2006 Ford Escape
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 720 owner complaints filed for this model year. This is the 15th highest complaint count among 26 Escape model years with reports.
Of the 2006 reports, 23 involved a crash and 10 involved a fire. 30 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
EquipmentSep 3, 2010
MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.
AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.
MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.
Campaign 10E043000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints
720 reports, newest first.
Electrical system, Engine, Fuel/propulsion system, Jul 9, 2016
OUR VEHICLE SEEMINGLY RANDOMLY SHUTS OFF ALL POWER TO THE ENGINE AND THE ELECTRIC MOTOR. THIS CAN HAPPEN WHILE WE ARE MOVING OR STOPPED IN AN INTERSECTION. WE GET A MESSAGE OF STOP SAFELY NOW ON THE DASHBOARD. WHEN YOU ARE IN THE MIDDLE OF AN INTERSECTION WAITING TO TURN LEFT IN SIX LANES OF TRAFFIC AND YOUR CAR STOPS FOR NO APPARENT REASON THIS ISN'T VERY SAFE. THIS HAS HAPPENED ABOUT 30 TIMES. SOMETIMES IT GOES A YEAR WITHOUT A MISHAP OR THREE TIMES IN ONE DAY.
Structure, Jul 9, 2016
BOUGHT VEHICLE FOR 17YR OLD SON FIRST CAR. WHILE HE WAS DRIVING, HE NOTICED A LOUD BANGING SOUND FROM THE BACK. AFTER INVESTIGATION, FOUND THAT REAR WHEEL WELL HAD TOTALLY CORRODED AWAY AND REAR SHOCK WAS POKING INTO THE INTERIOR. REPORTED TO FORD WHO SAID NO RECALLS AND WOULD DO NOTHING. WHEN RESEARCHING PROBLEM ON THE WEB, IT TURNS OUT THAT MANY PEOPLE HAVE HAD THE SAME PROBLEM. THE FORD DEALER ADVISED ME NOT EVEN TO DRIVE IT HOME AS IT IS A SAFETLY HAZARD AND THAT THE WHEEL MIGHT FALL OFF. IF THIS WAS A ONE OFF SITUATION, I MIGHT BE ABLE TO ACCEPT IT, BUT HOW CAN FORD CONTINUE TO ALLOW PEOPLE TO DRIVE AROUND IN A CAR WITH AN OBVIOUSLY KNOWN DEFECT AND THAT THEIR DEALERS TELL YOU IS DEADLY. I CANNOT CONTINUE TO SUPPORT AN AMERICAN COMPANY WITH SUCH AN ATTITUDE.
Power train, Service brakes, Jun 20, 2016
THE WHEEL SPEED SENSOR RING, ALSO KNOWN AS THE TONE RING, CAN SPLIT OR CRACK WHILE DRIVING, CAUSING LOSS OF ABS AND 4 WHEEL DRIVE. THIS IS WHAT HAPPENED TO ME. IT'S A KNOWN DEFECT, IS FRIGHTENING WHEN IT HAPPENS, AND SHOULD HAVE LONG AGO RESULT IN A RECALL.
Other or unspecified, Jun 16, 2016
A COUPLE MONTHS AGO, I BOUGHT A 2006 FORD ESCAPE, BUT WITHIN A SHORT TIME IT STARTED SHUTTING DOWN WITH NO WARNING. I LOST ALL POWER (STEERING AND BRAKES) AND HAD TO PULL THE EMERGENCY BRAKE TO STOP. THANK GOD I WAS NEAR A PARKING LOT AND THERE WAS NO CARS COMING. NOW, EVERY TIME I DRIVE IT, THE PROBLEM GETS WORSE. WHEN GOING UP HILLS AND AT HIGHER SPEEDS, IT SPITS AND SPUTTERS AND SOMETIMES IT WILL JUST SHUT DOWN WHILE DRIVING! IT HAS GOTTEN PROGRESSIVELY WORSE AND NOW WHEN I STOP AT A STOP SIGN AND START TO PULL OUT AT AN INTERSECTION IT JUST SHUTS OFF. THE CAR WILL START RIGHT BACK UP BUT IT IS SO DANGEROUS WHEN IT JUST SHUTS OFF GOING DOWN THE ROAD. I HAVE PUT IT IN THE GARAGE TWICE, BUT BOTH TIMES THEY COULDN'T FIND ANYTHING WRONG AND THERE ARE NO CODES BEING THROWN. I ALSO TOOK IT TO A FORD DEALER, BUT THEY COULD FIND NOTHING WRONG.. BUT SOMETHING NEEDS TO BE DONE, ITS SO DANGEROUS AND I'M AFRAID TO DRIVE THE CAR.
Structure, Jun 16, 2016
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING, THE VEHICLE SHOOK SEVERELY. THE CONTACT INSPECTED THE VEHICLE AND COULD VISIBLY SEE THE REAR PASSENGER SHOCKS. THE CONTACT ALSO NOTICED DAMAGE FROM WHERE THE REAR TIRE WAS HITTING THE REAR WHEEL WELL AND CAUSED PIECES OF THE WELL TO DETACH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOISED THAT THE PASSENGER SIDE REAR WHEEL WELL WAS SEVERELY CORRODED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE); HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.
Service brakes, Jun 15, 2016
NEARLY IMPOSSIBLE TO BRAKE, MAJOR SAFETY ISSUE WITH THE HYDROLIC REGENERATIVE BREAKING SYSTEM AND ABS. WHILE DRIVING THE VEHICLE ON CITY STREETS, SPEEDS BETWEEN 0-40MPH THE BRAKE PEDAL WILL BECOME VERY HARD AND IMPOSSIBLE TO PRESS WITH LOSS OF BRAKING. WHEN THIS HAPPENS I AM FORCED TO RAPIDLY RELEASE THE BRAKE PEDAL AND BRAKE AGAIN (PUMPING) THE BRAKES IN ORDER TO STOP. ON SEVERAL OCCASIONS THIS PUMPING OF THE BRAKES HAS CAUSE THE BREAK PEDAL TO GO FROM HARD/IMPOSSIBLE TO PUSH TO COMPLETELY SOFT HITTING THE FLOOR WITH NO BRAKING CAPABILITIES. ON THESE OCCASIONS I AM FORCED TO PULL OF THE ROAD QUICKLY, DOWNSHIFT TO LOW GEAR AND EVEN USE THE EMERGENCY BRAKE TO AVOID CAUSING AN ACCIDENT. ONLY ABOUT 60% OF THE TIME WHEN THIS EVENT OCCURRED DOES THE ABS LIGHT, BRAKE LIGHT AND SERVICE BRAKE SYSTEM WARNING INDICATORS ILLUMINATE OR DISPLAY. WHEN THIS OCCURRES I AM USUALLY FORCED TO TURN THE ENGIN OFF, REMOVE THE KEY, LET THE SYSTEM PURGE (MAKES NOISE) AFTER THE VEHICLE SITS FOR A COUPLE MINUTES AND THEN RESTART THE VEHICLE IN ORDER TO KEEP DRIVING AND FIX THE ISSUE. SOMETIMES IT FIXES TO ISSUE FOR THE REST OF THE DRIVING TIME WHILE OTHERS ONLY WORK TEMPORARILY AND THE ISSUE RETURNS ALMOST IMMEDIATELY. I FEEL THAT THIS BRAKING ISSUE IS A HUGE SAFETY CONCERN FOR MY FAMILY AND I AND OUR PIECE OF MIND IN THE SAFETY OF THIS VEHICLE IS NOT GOOD. AS AN ADDITIONAL NOTE THIS BRAKE ISSUE ONLY BECAME EVIDENT AFTER WE HAD ANOTHER RECALL ISSUE FIXED ON THIS VEHICLE FOR STALLING. BEFORE THAT FIX WE NEVER HAD ANY BRAKING ISSUES.
Power train, Service brakes, Engine, Jun 4, 2016
DRIVING CAR AND BRAKES FAILED COMPLETELY. HAD TO JUMP ON THE BRAKES TO GET ANY TRACTION WHATSOEVER. WAS FORTUNATELY ABLE TO USE THE EMERGENCY BRAKE BEFORE I GOT INTO AN ACCIDENT. YELLOW ABS AND RED BRAKE LIGHTS ARE ON, ALONG WITH MESSAGES OF CHECK BRAKE SYSTEM AND REGEN BRAKES DISABLED. APPEARS TO BE A COMMON PROBLEM WITH ESCAPE HYBRID THAT IT IS THE HYDRAULIC CONTROL UNIT - A PART TO REPAIR WHICH IS MORE EXPENSIVE THAN THE CAR IS WORTH.
Other or unspecified, May 27, 2016
BREAKS FAILED..FORD DEALER SAID NEEDS A NEW HYDROLIC UNIT ETC FOR $5200.00!! FOUND INFO ONLINE THAT SHOWS THIS SHOULD BE A RECALL!!! BIG SAFETY PROBLEM.. PLEASE RESPOND..HELP
Power train, May 20, 2016
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE LOST ACCELERATION WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE TO A PARKING LOT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE WITH A TRANSMISSION VALVE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.
Service brakes, May 17, 2016
THE BRAKES ON OUR 2006 FORD ESCAPE HYBRID BEGAN GRINDING AROUND FEBRUARY 2016. WE HAD THE PADS AND ROTORS REPLACED AND IT BRAKED BETTER, BUT WITHIN A MILE AFTER LEAVING THE FORD SERVICE CENTER THE BRAKE LIGHT CAME ON AND SHORTLY AFTER - WHILE MOVING - THE BRAKE PEDAL WENT TO THE FLOOR AND THERE WERE NO BRAKES. WE HAD TO COAST TO A STOP AND PULL OVER. WHEN THE CAR IS STOPPED AND TURNED ON AND OFF, YOU CAN SOMETIMES GET THE BRAKES TO WORK FOR LESS THAN A MILE. ITS SO UNSAFE, WE HAD IT TOWED TO SERVICE CENTERS FOR ESTIMATES. TWO FORD DEALERS AND ONE OTHER SERVICE PLACE INVESTIGATED THE PROBLEM THOROUGHLY AND ALL CAME BACK SAYING THE HYDRAULIC CONTROL UNIT MUST BE REPLACED AT AN AVERAGE COST OF $4,500. OTHERWISE, WE LIKE THE CAR, BUT THIS ONE REPAIR IS GREATER THAN THE BLUE BOOK VALUE AND IS VERY DANGEROUS.
Suspension, May 16, 2016
WENT CHANGE THE SHOCKS AND THE WHOLE BRACKET SYSTEM HAD RUSTED OUT ON THE PASSENGER SIDE REAR. THEY HAVE RECALLED THESE FROM 2001-2004. IT IS FINE ON THE DRIVERS SIDE BUT THE PASSENGER SIDE IT TOTALLY RUSTED THRU IT IS GOING TO COST 3000 TO FIX. I HAVE ONLY HAD THIS VEHICLE A YEAR. IT MADE A CLUNK NOISE TWICE SO I TOOK IT IN TO THE SHOP, I AM DRIVING TWO KIDS AROUND I AM A SINGLE MOM SUCK CRAP.
Vehicle speed control, May 14, 2016
MY 2006 FORD ESCAPE CONSTANTLY AND UNEXPECTEDLY HAS A STUCK GAS PEDAL IN THE CLOSED POSITION. THE CABLE AND THROTTLE BODY HAVE BEEN REPLACED SEVERAL TIMES AT MY EXPENSE AND FORD REFUSES TO ACKNOWLEDGE THE PROBLEM. MY WIFE, DAUGHTER AND I WERE NEARLY KILLED AT A LARGE INTERSECTION WHILE TRYING TO TURN LEFT. THE CAR WAS STOPPED AT A LIGHT WITH ONCOMING TRAFFIC APPROACHING US IN THE OPPOSITE LANES. WHEN A LARGE GAP APPEARED IN THE ONCOMING TRAFFIC, I TRIED TO PROCEED AND THE GAS PEDAL STUCK AS I TURNED. IT WOULD NOT DEPRESS AND THIS LEFT ME WITHOUT POWER AND THE RAPIDLY APPROACHING ONCOMING CARS HAD TO SWERVE SO AS TO AVOID "T-BONING" OUR CAR. THE OTHER DRIVERS STATED THAT THEY DID NOT ANTICIPATE OUR CAR SUDDENLY FAILING TO PROCEED AS THEY APPROACHED US. THEY THEN ASSISTED US IN REMOVING (PUSHING) THE CAR FROM THE ROADWAY. I HAVE COMPLAINED TO THE LOCAL FORD DEALERSHIP NUMEROUS TIMES BUT THEY REFUSE TO PROVIDE ME WITH A PERMANENT REPAIR. THE PEDAL STICKS VERY OFTEN AND VERY UNEXPECTEDLY. IT DOESN'T STICK OPEN. IT STICKS IN THE FULLY CLOSED POSITION AND WILL NOT DEPRESS NO MATTER HOW MUCH FORCE IS APPLIED TO THE PEDAL. WHEN IT UNSTICKS IT HAPPENS AS UNEXPECTEDLY AS IT BEGAN. THE PEDAL STICKS ONLY WHEN THE PEDAL IS IN THE NON-DEPRESSED POSITION. IT MAY HAPPEN WHEN FIRST TRYING TO DRIVE THE CAR OR AFTER MANY HOURS OF DRIVING. IT MAY HAPPEN (AS IN THE PREVIOUS EXAMPLE) AFTER HAVING STOPPED AT A TRAFFIC STOP. I HAVE REPLACED THE THROTTLE BODY AND CABLE SEVERAL TIMES, AS SUGGESTED BY EVERY DEALERSHIP IN MY AREA (OF MICHIGAN). NOTHING HAS RESOLVED THE PROBLEM AND I HAVE GOTTEN ZERO COOPERATION FROM FORD CORP.
Vehicle speed control, Fuel/propulsion system, May 1, 2016, fire
MY FRIEND BORROWED MY 06 FORD ESCAPE, WHICH HAD NOT SHOWN ANY MECHANICAL ISSUES. SHORTLY AFTER GETTING ON THE INTERSTATE HWY, THE GAS PEDAL STUCK TO THE FLOOR AND RAPIDLY EXCELLERATED TO 85 MPH PLUS, WITHOUT WARNING. IT IS A 6 LANE HWY AND WAS SATURDAY. PUTTING THE VEHICLE IN NEUTRAL AND USING BOTH THE BRAKE AND THE E BRAKE, WHILE TRYING TO MANEUVER TRAFFIC TO GET TO THE SHOULDER, AS A TRACTOR TRAILER RIG WAS BARRELING BY UNAWARE. THIS WAS AN EXTREMELY DANGEROUS SITUATION. IT IS MIRACULOUS THAT NO ONE WAS HURT. THE BRAKES SMOKED AND THE FIRE DEPARTMENT WAS CALLED AS A PRECAUTION. IT HAD TO BE TOWED. UPON RESEARCHING FURTHER, WE DISCOVERED ALL THE COMPLAINTS ABOUT THE THROTTLE BODY PROBLEMS. I AM DISAPPOINTED THAT THERE HAVE BEEN NO WARNINGS ABOUT THIS ISSUE. WILL SOMEONE HAVE TO DIE, BEFORE ANY ACTIONS ARE TAKEN? IT SEEMS AS THOUGH PREVENTION WOULD GO FURTHER, RATHER THAN REACTING TO ONLY THE EXTREMES OF DEATH AND DISMEMBERMENT. I AM SUGGESTING THAT FORD TAKE A PROACTIVE POSITION HERE AND NOTIFY FORD ESCAPE OWNERS. FIX THE ISSUE!!!
Power train, Apr 11, 2016
WHILE DRIVING MY VEHICLE IT WENT INTO OVERDRIVE WITHOUT ME ACCELERATING. THIS OFTEN OCCURRED WHETHER MY FOOT WAS LIGHTLY PRESSED ON THE (FOOT) PEDAL OR OFF THE PEDAL. THE VEHICLE LOST ITS ABILITY TO FORWARD DRIVE, WHEREBY I HAD TO ALLOW THE CAR TO GLIDE OF TO THE SHOULD OF THE ROAD. WHEN THE VEHICLE WAS FINALLY OFF THE ROAD I WOULD EXPERIENCE DIFFICULTY SHIFTING THE GEARS - STICKING AS I TRIED TO PUT IT IN GEAR. IT IS A MANUAL DRIVE 2006 FORD ESCAPE. THIS [STALLING] OCCURRED AFTER SEVERAL TRIPS TO THE MECHANICS BEFORE MY VEHICLE WAS RENDERED COMPLETELY IMMOBILE I.E. UNABLE TO REVERSE OR FORWARD DRIVE. THE MECHANICS, AT THE FORD DEALERSHIP, DIAGNOSED MY VEHICLE WITH TRANSMISSION PROBLEMS, THAT WOULD REQUIRE A TOTAL TRANSMISSION REBUILD/REPLACEMENT. I HAVE NOT RECEIVED A RECALL NOTICE, BUT I KNOW THAT MY VEHICLE IS AMONG THE MODEL 2001 - 2009 FORD ESCAPES THAT HAVE EXPERIENCED TRANSMISSION TROUBLES/RECALLS IN LAST 6 MONTHS. SINCE ~JANUARY 2016, THE VEHICLE WAS TOWED BY THE DEALERS AND REMAINS THERE, TO DATE, WITH NO MENTION OF RECALLS ON THIS MAKE/MODEL/YEAR VEHICLE. I CONTACTED FORD CORP. CUSTOMER SERVICES TOLL-FREE # (1) TO INFORM THEM OF THE PROBLEM, (2) TO DETERMINE THE RECALL SELECTION PROCESS AND (3) TO DETERMINE IF RECALL NOTICES WERE SENT TO BOTH [MY] DEALER &/OR MANUFACTURER, BUT WITH NOT AVAIL. BOTH, REPRESENTATIVES SKIRTED AROUND MY QUERIES, LATER TOLD ME TO HOLD ON THE LINE UNTIL THEY COULD CONDUCT A INTERNAL INQUIRY BUT, INSTEAD, REDIRECTED THE CALL TO THE TELEPHONE CUSTOMER CARE SURVEY -- PRIOR TO MY CALL ENDING.
Structure, Apr 8, 2016
PREMATURE RUSTED OUT WHEEL.
Power train, Mar 29, 2016
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING 65 MPH, THE VEHICLE DECELERATED WITHOUT WARNING AND STALLED. THE CONTACT EXPERIENCED THE SAME FAILURES LISTED IN NHTSA CAMPAIGN NUMBER: 15V606000 (POWER TRAIN), BUT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 97,000.
Power train, Electrical system, Mar 20, 2016
WITHOUT WARNING TRANSMISSION COMPLETELY FAILS. NO INDICATION OF PROBLEMS, JUST DROPPED THE TRANSMISSION ON THE WAY TO WORK. THANK GOODNESS THERE WAS NO TRAFFIC BEHIND US OR WE WERE IN AN INTERSECTION. JUST COMPLETELY STOPPED PULLING WHILE TRAVELING DOWN THE ROAD AT 45 MPH. TRANSMISSION REBUILT. SINCE THEN AND STILL CURRENTLY THE CHARGING LIGHT STAYS ON CONSTANTLY. HAS BEEN IN THE AUTOMOTIVE REPAIR SHOP FOR A MONTH AND NO ONE CAN FIND A PROBLEM OR MATCH THE CODES WITH AN APPARENT PROBLEM. ON IT'S WAY TO A SECOND SHOP FOR ANOTHER OPINION. IDLES HIGH BOTH IN PARK AND IN GEAR, CONSTANT VIBRATION INSIDE THE VEHICLE (STEERING WHEEL, DASH, CONSOLE ETC.). DASH/SPEEDOMETER MAKES HUMMING NOISE IN THE AFTERNOONS. ALARM HAS RANDOMLY GONE OFF TWICE AND INTERIOR LIGHTS WOULD NOT GO OUT ON THEIR OWN - HAD TO TURN OFF MANUALLY. "RIGHT REAR DOOR AJAR" OR "LIFT GATE AJAR" MESSAGES WERE DISPLAYED, BUT THE DOORS WERE FINE. MESSAGE DID NOT RESET WHEN RE-CLOSING THE DOORS, JUST RESET EVENTUALLY ON ITS OWN. GAS MILEAGE HAS DROPPED TO 15 MPG. RADIO VOLUME WILL NOT COME DOWN. GET LOUDER IF YOU TOUCH IT. THIS PROBLEM HAS BEEN GOING ON AWHILE, BUT NOW WITH EVERYTHING ELSE POSSIBLY ELECTRICALLY GOING ON, DON'T KNOW IF IT'S RELATED. WE'VE ALREADY SPENT AROUND $2000.00 ON IT AND I STILL DON'T FEEL SAFE TO DRIVE IT, ESPECIALLY AFTER REVIEWING ALL THE COMPLAINTS THIS MODEL ESCAPE HAS HAD. WITHOUT DIAGNOSIS OF A PROBLEM, I FEAR IT MAY ESCALATE TO OTHER COMPUTER ISSUES AND CAUSE FAR WORSE DRIVING/SAFETY PROBLEMS. UNDETERMINED ELECTRICAL/INTERIOR GOING CRAZY SEEMS TO BE A COMMON COMPLAINT EVEN WHEN WHAT APPEARS TO BE THE PROBLEM IS ADDRESSED. I AM DISAPPOINTED TO BE HAVING SUCH PROBLEMS WITH THIS FORD. MY HUSBAND ACTUALLY RECENTLY PURCHASED A USED ACURA INSTEAD OF A FORD BECAUSE OF IT. I HAVE NO TRANSPORTATION OF MY OWN UNTIL THESE SAFETY/RELIABILITY ISSUES ARE RESOLVED. ...UPDATED 04/12/16 *BF THE CONSUMER TOOK THE VEHICLE TO ANOTHER REPAIR SHOP. SHE WAS INFORMED THE ALTERNATOR NEEDED TO BE REPLACED AT A COST OF $500.00 UPDATED 04/13/16.*JB
Structure, Mar 18, 2016
I HEARD A LOUD CLUNKY FROM THE RIGHT REAR WHEEL WELL, LOUDER WHEN GOING OVER BUMPS. UPON INSPECTION I OBSERVED THE ENTIRE WHEEL WELL WAS MISSING IT'S PROTECTIVE COATING AND FLAKING RUST/CORROSION WAS EVERYWHERE WITH EXPOSED WHITE FIBERGLASS SHEETING VISIBLE THE RIGHT REAR SHOCK IS EXPOSED, MISSING BOLTS AND WITH THE BRACKET MISSING THE OTHER SIDE OF THE CARE (LEFT REAR) DOES NOT EXHIBIT THIS RUST. WITH PALPATION OF THE RIGHT RUSTED REAR WELL A PERSON CAN MOVE THE REMAINING PIECES. THIS IS VERY UNSAFE AND CAN NOT IMAGINE WHY THERE IS NOT A RECALL AS OTHER REVIEWS ONLINE DESCRIBE THE SAME PROBLEM. I CALLED FORD: NO ASSISTANCE OR RECALL AS OF THIS DATE. I RESIDE IN WISCONSIN AND TOOK CARE TO REMOVE UNDERBODY SALT TO NO AVAIL, EVIDENTIALLY.
Structure, Mar 15, 2016
PURCHASED NEW 2006 FORD ESCAPE,MAINTAINED AND GARAGED NO RUST ON CAR ANYWHERE. .LAST WEEK NOTICED LOUD NOISE RIGHT PASSENGER WHEEL.BROUGHT TO MY SHOP HE SAID UNREPAIRABLE RUSTED WHEEL WELL.WHEN I BROUGHT TO FORD DEALERSHIP THEY CONFIRMED THAT THIS WAS THE PROBLEM AND THE COST TO REPAIR WAS MORE THAN CAR WAS WORTH. I FEEL 10 YEARS IS NOT ACCEPTABLE FOR THE LIFE OF A CAR.
Suspension, Feb 23, 2016
REAR PASSENGER WHEEL WELL COMPLETELY RUSTED OUT. SUSPENSION NOT MOUNTED TO VEHICLE NOW, AND HAMMERS BOTTOM OF INTERIOR WHEN GOING OVER ANY BUMP IN THE ROAD. EVERY OTHER WHEEL WELL IS FINE. ALL MECHANICS I HAVE SPOKEN WITH, INCLUDING A FORD CERTIFIED BODY SHOP WILL NOT TOUCH THE ISSUE AND ADVISED ME TO SCRAP THE VEHICLE.
Fuel/propulsion system, Feb 11, 2016
VEHICLE STALLED DURING ACCELERATATION. THEN WENT IDLE AND WENT INTO SAFETY MODE IN TRAFFIC. PROBLEM IS THE THROTTLE BODY CONSUMER SATISFACTION ALERT # 13NO3 CODES P2135,P2110,P2111
Service brakes, Feb 3, 2016
TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. WHILE PULLING INTO A RESIDENTIAL DRIVEWAY AT 10 MPH, THE BRAKES FAILED TO STOP THE VEHICLE AND THE PEDAL TRAVELED TO THE FLOORBOARD WHEN DEPRESSED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE MASTER CYLINDER AND HYDRAULIC SYSTEM FAILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000. UPDATED 06/08/16*LJ THE CONSUMER STATED THE BRAKE PEDAL WAS STUCK IN PLACE FOR APPROXIMATELY5-6 SECS BEFORE THE PEDAL TRAVELED TO THE FLOORBOARD. *JS
Electronic stability control (ESC), Fuel/propulsion system, Jan 31, 2016
FORD MEC PUMP RECALL, DID NOT HELP AFTER REPLACING PART. MY ESCAPE DIED ON ME WHILE GOING 70 MPH ON A BUSY HIGHWAY, WITH MY 18-MONTH OLD SON IN THE BACK SEAT. THE "STOP SAFELY NOW" MESSAGE APPEARED AND I WAS BARELY ABLE TO GET OVER 3 LANES ONTO THE SHOULDER BEFORE IT STOPPED COMPLETELY, WITH CARS SPEEDING RIGHT PAST ME. THIS WAS VERY DANGEROUS. IT HAPPENED 2 MORE TIMES ON THE WAY HOME. THIS WAS DURING THE LAST HALF OF JUST A 20 MILE TRIP.
Suspension, Structure, Jan 21, 2016
ESCAPE WHEEL WELL RUST CAUSED STRUT TO DETATCH FROM VEHICLE. I WAS DRIVING DOWN THE HIGHWAY WHEN I HEARD LOUD THUMPING NOISES, I CHECKED AND DIDN'T SEE ANYTHING THAT IT MIGHT BE SO I TOOK IT TO A MECHANIC WHO SHOWED ME THE EXCESSIVE WHEEL WELL RUST THAT CAUSED THE STRUT TO DETATCH FROM THE BODY. HE SAID IT WAS NOT SAFE TO DRIVE AND THAT IT MUST BE FIXED BY A BODY SHOP AS HE COULDN'T FIX IT. I GOT ESTIMATES FROM BODY SHOPS AS WELL AS FORD AND THEY ALL SAID IT WOULD BE AROUND $4,000 TO $5,000 THIS IS NO OTHER RUST ON THE VEHICLE OTHER THAN THE EXCESSIVE PASSENGER REAR WHEEL WELL RUST AND IS HAS ONLY 130-140K MILES ON IT. NOW I CANNOT DRIVE IT WITHOUT RISK OF A MAJOR ACCIDENT DUE TO THE PROBLEM SO IT IS SITTING IN MY GARAGE. I HAVE PHOTOS BUT AM UNABLE TO UPLOAD THEM TO THIS SITE AT THIS TIME.
Steering, Jan 20, 2016
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING VARIOUS SPEEDS, THE POWERING STEERING MADE AN ABNORMAL NOISE WITHOUT WARNING. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.