2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints: electrical system
179 reports, newest first. Show all
Engine and engine cooling, Electrical system, Visibility, Feb 11, 2012
I BOUGHT A 2002 FORD EXPLORER SPORT TRAC NEW. SHORTLY AFTER HAVE ELECTRIC WINDOW PROBLEMS DRIVERS DOOR BACK PASSENGER WINDOW AND NOW THE PASSENGER DOOR WINDOW, BAD BODY MOUNTS,AND IDLES BAD WHEN IN PARK OR STOPPED AT A RED LIGHT. RPM'S 500 TO 1000 BACK DOWN TO 500-400. 2002 HAD A BABY GIRL 1 1/2 YEARS AND ANOTHER ON THE WAY NEEDED A 4 DOOR AND ALSO FOR WORK. I KICK MY SELF EVERY DAY THAT I HAVE OWNED IT BUT HAD NO CHOICE MONEY WAS TIGHT AND STILL IS COULD NOT AFFORD EVERY TIME GETTING THINGS FIXED SO I LIVED WITH IT!!!! UNTIL I FOUND THIS WEB PAGE I AM FED UP I HAVE ALWAYS OWNED FORD BUT AFTER THIS IM NOT SO SURE ANYMORE! AND READING OTHER PEOPLES WITH THE SAME PROBLEMS THE SPORT TRAC IS ONE BIG LEMON!!!!!! *TR
Electrical system, Vehicle speed control, Jan 20, 2012
AT A STOP, BEGAN ACCELERATING TO ENTER HIGHWAY, ACCELERATOR PEDAL BECAME STUCK AND CAR CONTINUED TO ACCELERATE UP TO 90 MPH AT FULL THROTTLE BEFORE I SHUT VEHICLE OFF AND PUT IT IN NEUTRAL. HAS HAPPENED ON SEVERAL OCCASIONS, ALL EXACTLY THE SAME. VEHICLE ACCELERATES AT FULL THROTTLE AND HAS TO BE SHUT OFF BEFORE AN ACCIDENT OCCURS. ONLY WAY TO CORRECT PROBLEM IS TO EXIT VEHICLE AND PUSH GAS PEDAL SEVERAL TIMES; START VEHICLE AND SEE IF ENGINE IS STILL AT FULL THROTTLE.
Engine and engine cooling, Electrical system, Jan 9, 2012
I HAVE A 2002 FORD EXPLORER THAT IS IN THE SHOP RIGHT NOW WITH A TORN DOWN ENGINE. I WENT OUT TO START IT ONE MORNING AND IT HAD A HARD START THEN IT STARTED TICKING. COME TO FIND OUT IT THE TIMING CHAIN. FROM WHAT I HAVE READ ONLINE IT IS A VERY COMMON COMPLAINT AND I AM REALLY SURPRISED THAT THIS TRUCK HAS NOT BEEN RECALLED AGAIN FOR THIS PROBLEM. I AM HAVING TO PAY FOR SOMETHING THAT FORD MADE A MISTAKE ON. THE PULLEY ON THE TRUCK IS PLASTIC, AND IT IS FAILING. I ALSO HAVE PROBLEMS WITH MY ELECTRICAL PARTS ON IT. THE LIGHTS INSIDE WILL STAY ON AFTER I TURN IT OFF AND GET OUT AND IF I TURN ON MY REAR DEFROST MY TRUCK DINGS AND SAYS DOOR AJAR..... THIS TRUCK IS AWFUL. *TR
Suspension, Power train, Electrical system, Dec 6, 2011
REAR SPRING CRACKED AT 100,000 MIL TRANSMISSION FAILED AT 120,000 MIL BODY ELECTRICAL NOT SEALED WELL AND KEEPS SHORTING IN DIFFERENT PLACES CRUISE GETS STUBBORN AND SCARED TO USE IT , IM AFRAID OF IT GETTING STUCK IN CRUISE. *TR
Power train, Electrical system, Nov 17, 2011
I COME TO REALIZE IN THE AUTOMOTIVE INDUSTRY VEHICLES DO NOT A TRANSMISSION GAUGE. TRANSMISSION SENSORY LIGHT TO LET YOU KNOW WHEN YOUR TRANSMISSION FLUID IS GETTING LOW. THIS IS A PROBLEM FOR ME AND MANY MORE AMERICANS. MY FORD EXPLORER SPORT TRAC DO NOT HAVE A TRANSMISSION SENSORY LIGHT OR A GAUGE. THE TRANSMISSION IS SLIPPING AND NOT SHIPPING OUT GEARS RIGHT. SOMEONE IS RESPONSIBLE FOR THIS PROBLEM. WE HAVE ALL OTHER FLUID GAUGES EXCEPT A TRANSMISSION GAUGE. *TR
Power train, Electrical system, Oct 27, 2011
THE TRANSMISSION STARTED TO SLIP IN MAY OF 2011. I HAD THE TRANSMISSION SERVICED AND IT DID NOT CORRECT THE PROBLEM. I AM UNABLE TO CHECK THE TRANSMISSION FLUID AS IT IS A SEALED UNIT NO DIP STICK. WE DROVE THE VEHICLE UNTIL IT NO LONGER MOVES. THE COST TO REPLACE THE TRANSMISSION IS 2800.00 PLUS... THERE WAS NO REASON WHY THIS SHOULD HAVE HAPPENED. *TT
Electrical system, Sep 14, 2011, fire
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE PARKED, THE CONTACT NOTICED FLAMES AROUND THE RADIO CONSOLE AND THE DASHBOARD. THE FIRE DEPARTMENT REPORTED TO THE SCENE AND A REPORT WAS FILED. THE CAUSE OF THE FIRE WAS DETERMINED TO BE A FAILURE WITHIN THE RADIO CONSOLE WIRES. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR REPAIRS. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.
Electrical system, Jun 3, 2011
SPARKPLUG WAS EJECTED FROM HEAD WHILE DRIVING. THE PLUG WAS MANUFACTURER SPECIFICATION AND PROPERLY INSTALLED TO THE CORRECT TORQUE. SPARKPLUG HOLE WAS DAMAGED AND NEEDED TO BE MACHINED FOR A NEW PLUG. CREATES A SAFETY HAZARD WHILE DRIVING AS WELL AS A FIRE HAZARD AS THE EMPTY CYLINDER FORCES AIR/FUEL MIXTURE INTO THE ENGINE COMPARTMENT WHERE EJECTED SPARK PLUG COULD IGNITE IT. *TR
Electrical system, Feb 28, 2011
TL*THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 50-60 MPH THE LIGHTS ON THE DASHBOARD FLICKERED ON AND OFF WHICH ALSO INCLUDED A BEEPING NOISE. THE VEHICLE HAD NOT BEEN TAKEN TO THE DEALER FOR THE FAILURE. THE FAILURE WAS INTERMITTENT AND HAD BEEN ON GOING FOR MORE THAN A YEAR. THE CONTACT STATED THAT THE FAILURE HAPPENED MORE FREQUENTLY WHILE DRIVING ON THE HIGHWAY. THE FAILURE MILEAGE WAS 95,000 AND THE CURRENT MILEAGE IS 114,376. UPDATED 03/29/11*LJ UPDATED 09/16/11*JB
Electrical system, Air bags, Latches/locks/linkages, Interior lighting, Jan 19, 2011
THE SIDE CURTAIN AIRBAG SPONTANEOUSLY DEPLOYED UPON SIDE DOOR CLOSURE OF A FORD EXPLORER. THE VEHICLE WAS SITTING AFTER RE-FUELING. CONCURRENT WITH AND IMMEDIATELY PRIOR TO THE DEPLOYMENT OF THE AIRBAG, THE DOOR ALARM SYSTEM WAS CHIMING THAT A DOOR WAS AJAR, AND AFTER INSPECTION BY A MECHANIC IT WAS DETERMINED THAT THE SECURITY/DOOR WARNING SYSTEM MODULE HAS FAILED. FORD WAS SENT THE AIRBAG MODULE FOR INSPECTION, AND HAS YET TO PROVIDE THE RESULTS OF THE MODULE INSPECTION - AFTER A PERIOD OF MORE THAN 5 MONTHS. FURTHER PROBLEMS PERSIST WITH THE ELECTRONIC SYSTEM. THE DOOR AJAR ALARM CONTINUES TO SOUND AT RANDOM INTERVALS, THE INTERIOR LIGHTS FLICKER ON AND OFF AT RANDOM INTERVALS, AND THE DOOR LOCKS REPEATEDLY LOCK AND UNLOCK, ALL OF WHICH CAUSE A DISTRACTING POTENTIAL SAFETY HAZARD WHILE DRIVING. *TR
Electrical system, Exterior lighting, Nov 28, 2010
NO LEFT TURN SINGLE OR BRAKE LIGHTS, WHEN THE STEERING WHEEL IS TILITED DOWN WE FOUND THE TURN SINGLES DO NOT WORK OR BRAKE LIGHTS. *TR
Electrical system, Visibility, Oct 21, 2010
HEATER FAILED CAUSING WINDOWS TO "FOG" OVER AND DECREASED ABILITY TO SEE OUT WINDSHIELD. *TR
Electrical system, Oct 4, 2010, fire
LEADING UP TO THE EVENT OF THE FIRE, OCCASIONALLY THE "DOOR AJAR" BUTTON WOULD FLASH DURING DRIVING, THE ALARM WOULD RANDOMLY GO OFF, AND THE LIGHTS INSIDE THE VEHICLE WOULD FLASH AT RANDOM TIMES. THIS WAS NEVER A PATTERN, AND THE CAR WENT PERIODS OF TIME WITH NOTHING HAPPENING TO IT. ONE MORNING, I OPENED THE CAR DOOR AND FOUND THE ENTIRE INSIDE TO BE BURNED OUT. THE FIRST STARTED IN THE MIDDLE CONSOLE. *TR
Fuel system, Gasoline, Electrical system, Sep 15, 2010
EVEN WITH A FULL TANK OF GAS THE GAS GAUGE WILL GO TO "0" AND THE "CHECK GAUGE" LIGHT COMES ON BECAUSE THE SENDER ASSEMBLY UNIT OF THE GAS GAUGE DOES NOT WORK. THERE HAD BEEN ANOTHER 2002 EXPLORER BROUGHT IN FOR THE SAME PROBLEM THAT MORNING. THE PART IS NOT AVAILABLE AND IS ON BACK ORDER. THE PART COST $76.79 BUT THE LABOR WILL BE $270! THIS IS A LOT OF MONEY FOR US TO PAY DUE TO AN FORDS ENGINEERING PROBLEM. ARE MANY OTHER 2002 EXPLORERS EXPERIENCING THE SAME PROBLEMS? MANY TIMES, BECAUSE THE FUEL SENDING UNIT IS CORRUPTED, IT WILL PUT TOO MUCH FUEL IN INJECTORS, WHICH HAS CAUSED MY CAR TO "BOG DOWN" ESPECIALLY DANGEROUS AT INTERSECTIONS AND AT HWY ENTRANCE RAMPS. *TR
Electrical system, Exterior lighting, Aug 31, 2010
PART # E6DB-14489-DA. THIS IS A WIRING HARNESS CONNECTOR LOCATED IN THE STEERING COLUMN THAT BECOMES UNPLUGGED WHEN YOU TILT STEERING DOWNWARD. RESULT IS BRAKES LIGHTS AND TURN SIGNALS NO LONGER FUNCTION. ** MY SISTER-IN-LAW WAS NEARLY REAR-ENDED WHILE WAITING TO MAKE A TURN. THIS IS A MAJOR SAFETY ISSUE. MANY OTHER PEOPLE WITH SAME ISSUE. ALSO, HAVE SEEN SIMILAR COMPLAINTS FOR OTHER FORD VEHICLES (TAURUS). SERIOUS ACCIDENTS WILL HAPPEN IF PUBLIC IS NOT NOTIFIED. DEALERS CHARGING $200+ TO FIX. *TR
Electrical system, Aug 25, 2010
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE ALARM ON THE VEHICLE WOULD INDEPENDENTLY ENGAGE SPORADICALLY. THE CONTACT WAS ABLE TO RESET THE ALARM YET THE FAILURE WOULD ONLY RECUR. THE DEALER ADVISED THAT THEY COULD REPLACE ALL OF THE SENSORS BUT THEY WERE UNABLE TO GUARANTEE THAT THE REPAIR WOULD RESOLVE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 73,000.UPDATED 11/19/10. *LJ THE CONSUMER STATED HE EXPERIENCED SEVERAL ELECTRICAL PROBLEMS WITH THE VEHICLE SUCH AS THE DOORS, DOME LIGHTS, WINDOWS. RADIO AND POWER SEATS. THE CONSUMER STATED SHE WOULD THE GET PROBLEM FIXED, BUT IT WOULD SOON RETURN. UPDATED 12/01/10
Electrical system, Aug 18, 2010
DOOR AJAR LIGHT REMAINS ON ALTHOUGH ALL DOORS ARE SECURELY CLOSED AND LOCKED. DRIVERS SIDE LOCKS ARE INOPERABLE. *TR
Electrical system, Aug 14, 2010
MY 2002 FORD EXPLORER LXT, THE DOOR AJAR LIGHT STAYS ON AND THE DOME LIGHT WILL STAY ON. EVERY ONCE AND A WHILE THE ALARM WILL SOUND FOR NO REASON. THIS IS A SAFETY CONCERN CAUSE WHILE DRIVING AT NIGHT AND HAVING THE DOME LIGHT TURN ON HINDERS YOUR VISION AND COULD CAUSE A TRAFFIC CRASH. HAVING THE LIGHT STAY ON AFTER YOU GET OUT ALSO DRAINS THE BATTERY AND CAUSES PROBLEMS WHEN YOU GO TO START IT UP. *TR
Power train, Electrical system, Jun 29, 2010
O/D LIGHT BLINKING AND IRREGULAR SHIFTING DURING ACCELERATION. 2002 FORD EXPLORER DOES NOT SHIFT PROPERLY. EVERYTIME I LEAVE A STOP SIGN OR TRAFFIC LIGHT, THE RPM'S BECOME VERY HIGH (OVER 5,000) AND WILL NOT SHIFT. TO KEEP THE ENGINE FROM RACING, I HAVE TO LIFT MY FOOT OFF THE GAS PEDAL TO GET IT TO SHIFT. THIS CAUSES THE CAR TO SLOW DOWN QUICKLY AND WITH A LINE OF CARS BEHIND ME THAT DO NOT ANTICIPATE ME SLOWING DOWN JUST AS I AM ACCELERATING, THIS FORCES THEM TO SLOW DOWN QUICKLY UNEXPECTEDLY SO THEY DO NOT RUN INTO THE BACK OF THE TRUCK. THIS IS DANGEROUS. *TR
Electrical system, Seats, Jun 28, 2010
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THE DRIVER'S SEAT DETACHED FROM THE FLOOR BOARD. THE ELECTRICAL GAUGES AND COMPONENTS WERE ALSO INOPERABLE AND THE POWER DOOR LOCKS HAD FAILED. NEITHER THE DEALER OR MANUFACTURER WAS CONTACTED IN REGARDS TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 90,000.
Electrical system, Interior lighting, Jun 19, 2010
I BOUGHT MY 2002 FORD EXPLORER USED BUT ALSO HAVE A FATHER-IN-LAW WITH A FORD AND HE HAS THE SAME PROBLEM. WHEN WE BOUGHT IT THE DOOR AJAR LIGHT WAS ON ALL THE TIME AND THE DOME LIGHT WOULD STAY ON BUT AS WE DROVE THE LIGHT WOULD TURN OFF BUT THE LIGHT WOULD STAY ON. RECENTLY LAST WEEK THE LIGHT STAYS ON LIKE NORMAL BUT NOT THE LIGHTS GOES ON AND OFF, IT DINGS CONSTANTLY, AND THE DOORS LOCK AND UNLOCK WHILE GOING DOWN THE ROAD. IT IS VERY DISTRACTIVE AS WELL AS ANNOYING. WE GOT ONLINE TO SEE WHAT OTHER PEOPLE HAVE DONE AND THERE WERE LOTS OF COMPLAINTS. WE TRIED THE WD40 BUT THEY SAY THAT ONLY WORKS FOR A DAY OR SO. *TR
Power train, Electrical system, Equipment, May 28, 2010
OH WHERE DO I BEGIN. I HAVE 90,000 MILES ON MY SUV. MY RADIO GOES OFF AND ON RANDOMLY. DOOR AJAR IS ON RANDOMLY. WHEN SHIFTING FROM PARK TO DRIVE, IT STICKS AND I HAVE TO TAP IT TO GO INTO DRIVE. REAR WHEEL BEARING HAD TO BE REPLACED. O/D LIGHT CAME ON AND FLASHING. ONE TIME I THOUGHT IT WAS IN PARK AND WHEN GETTING OUT OF MY CAR, IT BEGAN TO ROLL AFTER TAKING MY FOOT OF THE BRAKE. I SEE THESE SEEM TO BE PROBLEMS FOR SEVERAL FORD EXPLORER OWNERS. PLEASE PLEASE PLEASE GET THIS ACROSS TO FORD THAT THESE NEED TO BE RECALLED, IF NOT I WILL NOT BE A FORD OWNER EVER AGAIN AND TELL EVERYONE I KNOW NOT TO BUY A FORD! WHAT IS GOING TO TAKE, A DEATH OR INJURY?? TAKE RESPONSIBILITY FORD! HOPE THIS NEVER HAPPENS TO YOU BUT THEN AGAIN, YOU PROBABLY DON'T EVEN DRIVE A FORD. *TR
Electrical system, Structure, Apr 19, 2010
DOOR AJAR LIGHT AND BEEPING SENSOR IS ALWAYS GOING OFF. CAUSING THE DOORS TO UNLOCK WHILE DRIVING AND ALSO CAUSING THE INSIDE DOME LIGHT TO TURN ON AND OFF. I HAVE DONE SOME RESEARCH AND ALOT OF FORD EXPLORERS ARE HAVING THIS PROBLEM. *TR
Electrical system, Feb 12, 2010
2002 FORD EXPLORER LIMITED ELECTRICAL ISSUES: 1)WHEN I PUSH THE REAR DEFROSTER BUTTON THE 'DOOR AJAR ' NOTICE COMES ON 2)WHEN THE REAR DEFROSTER IS ON THE MIRROR ADJUSTMENT SWITCH DOES NOT WORK 3)IF I LEAVE THE AUTOMATIC HEADLIGHT SWITCH ON AND I SHUT THE CAR DOWN AND LOCK IT WITH THE KEY FARB THE HORN BEEPS TWICE (INDICATING THE DOOR IS AJAR) AND THE INTERIOR LIGHT STAYS ON. I HAVE TO EITHER SWITCH THE AUTOMATIC HEADLIGHT SWITCH TO OFF OR MANUALLY TURN THE INTERIOR LIGHT OFF. 4)THE BACK UP BEEPER SWITCH SOMETIMES GOES OFF WHEN I PUT THE CAR IN REVERSE. THANKS FOR HELPING ME OUT. *TR
Power train, Electrical system, Feb 11, 2010
ON DEC 4TH 2009, MY 2002 FORD EXPLORER WAS DRIVING FINE ONE MINUTE AND THE NEXT THE O/D LIGHT STARTED FLASHING. I TURNED OFF THE IGNITION AND RESTARTED THE VEHICLE. THE O/D LIGHT BLINKING WENT AWAY. THE VERY NEXT DAY AGAIN, WITH THE LIGHT ONCE AGAIN FLASHING, THE VEHICLE REFUSED TO MOVE FORWARD WHEN GAS PEDAL WAS ENGAGED; HOWEVER THE RPM REVVED UP BETWEEN 3 AND 4. THROUGHOUT THAT SAME DAY, I ATTEMPTED TO GET VEHICLE INTO DRIVE MODE...EVENTUALLY THE VEHICLE JUST INCHED FORWARD AND FINALLY STOPPED MOVING ALTOGETHER. AFTER A CONSULTATION WITH MY LOCAL TRANSMISSION REPAIR SHOP.. I WAS DISHEARTEN TO LEARN THAT IN ORDER TO REPAIR, WHAT HE DESCRIBED AS A BAD TRANSMISSION, WHICH IS VERY COMMON WITH THE 2002 FORD EXPLORERS..I'D HAVE TO PAY $2868....SINCE THIS INCREDIBLE REVELATION, I'M DISCOVERING FORD KNOWS ALL ABOUT BUT REFUSES TO DO THE CONSCIONABLE THING AND RECALL THESE DEFECTIVE, DANGEROUS BUT COSTLY VEHICLES. I REGRETTABLE PAID THE $2868 REPAIR CHARGE FOR A REBUILT TRANNY WITH ABSOLUTELY NO ASSISTANCE FROM FORD. MY VEHICLE IS PAID OFF AND I REALLY CANT AFFORD TO JUST INVEST CLOSE TO 3K IN A VEHICLE THAT SHOULD'VE BEEN RECALLED AND FIXED ESPECIALLY SINCE THE FORD CORPORATION IS FULLY AWARE BUT DOESN'T CARE ABOUT THE PEOPLE WHO STILL BUY AMERICAN AND WANT TO CONTINUE SUPPORTING AMERICAN MADE PRODUCTS. BUT SINCE FORD REFUSES TO STAND BEHIND THEIR PRODUCT, IT MAY FORCE A LOYAL CUSTOMER TO GO ELSEWHERE IN THE FUTURE WHEN PURCHASING A NEW VEHICLE. MY VEHICLE WAS RECENTLY REPAIRED ON 2/8/10.. SO FAR I'VE DRIVEN IT ONCE... SO FAR SO GOOD...I RECEIVED A BETTER WARRANTY FROM MY TRANNY SHOP THAN THE FORD COMPANY WAS WILLING TO STAND BEHIND. THE DRIVERS SIDE DOOR AJAR ALARM CHIMES WHILE DOOR IS SECURELY CLOSED. THE LOCKING MECHANISM OPENS AND CLOSES. THIS ISSUE IS ALSO KNOWN AND A PROBLEM FOR THE 2002 FORD EXPLORER AND YET STILL NO RECALL... THANK YOU FOR LISTENING TO MY COMPLAINT. *TR