2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints: power train
1,575 reports, newest first. Show all
Steering, Suspension, Parking brake, Engine and engine cooling, Power train, Seats, Aug 21, 2010
PURCHASED 2002 EXPLORER XLT V6 4.0L ALREADY TRANSMISSION SLIPPING SOLENOID OR WHATEVER OUT.. I HAVE READ REPORTS AND WONDER WHY THIS TRANSMISSION IS NOT RECALLED? I HAVE IT IN SHOP NOW HAVING TO HAVE IT REBUILT AND EVERYTHING CHANGED. ALSO RIGHT WHEEL BEARINGS BAD, UPPER AND LOWER BALL JOINTS BAD, SUSPENSION SHOT. AND THE RECORDS SHOW THE PREVIOUS OWNERS MAINTAINED EVERYTHING WELL. BUT ALSO HAD TRANSMISSION REPLACED AND HAD PROBLEMS AT 99,000MILES. PLEASE DOING SOMETHING FOR ALL OF US OUT HERE. ALSO COOLANT LEAK, ENGINE LEAK, POWER SEAT FAILURE, AND ON. *TR
Power train, Aug 20, 2010
2002 FORD EXPLORER XLS. I WAS SHIFTING FROM DRIVE TO PARK AND THE SHIFTER BROKE IN MY HAND. NOT A GOOD THING. AFTER DOING SOME RESEARCH IT SEEMS THIS A COMMON PROBLEM WITH FORD EXPLORERS DUE TO THE CAST ALUMINUM THAT IS USED IN THE PART. FORD SHOULD HAVE A RECALL FOR THIS, SEEING AS HOW IT HAPPENS DUE TO THE WAY IT WAS MADE NOT DUE TO DRIVER ERROR. *TR
Power train, Aug 20, 2010
2002 FORD EXPLORER TRANSMISSION FAILURE. THE TRANSMISSION KEPT SLIPPING, WOULDN'T SHIFT, AND THE O/D LIGHT KEPT COMING ON. I TOOK IT TO THE FORD DEALER IN WASILLA, AK THREE TIMES AND EACH TIME THEY KEPT IT FOR 3-4 WEEKS WHILE "REPAIRING" IT. THE FOURTH TIME IT WENT OUT (MAY 2008), IT WAS OUT OF WARRANTY, SO I HAD TO PURCHASE A REBUILT TRANSMISSION. IN AUGUST 2012, THE TRANSMISSION WENT OUT AGAIN; IT SIMPLY WOULDN'T ENGAGE IN ANY GEAR. THIS COULD HAVE BEEN EXTREMELY DANGEROUS HAD I BEEN STRANDED (1) IN THE DEAD OF WINTER (WHICH, IN ALASKA, CAN BE 35 BELOW AND LIFE&DEATH SITUATION) OR (2) IN HEAVY TRAFFIC, CAUSING AN ACCIDENT. I HAVE NOW BEEN INFORMED THAT COOLANT GOT INTO THE TRANSMISSION (WHICH IS SUPPOSEDLY SEALED?) AND THE TRANSMISSION MUST BE REPLACED AGAIN; BUT THE WARRANTY IS VOID. I SEE HUNDREDS OF COMPLAINTS ON THIS TRANSMISSION. WHY HASN'T ANYTHING BEEN DONE - A RECALL?? *TR
Power train, Aug 18, 2010
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE IGNITION WAS STARTED AND THE GEAR SELECTOR WOULD NOT SHIFT OUT OF PARK. THE CONTACT STATED THE GEAR SHIFT LEVER FRACTURED INSIDE OF THE STEERING COLUMN. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THEY INFORMED THE CONTACT THAT THE STEERING COLUMN ASSEMBLY WOULD NEED TO BE REPLACED. THE PART WAS UNAVAILABLE AND THE DEALER WAS IN THE PROCESS OF LOCATING THE PART FOR REPAIR. THE VEHICLE WAS NOT. THE FAILURE MILEAGE WAS APPROXIMATELY 117,000.
Power train, Aug 17, 2010
2002 FORD EXPLORER WITH 120,000 MILES. TRANSMISSION BEGAN TO SLIP 3RD GEAR. STALLING IN TRAFFIC. FORD DEALER COULD NOT LOOK AT IT FOR 2 DAYS SO WENT TO INDEPENDENT SHOP WHO KNEW THE PROBLEM WELL. NOT ONLY HAD TO REPLACE SOLENOID VALVES, BUT ALSO TORQUE CONVERTER AND REBUILD. HAD TO DRILL OUT ONE PORT AND INSTALL STRONGER LINKAGE PART FORD OFFERED SINCE 2006. *TR
Power train, Aug 17, 2010
TL* THE CONTACT OWNS A 2002 FORD EXPLORER XLT. THE CONTACT STATED WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD FAIL TO ENGAGE IN THIRD AND FOURTH GEARS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE TRANSMISSION WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER ADVISED THAT THE VEHICLE WAS NOT UNDER RECALL AND WOULD NOT PROVIDE ANY FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 11,250 AND THE CURRENT MILEAGE WAS APPROXIMATELY 11,300.
Power train, Aug 17, 2010
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE ATTEMPTING TO SHIFT THE VEHICLE FROM DRIVE TO PARK, THE GEAR SHIFT LEVER SUDDENLY FRACTURED INTO THE CONTACTS HAND. THERE WHERE NO PRIOR WARNINGS OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS 136,000.
Power train, Aug 17, 2010
OD OFF LIGHT FLASHING, CAUSING THE 02 FORD EXPLORER NOT TO SHIFT PROPERLY, REPLACED TRANSMISSION 3 TIMES AND THE LIGHT IS STILL FLASHING. FORD NEEDS TO RECALL THIS JUNK. *TR
Power train, Aug 15, 2010
HELLO, I AM COMPLAINING ABOUT A PROBLEM WITH MY 2002 FOR EXPLORER. ME AND MY FAMILY WERE DRIVING AND GETTING READY TO MERGE ONTO THE HIGHWAY AND SUDDENLY THE CAR JERKED AND THE OVERDRIVE LIGHT STARTED BLINKING. THEN THE RPM'S WENT UP TO ABOUT 5000. I THEN HAD TO RUN OFF THE ROAD TO AVOID A SEMI RUNNING US OVER. I HAVE 5 CHILDREN AND WE WERE LUCKY. I DON'T WANT THIS TO HAPPEN TO OTHER FAMILIES. THIS NEEDS TO BE A RECALL! THANK YOU *TR
Steering, Power train, Aug 11, 2010
I HAVE A 2002 FORD EXPLORER AND THIS MORNING I WAS GOING AT WORK WHEN THE GEAR SHIFT ARM BROKE OFF IN MY HAND. I HAD TO CALL MY WIFE FOR GO AT WORK AND I WAS UNABLE TO REMOVE MY KEYS FROM THE IGNITION. MY CAR IS COMPLETELY UN-DRIVABLE. *TR
Power train, Vehicle speed control, Equipment, Aug 11, 2010
MAJOR TRANSMISSION PROBLEMS AT 106K MILES ON MY FORD EXPLORER XLT 4.0L. THIS WAS NOT DUE TO POOR MAINTENANCE OR UP KEEP! SHIFTING INTO NEUTRAL GOING 75 MILES AN HR DOWN THE FREEWAY, SHIFTING OUT OF PLACE, ROUGH, SCARY SHIFTS, SHIMMING FROM THE TRANSMISSION JUMPING ALLOVER THE PLACE IS JUST THE BEGINNING. AFTER 5 TRIPS TO THE MECHANIC, FIRST I DID WIRES, THEN PLUGS, THEN UPDATED COMPUTER, FULL TRANNY FLUSH AND FINALLY HAD TO REBUILT THE TRANSMISSION DUE TO THE SOLENOIDS IN THE TRANSMISSION BEING DEFECTIVE AND FAULTY PER A FORD SERVICE MANAGER IN OWATONNA, MN. THE SERVICE MANAGER INFORMED ME THAT FORD WAS LOOKING AT MAKING IT A RECALL, BUT IT WASN'T THE TOP OF THEIR PRIORITY LIST AND MAYBE THEY WOULD EVENTUALLY GET TO IT! HE HAS SEEN MANY OF THESE TRUCKS IN THE SHOP WITH THEIR "BUSY" TRANSMISSIONS, AND THE SAME ISSUES! THIS WAS THE ISSUE ALL ALONG..AFTER ALL OF THE SERVICE APPTS, AND MONEY SPENT NOTHING WAS RESOLVED, UNTIL THE TRANSMISSION WAS REBUILT! $4K LATER JUST FOR THE TRANNY REPAIR! FOR THEIR FAULTY DEFECTIVE TRANSMISSION SOLENOIDS! AS IF THE TRUCK DIDN'T ALREADY COST ENOUGH! AND THE TROUBLESHOOTING "BANDAIDS" (WHICH BETWEEN THE TRANNY, DIAGNOSTICS, LABOR ETC TOTAL WELL OVER $5500!!) I CONTACTED FORD AFTER DIRECTED TO DUE SO MY (THEIR) TECHNICIAN AND EMPLOYEE OF 25 YRS. I READ ALL THE POSTS OF DUPLICATE COMPLAINTS (I SEE THERE ARE SEVERAL OTHER CONSUMERS IN MY SITUATION!), TO INFORM THEM OF THE MONEY I'VE LOST, TIME INCURRED INTO THIS HEADACHE, AND ALL THE DAYS I WENT WITHOUT A VEHICLE FOR MY FAMILY THAT I HAD NOTHING TO DO WITH IT WAS THEIR EQUIPMENT! THAT IT WAS THEIR FAULT! CURIOUS ABOUT WHAT THEIR COMPENSATION WAS, IF ANY, GOING TO BE. OR WHAT THEY PLANNED ON DOING ABOUT IT! AND AFTER SEVERAL SERVICE APPT, $5500 LOSS AND NUMEROUS COMPLAINTS THAT FORD IS AWARE OF THE REP STATED BASICALLY SAID OH WELL! ITS UR PROBLEM NOT OURS!!! LOL! *TR
Power train, Aug 10, 2010
ORIGINAL OWNER OF A 2002 FORD EXPLORER XLT. TRANSMISSION IS NOT SHIFTING PROPERLY. O/D LIGHT IS CONSTANTLY BLINKING ON THE DASHBOARD. NEVER TOWED ANYTHING AND HAD THE TRANSMISSION SERVICED. VERY DISAPPOINTING COMING FROM A LOYAL FORD FAN. *TR
Power train, Aug 9, 2010
TRANSMISSION FAILED. *TR
Power train, Aug 7, 2010
2002 FORD EXPLORER, TRANSMISSION TOTAL FAIL WHILE DRIVING. *TR
Engine and engine cooling, Power train, Visibility, Air bags, Aug 5, 2010
LONG LIST OF REPAIRS MADE THIS SUMMER INCLUDING COMPUTER, AIRBAG SENSORS, A/C WHOLE SYSTEM, MAIN WINDOW CONTROLS AND NOW MY TRANSMISSION. *TR
Power train, Jul 30, 2010
NOISE FROM REAR WHEEL HUB BEARINGS. FORD TSB 05-25-8. I HAVE ONLY 35,000 ON THIS VEHICLE AND AM CONCERNED THAT IF THERE IS A BEARING FAILURE ON A REAR WHEEL HUB YOU COULD LOSE CONTROL OF THE VEHICLE. I FEEL THAT FORD SHOULD BE RESPONSIBLE TO CORRECT THIS DEFECT. *TR
Power train, Jul 29, 2010
2002 FORD EXPLORER O/D LIGHT STARTED FLASHING, TRANSMISSION IS SLIPPING, CLUNKING AND SEEMS LIKE IT WON'T LAST MUCH LONGER. *TR
Power train, Jul 26, 2010
2ND GEAR OUT OF TRANSMISSION. IT OCCURS EVERYTIME YOU DRIVE IT. THE OD LIGHT BLINKS AND THE ENGINE LIGHT COMES ON AS A RESULT. THE TRANSMISSION HAS TO BE REPLACED, THE OLD TRANSMISSION IS AVAILABLE AT THIS TIME, BUT WON'T BE FOR LONG. *TR
Power train, Jul 26, 2010
DURING NORMAL DRIVING CONDITIONS, "SERVICE ENGINE SOON" LIGHT TURNS ON, FOLLOWED BY "O/D OFF" LIGHT FLASHING, FOLLOWED BY ERRATIC SHIFTING BY AUTOMATIC TRANSMISSION. HAPPENS AT LEAST ONCE PER WEEK, RESETS AFTER ENGINE IS TURNED OFF AND RESTS FOR A SHORT PERIOD OF TIME. *TR
Power train, Jul 25, 2010
I HAVE A 02 FORD EXPLORER DRIVING ON THE ROAD WHEN THE OD LIGHT FLASHING LOST POWER IT HARD TO SHIFT IN GEAR AM NOT THE ONLY 1 WIT THIS PROBLEM THERE THOUSAND OF FORD OWNER WIT THIS SAME PROBLEM WHY CANT U GUYS MAKE FORD RECALL THIS PROBLEM TOYOTA MAKE THEY RECALL THEY MANUP TO THEIR PROBLEM WHY CANT FORD DO THAT. *TR
Power train, Jul 24, 2010
LAST NIGHT, THE O/D OFF LIGHT ON MY 2002 FORD EXPLORER STARTED BLINKING. TODAY, THE VEHICLE WILL NOT DRIVE IN NORMAL DRIVE MODE OR REVERSE. IN DOING SOME INVESTIGATING, APPARENTLY, THIS IS A COMMON ISSUE WITH FORD EXPLORERS. PARTICULARLY THE 2002 MODELS. THIS IS NOT ONLY DANGEROUS, BUT UNFAIR THAT FORD HAS NOT TAKEN RESPONSIBILITY FOR THIS VERY COMMON ISSUE. I'M AWAITING AN ANSWER ON WHAT EXACTLY IS WRONG WITH MY EXPLORER. BASED ON MY RESEARCH, THE MOST COMMON CAUSE IS A FAULTY TRANSMISSION. I HOPE FORD DOES THE RIGHT THING AND INSTITUTES A RECALL TO THE MANY DRIVERS OF 2002 EXPLORERS THAT HAVE SUFFERED WITH THIS PROBLEM. *TR
Power train, Jul 24, 2010
I HAVE A 2002 FORD EXPLORER I WAS DRIVING DOWN THE HIGHWAY WHEN I NOTICED THE OVERDRIVE LIGHT FLASHING. THEN THE PASSENGER ASKED ME IF I COULD SMELL TRANSMISSION FLUID AND I HAD SAID YES. THIS ENDED UP COSTING ME $2800 AND MY MECHANIC TOLD ME THAT THE TORQUE CONVERTER WAS FAILING AND SENSE HE HAD IT APART HE SHOULD GO AHEAD AND REBUILD IT. *TR
Power train, Jul 23, 2010
2002 FORD EXPLORER TRANSMISSION FAILS. *TR
Power train, Jul 20, 2010
DRIVING MY 2002 FORD EXPLORER WITH MY DAUGHTER IN THE BACK SEAT, WHEN THE O/D LIGHT STARTS TO FLASH AND THE CAR BECOMES JERKY, THEN LOCKS INTO GEAR SO I BRAKE PUT IT IN PARK AND TURN THE CAR OFF FOR A BIT , TURN IT BACK ON AND THE O/D FLASHES AND I MANAGED TO MAKE IT HOME BUT ONLY GOING SLOW AS CONCERNED FOR THE SAFETY OF MYSELF AND MY CHILD. I LET THE CAR SIT FOR A FEW DAYS AND HAD MY HUSBAND DRIVE IT AROUND THE NEIGHBORHOOD AND IT GOT STUCK IN GEAR ON HIM TWICE. WE'VE CONTACTED A TRANSMISSION SHOP AND THEY SAID IN THIS YEAR AND MODEL IT HAS BEEN VERY COMMON FOR THE TRANSMISSION TO BE REBUILT OR REPLACED. THEY RECOMMENDED TO HAVE IT REPAIRED AND EITHER PUT THE CAR UP FOR SALE OR REPAIR IT AS IN THEIR EXPERIENCE THEY TRANSMISSION WILL PROBABLY GO AGAIN IN A YEAR OR 2.. FORD NEED TO ACCEPT THAT THERE IS AN ISSUE AND OWN UP TO THEIR MISTAKES, THEY CAN'T EXPECT PEOPLE TO JUST SIT BACK AND ACCEPT IT. SOMETHING NEEDS TO BE DONE ABOUT THE ISSUE, IF I WAS TRAVELING AT A HIGHER SPEED WHEN IT FIRST STARTED WHO KNOWS WHAT COULD OF HAPPENED, I MAY NOT OF BEEN ABLE TO KEEP CONTROL AND SOMETHING SERIOUS MAY OF BEEN BUT LUCKILY IT WASN'T, BUT WE DON'T WANT TO READ ABOUT THE PERSON WHO COULDN'T KEEP CONTROL. *TR
Power train, Jul 19, 2010
O/D AND CHECK ENGINE LIGHT GOES ON EVERY TIME I DRIVE MY SUV EVERYTIME I DRIVE IT AS SOON AS THE LIGHTS GO ON THE SUV TANS STARTS ACTING UP AND SLIP CALLED FORD DEALER AND THEY SAID THIS IS A COMMON PROBLEM BUT, HAS NOT BEEN RECALLED SO IT WILL COST 2,300.00 PLUS LABOR. I AM A SINGLE MOTHER OF 4 . WHY IS IT THERE ARE SO MANY COMPLAINTS ABOUT THIS YEAR FORD BUT, YET NOTHING IS BEING DONE ABOUT IT ! I JUST BOUGHT THIS CAR IN FEB OF THIS YEAR AND NOW I AM HAVING THIS PROBLEM ! I PULLED OUT FROM A GREEN LIGHT THE OTHER DAY AND ALMOST GOT IN AN ACCIDENT BECAUSE THE TRANS SLIPPED HAD ALL 4 CHILDREN IN THE CAR WITH ME ! MAYBE I SHOULD NOT BE DRIVING THIS BUT,THIS IS MY ONLY VEHICLE AND I NEED TO DRIVE ! AND I SURE DON'T HAVE THE MONEY TO REPLACE THIS PROBLEMS THAT EVERYONE IS HAVING BESIDES ME ! FORD NEEDS TO FIX THERE PROBLEM BEFORE SOMEONE ENDS UP IN A REALLY BAD ACCIDENT OR ENDS UP WORSE DEAD !! *TR