENGINES FOR THE PCM ON DECELERATIONS BELOW 40 MPH BECAUSE OF FUEL-AIR MIXTURES BEING SENT TO THE ENGINE. IT WAS ISSUED IN APRIL OF 2004. I CALLED FORD MOTOR COMPANY, MY DEALER THAT I BOUGHT THE VEHICLE FROM, AND ANOTHER DEALER CLOSE TO ME; THEY ALL SAID THAT THERE WERE NO RECALLS ON MY ESCAPE. I LOOKED IT UP MYSELF AND THEY WERE CORRECT, BUT IF THIS RECALL WAS ALREADY FIXED THEN IT WAS OBVIOUSLY NOT FIXED CORRECTLY BECAUSE THE EXACT DEFINIATION OF THE RECALL IS WHAT IS HAPPENING WITH MY ESCAPE. MY COMPLAINT IS THAT I THINK FORD NEEDS TO ACKNOWLEDGE MY EXCEPTION AND KNOW THAT THIS IS NOT BECAUSE THE ENGINE NEEDS TO "RE-PROGRAM" ITSELF FOR A FEW WEEKS. IT IS A RECALL AND I THINK IT NEEDS TO BE FIXED FOR FREE, LIKE IT IS SUPPOSED TO BE. I DON'T LIKE TO BE IN THE MIDDLE OF A 7 LANE HIGHWAY AND LOOSE CONTROL OF MY STEERING AND EVERYTHING WITHIN MY CAR. *JB
Power train, Oct 3, 2007
PULLED 2002 FORD EXPLORER INTO COVERED SPACE AT APARTMENT COMPLEX AND PROCEEDED TO PUT THE CAR INTO PARK. WHILE ATTEMPTING TO PUT THE CAR INTO THE PARK THE GEAR SHIFT BROKE OFF FROM THE STEERING COLUMN. I COULD NOT BELIEVE WHAT HAD JUST HAPPENED. EXCESSIVE FORCE WAS NOT USED AND NEVER IN MY WILDEST DREAMS DID I EVER IMAGINE THIS TYPE OF FAILURE ON A CAR. LATER I RESEARCHED THE PROBLEM ON THE INTERNET AND FOUND THAT THIS IS A COMMON PROBLEM WITH THE 2002 FORD EXPLORER. I CAN'T START THE CAR SINCE IT IS NOT IN PARK OR NEUTRAL. HAD TO HAVE THE CAR TOWED AND ACCORDING TO THE INTERNET THE REPLACEMENT PART IS BACK ORDERED UNTIL MID NOVEMBER. SO, FORD IS OK WITH HAVING A PRODUCT ON THE ROAD THAT I CANNOT DRIVE FOR 1.5 MONTHS BECAUSE OF A BAD PART? IT APPEARS THE BAD PART IS MADE OF ALUMINUM WHICH IS SHOCKING. WILL HAVE TO GET A RENTAL FOR THE ENTIRE TIME I AM WITHOUT THE CAR. THIS KIND OF FAILURE IS UNACCEPTABLE AND THERE SHOULD BE A RECALL ON THIS PROBLEM. *TR
Power train, Jun 25, 2007
I OWN A 2002 FORD ESCAPE AND WAS DRIVING ON THE FREEWAY WHEN THE OVERDRIVE OFF LIGHT STARTED FLASHING. I PULLED OVER ,BUT WAS NOT ABLE TO REENGAGE THE OVERDRIVE. CONTINUED THE COMMUTE HOME AND THE TRANSMISSION STARTED SHIFTING ROUGHLY, AND THEN THE CHECK ENGINE LIGHT CAME ON. I WAS ABLE TO DRIVE IT TO THE DEALER, WHERE THEY TOLD ME I WOULD NEEDED A NEW TRANSMISSION. I TOOK IT, ,,(BY THIS POINT THE VEHICLE WASN'T DRIVEABLE AND HAD TO HAVE IT TOWED TO A TRANSMISSION SHOP NEAR MY HOME. THEY STATED THAT I WOULD NEED A NEW TRANSMISSION, AND THAT THIS SEEMED TO BE A COMMON OCCURRENCE FOR FORD ESCAPES. THEY SAID THAT A VEHICLE AT 90000 MILEAGE SHOULD NOT HAVE THE EXTENSIVE KIND OF TRANSMISSION DAMAGE THAT THIS VEHICLE DID.*AK
Power train, Dec 1, 2006
O/D OFF LIGHT BEGAN FLASHING. APPARENTLY, THE TORQUE CONVERTER FAILED AND THE ENTIRE TRANSMISSION HAD TO BE REPLACED. CAR WAS ONLY 4 YEARS OLD WITH 53000 MILES. IF I DIDN'T HAVE AN EXTENDED WARRANTY, THE REPAIRS WOULD HAVE COST OVER $3000. APPARENTLY, THIS SAME PROBLEM EXISTS ON THE 2002 FORD EXPLORER AS WELL. *NM
Power train, Nov 14, 2006
I BOUGHT MY 2002 FORD ESCAPE IN MAY OF 2005, THE DEALERSHIP HAD TO REBUILD THE TRANSMISSION 3 DAYS LATER AT 80K BECAUSE IT WAS SLIPPING BETWEEN GEARS. NOW A YEAR AND HALF LATER, I'VE BEEN TOLD BY A SPECIALIST THAT I NEED A NEW TRANSMISSION, WHICH WILL COST ME $2500 - $4000! THE DEALER WILL NOT WARRANTY THEIR WORK BECAUSE IT HAS BEEN OVER A YEAR SINCE THE SERVICE, BUT I'VE ONLY PUT 20K MILES ON IT! THE TRANSMISSION SPECIALIST EXPLAINED THAT THE 2002 ESCAPE HAS THE SAME TRANSMISSION AS A MAZDA 626, WHICH IS NOTORIOUS FOR FAILING. HE SAID EVEN IF I PAY TO HAVE IT REPLACED, IT WILL FAIL AGAIN. *NM