2002 Ford Escape
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,070 owner complaints filed for this model year. This is the 13th highest complaint count among 26 Escape model years with reports.
Of the 2002 reports, 68 involved a crash and 108 involved a fire. 45 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleJan 9, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2001-2002 ESCAPE VEHICLES MANUFACTURED FROM OCTOBER 22, 1999, THROUGH JULY 19, 2002, EQUIPPED WITH A BRAKE MASTER CYLINDER RESERVOIR CAP THAT COULD LEAK BRAKE FLUID. IF BRAKE FLUID LEAKS FROM THE CAP, IT COULD COME IN CONTACT WITH THE ANTILOCK BRAKE SYSTEM (ABS) MODULE WIRING HARNESS CONNECTOR.
CORROSION CAN DEVELOP IN THE ELECTRICAL CONNECTOR LEADING TO MELTING, SMOKE OR A FIRE.
DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER RESERVOIR CAP AND THE ABS ELECTRICAL SYSTEM WILL BE MODIFIED. AN INTERIM LETTER WAS MAILED ON JANUARY 20, 2012. DUE TO A PARTS DELAY, HOWEVER, THE REMEDY MAY NOT BE AVAILABLE CURRENTLY. IF PARTS ARE NOT AVAILABLE, FORD WILL INSTRUCT OWNERS TO PARK THEIR VEHICLES OUTSIDE UNTIL SUCH TIME AS PARTS BECOME AVAILABLE. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. THIS RECALL CAMPAIGN IS RELATED TO 07V-156.
Campaign 12V005000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Apr 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V165000 on NHTSA.gov
Representative owner complaints: power train
115 reports, newest first. Show all
Service brakes, Hydraulic, Parking brake, Engine and engine cooling, Power train, Exterior lighting, Vehicle speed control, Equipment, Dec 27, 2002
CONSUMER STATED ON JULY 2, 2002 THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR A BROKEN HEADLIGHT AND MISSING EQUIPMENT FROM THE VEHICLE, ON JULY 23, 2002 THE VEHICLE BEGAN EXPERIENCING STALLING, BRAKE AND ODOMETER PROBLEMS, THE BRAKES WERE REPLACED DUE TO A FLAW, THE STALLING AND THE ODOMETER PROBLEMS COULD NOT BE DUPLICATED, ALSO THERE WERE PROBLEMS WITH THE SPEAKERS AND THE CLUTCH STICKING, CONSUMER STATED WHILE THE VEHICLE WAS PARKED, THE PARKING BRAKE DISENGAGED AND THE VEHICLE ROLLED INTO A HOTEL.*JB
Steering, Power train, Nov 21, 2002
POWER STEERING LEAKED IN OCT 2001, PROBLEM CAUSED BY FAILED RACK AND PINION STEERING SYSTEM. DEALER REPLACED AFTER HAVING VEHICLE IN SHOP FOR A MONTH. IN NOV 2002, THE VEHICLE SUFFERED A TRANSMISSION FAILURE WHILE CROSSING A MAJOR INTERSECTION. BARELY MANAGED TO GET THROUGH THE INTERSECTION WITHOUT AN ACCIDENT. THE NEAREST FORD DEALER HAPPENED TO BE ACROSS THE STREET. TOOK INTO SERVICE DEPT AND THEY FOUND THAT THE TRANSMISSION HAD FAILED AND WAS WELDED TOGETHER. THE ONLY SERVICE PERFORMED WAS RACK/PINION REPLACEMENT BY ORIGINAL DEALER IN OCT 2001. EXPERTS TELL US THAT TRANSMISSIONS ARE NOT WELDED. THEY ARE BOLTED. EITHER VEHICLE CAME FROM FACTORY WITH WELDED TRANSMISSION (POSS. OTHER VEHICLES WITH SAME PROBLEM) OR ORIGINAL DEALER DAMAGED TRANSMISSION WHEN INSTALLING NEW RACK/PINION SYSTEM AND WELDED THE DAMAGE WITHOUT REPORTING IT TO THE CONSUMER. NOT HAPPY ABOUT 2 MAJOR PROBLEMS IN JUST OVER A YEAR. DT
Power train, Oct 23, 2002
THE GAS PEDAL AND BRAKE PEDAL VIBRATE CONSTANTLY BETWEEN 1600-1800 RPM'S. I TOOK THE TRUCK TO THE DEALER, BUT WAS TOLD THAT IT WAS A TRAIT OF THE VEHICLE. I HAVE DRIVEN OTHER ONES AND THEY DO NOT SHOW THIS TRAIT. IT HAPPENS IN EVERY GEAR OF THE TRANSMISSION, BUT WHEN IN PARK THE PEDALS WON'T VIBRATE AT STATED RPM. AS THE LOAD ON THE VEHICLE INCREASE THE INTENSITY OF THE VIBRATION INCREASES. THE CONDITION IS VERY ANNOYING BECAUSE IT OCCURS AT NORMAL HIGHWAY AND CITY SPEEDS. I WOULD LIKE TO GET THE ISSUE RESOLVED, BUT THE MANUFACTURER SEEMS UNWILLING TO HELP. DT
Power train, Oct 9, 2002, crash
CONSUMER STATES WHILE SHIFTING INTO REVERESE ON LEVEL GROUND, THE VEHICLE JUMPED INTO FORWARD, TOOK OFF AND HIT A LIGHT POLE BEFORE STOPPING. DEALER AND THE MANUFACTURER HAS NOT BEEN NOTIFIED AT THIS TIME. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. MR
Power train, Aug 22, 2002
WHILE DRIVING AT 35MPH ON FLAT SURFACE AND WITH NO WARNING ENGINE WILL STALL, CAUSING CONSUMER TO PULL OVER. DEALER WILL BE NOTIFIED.*AK
Power train, Electrical system, Aug 12, 2002
VEHICLE STALLED TWICE AT 40 MPH. DEALER REPLACED PCM SENSOR AND REPROGRAMMED COMPUTER.*AK
Power train, Jun 13, 2002
ENGINED STALL WHILE COASTING DOWN A HILL AT 35 MPH. LOST POWER STEERING AND BRAKING.*AK
Service brakes, Hydraulic, Engine and engine cooling, Power train, May 17, 2002
BOUGHT VEHICLE 11/1/2001. THE FIRST TIME, 1/9/2002 WITH ONLY 1547 MILES, LET OFF OF GAS, COASTING DOWN HILL, APPROX 40 MPH, CAR DIED, LOST POWER STEERING AND BRAKES. AFTER COASTING TO A STOP, CAR RESTARTED. DEALER REPLACED POWERTRAIN CONTROL MODULE RELAY. 2ND TIME, ON 5/3/2002, WITH 3949 MILES, SIMILAR CONDITIONS, CAR DIED, LOST POWER STEERING AND BRAKES, CAR RESTARTED AFTER COASTING TO A STOP. DEALER CHANGED THE FUEL MIXTURE IN THE COMPUTER. I HAVE SERIOUS DOUBTS THAT THIS HAS FIXED THE PROBLEM.
Power train, May 7, 2002
VEHICLE CUTS OFF WHEN DECELERATING, GOING DOWN A HILL TO ACCELERATE UP A HILL. PROBLEM IS INTERMITTENT. ALSO, FORD IS AWARE OF PROBLEM, BUT NOT SURE OF WHAT SOLUTION COULD CURE THE PROBLEM. PLEASE PROVIDE MORE INFORMATION.*AK
Power train, Electrical system, Apr 16, 2002
VEHICLE STALLED AT 35-40 MPH. DEALER REPLACED ECC POWER RELAY. MILEAGE WAS 5162 MILES. VEHICLE STALLED AGAIN AT SAME SPEED ON 15 APRIL 2002, DEALER REPROGRAMMED TCM. *AK
Power train, Mar 26, 2002
WHILE DRIVING VEHICLE STALLED CAUSING THE STEERING WHEEL TO LOCK UP AND THE SYSTEM TO SHUT DOWN, AFTER THE VEHICLE SAT FOR 30 MIN THE VEHICLE COULD BE RESTARTED, THE DEALER HAS BEEN CONTACTED, CONSUMER STATES THE PROBLEM WAS THE PCM. NLM
Service brakes, Hydraulic, Engine and engine cooling, Power train, Mar 11, 2002
2002 FORD ESCAPE XLT, VEHICLE WOULD NOT START, ENGINE TURNED OVER BUT SOOUNDED LIKE IT WAS GOING TO BLOW UP. AFTER SEVERAL ATTEMPTS IT FINALLY STARTED. IT DOES THIS 2 OR 3 TIMES A DAY. DEALER SAYS NO PROBLEM, IT WILL FIX ITSELF. VEHICLES ENGINE SMOKED ON TWO OCCASIONS, THOUGHT THE CAR WAS ON FIRE. DEALER SAYS THERE IS NOTHING WRONG. VEHICLE WILL SURGE ON ITS OWN, EVEN WITH THE BRAKE DEPRESSED, ALMOST AS IF I HAD FLOORED IT. I CANNOT DRIVE 20 MPH, IT SURGES FORWARD! LAST INCIDENT I HAD WITH THE VEHICLE, I LOST COMPLETE USE OF THE BRAKES, NO HYDRAULICS, NO NOTHING. PEDAL DEPRESSED RIGHT TO THE FLOOR. ALMOST GOT INTO A HEAD ON COLLISION, USED E-BRAKE TO STOP. HAPPENED A SECOND TIME LATER THAT DAY. TOOK CAR TO DEALERSHIP, NOTHING IS WRONG. CONTACTED FORD REP. AND THEY WILL NOT DO ANYTHING TO HELP ME. I DO NOT FEEL SAFE DRIVING THIS VEHICLE. I DO NOT WISH TO KEEP THE VEHICLE.
Steering, Service brakes, Hydraulic, Power train, Vehicle speed control, Other or unspecified, Feb 26, 2002
ON SEVERAL OCCASIONS, WHILE TRAVELING ON A STEEP CURVY ROAD AT 25 MPH, VEHICLE LOST POWER BRAKES AND POWER STEERING, CONSUMER HAD TO USE BOTH FEET ON BRAKE PEDAL TO CONTROL SPEED, OIL AND EMISSION LIGHTS CAME ON, CONSUMER WAS ABLE TO TURN OFF STREET ONTO PARKING LOT AND SLOW DOWN ENOUGH TO AVOID CRASHING, ENGINE WAS STILL ON WHEN VEHICLE CAME TO A STOP, DEALER REFLASHED PCM AND REPLACED MASS AIRFLOW SENSOR, THROTTLE BODY AND IAC SOLENOID. *AK *TT
Power train, Dec 3, 2001
I HAVE OWNED THE VEHICLE FOR 90 DAYS. 30 OF THOSE DAYS THE VEHICLE WAS OUT OF SERVICE. THE CAR CANNOT BE DRIVE WHEN GEAR ASSEMBLY STICKS.*AK
Power train, Jul 10, 2001
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK