2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints: engine and engine cooling
194 reports, newest first. Show all
Engine and engine cooling, Jul 1, 2004
MY 2002 FORD EXPLORER SPORT TRAC STALLS WHEN GOING DOWN THE ROAD. IT'S LIKE YOU'RE TAKING YOUR FOOT OFF THE GAS AND BACK ON IT AGAIN EXCEPT THAT ISN'T WHAT I'M DOING. TODAY IT DID THAT AND THEN WENT DEAD WHILE DRIVING DOWN THE ROAD. I TOOK IT TO THE FORD PLACE BUT THEY SAID WITH NO LIGHTS ON IT WOULDN'T DO ANY GOOD TO HOOK IT UP TO A MACHINE. THEY SAID IT COULD BE ANYTHING FROM ELECTRONICS, FUEL PUMP, ETC. MY WARRANTY RUNS OUT IN ABOUT 4,500 MILES. THIS HAS BEEN GOING ON FOR ABOUT A YEAR WITH THE STALLING OUT BUT THIS WAS THE FIRST TIME IT ACTUALLY WENT DEAD WHILE DRIVING DOWN THE ROAD. I WOULD ESTIMATE THAT OVER THE PAST YEAR THAT IT HAS STALLED AT LEAST 25 SEPARATE OCCASIONS BUT ONLY 1 TIME SO FAR DID IT GO DEAD. *NM
Engine and engine cooling, Fuel system, Gasoline, Exterior lighting, Jun 23, 2004
WHILE DRIVING 65 AND ATTEMPTING TO PASS ANOTHER VEHICLE CONSUMER'S VEHICLE FAILED TO GO INTO PASSING GEAR. ENGINE STALLED AND CONSUMER HAD TO COAST TO THE SIDE OF THE HIGHWAY. ONCE OFF THE ROAD CONSUMER RESTARTED THE VEHICLE AND CONTINUED DRIVING. *AK THE VEHICLE WAS TOWED TO THE DEALER BUT THE TECHNICIAN COULDN'T FIND ANYTHING WRONG. THE VEHICLE WAS TAKEN BACK TOT HE DEALER WHERE THEY REPLACED THE FUEL PUMP, GAS TANK AND AIR FLOW SENSOR. SO FAR THE VEHICLE HAS BEEN RUNNING AS IT SHOULD. THE HEAT SHIELD UNDER THE VEHICLE RATTLED. THE DEALER ADJUSTED IT. THE MULTIFUNCTION SWITCH WOULD NOT LOCK IN PLACE WHEN USING THE TURN SIGNALS. *NM
Engine and engine cooling, Jun 22, 2004
BOUGHT CAR IN JANUARY 2003, WAS A DEALER VEHICLE. WE HAD 54,000 MILES ON IT WHEN I WAS DRIVING IT HOME FROM WORK AND THE CHECK ENGINE LIGHT CAME ON THE SAME TIME THE EXPLORER STARTED ALMOST BUCKING. THE FRONT END OF THE VEHICLE WAS SHAKING SO BAD THAT I IMMEDIATELY PULLED OVER AS BEST AS I COULD. I CALLED AAA AND AS THEY HAD ME TURN THE VEHICLE AROUND SO IT COULD BE PUT ON THE TRUCK THE ENGINE STOPPED ALL TOGETHER, AND THE VEHICLE WOULD NOT TURN OVER. AFTER BRINGING IT TO MY MECHANIC I WAS TOLD THAT THE ENGINE HAD SEIZED UP. I CALLED MY LOCAL FORD DEALER WHERE I HAD PURCHASED THE VEHICLE AND WAS TOLD THAT IT WOULD NOT BE COVERED BECAUSE MY WARRANTY WAS FOR 36,000. I HAVE HAD THE OIL CHANGED ALWAYS ON TIME AND ALSO HAD THE VEHICLE IN FOR ITS FULL MAITENCE CHECK JUST MONTHS BEFORE. COME TO FIND OUT, THE VALVE SPRING IN THE MOTOR BROKE AND CAUSED THE ENGINE TO SEIZE. I HAD TO ORDER A NEW ENGINE FROM FORD AND BETWEEN THE ENGINE AND LABOR IT COST ME CLOSE TO $3,900. WHEN I CALLED THE FORD COMPANY, BECAUSE I GOT NOWHERES WITH MY LOCAL FORD DEALER I WAS TOLD THAT THEY COULD NOT DO ANYTHING FOR ME. IF A RECALL WAS TO EVER COME ABOUT THEN I SHOULD SAVE MY RECEIPTS. I HAVE PICTURES OF THE ENGINE TO PROVE WHAT HAD HAPPENED IF I EVER NEED THEM. THE WAY I LOOK AT IT, I HAVE MORE MILES, BECAUSE OF MY JOB, THAN OTHERS DO ON A 2002. IT'S JUST A MATTER OF TIME UNTIL OTHERS HAVE THIS HAPPEN. MY LOCAL FORD COMPANY SAYS ITS A FLUKE. NICE REASON HAH? TO ME A $3,900. FLUKE IS NOTHING TO LAUGH ABOUT!*AK
Engine and engine cooling, Jun 15, 2004
WHILE DRIVING AT 30 MPH THE CONSUMER BEGAN TO HEAR A PINGING SOUND IN THE ENGINE. AFTER THE VEHICLE PICKED UP SPEED THE PINGING SOUND WENT AWAY. THE DEALER EXAMINED THE VEHICLE AND FOUND THAT THE TIMING CHAIN HAD TOO MUCH PLAY IN IT. THE DEALER INFORMED THE CONSUMER THAT THERE IS AN IMPROVED PART BUT, IT COST NINE HUNDRED DOLLARS. *LA
Engine and engine cooling, Jun 8, 2004
I BOUGHT A FORD EXPLORER SPORT TRAC IN AUG. OF 2002. EVER SINCE IT WAS A YEAR OLD I HAVE HAD NOTHING BUT PROBLEMS WITH IT. I HAD IT 6 TIMES FOR THE SAME ISSUE, THEY REPLACED THE SAME PART 4 TIMES, THAT DID NOT HELP. THEY FINALLY CALLED THE FORD HELP LINE AND FOUND OUT THEY NEEDED TO REPLACE THE WHOLE GAS TANK. MY TRUCK THE FIRST TIME LOST ALL POWER WHILE DRIVING DOWN THE ROAD, I SHUT IT OFF AND IT RESTARTED FINE. I TOOK INTO THE DEALERSHIP AND THEY HAD TO RE-PROGRAM THE MAIN COMPUTER CHIP. NEXT, MY TRUCK WOULDN'T START UNLESS HOLDING DOWN THE GAS PEDAL THEN FINALLY IT WOULD START AND THERE WOULD BE A BLACK SMOKE CLOUD THAT WOULD COME OUT OF THE TAIL PIPE EACH TIME. THE NEW GAS TANK FINALLY FIXED THIS PROBLEM! NOW I HAVE OTHER ISSUES WITH A NOISE IN THE ENGINE AND WHEN I FIRST START IT UP AND BACK OUT OF THE GARAGE OR PARKING SPACE IT SPUTTERS THEN ONCE IN DRIVE IT IS OK, ALSO WHEN SHIFTING AFTER 40MPH IT HAS A HARD SHIFT INSTEAD OF A SMOOTH ONE. STILL TRYING TO GET IT FIXED.*AK
Engine and engine cooling, May 28, 2004
WHILE DRIVING AT ANY SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE CAUSE HAS YET TO BE DETERMINED. PLEASE PROVIDE ADDITIONAL INFORMATION. *LA
Engine and engine cooling, Latches/locks/linkages, Apr 26, 2004
CONSUMER COMPLAINED ABOUT A STALLING PROBLEM. VEHICLE WAS TAKEN TO DEALER. HOWEVER, THE PROBLEM HAD NOT BEEN CORRECTED. ALSO, RIGHT REAR DOOR LOCKS MALFUNCTIONED, AND DOOR COULDN'T BE OPENED EXCEPT FROM THE OUTSIDE. *AK
Engine and engine cooling, Electrical system, Equipment, Apr 13, 2004
THE AUTOMATIC GEAR SHIFT BROKE. COULD NOT CHANGE GEARS. ELECTRIC WINDOWS STOPPED WORKING BOTH DRIVER AND PASSENGER. AIR CONDITIONER BROKE - AIR CONDITIONER CLUTCH MAKE RUBBING NOISE WHEN ENGAGED.
Engine and engine cooling, Power train, Mar 2, 2004
THE VEHICLE STALLED WHILE IDLING AT A LIGHT. *PH THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE VALVE. UNFORTUNATELY WITHIN THREE DAY THE VEHICLE STALLED AGAIN. THE VEHICLE WAS RETURNED TO THE DEALER BUT THEY WERE UNABLE TO DUPLICATE OR REPAIR THE PROBLEM. THE VEHICLE BEGAN TO SURGE WHILE SURGING IDLING. THE DEALER WAS UNABLE TO PERMANENTLY RESOLVE THAT PROBLEM. THE CONSUMER NOTICED A WHINE IN THE REAR END OF THE VEHICLE. THE DEALER REPLACED THE REAR DIFFERENTIAL BUT WHEN THE VEHICLE WAS RETURNED TO THE CONSUMER THE NOISE WAS STILL PRESENT. THE VEHICLE WAS STILL UNDER WARRANTY WHEN ALL THESE PROBLEMS STARTED. *NM
Engine and engine cooling, Power train, Feb 25, 2004
VEHICLE STALLS AFTER DRIVING 20 MILES OR ABOVE ON FREEWAY. WHEN ON EXIT RAMP,ENGINE LIGHT TURNS ON AND THE ENGINE SHUTS OFF. I HAVE TO PUT IT IN PARK AND START ENGINE AGAIN. THE VEHICLE ALSO ACCELERATES WHEN STOPPED AT LIGHT, WHILE FOOT IS ON BRAKE. THE ENGINE STALLS TO CHANGE INTO FASTER SPEED. *AK
Engine and engine cooling, Jan 26, 2004
DRIVING ON THE EXPRESSWAY, WHEN WE GOT OFF & WE TRIED TO STOP MY HUSBAND HEARD A REVVING NOISE THE CAR DID NOT WANT TO COME TO A COMPLETE STOP. HE SHUT THE CAR OFF AND THE PROBLEM CONTINUED. THE CAR WAS ACCELERATING ON ITS OWN. WE HAD TO SHUT THE CAR OFF & COAST TO A STOP BECAUSE THE BRAKES WERE NOT WORKING EITHER. WE WERE LUCKY NOT TO REAR-END SOMEONE & THAT NO ONE IN THE CAR INCLUDING MY 2 SMALL CHILDREN WERE HURT. THE SAME THING HAPPENED 4 DAYS EARLIER. I WAS ALSO THANKFUL MY HUSBAND WAS DRIVING. THE CAR HAD TO BE TOWED. I HAVE TAKEN THIS CAR IN 5 OTHER TIMES FOR RELATED PROBLEMS. THEY CAN NEVER SEEM TO FIND A PROBLEM. THIS IS A LEASE CAR & I HAVE HAD IT FOR 1YR 9MTHS. IT WAS FIRST SERVICED 1 MONTH AFTER I GOT IT FOR A RELATED PROBLEM. I DO NOT FEEL SAFE DRIVING MY FAMILY OR SELF ANYMORE IN THIS CAR, IT IS SO UNPREDICTABLE. *LA
Engine and engine cooling, Jan 9, 2004
WHILE DRIVING AT ANY SPEED VEHICLE INTERMITTENTLY STALLED. CONSUMER MADE CONTACT WITH THE DEALERSHIP. THE CAUSE OF FAILURE WAS NOT IDENTIFIED AT THIS TIME. HOWEVER, FLOOR MANAGER SUGGESTED THAT FOR ANOTHER $125.00 CONSUMER COULD HAVE A NICE AND DECENT NEW CAR". *AK
Engine and engine cooling, Visibility, Wheels, Dec 16, 2003
WHEN STOPPING OR SLOWING DOWN, INTERMITTENTLY THE VEHICLE STALLED WHEN TURNING LEFT, THERE WAS A KNOCKING SOUND COMING FROM THE FRONT LEFT WHEEL. THE HEAT VENTS THAT BLEW DIRECTLY ON THE CONSUMER DID NOT WORK. THESE PROBLEMS HAVE OCCURRED AT LEAST THREE TIMES IN ONE MONTH. THE MANUFACTURER AND THE DEALER WERE NOT AWARE OF THE PROBLEM. *JB
Service brakes, Hydraulic, Engine and engine cooling, Electrical system, Tires, Dec 2, 2003
ALL FOUR TIRES WERE SLIGHTLY CUPPING, AND THE BRAKES MADE A THUMPING NOISE WHEN THEY WERE DEPRESSED. DEALERSHIP REPLACED THE PADS, LUBED THE FRONT CALIPER SLIDE PIN, AND REPLACED ROTORS. *AK VEHICLE EXPERIENCING PROBLEMS WITH TIRES CUPPING. THE FOLLOWING REPAIRS WERE PERFORMED ON THE VEHICLE: ENGINE REPLACED, BRAKES, REPLACED, ALIGNMENT, BATTERY WIRING ASSEMBLY REPAIRED, DPFE SENSOR REPLACED. CONSUMER ASKED DEALER FOR A FULL REFUND ON VEHICLE.*MR
Engine and engine cooling, Nov 18, 2003
WHILE CHANGING THE OIL IN THE VEHICLE CONSUMER NOTICED THAT SEVERAL DRIVER SIDE MOTOR MOUNT BOLTS WERE LOOSE. MANUFACTURER WAS INFORMED OF THE PROBLEM, AND INFORMED THE CONSUMER THAT MAYBE THE PROBLEM OCCURRED AT THE FACTORY. *AK *NLM
Engine and engine cooling, Nov 12, 2003
THE VEHICLE MUST BE DRIVEN WITH THE WINDOWS DOWN BECAUSE CHEMICAL FUMES ENTER INTO THE PASSENGER'S COMPARTMENT. THE DEALER INSPECTED THE VEHICLE SEVERAL TIMES, AND COULD NOT DUPLICATE OR CORRECT THE PROBLEM. *AK THE CATALYTIC CONVERTER WAS REPLACED AND RESET BUT THE PROBLEM REMAINED THE SAME. *SCC *JB
Engine and engine cooling, Nov 4, 2003
VEHICLE WAS TAKEN TO DEALER ON FOUR PREVIOUS OCCASIONS TO ADDRESS AN OVERHEATING PROBLEM THAT OCCURRED SUDDENLY WHILE DRIVING. TEMPERATURE GAUGE WOULD SPIKE AND THEN RETURN TO ALMOST NORMAL LEVELS. ON THE FIFTH TRIP TO THE DEALER 10/24/03, WAS THEN TOLD THE PROBLEM IS A CRACKED CYLINDER HEAD., THIS WAS LATER DIAGNOSED AS A PISTON PROBLEM. VEHICLE IS STILL WITH DEALER WITH COMPRESSION PROBLEMS. *AK
Engine and engine cooling, Oct 28, 2003
WHILE MERGING ONTO A FREEWAY, COULDN'T GET OVER 2,000 RPM AND THUS COULDN'T GET ENOUGH SPEED TO MERGE ON AT OVER 25MPH. VEHICLE STALLED SEVERAL TIMES WHILE TRYING TO GET OFF THE FREEWAY. NEW VEHICLE HAS 10812 MILES. FORD MAINTENANCE DEPT STATED THEY COULDN'T FIND ANYTHING WRONG, IT RAN FINE FOR THEM. MY HUSBAND WENT TO PICK UP THE VEHICLE AND IN DRIVE IT RAN, IN NEUTRAL COULDN'T GET MORE THAN 2,000 RPM, MECHANIC SAID IT WAS THE GOVERNOR, NEEDLESS TO SAY, MY HUSBAND SAID FIX THE CAR. THEY STILL HAVE MY TRUCK.*AK
Engine and engine cooling, Electrical system, Structure, Seats, Oct 27, 2003
WHILE DRIVING AT VARIOUS SPEEDS BLACK SMOKE WOULD CAME FROM THE TAIL PIPE. CONSUMER COULD SMELL GAS FUMES INSIDE THE VEHICLE. .*AK DRIVERS REAR DOOR WILL NOT OPEN FROM THE INSIDE. DRIVERS SIDE SEAT MOLDING IS FALLING OFF. CENTER DUCT LOOSE ON DASH. DRIVERS SEAT CUSHION LOST ITS FORM. *TS
Engine and engine cooling, Sep 18, 2003
ENGINE STALLED AT 4683 MILES ON THE ODOMETER. DATE: 7 OCTOBER 2002. I NOTED THAT IT NOW IDLES AT 600 RPM. I DON'T KNOW WHAT THAT MEANS. *JB
Engine and engine cooling, Sep 18, 2003
4405 MILES, 9:05 A.M., SEPTEMBER 1, 2002, CAR STALLED AGAIN. *JB
Engine and engine cooling, Aug 18, 2003
I HAVE BEEN SMELLING ANTI-FREEZE. I JUST NOTICED THAT MY RADIATOR HOSE HAS BEEN RUBBING ON THE OIL FILL AND MADE A NICE BIG HOLE ON THAT SIDE AS WELL AS ON THE OTHER SIDE FROM ANOTHER MECHANISM UNDER THE HOOD. NICE ASSEMBLY. I OWNED MY TRUCK FOR 8 MONTHS NOW.*AK
Engine and engine cooling, Aug 14, 2003
WHILE DRIVING FOR EXTENED POINT OF TIME VEHICLE WOULD OVERHEAT WITHOUT WARNING, CAUSING CONSUMER TO PULL OFF THE ROAD. CONSUMER HAD CONTACTED THE DEALER ON FOUR SEPARATE OCCASIONS, AND THE PROBLEM STILL OCCURS. *AK
Engine and engine cooling, Aug 7, 2003
THE CONSUMER NOTICED THAT OIL WAS LEAKING FROM THE VEHICLE. THE DEALER REPLACED THE OIL PAN GASKET BUT THE LEAKING PERSISTED. THE DEALER THEN REPLACED THE OIL PAN BUT OIL CONTINUED TO LEAK. THE DEALER EVENTUALLY HAD TO GLUE THE SCREWS TO THE OIL PAN TO SOP THE LEAKING. THE CONSUMER WAS NOT SATISFIED WITH THIS REPAIR. *AK *PH *NLM
Engine and engine cooling, Aug 6, 2003
CONSUMER STATES THAT WHILE DRIVING AT ANY SPEED AND WITHOUT WARNING VEHICLE WILL STALL, AND IT WILL BE HARD FOR THE CONSUMER TO CONTROL THE VEHICLE. DEALER NOTIFIED. *AK