2004 Ford Escape
Problems, recalls and owner-reported issues
Suspension is the leading concern among 499 owner complaints filed for this model year. This is the 19th highest complaint count among 26 Escape model years with reports.
Of the 2004 reports, 29 involved a crash and 14 involved a fire. 16 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Structure, frame and membersApr 2, 2014
Ford Motor Company (Ford) is recalling certain model year 2001-2004 Escape vehicles manufactured October 22, 1999, through January 23, 2004, originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. These vehicles may experience excessive corrosion at the forward attachment of the lower control arm.
A separation of the lower control arm can result in a significant loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will install a newly designed reinforcement cross-brace, free of charge. The recall began on May 30, 2014. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 14S02.
Campaign 14V165000 on NHTSA.gov
Engine and engine coolingJul 26, 2012
Ford Motor Company is recalling certain model year 2001 through 2004 Escape vehicles equipped with 3.0L V6 engines and speed control manufactured from October 22, 1999, through January 23, 2004. Inadequate clearance between the engine cover and the speed control cable connector could result in a stuck throttle when the accelerator pedal is fully or almost-fully depressed. This risk exists regardless of whether or not speed control (cruise control) is used.
A stuck throttle may result in very high vehicle speeds and make it difficult to stop or slow the vehicle, which could cause a crash, serious injury or death.
Ford will notify owners, and dealers will repair the vehicles by increasing the engine cover clearance, free of charge. The safety recall began August 3, 2012. Remedy parts are expected to be available in mid-August 2012. Until then dealers will disconnect the speed control cable as an interim remedy, if parts are not available at the time of an owner's service appointment. Owners may contact Ford at 1-866-436-7332.
Campaign 12V353000 on NHTSA.gov
Service brakes, hydraulic, antilock/traction control/electronic limited slip, control unit/moduleApr 10, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH ANTILOCK BRAKES (ABS), THE ABS MODULE CONNECTOR MAY HAVE MISSING OR DISLODGED WIRE SEALS. THIS CONDITION COULD ALLOW CONTAMINATION TO ENTER THE MODULE CONNECTOR, CREATING A POTENTIAL FOR AN ELECTRICAL SHORT.
AN ELECTRICAL SHORT MIGHT CAUSE AN ABS MALFUNCTION THAT WOULD ILLUMINATE THE ABS WARNING LIGHT, AND IN SOME CASES, THE MODULE MAY OVERHEAT RESULTING IN BURNING ODOR, SMOKE, AND/OR FIRE. THIS CONDITION COULD OCCUR EITHER WHEN THE VEHICLE IGNITION SWITCH IS IN THE OFF POSITION OR WHILE THE VEHICLE IS BEING OPERATED.
DEALERS WILL INSPECT THE WIRE HARNESS CONNECTOR TO THE ABS MODULE FOR MISSING OR DISLODGED WIRE SEALS, AND REPAIR OR REPLACE THE HARNESS CONNECTOR AS APPROPRIATE. THE DEALER WILL ALSO INSPECT THE CONNECTOR ON THE ABS MODULE AND REPLACE IT IF IT IS FOUND TO BE CORRODED OR DAMAGED. THE RECALL BEGAN ON APRIL 23, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V156000 on NHTSA.gov
Service brakes, hydraulic, foundation components, master cylinderMar 29, 2007
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.
Campaign 07E023000 on NHTSA.gov
Latches/locks/linkages, doors, latchDec 20, 2004
CERTAIN 2004-2005 SPORT UTILITY VEHICLES AND CERTAIN 2001-2003 SPORT UTIITY VEHICLE HAVING REAR LIFTGATE COMPONENTS SERVICED WITH 2004 EQUIVALENT COMPONENTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 206, 'DOOR LOCKS AND DOOR RETENTION COMPONENTS.' THE REAR LIFTGATE LATCHING SYSTEM DOES NOT MEET THE INERTIA LOAD REQUIREMENT IN ONE DIRECTION.
IF THE LIFTGATE IS LEFT UNLOCKED, THERE IS THE POTENTIAL THAT IT MAY OPEN DURING A CRASH.
DEALERS WILL REPLACE THE REAR LIFTGATE LATCH RELEASE ROD, THE RELEASE ROD ATTACHMENT CLIP AND THE DOOR HANDLE RETURN SPRING. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V602000 on NHTSA.gov
Vehicle speed control, cablesDec 7, 2004
ON CERTAIN SPORT UTILITY VEHICLES BUILT WITH 3.0L V6 ENGINES, THE ACCELERATOR CABLE MAY PREVENT THE THROTTLE FROM RETURNING TO THE IDLE POSITION.
AN UNEXPECTED INCREASE IN ENGINE IDLE SPEED MAY INCREASE STOPPING DISTANCE AND MAY RESULT IN A VEHICLE CRASH.
DEALERS WILL REPLACE THE ACCELERATOR CABLE. THE RECALL BEGAN ON JANUARY 10, 2005. OWNERS SHOULD CONTACT FORD AT 1-866-436-7332.
Campaign 04V574000 on NHTSA.gov
Representative owner complaints
499 reports, newest first.
Structure, Mar 3, 2016
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 25 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,000.
Suspension, Mar 3, 2016
MY REAR SHOCK MOUNT TOWER IS RUSTED OUT AND BANING IT IS READY TO COME UP THROUGH THE INTERIOR.
Suspension, Structure, Feb 21, 2016
THE FRAME AROUND THE REAR SUSPENSION IS RUSTED OUT (THROUGH) THE REAR SHOCK IS NOT CONNECTED TO ANYTHING. IS THERE A RECALL ON THIS ? I KNOW THE VEHICLE IS OLD BUT I HAVE NEVER HEARD OF THIS ON EVEN OLDER VEHICLES.
Steering, Suspension, Structure, Feb 18, 2016
ENGINE CRADLE, PART OF THE FRAME IS UNDER RECALL,IS BROKE. DEALER APPLIED "BAND-AID" MANUFACTURER DECLINES TO REPLACE BROKEN CROSS-MEMBER, EVEN THOUGH IT IS UNDER RECALL. RECALL #14V165000
Suspension, Structure, Wheels, Feb 3, 2016
I JUST PURCHASED A USED 2004 FORD ESCAPE XLT WITH ONLY 45,000 MILES ON IT (12 YEARS OLD, 45,000'WHAT I THOUGHT WAS A DIAMOND IN THE ROUGH). IT HAD UNDERCOATING TO PROTECT FROM RUST WHEN IT WAS NEW. VERY WELL TAKEN CARE OF, LIKE NEW INSIDE! SO IMAGINE MY SURPRISE AFTER DRIVING IT 2 MONTHS WHEN THE PASSENGER SIDE REAR WHEEL WELL STARTED FALLING APART (WASN'T LIKE THAT WHEN I BOUGHT IT). WITHIN A 3 WEEK SPAN IT WAS ALMOST COMPLETELY DESTROYED. AGAIN IT WAS PROTECTED WITH UNDERCOATING AND STILL RUSTED OUT ALL THOSE YEARS IN A GARAGE BEING BARELY DRIVEN!!! I ASKED ABOUT GETTING BOTH SIDES DONE WHILE IT'S IN THE SHOP AND MECHANIC SAID THE DRIVER SIDE REAR WELL WAS FINE AND IN GOOD SHAPE, ALMOST NO RUST AT ALL. FORD STOCKS ONLY THE PASSENGER WHEEL WELL, NOT THE DRIVER SIDE. THIS IS OBVIOUSLY A KNOWN MANUFACTURING FAILURE/SUBSTANDARD PART THAT FORD DOESN'T WANT TO OWN BEYOND SELLING YOU THE REPLACEMENT PART. I'M LOSING APPRECIATION FOR "AMERICAN MADE" VALUES. THIS ONE IS ESPECIALLY UPSETTING BECAUSE IT'S A BRAND I PREVIOUSLY HELD IN HIGH REGARD. THIS EASILY COULD HAVE BEEN DANGEROUS AT HIGH SPEEDS ON MY TRIPS.
Power train, Jan 29, 2016
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT MENTIONED THAT THE VEHICLE REMAINED IDLE WHEN THE GEAR WAS PLACED IN THE DRIVE POSITION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 81,200.
Engine and engine cooling, Vehicle speed control, Jan 13, 2016
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE REVVED AND UNINTENDED ACCELERATED, WHILE DRIVING AT LOW SPEEDS. THE CONTACT WAS ABLE TO ENGAGE THE BRAKE PEDAL, SHIFTED THE GEAR INTO NEUTRAL, ENGAGED THE EMERGENCY BRAKE, AND COASTED THE VEHICLE OUT OF TRAFFIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V353000 (ENGINE AND ENGINE COOLING, VEHICLE SPEED CONTROL). THE APPROXIMATE FAILURE MILEAGE WAS 113,000. UPDATED 01/05/2017*CT THE CONSUMER STATED ON JANUARY 18, 2016, THE DEALER REPLACED THE PCV HOSE CONNECTOR. ON FEBRUARY 14, 2016 IT FROZE UP AGAIN AND ON FEBRUARY 17TH THEY CLEANED IT AGAIN AND REPLACED THE VACUUM COUPLING. ON DECEMEBR 15, 2016 WHILE DRIVING DOWN THE HIGHWAY, THE THROTTLE STUCK WIDE OPEN AGAIN. THE PVC AREA WAS COMPLETELY FROZEN AGAIN. THE CONSUMER CLEANED IT, ONLY TO FREEZE AGAIN. UPDATED 02/14/17.*JB
Vehicle speed control, Dec 16, 2015
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT ACCELERATOR PEDAL WAS DEPRESSED BUT THE ACCELERATOR PEDAL WENT TO THE FLOORBOARD, AND THE VEHICLE FAILED TO ACCELERATE. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE ACCELERATOR CABLE FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS MADE AWARE OF NHTSA CAMPAIGN NUMBER: 04V574000 (VEHICLE SPEED CONTROL), BUT THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 117,000.
Air bags, Dec 15, 2015
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE STARTING THE VEHICLE, THE AIR BAG WARNING LIGHT ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 72,400.
Suspension, Dec 10, 2015
RIGHT REAR FENDER WELL RUSTED AWAY SHOWING INSIDE OF TRUNK LINER AND MAKING LOUD BANGING NOISES
Suspension, Structure, Dec 7, 2015
SHOCK FRAME SUPPORT ON RIGHT REAR SIDE COMPLETELY RUSTED OUT MAKING VEHICLE UNSAFE TO DRIVE ALONG WITH ENTIRE AREA RUSTING OUT PREMATURELY. I CAN SEE THE OUTSIDE THRU MY SPEAKER GRILL. HOW COULD THIS NOT BE A SAFETY RECALL WHEN IT IS CLEARLY A FORD DEFECT? REPAIR QUOTES IN THE $2000- $2500 RANGE.
Structure, Dec 6, 2015
OUR 2004 FORD ESCAPE IS MAKING METALLIC CREAKING, SQUEAKING AND GROANING SOUNDS FROM THE PASSENGER SIDE REAR. THE SOUND IS TRIGGERED BY JUST SITTING IN THE STATIONARY CAR AND ROCKING BACK AND FORTH. IT BECOMES CONSTANT AS SOON AS THE VEHICLE STARTS MOVING. THERE ARE ALSO OCCASIONAL HEAVY METALLIC THUMPS OR KNOCKS ON THE PASSENGER SIDE OR UNDERSIDE OF THE CAR, AND THE RIDE IS ROUGH. THE PASSENGER SIDE REAR INNER METAL WHEELHOUSE IS EXTREMELY RUSTY. A FEW HOLES ARE SEVERAL INCHES SQUARE & GO ALL THE WAY THROUGH INTO THE INTERIOR OF THE CAR. PART OF THE RUST IS VERY NEAR WHERE THE TOP OF THE SHOCK ABSORBER BOLTS INTO THE WHEELHOUSE. THE WHEELHOUSE METAL IS SO RUSTY THAT I CAN FLEX IT WITH MY HAND AND CAUSE THE CREAKING SOUNDS. I BELIEVE THE HEAVY METALLIC THUMPS ARE CAUSED WHEN THE CONICAL BUMPER INSIDE THE TOP OF THE SPRING BOTTOMS OUT AND HITS THE SUSPENSION MOUNTED TO THE BOTTOM OF THE SPRING. THIS LIKELY HAPPENS BECAUSE THE SHOCK ABSORBER CANNOT STOP IT, SINCE THE RUSTY WHEELHOUSE BENDS SO MUCH. THIS SERIOUS SAFETY PROBLEM IS HEAVILY DOCUMENTED ON THE INTERNET BY A VERY LARGE NUMBER OF PEOPLE. THE TOP OF THE SHOCK ABSORBER COULD CRASH THROUGH THE WHEELHOUSE AND PROTRUDE INTO THE CAR INTERIOR, INJURING OCCUPANTS OF THE CAR. THIS WOULD MAKE LOSS OF CONTROL MORE LIKELY. IT WOULD BE EXTREMELY DANGEROUS IF THE SHOCK ABSORBER BREAKS FREE AND BECOMES TANGLED UP WITH THE REAR WHEEL OR PUNCTURES THE TIRE. THIS CAR IS A UNIBODY CONSTRUCTION, SO THIS WHEELHOUSE IS SUPPOSED TO PROVIDE STRUCTURAL STRENGTH FOR THAT PART OF THE CAR. IN THE EVENT OF A CRASH THIS RUSTY WHEELHOUSE WILL DISINTEGRATE AND NOT PROPERLY ABSORB THE CRASH ENERGY LIKE IT IS SUPPOSED TO. THIS MAKES IT MORE LIKELY THAT THE OCCUPANTS WILL GET INJURED. PLEASE FORCE A VEHICLE RECALL ASAP WHICH MAKES FORD MOTOR CO. REPLACE THIS DANGEROUS WHEELHOUSE WITH ONE THAT HAS A SAFER, NON-RUSTING DESIGN.
Air bags, Dec 2, 2015
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SEATBELT ALARM PRE-TENSIONER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.
Structure, Nov 20, 2015
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING 45 MPH, A LOUD BANGING NOISE WAS HEARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR PASSENGER WHEEL WELL, AND THE SHOCK ABSORBER TOWER WERE SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 144,000.
Electrical system, Service brakes, Nov 17, 2015, fire
WE OWN A 2004 ESCAPE. THAT TWO WEEKS AGO CAUGHT FIRE DUE TO THE ABS CONTROL MODULE. WE ALSO HAVE HAD BRAKE LINES GO BAD DUE TO PART FAILURE TWICE. AND THE TOTAL OF THREE ALTERNATORS. NOW WE HAVE SPOKEN TO FORD REGARDING THE 01-03 FIRE ISSUE. BUT THEY WILL NOT DO ANYRHING TO CONSIDER THE 04 EVEN THOUGH IN RESEARCHING THE ACTUAL RECALL IT WAS THE SAME ISSUE. I WOULF LIKE TO SEE THIS HAPPEN. WE ARE SELLING OUR VEHICLE TO THE SEALER SUE TO LACK OF RELIABILITY. BUT WANTED TO VET THE WORD OUT ON THIS ISSUE. OUR ENGINE ALSO IDLE AND TRIES TO PULL THE VEHICLE FORWARD EVEN WITH THE BRAKES APPLIED. THIS IS DUE TO A FAULTY IDLE AIR CONTROLL VALVE.
Other or unspecified, Nov 17, 2015
RIGHT, REAR BACK WINDOW HINGE BOLT RUSTED OFF AND BROKE
Structure, Nov 8, 2015
2004 FORD ESCAPE. REAR RIGHT WHEEL HUB RUST/CORROSION AROUND STRUT ASSEMBLY. SAFETY ISSUE WITH REAR SHOCK. KNOWN PROBLEM WITH 2004 TO 2006 FORD ESCAPE DESPITE RUST PROOFING. RUSTS AROUND AREA FOR STRUT LEADING TO STRUCTURAL COMPROMISE OF THIS ASSEMBLY. UNSAFE TO DRIVE.
Suspension, Service brakes, Nov 2, 2015
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING AT AN UNKNOWN SPEED OVER A BUMP IN THE ROAD, THE VEHICLE EMITTED A CLUCKING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, WHICH INDICATED THAT THE FRONT SUSPENSION BAR WAS FRACTURED. THE FRONT SUSPENSION BAR WAS REPLACED. THE CONTACT ALSO STATED THAT THE BRAKE LINES ALSO FAILED DUE TO CORROSION. THE BRAKE LINES WERE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 125,715. ..UPDATED 02/01/16 *BF *JS
Air bags, Vehicle speed control, Service brakes, Oct 19, 2015, crash
TL* THE CONTACT OWNED A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 20 MPH, THE SPEED ACCELERATED INDEPENDENTLY, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND CAUSING THE VEHICLE TO CRASH INTO A GUARD RAIL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. THE VEHICLE WAS DESTROYED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V353000 (ENGINE AND ENGINE COOLING, VEHICLE SPEED CONTROL). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Power train, Engine, Oct 14, 2015
AT INTERMITTENT TIMES VEHICLE WILL STALL AND DIE. AFTER DRIVING AT 45MPH AND STOP CAR WILL DIE IN THE INTERSECTION. DRIVING AT 70MPH ON THE HIGHWAY VEHICLE WILL STALL WOTH CRUISE CONTROL ON. WHEN IT STALLS AT HIGHWAU SPEED IT JERKS SO VIOLENTLY THAT KIDS IN THE BACK SEAT GET BOUNCED AROUND. IT DOESNT STALL WHEN IDLING. ONLY IN DRIVE WHEN START TO TAKE OFF FROM A STOP OR IF YOUR MAINTANING A STEADY SPEED. THEN TRY TO SPEED UP OR SPEED DOWN.
Suspension, Oct 10, 2015
RIGHT SIDE REAR SHOCK ABSORBER TOWER RUSTED OUT
Suspension, Oct 7, 2015
RIGHT REAR WHEEL WELL RUSTED THROUGH AND THE SHOCK AND SPRING PUNCHED THROUGH THE BODY OF THE CAR. HIGHLY DANGEROUS, AS OUR CHILDREN AND MY WIFE DRIVE THE CAR, BUT THE ONLY INDICATION THAT THIS OCCURRED WAS AN OCCASIONAL LOUD NOISE (MIMICKING A SHOCK ABSORBER BOTTOMING OUT). UNTIL I INSPECTED THE VEHICLE, NOTHING ELSE, SUCH AS HANDLING OR OTHER FACTORS WARNED OF THE DIRE SITUATION. FOR INSTANCE, MY WIFE TRAVELS BACK AND FOURTH TO HER PARENTS VIA A BUSY HIGHWAY COVERING ABOUT 50-60 MILES MULTIPLE TIMES A WEEK AND THIS COULD HAVE CAUSED A FATAL CRASH. MY GUESS IF WE HAVE BEEN DRIVING ON THIS BASED ON THE OCCASIONAL NOISE FOR 2 MONTHS.
Steering, Suspension, Structure, Sep 19, 2015
FORD'S 14S02 RECALL WAS TO DEAL WITH EXCESSIVE RUST ON A SUBFRAME UNIT. IF THE RECALL INSPECTION OF THE SUBFRAME DID NOT RESULT IN CHARACTERISTICS WARRANTING REPLACEMENT, FORD INSTRUCTED DEALERS TO INSTALL A CROSS BRACE. APPROXIMATELY 13 MONTHS AFTER OUR 2004 FORD ESCAPE HAD THE CROSS BRACE INSTALLED THE SUBFRAME UNIT FAILED WHILE WE WERE DRIVING. THE CAR VIOLENTLY JERKED TO THE SIDE AND IF THERE HAD BEEN ANOTHER CAR OR ANY OBSTACLE ON THAT SIDE OF OUR VEHICLE WE WOULD HAVE HIT IT. I CONTACTED FORD SEVERAL TIMES AND ON EACH OCCASION WAS TOLD FORD WOULD NOT COVER THE COST OF THE REPAIRS BECAUSE THEY HAD ALREADY INSTALLED THE CROSS BRACE - WHICH WAS NOT THE PART THAT FAILED AND WAS NOT THE PART FOR WHICH THE RECALL WAS INITIATED. THE REPAIR COST OVER $800. AT THE TIME OF THE INCIDENT THE ESCAPE HAD FEWER THAN 60,000 MILES. DURING EACH ON MY CALLS TO FORD, AND AFTER BEING TOLD FORD WOULD NOT COVER THE REPAIR COSTS, I ASKED TO SPEAK WITH A SUPERVISOR. EACH TIME I WAS TOLD THEY COULD HAVE A SUPERVISOR CALL ME 1 BUSINESS DAY LATER, BUT THEY WOULD NOT GIVE ME A TIME WHEN I COULD EXPECT THE CALL SO I HAD TO BE AVAILABLE AT ANY TIME THROUGHOUT THE DAY. TO SUMMARIZE, THE BAND-AID FORD PUT ON TO DEAL WITH THE SUBFRAME PROBLEM (THE CROSS BRACE) DID NOT FAIL. THE PART FOR WHICH THE RECALL WAS INITIATED DID FAIL EVEN WITH THE CROSS BRACE. FORD IS DENYING COVERAGE FOR THE REPAIR COSTS.
Structure, Sep 18, 2015
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING AT APPROXIMATELY 40 MPH, THE VEHICLE VIOLENTLY VEERED TO THE RIGHT WITHOUT WARNING. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SUBFRAME FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE) BUT THE REMEDY FAILED TO PREVENT THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 59,000.
Electrical system, Air bags, Sep 3, 2015
TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING AT APPROXIMATELY 65 MPH, THE AIR BAG WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 61,000.