2000 Ford Explorer
Problems, recalls and owner-reported issues
Tires is the leading concern among 1,078 owner complaints filed for this model year. This is the 11th highest complaint count among 26 Explorer model years with reports.
Of the 2000 reports, 112 involved a crash and 83 involved a fire. 118 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Seats, front assembly, reclinerAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.
THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V281000 on NHTSA.gov
Vehicle speed control, cablesAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.
THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V280000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, tread/beltMay 22, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
Campaign 01X001000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH THE 3.27 OR 3.55 AXLE RATION. THE SUBJECT VEHICLES HAVE A POWERTRAIN CONTROL MODULE THAT COULD ALLOW THE VEHICLE TO EXCEED THE DESIGN INTENT TOP SPEED. AT THESE EXTREME SPEEDS, THE VEHICLE COULD BE CAPABLE OF EXCEEDING THE SPEED RATING OF THE TIRE.
OPERATING THE VEHICLE ABOVE THE MAXIMUM SPEED RATING COULD LEAD TO A TIRE FAILURE WHICH AT THESE SPEEDS COULD RESULT IN A CRASH.
DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE.
Campaign 00V395000 on NHTSA.gov
Tires, tread/beltAug 21, 2000
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.
Campaign 00T005000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Air bags, side/windowJul 5, 2000
VEHICLE DESCRIPTION: 4-DOOR SPORT UTILITY VEHICLES EQUIPPED WITH SIDE AIR BAGS. THE SUBJECT VEHICLES HAVE A REVISED LEVEL SIDE CRASH SENSOR THAT COULD DEPLOY THE SIDE AIR BAG IF THE IGNITION KEY IS IN THE "RUN" POSITION AND THE SEATBELT WEBBING IS FORCIBLY EXTRACTED FROM A LOCKED RETRACTOR WITH A JERKING MOTION.
INADVERTENT SIDE AIR BAG DEPLOYMENT COULD CAUSE PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL REPLACE THE SIDE CRASH SENSORS WITH A REVISED DESIGN THAT WILL REDUCE THE LIKELIHOOD OF AN UNEXPECTED SIDE AIR BAG DEPLOYMENT.
Campaign 00V179000 on NHTSA.gov
Electrical system, wiring, fuses and circuit breakersMar 7, 2000
VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES EQUIPPED WITH 4.0L ENGINES AND ALL-TIME 4-WHEEL DRIVE (A4WD) POWERTRAINS. THE GENERIC ELECTRONIC MODULE (GEM) COULD EXPERIENCE A CONDITION REFERRED TO AS "LOCK-UP" IN WHICH THE GEM CONTROLLED ELECTRONIC FUNCTIONS (E.G., FRONT WINDSHIELD WIPERS, INTERIOR LIGHTS, 4X4 SYSTEM, ETC.) COULD NOT BE TURNED ON OR, IN SOME CASES IF THE FUNCTION IS ON, COULD NOT BE TURNED OFF.
AN INOPERATIVE WINDSHIELD WIPER SYSTEM COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSTALL A RESISTOR IN THE GEM CIRCUIT.
Campaign 00V072000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
102 reports, newest first. Show all
Engine and engine cooling, Service brakes, Apr 16, 2025
See attached document for complaint.
Engine and engine cooling, Electrical system, Jun 13, 2016, fire
2000 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO RECALL STATES ENGINE RUNNING WITHOUT IGNITION KEY COULD START A FIRE. CONSUMER STATES THOUGHT DEALERSHIP REPAIRED RECALL PROBLEMS. VEHICLE EXPLODED SEVEN MINUTES AFTER CONSUMER EXISTS VEHICLE. *SMD
Engine and engine cooling, Power train, Nov 20, 2014
TIMING CHAIN RATTLES. *TR
Engine and engine cooling, Feb 21, 2012, fire
TL* THE CONTACT OWNS A 2000 FORD EXPLORER. THE CONTACT WAS DRIVING 35 MPH WHEN SMOKE EMITTED FROM THE REAR END OF THE VEHICLE. THE CONTACT EXITED THE VEHICLE AND NOTICED FLAMES COMING FROM UNDER THE VEHICLE. THE VEHICLE WAS DESTROYED. THE POLICE AND THE FIRE DEPARTMENT WERE CONTACTED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 179,000.
Engine and engine cooling, Jan 20, 2012, fire
SPARKPLUG SUPER-HEATED AND MELTED LONGITUDINALLY DESTROYING THE OUTERMOST SPARKPLUG THREADS (7 THROUGH THE SEATING SURFACE OF THE SPARK PLUG). INNER MOST THREADS, THE ONES DEEPEST INTO THE HEAD WERE NOT DAMAGED. A SECOND PLUG WAS INSTALLED ALONG WITH A NEW SPARK PLUG WIRE AND WITHIN 20 MILES, THE SPARKPLUG WAS AGAIN MELTED BEYOND SALVAGE AND THE NEW WIRE BURNED UP. DUE TO THE DESTRUCTION OF THE SPARKPLUG, IT WAS ABLE TO BE REMOVED WITHOUT TOOLS AS THERE WERE NO THREADS REMAINING IN THE CYLINDER HEAD. FORTUNATELY THE FIRE DAMAGE (LIKELY FROM THE SPARK OF THE PLUG) WAS LIMITED ONLY TO DAMAGING THE SPARKPLUG AND THE SPARK PLUG WIRE LABLED #3. *TT
Engine and engine cooling, Dec 13, 2011, fire
THIS IS TO REPORT A FIRE IN A 2000 FORD EXPLORER: ON FRIDAY, 25 NOV 11, 5 ADULTS (MY HUSBAND, 2 SONS, DAUGHTER-IN LAW, AND MYSELF) AND 2 DOGS, LEFT BETHLEHEM PA FOR OUR FAMILY CHRISTMAS TRIP IN OUR 2000 FORD EXPLORER, PULLING A UTILITY TRAILER. THE INTENT OF THE TRIP WAS TO START AT A CHRISTMAS TREE FARM, CUT DOWN 3 CHRISTMAS TREES, HAUL THEM IN THE TRAILER AND CONTINUE WITH SEVERAL OTHER CHRISTMAS RELATED TRADITIONAL STOPS. MY HUSBAND, DROVE APPROXIMATELY 45 MINUTES NORTH TO BISSELS CHRISTMAS TREE HILL IN LEHIGHTON, PA. HE DID NOT USE CRUISE CONTROL BECAUSE WE WERE PULLING THE TRAILER. THE TRIP WAS FINE WITH ABSOLUTELY NO INDICATIONS THAT ANYTHING WAS WRONG WITH THE VEHICLE. IT ALSO HAD NOT HAD ANY SERVICE DONE TO IT RECENTLY (A QUESTION FREQUENTLY ASKED TO US). HE PARKED THE VEHICLE ALONG AN EMBANKMENT AT THE TREE FARM AND WE ALL WERE IN VARIOUS STAGES OF GETTING OUT OF THE CAR WITH THE DOGS WHEN SOMEONE NEARBY YELLED TO US THAT OUR CAR WAS ON FIRE. SHE REPEATED IT AS WE LOOKED TO SEE WHO SHE WAS ADDRESSING. WE LOOKED AT OUR CAR AND SAW THAT UNDER IT, FIRE BALLS WERE HITTING THE GROUND FROM WHAT APPEARED TO BE THE CENTER OF THE ENGINE. MY HUSBAND ATTEMPTED TO OPEN THE HOOD AND SMOKE WAS IMMEDIATELY POURING OUT OF THE ENGINE. WE ALL QUICKLY GOT AWAY FROM THE VEHICLE. MY ONE SON IMMEDIATELY CALLED 911 AND MY OTHER SON RAN NEARBY TO TRY AND FIND A FIRE EXTINGUISHER. THE SMOKE QUICKLY TURNED INTO A FULL BLOWN FIRE. THE COMPLETE FRONT OF THE VEHICLE, ALONG WITH THE EMBANKMENT NEARBY, WAS ABLAZE. THE MAHONING VALLEY POLICE CAME, THEN THE FIRE CAPTAINS, THEN 2 FULL FIRE TRUCKS FROM LEHIGHTON AND MAHONING VALLEY FIRE DEPARTMENTS. THEY QUICKLY EXTINGUISHED EVERYTHING, ALONG WITH THE VEHICLE WE LOST MY PURSE, JACKETS, AND OTHER MISCELLANEOUS VALUABLES THAT WERE ON THE FLOOR OF THE FRONT SEAT AND IN THE GLOVE COMPARTMENT. *TR
Engine and engine cooling, Power train, Jul 18, 2011, fire
THE 2000 FORD EXPLORER SUV BEGAN TO SLOW DOWN AS THE ENGINE RPMS INCREASED. AFTER PULLING OVER AND TURNING THE IGNITION OFF, WE NOTICED SMOKE COMING FROM THE HOOD. UNDERNEATH THE CAR, FLAMES WERE DRIPPING DOWN FROM THE TRANSMISSION. WE USED A FIRE EXTINGUISHER TO EXTINGUISH THE FLAMES ON THE GROUND, AND ATTEMPTED TO OPEN THE HOOD. AFTER THE HOOD WAS OPENED, LARGE FLAMES WERE OBSERVED IN THE ENGINE COMPARTMENT. THE FIRE EXTINGUISHER WAS USED UNTIL EMPTY AND HAD LITTLE IMPACT. THE CAR BEGAN TO BURN QUICKLY AND THE FLAMES SPREAD FROM FRONT TO BACK. THE EMERGENCY SERVICES ARRIVED, EXTINGUISHED THE FIRE AND COLLECTED WITNESS STATEMENTS. NO ONE WAS HURT IN THE INCIDENT AND THE FRAME WAS TOWED VIA AAA TO A NEARBY AUTOMOTIVE SHOP. *KB
Engine and engine cooling, Jun 14, 2010, fire
MY FORD EXPLORER CAUGHT ON FIRE. ALL I SAW WAS CLOUD OF SMOKE. THEN PEOPLE STARTED YELLING AND BLOWING THEIR HORN AT ME, THE UNBELIEVABLE, THAT MY CAR WAS ON FIRE. *TR
Engine and engine cooling, Sep 1, 2009
TL*THE CONTACT OWNS A 2000 FORD EXPLORER . THE CONTACT STATES THAT WHILE DRIVING THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND THE VEHICLE STALLED. SHE THEN PULLED OVER AND TURNED THE VEHICLE OFF. SHE THEN RESTARTED THE VEHICLE AND DROVE DIRECTLY TO THE DEALER. THE TECHNICIAN ADVISED HER THAT THE FAILURE OCCURRED FROM A CRACK IN THE CYLINDER HEAD OF THE ENGINE. THE VEHICLE WAS REPAIRED UNDER OWNERS EXPENSE. WHEN IT WAS AT THE DEALER SHIP THEY TOOK THE VEHICLE APART WITHOUT THE DRIVERS PERMISSION. THE DRIVER CALLED AN INVESTIGATOR FROM THE BUREAU OF AUTOMOTIVE REPAIR. IT WAS DETERMINED THAT THEY USED A DEFECTIVE ENGINE FOR THE 2000 FORD MODELS AND FOUND OUT AFTER A YEAR AND THAT'S WHY THE Y DISCONTINUED USING THAT SPECIFIC ENGINE. THE FAILURE MILEAGE WAS 93104 AND THE CURRENT MILEAGE WAS 93300.
Engine and engine cooling, Apr 27, 2009
SPARK PLUG CLOSEST TO DRIVER DOES NOT SEAT AND COMES OUT. NOT A FULL BLOW OUT OF IT, BUT THE PLUG FEELS REAL LOOSE. I TRIED NEW PLUG BUT IT STILL FEELS LOOSE. *TR
Engine and engine cooling, Jan 7, 2009, fire
TL*THE CONTACT OWNS A 2000 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 30 MPH, ANOTHER DRIVER INFORMED THE CONTACT THAT THERE WERE FLAMES UNDERNEATH THE VEHICLE. SHE PULLED OVER ONTO THE SIDE OF THE ROAD AND NOTICED FLAMES UNDERNEATH THE VEHICLE AND THE HOOD. THE CONTACT QUICKLY REMOVED HER CHILDREN AND CHILD SEAT FROM THE VEHICLE. IN A MATTER OF SECONDS, THE HOOD BURST INTO FLAMES. THE VEHICLE WAS DESTROYED AND TOWED TO THE JUNKYARD. THE INSURANCE COMPANY WILL NOT INVESTIGATE THE FAILURE BECAUSE THE VEHICLE DID NOT HAVE COMPLETE COVERAGE. THE MIAMI MIDWAY POLICE DEPARTMENT FILED REPORT NUMBER PPOC9A02C02188. THE CURRENT AND FAILURE MILEAGES WERE 96,000.
Engine and engine cooling, Power train, Dec 15, 2008
AT 166,000 HEAD GASKET BLEW PLUS THERE WERE OTHER ENGINE PROBLEMS. REPLACED WITH ANOTHER ENGINE. NOW TRANSMISSION IS GOING OUT. IT WILL GO INTO REVERSE FINE BUT WILL GO INTO DRIVE WITH PROBLEMS. IF VEHICLE IS COLD IT WILL GO INTO DRIVE FASTER THAN WHEN IT IS WARMED UP. AT WARM TEMP IT MAY TAKE SEVERAL TRIES OF SHIFTING FROM PARK BACK TO DRIVE OR WAITING SEVERAL MINUTES FOR IT TO DROP INTO DRIVE AFTER SHIFTING OUT OF PARK. HAVE ONLY OWNED THIS VEHICLE LESS THAN 2 YEARS. *TR
Engine and engine cooling, Dec 2, 2008
TL*THE CONTACT OWNS A 2000 FORD EXPLORER. WHILE THE VEHICLE WAS UNDERGOING AN OIL CHANGE, THE MECHANIC FOUND ANTIFREEZE IN THE OIL. NEW OIL WAS PLACED IN THE VEHICLE AND, ONCE IT WAS RESTARTED, ANTIFREEZE WAS FOUND IN THE OIL AGAIN. THE CONTACT CALLED THE MANUFACTURER FOR ASSISTANCE AND THEY STATED THAT THERE WAS NO RECALL ON THE HEAD GASKET. THEY FURTHER STATED THAT THE FAILURE WAS DUE TO A BLOWN HEAD GASKET OR A FAILED HEAD BOLT. THE VEHICLE HAS NOT BEEN TAKEN TO THE DEALER. THE FAILURE MILEAGE WAS 110,000.
Engine and engine cooling, May 28, 2008
TL*THE CONTACT OWNS A 2000 FORD EXPLORER. WHEN THE VEHICLE IS STARTED, THE ENGINE MAKES A LOUD RATTLING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY DISCOVERED THAT THE TIMING BELT WAS OFFLINE. THE DEALER INFORMED THE CONTACT THAT THEY WERE CONDUCTING A FREE REPAIR FOR THIS FAILURE; HOWEVER, THE TIME HAD ALREADY EXPIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WERE NO LONGER HONORING THE REPAIR. THE FAILURE MILEAGE WAS 130,000. UPDATED 06/17/08. *LJ UPDATED 06/17/08
Engine and engine cooling, Jan 25, 2008
TL*THE CONTACT OWNS A 2000 FORD EXPLORER. THE FUEL LINE RUSTED AND DEVELOPED TINY PIN HOLES AND CRACKS. THE ENGINE LIGHT ILLUMINATED ALSO. THE CONTACT WAS INFORMED THAT THE COST WOULD BE BETWEEN $400 AND $500 TO REMOVE THE TANK. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 34,200 AND FAILURE MILEAGE WAS 34,100.
Engine and engine cooling, Nov 28, 2007
VEHICLE STARTED RUNNING VERY ROUGH IN DRIVE BUT OK IN PARK AND SMELL OF FUEL OR EXHAUST WAS IN CABIN. TOOK VEHICLE TO DEALERSHIP IMMEDIATELY. DEALERSHIP SAID VALVE WAS BURNED OUT AND THIS ONLY HAPPENS IF VEHICLE HAS OVERHEATED. THIS VEHICLE HAS NEVER OVERHEATED AND EVEN ACKNOWLEDGED A FULL AND CLEAN COOLANT LEVEL PRESENT. DEALERSHIP WANTS $1,800 TO FIX ENGINE WHICH ONLY HAS 68,000 MILES ON IT. *TR
Engine and engine cooling, Jul 5, 2007
VEHICLE DIED DURING TRAVEL WITH NO WARNING, FORD ISSUED RECALL. HOWEVER DUE TO THE LIMITED NUMBER OF CONSUMERS WITH THIS YEAR AND SPECIFIC MODEL COMPLAINTS WERE OVERLOOKED. DEALER SHOULD OFFER RECOURSE. *AK
Engine and engine cooling, May 21, 2007
TL*THE CONTACT OWNS A 2000 FORD EXPLORER. ON MAY 21, 2007, THE CONTACT STATED THAT THE COIL PACK AND SPARK PLUGS FAILED IN HER VEHICLE TWICE IN FOUR DAYS. THE CONTACT STATED THAT THE SERVICE ENGINE LIGHT ILLUMINATED AND THE VEHICLE VIBRATES AND LOOSES POWER WHEN DRIVING. THE CONTACT STATED THAT SPEED AND WEATHER WERE NOT FACTORS. THE PURCHASE DATE AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 150,000.
Engine and engine cooling, Electrical system, May 21, 2007
TL*THE CONTACT OWNS A 2000 FORD EXPLORER XLT. WHILE DRIVING THE VEHICLE, THE FACTORY INSTALLED INTERIOR LIGHTS BEGAN FLASHING ON AND OFF. THE DEALER STATED THAT THE FAILURE WAS DUE TO A FAULTY CONNECTION WITH THE REAR VIEW MIRROR. SHE WAS CHARGED $477 PLUS LABOR FOR THE REPAIR. THE CONTACT WROTE AND CALLED THE MANUFACTURER, BUT THEY HAVE NOT RESPONDED. THE APPROXIMATE DATE OF FAILURE WAS IN NOVEMBER OF 2006. THE SECOND INCIDENT OCCURRED WHEN THE VEHICLE WAS TAKEN TO THE SAME DEALER WHO STATED THAT THERE WAS A LEAK IN THE ENGINE. SHE STATED THAT THE VEHICLE HAS AN ENGINE WARRANTY OF 60,000 MILES. HOWEVER, THE DEALER CHARGED HER FOR THIS REPAIR AS WELL. THIS FAILURE OCCURRED ON FEBRUARY 6, 2007. THE CONTACT NOTIFIED HER STATE ATTORNEY GENERALS OFFICE WHO STATED THAT THEY RECEIVED A LETTER FROM FORD AND THAT SHE COULD SUE FORD IF SHE WISHED. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 57,000 AND FAILURE MILEAGE WAS 55,000.
Engine and engine cooling, Mar 30, 2007
NO EVENTS LED UP TO THE CRANKSHAFT FAILURE. OUR 2000 FORD EXPLORER WAS BEING DRIVEN AS A DAILY ROUTINE TRIP IN TOWN. THE CAR DIED AT A STOP LIGHT. I WAS ABLE TO RESTART THE CAR . THE CAR MADE A LOUD CLUNK. I DROVE THE VEHICLE INTO A PARKING LOT AND SHUT IT OFF. WE HAD A CERTIFIED FORD MECHANIC COME OUT TO LOOK AT THE CAR. HE WAS VERY FAMILIAR WITH THIS V6 ENGINE. HE STATED TO US THAT THE CRANKSHAFT FORD USED WAS A CAST IRON CRANK AND NOT A FORGED STEEL CRANK. WHAT HAPPENS IS THE CRANKSHAFT WILL DEVELOP CRACKS IN IT AND EVENTUALLY BREAK APART. HIS COMMENT WAS IT WAS A BAD IDEA AND BAD DESIGN BY FORD. THIS MECHANIC WORKED FOR FORD FOR 18 YEARS AND STATED THAT THIS PARTICULAR ENGINE WAS USED FROM 1995-2001 AND I BELIEVE HE SAID IT WAS A COLOGNE V6 .OUR 2 OPTIONS AT THIS POINT IS TO PUT IN A NEW MOTOR OR JUNK THE CAR. THIS VEHICLE IS A 2000 FORD EXPLORER SPORT 2 DOOR. TWO WHEEL DRIVE. DEALER MAINTAINED AT 30000,60000,AND RECENTLY AT 90000 MILES .CURRENT MILEAGE IS 91000. OIL CHANGED EVERY 2 MONTHS REGARDLESS. MAINTENANCE RECORDS ARE ALL AVAILABLE. NO REASON FOR AN IMPORTANT COMPONENT LIKE A CRANKSHAFT TO CRACK AND RUIN THE CAR. *JB
Engine and engine cooling, Mar 29, 2007
2000 EXPLORER XLT WITH APPROXIMATELY 55000 MILES. TAKEN TO DEALER TO BE SERVED C FOR STALLING AND FAILURE TO RESTART WITH HIGH TEMPERATURE. DEALER REPORTED THAT ENGINE HDS COOLANT AND OIL MIXING AND WILL HAVE TO BE REPLACED, $3500 COST. WHEN I OBJECTED, DEALER THEN STATED THAT THE LOWER INTAKE MANIFOLD GASKET FAILED, AND THAT THE ENGINE WILL NEED TO BE TORN DOWN TO FIX , 2,000. . I OBJECTED AGAIN, AND DEALER DECIDED TO REPLACE GASKET, FLUSH OIL, COOLANT SYSTEMS, AND RETURN TO THE ROAD , $1100. DEALER INFORMED ME THAT THEY COULD NOT BE HELD RESPONSIBLE FOR FUTURE ENGINE FAILURE DUE TO COOLANT IN ENGINE. I INVESTIGATED, AND FOUND SECRET WARRANTY SERVICE BULLETIN , NETS NUMBER 616816. WHEN I ATTEMPTED TO RECOVER COST OF REPAIR UNDER SB, DEALER REFUSED, CLAIMING THAT SB EXTENSION WAS OVER , ENDED DECEMBER 2006. THIS VEHICLE HAD LESS THAN THE LIMITED MILEAGE UNDER THE WARRANTY, AND OBVIOUS DRIVING RATES LESS THAN EXPECTED UNDER THE WARRANTY , ORIGINAL AND SECRET EXTENSION.. CUSTOMERS HAVE NOT BEEN MADE AWARE OF THIS SECRET WARRANTY EXTENSION. ENGINE GASKETS, INCLUDING HEAD GASKETS AND MANIFOLD GASKETS WERE NOT OWNER SERVICED ITEMS, AND WERE EXPECTED TO LIVE AS LONG AS THE POWER PLANT. I EXPECTED FORD TO LIVE UP TO THEIR PRODUCT HYPE AND FIX THIS VEHICLE FOR FREE, INCLUDING COMPLETE ENGINE REPLACEMENT IF REQUIRED.*AK
Engine and engine cooling, Feb 3, 2007
#8 SPARK PLUG POPPED OUT OF HEAD CAUSING THE THREADS TO STRIP IN HEAD & BUSTED COIL PACK. CONVERTER WAS GLOWING RED & POPPING. *NM
Engine and engine cooling, Dec 13, 2006
DT*: THE CONTACT STATED THE ENGINE RATTLED AND THE VEHICLE NEEDED THE ENGINE BOLTS TIGHTENED TO RESOLVE THE ISSUE. THE VEHICLE HAD BEEN TO A PRIVATE MECHANIC BUT NOT A SERVICE DEALER.
Engine and engine cooling, Vehicle speed control, Nov 16, 2006, fire
DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED IN FRONT OF THE RESIDENCE, A NOISE WAS HEARD, THEN FIRE WAS NOTICED COMING FROM UNDER THE HOOD. THE CONTACT CALLED THE FIRE DEPARTMENT WHO EXTINGUISHED THE FIRE AND REPORTED THE FIRE AS ELECTRICAL FAILURE FROM THE SPEED CONTROL SYSTEM. THE CONTACT TOOK PICTURES OF THE CHARRED VEHICLE. THE INSURANCE COMPANY DEEMED THE VEHICLE A TOTAL LOSS. THE DEALERSHIP WAS CONTACTED BUT NEVER RETURNED THE CALL. THE MANUFACTURER WAS ALSO CONTACTED WHO INFORMED HER THE VEHICLE WAS NOT INCLUDED IN ANY RECALL PERTAINING TO THE SPEED CONTROL SYSTEM DUE TO THE VIN. THE FIRE DEPARTMENT HAD NOT DETERMINED WHAT CAUSED THE FIRE, HOWEVER, THE CONSUMER HAD READ ABOUT REPORTS WHERE VEHICLE WERE CATCHING ON FIRE DUE TO FAULTY CRUISE CONTROL SWITCHES. UPDATED 12/13/06. *JB UPDATED 04/03/07. *JB
Engine and engine cooling, Sep 5, 2006
OVER THE PAST THREE TO FOUR MONTHS MY 2000 FORD EXPLORER (6 CYLINDER W/ SOHC ENGINE) HAS DEVELOPED A PROBLEM WITH THE ENGINE. THE PROBLEM OCCURS ON AN INTERMITTENT BASIS. AT TIMES THE ENGINE WILL NOT START. WHEN IT DOES START IT WILL NOT IDLE AND DIES UNLESS THE RPM'S ARE MANUALLY HELD AT A HIGH ENOUGH LEVEL TO ALLOW THE ENGINE TO RUN. WHEN BRAKING AT ANY SPEED THE ENGINE WILL DIE WHEN THE AUTOMATIC TRANSMISSION SHIFTS FROM A HIGHER GEAR TO A LOWER GEAR ALLOWING THE RPM'S TO FALL BETWEEN SHIFTS. THIS REQUIRES SHIFTING THE CAR INTO NEUTRAL TO RE-START WITH A LOSS OF ALL POWER STEERING AND BRAKING FUNCTIONS. A FIRST IT SEEMED THE PROBLEM ONLY OCCURRED AFTER THE CAR WAS PARKED OUTSIDE DURING HOT DAYS. NOW THE PROBLEM OCCURS AT DIFFERENT TIMES AND DIFFERENT WEATHER CONDITIONS. THE CAR RECENTLY HAD THE FUEL SYSTEM SERVICED (ALONG WITH THE 65K RECOMMENDED SERVICE PACKAGE) AT A LOCAL FORD DEALER. THE PROBLEM PERSISTS. I WROTE TO CONSUMER REPORTS MAGAZINE AND THEY SUGGESTED I FORWARD THIS INFORMATION. *B