2004 Ford Escape
Problems, recalls and owner-reported issues
Suspension is the leading concern among 499 owner complaints filed for this model year. This is the 19th highest complaint count among 26 Escape model years with reports.
Of the 2004 reports, 29 involved a crash and 14 involved a fire. 16 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Representative owner complaints
499 reports, newest first.
Suspension, Structure, Jul 9, 2017
WE HAD NOTICED WE WAS GETTING WATER INSIDE OUR ESCAPE BAD IT WAS STANDING WATER IN FLOOR BOARD SO WE LOOKED AT THE INNER AND OUTER WHEEL HOUSING AND IT WAS RUSTED VERY BAD THE MECHANIC SAID IT WAS NOT SAFE FOR US TO DRIVE. THE PASSENGER SIDE WAS THE WORST. THEY HAD TO WELD IN PIECES TO TRUCK AND FLOOR BOARDS NOW MIND YOU WE HAVE AN 11 YEAR OLD THAT RIDES RIGHT WHERE THIS WAS RUSTED THE WORST :( WHEN WE NOTICED THIS WE WAS IN KANSAS CITY MISSOURI AND HAD TO DRIVE HOME TO CARROLLTON. MISSOURI .I WILL HAVE A REPAIR INVOICE THIS WEEK CAUSE IT IS IN THE SHOP NOW GETTING FIXED AND THEY TOLD US AT THE SHOP THEY HAVE HAD TO REDO A LOT OF THESE BUT HAS NEVER BEEN THIS BAD PLEASE HELP SOMEONE IS GONNA GET HURT BAD.ALSO THIS IS A VERY EXPENSIVE REPAIR SO PLEASE HELP WITH THIS.IF YOU SEND ME SOMEWHERE TO SEND PICS I WILL GET THEM FROM THE SHOP BECAUSE THEY TOOK SOME.THANK YOU FOR TAKING TIME TO READ THIS
Suspension, Jul 7, 2017
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD A RATTLING NOISE FROM THE REAR OF THE VEHICLE. THE CONTACT NOTICED THAT THE REAR PASSENGER SIDE STRUT DETACHED FROM THE VEHICLE. THE CONTACT CALLED HOWELL MOTORS (LOCATED ON 6488 RIDGE ROAD LOCKPORT 14094) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15E045000 (SUSPENSION). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT OFFER ANY ASSISTANCE. THE MANUFACTURER STATED THAT NHTSA ISSUED RECALLS. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.
Other or unspecified, Jul 3, 2017
I BELIEVE I HAVE BEEN A VICTIM OF ODOMETER FRAUD. I PURCHASED MY 2004 FORD ESCAPE XLT FROM FIRST CHOICE RENTAL CARS & SALES 3517 OLD PETERSBURG RD MARTINEZ GA 30907. I PURCHASED THE VEHICLE FOR $4700 IN CASH. I RECENTLY FOUND OUT THROUGH CARFAX THAT I AM THE 4TH OWNER AND THE ODOMETER WAS PREVIOUSLY AT 186,475. MY CAR ODOMETER IS CURRENTLY READING AT 147,355 AND COUNTING BECAUSE I DRIVE THIS CAR DAILY. WHEN I PURCHASED THE VEHICLE THE BILL OF SALE DID NOT HAVE THE MILEAGE ON IT, THE BILL STATED EXEMPT. I WOULD LIKE TO KNOW CAN I GET MY MONEY BACK FOR THE VEHICLE, BECAUSE I WOULD HAVE NEVER BOUGHT THIS VEHICLE IF I WOULD HAVE KNOW THE ODOMETER HAD BEEN ROLLED BACK.
Engine and engine cooling, Structure, Vehicle speed control, Jun 28, 2017, crash
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHEN THE GEAR WAS SHIFTED INTO DRIVE, THE VEHICLE INDEPENDENTLY ACCELERATED IN EXCESS OF 30 MPH. AS A RESULT, THE CONTACT'S VEHICLE CRASHED INTO ANOTHER VEHICLE. THE CONTACT WAS ABLE TO STOP THE VEHICLE BY SHIFTING INTO NEUTRAL AND SHUTTING OFF THE ENGINE. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE INDEPENDENT MECHANIC (CT CONVEYOR LLC LOCATED AT 320 TERRYVILLE RD, BRISTOL, CT 06010; (860) 637-2926) WHERE IT WAS DIAGNOSED THAT THE CRUISE CONTROL CABLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBERS: 12V353000 AND 14V165000 (ENGINE AND ENGINE COOLING, VEHICLE SPEED CONTROL AND STRUCTURE). THE PARTS TO DO THE REPAIRS WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIRS. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 199,400. ..UPDATED 08/31/17 *BF *CN
Vehicle speed control, Engine, Fuel/propulsion system, Jun 12, 2017
MY 04 FORD ESCAPE HAS A 4 CYLINDER AND IS A MANUAL. IT HAS BEGUN TO ACCELERATE BY ITSELF. IT WILL ACCELERATE WHETHER IT IS IN GEAR OR IN NEUTRAL. I ASSUMED THERE WOULD RECALL FOR THIS PROBLEM, AS I KNOW OTHER VEHICLES HAVE BEEN IN SERIOUS ACCIDENTS WITH SIMILAR PROBLEMS. I CAN TAKE MY FOOT OFF OF THE PEDAL AND IT WILL STAY AT A STEADY SPEED, OR ACCELERATE, ON ITS OWN. OFTEN WHEN I'M SWITCHING GEARS, PUT IT IN NEUTRAL, IT WILL SELF-REV ITSELF UP TO 4000+ RPMS! I WILL HAVE TO WAIT AND COAST FOR ABOUT 10 TO 30 SECONDS FOR IT TO BRING ITSELF BACK DOWN TO A REASONABLE RPM TO GET IT INTO THE NEXT GEAR. SO, IT IS INTERMITTENT, BUT HAPPENS ABOUT 50% OF THE TIME YOU ARE DRIVING IT, AND AT TIMES CAN BE VERY DANGEROUS. I ASSUMED FORD MIGHT PAY FOR THE REPAIR AS THIS IS A DANGEROUS SITUATION, HOWEVER MY DEALER SAYS "NO" BECAUSE THERE IS NO RECALL.
Engine, May 1, 2017
VEHICLE AT IDLE, MISFIRED. PULLED OFF AND WENT TO DRIVE ONTO THE HIGHWAY. VEHICLE LOST ALL POWER AND IT GOT WORSE. A SMELL CAME FROM THE FRONT AND SMOKE CAME OUT OF THE DASH. HAD THE DRIVER, TWO TODDLERS, AND I (PASSENGER) IN THE VEHICLE. DRIVER AND I WERE COUGHING FROM THE SMELL AND THE SMOKE. HAD TO ROLL DOWN THE WINDOWS IN THE FRONT AND PARTLY ROLL THEM DOWN IN THE REAR DURING THE RAIN. MADE IT 2-3 MILES BEFORE WE TURNED AROUND AND WENT BACK HOME.
Structure, Apr 24, 2017
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING 35 MPH, THE VEHICLE BEGAN TO SHAKE VIOLENTLY WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUBFRAME WAS CRACKED AND NEEDED TO BE REPLACED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRAME FRACTURED AND NEEDED TO BE REPLACED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE CONTACT WAS INFORMED THAT THE DAMAGE WAS TOO EXTENSIVE TO BE REMEDIED PER THE RECALL. THE MANUFACTURER STATED THAT DUE TO THE AGE AND MILEAGE OF THE VEHICLE, ASSISTANCE WOULD BE DENIED. THE FAILURE MILEAGE WAS UNKNOWN.
Suspension, Apr 12, 2017
STRUCTURE: FRAME AND MEMBERS. MY LOWER CONTROL ARM REAR RIGHT RUSTED OUT SEPARATING ENTIRELY FROM THE BODY OF MY ESCAPE. I LIVE IN MICHIGAN AND NOTICED A FORD RECALL 14V165000 BUT WHEN I CALLED THE FORD DEALERSHIP THEY INFORMED ME THAT MY VEHICLE IS NOT AFFECTED BY IT. I QUIT DRIVING MY FORD FOR RISK OF CRASHING. PLEASE INFORM ME WHY MY VEHICLE IS NOT AFFECTED BUT IT IS EXACTLY WHAT HAPPENED TO MY FORD. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB
Vehicle speed control, Apr 12, 2017
WHEN PRESSIG ON THE GAS PEDAL TO PASS ANOTHER VEHICLE , MY VEHICLE BEGAN TO INCRESS IN SPEED AND WOULD NOT STOP.THE PEDAL STUCK AND I HAD NO CONTROL OF THE SPEED OF THIS VEHICLE. SPEED REDUCED WHEN GEAR SHIFT PLACED IN NETURAL AND THEN WHEN SLOW ENOUGH INTO REVERSE. WHEW!!!! WIFE AND I THOUGHT WE WERE A GONNER. THIS HAPPEN ON THE HIGHWAY. SEED REACHED COLSE TO 90 MILE AN HOUR BEFOR BROUGHT UNDER CONTROL.
Suspension, Structure, Apr 12, 2017
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING 35 MPH, THE VEHICLE VIOLENTLY BOUNCED UP AND DOWN WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE REAR SUBFRAME WAS RUSTED AND CORRODED AND THE REAR LOWER CONTROL ARM SEPARATED FROM THE VEHICLE. THE TECHNICIAN STATED THAT THE REAR LOWER CONTROL ARMS NEEDED TO BE REPLACED. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE), BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 118,000.
Suspension, Structure, Mar 29, 2017
MY 2004 FORD ESCAPE HAS MAJOR RUST ISSUES THAT HAS AFFECTED THE STRUCTURAL INTEGRITY OF THE VEHICLE. THE VEHICLE IS NOT DRIVEABLE UNLESS THE RUST IS REPAIRED. I JUST FILED A COMPLAINT WITH FORD (CASE #CAS12002459). CURRENTLY THERE ARE NO RECALLS ON THE VEHICLE AND AS A CONSUMER I AM TURNING TO THE NHTSA FOR SUPPORT IN HAVING FORD MAKE THE NCESSARY REPAIRS YO MY VEHICLE.
Other or unspecified, Mar 13, 2017
DANGEROUS FAILURE OF MY CAR FRAME, WHILE I WAS DRIVING ON A PUBLIC ROAD. THIS FAILURE HAPPENED AFTER THE FRAME PROBLEM WAS IDENTIFIED AND REMEDIED A FEW YEARS EARLIER. IT WAS A SEPARATION OF THE LOWER CONTROL ARM WHERE IT MEETS THE FRAME. VERY SCARY.
Power train, Feb 10, 2017
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE TRANSMISSION SLIPPED WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE BECAME UNABLE TO BE DRIVEN. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.
Suspension, Structure, Jan 24, 2017
I WAS DRIVING TO WORK ON A SMOOTH ROADWAY AND ALL OF A SUDDEN MY REAR END STARTED TO CLUNK AND BANG. I WAS SO STARTLED THAT I HAD TO PULL OVER IN HEAVY MORNING TRAFFIC AND HAD TO MISS WORK AND TAKE IT TO A MECHANIC WHERE I WAS TOLD THE REAR SHOCK ASSEMBLIES HAD SNAPPED FROM THE VEHICLE. AFTER DUE DILIGENCE I FOUND THERE WAS A RECALL ISSUED FOR THE FRONT END FOR THE SAME MAKE AND MODEL BECAUSE OF MOUNTS SEPARATING FROM THE AUTO DUE TO SALT AND CORROSION. WHEN I CONTACTED FORD I WAS TOLD THERE WAS NO RECALL FOR THAT SITUATION, BUT I DID FIND A LARGE AMOUNT OF COMPLAINTS FROM INDIVIDUALS WITH THE SAME ISSUE IN THEIR SAME YEAR AND MODEL ESCAPES. THE MECHANIC TOLD ME AT THE LEAST IT WILL BE 1800 TO FIX, BUT SINCE THERE IS NO METAL TO WELD TO IT WILL REQUIRE A FULL REBUILD OF THE BODY, MOUNTS, AND FRAME IN THAT AREA. THE FOLLOWING SITE IS A REPRESENTATION OF THE ISSUEHTTP://WWW.FORDFORUMS.COM/F59/2005-ESCAPE-SHOCK-MOUNT-RUSTED-OUT-177762/INDEX4.HTML. *TR
Vehicle speed control, Jan 23, 2017
UNABLE TO ACCELERATE CAR WHILE DRIVING FORWARD ON A CITY STREET. AFTER GETTING THE VEHICLE TO A SAFE LOCATION WE NOTICED THE CABLE CONNECTING THE ACCELERATOR PEDAL HAD SHEARED AND COMPLETELY DETACHED FROM THE PEDAL. *TR
Structure, Dec 30, 2016, crash
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE SWERVED INDEPENDENTLY INTO A DITCH. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE CONTACT NOTICED THAT THE SUBFRAME WAS RUSTED AND DETACHED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
Structure, Nov 21, 2016
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT TOOK THE VEHICLE TO A LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE SUBFRAME NEEDED TO BE REPLACED. THE MANUFACTURER DID NOT WANT TO REPLACE THE SUBFRAME FOR FREE. THE CONTACT STATED THAT THE VEHICLE COULD NOT BE DRIVEN LONG DISTANCES. THERE WERE NO RECALLS FOR THE VEHICLE. THE FAILURE MILEAGE WAS 100,000.
Suspension, Structure, Nov 17, 2016
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING OVER A BUMP IN THE ROAD AT ANY SPEED, A THUMPING NOISE EMITTED FROM THE VEHICLE. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND NOTICED THAT THE REAR PASSENGER SIDE WHEEL WELL WAS RUSTED AND THE SHOCK ABSORBER HAD LOOSENED. THE CONTACT NOTIFIED THE MANUFACTURER. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.
Power train, Electrical system, Engine, Nov 2, 2016
ABS LIGHT AND ENGINE LIGHT CAME ON WHILE DRIVING AND VEHICLE SHUT DOWN COMPLETELY. TOWED TO SHOP TO HAVE REPLACED THE ALTERNATOR AND BATTERY BAD. SINCE THEN 3- ALTERNATORS, 2- BATTERIES, 3- O2 SENSORS, AND AN AIRBAG LIGHT THAT BLINKS ON AND OFF AND ILLUMINATES WHEN YOU HONK THE HORN ON THE STEERING WHEEL. ALSO WHEN TURNING ON HEADLIGHTS, ALL DASH LIGHTS AND STEREO CONSOLE LIGHTS DIM TO ALMOST INVISIBLE. TOOK TO 4 DIFFERENT FORD DEALERSHIPS AND NO ONE CAN FIGURE OUT THE PROBLEM!!!! THIS COMPANY SHOULD REALIZE THIS CAR IS A LEMON, AND BACK THEIR WORKMANSHIP. AND BLOW THIS CAR UP !!! *TR
Power train, Oct 25, 2016
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. AFTER DRIVING THE VEHICLE AND SHIFTING INTO PARK, THE GEAR SHIFT INDICATED THAT IT WAS IN THE PARK POSITION. HOWEVER, THE VEHICLE WAS STILL IN THE DRIVE POSITION AND WOULD NOT SHIFT OUT OF THE DRIVE POSITION. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V606000 (POWER TRAIN). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.
Structure, Oct 24, 2016
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE FRONT SUBFRAME WAS RUSTED AND AFFECTED THE CONTROL ARM. THERE WAS A RECALL FOR THE FRONT SUBFRAME RUST; HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT REQUESTED THAT THE VIN BE INCLUDED IN THE RECALL. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 111,255.
Suspension, Sep 30, 2016
STRUT MOUNT PASSENGER SIDE REAR RUSTED RIGHT OUT
Steering, Suspension, Wheels, Sep 13, 2016
MY VEHICLE WAS SERVICED FOR RECALL THAT WAS ISSUED. THE RECALL WAS FOR THE SUBFRAME RUSTING THROUGH WHERE IT MEETS THE CONTROL ARM RESULTING IN STEERING FAILURE. MY VEHICLE HAD THIS PROBLEM UNDER WAY AND WAS RUSTED THROUGH TO THE POINT OF SEPARATION. THE DEALERSHIP PERFORMED THE RECALL AND INSTALLED A "BRACE" ON THE SUBFRAME BUT ADVISED THAT THE VEHICLE WAS NOT SAFE TO DRIVE BECAUSE OF THE SEPARATION, WHICH IS EXACTLY WHAT THE RECALL IS DESIGNED TO PREVENT. THE DEALER STATED THAT SINCE THE FAILURE/SEPARATION HAD ALREADY BEGUN THEY COULD NOT REPAIR IT AND GAVE ME THE VEHICLE BACK IN A CONDITION WHICH IS "UNSAFE TO DRIVE", ACCORDING TO THE WORD OF THE DEALERSHIP. MY CONCERN IS THAT MY VEHICLE IS EXPERIENCING THE SAFETY ISSUE FOR WHICH THE RECALL WAS ISSUED AND THE VEHICLE MANUFACTURER WILL NOT RESOLVE THE RECALL ISSUE.
Structure, Wheels, Aug 30, 2016
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE FRONT PASSENGER SIDE TIRE AND FRAME FRACTURED AND CAUSED SPARKS TO EMIT FROM THE VEHICLE. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT HAD RECEIVED NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.
Suspension, Structure, Aug 29, 2016
PASSENGER REAR WHEEL WELL HAS COMPLETELY RUSTED OUT AND SHOCK AND MOUNT HAVE RUSTED AND BROKEN OFF OF FRAME. WHILE DRIVING THE VEHICLE ON A VILLAGE STREET, HIT A ROUGH PATCH OF ROAD BY A MANHOLE AND HEARD A TERRIFYING NOISE, THEN IT SOUNDED LIKE THE BACK OF THE CAR WAS GOING TO FALL OFF. UPON PARKING AND INSPECTING THE VEHICLE, THE BROKEN PIECE WAS PRESSED AGAINST THE REAR TIRE, AND HAD RUBBED SOME OF THE RUBBER OFF IN THE SHORT TIME IT WAS DRIVEN AFTERWARD. RESEARCH SHOWS THAT FRAME CORROSION SEEMS TO BE A COMMON PROBLEM WITH THE VEHICLE, AND THERE WAS A RECALL FOR CORROSION ON THE FRONT END. IT SEEMS THAT IT SHOULD BE FOR THE ENTIRE FRAME, AND RECTIFIED BEFORE ACCIDENTS AND INJURIES OCCUR. MY VEHICLE FALLS UNDER THOSE DATE AND STATE PARAMETERS, YET THE VIN # IS NOT INCLUDED FOR SOME UNKNOWN REASON. FRONT RECALL: FORD MOTOR COMPANY (FORD) IS RECALLING CERTAIN MODEL YEAR 2001-2004 ESCAPE VEHICLES MANUFACTURED OCTOBER 22, 1999, THROUGH JANUARY 23, 2004, ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN AND THE DISTRICT OF COLUMBIA. THESE VEHICLES MAY EXPERIENCE EXCESSIVE CORROSION AT THE FORWARD ATTACHMENT OF THE LOWER CONTROL ARM. CONSEQUENCE: A SEPARATION OF THE LOWER CONTROL ARM CAN RESULT IN A SIGNIFICANT LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH. REMEDY: FORD WILL NOTIFY OWNERS, AND DEALERS WILL INSTALL A NEWLY DESIGNED REINFORCEMENT CROSS-BRACE, FREE OF CHARGE. THE RECALL BEGAN ON MAY 30, 2014. OWNERS MAY CONTACT FORD AT 1-800-392-3673. FORD'S NUMBER FOR THIS RECALL IS 14S02.