2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints: power train
1,575 reports, newest first. Show all
Power train, Jun 8, 2011
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE ODOMETER BEGAN TO FLASH AND THE VEHICLE BEGAN TO JERK ABNORMALLY. THE VEHICLE WAS TAKEN HOME AND PARKED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 84,000.
Power train, Jun 3, 2011
TRANSMISSION GEAR SHIFT BROKE OFF STEERING COLUMN AS THE VEHICLE WAS PUT IN PARK. COULD HAVE BEEN A MAJOR SAFETY ISSUE HAD I BEEN ANYWHERE OTHER THAN MY HOME AND SHIFTING INTO ANY OTHER GEAR THAN PARK. THOUGHT THIS WAS AN ISOLATED INCIDENT ONLY TO FIND INFORMATION ONLINE THAT THIS IS A COMMON OCCURRENCE WITH THE 2002 EXPLORERS (OVER 100 REPORTED ON ONE WEBSITE ALONE). OTHER ISSUES I'VE EXPERIENCED SINCE DAY 1 OF PURCHASING THE VEHICLE NEW ARE TRANSMISSION LUNGING, VEHICLE ROCKING WHEN PUT IN PARK, AND DIFFICULTY SHIFTING INTO PARK.
Power train, Jun 3, 2011
TODAY I DROVE MY 2002 FORD EXPLORER OUT AND UPON RETURNING HOME I COULD NOT SHIFT IT INTO PARK. I SWITCHED IT OFF THINKING THAT IF I CRANK IT UP AND TURN THE WHEELS IT WOULD GO INTO PARK BUT I COULDN'T EVEN CRANK IT UP BECAUSE I WAS NOT IN THE PARK GEAR. I PLAYED WITH IT FOR 20 MINUTES AND IT FINALLY WENT INTO PARK. I LET IT SIT FOR A COUPLE HOURS AND WENT BACK OUT AND CRANKED IT, IT WENT INTO GEAR. I DROVE IT AROUND THE BLOCK CAME BACK AND PARKED. CRANKED IT UP ABOUT 10 MINUTES LATER TO GO OUT AND IT WOULD NOT COME OUT OF PARK GEAR. I HAVE NO IDEA WHAT THE PROBLEM BUT IF IT'S SOMETHING SERIOUS THE DEALER CAN HAVE IT BACK. SOMETHING SHOULD BE DONE TO MAKE FORD REPAIR THEIR MALFUNCTIONS, WE ARE TALKING SOME SERIOUS MONEY ON THESE REPAIRS AND A LOT OF PEOPLE LIKE MYSELF IS LOOKING FOR WORK NOW. PEOPLE WE NEED TO START PROTESTING OUT SIDE THESE DEALERSHIPS. THEY ARE GETTING RICH AND WE ARE SUFFERING AT THEIR MISHAPS. *TR
Power train, May 31, 2011
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THE GEAR SELECTOR LEVER FRACTURED WHEN SHIFTING FROM PARK INTO DRIVE. THERE WAS NO PRIOR WARNING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS AND REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 108,000.
Power train, Latches/locks/linkages, May 31, 2011, crash
THIS REQUESTED RECALL INVOLVES A 2002 FORD EXPLORER HAVING AN AUTOMATIC TRANSMISSION. DURING NORMAL USE, THE SHIFT LEVER BREAKS OFF AT A CAST ROTATING CYLINDER THAT TRANSMITS THE TORQUE FROM THE GEAR SHIFTER TO PUSH AND PULL THE CABLE THAT PUTS THE VEHICLE IN PARK, DRIVE, NEUTRAL, AND REVERSE. THE VEHICLE ALSO HAD A TENDENCY TO JUMP OUT OF PARK EVEN BEFORE THE PART BROKE WHICH CAUSED THE VEHICLE TO ROLL BACK AND ALMOST PINNED ME BETWEEN ANOTHER VEHICLE WHEN THE VEHICLE ROLLED BACK AND CRASHED INTO A VEHICLE PARKED DOWNHILL. THIS WAS A NEAR MISS ACCIDENT. FORD WANTS TO CHARGE $1500 TO REPLACE THE ENTIRE STEERING COLUMN. WE ELECTED TO JUNK THE VEHICLE AT THIS TIME UNTIL ANOTHER SOLUTION CAN BE FOUND. VEHICLE STILL DRIVES IF YOU REACH YOUR HAND AND PUSH/PULL THE TRANSMISSION CABLE TO SHIFT THE AUTOMATIC TRANSMISSION INTO GEAR. WE CAN SEND THE BROKE OFF SECTION OF THE PART IF YOU WILL RETURN IT. ON THE INTERNET, THERE ARE MANY REPORTS OF THE SAME FAILURE FOR YEARS 2002 THROUGH 2005 FORD EXPLORERS. *TR
Steering, Power train, May 19, 2011
WHEN PUTTING CAR INTO PARK OR REVERSE, CAR WOULD SOMETIME STILL BE IN DRIVE FOR SECONDS AFTER PUTTING CAR IN GEAR. SEVERAL TIMES NOW, OCCASIONALLY CAR WILL SIMPLY SHUT OFF. RECENTLY, THE CAR WOULD NOT GO INTO PARK AND SHIFTER SEPARATED FROM STEERING COLUMN. *TR
Steering, Power train, May 14, 2011
WHILE BACKING UP, THE GEAR SHIFT BROKE ON MY 2002 FORD EXPLORER. IT WAS GOOD THAT I WAS NOT IN TRAFFIC BECAUSE I COULD NOT GET THE CAR BACK IN GEAR AND COULD HAVE GOTTEN HIT AND OR CAUSED AN ACCIDENT. THE STEERING COLUMN WAS REPLACED AND THE PARTS WERE IN MY OPINION OVER PRICED. MY FEAR IS THAT IT MAY HAPPEN AGAIN BECAUSE IT MAY HAVE BEEN REPLACED WITH THE SAME DEFECTIVE PART. *TR
Power train, May 11, 2011
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE AUTOMATIC TRANSMISSION FAILED AND WAS REPLACED AT THE CONTACTS EXPENSE. TWO YEARS LATER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO A MECHANIC SHOP WHO ADVISED THAT THE TRANSMISSION WOULD NEED TO BE REPLACED OR REBUILT A SECOND TIME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED WHO OFFERED NO ASSISTANCE AND THERE WERE NO RECALLS FOR THE FAILURE. THE FAILURE MILEAGE WAS 120,000.
Power train, May 10, 2011
TRANSMISSION FAILURE AT 60K MILES. HARD SHIFTING, JERKING, SUDDEN SHIFTS INTO 4X4 HIGH. REPLACEMENT COST OF 2800 DOLLARS. THREE VISITS LATER AND IT STILL ISN'T RIGHT. *TR
Power train, May 4, 2011
TRANSMISSION HAS HAD PROBLEMS SINCE CAR WAS BOUGHT. HAVE HAD WORK DOWN ON IT AND FINALL Y HAD TO REPLACE IT IN MAY 2011, COST $5000. *TR
Power train, May 2, 2011, crash
FORD EXPLORER TRANSMISSIONS SLIPPING AND GOING OUT WILL GET U KILLED IF U PULL OUT IN TRAFFIC AND IT STARTS SLIPPING AND WANT GO SOMEONE MAY HIT U AND GET U KILLED. *TR
Power train, Apr 28, 2011
MY 2002 FORD EXPLORER HAS A REAR END NOISE IT IS REALLY LOUD I'VE NOTICED MANY EXPLORERS HAVE THE SAME PROBLEM. I HAVE REPLACE REAR AXLE THE WHOLE REAR END AND THE NOISE COMES BACK I THINK ITS RIDICULOUS THAT I HAVE TO PAY ALL THIS MONEY TO FIX IT WHEN ITS A WIDE SPREAD PROBLEM FOR FORD EXPLORERS. FORD SHOULD HAVE A SOLUTION BY NOW AND SHOULD FIX IT FOR FREE.THE NOISE IS A CONSTANT WHEN DRIVING. *TR
Suspension, Power train, Apr 25, 2011
OUR 2002 FORD EXPLORER XLT WITH 109,000 MILES HAS SERIOUS TRANSMISSION SLIPPAGE BETWEEN 2ND AND 3RD GEARS. THE LOCAL DEALER AND AN INDEPENDENT REPAIR SHOP STATE THAT THE TRANSMISSION NEEDS REPLACED AT A COST BETWEEN $2,500 AND $3,500. IT IS DANGEROUS TO DRIVE IN ITS CURRENT CONDITION BECAUSE THERE ARE TIMES WHEN IT WILL NOT ACCELERATE. THE REAR DIFFERENTIAL AND BALL BEARINGS ALSO NEED REPLACED ACCORDING TO 2 SEPARATE MECHANICS. THERE IS A RANDOM THUMPING COMING FROM THE BACK OF THE VEHICLE DAILY. THE COST TO REPAIR IS BETWEEN $2,000 AND $5,000. THEY CANNOT TELL US EXACTLY UNTIL THEY ACTUALLY GET IN THERE TO DO THE REPAIR. *TR
Power train, Apr 19, 2011
MY TRANSMISSION ON MY 2002 FORD EXPLORER XLT WONT SHIFT INTO 3RD GEAR. *TR
Power train, Apr 18, 2011
TRANSMISSION IS WHINING AND NEEDS TO BE REPLACED. *TR
Steering, Power train, Apr 15, 2011
PLEASE DO SOMETHING ABOUT THIS !!!! THE EXPLORER GEAR SHIFTER IS DEFECTIVE AND UNSAFE. THERE IS A COMMON THREAD WITH GEARSHIFT SELECTOR BREAKAGE ON FORD EXPLORERS WHICH INDICATES THAT RECALL IS URGENTLY NEEDED. AFTER PARKING, I TRIED TO MOVE THE GEAR SHIFTER FROM DRIVE TO PARK TO EXIT THE VEHICLE. TO MY ABSOLUTE ASTONISHMENT THE GEAR SHIFTER BROKE LIKE A DANGLING BROKEN ARM IN THE REVERSE POSITION. THE VEHICLE WAS RENDERED USELESS AND ME OPTIONLESS. I WORK AT A SECURE GOV'T FACILITY AND IT WAS NO PICNIC TRYING TO GET A TOW TRUCK DRIVER ACCESS. I FINALLY GOT THE TRUCK TOWED TO THE NEAREST DEALERSHIP AT $85. THE DEALER THEN INFORMED ME THAT THE ENTIRE STEERING COLUMN WOULD HAVE TO BE REPLACED AT $1,690. THEY DIDN'T HAVE THE PART AND NEEDED A DAY TO GET THE TRUCK BACK TO ME. I HAD TO RENT A CAR WHICH WAS ANOTHER $102 BUCKS. MAKE FORD TAKE CARE OF THIS SAFETY HAZARD. I ASKED FOR THE PART AND CAN SHOW YOU WHAT BROKE INSIDE WHICH IS LITERALLY A WEAK METAL HOUSING THAT THE GEAR SHIFT HANDLE FITS IN.... *TR
Power train, Apr 15, 2011
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE OVERDRIVE WARNING INDICATOR ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE TRANSMISSION ALSO EXHIBITED SEVERE HESITATION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION WHERE THE TECHNICIAN DETECTED THAT THE FAILURE WAS RELATED TO THE TRANSMISSION. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 114,071.
Power train, Apr 15, 2011
MY WIFE WAS PREPARING TO TAKE OUR 3 CHILDREN TO SCHOOL. SHE PUT OUR 2002 FORD EXPLORER IN REVERSE AND BACKED OUT OF OUR DRIVEWAY. AFTER STOPPING, SHE ATTEMPTED TO SHIFT INTO DRIVE. THE GEAR SHIFT LEVER BROKE, LEAVING HER WITH A CAR STUCK IN NEUTRAL. THE KEYS ARE LOCKED IN THE IGNITION AND CANNOT BE REMOVED. AFTER RESEARCHING THIS ONLINE, I WAS VERY SURPRISED TO DISCOVER THIS IS NOT A RECALL ITEM AND THAT FORD MOTOR COMPANY'S RECOMMENDED FIX IS CHANGING OUT THE ENTIRE STEERING COLUMN. IS THIS REALLY TRUE? *TR
Power train, Apr 12, 2011
TL*THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE THE VEHICLE WAS PARKED THE CONTACT STATED THAT THE GEAR SHIFT BROKE OFF WHILE SWITCHING GEARS FROM DRIVE TO PARK. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR A MECHANIC SINCE THE CONTACT WAS UNABLE TO BE DRIVE IT. THE APPROXIMATE FAILURE MILEAGE WAS 148,000.
Power train, Apr 11, 2011
DRIVING 2002 FORD EXPLORER WHEN O/D LIGHT FLASHED AND WARNING CAME ON TO CHECK TRANSMISSION. WILL NEED A NEW TRANSMISSION. *TR
Power train, Mar 15, 2011
GEAR SHIFT IN MY 2002 FORD EXPLORER BROKE OFF WHILE TRYING TO PUT MY CAR IN GEAR. I HAVE BEEN INFORMED BY THE LOCAL DEALER THAT THE PART IS PART OF THE STEERING COLUMN AND IT WOULD COST APPROX. $1200.00 TO REPLACE. THE PART THAT BROKE IS MADE OF ALUMINUM AND IS ONLY ABOUT 4-5 INCHES LONG. THIS WAS A DANGER TO ME BECAUSE MY DRIVEWAY IS ON A SLIGHT INCLINE. IN ADDITION IF THE VEHICLE WENT INTO REVERSE, I COULD OF HAD CAUSE PROPERTY DAMAGE AND HOW WOULD I PUT THE VEHICLE BACK IN PARK? *TR
Power train, Mar 15, 2011
TL*THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS THE VEHICLE WOULD LUNGE FORWARD AT TIMES, STALL, AND SHIFTING WOULD BE DIFFICULT. THE VEHICLE WAS NOT INSPECTED BY THE DEALER NOR BEEN WAS IT REPAIRED. THE MANUFACTURER ADVISED HER THAT THE TRANSMISSION MIGHT NEED TO BE REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.
Power train, Mar 11, 2011
TL*THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WOULD NOT SHIFT PROPERLY FROM SECOND TO THIRD GEAR. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY PERFORMED A DIAGNOSTIC TEST WHICH CONCLUDED THAT THE HYDRAULIC PRESSURE BUILD UP HAD CAUSED THE TORQUE CONVERTER TO POP OUT AND ADVISED THE CONTACT THAT THEY WOULD NEED TO REPLACE OR REBUILD THE TRANSMISSION. A PRIVATE MECHANIC CONFIRMED THE FAILURE AND REBUILT THE TRANSMISSION. THE CURRENT AND FAILURE MILEAGE WAS 115,000.THE VIN WAS UNAVAILABLE. UPDATED 03/24/11*LJ
Power train, Mar 10, 2011
2002 FORD EXPLORER REAR END GROWL/WHINE. *TR
Power train, Mar 7, 2011
WAS DRIVING DOWN THE HIGHWAY AT 55 MPH AT MY OVERDRIVE LIGHT STARTED FLASHING AND MY INFORMATION SCREEN SHOWED "CHECK TRANSMISSION" WHEN I GOT HOME, I LOOKED UP THE PROBLEM ON THE INTERNET AND FOUND THAT MY TRANSMISSION JUST WENT BAD AND WILL NEED TO BE REPLACED ACCORDING TO WHAT HUNDREDS OF COMPLAINTS SAY HAD TO BE DONE TO FIX THE SAME PROBLEM.