2002 Ford Escape
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,070 owner complaints filed for this model year. This is the 13th highest complaint count among 26 Escape model years with reports.
Of the 2002 reports, 68 involved a crash and 108 involved a fire. 45 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleJan 9, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2001-2002 ESCAPE VEHICLES MANUFACTURED FROM OCTOBER 22, 1999, THROUGH JULY 19, 2002, EQUIPPED WITH A BRAKE MASTER CYLINDER RESERVOIR CAP THAT COULD LEAK BRAKE FLUID. IF BRAKE FLUID LEAKS FROM THE CAP, IT COULD COME IN CONTACT WITH THE ANTILOCK BRAKE SYSTEM (ABS) MODULE WIRING HARNESS CONNECTOR.
CORROSION CAN DEVELOP IN THE ELECTRICAL CONNECTOR LEADING TO MELTING, SMOKE OR A FIRE.
DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER RESERVOIR CAP AND THE ABS ELECTRICAL SYSTEM WILL BE MODIFIED. AN INTERIM LETTER WAS MAILED ON JANUARY 20, 2012. DUE TO A PARTS DELAY, HOWEVER, THE REMEDY MAY NOT BE AVAILABLE CURRENTLY. IF PARTS ARE NOT AVAILABLE, FORD WILL INSTRUCT OWNERS TO PARK THEIR VEHICLES OUTSIDE UNTIL SUCH TIME AS PARTS BECOME AVAILABLE. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. THIS RECALL CAMPAIGN IS RELATED TO 07V-156.
Campaign 12V005000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Apr 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V165000 on NHTSA.gov
Representative owner complaints: structure
89 reports, newest first. Show all
Structure, Oct 14, 2015
THE FRONT PASSENGER DOOR LOCKING SYSTEM IS DEFECTIVE AND IS STUCK IN THE LOCK POSITION. UNABLE TO OPEN DOOR FROM THE OUTSIDE OR THE INSIDE OF THE CAR. THIS IS A SAFETY ISSUE THAT SHOULD HAVE BEEN ADDRESSED IN THE PAST SINCE I NOTICED NUMEROUS COMPLAINTS REGARDING THIS SAME PROBLEM ON THE INTERNET OR YOUR NHTSA WEBSITE. THE FORD DEALER SERVICE MANAGER ALSO MENTIONED TO ME THAT THIS IS A RECURRING PROBLEM THAT SHOULD HAVE BEEN ADDRESSED IN THE PAST BY FORD. SERVICE FEE IS $500 IF THE REPAIRMAN IS ABLE TO OPEN THE DOOR WITHOUT BREAKING IT AS SOMETIMES IT DOES BREAK CAUSING AN EVEN MORE EXPENSIVE REPAIR. THIS IS AN EXPENSIVE REPAIR JOB FOR A JAMMED LOCKING MECHANISM THAT SHOULD EASILY BE WORKING PROPERLY. GOD FORBID I AM INVOLVED IN A CAR ACCIDENT AND MY WIFE, OTHER FRONT PASSENGER OR MYSELF IS UNABLE TO OPEN THE DOOR IN CASE OF AN EMERGENCY. THIS IS A MAJOR INCONVENIENCE AS ANY PASSENGER THAT WANTS TO SIT IN THE FRONT HAS TO LEAP THROUGH THE DRIVER DOOR TO SIT IN THE FRONT. MY WIFE IS THE ORIGINAL OWNER OF THIS CAR AND IT CURRENTLY HAS 130,000 MILES. ALL CAR DOORS SHOULD BE ABLE TO WORK WITHOUT JAMMING AS THIS OBVIOUSLY POSES A SAFETY ISSUE. WHY NHTSA HAS NEVER BOTHERED TO ESCALATE THIS PROBLEM TO A RECALL IS BEYOND ME WHEN THERE ARE OTHER FORD ESCAPE OWNERS WITH THE SAME SAFETY PROBLEM? PLEASE ADVICE, THANKS.
Structure, Sep 14, 2015
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CROSS BAR REINFORCEMENT WAS INSTALLED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 66,946.
Structure, Jul 31, 2015
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 25 MPH, A STRANGE NOISE WAS HEARD COMING FROM THE FRONT OF THE VEHICLE BEFORE THE STEERING WHEEL SUDDENLY VEERED TO THE RIGHT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SUBFRAME FRACTURED DUE TO SEVERE RUSTING AND CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS PREVIOUSLY SERVICED UNDER THE NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE FAILURE MILEAGE WAS 180,000. THE VIN WAS NOT AVAILABLE. MA 10/2 *CN
Suspension, Structure, Jun 24, 2015
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 25 MPH, THE WHEEL BEARING COMPLETELY DETACHED FROM THE VEHICLE, WHICH RESULTED IN THE WHEEL DETACHING FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. AN INDEPENDENT MECHANIC DIAGNOSED THAT CORROSION FROM THE SUBFRAME CAUSED THE WHEEL BEARING TO DETACH AND IT NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.
Structure, May 4, 2015
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT THERE WAS EXTENSIVE RUST AND CORROSION ON THE UNDERBODY FRAMING AND THE CROSS MEMBER. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE VEHICLE WAS TAKEN TO THE DEALER, WHO INSTALLED A NEWLY DESIGNED REINFORCEMENT; HOWEVER, THE FRAME AND THE CROSS MEMBER WERE RUSTED AND NOT COVERED UNDER THE RECALL REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 189,000. THE VIN WAS NOT AVAILABLE.
Structure, Apr 20, 2015
RECEIVED NOTICE IN MAIL MY FORD WAS RECALLED DUE TO CORROSION RELATED SEPARATION OF FORWARD ATTACHMENT OF LOWER CONTROL ARM FROM SUBFRAME. THIS WAS FIX WITH JUST REINFORCED CROSSBAR...AN INDEPENDENT MECHANIC JUST RECENTLY CHECK MY VEH DUE TO STEERING AND FRONT END ISSUE I HAVE BEEN HAVING AND DISCOVERED THE AREA WHERE THE CROSSBAR HOLD ON TO IS RUSTED OFF..I CAN NOT DRIVE VEHICLE...THIS RUST THEY TELL ME WAS/OR WOULD HAVE BEEN NOTICE OF TIME CROSS BAR WAS INSTALL AND SHOULD HAVE NOTIFIED ME THAT MORE WORK SHOULD HAVE BEEN DONE. PERHAPS CORRECT/REPLACE THE WHOLE THING...I WOULD LIKE TO HAVE IT REPAIRED AT FORDS REQUEST,,,THE DEALERSHIP DENIED DUE TO RECALL FIXED ACCORDING TO FORD. HAD I BEEN AWARE IF THIS RUST ISSUE AT TIME OF REPAIR I WOULD HAVE BEEN ABLE TO DEAL WITH IT AND NOT BE AT RISK DRIVING ALL THESE PAST MONTHS.... *TR
Suspension, Structure, Mar 30, 2015
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE WAS RECENTLY SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE DEALER WAS TO INSTALL A NEWLY DESIGNED REINFORCEMENT CROSS-BRACE FOR THE UNINTENDED DETACHMENT OF THE LOWER CONTROL ARM. A SHORT TIME AFTER THE REPAIR, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ANOTHER SERVICE, WHO NOTICED THAT THE BALL JOINT WAS SEPARATED FROM THE CONTROL ARM AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 152,000.
Structure, Feb 25, 2015
2002 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO EXCESSIVE CORROSION AND LARGE CRACK IN THE ENGINE CRADLE/ SUBFRAME. *SMD THE CONSUMER STATED THE STEERING WENT TO THE LEFT APPROXIMATELY 15 DEGREES WHILE DRIVING STRAIGHT DOWN THE ROAD. THE SENT IN RECALL NOTICE # 14V165000. ACCORDING TO FORD, THE VEHICLE DID NOT HAVE COMPLETE SEPARATION OF THE LOWER CONTROL ARM. *JB
Suspension, Structure, Feb 1, 2015
WHILE PULLING OUT OF A PARKING LOT, I NOTICED THE VEHICLE'S STEERING SEEMED LOOSE & THERE WAS A CREAKING NOISE FROM THE FRONT END. VEHICLE CONTINUED TO PULL TO THE RIGHT AS I DROVE DOWN THE ROAD, AND CREAKING NOISE INCREASED. I DROVE DIRECTLY TO DEALER WHERE I'D HAD THE WORK FOR RECALL 14V165000 COMPLETED ONLY 4 WEEKS PRIOR (26 DEC 2014), AND THEIR ASSESSMENT WAS A CRACKED SUBFRAME. SERVICE WRITER INFORMED ME THAT THE CAR WAS DANGEROUS TO DRIVE, AND THE COST TO REPAIR WOULD BE A MINIMUM OF $2000 IN PARTS AND LABOR, PLUS THE LIKELIHOOD OF ADDITIONAL REPAIRS NEEDED ONCE THEY FOUND OTHER CORRODED PARTS IN NEED OF REPLACEMENT. I DECLINED THE REPAIR AND PURCHASED A NEW CAR (NOT A FORD) INSTEAD. *TR
Structure, Dec 17, 2014
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT THE CROSS-BRACE FRACTURED. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER: 14V165000 (STRUCTURE) BUT THE RECALL REMEDY FAILED TO REPAIR THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC, WHO DIAGNOSED THAT THE SUB FRAME AND THE CONTROL ARM NEEDED TO BE REPLACED. IN ADDITION, THE MECHANIC ADVISED THAT THE VEHICLE COULD NOT BE DRIVEN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.
Suspension, Structure, Nov 14, 2014
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE TRAVELING 25 MPH, THE FRONT LOWER CONTROL ARM FRACTURED AND THE WHEEL DETACHED FROM THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT INDICATED THAT THERE WAS RUST ON THE FRONT END OF THE LOWER CONTROL ARM AND THE SUBFRAME. ALSO, THE SUBFRAME WAS RUSTED THROUGH ON THE FRONT PASSENGER SIDE. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP WHO REPLACED THE FRONT LOWER CROSS MEMBER AND THE FRONT SUBFRAME. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE: BODY). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 139,145. UPDATED 01/23/15*LJ UPDATED 6/3/2015 *JS
Suspension, Structure, Oct 2, 2014
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 10 MPH ON UNEVEN PAVEMENT, THE STEERING WHEEL SUDDENLY TURNED APPROXIMATELY 45 DEGREES TO THE RIGHT. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE PASSENGER SIDE SUBFRAME WAS RUSTED AND CORRODED, WHICH CAUSED THE LOWER CONTROL ARM TO FAIL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,900.
Structure, Equipment adaptive/mobility, Sep 22, 2014
VINYL DOOR PANEL OF FRONT PASSENGER DOOR PEALED OFF. *TR
Suspension, Structure, Sep 9, 2014
MY CAR IS INCLUDED IN THE RECALL FOR THE RUSTED OUT SUBFRAME. IT HAS AT LEAST 2 OBLONG RUSTED OUT HOLES NEAR THE CONTROL ARM. IT WAS TAKEN TO THE DEALER. THEY INSTALLED A CROSS BRACE. 3 DIFFERENT DEALERS TOLD ME THE BRACE WILL HOPEFULLY, IF I AM LUCKY, HELP ME PULL OVER WITHOUT CRASHING WHEN (NOT IF) THE SUBFRAME GIVES AWAY AND THE CONTROL ARM FALLS OFF. TWO OF THE THREE LITERALLY TOLD ME, "GOOD LUCK." I FEEL IF FORD REALIZES THE ISSUE IS SERIOUS ENOUGH FOR A RECALL THEY SHOULD PROPERLY FIX THE PROBLEM. *TR
Steering, Suspension, Structure, Aug 14, 2014
VEHICLE SUB-FRAME FAILED DUE TO CORROSION CAUSING SEPARATION OF THE LOWER CONTROL ARM RESULTING IN DIMINISHED STEERING CONTROL. THIS ISSUE APPEARS TO BE COVERED BY FORD SAFETY RECALL 14S02 AND NHTSA RECALL 14V-166 THAT PROVIDED A REINFORCEMENT OF THE SUB-FRAME. UNFORTUNATELY THE REINFORCING PARTS NECESSARY FOR THE RECALL ACTION WERE NOT IMMEDIATELY AVAILABLE BEFORE THE FRAME FAILED. *TR
Structure, Aug 13, 2014
TOOK MY ESCAPE IN TO LOCAL FORD DEALERSHIP FOR REPAIR OF SAFETY RECALL 14V-165. THE DEALERSHIP TOLD ME THAT THE CORROSION ON THE SUBFRAME AND ENGINE CRADLE WAS MORE EXTENSIVE THAN WHAT THE RECALL HAS EVER DEALT WITH AND THAT THE INSTALLATION OF JUST THE REINFORCEMENT CROSSBRACE ON THE SUBFRAME WILL NOT FIX THE PROBLEM ONLY "BANDAID" IT. THE CORROSION IS SO BAD THE PART IS GOING TO BREAK UNDER ANY DRIVING CONDITIONS AND CAN THEREFORE CAUSE A CRASH. SO NOW I HAVE CALLED THE FORD MOTOR COMPANY TO DISPUTE THE PROBLEM TO BE FIXED PROPERLY BUT THEY DENIED MY CLAIM AND I AM THEREFORE STILL WITHOUT A VEHICLE TO DRIVE BECAUSE MINE IS UNSAFE TO DRIVE. *TR
Structure, Jul 24, 2014
PEELING PAINT ON ROOF, HUTCH AND AROUND THE DRIVER SIDE REAR DOOR. *TR
Steering, Suspension, Structure, Jul 17, 2014
CORROSION-RELATED SEPARATION LOWER CONTROL ARM FROM SUBFRAME. CAR START PULLING INSTANTLY TO THE RIGHT. HAVE TO CALL TOWING TO GET TO DEALER FOR REPAIR, FORD COMPANY REFUSE TO REPAIR UNDER SAFETY RECALL NOTICE 14S02. DEALER QUOTE ME AROUND $2000 FOR REPAIR. *TR
Steering, Suspension, Structure, Jul 3, 2014
CAR WAS MAKING CREAKING SOUNDS. GOING AROUND A CORNER THE CAR BASICALLY HAD NO STEERING OR CONTROL. GOT CAR TO FORD DEALERSHIP AND BASED ON TAKING PHOTO OF THE CAR I WAS TOLD THAT FORD DECIDED TO PUT A CROSS BRACE ON AS OPPOSED TO REPLACING SUB FRAME. I TOLD DEALERSHIP I DID NOT AGREE WITH DECISION THAT SUBFRAME SHOULD BE REPLACED CAR WAS RETURNED TO ME WITH CROSS BRACE INSTALLED.APROX 4 WEEKS LATER CAR WAS UNDRIVEABLE. CONTACTED FORD TOLD ME TO TOW CAR BACK TO DEALERSHIP. AFTER INSPECTION OF VEHICLE WAS TOLD NOW THAT SUB- FRAME WAS BROKEN DEALERSHIP CONTACTED FORD AND WAS TOLD THAT THEIR REQUEST TO REPLACE SUB FRAME WAS DENIED. THE SUB FRAME HOLDS ENGINE,TRANS, ALL STEERING AND BRAKE COMPONENTS. THIS IS A VERY DANGEROUS. MY FAMILY COULD HAVE BEEN KILLED. I WAS TOLD BY FORDSUPV THAT BECAUSE THEY PUT ON BRACE INSTEAD OF MAKING THE CORRECT REPAIR THAT WAS ACTUALLY PART OF SUB FRAME RECALL THEY WOULD NOT REPLACE SUB FRAME. THIS IS HOW FORD TREATS THEIR CUSTOMERS AND PUTS THEM IN HARMS WAY. IF YOU LOOK AT THE HISTORY OF FORD VEHICLES FORD WINDSTAR FORD ESCAPE ETC. YOU WILL SEE THEY ARE USING DEFECTIVE STEEL ON UNDER BODY COMPONENTS CAUSING EXCESSIVE RUST RESULTING IN CRITICAL COMPONENT FAILURES. IN MY 48 YEARS OF DRIVING I HAVE NEVER HAD A VEHICLE WITH A BROKEN FRAME WHEN I ASKED FORD FOR PHONE NUMBER OR ADDRESS TO [XXX]. FIELDS I WAS TOLD THAT IS NOT GIVEN OUT AND THAT THE FORD SUPERVISORS DENIAL WAS FINAL DECISION. I FEEL FORD IS 100% WRONG IN THIS ISSUE AND IS NOT MAKING SAFE CARS, AND WHEN THERE IS A RECALL WILL NOT EVEN FIX THE RECALLED PARTS. ONCE AGAIN THIS IS AN EXTREMELY DANGEROUS SITUATION THAT COULD HAVE RESULTED IN DEATH TO MY FAMILY IF I WAS DRIVING ON THE X-WAY SHAME SHAME ON YOU FORD MOTOR. I WILL BE LOOKING INTO FILING LAW SUIT OR CLASS ACTION LAW SUIT AGAINST YOU. PLEASE DO THE RIGHT THING FOR THE UNLUCKY INDIVIDUALS WHO OWN THESE CARS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Structure, Jun 25, 2014
I RECEIVED A LETTER ABOUT RECALL NOTICE 14S02/NHTSA RECALL 14V-165. I HAVE CALLED MY LOCAL FORD DEALERSHIP AND GONE IN TO THE SERVICE CENTER ABOUT THIS RECALL. THE DATE ON MY LETTER WAS MAY 2014. THEY SAID THEY DID NOT HAVE THE PARTS TO FIX THE VEHICLE. I HAVE TRIED SEVERAL TIMES TO GET THIS FIXED AND AM JUST BLOWN OFF BY THE DEALERSHIP. WHAT DO I HAVE TO DO GET THIS RECALL TAKEN CARE OF. *TR
Structure, Jun 18, 2014
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT THE SUB FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Structure, Jun 11, 2014
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT THE FRONT PASSENGER DOOR, REAR HATCHBACK, AND DRIVER'S SIDE REAR DOOR WERE RUSTED AND UNABLE TO BE OPENED. THE DEALER STATED THAT THE DOORS NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 153,000.
Steering, Suspension, Structure, May 24, 2014
WHILE DRIVING ON A RURAL CITY STREET AT 30 MPH I DECELERATED TO PREPARE TO TURN RIGHT. WHEN I BEGAN TO MAKE MY RIGHT HAND TURN I HEARD A LOUD POP AND THE CAR BEGAN TO RATTLE THE CAR CAME TO A STOP WITHIN 10 FEET OF THE POP. I APPLIED A SMALL AMOUNT OF POWER TO THE ENGINE TO TRY AND GET COMPLETELY OUT OF THE ROAD, BUT THE CAR WOULD NOT MOVE. UPON INSPECTION OF THE FRONT PASSENGER TIRE IT WAS FACING 90 DEGREES IN THE OPPOSITE DIRECTION OF THE CAR, AND PUSHED TO THE BACK OF THE WHEEL WELL. THE CV SHAFT HAD COME COMPLETELY DETACHED FROM THE DRIVE SHAFT. THE VEHICLE HAD TO BE TOWED TO A LOCAL SHOP THAT DID SUB-FRAME WORK. UPON INSPECTION AT THE AUTO BODY SHOP IT WAS REVEALED THAT THE ENGINE CRADLE HAD ALSO BECOME DETACHED DUE TO THE PROXIMITY TO THE EXHAUST FROM THE ENGINE HEATING IT UP CONSTANTLY. ALONG WITH THE FOLLOWING PARTS NEEDING REPLACEMENT: RIGHT FRONT CV SHAFT, FRONT ENGINE CRADLE, FRONT CONTROL ARM BOLTS, CONTROL ARM BUSHING, CV DRIVE AXLE, HEAVY DUTY EXHAUST CLAMPS. THE SHOP HAD TO REMOVE AND REPLACE THE ENGINE CRADLE AND THE RIGHT FRONT SUB-FRAME. IF I HAD BEEN ON A HIGH SPEED INTERSTATE, AND THIS HAPPENED I WOULD HAVE PROBABLE FLIPPED, BECAUSE THE FRONT RIGHT TIRE WAS UNABLE TO MOVE, AND WAS PULLING TOWARDS THE INSIDE OF THE CAR. THE TOTAL COST TO GET THIS REPAIRED TO A SAFE DRIVING CONDITION WAS $1352.69. *TR
Steering, Suspension, Structure, Apr 26, 2014
WHILE DRIVING HER 2002 FORD ESCAPE TO WORK MY DAUGHTER NOTICED THE STEERING WAS NOT RIGHT. IN ORDER FOR HER TO KEEP DRIVING STRAIGHT SHE HAD TO TURN THE STEERING WHEEL. SHE WENT OVER A PAIR OF ROUGH RAILROAD TRACKS & LOST CONTROL OF THE VEHICLE. HER FRONT PASSENGER TIRE CONTROL BAR HAD COMPLETELY SEPARATED FROM THE FRAME. IT WAS RUSTED THROUGH. LUCKILY SHE WAS DRIVING IN A 30MPH ZONE & THERE WERE NO OTHER CARS AROUND. THANKFULLY SHE WAS NOT HURT BUT QUITE SHAKEN UP. WE WERE UNAWARE OF A VEHICLE RECALL ON THIS MODEL UNTIL A FRIEND OF HERS RECALLED SEEING AN ARTICLE IN THE NEWS ABOUT CONTROL BARS RUSTING THROUGH CAUSING STEERING PROBLEMS. HER FRONT TIRE WAS COMPLETELY BALD AFTER THIS INCIDENT. (TREAD WAS GOOD BEFORE). I CALLED FORD AS SOON AS I WAS ABLE & REPORTED THE INCIDENT. THE REP TOLD ME THAT IN ORDER FOR A REPAIR THE VEHICLE HAD TO BE TOWED TO A FORD DEALER & TO KEEP THE TOW BILL AS THEY WOULD COVER IT. RIGHT NOW THE SUV IS AT THE DEALER. IT HAS BEEN 2 DAYS SINCE THEY'VE HAD IT & I'VE HEARD NOTHING. I AM GETTING VERY IMPATIENT. BECAUSE IT'S A RECALL I HAVE A HUNCH THEY PUT IT ON THE BACK BURNER. THIS VEHICLE IS HER ONLY WAY TO SCHOOL & WORK. I ASKED ABOUT A LOANER & THEY EXPLAINED THAT BECAUSE OF THE HUGE VOLUME OF RECALLS, A LOANER WOULD BE DIFFICULT TO COME BY. WHAT HAS HAPPENED TO CUSTOMER SERVICE? I AM EXPECTING NOT ONLY THE VEHICLE TO BE FIXED BUT I FEEL WE SHOULD BE COMPENSATED FOR THE 1 TIRE - MAYBE 2 DEPENDING ON THE CONDITION OF THE OTHER SIDE. I DON'T NEED A SET OF NEW ONES - JUST SOMETHING TO PASS INSPECTION. IF ANYONE HAS EXPERIENCED THE SAME ISSUES PLEASE POST SOMETHING BACK. THANK YOU ! [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Structure, Apr 7, 2014
WHILE DRIVING ALONG A HIGHWAY IN VIRGINIA, I HEARD. (AND FELT) A LOUD NOISE FROM THE REAR OF THE CAR. I THOUGHT I HIT A POTHOLE. I CONTINUED DRIVING TOWARD FLORIDA, STOPPING IN A MOTEL IN SOUTH CAROLINA. THE NEXT MORNING, WHILE RE-PACKING THE CAR, I NOTICED THE GAS TANK HAD FALLEN AND WAS PARTLY SITTING ON THE REAR AXLE. *TR