2006 Ford Escape
Problems, recalls and owner-reported issues
Service brakes is the leading concern among 720 owner complaints filed for this model year. This is the 15th highest complaint count among 26 Escape model years with reports.
Of the 2006 reports, 23 involved a crash and 10 involved a fire. 30 people were injured and 2 people died.
What owners report most often
Recalls and investigations
Power train, automatic transmission, lever and linkage, floor shiftSep 29, 2015
Ford Motor Company (Ford) is recalling certain model year 2001-2008 Ford Escape and Mercury Mariner vehicles manufactured March 31, 2001, to September 1, 2009. The affected vehicles are equipped with either a 2.3L or 3.0L engine and have had their CD4E transmission replaced with remanufactured one that was rebuilt between June 11, 2015 through July 15, 2015. These service repair part transmissions have a shift lever bolt that may not be properly tightened. As a result, the shift control lever could disengage from the transmission without warning.
If the shift lever disengages from the transmission, a driver may be unable to shift gear positions and the indicated shift position may not represent the gear position the vehicle is in. Should a disengagement occur while the vehicle is being driven, when the driver goes to stop and park the vehicle, the gear selection indicator may show that the transmission is in the "PARK" position, but the vehicle transmission may not actually be in the "PARK" gear position. If the vehicle is not in the "PARK" position there is a risk the vehicle will roll away as the driver and other occupants exit the vehicle or anytime thereafter. A vehicle rollaway increases the risk of injury to exiting occupants and bystanders.
Ford will notify owners, and dealers will inspect the transmissions and either tighten the manual shift lever bolt or replace the manual shift lever assembly. These repairs will be performed free of charge. The recall began on October 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S28.
Campaign 15V606000 on NHTSA.gov
Suspension, front, wheel bearingJun 3, 2015
The Timken Company (Timken) is recalling certain aftermarket front wheel bearings, part number 510072, sold from January 22, 2015, to May 21, 2015, to be used as service parts on 2001-2012 Ford Escape, 2001-2011 Mazda Tribute, and 2005-2011 Mercury Mariner vehicles. The affected wheel bearings have incorrect dimensions of a 42mm bore, 76mm outer dimension, and 39mm width, instead of a 42mm bore, 78mm outer dimension and a 45mm width.
Use of an incorrectly sized wheel bearing can adversely affect the braking and steering of the vehicle, increasing the risk of a crash.
Timken has begun notifying distributors who will offer purchasers replacement wheel bearings, free of charge. The recall began on May 21, 2015. Owners may contact Timken customer service at 1-866-984-6536.
Campaign 15E045000 on NHTSA.gov
Hybrid propulsion systemSep 3, 2014
Ford Motor Company (Ford) is recalling certain model year 2005-2008 Ford Escape hybrid electric vehicles manufactured October 13, 2003, to June 20, 2008, and 2006-2008 Mercury Mariner hybrid electric vehicles manufactured June 10, 2005, to June 20, 2008. The coolant pump for the hybrid system may fail resulting in the hybrid electronics overheating.
If the hybrid electronics system overheats, it may shut down the powertrain, resulting in a stall-like condition, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect and replace the original Motor Electronics Coolant (MEC) Pump with an improved brushless pump, free of charge. The recall is expected to begin on October 27, 2014. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S19.
Campaign 14V526000 on NHTSA.gov
EquipmentSep 3, 2010
MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.
AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.
MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.
Campaign 10E043000 on NHTSA.gov
Visibility, windshield wiper/washer, motorNov 9, 2005
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
Campaign 05V520000 on NHTSA.gov
Representative owner complaints
720 reports, newest first.
Power train, Service brakes, Fuel/propulsion system, Jan 19, 2016
THE BRAKE SYSTEM IS VERY IRRITATING BECAUSE MY ABS AND BRAKE LIGHT ARE ON AT WEIRD TIMES AND TO FIX THEY SAID IT WOULD COST ME $4500. THAT'S RIDICULOUS I CAN'T AFFORD SOMETHING LIKE THAT. IT ALSO JUST STARTED SPITTING GAS OUT AT ME WHEN I GO TO FILL IT UP. DID IT TO ME TWICE THE OTHER DAY AND I HAVE NO IDEA WHAT THE REASONING WAS FOR THAT NEVER HAD HAPPEN BEFORE. THEN WHEN I GO TO DROVE OFF SOMETIMES THE VEHICLE LIKES TO MAKE A POP NOISE ONCE OR TWICE NOT SURE WHAT THAT'S ALL ABOUT. THESE CARS ARE HAVE MORE PROBLEMS THEN THEY ARE WORTH.
Visibility/wiper, Jan 16, 2016
REAR WINDOW EXPLODED OUTWARD ONTO THE DRIVEWAY.
Structure, Jan 6, 2016
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT HEARD A LOUD BANGING NOISE COMING FROM THE REAR PASSENGER SIDE OF THE VEHICLE WHEN DRIVING OVER A BUMP IN THE ROAD. ADDITIONALLY, THE ODOR OF EXHAUST FUMES WAS PRESENT IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR PASSENGER SIDE WHEEL WELL WAS RUSTED AND CORRODED, WHICH CAUSED EXHAUST FUMES TO ENTER THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,000.
Steering, Jan 2, 2016
VEHICLE WAS PARKED. RESTARTED AND POWER STEERING WOULDN'T WORK. YELLOW WRENCH WARNING, AND POWER STEERING LISTED ON FAULT INDICATOR. WILL TAKE TO DEALER.
Electrical system, Engine, Fuel/propulsion system, Dec 26, 2015
ON SEVERAL OCCASIONS AFTER GETTING OFF THE HIGHWAY ONTO AN EXIT RAMP MY VEHICLE HAS DIED WITH NO CHECK ENGINE LIGHTS, IT ALSO SHUTS DOWN WHEN MAKING A HARD TURN AT SLOWER SPEEDS. I HAVE HAD ISSUES WITH THE ACCELERATOR STICKING WHEN IT IS COLD OUTSIDE (SEVERAL TIMES HAVING TO MANUALLY SHUT OFF ENGINE AND COAST TO A STOP IN SNOW). I HAVE CURRENTLY STARTED EXPERIENCING A #3 MISFIRE AND AM CURRENTLY WAITING FOR PARTS TO COME. I HAVE ALREADY REPLACED ALL SPARK PLUGS AND NUMBER 3 IGNITION COIL. I AM WAITING FOR OTHER 3 COILS TO COME IN. IF STILL SHOOTING WILL TRY REPLACING SEALS. IT ALSO WAS "BURNING" OIL THEN STARTED TO HAVE AN ACTUAL OIL LEAK FROM MAIN SEAL. I DO THE REPAIRS MYSELF AND APPARENTLY THESE ARE KNOWN ISSUES. I COMPLAINED TO FORD ABOUT THE STICKY ACCELERATOR AND GOT NO REPLY. IT ALSO MAKES A TAPPING SOUND FROM THE CAM SHAFT WHICH I FOUND OUT IS TYPICAL OF FORD ESCAPES.
Visibility/wiper, Dec 25, 2015
CAR WAS PARKED IN OUR CARPORT OVERNIGHT (12/24-25, 2015). WHEN I CAME OUT THE REAR WINDOW WAS SHATTERED. MOST OF THE GLASS WAS OUTSIDE THE CAR, PERHAPS 5 PERCENT WAS INSIDE. NO FALLEN BRANCHES, NO SIGN OF FOUL PLAY, NONE OF OUR OTHER CARS WERE DAMAGED IN ANY WAY. I LOOKED UP AND FOUND THAT SIMILAR INCIDENTS OF "RANDOM REAR WINDOW EXPLOSION" HAD BEEN REPORTED ON FORD ESCAPES, AND THAT THERE WAS AN ACTIVE NHTSA INVESTIGATION HAPPENING, SO I WANTED TO ADD OUR INCIDENT TO THE LIST.
Suspension, Structure, Other or unspecified, Dec 21, 2015
THE RIGHT WHEEL WELL OF MY 2006 FORD ESCAPE (LIMITED) IS COMPLETELY RUSTED OUT. I CAN NO LONGER DRIVE THIS VEHICLE BECAUSE THE SHOCK IS ABOUT TO BREAK THROUGH THE INTERIOR OF THE VEHICLE. THE RUST HAS CAUSED EXHAUST TO POUR INTO THE VEHICLE. BEFORE KNOWING ABOUT THIS, I TOOK MY VEHICLE TO SEVERAL DIFFERENT MECHAINCS BECAUSE I COULD SMELL EXHAUST. THEY COULDN'T FIND ANYTHING. A CANADIAN AUTO BODY PERSON (I LOVE ON THE BORDER) TOLD ME THAT IT WAS COMING FROM THE HOLES IN THE RIGHT WHEEL WELL AND SHOWED ME THE LARGE HOLE WHERE EXHAUST IS LEAKING IN. THIS IS A SERIOUS SAFETY ISSUE THAT ALL ESCAPE OWNERS (2006 AT LEAST) NEED TO BE MADE AWARE OF!!! I CAN'T TAKE AND ATTACH PHOTOS AT THIS TIME DUE TO THE WEATHER BUT CAN PROVIDE THEM ANOTHER TIME, UPON REQUEST. I SHOULD NOTE THAT I LIVE IN NORTHERN MICHIGAN AND THAT I HAVE TAKEN METICULOUS CARE OF THIS VEHICLE.
Hybrid propulsion system, Dec 21, 2015
2006 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO MOTOR ELECTRONICS COOLANT PUMP RECALL NOTICE. *SMD THE CONSUMER STATED HIS WIFE WAS DRIVING, WHEN SHE LOST POWER IN THE MIDDLE OF A MAJOR INTERSECTION. THE CONSUMER STATED THE INCIDENT HAPPENED TWICE. THE CONSUMER REFERENCED RECALL 3 14V526000. *JB
Power train, Other or unspecified, Engine, Dec 8, 2015
DRIVING DOWN THE FREEWAY AND MY VEHICLE SHUTS OFF WITHOUT WARNING. THERE IS A LOUD KNOCKING AND SHUTTERING NOISE LIKE MY WHOLE ENGINE IS GOING TO DROP ONTO THE FREEWAY. I GET TO THE SHOULDER AND PUT IT IN PARK. AS I TRY TO START THE VEHICLE AGAIN THE ENGINE/MOTOR STARTS SHAKING YET AGAIN WITH A LOUD KNOCKING NOISE AND WONT TURN OVER. I HAD TO GET MY CAR TOWED. MY CHILDREN WERE EXTREMELY SCARED AND BEING ON THE FREEWAY THIS ISSUE IS VERY DANGEROUS AND HAS BEEN COMPLAINED ABOUT MULTIPLE TIMES.
Steering, Nov 24, 2015
TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE PARKED, THE POWER STEERING FAILED. IN ADDITION, WHEN THE VEHICLE WAS BEING DRIVEN, THE STEERING WHEEL SEIZED AND WAS DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE POWER STEERING MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 137,000. VIN WAS NOT PROVIDED.
Power train, Air bags, Engine, Oct 21, 2015
I BOUGHT THE VEHICLE ON SEPTEMBER 4,2015 ALL THESE PROBLEM STARTED 1 MONTH AFTER. MANUEL TRANSMISSION GETS TO ROUGH AT TIMES WHEN BEING SHIFTED INTO 1ST GEAR AND REVERSE GETS STUCK AND HARD TO SHIFT, MIGHT BE PART OF THE RECALL NO# 15S28 THE ENGINE OIL SEEMS TO USE 1QT A WEEK, RECENTLY HAD A CHANGED OIL BUT CONTINUES TO USE THE SAME EVERY WEEK, MILEAGE IS AT 132467. THE AIR BAG FOR PASSENGER LIGHT CONTINUES TO LIGHT UP AND GOES OFF WHEN DRIVEN. A BANGING NOISE WHEN DRIVEN ON THE ROAD AT REAR SHOCK ABSORBERS ARE LOCATED, THE SHOCKS ARE STILL NEW.
Engine, Oct 11, 2015
I PURCHASED MY 06 FORD ESCAPE IN JANUARY OF THIS YEAR. IT HAS 92,000 MILES ON IT. I TEST DROVE THE CAR AND HAD IT INSPECTED BY A MECHANIC AFTER PURCHASE TO MAKE SURE THAT THERE WASNT AN ISSUE THE DEALER " FORGOT " TO MENTION, ABOUT 3 WEEKS AFTER PURCHASE MY OIL LIGHT CAME ON. I ADDED OIL BUT DID NOT GET AN OIL CHANGE BECAUSE I WASN'T DUE ONE FOR 1400 MILES. AFTER THAT THE CAR WAS FINE.... FOR ABOUT A WEEK WHEN THE OIL LIGHT CAME ON AGAIN, IN THE MEAN TIME I WAS DILIGENT ABOUT CHECKING THE OIL AND ALSO INSPECTING BENEATH THE VEHICLE TO MAKE SURE THERE WAS NO OIL ON THE GROUND. THERE WASN'T. THE OIL LIGHT STOPPED COMING ON BUT I CONFINED TO CHECK THE OIL DAILY. AND I'M GLAD I DID BECAUSE , THE OIL IN MY CAR CONTINUED TO DISAPPEAR. I HAVE NOW HAD THE CAR 9 MONTHS AND THE PROBLEM HAS PROGRESSIVELY GOTTEN WORSE. THE CAR BARELY DRIVES NOW AND THE CHECK ENGINE LIGHT IS INDICATING A CYLINDER IS MISFIRING. I'M GOING THEY A QT OF OIL A DAY AND DRIVING ONLY 30 MILES ROUND TRIP TO WORK AND BACK .I'VE RESEARCHED THIS ISSUE AND I KNOW THAT THIS IS A CONSISTENT AND ONGOING PROBLEM WITH THIS VEHICLE. FORD HAS LEFT ME WITH 4,000 DOLLARS LEFT OF A LOAN, NO WAY FOR MY HUSBAND AND I TO GET TO WORK OR BRING OUR CHILDREN TO SCHOOL AND WITH XMAS COMING, NOT ONE EXTRA DIME TO PUT TOWARDS A NEW VEHICLE. I KNOW FORD HAS BEEN INFORMED OF THESE PROBLEMS. WHAT WILL IT TAKE FOR THEM TO ISSUE A RECALL? WHEN THE 06 ESCAPES ENGINE FAILS ON A BUSY HIGH WAY AND GOD FORBID PEOPLE ARE HURT ? OR WORSE? AND FORD CAN'T SAY THEY WEREN'T WELL AWARE OF THE PROBLEM BECAUSE THEY HAD IT WITH THE 05 ESCAPE TOO AND STILL USED THE SAME ENGINE IN THE 06. NOW I'M PAST THE LEMON LAW TIME FRAME AND I HAVE NO OPTIONS BUT TO PAY FOR A 6500 DOLLAR LAWN ORNAMENT.
Other or unspecified, Oct 8, 2015
THROTTLE CABLE BROKE. THE GAS PEDAL FELL TO THE CAR FLOOR AND THE CAR STOPPED ALL ACCELERATION. I WAS ON A CITY STREET UNDER THE SPEED LIMIT, SO I WAS ABLE TO PULL TO THE SIDE OF THE ROAD AND WAIT FOR A TOW TRUCK. MY MECHANIC FIXED IT 9/23, AS THIS IS A DEALER ONLY PART AND I HAD TO ORDER IT.
Suspension, Sep 25, 2015
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING AT APPROXIMATELY 5 MPH, THERE WAS A LOUD BUMP FROM THE REAR PASSENGER SIDE. THE CONTACT OBSERVED RUST ON THE REAR TIRE. THE FAILURE RECURRED CONTINUOUSLY, CAUSING THE VEHICLE TO BECOME INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SHOCK ABSORBER NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 85,000. ...UPDATED 02/03/16 *BF; UPDATED 4/6/18*JB THE CONSUMER STATED THE VEHICLE WAS REPAIRED. *TR
Steering, Sep 16, 2015
ON JULY 24, 2015 MY WIFE AND 2 KIDS, 6 AND 2 YEARS OLD WERE ALMOST KILLED WHEN THE POWERED STEERING SYSTEM FAILED, THE CAR WAS IMPOSSIBLE TO CONTROL AND HIT THE CURVE GOING OVER THE SIDEWALK. MY 6 YEAR OLD GOT A BRUISE ON HIS HEAD FROM HITTING THE WINDOW AND A WALKING PEDESTRIAN ALMOST GOT KILLED. IF MY WIFE WAS GOING A LITTLE FASTER, WE WOULD BE DEALING WITH A MURDER BY NEGLIGENCE CASE. THE POWER STEERING IN THIS MODEL IS ELECTRICAL, NOT HYDRAULIC; I HAVE ATTACHED PICTURES OF THESE PARTS. IVE NEVER SEEN THIS SYSTEM BEFORE; AS AN ELECTRICAL ENGINEER I KNOW THIS SYSTEM IS UNRELIABLE FOR ANY OF THE CRITICAL SAFETY SYSTEMS IN A VEHICLE, SUCH AS STEERING OR BRAKES. THE MOTOR COULD SHORT OR THE BRUSHES MAY WEAR, MOTOR DRIVES MAY BURN, AND EVEN A LOW BATTERY COULD TURN THESE STEERING ASSISTANCE INTO A LOAD, MAKING MANEUVERS EVEN MORE DIFFICULT. ALSO A COMPUTER CODE COULD CREATE PROBLEMS THAT CAN CAUSE FATALITIES MAKING SHARP TURNS AT HIGH VELOCITIES. A HYDRAULIC SYSTEM MAY GO LOW ON FLUID AND MAKE SOUNDS; IT MAY GET A LITTLE HARDER TO TURN BUT NEVER WILL GET TOTALLY STUCK. THIS SYSTEM IS NOT SAFE FOR SOMETHING AS CRITICAL AS THE STEERING TRAIN!
Steering, Suspension, Structure, Sep 15, 2015
RIGHT REAR WHEEL HOUSING COMPLETELY GONE. FIRST INDICATION OF ANY ISSUE WAS WHEN SHOCK NO LONGER PROPERLY SUPPORTS. RUST AND TOTAL DE-LAMINATION OF METAL HOUSING SUPPORTING SHOCK. FEAR OF SHOCK PUNCHING THROUGH - INTO CARGO HOLD IN THE AREA OF THE JACK STORAGE.
Exterior lighting, Back over prevention, Sep 15, 2015
TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE BACK UP LIGHTS AND CAMERA FAILED TO ACTIVATE, WHICH DEACTIVATED THE ALERT CHIME. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED AFTER THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V526000 (HYBRID PROPULSION SYSTEM). THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Structure, Aug 28, 2015
WHEN A DRIVER WAS TRAVELLING DOWN THE HIGHWAY, THE HOOD FLEW UP ON THIS VEHICLE THAT WE USE FOR THE COMPANY. THIS HAPPENED TO ANOTHER FORD ESCAPE THE COMPANY HAS, YEAR 2010, THAT I AM ALSO GOING TO FILE A COMPLAINT ON AS IT IS A MAJOR SAFETY ISSUE WITH NO CURRENT RECALL.
Service brakes, Aug 26, 2015
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 5 MPH, WHEN THE BRAKE PEDAL WAS DEPRESSED, THE AUTOMATIC BRAKING SYSTEM ENGAGED INDEPENDENTLY. AS A RESULT, THE VEHICLE SHOOK VIOLENTLY. THE CONTACT DISCOVERED THAT THE FRONT TONE RINGS WERE CRACKED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.
Electrical system, Other or unspecified, Aug 4, 2015
I HAD GONE VA BEACH TO WASHINGTON D.C. AND WAS ON THE WAY BACK WHEN THE VEHICLE HAD COMPLETELY SHUTDOWN JUST BEFORE THE HAMPTON ROADS BRIDGE TUNNEL IN NEWPORT NEWS. WE WERE ON THE INTERSTATE DURING THE ENTIRE TRIP AND WAS LUCKY TO BE IN THE RIGHT LANE. A AAA BE TOW TRUCK PULLED US OFF TO THE SIDE. WE TRIED TO RESTART IT BUT IT SHUT OFF. EVERYTHING ELSE WAS WORKING FINE. I WENT BACK THE NEXT DAY AND THE VEHICLE WORKED FINE. I HAD IT CHECKED OUT BY THE DEALER AND THEY SAID THERE WAS NOTHING WRONG WITH IT. I JUST HAD THE COOLING PUMP REPLACED BECAUSE OF THE RECALL. I LOOKED AT THE MANUAL AND IT STATED THAT WHEN THE HIGH VOLTAGE BATTERY GETS TOO HOT THAT IT WILL SHUT OFF. THIS COULD CAUSE A SERIOUS ACCIDENT. I BELIEVE THAT FORD SHOULD FIND A WAY TO ALLOW THE VEHICLE TO STILL OPERATE ON GAS POWER WHEN HIGH VOLTAGE BATTERY NEEDS TO COOL DOWN AND TO FIND A WAY TO ALLOW BETTER VENTILATION SO THE BATTERY DOES NOT GET SO HOT SINCE IT IS LOCATED IN THE TRUNK WHERE PEOPLE PUT THEIR BELONGINGS.
Other or unspecified, Aug 1, 2015
I WAS DRIVING ON A STATE ROAD AT ABOUT 45 MPG WHEN THE CAR STARTED TO OVERHEAT, AC WAS NOT COOLING AS IT WAS BEFORE THE WARNING THEN A SAFETY SIGN CAME ON THE DASHBOARD TO STOP THE VEHICLE SAFELY. THE NEXT DAY (SATURDAY) I CALLED GREENWAY FORD DEALERSHIP, COLONIAL SR 50, FL AND ASK IF THERE IS A RECALL ON MY VEHHICLE AND EXPLAINED WHAT HAPPENED. I WAS TOLD YES THERE IS A RECALL ON THE COOLING PUMP/MOTOR TO BRING IN THE VEHICLE ON MONDAY. I PAID FOR THE VEHICLE TO BE TOWED ON MONDAY AT 7:30AM AS I WAS TOLD NOT TO DRIVE IT. I CALLED THE DEALERSHIP TO ENSURE THAT THE VEHICLE WAS THERE AND ASKED TO BE CONTACTED ONCE A DIAGNOSIS WAS DONE. NO ONE CALLED ME UNTIL 4:30PM TO PICK UP THE VEHICLE. TWO DAYS LATER THE VEHICLE WARNING SIGN CAME ON AGAIN TO SAFELY STOP THE VEHICLE. I CALLED THE DEALERSHIP AGAIN AND I WAS TOLD I CAN WAIT AND SEE IF IT HAPPENS AGAIN WHICH I DID A COUPLE WEEKS LATER AND LEFT A VOICE MESSAGE. TWO DAYS AGO, THE SAME WARNING SAFETY SIGN CAME ON. YESTERDAY, I PRIVATELY WENT TO A MECHANIC TO RUN A DIAGNOSTIC, WHICH HAD AN ERROR CODE OF P1A10 - HYBRID POWERTRAIN MODULE -BATTERY DISABLED. I WENT TO THE DEALERSHIP AS I HAD NO RETURN CALL FROM THE MANAGER MARK FOSTER. AFTER 2 AND 1/2 HOURS I WAS TOLD THAT I HAVE TO REPLACE THE HYBRID BATTERY COOLING FANS AS ONE IS NOT WORKING FOR A COST OF $1,127.26 WHEN I INQUIRED ABOUT THE HYBRID BATTERY BEING DISABLED I WAS TOLD BY THE MANAGER AND TECHNICIAN THAT THE "BATTERY IS PROTECTING ITSELF FROM MELTING OR CATCHING ON FIRE BY DISABLING". THE PROBLEM THAT EXISTED PRIOR TO CHANGING THE COOLING PUMP STILL EXISTS AND THE FORD COMPANY NOR THE DEALERSHIP IS TAKING ANY RESPONSIBILITY.
Other or unspecified, Jul 31, 2015
THE 2006 FORD ESCAPE XLT CAR WAS WELL MAINTAINED AND I AM THE ONLY OWNER. THE RIGHT WHEEL WELL SHOCK TOWER IS COMPLETELY RUSTED OUT AND IS VERY DANGEROUS TO DRIVE. THE COST WAS ESTIMATED AT OVER 1,000. DOLLAR TO FIX. THERE HAS BEEN NUMEROUS OTHERS WHO HAVE HAD THE SAME EXPERIENCE AND FORD WILL NOT DO ANYTHING ABOUT THE SAFETY ISSUE. SINCE I REPLACED THE 2 REAR SHOCKS THE RIGHT WHEEL WELL RUSTING CLUNKING ISSUE HAS GOTTEN WORSE AND IS A VERY BAD SAFETY ISSUE TO DRIVE. PLEASE MAKE FORD RESPONSIBLE FOR THIS COMMON TERRIBLE SAFETY ISSUE.
Structure, Jul 29, 2015
TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 45 MPH, THE REAR PASSENGER SIDE OF THE VEHICLE STARTED SHAKING VIOLENTLY. THE CONTACT OBSERVED RUST ON THE REAR PASSENGER SIDE TIRE. THE FAILURE RECURRED CONTINUOUSLY CAUSING THE VEHICLE TO BECOME INOPERABLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 150,000.
Other or unspecified, Jul 28, 2015
THE ANTI-THEFT SYSTEM IS UNSTABLE AND IS TRIGGERED RANDOMLY. THIS IS AN ONGOING PROBLEM WITH THIS VEHICLE AND HAS BEEN REPORTED WIDELY AMONG OTHER OWNERS OF FORD ESCAPE - MODEL AND YEAR ARE VARIED. THE ANTI-THEFT SYSTEM IS TRIGGERED BY NO EXTERNAL CAUSE BUT DOES SEEM TO REACT STRONGLY TO HEAT. ALTHOUGH LATELY THIS IS NOW HAPPENING IN THE MIDDLE OF THE NIGHT. FORD CHARGES EXCESSIVELY FOR DIAGNOSES AND REPAIR AND IT IS GENERALLY FOUND TO BE A PROBLEM WITH AN ACCESS POINT SENSOR. THIS IS A SYSTEMIC PROBLEM WITH THE FORD ALARM SYSTEM AND SHOULD NOT BE THE CONSUMER THAT BEARS THE BRUNT OF RESPONSIBILITY FOR A DEFECT THAT THE CORPORATION IS BUILDING INTO ALL YEARS OF THE FORD ESCAPE.
Service brakes, Jul 28, 2015
CAR HAD BEEN PARKED AT AIRPORT PARKING LOT FOR A MONTH. WHEN RETRIEVING IT UPON RETURN BRAKES FAILED, ABS AND BRAKE SERVICE WARNING LIGHT CAME ON, AND PEDDLE WENT TO THE FLOOR. WE PARKED THE CAR IN THE LOT, RENTED A CAR TO GET HOME. NEXT MORNING WE ARRANGED AAA TO TOW VEHICLE. WHEN TOW OPERATOR CAME THE VEHICLE BRAKING SYSTEMS WAS PERFECTLY FINE. WE CHOSE TO PAY HIM AND DRIVE THE CAR HOME. TOOK VEHICLE TO DEALER AND EXPLAINED THE ISSUE. THEY NEVER ACKNOWLEDGED ANY UNDERSTANDING OF THIS PROBLEM. THEY REPLACED REAR BRAKE PADS AND ROTORS BECAUSE THERE WAS ALSO LOUD BRAKE NOISE. NOW ONE YEAR LATER, JULY 27 2015, [97000+ MILES] SLOWING FOR A RIGHT TURN ON A RURAL HIGHWAY AND THE BRAKE SYSTEM FAILED AGAIN. WITH NO WARNING THE PEDDLE WENT TO THE FLOOR. WITH A CONCERTED EFFORT I WAS ABLE TO SLOW THE VEHICLE AND MAKE THE TURN WITHOUT INCIDENT. THE ABS LIGHT AND SERVICE BRAKE WARNING LIGHTS WERE LIT. CONDITION PERSISTED AS WE CONTINUED A FEW MILES TO THE SHOPPING PLAZA. AFTER SHOPPING WE DECIDED TO RETURN DIRECTLY HOME, BUT WHEN CAR WAS STARTED THE FAULT HAD CLEARED AND THE BRAKES FUNCTIONED NORMALLY. WE HAVE JUST SPENT THE MORNING SEARCHING INTERNET AND FIND THIS IS AN ISSUE FORD KNOWS ABOUT AND IS DENYING TO ACKNOWLEDGE. AND APPARENTLY IT IS VERY EXPENSIVE TO RESOLVE WITH THE NEED TO REPLACE THE HCU. WE NOW UNDERSTAND WHAT THE PROBLEM IS BUT ARE AMONG THE MANY WHO FEEL THIS IS CERTAINLY A SERIOUS ENOUGH SAFETY ISSUE FORD SHOULD PARTICIPATE IN ITS RESOLVE FOR OWNERS WITH DEFECTIVE BRAKE SYSTEMS. OUR EXPERIENCE SO FAR IS, THAT THOUGH THERE IS SOME ABILITY TO BRAKE IT IS NOT ANYWHERE EQUAL TO THE 'NORMAL' BRAKING CAPACITY AND THAT IS DANGEROUS. AND THE INTERMITTENT AND RANDOM OCCURRENCE IS TROUBLING TO SAY THE LEAST. WE WILL CONTACT THE DEALER TODAY TO GET THE REACTION TO OUR CONCERN.