2002 Ford Escape
Problems, recalls and owner-reported issues
Engine and engine cooling is the leading concern among 1,070 owner complaints filed for this model year. This is the 13th highest complaint count among 26 Escape model years with reports.
Of the 2002 reports, 68 involved a crash and 108 involved a fire. 45 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleJan 9, 2012
FORD IS RECALLING CERTAIN MODEL YEAR 2001-2002 ESCAPE VEHICLES MANUFACTURED FROM OCTOBER 22, 1999, THROUGH JULY 19, 2002, EQUIPPED WITH A BRAKE MASTER CYLINDER RESERVOIR CAP THAT COULD LEAK BRAKE FLUID. IF BRAKE FLUID LEAKS FROM THE CAP, IT COULD COME IN CONTACT WITH THE ANTILOCK BRAKE SYSTEM (ABS) MODULE WIRING HARNESS CONNECTOR.
CORROSION CAN DEVELOP IN THE ELECTRICAL CONNECTOR LEADING TO MELTING, SMOKE OR A FIRE.
DEALERS WILL REPLACE THE BRAKE MASTER CYLINDER RESERVOIR CAP AND THE ABS ELECTRICAL SYSTEM WILL BE MODIFIED. AN INTERIM LETTER WAS MAILED ON JANUARY 20, 2012. DUE TO A PARTS DELAY, HOWEVER, THE REMEDY MAY NOT BE AVAILABLE CURRENTLY. IF PARTS ARE NOT AVAILABLE, FORD WILL INSTRUCT OWNERS TO PARK THEIR VEHICLES OUTSIDE UNTIL SUCH TIME AS PARTS BECOME AVAILABLE. OWNERS MAY CONTACT THE FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332. THIS RECALL CAMPAIGN IS RELATED TO 07V-156.
Campaign 12V005000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Apr 6, 2004
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 3.0L V6 ENGINES, DURING DECELERATION, THE ENGINE CAN STALL.
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
DEALERS WILL REPROGRAM THE POWER CONTROL MODULE (PCM) WITH THE APPROPRIATE CALIBRATION. OWNER NOTIFICATION BEGAN ON APRIL 21, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V165000 on NHTSA.gov
Representative owner complaints
1,070 reports, newest first.
Service brakes, Hydraulic, Jun 11, 2011
MY ABS SYSTEM WAS COMING ON WHILE STOPPING FOR NO APPARENT REASON. WHEN I TOOK VEHICLE TO DEALER, THEY SAID I HAD A CRACKED TONE RING. I HAD THE SAME TONE RING REPLACED 4 YEARS AGO. OF COURSE IT WASN'T UNDER WARRANTY. $400 LATER, IT IS FIXED... *TR
Service brakes, Hydraulic, Electrical system, Other or unspecified, Jun 10, 2011, fire
I DROVE MY VEHICLE HOME FROM WORK (LESS THAN 5 MILES). WHEN I PULLED INTO MY DRIVEWAY AND PARKED MY VEHICLE, SMOKE BEGAN TO POUR OUT FROM THE ENGINE COMPARTMENT. WHEN I OPENED THE HOOD THERE WERE FLAMES DIRECTLY IN FRONT OF THE DRIVER SIDE NEAR THE FIRE WALL. THESE FLAMES WERE ORIGINATING FROM THE ABS MODULE LOCATION.
Service brakes, Hydraulic, May 27, 2011
BRAKES WOULD FEEL LIKE THEY WERE FADING AND THEN ABS FELT LIKE IT WAS WORKING. NO WARNING LIGHTS WOULD COME ON. DEALER FOUND CRACKED ABS TONE RINGS. AN 800 DOLLAR REPAIR. *TR
Service brakes, Hydraulic, Other or unspecified, May 26, 2011
WHILE ACCELERATING ON AN ON-RAMP ENTERING A STATE HIGHWAY, TRAFFIC AHEAD OF ME CAME TO A STOP. I WENT FROM APPLYING PRESSURE ON THE GAS PEDAL TO IMMEDIATELY MOVING MY RIGHT FOOT TO THE BRAKE PEDAL TO APPLY PRESSURE. THE BRAKE PEDAL GAVE VERY LITTLE RESISTANCE. I DEPRESSED THE PEDAL ALL THE WAY TO THE FLOOR OF THE VEHICLE. MY VEHICLE CAME TO A VERY SLOW STOP AS IF I WAS ONLY LIGHTLY DEPRESSING THE BRAKE. MY TIRES DID NOT SKID AS I WOULD EXPECT AND THE VEHICLE TOOK SEVERAL SECONDS TO FINALLY COME TO A VERY SLOW AND GRADUAL STOP. THE STOP WAS SO SLOW AND GRADUAL THAT I COULD NOT EVEN FEEL MOMENTUM PUSHING MY BODY FORWARD AS USUALLY EXPERIENCED WHEN SUDDENLY BRAKING.
Engine and engine cooling, May 26, 2011, fire
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED WHILE THE VEHICLE WAS PARKED IN THE GARAGE, THE ENGINE CAUGHT FIRE. THE FIRE DEPARTMENT STATED THAT THE FIRE INITIATED IN THE ENGINE COMPARTMENT. A FIRE DEPARTMENT REPORT WAS FILED. THE MANUFACTURER FIWAS MADE AWARE OF THE FAILURE AND THE INSURANCE COMPANY WAS INVESTIGATING THE CAUSE OF FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 110,000.
Service brakes, Hydraulic, Electrical system, May 23, 2011, fire
ABS MODULE CONNECTOR CAUGHT FIRE WHILE CAR WAS PARKED. RECALL FOR ABS MODULE CONNECTOR INSPECTION WAS COMPLETED 7/6/2007. BROUGHT VEHICLE BACK IN 1/7/2008 DUE TO ABS LIGHT REMAINING ON. NO MENTION OF ABS, NOTED ROTORS BELOW SPECS AND BRAKE PADS NEED REPLACING.
Electrical system, May 23, 2011, fire
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT WAS DRIVING 60 MPH WHEN SPARKS STARTED TO SHOOT FROM UNDER THE HOOD. THE CONTACT WAS ABLE TO RAPIDLY MOVE THE VEHICLE FROM OFF THE ROADWAY AND AS THE HOOD WAS LIFTED, THE CONTACT NOTICED THAT THE ENGINE WAS ON FIRE. THE POLICE AND THE FIRE DEPARTMENT WERE DISPATCHED TO EXTINGUISH THE FIRE. A POLICE REPORT WAS AVAILABLE. THE VEHICLE WAS TOWED BACK TO THE CONTACTS RESIDENCE AND THE VEHICLE WAS DEEMED AS DESTROYED. THE VEHICLE WAS NOT INSPECTED FOR THE CAUSE OF THE ENGINE FIRE BUT THE FIRE DEPARTMENT ADVISED THAT THE FIRE COULD POTENTIALLY HAVE BEEN CAUSED BY AN ELECTRICAL FAILURE. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN. UPDATED 9/16/11 *CN UPDATED 2/9/12 *CN
Fuel system, Other, May 18, 2011
GAS TANK SHIELD AND STRAPS ARE RUSTED SO BADLY THAT THERE IS A 5" X 6" HOLE IN THE GAS TANK SHIELD. THE STRAPS HOLDING THE SHIELD ARE ALSO BADLY RUSTED. *TR
Engine and engine cooling, May 8, 2011, fire
APRIL 25, 2001 I DROVE THE CAR 5 MINUTES TO THE LOCAL POOL AND CAR WAS PARKED FOR ABOUT AN HOUR. |THEN DROVE FRIEND BACK HOME FROM LOCAL POOL TO HER HOUSE ABOUT A 5 MINUTE DRIVE, I THEN TURNED THE CAR IGNITION WAS OFF, SUDDENLY THERE WAS SMOKE COMING FROM UNDER THE ENGINE COMPARTMENT AREA. TRIED TO OPEN HOOD, GREY SMOKE BILLOWED OUT FROM UNDER THE HOOD, THEN SPARKS FELL ON THE PAVEMENT FROM UNDER THE CAR AND THEN FLAMES BURST OUT THROUGH THE OPEN CRACK OF THE HOOD. THE FIRE SEEMED SPONTANEOUS, THERE WAS A BURNING SMELL LIKE DIRTY AIR JUST BEFORE THE SMOKE STARTED. FIRE DEPARTMENT, POLICE AND AMBULANCE WERE CALLED. IT HAD NEVER OCCURRED BEFORE THE CAR WAS TOWED TO A LOCAL BODY SHOP AND WAS TAKEN TO ANOTHER LOCATION BY THE INSURANCE COMPANY. I KNOW THAT RECALL WORK WAS DONE ON THE CAR TWICE AND CAN VERIFY WITH THE SERVICE DEPARTMENT. I BELIEVE THAT WORK WAS DONE ON THE BRAKES AND THE GAS PEDAL AS INSTRUCTED IN THE RECALL NOTICES. I BELIEVE THE CAR IS STILL BEING EXAMINED BY THE INSURANCE INVESTIGATORS AS OF MAY 8, 2011. I HAVE BEEN INFORMED BY THE INSURANCE APPRAISER THAT THE VEHICLE IS A COMPLETE WRITE OFF. *TR
Other or unspecified, May 2, 2011
FRONT LOWER SUB-FRAME IS ROTTED OUT AND THE VEHICLE IS UNSAFE TO DRIVE. (MY SERVICE GARAGE, WHO HAVE MAINTAINED MY VEHICLE CONTINUOUSLY SINCE I BOUGHT IT, SAYS THIS IS VERY PREMATURE FOR THIS CONDITION TO OCCUR.)
Child seat, Apr 30, 2011
HAVE NOTICED ON MORE THAN ONE OCCASION THAT THE SUPERLATCH ON OUR XTSL IS LOOSENING TO A VERY UNSAFE LEVEL. IT IS INSTALLED FORWARD-FACING AND CHILD DOES NOT TOUCH THAT PART OF THE SEAT GETTING IN OR OUT. WHEN I'VE CHECKED THE SECURITY OF THE SEAT, IT WILL WOBBLE AT THE BOTTOM BACK & FORTH BY 3-5 INCHES. TIGHTENING IT ONLY FIXES IT TEMPORARILY SO IT IS NOT AN INSTALLATION PROBLEM, IT IS A FAILURE OF THE SUPERLATCH. I'M VERY CONCERNED ABOUT MY CHILD'S SAFETY IN THE EVENT OF A CAR ACCIDENT. I WILL BE SWITCHING THE SEAT BACK TO OUR OTHER CAR, A 2010 FUSION SEL AS I DID NOT NOTICE IT IN THAT CAR, BUT I WILL BE MONITORING IT VERY CLOSELY. (RELATED VEHICLE INFORMATION: MODEL YEAR=2002, MAKE=FORD, MODEL=ESCAPE). *TR
Electrical system, Air bags, Apr 27, 2011
MY AIRBAG LIGHT KEEPS COMING ON EVERY TIME I START MY FORD ESCAPE. UPON REVIEW OF THIS IT'S BEEN ON COMPLAINT WEBSITES SEVERAL TIMES BY HUNDREDS OF PEOPLE. HOW MANY OF THESE PEOPLE NEED TO DIE DUE TO MALFUNCTION OF THE AIR BAGS BEFORE WE HAVE A RECALL. THIS LIGHT HAS BEEN ON SINCE I'VE OWNED THE VEHICLE. ALSO MY WINDOW STOPPED GOING UP. THE DIPSTICK CAN'T GIVE A CLEAR READING OF THE OIL AMOUNT. THESE THINGS LEAD TO DEATH, CONSTANT AND COSTLY REPAIR, AND CONSTANT PROBLEMS. *TR
Electrical system, Apr 11, 2011, fire
2002 FORD ESCAPE ELECTRICAL FIRE. VEHICLE HAD BEEN DRIVEN THAT DAY, BUT HAD GONE LESS THAN A MILE WHEN IT WAS NOTED THE SUV HAD A SMOKY SMELL AND WE PULLED OVER. WITHIN MINUTES THE ENTIRE ENGINE COMPARTMENT WAS INVOLVED. IT APPEARED TO START NEAR THE BATTERY, THE BATTERY WAS APPROXIMATELY 8 WEEKS OLD. *TR
Fuel system, Gasoline, Mar 28, 2011
DRIVING TO DOVER DE. PULLED INTO GAS STATION OUTSIDE LANCASTER PA FOR FUEL. FILLED TANK AND WENT TO PULL AWAY FROM PUMP. HEARD SOMETHING DRAGGING AND FOUND FUEL TANK STRAP HAD SNAPPED AND LEFT FUEL TANK DRAGGING ON DRIVESHAFT. *TR
Power train, Mar 15, 2011
TL*THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 40 MPH THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE TRANSMISSION WAS DEFECTIVE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 150,000.
Service brakes, Hydraulic, Mar 14, 2011
ABS LIGHT CAME ON AS DID THE BRAKE SERVICE LIGHT. FOUND A RECALL NOTICE AND CALLED FORD. THEY STATED MY VEHICLE WAS NOT PART OF THE NOTICE AND IT DID NOT MATTER IF MY VEHICLE HAD THE IDENTICAL ISSUES WITH THE ABS MODULE. THEY BASICALLY SAID THEY WOULD DO NOTHING UNLESS A NEW RECALL NOTICE WAS ISSUED FOR THE SAME PROBLEM FROM OTHERS WHOSE VEHICLES WERE NOT INCLUDED IN THE FIRST RECALL! NEVER AGAIN FORD. NEVER. *TR
Service brakes, Hydraulic, Mar 10, 2011, fire
TL* THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH WHEN THE ABS LIGHT WANING ILLUMINATED AND THE CONTACT DETECTED AN ABNORMAL BURNING ODOR. THE FAILURE RECURRED SPORADICALLY BUT WAS NOT TAKEN TO THE DEALER OR A MECHANIC FOR THE FAILURE. SHE REFERENCED THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 07V156000 (SERVICE BRAKES, HYDRAULIC:ANTI LOCK:CONTROL UNIT/MODULE) AND CONTACTED THE MANUFACTURER WHO ADVISED THAT HER VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE MILEAGE WAS 105,000 AND THE CURRENT MILEAGE WAS 106,000.
Service brakes, Hydraulic, Feb 16, 2011
AFTER READING THE BELOW REPORT, WE TOOK OUR 2002 FORD ESCAPE TO GOLDEN CIRCLE FORD IN JACKSON TN. WE WERE INFORMED THAT THEY HAD NEVER HEARD OF THIS REPORT. OUR MASTER CYLINDER HAS BRAKE FLUID LEAKING ALL AROUND IT AND EVEN LEAVES SPOTS IN THE GARAGE. MY COMPLAINT IS THAT IT SEEMS ONE HAND HAS NO IDEA WHAT THE OTHER IS DOING. THESE REPORTS NEED TO ALSO GO TO THE DEALERSHIP SERVICE DEPARTMENTS SO THEY CAN BE FAMILIAR WITH PROBLEMS WITH THEIR PRODUCTS. TO DATE, OUR PROBLEM STILL HAS NOT BEEN RESOLVED. COMPONENT: SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER DETAILS: CERTAIN CARDONE MASTER CYLINDERS WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID. CONSEQUENCE: LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Engine and engine cooling, Electrical system, Other or unspecified, Feb 6, 2011, fire
THE VEHICLE WAS PARKED IN THE DRIVEWAY. WHILE TURNING THE IGNITION TO START, THERE WAS A CATASTROPHIC ENGINE EXPLOSION. THE HOOD LARGELY CONTAINED THE FIRE. LUCKILY NO ONE WAS INJURED AND THE FIRE DID NOT LAST LONG AND DID NOT SPREAD TO THE SURROUNDINGS. A TOW TRUCK WAS CALLED AND THE REPAIR SHOP TECHNICIAN FOUND THE "INTAKE MANIFOLD HAD BLOWN TO PIECES". A CODE ON THE SYSTEM INDICATED A MISFIRE ON CYLINDER 5. THE VEHICLE WAS REPAIRED FOR $1720, INCLUDING CAM POSITION SENSOR, INTAKE MANIFOLD, AND IGNITION COIL, RELATING TO THE INCIDENT.
Service brakes, Hydraulic, Feb 2, 2011
TL*THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT THE BRAKES FAILED WHILE HE WAS DRIVING 15 MPH. THE BRAKE LIGHT ILLUMINATED AT THE TIME OF THE FAILURE. THE CONTACT HAD THE EMERGENCY BRAKE SERVICE SIX MONTHS PRIOR TO THE FAILURE BUT THE ABS LIGHT ILLUMINATED THE DAY BEFORE THE FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO REPLACED THE MASTER CYLINDER AND BRAKE BOOSTER. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 103,689.
Visibility, Jan 14, 2011
OUR REAR HATCH WINDOW ON OUR 2002 FORD ESCAPE XLS EXPLODED OVERNIGHT WHILE SITTING UNDISTURBED IN OUR GARAGE. IT HAD BEEN SITTING FOR 10 HOURS IN OUR ENCLOSED GARAGE WHEN IT EXPLODED FOR NO REASON. THE TEMPERATURE OUTSIDE WAS IN THE SINGLE DIGITS. I'M WONDERING IF THE REAR DEFROST WASN'T CUT OFF WHEN THE CAR WAS SHUT OFF? WHEN I STARTED THE CAR AFTER THE WINDOW SHATTERED THE REAR DEFROST WAS ON. THERE ARE OTHER REPORTS ON THE INTERNET WITH SIMILAR OCCURRENCES. REAR WINDOW EXPLODING ON FORD ESCAPES SOUNDS COMMON. INSURANCE COMPANY IS SUPPOSE TO BE IN CONTACT WITH ME, BUT I IMAGINE WE WILL BE PAYING MOST OF THE REPAIR OUT OF POCKET SINCE WE HAVEN'T MET A DEDUCTIBLE. *TR
Engine and engine cooling, Jan 13, 2011
SPARK PLUG BLEW OUT OF THE HEAD WHICH ALSO BROKE THE IGNITION COIL HOUSING. I TAPPED THE SPARK PLUG HOLE IN THE HEAD TO ACCEPT A "HELI-COIL" INSERT AND REINSTALLED THE SPARK PLUG. ALSO HAD TO REPLACE THE COIL TO SECURELY MOUNT THE IGNITION COIL. FIX APPEARS TO BE WORKING... FOR NOW.
Service brakes, Hydraulic, Air bags, Jan 13, 2011, crash
TL*THE CONTACT OWNS A 2002 FORD ESCAPE. WHEN THE CONTACT APPLIED THE BRAKES AT A TRAFFIC LIGHT, THE BRAKE PEDAL EXTENDED TO FLOOR CAUSING THE CONTACT TO CRASH INTO A LIGHT POLE AT 25 MPH. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS TOWED TO THE CONTACTS HOME. THE VEHICLE HAD NOT BEEN INSPECTED, BUT THE CONTACT WAS CERTAIN THAT THE VEHICLE WAS DESTROYED. THE CONTACT REFERENCED NHTSA RECALL CAMPAIGN 07V156000, SERVICE BRAKES UNIT CONTROL MODULE; HOWEVER, THE RECALL REPAIR WAS PERFORMED TWO YEARS PRIOR TO THE CRASH AND THE REPAIR CAUSED THE CRASH TO OCCUR. THE FAILURE AND CURRENT MILEAGES WERE 220,000. UPDATED 3/8/11 *CN UPDATED 12/14/11 *CN
Air bags, Seat belts, Vehicle speed control, Jan 9, 2011, crash
MY 2002 FORD ESCAPE WAS BOUGHT NEW IN MARCH OF 2002. THE PROBLEM WITH IT ACCELERATING AT LOW SPEEDS STARTED ABOUT 6-7 MONTHS LATER. RETURNED TO THE DEALERSHIP MANY TIMES TO HAVE IT CHECKED BUT WAS TOLD EVERY TIME THERE WAS NOTHING WRONG. I'VE HAD ONE ACCIDENT AS A RESULT OF THIS PROBLEM. I STILL OWN THE SAME ESCAPE AND STILL HAVE THE PROBLEM WITH IT . I WAS TOLD THAT THERE WERE NO COMPLAINTS OF THIS NATURE WITH THESE MODELS BUT HAVE SINCE LEARNED THAT THERE HAVE BEEN MANY. I ALSO AS HAVE MANY PEOPLE HAD THE PROBLEM WITH THE AIR-BAG LIGHT ON .AGAIN MANY TRIPS TO THE DEALER AND WAS TOLD NOTHING WAS WRONG ABOUT $300 LATER FOR LABOR COSTS. FINALLY ON ONE MORE ATTEMPT TO FIND OUT WHAT WAS WRONG I RETURNED TO THE DEALER AGAIN AND WAS TOLD THAT A SENSOR IN THE SEAT-BELT WAS THE PROBLEM AND IT WOULD COST APPROXIMATELY $300-$400 TO REPAIR IT AND THAT THE AIR BAGS MAY OR MAY NOT BE WORKING BECAUSE OF THIS SENSOR. I HAVE PERSONALLY LOST ALL FAITH IN FORD CANADA AND THEIR PRODUCTS AND SOME OF THE EMPLOYEES AT THE DEALERSHIPS I'VE DEALT WITH. I AM IN THE PROCESS I BUYING A NEW CAR BUT IT'S NOT A FORD. NEVER AGAIN WILL I BUY A FORD
Structure, Jan 6, 2011
TL*THE CONTACT OWNS A 2002 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, SHE HEARD A METAL NOISE. WHEN SHE OPENED THE PASSENGER FRONT DOOR, IT FELL ON HER FOOT. SHE WAS ABLE TO PUT THE DOOR BACK IN PLACE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT THE FRONT PASSENGER DOOR PIN HAD BEEN INSTALLED UPSIDE DOWN. THE DEALER REPLACED THE DOOR PIN AND HINGE ASSEMBLY. THE CURRENT AND FAILURE MILEAGES WERE 114,083. UPDATED 02/17/11*LJ UPDATED 12/06/2011 *LN