2000 Ford Explorer
Problems, recalls and owner-reported issues
Tires is the leading concern among 1,078 owner complaints filed for this model year. This is the 11th highest complaint count among 26 Explorer model years with reports.
Of the 2000 reports, 112 involved a crash and 83 involved a fire. 118 people were injured and 4 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Seats, front assembly, reclinerAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.
THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V281000 on NHTSA.gov
Vehicle speed control, cablesAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.
THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V280000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, tread/beltMay 22, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
Campaign 01X001000 on NHTSA.gov
Power train, automatic transmission, control module (tcm/pcm/tecm)Nov 28, 2000
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH THE 3.27 OR 3.55 AXLE RATION. THE SUBJECT VEHICLES HAVE A POWERTRAIN CONTROL MODULE THAT COULD ALLOW THE VEHICLE TO EXCEED THE DESIGN INTENT TOP SPEED. AT THESE EXTREME SPEEDS, THE VEHICLE COULD BE CAPABLE OF EXCEEDING THE SPEED RATING OF THE TIRE.
OPERATING THE VEHICLE ABOVE THE MAXIMUM SPEED RATING COULD LEAD TO A TIRE FAILURE WHICH AT THESE SPEEDS COULD RESULT IN A CRASH.
DEALERS WILL REPROGRAM THE POWERTRAIN CONTROL MODULE.
Campaign 00V395000 on NHTSA.gov
Tires, tread/beltAug 21, 2000
TIRE DESCRIPTION: FIRESTONE WILDERNESS AT, SIZE P235/75R15, PRODUCED AT THE DECATUR, ILLINOIS TIRE PLANT AND ALL FIRESTONE RADIAL ATX AND RADIAL ATX II TIRES, SIZE P235/75R15. OPERATION OF THESE TIRES AT LOW INFLATION PRESSURES, HIGH SPEED, AND IN HOT WEATHER, CAN CONTRIBUTE TO SEPARATION OF THE TIRE TREAD.
IF THE TREAD SEPARATES FROM THE TIRE, THE DRIVER CAN LOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH CAUSING INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON AUGUST 29, 2001. HOWEVER, CUSTOMERS SHOULD CONTACT FIRESTONE CUSTOMER SERVICE AT 1-800-465-1904 FOR POSSIBLE ASSISTANCE.
Campaign 00T005000 on NHTSA.gov
Seat beltsAug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 00V228001 on NHTSA.gov
Air bags, side/windowJul 5, 2000
VEHICLE DESCRIPTION: 4-DOOR SPORT UTILITY VEHICLES EQUIPPED WITH SIDE AIR BAGS. THE SUBJECT VEHICLES HAVE A REVISED LEVEL SIDE CRASH SENSOR THAT COULD DEPLOY THE SIDE AIR BAG IF THE IGNITION KEY IS IN THE "RUN" POSITION AND THE SEATBELT WEBBING IS FORCIBLY EXTRACTED FROM A LOCKED RETRACTOR WITH A JERKING MOTION.
INADVERTENT SIDE AIR BAG DEPLOYMENT COULD CAUSE PERSONAL INJURY TO THE SEAT OCCUPANT.
DEALERS WILL REPLACE THE SIDE CRASH SENSORS WITH A REVISED DESIGN THAT WILL REDUCE THE LIKELIHOOD OF AN UNEXPECTED SIDE AIR BAG DEPLOYMENT.
Campaign 00V179000 on NHTSA.gov
Electrical system, wiring, fuses and circuit breakersMar 7, 2000
VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES EQUIPPED WITH 4.0L ENGINES AND ALL-TIME 4-WHEEL DRIVE (A4WD) POWERTRAINS. THE GENERIC ELECTRONIC MODULE (GEM) COULD EXPERIENCE A CONDITION REFERRED TO AS "LOCK-UP" IN WHICH THE GEM CONTROLLED ELECTRONIC FUNCTIONS (E.G., FRONT WINDSHIELD WIPERS, INTERIOR LIGHTS, 4X4 SYSTEM, ETC.) COULD NOT BE TURNED ON OR, IN SOME CASES IF THE FUNCTION IS ON, COULD NOT BE TURNED OFF.
AN INOPERATIVE WINDSHIELD WIPER SYSTEM COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSTALL A RESISTOR IN THE GEM CIRCUIT.
Campaign 00V072000 on NHTSA.gov
Representative owner complaints
1,078 reports, newest first.
Seats, Aug 18, 2008
TL*THE CONTACT OWNS A 2000 FORD EXPLORER. WHILE DRIVING LESS THAN 20 MPH, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT (THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME) FRACTURED. THE CONTACT LOST CONTROL OF THE STEERING WHEEL AND FOOT PEDALS. SHE RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 03V281000 (SEATS:FRONT ASSEMBLY:RECLINER) OR RECALL NUMBER PE03020AND. FORD STATED THAT THE RECALL REPAIRS WOULD NOT BE PERFORMED BECAUSE THE SEAT HAD ALREADY FAILED. THE CONTACT WAS UNABLE TO HAVE THE REPAIRS DONE DUE TO MEDICAL CONDITIONS AND, UPON RECOVERY, WAS INFORMED BY FORD THAT THE RECALL REPAIRS WOULD NOT BE PERFORMED BECAUSE THEY WERE NOT COMPLETED IN A TIMELY FASHION. THE FAILURE MILEAGE WAS 50,000 AND CURRENT MILEAGE WAS 80,000.
Structure, Aug 11, 2008
UPON OPENING MY TAILGATE ONE DAY, THE LEFT SIDE LIFTGATE HINGE POPPED OFF. AS A RESULT, THE LEFT SIDE OF THE REAR WINDSHIELD IS OUT OF PLACE, AND IS BARELY HANGING ON. I TOOK MY VEHICLE TO A BODY SHOP, AND WAS TOLD THAT I'D NEED TO GET THE REPLACEMENT PART (LIFTGATE HINGE) FROM FORD. A FORD DEALERSHIP TOLD ME THAT IT WOULD COST APPROXIMATELY $300 TO REPAIR. *TR
Exterior lighting, Aug 9, 2008
MULTISWITCH IN 2000 FORD EXPLORER FAILED AND GAVE OFF SMOKE, AFRAID OF FIRE. *TR
Latches/locks/linkages, Jul 15, 2008
DRIVER'S SIDE DOOR WILL NO LONGER LOCK AUTOMATICALLY. I HAVE TO PHYSICALLY PUSH THE BUTTON DOWN AND SOMETIMES IT WON'T UNLOCK. *TR
Power train, Jul 14, 2008
O/D LIGHT FLASHING. GRIFFEN FORD COULD NOT ID PROBLEM. UNACCUSTOMED TO HOW THIS TRANSMISSION SHOULD HANDLE, I HAD NO IDEA HOW THE LOWEST GEAR RATIO SHOULD FEEL AND ASSUMED WHAT IT DID FEEL LIKE WAS NORMAL. AT 110,000 A/TRAN FAILED AND HAD TO BE REMANUFACTURED. USED PRIVATE SHOP. OUTSTANDING RE-BUILD AND THAT IS WHEN I FOUND OUT THAT I NEVER HAD A LOW(EST) GEAR BUT DID AFTER THE TRANSMISSION WAS REBUILT. FAITHFUL CHANGE AND CLEANING OF TRANS FLUID, NO TOWING EVER, AND EXCELLENT MAINTENANCE RECORD DID NOT PREVENT A TRANSMISSION FAILURE WHICH IS EVIDENCE OF FORD POOR QUALITY CONTROL AT THE MANUFACTURING OR ASSEMBLY LEVEL. OBVIOUSLY NO ONE EVER PICKED UP THE FACT THAT THE LOW GEAR NEVER WORKED, NOT AT THE FORD FACTORY, AT THE DEALERSHIP, BY SALES, OR SERVICE, AND WAS NEVER PROPERLY ROAD TESTED. POOR REFLECTION ON FORD MOTOR CORPORATION. *TR
Air bags, Jul 14, 2008, crash
IN AVOIDANCE OF HITTING A COW, I ROLLED MY FORD EXPLORER AT LEAST 3 TIMES AND NONE OF THE AIRBAGS DEPLOYED, FRONT NOR THE SIDE CURTAIN AIRBAGS. MY HUSBAND AND MYSELF WERE FORTUNATE TO COME OUT WITH MINOR INJURIES. I HAVE CONTACTED FORD MOTOR COMPANY AND THE HAVE NOT YET OFFERED TO SETTLE. *TR
Power train, Jul 11, 2008
O/D LIGHT STARTED FLASHING AND WOULDN'T CORRECT WITH THE BUTTON ON THE GEAR SHIFT. EXPLORER WOULD REV AT INAPPROPRIATE TIMES. MILEAGE HAS DROPPED FROM 21 TO 16 MPG WHICH OUTRAGEOUS. TOOK IT IN TO BE CHECKED EXPECTING THE SENSORS TO BE OFF BUT WAS TOLD THE TRANSMISSION WAS SHOT, THE CONVERTER WAS BUSTED, METAL IN THE TRANSMISSION, WOULD NEED TO COMPLETELY REPLACE THE TRANSMISSION. *TR
Steering, Jun 6, 2008, fire
TL*THE CONTACT OWNS A 2000 FORD EXPLORER SPORT. WHILE STOPPED AT A STOP LIGHT, SMOKE APPEARED FROM THE STEERING COLUMN. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE MULTIFUNCTION SWITCH IN THE STEERING COLUMN FAILED. THEY FURTHER STATED THAT ONCE THE SWITCH FAILS, IT COULD CATCH FIRE. THE VEHICLE CANNOT BE DRIVEN UNTIL THE SWITCH IS REPLACED. THE VEHICLE IS CURRENTLY AT THE DEALER FOR REPAIR. THERE WERE NO WARNING INDICATORS PRIOR TO THE FAILURE. THE FAILURE MILEAGE WAS 79,000.
Latches/locks/linkages, Jun 5, 2008
DRIVER POWER LOCKING DOOR WILL NOT UNLOCK FROM THE OUTSIDE. *TR
Exterior lighting, May 29, 2008, fire
WHEN I TURNED ON MY LEFT TURN SIGNAL, IT DOESN'T BLINK. IT JUST FREEZES AND SMOKE COMES FROM THE STEERING COLUMN. ONCE I TURNED OFF THE TURN SIGNAL IT STOPPED SMOKING. *TR
Engine and engine cooling, May 28, 2008
TL*THE CONTACT OWNS A 2000 FORD EXPLORER. WHEN THE VEHICLE IS STARTED, THE ENGINE MAKES A LOUD RATTLING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY DISCOVERED THAT THE TIMING BELT WAS OFFLINE. THE DEALER INFORMED THE CONTACT THAT THEY WERE CONDUCTING A FREE REPAIR FOR THIS FAILURE; HOWEVER, THE TIME HAD ALREADY EXPIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WERE NO LONGER HONORING THE REPAIR. THE FAILURE MILEAGE WAS 130,000. UPDATED 06/17/08. *LJ UPDATED 06/17/08
Air bags, May 19, 2008
TL*THE CONTACT OWNS A 2000 FORD EXPLORER SPORT. SHE STATED THAT SHE HEARD A CONSTANT BEEPING NOISE. THE DEALER STATED THAT THE CONTROL PANEL CAUSED THE FAILURE AND THIS COULD RESULT IN THE AIRBAGS DEPLOYING WITHOUT WARNING. AS A RESULT, THE DEALER DISCONNECTED THE AIRBAGS. THE BEEPING NOISE CONTINUED TO OCCUR. AS OF MAY 19, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE 100,000.
Vehicle speed control, May 15, 2008
TL*THE CONTACT OWNS A 2000 FORD EXPLORER. THE CONTACT RECEIVED A FORD RECALL NOTICE FOR THE VEHICLE SPEED CONTROL: CRUISE CONTROL IN AUGUST OF 2007. HE IMMEDIATELY CALLED THE DEALER AND WAS INFORMED THAT THE PARTS WOULD BE UNAVAILABLE UNTIL DECEMBER OF 2007. THE DEALER ALSO STATED THAT HE DID NOT HAVE TO HAVE HIS CRUISE CONTROL SWITCH DEACTIVATED. SINCE THAT TIME, THE CONTACT HAS CALLED THE DEALER ON SEVERAL OCCASIONS AND THEY CONTINUE TO STATE THAT THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WOULD NOT PROVIDE ANY INFORMATION REGARDING THE RECALL. THE VEHICLE HAS NOT BEEN REPAIRED. THERE HAD BEEN NO FAILURE TO DATE. THE RECALL NUMBER WAS UNKNOWN.
Vehicle speed control, May 13, 2008, fire
TL*THE CONTACT OWNS A 2000 FORD EXPLORER. WHILE DRIVING AT AN UNKNOWN SPEED, SMOKE APPEARED FROM THE STEERING WHEEL. THE VEHICLE WAS TAKEN TO A DEALER AND THEY DISCONNECTED THE VEHICLE SPEED CONTROL. THE DEALER NEVER MENTIONED IF THE SMOKE WAS DUE TO THE RECALL NOTICE THE CONTACT RECEIVED IN AUGUST OF 2007 FOR THE VEHICLE SPEED CONTROL. HE CALLED SEVERAL DEALERS DURING THAT NINE MONTH PERIOD, BUT THERE ARE STILL NO PARTS AVAILABLE. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT MILEAGE WAS 111,000 AND FAILURE MILEAGE WAS 96,000.
Power train, May 1, 2008
PROBLEM WITH TRANSMISSION. SLIPS BETWEEN 2ND AND 3RD GEAR. OVER DRIVE LIGHT IS FLASHING. TOOK TO REPAIR SHOP AND COST $300, DID NOT FIX PROBLEM. *TR
Steering, Suspension, Apr 22, 2008
DURING AN UP-HILL LEFT HAND TURN AT SPEED LESS THAN 10 MILES PER HOUR THE DRIVER'S SIDE SWAY BAR LINK FAILED AND BROKE WITH A LOUD BANG. A SWAY BAR LINK KIT WAS PURCHASED FROM NAPA AND REPLACED BY THE OWNER. *TR
Vehicle speed control, Apr 18, 2008
2000 FORD EXPLORER WITH A POSSIBILITY OF A FIRE HAZARD. CONSUMER STATED THAT FORD DOES NOT HAVE THE PARTS TO REPAIR THIS PROBLEM. CONSUMER WOULD LIKE THIS PROBLEM SOLVED IN A TIMELY MANNER. *KB
Vehicle speed control, Apr 18, 2008
A RECALL WAS ISSUED IN AUGUST 2007 FOR THE SPEED (CRUISE) CONTROL DEACTIVATION SWITCH (RECALL 05S28). IT IS NOW APRIL 2008 AND I HAVE NOT BEEN CONTACTED FOR THE REPLACEMENT PART. FORD STATED IN THEIR LETTER THAT THEIR "COMMITMENT, TOGETHER WITH FORD AND LINCOLN MERCURY DEALERS, IS TO PROVIDE YOU WITH THE HIGHEST LEVEL OF SERVICE AND SUPPORT." I THINK THAT AFTER 8 MONTHS, A "REASONABLE TIME" HAS BEEN EXCEEDED. IT HAS BECOME FRUSTRATING AND EXPENSIVE HAVING TO WAIT THIS LONG FOR A SIMPLE FIX. FORD MOTOR COMPANY HAS DISPLAYED A FAILURE TO "PROVIDE ME WITH THE HIGHEST LEVEL OF SERVICE AND SUPPORT." WHAT HAS HAPPENED IS, THAT FORD MOTOR CO. HAS FAILED TO PRODUCE ENOUGH PARTS TO SUPPORT THIS RECALL. THEY KNOW HOW MANY VEHICLES WERE POTENTIALLY COVERED WITH THIS RECALL AND SHOULD HAVE PREPARED TO REPLACE/SERVICE THIS PART IN A "REASONABLE AMOUNT OF TIME". MEANWHILE, I HAVE BEEN FORCED TO BE INCONVENIENCED AND ABSORB ADDITIONAL EXPENSE DUE TO FORD MOTOR CO.'S INCOMPETENCE AND SHORT SIGHTED. *TR
Vehicle speed control, Apr 16, 2008
AUGUST 2007 I RECEIVED A LETTER FROM FORD MOTOR CO. NOTIFYING ME OF A DEFECT IN THE SPEED CONTROL DEACTIVATION SWITCH IN MY 2000 FORD EXPLORER. SEPTEMBER 2007 I HAD THE NEARBY DEALER DISCONNECT THE SWITCH PER NOTICE. AS OF TODAY, APRIL 16, 2008, THE SPEED CONTROL HAS NOT BEEN REPAIRED IN A "REASONABLE TIME". EACH TIME WE CALL THE DEALER, WE GET THE SAME ANSWER "THE PART HAS NOT BEEN RECEIVED YET". I'VE DRIVEN 7 MONTHS WITHOUT USE OF THE SPEED CONTROL IN MY VEHICLE. I WOULD REALLY LIKE TO KNOW WHEN FORD INTENDS TO GET THIS PART OUT TO THEIR DEALERS SO THAT THIS PROBLEM CAN BE FIXED PROPERLY. THIS IS RIDICULOUS HAVING TO WAIT THIS LONG FOR A PART THAT FORD HAS KNOWN ABOUT FOR A WHILE. *TR
Electrical system, Exterior lighting, Visibility, Vehicle speed control, Apr 11, 2008
TL*THE CONTACT OWNS A 2000 FORD EXPLORER. FOR THE PAST TWO MONTHS, THE CONTACT HAS EXPERIENCED ELECTRICAL FAILURE WITH HIS VEHICLE. THE INSTRUMENT PANEL AND HEADLIGHTS DO NOT ILLUMINATE, THE WINDSHIELD WIPERS WORK INTERMITTENTLY, AND THE BATTERY IS ALWAYS LOW. THE VEHICLE WAS TAKEN TO THE AUTO GARAGE, BUT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER ON APRIL 8, 2008 AND THEY STATED THAT THE HEADLIGHT AND GLOBE WIRING WERE THE CAUSE OF THE FAILURES. THE COST OF THE REPAIR IS $800. ACCORDING TO THE MANUFACTURER, THE DEALER INFORMED THEM THAT THE FAILURE WAS NOT UNDER THE HOOD; THEREFORE, THEY WERE NOT RESPONSIBLE. THE CONTACT BELIEVES THAT HIS VEHICLE IS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 00V072000 (ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS) AND HE DID NOT RECEIVE A RECALL NOTICE. THE VIN, ENGINE SIZE, AND NUMBER OF CYLINDERS WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 100,000. UPDATED 05/19/08 *BF UPDATED 05/19/08. *JB
Latches/locks/linkages, Apr 9, 2008
TL*THE CONTACT OWNS A 2000 FORD EXPLORER. THE CONTACT STATED THAT THE DOORS ON HER VEHICLE LATCH AND UNLATCH INTERMITTENTLY. THE VEHICLE HAS NOT YET BEEN TAKEN TO THE DEALER. THE FAILURE MILEAGE WAS 105,000 AND CURRENT MILEAGE WAS 106,000.
Vehicle speed control, Mar 31, 2008
RECALL NOTICE FROM FORD ON MY CRUISE CONTROL 8 MONTHS AGO. I GOT A NOTICE IN SEPTEMBER OF 2007 TELLING ME TO GET IT BACK TO THE DEALER FOR A REPAIR. IT IS NOW APRIL OF 2008 AND I JUST GOT OFF THE PHONE WITH BOTH THE LOCAL DEALER HALDERMAN FORD OF ALLENTOWN,PA AND THE TOLL FREE NUMBER OF FORD FOR RECALLS. BOTH LOCATIONS TELL ME THAT THEY HAVE NO IDEA OF THE AVAILABILITY OF REPAIR PARTS. ALMOST 8 MONTHS LATER???? AND STILL NO PARTS TO REPAIR THIS. AND TO THINK THAT I SHOULD NEED ANOTHER VEHICLE, I WILL BE HARD PRESSED TO CONSIDER FORD AFTER BEING TREATED THIS WAY. *TR
Suspension, Wheels, Mar 29, 2008
BEARING BROKE ON FORD EXPLORER. WHEEL WAS ALMOST OFF THE VEHICLE. FORTUNATELY GOING SLOW. *TR
Vehicle speed control, Mar 27, 2008
IN AUGUST 2007 I RECEIVED A SAFETY RECALL NOTICE (05S28) FOR MY 2000 FORD EXPLORER AND HAVE PERIODICALLY BEEN CONTACTING THE LOCAL FORD DEALERSHIP BUT THE NECESSARY REPAIR PARTS ARE STILL NOT AVAILABLE, 8 MONTHS LATER. THE LATEST CALL EARLIER THIS WEEK GENERATED THE USUAL RESPONSE OF "CALL BACK IN 30 DAYS." I'M RELUCTANT TO EXERCISE THE ALTERNATIVE OF DISCONNECTING THE SPEED CONTROL SYSTEM FOR FEAR OF NEVER GETTING THE NECESSARY REPAIRS. THE RISK OF A FIRE IS A SERIOUS CONCERN. *TR
Vehicle speed control, Mar 26, 2008
TL*THE CONTACT OWNS A 2000 FORD EXPLORER. THE CONTACT RECEIVED A SAFETY RECALL NOTICE FOR THE VEHICLE SPEED CONTROL: CRUISE CONTROL IN AUGUST OF 2007 AND THE SPEED CONTROL SWITCH WAS DISCONNECTED AT THAT TIME. SHE HAS CALLED FORD ALMOST EVERY WEEK SINCE AND THEY CONTINUE TO STATE THAT THE PART IS UNAVAILABLE AND THEY DO NOT KNOW WHEN IT WILL ARRIVE. THERE HAD BEEN NO FAILURE TO DATE. THE PURCHASE DATE AND RECALL NUMBER WERE UNKNOWN. THE CURRENT MILEAGE WAS 100,000. UPDATED 4/11/08 *CN UPDATED 04/11/08 *TR