2002 Ford Escape
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,070 owner complaints filed for this model year. This is the 13th highest complaint count among 26 Escape model years with reports.
Of the 2002 reports, 68 involved a crash and 108 involved a fire. 45 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleJan 9, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2001-2002 ESCAPE VEHICLES MANUFACTURED FROM OCTOBER 22, 1999, THROUGH JULY 19, 2002, EQUIPPED WITH A BRAKE MASTER CYLINDER RESERVOIR CAP THAT COULD LEAK BRAKE FLUID. IF BRAKE FLUID LEAKS FROM THE CAP, IT COULD COME IN CONTACT WITH THE ANTILOCK BRAKE SYSTEM (ABS) MODULE WIRING HARNESS CONNECTOR.
CORROSION CAN DEVELOP IN THE ELECTRICAL CONNECTOR LEADING TO MELTING, SMOKE OR A FIRE.
DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER RESERVOIR CAP AND THE ABS ELECTRICAL SYSTEM WILL BE MODIFIED. AN INTERIM LETTER WAS MAILED ON JANUARY 20, 2012. DUE TO A PARTS DELAY, HOWEVER, THE REMEDY MAY NOT BE AVAILABLE CURRENTLY. IF PARTS ARE NOT AVAILABLE, FORD WILL INSTRUCT OWNERS TO PARK THEIR VEHICLES OUTSIDE UNTIL SUCH TIME AS PARTS BECOME AVAILABLE. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. THIS RECALL CAMPAIGN IS RELATED TO 07V-156.
Campaign 12V005000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Apr 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V165000 on NHTSA.gov
Representative owner complaints: service brakes
198 reports, newest first. Show all
Service brakes, Oct 28, 2013, crash
FIRST INCIDENT- I WAS COMING OFF AN EXIT AND THE CAR INFRONT OF ME GOT CUT OFF ON THE OFF RAMP BECAUSE THERE WAS AN ENTRANCE RIGHT AFTER THE TURN, HE BRAKE AND I SLAMMED ON MY BRAKES. MY ABS DID NOT KICK IN. I DID REAR ENDED THE CAR INFRONT OF ME, BUT MY CAR HAD ALL THE DAMAGE. I DID NOT THINK ANYTHING OF THIS AND ONLY BLAMED MYSELF. MY CAR GOT REPAIRED. NOW (10/28/13)- MY CARS ABS/BRAKES ARE NOT WORKING. I DO NOT FEEL SAFE BEHIND THE CAR. LAST YEAR 2012, I GOT THE RECALLS COMPLETED BUT THEY WERE MINOR. BUT MY ABS SYSTEM/BRAKES ARE CRUCIAL. MY BRAKES ARE STICKING, PULSING, GOING ALL THE WAY TO THE FLOOR. IT IS MORE THAN JUST A TONE RING! THAT IS THE RESPONSE I RECEIVED WHEN I WENT TO A FORD DEALERSHIP. SOMETHING IS INCORRECT WITH MY ABS PUMP AND SOMETHING HAS TO BE DONE ABOUT IT. WHEN I THINK OF THE FIRST INCIDENT I THINK SOMETHING MAY HAVE BEEN WRONG ALL ALONG. *TR
Service brakes, Hydraulic, Vehicle speed control, Sep 12, 2013, crash
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED WHILE DRIVING 55 MPH THE VEHICLE ACCELERATED INDEPENDENTLY. THE CONTACT APPLIED IMMENSE PRESSURE TO THE BRAKES TO NO AVAIL. THE CONTACT CRASHED INTO FIVE VEHICLES. THE CONTACT SUFFERED BRUISES TO HER LEGS. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 135,000. UPDATED 12/5/13*CN
Electrical system, Equipment adaptive/mobility, Service brakes, Aug 30, 2013, fire
MY ESCAPE WAS PARKED IN DRIVEWAY WHEN WE WENT TO GO TO TOWN AND IT WAS SMOKING THEN ON FIRE THIS WAS IN THE EVENING ABOUT 8 IF WE HADN'T GONE OUT WE WOULD HAVE HAD A HUGE FIRE WITCH COULD HAVE INVOLVED 3 OTHER CARS NOT TO MENTION OUR HOUSE WE LIVE IN RAMONA CA 92065 AND ITS FIRE SEASON WE ARE IN A RURAL AREA..
Service brakes, May 16, 2013
HAD POWERTRAIN CONTROL MODULE RE-CALIBRATED, RE-PROGRAMMED PCM, ABS MODULE CONNECTOR REPAIR AND INSPECTION, ABS RELAY INSTALLATION AND MASTER CYLINDER CAP REPLACED, ALL RE-CALLS. FIND OUT HCU HYDRAULIC CONTROL UNIT IS FAILING WHICH IS A SAFETY HAZARD AND CAN RESULT IN BRAKES FAILING AND POSSIBLE DEATH FROM LOSS OF CONTROL AND ACCIDENT. THANK GOD THIS HASN'T HAPPENED BUT FORD NEEDS TO TAKE RESPONSIBILITY FIX THIS ISSUE WITH SO MANY OTHERS WITH SAME PROBLEM. *TR
Service brakes, Mar 5, 2013
MY 2002 ESCAPE WAS SERVICED FOR A RECALL ISSUED A FEW YEARS BACK. THE WIRING HARNESS ON THE ABS BRAKE SYSTEM. WHEN WE TOOK IT IN TO HAVE THE RECALL REPAIRED THE DEALER SAID THE ABS MODULE WAS BAD- $900 TO FIX IT!! THEY SAY IT IS NOT RELATED BECAUSE IT DIDN'T CATCH FIRE OR BURN UP/MELT THE WIRING HARNESS?? I HAVE TO WAIT FOR PARTS TO MELT OR CATCH FIRE BEFORE THEY WILL FIX THE PART IT PLUGS INTO?? EVERY VEHICLE WE HAVE PURCHASED NOW IN THE LAST 20 YEARS HAS BEEN A FORD. WE PAID OFF BOTH OUR FORDS AND WERE READY TO PURCHASE AND HAND DOWN THE ESCAPE TO MY 16 Y/O DAUGHTER.IT IS NOT SAFE! MORE THAN 4 RECALLS ALL SAFETY RELATED ON THIS VEHICLE. OUR F150 GOES IN FOR A FEW RECALLS AND SPARK PLUGS- A WHOPPING $500 TO CHANGE SPARK PLUGS BECAUSE OF THE DESIGN OF THE ENGINE AND AN EXTRA HOUR OF LABOR FOR EACH ONE THAT BREAKS OFF...LOVELY! AT THE MERCY OF FORD AND ONCE AGAIN, TOTAL DISSATISFACTION AND DISAPPOINTMENT. NOW THEY COULD CARE LESS WHO GETS HURT,I'M NOT GOING TO RISK MY DAUGHTERS LIFE OR ANYONE'S FOR THAT MATTER. FORD SHOULD TAKE CARE OF THIS. ALSO, IT SAYS 'MODIFIED ABS SYSTEM' IN RECALL WITH MASTER CYLINDER CAP (NOT EVEN REPAIRED SEE BELOW)NOW THEY WANT TO CHARGE IS $900 TO REPAIR. SOMEONE OR MANY WILL END UP INJURED OR WORSE! MY 2002 ESCAPE WAS SERVICED FOR A RECALL ISSUED A FEW YEARS BACK. THE WIRING HARNESS ON THE ABS BRAKE SYSTEM (NOT GOOD) WHEN WE TOOK IT IN TO HAVE THE RECALL REPAIRED THE DEALER SAID THE ABS MODULE WAS BAD- $900 TO FIX IT!! THEY SAY IT IS NOT RELATED BECAUSE IT DIDN'T CATCH FIRE OR BURN UP/MELT THE WIRING HARNESS?? MORE THAN 4 RECALLS ALL SAFETY RELATED ON THIS VEHICLE THE NEWEST BRAKE SYSTEM RECALL IS THE MASTER CYLINDER FLUID CAP (DIDN'T EVEN KNOW ABOUT THIS ONE AND IT WAS NOT FIXED AND MY FLUID IS LEAKING ALL OVER THE PLACE. *TR
Service brakes, Hydraulic, Service brakes, Feb 13, 2013
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING DOWNHILL AT 40 MPH AND ATTEMPTING TO APPLY THE BRAKES, THE BRAKE PEDAL ABNORMALLY TRAVELED TO THE FLOOR BOARD. THE CONTACT MENTIONED THAT IN ORDER TO STOP THE VEHICLE HE HAD TO DOWN SHIFT AND ENGAGE THE EMERGENCY BRAKE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 176,000. UPDATED 3/14/13 *CN THE CONSUMER STATED BOTH FRONT BRAKE HOSES FAILED AT THE SAME TIME. UPDATED 03/21/13
Service brakes, Jan 31, 2013, crash
I WAS DRIVING DOWN A SMALL HILL AND HAD A BLOW OUT THE BRAKES DID NOT STOP THE CAR LOST CONTROL AND ROLLED OVER THE SIDE OF THE HILL.
Service brakes, Jan 15, 2013
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT BRAKE FLUID WAS LEAKING ONTO THE BRAKE RESERVOIR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN ADVISED THAT THE MASTER CYLINDER WOULD NEED TO BE REPLACED BUT THE PART WAS NOT AVAILABLE FOR REPAIR. THE BRAKE WARNING LIGHT CONTINUED TO ILLUMINATE INTERMITTENTLY. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 12V005000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE) THAT COULD HAVE BEEN RELATED TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 25,000.
Electronic stability control (ESC), Service brakes, Dec 5, 2012
I OWN THREE FORD ESCAPES AND ON THIS VEHICLE I'VE HAD THE RIGHT FRONT ABS RING SNAP SAME AS ALL THE OTHERS WITH NO WARRANTY FROM THE DEALER. *TR
Service brakes, Nov 19, 2012
WHEN I FIRST START MY VEHICLE AND BEGIN DRIVING IT, UNLESS I REACH 20 MPH BEFORE NEEDING TO BRAKE, THE BRAKES MAKE A GRINDING NOISE AND AT FIRST THE PEDAL RESISTS, THEN IT GIVES WAY IN, CAUSING THE BRAKE TO NEED TO PRESSED DOWN COMPLETELY BEFORE THE VEHICLE WILL COME TO A STOP. ONCE I REACH THE 20 MPH OR SO, THE ABS LIGHT COMES ON, AND AFTER THAT, THE BRAKES WORK FINE. I TOOK IT TO MY FORD DEALERSHIP, THEY REPORTEDLY DID NOT FIND A PROBLEM WITH THE BRAKES, BUT PERFORMED A RECALL ON ONLY THE ABS LIGHT ITSELF. THIS DID NOTHING FOR THE GRINDING RESISTANCE AND FAILURE OF THE BRAKE PEDAL UPON INITIALLY NEEDING TO STOP, AND STILL THE ABS LIGHT POPS ON ONCE I REACH 20-25 MPH. *TR
Service brakes, Nov 6, 2012
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS SHE WOULD HEAR A LOUD WHISTLING NOISE. WHEN SHE WOULD DEPRESSES THE BRAKES THE NOISE WOULD STOP. THE VEHICLE WAS LATER TAKEN TO A DEALER WHO DIAGNOSED THAT THE MASTER CYLINDER WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HER THAT THERE WERE NO RECALLS ON HER VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 203,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 230,000. THE VIN WAS UNAVAILABLE.
Service brakes, Jul 27, 2012
BRAKE TONE RINGS CRACK AND CAUSE ABS TO NOT FUNCTION PROPERLY. VERY COMMON PROBLEM ON FORD ESCAPES. *TR
Service brakes, Jul 27, 2012
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT THE BRAKES WERE EXHIBITING FAILURES AND THE VEHICLE WOULD JERK ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO DISCOVERED THAT THE BRAKE LINES WERE FRACTURED AND WOULD NEED REPLACING. THE DEALER REPLACED THE BRAKES, ROTORS, BRAKE PEDAL AND THE BRAKE LINES. THE VEHICLE CONTINUED EXHIBITING BRAKING ISSUES AFTER THE REPAIR. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBERS: 12V005000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE), 07V156000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE), AND 07E023000 (SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER) AND TOOK THE VEHICLE TO THE DEALER FOR REPAIRS. THE DEALER DENIED THE RECALL REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 33,000 AND THE CURRENT MILEAGE WAS 62,000.
Vehicle speed control, Service brakes, Jul 26, 2012, crash
[XXX] WAS DRIVING HER 2002 FORD ESCAPE WHEN, WHILE ACCELERATING UP A HILL, THE SPEED CONTROL THROTTLE GUIDE ROTATED UP INTO THE APPEARANCE COVER AND BECAME LATCHED IN A RIB. THIS RESULTED IN A WIDE OPEN THROTTLE, AND [XXX] WAS UNABLE TO SLOW OR STOP THE CAR. THE BRAKES THEN OVERHEATED AND FAILED, AND SHE SPED THROUGH TOWN UNTIL SHE SWERVED TO AVOID ANOTHER CAR AND CRASHED. HER CAR ROLLED SEVERAL TIMES, AND [XXX]WAS KILLED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Service brakes, Jul 20, 2012
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT BRAKE FLUID LEAKED FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO DEALER. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000 AND THE CURRENT MILEAGE WAS 130,000.
Service brakes, Jul 5, 2012
TL* THE CONTACT OWNS A 2002 FORD ESCAPE XLT. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN ID NUMBER :12V005000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE ). LATER, THE ABS WARNING LIGHT ILLUMINATED WHILE TRAVELING 25 MPH AND THE BRAKES FAILED TO WORK PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE ABS CONTROL MODULE NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED BUT THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 111,053.
Service brakes, Jun 27, 2012, fire
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT IN 2010, THE VEHICLE WAS PARKED WHEN SMOKE EMITTED FROM UNDER THE HOOD. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE ABS MODULE WAS THE CAUSE OF THE FAILURE. THE ABS MODULE WAS NOT REPLACED AT THE TIME OF THE FAILURE. THE VEHICLE WAS RECENTLY TAKEN TO AN AUTHORIZED DEALER TO BE REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 12V005000 (SERVICE BRAKES, HYDRAULIC: ANTI LOCK: CONTROL UNIT/MODULE). THE ABS MODULE COULD NOT BE REPLACED DUE TO FAILED WIRES THAT POSED A FIRE HAZARD. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 139,000 AND THE CURRENT MILEAGE WAS 166,000.
Service brakes, Hydraulic, Jun 4, 2012
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 12V005000 (SERVICE BRAKES, HYDRAULIC: ANTI-LOCK: CONTROL UNIT/MODULE) WAS RECEIVED JANUARY 2012. THE DEALER STATED THAT THE PART WOULD NOT BECOME AVAILABLE UNTIL THE END OF JUNE. THE MANUFACTURER ALSO ADVISED THE CONTACT THAT THE PART WAS NOT READILY AVAILABLE. THE CONTACT STATED THAT THE RECALL HAD EXCEEDED A REASONABLE TIME FOR REPAIR. THE APPROXIMATE FAILURE AND THE CURRENT MILEAGE WAS 98,000. THE CONSUMER WOULD LIKE THE SEAL REPLACED ON THE MASTER CYLINDER. UPDATED 07/12/12
Service brakes, May 30, 2012
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT THE ABS WARNING LIGHT REMAINED ILLUMINATED AND THE ABS MOTOR CONTINUED RUNNING ONCE THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TOWED TO THE DEALER WHERE A DIAGNOSTIC WAS PERFORMED, WHICH LOCATED THE FAILURE AT THE HYDRAULIC CONTROL UNIT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 12V005000 (SERVICE BRAKES, HYDRAULIC: ANTILOCK: CONTROL UNIT/MODULE) PRIOR TO THE FAILURE. THE CONTACT WAS UNABLE TO HAVE THE VEHICLE SERVICED UNDER THE RECALL WITHIN A REASONABLE TIME PERIOD AND BELIEVED THAT THE FAILURE WAS CAUSED BY THE LACK OF RECALL SERVICE. THE MANUFACTURE WAS CONTACTED AND DENIED ANY ASSISTANCE WITH REPAIRS, STATING THAT THE HYDRAULIC CONTROL UNIT WAS NOT ASSOCIATED WITH THE RECALL CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 120,000.
Service brakes, Hydraulic, May 22, 2012
2002 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO VEHICLE RECALL *TGW THE CONSUMER STATED HE HAS NOT RECEIVED ANY TYPE OF CORRESPONDENCE AS TO WHEN HE CAN HAVE THE RECALL PERFORMED ON HIS VEHICLE. RECALL # 07V156000 *JB
Service brakes, May 21, 2012
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT RECEIVED A RECALL NOTICE ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 07V156000 (SERVICE BRAKES, HYDRAULIC: ANTILOCK: CONTROL UNIT/MODULE). THE MANUFACTURER WAS NOTIFIED ON MARCH 26, 2012 AND INFORMED THE CONTACT THAT THE PART WAS UNAVAILABLE. AN AUTHORIZED DEALER WAS RECENTLY NOTIFIED AND THEY WERE ALSO UNCERTAIN WHEN THE PART WOULD BE AVAILABLE. THERE ARE NO FAILURES AT THIS TIME.
Service brakes, May 15, 2012
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED HE RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER: 12V005000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE) FIVE MONTHS AGO BUT THE DEALER DID NOT HAVE THE PARTS TO REPAIR THE VEHICLE. THE CONTACT WAS FORCED TO PARK HIS VEHICLE OUTSIDE DUE TO THE RISK OF A FIRE. THE MANUFACTURER WAS CONTACTED AND THEY ALSO STATED THE PARTS WERE UNAVAILABLE. THERE ARE NO FAILURES AT THIS TIME. THE CURRENT MILEAGE WAS 136,000.
Service brakes, Hydraulic, May 10, 2012
DEAR NHTSA: I RECEIVED A RECALL NOTICE IN JANUARY 2012 FOR MY 2002 FORD ESCAPE. A POSSIBLE ELECTRICAL SHORT COULD OCCUR IN THE ANTI-LOCK BRAKE SYSTEM WHICH COULD RESULT IN A FIRE. BECAUSE OF THIS SAFETY ISSUE, OWNERS WERE INSTRUCTED TO PARK THEIR CARS AWAY FROM STRUCTURES TO PREVENT POSSIBLE FIRE FROM SPREADING. .FOR THE LAST FOUR MONTHS FORD HAS BEEN TELLING US THAT PARTS ARE UNAVAILABLE AND THEY DO NOT KNOW WHEN THE PARTS WILL BE AVAILABLE. IT SEEMS THAT FORD HAS NO REGARD FOR THE SAFETY OF THEIR CUSTOMERS. THEY CERTAINLY DO NOT CARE ABOUT THE INCONVENIENCE THIS IS CAUSING THEIR CUSTOMERS. I HAVE BEEN UNABLE TO USE MY GARAGE SINCE JANUARY AND HAVE BEEN PARKING MY CAR AWAY FROM STRUCTURES AND OTHER VEHICLES. I CANNOT SELL OR TRADE MY VEHICLE. YESTERDAY,FORD CUSTOMER SERVICE TOLD ME THAT PARTS SHOULD BE AVAILABLE BY THE SECOND QUARTER OF THIS YEAR, ALTHOUGH THEY CANNOT GUARANTEE IT. PLEASE NOTE, I SPOKE TO FORD TWO MONTHS AGO AND WAS TOLD PARTS WOULD BE AVAILABLE BY APRIL. I AM GETTING THE IMPRESSION THIS IS NOT AT ALL A PRIORITY FOR FORD. PLEASE CONTACT FORD AND FIND OUT WHY NOTHING IS BEING DONE TO FIX THIS SAFETY ISSUE. PLEASE FEEL FREE TO CONTACT ME IF YOU WOULD LIKE ANY ADDITIONAL INFORMATION. THANK YOU... UPDATED 05/31/12 *BF CONSUMER STATES THEY HAVEN'T BEEN ABLE TO PARK IN THEIR GARAGE SINCE JANUARY AND THEIR PATIENCE HAS RUN ITS COURSE. CONSUMER HAD SPOKEN TO THEIR INSURANCE COMPANY AND INSURANCE COMPANY MAY NOT PAYOUT IF CAR CATCHES FIRE BECAUSE OF FORD'S NEGLIGENCE. UPDATED 6/6/12 *SD *TR
Service brakes, Hydraulic, Engine and engine cooling, May 1, 2012, fire
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT A BURNING ODOR WAS EXHIBITED FORM THE VEHICLE WHILE DRIVING 70 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THERE WERE TWO LEAKS COMING FROM THE ENGINE. THE VEHICLE WAS REPAIRED HOWEVER, THE BURNING ODOR REMAINED AFTER THE VEHICLE WAS REPAIRED. THE CONTACT ALSO STATED THAT SHE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER 07V156000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE) BUT WAS INFORMED THAT THE PARTS WOULD NOT BE AVAILABLE TO REPAIR THE VEHICLE UNTIL THE SECOND QUARTER OF 2012. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.
Service brakes, Hydraulic, Apr 27, 2012
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED FORD TOLD HER THAT THE PARTS FOR NHTSA RECALL CAMPAIGN ID NUMBER: 12V005000 (SERVICE BRAKES, HYDRAULIC: ANTI-LOCK: CONTROL UNIT/MODULE) WERE NOT AVAILABLE AND THE MANUFACTURER DID NOT GIVE A TIME FRAME FOR WHEN THE PARTS WOULD BE AVAILABLE. THE MANUFACTURER STATED THAT EVEN THOUGH IT STATES IN THE RECALL THAT THE VEHICLE MAY CATCH FIRE, IT WAS SAFE TO DRIVE. THE CURRENT MILEAGE WAS 100,000. UPDATED 07/06/12 *BF UPDATED 08/02/12