2000 Ford Explorer
Problems, recalls and owner-reported issues
Tires is the leading concern among 1,078 owner complaints filed for this model year. This is the 11th highest complaint count among 26 Explorer model years with reports.
Of the 2000 reports, 112 involved a crash and 83 involved a fire. 118 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Seats, front assembly, reclinerAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.
THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V281000 on NHTSA.gov
Vehicle speed control, cablesAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.
THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V280000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, tread/beltMay 22, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
Campaign 01X001000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH THE 3.27 OR 3.55 AXLE RATION. THE SUBJECT VEHICLES HAVE A POWERTRAIN CONTROL MODULE THAT COULD ALLOW THE VEHICLE TO EXCEED THE DESIGN INTENT TOP SPEED. AT THESE EXTREME SPEEDS, THE VEHICLE COULD BE CAPABLE OF EXCEEDING THE SPEED RATING OF THE TIRE.
OPERATING THE VEHICLE ABOVE THE MAXIMUM SPEED RATING COULD LEAD TO A TIRE FAILURE WHICH AT THESE SPEEDS COULD RESULT IN A CRASH.
DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE.
Campaign 00V395000 on NHTSA.gov
Tires, tread/beltAug 21, 2000
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.
Campaign 00T005000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Air bags, side/windowJul 5, 2000
VEHICLE DESCRIPTION: 4-DOOR SPORT UTILITY VEHICLES EQUIPPED WITH SIDE AIR BAGS. THE SUBJECT VEHICLES HAVE A REVISED LEVEL SIDE CRASH SENSOR THAT COULD DEPLOY THE SIDE AIR BAG IF THE IGNITION KEY IS IN THE "RUN" POSITION AND THE SEATBELT WEBBING IS FORCIBLY EXTRACTED FROM A LOCKED RETRACTOR WITH A JERKING MOTION.
INADVERTENT SIDE AIR BAG DEPLOYMENT COULD CAUSE PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL REPLACE THE SIDE CRASH SENSORS WITH A REVISED DESIGN THAT WILL REDUCE THE LIKELIHOOD OF AN UNEXPECTED SIDE AIR BAG DEPLOYMENT.
Campaign 00V179000 on NHTSA.gov
Electrical system, wiring, fuses and circuit breakersMar 7, 2000
VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES EQUIPPED WITH 4.0L ENGINES AND ALL-TIME 4-WHEEL DRIVE (A4WD) POWERTRAINS. THE GENERIC ELECTRONIC MODULE (GEM) COULD EXPERIENCE A CONDITION REFERRED TO AS "LOCK-UP" IN WHICH THE GEM CONTROLLED ELECTRONIC FUNCTIONS (E.G., FRONT WINDSHIELD WIPERS, INTERIOR LIGHTS, 4X4 SYSTEM, ETC.) COULD NOT BE TURNED ON OR, IN SOME CASES IF THE FUNCTION IS ON, COULD NOT BE TURNED OFF.
AN INOPERATIVE WINDSHIELD WIPER SYSTEM COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSTALL A RESISTOR IN THE GEM CIRCUIT.
Campaign 00V072000 on NHTSA.gov
Representative owner complaints
1,078 reports, newest first.
Air bags, Jan 15, 2004
AIR BAGS INOPERABLE DUE TO HIGH RESISTANCE OR POOR CONNECTIONS IN THE SIDE AIR BAG (SAB) WIRING HARNESS CIRCUITS OR RESTRAINTS CONTROL MODULE. (FORD ARTICLE #03-24-1) MANUFACTURER MAKES A SERVICE KIT FOR REPAIR AT CUSTOMERS EXPENSE OF $800 INSTALLED. I GUESS AIR BAGS AREN'T THAT IMPORTANT. *CB
Suspension, Equipment, Jan 14, 2004
WE PURCHASED THIS VEHICLE 1/03 WITH 39,000 MILES ON IT. 3/03 THE IDLE AIR CONTROL VALVE WENT BAD AND HAD TO BE REPLACED. THEN 7/03 THE ENTIRE TRANSMISSION HAD TO BE REPLACED BECAUSE SLIPPING FROM 2ND TO 3RD GEAR. THIS COST $1,800 TO FIX. THE VEHICLE ONLY HAD 43,000 MILES ON AT THAT TIME. NOW IT IS 1/04 AND THE TRUCK IS BACK IN THE SHOP FOR AN IDLE PROBLEM ONCE AGAIN AND THE VEHICLE JERKS AND BUCKS WHEN GOING DOWN THE ROAD AT 35-40 MPH. THIS IS A VERY UNSAFE SITUATION AND FORD SHOULD BE REPLACING ALL THE IAC VALVES UNDER A RECALL BECAUSE THERE ARE AN ABUNDANCE OF EXPLORER OWNERS WHO THIS HAS HAPPENED TO AROUND THE 39,000 -43,000 MILES MARK! *AK
Air bags, Jan 13, 2004, crash
WHILE DRIVING AT 40MPH WAS INVOLVED A FRONT COLLISION AND NEITHER OF THE AIR BAGS DEPLOYED. CONSUMER STATED THAT MANUFACTURER AND DEALER WERE NOT HELPING AT ALL. *AK *PH
Engine and engine cooling, Jan 12, 2004
THE STEERING WHEEL WILL NOT ADJUST CORRECTLY WHEN DRIVING. THE CONSUMER TOOK THE VEHICLE TO THE DEALER FOR ANALYSIS. THE PROBLEM COULD NOT BE SOLVED. *AK IT WAS DETERMINED THAT THE CONTROL SENSORS NEEDED TO BE REPLACED AND AFTER BEING REPLACED IT STILL FAILED. AS OF YET THE CONSUMER HAS NOT HAD AN ACCIDENT OR BEEN INJURED BUT IS CONCERNED THAT THE VEHICLE NEEDS TO BE INVESTIGATED BEFORE IT DOES HAPPEN. *CB THE CONSUMER STATED THE VEHICLE LOST POWER AND DIED, THE COMPUTER STATED THE PROBLEM WAS WITH THE IDLE CONTROL SPEED SENOR AND A VALVE, HOWEVER THE PROBLEM CONTINUED *JB
Air bags, Jan 12, 2004
THE AIR BAG WARNING LIGHT STARTED TO FLICKERED OR STAYED ON WHILE DRIVING. THIS COULD RESULT IN PREMATURE OR NON DEPLOYMENT OF THE AIR BAG IN AN ACCIDENT. DEALERSHIP HAS ONLY PERFORMED A TEMPORARY FIX TO CORRECT THE PROBLEM. THEY SERVICED THE TRUCK TWICE, BUT THE FAILURE STILL EXISTS. *AK *CB *JB
Electrical system, Jan 8, 2004
AFTER STARTING THE VEHICLE SMOKE CAME FROM BEHIND THE TURN SIGNAL SWITCH. CONSUMER SHUT THE VEHICLE OFF, AND TOOK THE KEY OUT OF THE IGNITION SWITCH TO STOP THE SMOKING. *AK NEITHER FORD NOR THE DEALERSHIP ACKNOWLEDGED THIS WAS A DEFECT AND NEITHER HAVE OFFERED TO REPAIR THE VEHICLE. *PH *NM
Power train, Jan 3, 2004
2000 FORD EXPLORER TRANSMISSION SLIPPING 2ND AND 3RD TO OVERDRIVE. OD KICKS OFF & WILL NOT RESET. DEALER CHARGED US FOR REPLACEMENT OF "SEPARATOR PLATE" AND "VALVE BODY". GASKET MATERIAL FOUND LODGED IN VALVE BODY BY DEALER. THIS IS A FORD DESIGN FLAW, BUT WE HAD TO PAY OVER $900 TO GET IT FIXED! VEHICLE HAS ONLY 66,000 MILES ON IT.*AK
Engine and engine cooling, Electrical system, Visibility, Jan 2, 2004
VEHICLE OVERHEATED/ THERMOSTAT, REAR WIPER MOTOR STOPPED WORKING, CHECK ENGINE LIGHT STAYS ON CONTINUALLY, BELT SQUEALS ON RAINY DAYS, RADIO COMES ON BY ITSELF, TIRES TO BE REPLACED, LIVED AT SAME ADDRESS SINCE VEHICLE PURCHASE AND NOT EVEN A NOTICE FOR RECALL ON TIRES.*AK
Power train, Dec 30, 2003
THE TRUCK'S VALVE BODY MALFUNCTIONED . WHEN THIS OCCURRED THE AUTOMATIC TRANSMISSION FAILED TO SHIFT CORRECTLY. ALTHOUGH THIS IS A COMMON PROBLEM AND THE DEALERSHIP IS AWARE OF IT THE CAUSE IS STILL UNKNOWN AND THERE'S ISN'T A REMEDY. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
Power train, Dec 22, 2003
INDEPENDENT SHOP REPLACED TWICE THE AUTOMATIC TRANSMISSION. DEALER NOTIFIED. *AK
Visibility, Dec 12, 2003
CONSUMER STATED THAT WINDSHIELD WIPERS WOULD NOT STOP AT THE RESTING PLACE. CONSUMER TOOK VEHICLE VEHICLE TO AN INDEPENDENT MECHANIC, AND WAS TOLD THAT HE NEEDED A GM MOTOR. CONSUMER CALLED THE MANUFACTURER, AND WAS TOLD THAT HIS VEHICLE WAS NOT ON RECALL.*AK
Suspension, Dec 2, 2003
WHILE DRIVING AT ANY SPEED CONSUMER HEARD A LOUD NOISE COMING FROM UNDER THE FRONT END. DEALER INSPECTED VEHICLE SEVERAL TIMES, BUT COULD NO DUPLICATE OR CORRECT THE PROBLEM. *AK
Service brakes, Hydraulic, Dec 1, 2003
WHILE DRIVING ABS WARNING LIGHT APPEARED ON THE DASHBOARD INTERMITTENTLY. *AK
Equipment, Nov 26, 2003
THE DISPLAY ON MY FORD EXPLORER RADIO QUIT WORKING, THE RADIO/CD/TAPE ALL IS WORKING PROPERLY, BUT THE DISPLAY LIGHT IS GONE. AFTER INFORMING MY MECHANIC, I WAS DIRECTED TO A SPECIALTY SHOP, THAT WORKS ON RADIOS FOR VEHICLES. THREE SECONDS INTO MY PHONE CALL WITH THEM, THEY LET ME KNOW THEY WORK ON UP TO FIVE FORD EXPLORERS A DAY, FOR THIS SAME PROBLEM. THEY SAID IT WOULD COST $125.00 TO FIX THIS, THEY ALSO SAID FORD WAS AWARE OF THIS PROBLEM AND HAS ISSUED A KIT TO "FIX" THESE RADIOS. THIS TO ME SHOULD BE A RECALL. BUT, AS I WAS INFORMED THIS "PROBLEM" IS NOT A DANGER TO THE CONSUMER, SO WE SHOULD PAY OUT OF OUR POCKETS. I'VE NEVER EXPERIENCED ANY PROBLEMS LIKE THIS BEFORE, AND MAYBE I'M INFORMING THE WRONG PEOPLE. IF SO, PLEASE DIRECT ME IN THE RIGHT DIRECTION WITH THIS COMPLAINT. THANK YOU FOR YOUR TIME. *LA
Tires, Nov 25, 2003
1993 FORD EXPLORER--SPARE TIRE CABLE RUSTED OUT ABOUT 2 YEARS AGO AND WE HAVE NO IDEA IF THIS TIRE FELL OUT ON AN INTERSTATE OR LOCAL TRAFFIC, WE NOW ALSO HAVE A 2000 FORD EXPLORER. WILL THE SAME THING HAPPEN AGAIN? MY SON-IN-LAW WAS TRANSPORTING PRISONERS WITH A 1998 EXPLORER AND THE SAME THING HAPPENED TO HIM IN TRAFFIC. *LA
Service brakes, Hydraulic, Vehicle speed control, Nov 24, 2003
THE TACHOMETER CABLE FAILED AT 40,378 MILES. *AK CONSUMER STATED THAT THE VEHICLE CRUISE CONTROL FAILED AT 40,578 MILES AND THE ABS FAILED AT 47,900 MILES. IN ADDITION, THE COMPANY WHERE THE VEHICLE WAS BOUGHT IS ALREADY OUT OF BUSINESS. *LA *JB
Visibility, Nov 17, 2003
MY 2000 FORD EXPLORER'S PASSENGER-SIDE REAR POWER WINDOW SHUDDERS WHEN IT IS ROLLED DOWN. YET FORD HAS INSTRUCTED ME THROUGH OUR LOCAL DEALER THAT IT IS A COMMON PROBLEM IN EXPLORERS, HENCE IT IS DEEMED "NORMAL." I HAD FOLLOWED THE PROPER CHANNEL TO COMPLAIN TO FORD'S VP OF CUSTOMER RELATIONS BUT THEY JUST NOTIFIED ME BY MAIL THE MATTERS CONSIDERED CLOSED. FOLLOWING ARE MORE DETAILS. 1. FIRST VISIT ON MAY 7, 2003. DEALER CLAIMED WEATHER STRIP WAS TOO BRITTLE. PART ORDERED. 2. SECOND VISIT ON JUNE 4, 2003. WEATHER STRIP REPLACED. PROBLEM PERSISTED. 3. THIRD VISIT ON SEPTEMBER 12, 2003. LUBED REGULATOR. PROBLEM PERSISTED. 4. LAST VISIT ON OCTOBER 22, 2003. DEALER CONTACTED FORD TECHNICAL ASSISTANCE AND WAS TOLD TO CHECK FOR LOOSE BOLT, WHICH WAS REPLACED. PROBLEM WAS STILL THERE WHEN I PICKED UP THE CAR. 5. SERVICE REPRESENTATIVE WAS INSTRUCTED BY FORD TO INFORM ME THAT THE SHUDDERING IS COMMON TO ALL EXPLORERS AND IS CONSIDERED "NORMAL." HENCE, THOUGH PROBLEM IS NOT FIXED, FORD WILL NOT AUTHORIZE ANY MORE REPAIRS. INDEED, AN EXAMINATION OF OTHER EXPLORERS IN DEALER'S LOT PROVE THAT MANY HAVE THE SAME SHUDDERING PROBLEM, WHILE SOME SHAKE EVEN MORE VIOLENTLY THAN MINE DOES. IN ALL CASES, THE PROBLEM SEEMED TO BE CONFINED TO THE REAR WINDOWS. EVEN THE DEALER REPRESENTATIVE ADMITS THE OPERATION OF THOSE SHUDDERING WINDOWS IS NOT NORMAL. I SUBMIT TO YOU THAT AN ILL-FITTED WINDOW THAT BINDS CAN SHATTER AND SERIOUSLY INJURE ANY PASSENGER SITTING NEXT TO IT. IF ALL EXPLORERS HAVE A LOOSE BOLT IN THE SEAT-BELT ASSEMBLY, THEY WOULDN'T CONSIDER THAT NORMAL JUST BECAUSE IT HAPPENS WITH HIGH FREQUENCY. BE IT A QUALITY OR DESIGN OVERSIGHT, FORD CANNOT BE ALLOWED TO USE A LOW STANDARD AS EXCUSE TO RENEGE ON A WARRANTY REPAIR. *LA
Steering, Suspension, Nov 11, 2003
DEALER SERVICE STATES LOWER BALL JOINT NEEDS REPLACEMENT. EXPERIENCE CLUNKING OVER BUMPS. DEALER SERVICE ALREADY REPLACED STEERING RACK DUE TO EXCESSIVE PLAY, SOMEHOW ARE PROBABLY RELATED TO LOWER BALL JOINT PLAY.*AK
Air bags, Equipment, Nov 5, 2003
WHILE DRIVING THE AIRBAG LIGHT APPEARED ON THE DASH AND WOULD NOT GO OFF UNTIL THE VEHICLE WAS SHUT OFF. *NLM *AK *PH *NLM
Engine and engine cooling, Nov 1, 2003
WHILE DRIVING AT ANY SPEED THE VEHICLE STALLED IN TRAFFIC. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM. *AK
Engine and engine cooling, Oct 30, 2003
WHEN STOPPING AT A STOP SIGN OR A TRAFFIC LIGHT VEHICLE STALLED. CONSUMER TOOK VEHICLE TO DEALER ON TWO SEPARATE OCCASIONS, BUT THE PROBLEM STILL OCCURS. *AK
Air bags, Oct 27, 2003
AIR BAG LIGHT REMAINS ILLUMINATED ON DASHBOARD. *MR THE AIR BAG LIGHT REMAINED ON LONG AFTER THE VEHICLE WAS RUNNING. THE PROBLEM WAS INTERMITTENT. THE DEALER SAID THAT THE CAUSE OF THE PROBLEM WAS TRACED TO THE WIRING HARNESS. THE CONSUMER REQUESTED REIMBURSEMENT. *SCC *JB
Fuel system, Other, Oct 23, 2003, crash, fire
WHILE DRIVING 30 MPH VEHICLE WAS INVOLVED IN A HEAD ON COLLISION. THE FUEL PUMP SHUTOFF SWITCH MALFUNCTIONED, CAUSING VEHICLE TO BURN TO THE GROUND. *AK
Tires, Oct 23, 2003, crash
WHILE DRIVING AT 65 MPH PASSENGER'S FRONT TIRE BLEW OUT. THIS CAUSED THE DRIVER TO LOSE CONTROL OF VEHICLE AND HIT A GUARD RAIL. DRIVER SUSTAINED MINOR INJURIES AND WAS TAKEN TO THE HOSPITAL. *AK
Service brakes, Hydraulic, Oct 22, 2003
WHILE DRIVING, THE CONSUMER HEARD A NOISE AND LATER DISCOVERED, THE CALIPER WAS IMPROPERLY ADJUSTED. DEALER HAD BEEN NOTIFIED. MR THE CONSUMER HEARD A NOISE WHILE DRIVING . WHEN HE HAD COME TO A COMPLETE STOP, THE VEHICLE WAS PLACED INTO REVERSE AND THE LEFT FRONT WHEEL IMMEDIATELY LOCKED UP AND THE TIRE RAPIDLY DEFLATED. WHEN THE WHEEL WAS REMOVED, TWO BOLTS IN THE BRAKE CALIPER WAS GONE. THE CALIPER ASSEMBLY WAS WEDGED INTO THE RIM AND TORE A HOLE 1-2 INCHES IN THE RIM OF THE WHEEL. *SCC *JB