2001 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 730 owner complaints filed for this model year. This is the 14th highest complaint count among 26 Explorer model years with reports.
Of the 2001 reports, 97 involved a crash and 41 involved a fire. 96 people were injured and 10 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Vehicle speed controlAug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
THIS COULD RESULT IN AN UNDERHOOD FIRE.
DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 07V336000 on NHTSA.gov
Fuel system, gasolineJun 13, 2006
CERTAIN AFTERMARKET FUEL FILTERS SOLD UNDER THE PUROLATOR BRAND NAME, P/N F65277, SHIPPED FROM JANUARY 16 THROUGH JUNE 2, 2006, FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. DUE TO INCORRECT DESIGN, THE QUICK CONNECTORS MAY NOT FULLY SEAT WITH THE TUBE INTERFACE, EVEN THOUGH THE PERSON MAKING THE CONNECTION MAY BELIEVE THAT THE QUICK CONNECTOR IS FULLY ATTACHED.
FAILURE OF THIS CONNECTION COULD LEAD TO FUEL SPILLAGE AND, IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
UFI WILL NOTIFY OWNERS AND REPLACE THE FILTERS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2006. OWNERS MAY CONTACT UFI FILTERS USA AT 800-230-5876.
Campaign 06E056000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Seats, front assembly, reclinerAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HIGH BACK SEATS, THE UPPER BOLT ON THE DRIVER'S SIDE HIGH BACK SEAT, THAT ATTACHES THE SEAT RECLINER MECHANISM TO THE SEAT BACK FRAME, COULD FRACTURE. IF THE BOLT FRACTURES AND DOES NOT JAM IN THE SEAT BACK FRAME, THE SEAT BACK MAY RECLINE UNTIL IT MAKES CONTACT WITH AN OBJECT BEHIND THE SEAT, SUCH AS THE SECOND ROW SEAT CUSHION.
THE DRIVER COULD POTENTIALLY LOSE CONTACT WITH THE STEERING WHEEL OR FOOT PEDALS DURING SUCH AN EVENT, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE DRIVER SEAT UPPER BOLT WITH A METAL SPACER AND BOLT. IN ADDITION, SEATS WITH TUBULAR BACK FRAMES WILL HAVE THE FULLY THREADED LOWER RECLINER BOLT REPLACED WITH A PARTIALLY THREADED BOLT. OWNER NOTIFICATION BEGAN ON AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V281000 on NHTSA.gov
Vehicle speed control, cablesAug 5, 2003
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL AND 4.0L SOHC ENGINES, IF THE STRAND COVER ON THE SPEED CONTROL CABLE BECOMES FLARED AT THE END, THE SPEED CONTROL CABLE MAY BIND WHEN THE SPEED CONTROL IS ACTIVATED.
THE THROTTLE RETURN SPRING FORCE MAY NOT BE SUFFICIENT TO OVERCOME THE BINDING CONDITION WHEN THE SPEED CONTROL IS DISENGAGED. BRAKING FUNCTION WOULD BE MAINTAINED THOUGH STOPPING DISTANCES MAY BE INCREASED.
DEALERS WILL INSPECT THE SPEED CONTROL CABLE AND, IF NECESSARY, REPLACE IT. OWNER NOTIFICATION BEGAN AUGUST 29, 2003. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 03V280000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, tread/beltMay 22, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. EQUIPMENT DESCRIPTION: FORD IS REPLACING ALL FIRESTONE WILDERNESS AT 15, 16, AND 17 INCH TIRES MOUNTED ON FORD TRUCKS AND SUVS. FORD REPORTS TREAD SEPARATION CAN OCCUR DUE TO A COMBINATION OF THE SENSITIVITY OF THE TIRE DESIGN TO STRESS, AGING, AND MANUFACTURING DIFFERENCES BETWEEN PLANTS. FORD IS REPLACING THESE TIRES TO PREVENT POSSIBLE PREMATURE TIRE FAILURE. VEHICLE DESCRIPTION: THE VEHICLES LISTED BELOW MAY HAVE BEEN ORIGINALLY EQUIPPED WITH FIRESTONE WILDERNESS AT TIRES OR MAY HAVE HAD WILDERNESS AT TIRES INSTALLED DURING THE FIRESTONE RECALL LAUNCHED IN AUGUST 2000. CERTAIN 1991 THROUGHT 2002 FORD EXPLORER CERTAIN 2001 THROUGHT 2002 EXPLORER SPORT, AND SPORT TRAC CERTAIN 1997 THROUGH 2002 MERCURY MOUNTAINEER CERTAIN 1991 THROUGH 2001 RANGER CERTAIN 1999 THROUGH 2001 EXPEDITION CERTAIN 1991 THROUGH 1994, AND 1997 MODEL YEAR F-SERIES CERTAIN 1991 THROUGH 1994 BRONCO NOTE: BOTH ORIGINAL EQUIPMENT AND REPLACEMENT TIRES ARE AFFECTED.
SHOULD THE TREAD SEPARATE AT HIGHWAY SPEEDS, A VEHICLE CRASH COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
THE REPLACEMENT/REIMBURSEMENT PROGRAM FOR THIS CAMPAIGN EXPIRED ON MARCH 31, 2002. HOWEVER, CUSTOMERS CAN CONTACT FORD AT 1-877-917-3673 OR GO ON-LINE TO WWW.FORD.COM FOR POSSIBLE ASSISTANCE.
Campaign 01X001000 on NHTSA.gov
Equipment, other, labelsOct 17, 2000
VEHICLE DESCRIPTION: CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567.4, "CERTIFICATION." THESE VEHICLES WERE SHIPPED FROM THE ASSEMBLY PLANT WITHOUT SAFETY CERTIFICATION LABELS.
INCORRECT TIRE INFLATION PRESSURE COULD RESULT IN TIRE TREAD SEPARATION, INCREASING THE RISK OF A CRASH.
DEALERS WILL REPLACE THE CERTIFICATION LABELS.
Campaign 00V313000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
73 reports, newest first. Show all
Engine and engine cooling, Vehicle speed control, May 16, 2005, crash, fire
DT: OWNS 2001 FORD EXPLORER, BOTH DRIVER AND PASSENGER ARE PREGNANT. HAD JUST ENTERED INTERSTATE AND WAS DRIVING ABOUT 70 MPH AND TRIED TO SLOW DOWN TO ABOUT 65MPH. TRIED TO TAP BRAKE BUT HEARD ENGINE REV UP AND IT IMMEDIATELY SPED BACK UP. TAPPED BRAKE AGAIN AND KNEW SOMETHING WAS WRONG. ENGAGED HAZARD LIGHTS AND TRIED TO PULL OFF ROAD. DOWN SHIFTED TO 2ND GEAR,THEN TO 1ST, AND SLOWED TO ABOUT 50 MPH. TRIED TO ENGAGE EMERGENCY BRAKE WITH NO LUCK. WAS USING BOTH BRAKES WHILE TRAVELING IN THE GRASS UPHILL. WHEN IT SLOWED TO ABOUT 15-20 MPH PASSENGER JUMPED FROM VEHICLE. VEHICLE CONTINUED TO REV UP, DRIVER LET OFF BRAKE WHILE TRYING TO ESCAPE AND WAS SLUNG FROM VEHICLE. THE EXPLORER WENT BACK AND CROSSED 4 LANES OF TRAFFIC, ENTERED ONTO SERVICE ROAD WHERE IT STRUCK A TREE. FROM THERE THE VEHICLE ACCELERATED UP THE TREE UP-ROOTING IT. THE TIRES CAUGHT FIRE AND BYSTANDER TRIED TO PUT OUT THE FIRE WITH AN ICE CHEST AND AGAIN IT CAUGHT ON FIRE. *TT
Engine and engine cooling, May 5, 2005
VEHICLE BEGAN STALLING WHEN IT WAS AROUND 30 DEGREES OR LOWER IN THE WINTER AND WOULD HAVE TO RESTART THE VEHICLE 3 OR 4 TIMES TO GET IT TO STAY STARTED, NOW VEHICLE DOES THIS EVERY MORNING AND EVEN WHEN ITS WARM OUT. TOOK VEHICLE TO DEALER, DEALER PUT SEAL ON INTAKE PLATTON. VEHICLE DOES IT EVERY TIME YOU START IT NOW.
Engine and engine cooling, Apr 25, 2005
THERE WERE NO PRECEDING EVENTS; UNEXPECTEDLY AND WITHOUT WARNING THE ENGINE DIED. THE ENTIRE ENGINE AND ALL ATTENDANT PARTS HAD TO BE REPLACED. THE FIRST NEW REPLACEMENT ENGINE ALSO FAILED IMMEDIATELY UPON INSTALLATION. THE DEALERSHIP REPLACED WITH YET ANOTHER ENGINE. COST TO CONSUMER: $6348.50. *AK
Service brakes, Hydraulic, Engine and engine cooling, Air bags, Jan 21, 2005
WHILE DRIVING 40 MPH, THE SRS LIGHT, ABS LIGHT AND CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. SUDDENLY, THE FRONT WHEELS LOCKED AND THE VEHICLE FLIPPED OVER. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION. THE CAUSE HAS NOT BEEN DETERMINED AT THIS TIME. PLEASE PROVIDE FURTHER DETAILS. *NM
Engine and engine cooling, Tires, Dec 2, 2004, crash
VEHICLE EXPERIENCED MULTIPLY PROBLEMS. CONSUMER NOTICED THAT WHILE DRIVING VEHICLE VIBRATED UNCONTROLLABLY. ALL TIRES HAD STRESS MARKS LOCATED IN THE INNER SIDE OF THE TIRES. GOODYEAR, WRANGLER RTS P255/70R16. ALSO, COOLANT WAS LEAKING FROM UNDERNEATH THE VEHICLE . CONSUMER DROVE VEHICLE TO THE DEALER, AND MECHANIC COULD NOT DUPLICATE THE LEAK. BUT TIRES WERE REPLACED DUE TO THE STRESS MARKS. *AK
Engine and engine cooling, Tires, Seats, Nov 5, 2004
DRIVER SEAT RECLINER BOLT, THE SEAT BACK/RECLINE/FORWARD BROKE, REPLACED SEVERAL TIMES. *BF THE OIL FILTER HAD COME WITH A HOLE TOO LARGE, THE DRIVER'S SIDE SEAT HANDLE BROKE, THE TIRES BLEWOUT AND CAUSED AN ACCIDENT THAT TOTALED THE VEHICLE. *SC
Engine and engine cooling, Fuel system, Gasoline, Oct 27, 2004
WHEN CHANGING GEARS, THERE WAS HESITATION AS IF THE TRUCK WANTED TO CUT OFF AND SHUDDER IN STEERING. HAD OXYGEN SENSOR AND FUEL INJECTOR CHECKED. *AK *JB
Engine and engine cooling, Fuel system, Gasoline, Fuel system, Other, Visibility, Structure, Latches/locks/linkages, Equipment adaptive/mobility, Sep 9, 2004
DROVE HOME, GARBAGE PICK-UP MISSED OUR HOUSE. GRAB THE CAN ,AND PUT IN BACK OF FORD SPORT TRAC..TRIED TO CATCH THE GARBAGE TRUCK DOWN A DIRT ROAD. WHEN ALL OF A SUDDEN THE FRONT HOOD ON MY SPORT TRAC CAME OPEN.ALSO HAVING PROBLEMS WHEN TURNING ON AIR-CONDITIONER.I BELEIVE SAME TYPE OF PARTS OR COMPONENTS USED IN PREVIOUS YEARS FORD EXPLORER SPORT...RANGING BACK TO 98 OR FURTHER.PROBABLY SAME TYPES RECALLED OR COMPLAINED ABOUT IN THOSE YEARS PROBLEMS WITH DEFECTS..I HAVE FOUND THAT MY 2001 FORD SPORT TRAC WAS ACTUALLY MADE IN LATE YEAR OF 2000.*AK
Engine and engine cooling, Jul 30, 2004
CURRENTLY FORD HAS AN EXTENDED WARRANTY PROGRAM UNDER ONP 00M12 WHICH EXTENDS THE WARRANTY FOR THE TIMING CHAIN TENSIONER ON, BUT NOT LIMITED TO, 2001 EXPLORER SPORT TRACS. ACCORDING TO FORD'S SYSTEM, MY CAR, WHILE A 2001 SPORT TRAC WITH THE SOHC MOTOR, IS NOT COVERED. I AM AT THIS TIME EXPERIENCING THE EXACT PROBLEM THAT THEY ARE COVERING UNDER THIS EXTENSION, BUT FOR SOME REASON MY CAR IS EXCLUDED. I CALLED CUSTOMER SERVICE AND THEY HAD NO INFORMATION WHY MY CAR WAS NOT COVERED, BUT DID ADMIT THAT 2001 SPORT TRACS WERE PART OF THIS EXTENDED COVEREAGE. THEY WOULD NOT PROVIDE ANY DETAILS OR FACTS TO SUPPORT THEIR REASONING. IT IS APPARENT THAT THIS IS A PROBLEM FOR THE SOHC MOTORS, THUS THE REASON FOR THE EXTENDED WARRANTY. HOWEVER, MY CAR SEEMS TO BE NOT PART OF THIS PROGRAM, THUS NOT COVERED BY THIS WARRANTY, YET I AM HAVING THE SAME ISSUE AS WHAT IS COVERED.*AK
Engine and engine cooling, Jul 23, 2004
THERE WERE REPEATED PROBLEMS WITH THE IDLE AIR CONTROL MOTOR ON 2001 FORD EXPLORER. *MR UPON STARTING THE VEHICLE, THE ENGINE IMMEDIATELY STALLED. *SC
Engine and engine cooling, May 11, 2004
PROBLEMS WITH TIRE EQUIPMENT ON 2001 EXPLORER SPORT.*MR WHILE DRIVING THE CHECK ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THAT THE EMISSIONS SENSOR NEEDED TO BE REPLACED. THE TECHNICIAN INDICATED THAT THE COST OF THE REPAIR WOULD BE $240.57 AND THAT THE REPLACEMENT WOULD TAKE ABOUT 45 MINUTES BECAUSE THE SENSOR WAS DIFFICULT TO GET TO. THE CONSUMER REQUESTED THAT THE OLD PART BE RETURNED TO HIM. WHEN THE CONSUME GOT HOME HE OPENED THE HOOD AND SAW THAT THE SENSOR WAS EXTREMELY ACCESSIBLE ON THE TOP RIGHT OF THE ENGINE. THE CONSUMER FELLS THE COST OF THE REPAIR WAS NOT REASONABLE. *NM
Engine and engine cooling, Apr 19, 2004
INTERMITTENTLY WHILE DRIVING AT 55 MPH VEHICLE STALLED AND HESITATED. A MECHANIC DETERMINED THAT THE INTAKE MANIFOLD GASKET NEEDED TO BE REPLACED. *AK
Engine and engine cooling, Apr 15, 2004
EGR VALVE FAILED ON MY VEHICLE 3 TIMES. ACCORDING TO AN ONLINE REPAIR FORUM, THIS COULD LEAD TO STALLING AND HESITATION IN ACCELERATION. MY EGR VALVE HAS FAILED ALL 3 TIMES DURING PERIODS OF ACCELERATION WHILE ON THE FREEWAY. THIS COULD POSE A SAFETY HAZARD SHOULD IT FAIL AND STALL WHILE ACCELERATING TO ENTER THE FREEWAY OR WHILE PASSING ANOTHER VEHICLE ON A 2 LANE ROAD.*AK
Engine and engine cooling, Fuel system, Gasoline, Power train, Jan 15, 2004
I PURCHASED THIS CAR ON OCTOBER 8,2003. THREE DAYS AFTER I BOUGHT IT THE CHECK ENGINE LIGHT CAME ON. I BROUGHT THE CAR BACK FOUR TIMES BACK TO BACK. THE FIRST TIME THEY SAID NOTHING WAS WRONG. THE SECOND AND THIRD TIME THE SAME THING. ON THE FOURTH ATTEMPT, THEY HAD ME TAKE IT TO ONE OF "THEIR" MECHANICS. HE SAID IT WAS A BAD SWITCH IN THE SYSTEM. NOT EVEN A WHOLE WEEK LATER, THE CHECK GUAGE LIGHT CAME ON. THE CAR LOT WHERE I BOUGHT IT FROM SAID THEY WERE NOT GOING TO LOOK AT MY CAR BECAUSE OUT OF THE KINDNESS OF THEIR HEART THEY'VE ALREADY LOOKED AT IT. SO I TOOK IT TO A FORD DEALERSHIP, THEY FIXED IT AND SAID IT WAS A PROBLEM WITH TRANSMISSION, AND THE STEERING WHEEL. THEY CAR LOT SAID IT WAS NOT THEIR PROBLEM. I HAD TO PAY OUT OF MY POCKET FOR SOME PROBLEMS THAT ARE STILL UNDER WARRANTY. THEN THE FIRST TIME THE CHECK ENGINE LIGHT CAME ON I LATER FOUND OUT THAT A SALES PERSON WHO WAS NOT CERTIFIED MECHANIC, TRIED TO FIX THE CAR WHEN THEY SAID THEY WERE SENDING IT TO A MECHANIC. I'M STILL HAVING PROBLEMS AND IT SEEMS LIKE THERE JUST GETTING WORSE!
Steering, Suspension, Service brakes, Hydraulic, Engine and engine cooling, Equipment, Jan 15, 2004
I HAVE SEVERAL MORE INVOICES 7-29-03 REPLACED DUST SEALS AND FORGOT TO PUT BRAKES BACK TOGETHER LOST WHOLE FRONT END AND BRAKING. HAD TRUCK FOR 3-4 DAYS THEY HAVE REPLACED THE WATER PUMP PULLEY AND S BELT 2-3 TIMES. CRUISE CONTROL 10-16, 12/31/02 AGAIN SQUELING NOISE 02/28/03 DEFROST KILLS TRUCK AND CHIRPING STILL. 2/10/03 STEERING WHEEL SNAPED PART FALLS AROUND INSIDE,CRUISE CONTROL WAS FIXED, BEARING FAILURE IN BELT TENSIONER AGAIN. TODAY STILL HAVING THE SAME PROBLEM. COME GET THE PIECE OF !@!@#@#. I AM SICK OF TAKING THIS TRUCK IN EVERY MONTH TO FIX SOMETHING. IT IS A LEMON
Engine and engine cooling, Jan 12, 2004
STARTING PROBLEMS WITH TEMPERATURES BELOW 40 DEGREES FAHRENHEIT ON A COLD START. VEHICLE ATTEMPTS TO START BUT WILL NOT TURN OVER WITHOUT PRESSURE BEING APPLIED TO ACCELERATOR. ONLY DUPLICATES IN COLD WEATHER. VERY WIDESPREAD PROBLEM MANY OTHER OWNERS REPORT SAME ISSUES. *LA
Engine and engine cooling, Dec 10, 2003
WHILE DRIVING AT ANY SPEED, THE VEHICLE LOST TOTAL POWER. *AK WHEN THE NEW MOTOR WAS PLACED IN THE VEHICLE, IT WOULD JUST DIE WHILE IN MOTION AT ANY SPEED. IT HAD TAKEN THE DEALER THREE ATTEMPTS WHEN THEY TOLD THE CONSUMER THAT THERE WASN'T A RUNNING CODE, SO IT COULD NOT BE FIXED. *SCC *JB
Engine and engine cooling, Oct 10, 2003
WHILE TRAVELING FROM WILLIAMSBURG/NEW PORT NEWS, VA MY ENGINE LIGHT CAME ON AND I PULLED OFF THE ROAD TO HAVE THE PROBLEM LOOKED AT. IT IS A POOR FLOW FOR THE EGR VALVE. ACCORDING TO DOCUMENTATION IN VARIOUS ENGINE REFERENCE BOOKS FAILURE OF THE VALVE COULD CAUSE ERRATIC ENGINE SURGES AND POTENTIAL OTHER RELATED PROBLEMS TO INCLUDE FAILURE OF THE POWER PLANT. THERE ARE APPARENTLY NO REPLACEMENT PARTS AVAILABLE FOR THE 4.0L V-6 WHICH IS A COMMON ENGINE IN THE RANGER AND EXPLORER MODELS. THE VEHICLE CURRENTLY HAS 42000 HIGHWAY MILES AND RECEIVES REGULAR MAINTENANCE. I AM CONCERNED ABOUT THE LOW LIFE OF THIS PART UNDER NORMAL WEAR AND TEAR AND CONDITIONS, AS WELL AS THE SAFETY AND ENVIRONMENTAL IMPACT THAT THE PART FAILURE COULD CAUSE. *LA
Engine and engine cooling, Aug 27, 2003
VEHICLE'S MOTOR STALLED OUT WHEN THE ACCELERATOR WAS DEPRESSED.*MR THE CONSUMER WANTS TO PUT FORD MOTOR COMPANY ON NOTICE THAT HIS VEHICLE IS IN FACT DEFECTIVE AND HAS NOT BEEN REPAIRED AND RESPECTFULLY REQUEST THAT FORD MOTOR COMPANY WILL EXTEND THE WARRANTY ON THIS VEHICLE AND REMEDY A FUTURE FAILURE, AT NO COST, SHOULD A SIMILAR PROBLEM RECCUR AFTER THE WARRANTY EXPIRES. *CB *JB
Suspension, Engine and engine cooling, Jun 20, 2003
WHILE DRIVING THE ENGINE LIGHT WAS FLASHING , SUDDENLY THE VEHICLE LOST POWER. DEALER STATED, SPRING BROKE OVER THE THIRD VALVE. CONSUMER INDICATED THAT THE VEHICLE WAS NOT ANY LONGER UNDER WARRANTY SO SHE HAD TO PAY. *AK
Engine and engine cooling, Other or unspecified, Apr 22, 2003
VEHICLE RATTLES OVER 80 MPH. THE WHOLE CAR JUST SHAKES UNNECESSARILY. BAD SMELL EXISTING COMING FROM THE ENGINE. ERP(VACUUM PART $600) IS BAD AT 45000 MILES ONLY ON A 2001 FORD EXPLORER SPORT. WHAT IS THIS. *NLM
Engine and engine cooling, Feb 28, 2003
EXHAUST FUMES SEEPED INTO THE VEHICLE'S INTERIOR CABIN. DEALER WAS UNABLE TO DETERMINE CAUSE OR SOURCE OF LEAK. MANUFACTURER STATED EXHAUST FUME SMELL WAS NORMAL. *JB THE SMELL WOULD WORSEN WHEN GOING UP HILLS AND OR THE MOUNTAINS. SCC
Engine and engine cooling, Jan 27, 2003
WHILE DRIVING AND WITHOUT WARNING TIMING CHAIN WAS MAKING A LOT OF NOISE. DEALER WAS NOTIFIED AND REPAIRED THE PROBLEM. VEHICLE STILL EXPERIENCED PROBLEMS. *AK
Engine and engine cooling, Dec 11, 2002
AFTER REMOVING FOOT FROM GAS PEDAL AT 20 TO 25 MPH, WHEN TOUCHING THE PEDAL TO INCREASE SPEED, TRUCK SPUN AS THOUGH AT FULL THROTTLE. HAPPENED ONCE WHILE TURNING BEND ON A WET SURFACE. THEN HAPPENED AGAIN ON A STRAIGHT SNOW COVERED ROAD. DEALER COULD NOT FIND A PROBLEM, BUT REPLACED THE IDLE AIR CONTROL VALVE SINCE IT'S THE MOST COMMON COMPONENT TO CAUSE THIS PROBLEM. DT
Engine and engine cooling, Dec 9, 2002
WHILE BRAKING THE VEHICLE CONTINUED TO ACCELERATE. THIS CONDITION ALMOST CAUSED THE VEHICLE TO HIT A PARKED CAR AND A PERSON. THE VEHICLE WAS TAKEN TO THE DEALER ON THREE OCCASION BUT THEY WERE UNABLE TO LOCATE THE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION. *PH *NLM