2004 Ford Escape
Problems, recalls and owner-reported issues
Suspension is the leading concern among 499 owner complaints filed for this model year. This is the 19th highest complaint count among 26 Escape model years with reports.
Of the 2004 reports, 29 involved a crash and 14 involved a fire. 16 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Representative owner complaints: structure
138 reports, newest first. Show all
Suspension, Structure, Wheels, Dec 31, 2014
ANOTHER CASE OF A 2004 FORD ESCAPE WITH EXTENSIVE RIGHT REAR WHEEL WELL RUST PUTTING THE STRUT IN DANGER OF COMING THROUGH THE BODY. I'M CURRENTLY TRYING TO FIGURE OUT HOW AND WHERE TO GET IT REPAIRED. THIS SEEMS TO BE A FLAW IN THE DESIGN OF THE PRODUCT. WHILE ONE WOULD HOPE FORD WOULD STEP UP I'M NOT SEEING ANYTHING ON THEIR PART SO FAR. *JS
Suspension, Structure, Dec 31, 2014
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT A UNKNOWN SPEED, THERE WAS AN ABNORMAL NOISE COMING FROM THE PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DETERMINED THAT THE REAR PASSENGER AND THE DRIVER SIDE SUB FRAME AND THE SUSPENSION WAS RUSTED AND CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 123,000.
Suspension, Structure, Dec 24, 2014
I WAS DRIVING THE VEHICLE WHEN I STARTED HEARING A LOUD THUMPING NOISE COMING FROM THE REAR OF THE VEHICLE. UPON INSPECTION I DISCOVERED THERE WAS RUST INSIDE THE REAR PASSENGER WHEEL WELL AND THAT THE SHOCK MOUNT WAS UNATTACHED FROM THE VEHICLE. *TR
Suspension, Structure, Nov 15, 2014
DRIVING AND SOUNDS LIKE A SQUARE BOWLING BALL IS ROLLING AROUND IN BACK. LOOK TO FIND A RUSTY MESS FROM SHOCK MOUNT GOING THROUGH WHEEL WELL. ASKED AROUND AND SEEMS TO BE COMMON PROBLEM. THANK GOODNESS I WASN'T FAR FROM HOME. VERY DANGEROUS, WHY IS THIS NOT RECALLED YET! *TR
Structure, Oct 1, 2014
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT HEARD A CLUNKING SOUND NEAR THE REAR PASSENGER SIDE OF THE VEHICLE. THE DEALER STATED THAT THE WHEEL WELL WAS CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
Structure, Sep 29, 2014
RUNNING BOARD RUSTED AND FELL OFF. *TR
Structure, Wheels, Sep 25, 2014
THE RIGHTSIDE OF MY WHEELWELL WAS ROTTED OUT ALONG WITH THE FLOOR AROUND IT THAT HELD THE WHEEL WELL THE SHOCK NEEDED TO BE REPLACED AS WELL. WHEN I WENT TO THE DEALERSHIP TO GET THE WHEEL WELL THEY TOLD ME THIS WAS A WELL KNOWN PART TO BE REPLACED. SO I ASKED WHY WAS IT NOT A RECALL ON IT NO ANSWER COULD HE GIVE ME. I WAS GETTING A BURNING SMELL FROM MY EXHAUST (MUFFLER FUMES) AS I DROVE HOME MANY TIMES I FELT MYSELF GETTING SLEEPY AS I DROVE ON TO GET TO MY DESTINATION I PRAYED TOGET SAFELY THERE LITTLE DID I KNOW I WAS GETTING FUMES IN MY CAR THAT CAUSED THIS. I HAVE DRIVEN WITH MY YOUNG GRANDCHILDREN IN THIS DANGEROUS CONDITION IN THIS CAR MY QUESTION IS IF THE FORD DEALERSHIP KNEW OF THIS TO BE A WELL KNOWN PROBLEM WHY DID THEY NOT RECALL IT I ONLY THANK THE LORD THAT IT DID NOT KILL ME OR MY GRANDCHILDREN. ALSO IT PAST INSPECTION A YEAR AGO HOW COULD THEY HAVE NOT SEEN WHAT WAS HAPPENING IN THIS AREA. I DO HAVE PICTURES OF IT AND IT WAS EVEN WORST THEN THE PICTURES I HAVE SEEN ONLINE PROOF ONE MORE TIME THAT GOD IS ALWAYS ON YOURSIDE IF YOU BELIEVE EVERYONE ELSE PLEASE CHECK YOUR WHEEL WELL GOD BLESS! *TR
Suspension, Structure, Engine, Sep 17, 2014
VEHICLE BROUGHT INTO REPAIR SHOP AND FOUND THAT THE ENGINE CRADLE AND WAS ROTTED CONSIDERABLY. A RECALL NOTICE ON THIS PROBLEM WAS SENT TO THE CUSTOMER AND CUSTOMER TOOK INTO BRIGHT FORD, INC FOR THE RECALL. REPAIR WAS DONE SEVERAL MONTHS LATER AND RETURNED TO CUSTOMER MAY 16, 2004. THREE MONTHS LATER WE AGAIN HAVE THIS VEHICLE IN THE SHOP AND UPON INSPECTION THE LOWER CONTROL ARM BRACKET ROTTED OFF OF THE CRADLE AND CAUSED THE LOWER CONTROL ARM TO BE ONLY MOUNTED BY THE REAR BOLT. THIS CAR IS CONSIDERED A HAZARD TO DRIVE DUE TO THE RIGHT FRONT TIRE MOVEMENT NOT BEING CONTROLLED BY STEERING. BRIGHTON FORD ON THEIR INVOICE #19744, FOUND THE FRONT SUB FRMAE RUSTING THROUGH ON RIGHT HAND SIDE. SENT QUOTE FOR NEW SUB-FRAME AND WERE DENIED AND THEY WERE TOLD TO PUT THIS CROSS BRACE ON THE VEHICLE. THIS REPAIR IS NOT IN LINE WITH THE REPAIRS THAT WERE NEEDED. THE VEHICLE CANNOT BE DRIVEN AT THIS TIME AND BRIGHTON FORD SAYS IT IS YOUR RESPONSIBILITY TO DETERMINE REPAIR. THIS WAS NOT A SAFE REPAIR AND KNOWINGLY TOLD CUSTOMER THAT IT WAS REPAIRED. *TR
Suspension, Structure, Wheels, Sep 2, 2014
I WAS DRIVING HOME FROM THE STORE AND STARTED HEARING A LOUD BANGING NOISE COMING FROM THE REAR OF THE TRUCK. UPON INVESTIGATION I DISCOVERED WHAT I BELIEVE TO BE A MAJOR SAFETY CONCERN IN MY 2004 FORD ESCAPE. THE REAR PASSENGER SIDE WHEEL WELL OVER THE SHOCK TOWER COMPLETELY RUSTED OUT AND SEPARATED OVER THE SHOCK. I HAVE BEEN TOLD AND SEEN THAT THIS SEEMS TO BE A COMMON PROBLEM WITH MY VEHICLE AND OTHER YEARS OF ESCAPES. AFTER SPEAKING WITH AN INDEPENDENT BODY SHOP IN MY AREA THEY INFORMED ME THIS WAS A COMMON PROBLEM THEY HAVE SEEN SEVERAL TIMES BEFORE. BUT WHEN I CONTACTED 3 LOCAL FORD DEALERS THEY ALL CLAIMED TO HAVE NEVER SEEN IT BEFORE. AND WANTED TO CHARGE ME A HUNDRED DOLLARS JUST TO LOOK AT IT. I AM TOLD THE VEHICLE IS UNDRIVEABLE IN THIS CONDITION. AND THAT IN MOST CASES CAN NOT BE REPAIRED. AFTER DOING MUCH RESEARCH ONLINE I FOUND HUNDREDS OF OTHER PEOPLE WITH THE SAME EXACT PROBLEM. I HAVE ALSO CONTACTED FORD AND AM AWAITING A RESPONSE. I WOULD LIKE TO SEE A RECALL MADE ON THIS AS I CAN SEE THIS BEING A MAJOR PROBLEM THAT COULD HAVE CAUSED AN ACCIDENT. AND IS GOING TO BE A VERY EXPENSIVE REPAIR JOB IF IT IS EVEN REPAIRABLE. I HAVE PHOTOS BUT AM NOT SURE HOW TO ATTACH THEM. *TR
Structure, Aug 11, 2014
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT HEARD A LOUD ABNORMAL NOISE NEAR THE REAR OF THE VEHICLE. THE CONTACT DISCOVERED THAT THE REAR PASSENGER SIDE WHEEL SHOCK AND TOWER WERE SEVERELY CORRODED AND PENETRATED THE SUBFRAME AND FLOOR INTERIOR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.
Suspension, Structure, Aug 3, 2014
I HAVE A 2004 FORD ESCAPE . I RECEIVED A RECALL NOTICE FOR A CORROSION ISSUE WITH THE SUB FRAME WHERE IT CONNECTS TO THE LOWER CONTROL ARMS . I HAVEN'T HAD AN ISSUE WITH IT YET AND WAS PLANNING ON GETTING THE RECALL WORK DONE WITHIN THE NEXT COUPLE OF WEEKS . ON 8/02/2014 WHEN I PULLED IN MY DRIVEWAY I HEARD A LOUD CLUNKING NOISE COMING FROM THE REAROF MY ESCAPE . WHEN I LOOK IN THE RIGHT REAR WHEEL WELL I COULD SEE AN 8 INCH AREA AROUND THE SHOCK MOUNT HAD RUSTED COMPLETELY THROUGH THE SHOCK MOUNT WAS NO LONGER ATTACHED TO THE VEHICLE . I'M SURE THIS COULD HAVE CAUSED A ACCIDENT HAD I BEEN DRIVING DOWN THE ROAD WHEN IT HAPPENED . I DID A GOOGLE SEARCH AND FOUND AN ENDLESS LIST OF PEOPLE WITH THE SAME ISSUE . I CALLED MY LOCAL FORD DEALER AND WAS TOLD THEY COULD DO THE RECALL WORK ON THE FRONT OF THE VEHICLE BUT THERE WAS NOT A RECALL FOR THE REAR WHEEL WELL /SHOCK MOUNT . I CAN NOT BELIEVE THERE IS NOT A RECALL YET FOR SUCH A SERIOUS AND COMMON PROBLEM . PLEASE LOOK INTO THIS SITUATION . I WORK FOR FORD AND THIS MAKES ME SICK , THEY SHOULD NOT HAVE TO BE FORCED INTO IMPLEMENTING A RECALL FOR SUCH A SERIOUS PROBLEM . FORD SHOULD ISSUE A RECALL ON THEIR OWN BEFORE SOMEONE IS HURT OR DIES FROM THIS PROBLEM . THIS IS A CONTROL ITEM AND FORD SHOULD BE HELD ACCOUNTABLE ! *TR
Suspension, Structure, Wheels, Jul 31, 2014, crash
DRIVING DOWN THE ROAD WIRHT MY 2 YOUNG KIDS AND ALL SUDDEN GO OVER THE TRAIN TRACKS AND THE REAR STRUT BROKE FROM THE SHOCK MOUNT AND CAME RIGHT UP THRU THE VEHICLE I HAVE FOUND THOUSANDS OF COMPLAINTS ON THIS ISSUE, FORD NEEDS TO STEP UP LUCK I GAINED CONTROL OF VEHICLE WITH A 1 MONT OLD BABY AND A 3 YEAR OLD THIS IS SEARIOUS MATTER! SOMEONE IS GOING TO DIE BECAUSE OF THIS IT NEEDS TO BE FIXED! *TR
Steering, Suspension, Structure, Jul 26, 2014
JULY 26,2014 IN OCTOBER 2013, I COULD NOT GET MY CAR INSPECTED ( FORD ESCAPE 2004 ) BECAUSE THE SUB FRAME IN THE FRONT WAS SO BADLY RUSTED THE STEERING RODS WAS FALLING OFF AND WOULD NOT PASS INSPECTION. THIS WAS BEFORE THE RECALL NOTICE. 14502/NHTSA RECALL 14V-165, SO I HAD A NEW SUBFRAME INSTALLED. REFERENCE # 10547199. [XXX] AT CLARION FORD WOULD DO NOTHING BECAUSE THERE WAS NO RECALL AT THE TIME. I HAVE SENT ALL THE INFORMATION, AND COST, TO FORD IN JUNE 2014 AND HAVE NOT HEARD NOTHING FROM FORD. IS THERE ANYTHING THAT YOU COULD DO THAT WOULD HAVE FORD CONTACT ME? THANK YOU INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
Structure, Wheels, Seats, Jul 9, 2014
THE SHOCK TOWER IN THE PASSENGER SIDE REAR WHEEL HAS BROKEN, DUE TO RUST AND CORROSION, AND PUNCTURED THROUGH THE INTERIOR OF THE TRUNK AND THE BACK SEAT. THE INTERIOR OF THE CAR BODY HAS SEPARATED FROM THE EXTERIOR BODY SO THAT THE WHEEL AND ROAD CAN BE SEEN FROM INSIDE THE BACK SEAT THROUGH A LARGE (INCH OR MORE WIDE) GAP. THERE IS NO CORROSION OR DAMAGE IN ANY OTHER WHEEL WELL. THERE IS A CORROSION RELATED RECALL ON THIS CAR WHICH THE DEALERSHIP SAYS IS UNRELATED TO THIS PARTICULAR AREA OF THE CAR (SAFETY RECALL 14S02). FORD'S CUSTOMER "CARE" CENTER ACKNOWLEDGED MULTIPLE COMPLAINTS YET HAS NO INVESTIGATION OR ACTIVITY AIMED AT A REMEDY FOR THIS COMMON PROBLEM. DUE TO FORD'S APPARENT NEGLIGENCE WHICH HAS CAUSED HUNDREDS OF FORD OWNERS IDENTICAL DAMAGE, MY CAR IS UNSAFE AND FORD IS UNWILLING TO ACT. *TR
Structure, Jul 8, 2014
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE REAR PASSENGER SIDE STARTED TO RATTLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSE THAT THE REAR PASSENGER SIDE WHEEL WELL WAS CORRODED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 143,000.
Structure, Jul 6, 2014
MY DAUGHTER COMPLAINED ABOUT A LOUD CLANGING NOISE FROM THE RIGHT REAR OF HER CAR. I BOUGHT IT USED FROM A DEALER AND IT HAS BEEN KEPT IN A GARAGE AND USED SPARINGLY. UPON INSPECTION I NOTED THAT THE RIGHT REAR STRUT HAD COMPLETELY BROKEN FREE DUE TO EXTENSIVE RUST OF THE WHEEL WELL. I CANNOT ALLOW HER TO DRIVE IT IN THIS CONDITION. NOT SURE IF IT CAN BE REPAIRED YET OR WHETHER IT WILL COST MORE THAN THE CAR IS WORTH. I NOW RECOGNIZE THAT THERE ARE MANY OTHER OWNERS WITH THE EXACT SAME PROBLEM. WITH SO MANY OWNERS HAVING THE SAME EXPERIENCE SOMETHING SHOULD BE DONE. *JS
Suspension, Structure, Jul 1, 2014
I BOUGHT MY 04 ESCAPE BRAND NEW, AND AM THE ORIGINAL OWNER CAR GARAGE KEPT, THIS IS A SEVERE SAFETY ISSUE!! RUSTED OUT WHEEL WELL AND SHOCK MOUNT WENT RIGHT THROUGH THE FRAME WHILE DRIVING AT ONLY 15 MPH OUT OF A PARKING LOT. *TR
Suspension, Structure, Jun 30, 2014
THE RIGHT REAR SHOCK TOWER MOUNT COMPLETELY BROKE AWAY FROM THE VEHICLE SUBFRAME DUE TO CORROSION/RUST. THIS CAUSED THE SHOCK TO LEAN OUTWARD TOWARD THE TIRE. THIS COULD NOT BE SEEN BY THE UNDERCOATING AS A PROBLEM PREVIOUS AND APPARENTLY ALLOWED IT TO CORRODE TO THE POINT THAT IT BROKE FREE. THIS EXACT SAME ISSUE OCCURRED IN MY INSURANCE LADY'S FORD ESCAPE, WHICH I BELIEVE WAS ONLY ONE MODEL YEAR DIFFERENT. ALSO ONLY ON THE RIGHT REAR SHOCK TOWER. IN SPEAKING WITH THE BODY SHOP ON THE REPAIR, THEY HAVE ALSO HEARD OF THIS ISSUE AND STATE THAT FORD HAS NOT RECOGNIZED IT AS A RECALL ISSUE. THIS IS A COSTLY REPAIR, AND TIME CONSUMING REPAIR AS THE VEHICLE IS GONE FOR ALMOST A WEEK. THIS IS ALSO A VERY DANGEROUS ISSUE DUE TO HOW IT FALLS APART. WE ARE LUCKY WE WERE WITHIN THE CITY LIMITS AND ONLY TRAVELING ABOUT 30 MPH WHEN IT OCCURRED. *TR
Steering, Suspension, Electrical system, Structure, Jun 23, 2014
2004 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO LOWER CONTROL ARM RUST RECALL NOTICE. *SMD THE CONSUMER STATED WHILE DRIVING ON THE INTERSTATE, HE HEARD A LOUD NOISE FROM THE REAR WHEEL WELL ON THE PASSENGER SIDE. HE PULLED OVER, AND DISCOVERED THE SHOCK WAS HANGING DOWN. HE WAS UNABLE TO PULL IT OF. SO HE DROVE BACK HOME, AND UPON FURTHER EXAMINATION, HE DISCOVERED THERE WAS NO FENDER LEFT ON THE SHOCK. ALSO, THE TRUNK LID WAS RUSTING. *JB THE CONSUMER HE WAS ABLE TO REMOVE THE KEY FROM THE IGNITION WHILE THE GEAR WAS IN DRIVE. THE CONSUMER STATED HE PULLED INTO THE DRIVEWAY, SHUT THE ENGINE OFF AND PLACED THE KEYS IN THE CONSOLE. HE EXITED THE VEHICLE TO REMOVE ITEMS FROM THE BACK SEAT. SOON AFTER, THE VEHICLE STARTED TO ROLL BACKWARDS. UPDATED 06/01/16.*JB
Suspension, Structure, Wheels, Jun 19, 2014
RUSTED OUT RIGHT WHEEL WELL WITH STRUCTURAL COLLAPSE. WE BOUGHT THIS CAR USED FROM A LOCAL FORD DEALER IN APRIL OF 2013. THIS CAR WAS BEING DRIVEN ON A FREEWAY ON JUNE 15, 2014 WHEN A LOUD THUMPING STARTED IN THE RIGHT REAR WHEEL ON . ON INSPECTION THE RIGHT REAR WHEEL WELL IS RUSTED OUT. THE SUPPORT THAT THE SHOCK ABSORBER IS ATTACHED TO WAS COMPLETELY ERODED AND A PART OF IT PUNCHED THROUGH THE WALL INTO THE INTERIOR OF THE TRUNK AREA. WE FELT IT WAS NOT SAFE TO DRIVE. WE HAD IT TOWED TO ANOTHER FORD DEALER WHO DIAGNOSED THE PROBLEM. THE ESTIMATED COST OF REPAIR IS $2259. REVIEW OF THE NHTSA COMPLAINT WEB SITE REVEALS MANY OTHER OWNERS WITH EXACTLY THE SAME PROBLEM. *TR
Suspension, Structure, Jun 9, 2014
I HAVE A HOLE AND RUST FORMING IN THE PASSENGER SIDE REAR WHEEL. THIS IS BEGINNING TO EXPOSE THE SHOCK AREA. I LIVE IN A HIGH SALT AREA. *TR
Suspension, Structure, Jun 3, 2014
REAR PASSENGER SHOCK MOUNT RUSTING OUT. *TR
Visibility, Structure, May 31, 2014
OPENED REAR WINDOW WHEN BOLT CONNECTING WINDOW TO HINGE BROKE. WINDOW SHIFTED DOWNWARDS AND HAD IT NOT BEEN CAUGHT COULD'VE SHATTERED AND INFLICTED LACERATIONS TO HANDS, ARMS, FACE, AND CHEST. INSPECTION OF BLOT SHOW CORROSION DUE TO BEING IMPROPERLY SEALED FROM WATER AND OTHER ELEMENTS. *TR
Suspension, Structure, May 30, 2014
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE THE VEHICLE BEING SERVICED, IT WAS ADVISED THAT THE SUB FRAME WAS EXTREMELY CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO ADVISED THAT THE VEHICLE WAS NOT WORTH REPAIRING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V165000 (SUSPENSION FRONT) HOWEVER, THE CONTACT NO LONGER OWNED THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.
Suspension, Structure, Engine, May 27, 2014
I HAVE A 2004 FORD ESCAPE (6 CYL., FRONT WHEEL DRIVE) THAT NOW HAS OVER 110,000 MILES. AT 108,465 MILES, THE #2 CATALYTIC CONVERTER BLEW AND WAS REPLACED (ALONG WITH ALL 6 IGNITION COILS). A SECOND MECHANIC FOUND DEBRIS IN THE #3 CATALYTIC CONVERTER, CLEANED IT AND THE EXHAUST SYSTEM. (THE ENGINE WAS NOT GETTING ENOUGH AIR PASSING THROUGH THE EXHAUST SYSTEM AND WOULD BARELY MAKE IT UP A HILL.) THEN HE DISCOVERED THE RIGHT REAR WHEEL WELL WAS RUSTING OUT POSING A SEVERE THREAT THAT THE SHOCK ABSORBER WILL PUNCH THROUGH INTO THE BODY OF THE CAR MAKING THE ESCAPE TOTALLY INOPERABLE. A RECALL IS ALREADY OUT FOR FORD MINIVANS FOR THE SAME ISSUE BUT APPARENTLY NOT FOR THE ESCAPES. WHY NOT? THIS CAN BE REPAIRED AT A COST OF NEARLY $2,000. WITH THE CATALYTIC CONVERTER AND IGNITION COILS, I'VE ALREADY SPENT OVER $2500 AND DON'T HAVE THE $2,000 FOR THIS NECESSARY REPAIR DUE TO POOR MATERIALS USED TO MAKE THIS VEHICLE. *TR