2000 Ford Explorer
Problems, recalls and owner-reported issues
Tires is the leading concern among 1,078 owner complaints filed for this model year. This is the 11th highest complaint count among 26 Explorer model years with reports.
Of the 2000 reports, 112 involved a crash and 83 involved a fire. 118 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Seats, front assembly, reclinerAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.
THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V281000 on NHTSA.gov
Vehicle speed control, cablesAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.
THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V280000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, tread/beltMay 22, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
Campaign 01X001000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH THE 3.27 OR 3.55 AXLE RATION. THE SUBJECT VEHICLES HAVE A POWERTRAIN CONTROL MODULE THAT COULD ALLOW THE VEHICLE TO EXCEED THE DESIGN INTENT TOP SPEED. AT THESE EXTREME SPEEDS, THE VEHICLE COULD BE CAPABLE OF EXCEEDING THE SPEED RATING OF THE TIRE.
OPERATING THE VEHICLE ABOVE THE MAXIMUM SPEED RATING COULD LEAD TO A TIRE FAILURE WHICH AT THESE SPEEDS COULD RESULT IN A CRASH.
DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE.
Campaign 00V395000 on NHTSA.gov
Tires, tread/beltAug 21, 2000
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.
Campaign 00T005000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Air bags, side/windowJul 5, 2000
VEHICLE DESCRIPTION: 4-DOOR SPORT UTILITY VEHICLES EQUIPPED WITH SIDE AIR BAGS. THE SUBJECT VEHICLES HAVE A REVISED LEVEL SIDE CRASH SENSOR THAT COULD DEPLOY THE SIDE AIR BAG IF THE IGNITION KEY IS IN THE "RUN" POSITION AND THE SEATBELT WEBBING IS FORCIBLY EXTRACTED FROM A LOCKED RETRACTOR WITH A JERKING MOTION.
INADVERTENT SIDE AIR BAG DEPLOYMENT COULD CAUSE PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL REPLACE THE SIDE CRASH SENSORS WITH A REVISED DESIGN THAT WILL REDUCE THE LIKELIHOOD OF AN UNEXPECTED SIDE AIR BAG DEPLOYMENT.
Campaign 00V179000 on NHTSA.gov
Electrical system, wiring, fuses and circuit breakersMar 7, 2000
VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES EQUIPPED WITH 4.0L ENGINES AND ALL-TIME 4-WHEEL DRIVE (A4WD) POWERTRAINS. THE GENERIC ELECTRONIC MODULE (GEM) COULD EXPERIENCE A CONDITION REFERRED TO AS "LOCK-UP" IN WHICH THE GEM CONTROLLED ELECTRONIC FUNCTIONS (E.G., FRONT WINDSHIELD WIPERS, INTERIOR LIGHTS, 4X4 SYSTEM, ETC.) COULD NOT BE TURNED ON OR, IN SOME CASES IF THE FUNCTION IS ON, COULD NOT BE TURNED OFF.
AN INOPERATIVE WINDSHIELD WIPER SYSTEM COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSTALL A RESISTOR IN THE GEM CIRCUIT.
Campaign 00V072000 on NHTSA.gov
Representative owner complaints: vehicle speed control
129 reports, newest first. Show all
Vehicle speed control, Seats, Sep 23, 2003
FORD RECALLS (03S03 / 03S04).*MR THE DRIVER SEAT BACK MAY RECLINE WHILE DRIVING POSING A SAFETY HAZARD. ALSO, THE SPEED CONTROL ON THE VEHICLE MAY NOT DISENGAGE DUE TO A BINDING CONDITION BETWEEN THE SPEED CONTROL STRAND COVER AND THE CABLE CONDUIT. THE CONSUMER RECEIVED A SAFETY RECALL PERTAINING TO THE ABOVE MENTIONED, HOWEVER SHE WAS UNABLE TO GET THE WORK PERFORMED IN A TIMELY MANNER AS A RESULT OF THE DEALER NOT HAVING THE RECALLED PARTS. *PH *JB *SC
Electrical system, Vehicle speed control, Sep 12, 2003, crash
WHILE THE CONSUMER'S WIFE PULLED INTO THE DRIVEWAY, THE GAS PEDAL BECAME STUCK AND CAUSED HER TO RUN INTO THE SIDE OF THE HOUSE. THE COLLISION CAUSED $18,000 WORTH OF DAMAGE TO THEIR HOME. SINCE THE VEHICLE HAD BEEN IN THE REPAIR SHOP 8 TIMES. EVERY ONCE IN A WHILE THE RPMS REVVED UP CAUSING THE ENGINE TO RACE. THERE WERE PROBLEMS WITH THE TAIL LIGHTS. THE DEALER/MECHANIC STATED THAT THEY COULD NOT FIND ANYTHING WRONG WITH THE VEHICLE, SO THEY COULD NOT REPAIR IT. AFTER ALMOST HAVING AN ACCIDENT, THE VEHICLE WAS TAKEN TO THE CHEVROLET DEALERSHIP AND AN ELECTRICAL PROBLEM WAS FOUND AND THE DEALERSHIP REPAIRED THE VEHICLE. *AK *SCC *JB
Vehicle speed control, May 30, 2003
FUEL PUMP FAILED ON MY 2000 FORD FOCUS ZTS (@ 45,000 MILES) CAUSED STALLING WHILE DRIVING ON INTERSTATE. CURRENTLY (@ 47,000 MILES) RPM'S ARE ERRATIC AND VEHICLE STALLS.*AK
Vehicle speed control, Feb 14, 2003
CRITICAL DEFECT IN THE THROTTLE LINKAGE/CRUISE CONTROLS 2000 EXPLORER. IN TWO INCIDENTS INVOLVING THE SAME CONDITIONS: 1) TRUCK , WHEN CRUISE CONTROL ENGAGED, SUDDENLY ACCELLERATED TO SPEEDS IN EXCESS OF 90 MPH, ON ICY AND SNOWY INTERSTATE (JANUARY 2003), BETWEEN NASHIVILLE AND CINCINNATI, OHIO. 2) TRUCK , WHEN CRUISE CONTROL ENGAGED, SUDDENLY ACCELLERATED TO EXCES OF 90 MPH, ON DRY INTERSTATE (71) BETWEEN CINCINNATI, OHIO AND COLUMBUS OHIO. IN BOTH OCCURRENCES, TRUCK TOTALLY NON-RESPONSIVE TO BRAKING ATTEMPTS, TO THE EXTENT THAT DRIVERS STOOD ON THE BRAKES TO ATTEMPT DISENGAGEMENT OF CRUISE CONTROL. ALL OTHER ATTEMPTS AT TURNING OFF ALSO INEFFECTIVE (SWITCHES NON-RESPONSIVE AS WELL). BRAKES HAVE BEEN SUBSTANTIALLY DAMAGED. DRIVERS BOTH MAINTAIN THAT ACCELLERATION HAPPENED WITHOUT WARNING AND ONLY DISENGAGEMENT OF THE TRANSMISSION (NEUTRAL) CEASED ACCELLERATION. THE RPM OF THE ENGINE CONTINUED TO MAINTAIN 4,000+ RPM AND ONLY COULD THE ENGINE BE DISENGAGED WHEN VEHICLE WAS STEERED INTO SOFT GROUND TO BE SLOWED. THIS PROBLEM IS REPETITIVE AND EXTREMELY DANGEROUS AS IS, BUT EGREGIOUS WHEN MIXED WITH ICY/SNOWY CONDITIONS. FORD DELAERSHIP NON-RESPONSIVE TO GREATER ISSUE; ATTEMPTING TO SHIF LIABILITY ON DRIVERS AND EXPECTING REPAIRS TO BE SHOULDERED BY DRIVERS/OWNERS. DRIVERS MAINTAIN GOOD DRIVING RECORDS AND NOW BELIEVE THIS PROBLEM TO BE LIFE-THREATENING. DRIVERS HAVE ALSO NOTED MULTIPLE OTHER CONSUMERS WITH SAME EXACT PROBLEM AND ARE AWARE OF RECALLS INVOLVING THIS SAME TYPE OF PROBLEM IN OTHER FORD PRODUCTS.
Vehicle speed control, Nov 22, 2002
CONSUMER STATE WHILE TRAVELING WITH SPEED CONTROL ON SPEED CONTROL WOULD NOT DISENGAGE CAUSE CONSUMER APPLIES FORCE TO BRAKE TO STOP VEHICLE. PLEASE PROVIDE FURTHER INFORMATION. TS
Vehicle speed control, Oct 30, 2002
WHILE THE CONSUMER WAS DRIVING WITH CRUISE CONTROL ON AT 63 MPH THE VEHICLE SLOWED DOWN, THE CHECK ENGINE LIGHT CAME ON AND THE ENGINE STALLED. *YH
Vehicle speed control, Oct 17, 2002
SPEED CONTROL SET AT 67 MPH. WOULD NOT DISENGAGE WHEN BRAKE TAPPED. HIT "OFF" BUTTON SEVERAL TIMES AND APPLIED HEAVY PRESSURE TO BRAKE PEDAL. ENGINE RACED TO 4000 RPM, ABS ENGAGED, VEHICLE SLOWED TO 55 MPH AND SPEED CONTROL DISENGAGED. SERIOUS SAFETY CONCERN. DT
Vehicle speed control, Sep 30, 2002
CONSUMER STATES THAT THE CRUISE CONTROL WOULD NOT DISENGAGE AND THE CRUISE CONTROL SWITCH WOULD NOT TURN OFF WHILE DRIVING 70 MPH. VEHICLE AT THE DEALER. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION. NLM
Vehicle speed control, Aug 31, 2002
TROUBLE STARTING. HAD TO REPLACE IDLE AIR CONTROL MOTOR.*AK
Vehicle speed control, Aug 5, 2002
WHILE DRIVING 60 MPH TOOK FEET OFF ACCELERATOR PEDAL AND CAR SPEEDED UP TO ABOUT 95MPH, CAUSING LOSS OF CONTROL.*AK CONSUMER HAD TO USE BOTH FEET ON THE BRAKES TO TRY AND STOP THE VEHICLE. THE ENGINE KEPT RUNNING FULL THROTTLE PULLING THE VEHICLE THRU THE BRAKING EFFORT. CONSUMER DIALED 911 FOR HELP. CONSUMER WAS ADVISED TO PLACE THE VEHICLE IN NEUTRAL TO AID IN THE SLOWING OF THE VEHICLE. THE ENGINE CONTINUED TO WIND OUT AT FULL FORCE. THE VEHICLES MOMENTUM PULLED CONSUMER THROUGH A RED LIGHT TO A SMOKING STOP. CONSUMER HAS REQUESTED THE TAPE AS EVIDENCE. *JG
Vehicle speed control, Jul 30, 2002
WHILE DRVING AT 10 MPH, CONSUMER ACCIDENTLY ACTIVATED THE RESUME CRUISE CONTROL WHICH WAS PREVIOUSLY ON, AND VEHICLE SUDDENLY ACCELERATED, HITTING A CONCRETE WALL. MINOR INJURIES SUSTAINED. *TT
Vehicle speed control, Jul 12, 2002
CRUISE CONTROL STUCK - DEALER TREATING AS RECALL PER FORD RECALL #99S09 DEALING WITH STICKING CRUISE CONTROL. CRUISE CONTROL WOULD NOT RELEASE THROTTLE (BRAKES OR OFF SWITCH FOR CRUISE CONTROL) - VEHICLE HAD TO BE PUT INTO NEUTRAL, STOPPED AND THEN ENGINE STOPPED. THIS IS A POTENTIALLY FATAL DESIGN ERROR. THE CRUISE CONTROL SERVO NEEDS TO RELINQUISH CONTROL OF THE VEHICLE THROTTLE ONCE BRAKES OR OFF SWITCH ENGAGED. IT SEEMS TO BE A RE-OCCURENCE OF THE PREVIOUS PROBLEM OR AN EXTENSION OF THE PREVIOUS PROBLEM. VEHICLE BUILD DATE WAS 12/06/00, PER DEALER.*AK
Vehicle speed control, Apr 10, 2002
WHILE DRIVING WITH CRUISE CONTROL ON AT 55MPH, AND AFTER TRYING TO APPLY BRAKES TO REMOVE CRUISE CONTROL, VEHICLE ACCELERATED TO 70MPH ON TWO OCCASIONS. DEALER NOTIFIED AND IS WAITING FOR PART WHICH IS NOT IN STOCK.*AK *TT
Vehicle speed control, Feb 8, 2002
CONSUMER WAS DRIVING WITH CRUISE CONTROL ON AT 60 MPH AND VEHICLE STARTED TO ACCELERATE WITHOUT COMMAND FROM 60 TO 85 MPH. CONSUMER APPLIED BRAKES,AND VEHICLE WOULD NOT SLOW DOWN. APPLIED ON OFF BUTTON, BUT IT WOULD NOT WORK, HIT EMERGENCY BRAKE, AND VEHICLE SLOWED DOWN. *AK
Vehicle speed control, Dec 21, 2001
WHILE TRAVELING RPMS WENT WAY UP TO NUMBER SIX. APPLIED BRAKES AND VEHICLE WAS STILL GOING. SHE COULD STOP ITBY TURNING VEHICLE OFF. DEALERSHIP WAS AWARE OF PROBLEM.*AK
Vehicle speed control, Oct 26, 2001
THE VEHICLE WOULD CRANK AND THEN IMMEDIATELY DIE. IN ORDER TO KEEP IT RUNNING YOU WOULD HAVE TO INCREASE THE RPMS TO ABOVE 1500. YOU WOULD HAVE TO HOLD DOWN THE BRAKE AND ACCELERATE AT THE SAME TIME TO BE ABLE TO DRIVE. THIS HAPPENED TWICE. I TOOK THE VEHICLE TO A LOCAL SHOP SINCE FORD CLAIMED THEY DID NOT KNOW WHAT THE PROBLEM COULD BE. AFTER EXPLAINING THE SITUATION THE MECHANIC INFORMED ME THAT HE WAS 99% SURE IT WAS THE ELECTRONIC IDLE CONTROLLER BECAUSE HE HAD REPLACED SEVERAL OF THEM ON EXPLORERS WHICH CORRECTED THE PROBLEM. THIS IS A POTENTIAL DANGEROUS SITUATION IF YOU ARE NOT AWARE OF HOW TO OVER COME THE SITUATION IN A TIME OF CRISIS. I BELIEVE THAT FORD HAS A MAJOR PROBLEM HERE THAT NEEDS TO BE INVESTGATED BEFORE SOMEONE IS SERIOUSLY INJUED OR POSSIBLE KILLED. THE COST TO REPAIR WAS APPROXIMATELY $175.00, HOWEVER I SPENT ANOTHER $100.00 CHANGING FILTERS AND CLEANING INJECTORS THINKING IT WAS A FUEL PROBLEM.*AK
Suspension, Vehicle speed control, Oct 25, 2001
VEHICLE ACCELERATES ON ITS OWN, THIS HAS HAPPENED 3 TIMES, TWICE WITH CRUISE CONTROL ACTIVATED. CONSUMER THINKS IT MAY HAVE TO DO WITH THE RECALL ON POWERTRAIN CALIBRATION THAT WAS DONE IN APRIL. PRIOR TO RECALL REPAIRS VEHICLE DID NOT HAVE THIS PROBLEM. VEHICLE TAKEN TO DEALER 3 TIMES, COULD NOT FIND A PROBLEM.*AK CUSTOMER STATES THAT THERE WAS A SQUEAKING NOISE IN THE RIGHT FRONT WHEEL INTERMITTENTLY AT LOW SPEEDS. THE VEHICLE HAD AN ACCIDENT DUE TO THE SURGING, THERE WERE NO INJURIES. *TT
Vehicle speed control, Sep 5, 2001
I NOTICED ON THE NHTSA WEBSITE THAT THERE ARE 7 COMPLAINTS ABOUT STALLING. THE DEALER TOLD ME IT WAS THE I.A.C. VALVE. I KNOW OF 3 OTHER INSTANCES OF THIS PROBLEM. THE LAST TIME IT HAPPENED ON ME WAS AT 70MPH ON THE INTERSTATE. THE DEALER STATED THERE IS NO RECALL ON THIS PROBLEM. BUT, THIS COULD BECOME A VERY SERIOUS SAFETY ISSUE. *AK
Vehicle speed control, Jul 18, 2001
IDLE SPEED CONTROL VALVE FAILURES ON FORD EXPLORERS CAUSE THE VEHICLE TO CRANK, START, THEN IMMEDIATELY SHUT OFF. THE VEHICLE WILL NOT MAINTAIN IDLE. THE ONLY WAY TO KEEP THE ENGINE RUNNING IS TO CONTINUE TO APPLY THROTTLE. THIS IS POTENTIALLY HAZARDOUS IF PERFORMED WHILE IN DRIVE OR REVERSE, AS UNINTENDED ACCELERATION (I.E. AUDI 5000) CAN RESULT. MANY EXPLORER OWNERS HAVE EXPERIENCED THIS PROBLEM. LOCAL FORD DEALER CHARGES $200 TO REPLACE THE VALVE.*AK
Service brakes, Hydraulic, Electrical system, Vehicle speed control, Mar 20, 2001
CRUISE CONTROL AND HORN HAS FAILED POSSIBLY DUE TO ELECTRICAL PROBLEMS . ALSO BRAKES TAKE LONGER TIME FOR VEHICLE TO STOP.*AK
Vehicle speed control, Feb 13, 2001
VEHICLE IDLES ROUGHLY. MANUFACTURE WARRANTY RECALLS HAVE NOT IMPROVED. DIFFERENT TYPES/GRADES OF GASOLINE HAVE NOT IMPROVED. VARIOUS DEALER SERVICE DEPARTMENTS UNABLE TO LOCATE/FIX PROBLEM.*AK
Vehicle speed control, Nov 27, 2000
VEHICLE HAS ROUGH IDLE ALMOST TO THE POINT OF STALLING. DEALER SAYS THEY CANNOT REPAIR. FORD CUSTOMER ASSISTANCE SAYS THEY CAN DO NOTHING. *AK
Vehicle speed control, Nov 13, 2000
THE IDLE AIR CONTROL VALVE STUCK AND REQUIRED REPLACEMENT. *MJS
Vehicle speed control, Sep 27, 2000, crash
CONSUMER WAS TRAVELING ABOUT 65MPH ON HIGHWAYAND WITHOUT PRIOR NOTICE VEHICLE STARTED TO SPEED UP AND DANCED ACROSS THE HIGHWAY. SHE TOOK FEET OFF THE GAS PEDAL AND THE BRAKE PEDAL, AND LET IT SLOW DOWN ON IT'S OWN. THERE WERE NO INJURIES.*AK
Vehicle speed control, Jul 26, 2000, crash
WHILE DRIVING ON A DRY STRAIGHT ROAD, ACCELERATOR LEFT OFF AND SWERVED TERRIBLY AND UNABLE TO CONTROL. HAS HAPPENED REPEATEDLY !!!