2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints: structure
532 reports, newest first. Show all
Structure, May 16, 2003
HATCH WINDOW EXPLODED AND SHATTERED UPON ROUTINE CLOSING. HAD CAR INTO DEALER 3 PREVIOUS TIMES TO REPAIR HATCH, THE STRUT HAD BROKE OFF ON THE LEFT SIDE EACH TIME. EACH TIME THEY REPAIRED OR REPLACED THE STRUT AND SAID IT WOULD BE FINE. THIS TIME THE STRUT DID NOT JUST BREAK OFF THE WHOLE WINDOW EXPLODED AND LEFT CUTS ON THE CONSUMERS HANDS AS WELL AS GLASS IN HER MOUTH AND ON HER HEAD. *NLM PE04045.PCO DOB IS 06/02_061704_JF
Structure, Apr 22, 2003
THE VEHICLE WAS ON ITS FOURTH REPAIR FOR REAR THE GLASS LIFT GATE, THE BRACKET DOOR FAILED TO STAY UP. *JB *JB
Suspension, Electrical system, Structure, Apr 7, 2003
THE VEHICLE'S TAILGATE GLASS EXPLODED WHILE THE CONSUMER ATTEMPTED TO CLOSE IT. THE DEALER WAS NOTIFIED. *NLM BROKEN LIFTGATE GLASS AND WIPER MOTOR AND ARM WERE REPLACED. THERE WERE SQUEAKS WHEN GOING OVER BUMPS. SWAY BAR BUSHINGS REPLACED. IGNITION SWITCH HARD TO INSERT KEY AT TIMES. CYLINDER AND TUMBLER REKEYED. BOTTOM DOOR MOLDING (PASSENGER SIDE) PEELING OFF. RUBBER GROMMET ON ANTENNA BASE OFF. RESECURED RUBBER GROMMET FOR ANTENNA BASE. *TT PE04045_PCO
Structure, Apr 1, 2003
THE DOORS WERE NOT PROPERLY SEALED WHICH COULD HAVE RESULTED FROM DEBRIS ON THE ROAD/WEATHER CORRODING THE DOOR. THE MANUFACTURER AND DEALERSHIP WERE AWARE OF THE PROBLEM, BUT DID NOT HAVE A REMEDY. *JB....*AK
Structure, Mar 6, 2003
THE PASSENGER DOOR HANDLE WAS REPLACED 4 TIMES, THE MECHANIC STATED THE GEAR INSIDE HANDLE WAS MADE OF PLASTIC AND WOULD CONTINUE TO BREAK. *JB
Structure, Feb 24, 2003
HYDROLIC ARM ON BACK LIFTGATE BROKE 3 TIMES AND WAS "REPAIRED" AT THE DEALER. IT BROKE A FOURTH TIME, CAUSING THE LIFTGATE WINDOW TO SHATTER. THE GLASS AND FALLING DEBRIS SCRATCHED THE PAINT ON THE BACK OF THE VEHICLE. I WAS NOT NOTIFIED OF THE RECALL. PE04045.PCO
Power train, Electrical system, Structure, Other or unspecified, Feb 10, 2003
LAST SUMMER (JULY 2002) DURING A MILITARY MOVE FROM GA TO AZ I NOTICED THAT MY WINDSHIELD HAD A LARGE PIECE OF GLASS MISSING ON THE OUTTER RIGHT EDGE THAT YOU COULD NOT SEE UNTIL YOU ACTUALLY GOT RIGHT UP ON THE WINDSHIELD. PART OF IT WAS VISIBLE TO AND PART OF IT WAS HIDDEN BEHIND THE RUBBER SEAL THAT IS AROUND THE WINDSHIELD. THIS WINDSHIELD WAS ACTUALLY INSTALLED WITH THIS PIECE MISSING FROM IT WHEN THE VEHICLE WAS BUILT AND SENT TO THE DEALERSHIP. ALSO, THE REAR GLASS HATCH, GAS SHOCK TWISTED FROM ITS ORIGINAL POSITION AND CAUSED THE WINDOW TO BE OFF CENTER BY ABOUT AN INCH OR MORE. AFTER FIXING IT THREE TIMES IT HAD TO BE REPLACED. BOTH OF THESE PROBLEMS (THE WINDSHIELD AND THE GAS SHOCK) HAVE BEEN FIXED BY MY LOCAL DEALERSHIP AND THUS FAR HAVE HELD UP. THERE ARE NUMEROUS OTHER COMPLAINTS THAT I HAVE ON MY VEHICLE THAT INCLUDE THE ELECRICAL SYSTEM NOT FUNCTIONING PROPERLY. WHEN YOU TURN THE TRUCK ON SOMETIMES ALL THE DASHBOARD LIGHTS STAY ON AS WELL AS THE INTERIOR LIGHTS AND YOU HAVE TO SHUT THE TRUCK DOWN AND BACK ON SEVERAL TIMES IN ORDER FOR THEM TO GO OUT. THE TRUCK WILL SOMETIMES STALL AT TAKE OFF OR WILL LURCH WHILE SHIFITING INTO A HIGHER GEAR AND HAS TOTALLY SHUT DOWN WHILE DRIVING DOWN THE ROAD ON A FEW OCCASIONS. THE TRIM PAINT ON THE DOORS, BOTH FRONT AND PASSENGER HAS FADED THERE ARE RUSTED SPOTS IN THE PAINT ON THE TOP OF THE VEHICLE, AND THE HOOD HAS A VERY BAD ORANGE PEEL EFFECT ON IT WITH GRIT IN THE PAINT. THE LEFT REAR SPEAKER HAS BUSTED AND THE PANEL ON THE REAR HATCH BELOW HAS BROKEN LOOSE AS WELL AS ONE OF THE PLASTIC BRACKET COVERS ON THE BACK OF THE PASSENGER SEATS. PE04045.PCO
Structure, Jan 27, 2003
THERE IS A HOLE IN FRONT BUMPER WITHOUT A FRILL OR GUARD WHICH ALLOWS DEBRIS TO ENTER DIRECTLY INTO VEHICLE'S RADIATOR.*AK
Structure, Dec 18, 2002
NHTSA#14956-01-F-061-000 LIFT GATE GLASS BRACKET ROTATION OF THE BRACKET COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS: CONSUMER STATES HAS THE SAME PROBLEM. DEALER HAS BEEN NOTIFIED PROVIDE FURTHER INFORMATION. TS PE04045.PCO
Structure, Nov 24, 2002
FOR THE SECOND TIME IN FIVE MONTHS, OUR EXPLORER BACK WINDOW HAS EXPLODED, PROPELLING THE WINDOW AND FRAME OUTWARDS, CUTTING MY HUSBANDS ARM AND SHATTERING GLASS ALL OVER HIM AND OUR DRIVEWAY. HE WAS ATTEMPTING TO CLOSE THE TAILGATE, BUT WAS JUST LOWERING IT, WHEN IT FLEW OUT. THE SECOND TIME IT HAPPENED, MY DAUGHTER WAS RAISING THE WINDOW, AND THE FRAMEAND WINDOW FLEW OUT, AND HIT HER IN THE SHOULDER, SPRAYING GLASS ALL OVER HER AND IMBEDDING IT IN THE GARAGE WALL. THIS TIME THEY REPLACED THE BACK WINDOW WITH A COMPLETELY RE-DESIGNED WINDOW. WE TOLD THEM THAT WE DIDN'T WANT THE VEHICLE, BECAUSE WE WERE AFRAID OF FUTURE INJURIES AND WERE ACTUALLY AFRAID TO USE IT AGAIN. THE DEALERSHIP TOLD US IT WAS FORDS PROBLEM, NOT THEIRS, AND SO WE CONTACTED FORD. A REPRESENTATIVE PROMISED TO GET BACK WITH US AFTER TAKING THE INFORMATION, BUT IT HAS BEEN OVER A WEEK NOW, AND WE HAVE NOT BEEN CONTACTED. I HOPE YOU CAN HELP US RESOLVE THIS MATTER. SHOULD THERE HAVE BEEN A RECALL? DT PE04045.PCO
Structure, Sep 4, 2002
REAR LIFTGATE WINDOW EXPLODED IN CONSUMER'S FACE. CAUSE OF EXPLOSION IS UNKNOWN. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK PE04045.PCO
Structure, Aug 22, 2002
MY 2002 FORD EXPLORER WAS PARKED IN AN PARKING LOT. RETURNING TO MY VEHICLE I ATTEMPTED TO PLACE MY ITEMS IN THE BACK SECTION OF THE SUV. WHEN THE HATCHBACK GLASS WAS OPENED THE LEFT HYDRAULIC LIFT SHATTERED THE REAR GLASS. THE GLASS FLEW TO THE FRONT SEAT AND 3 CAR LENGHTS OVER IN THE PARKING LOT. I HAVE TAKEN MY FORD EXPLORER BACK TO THE DEALER FOR REPAIR. THE REAR PANEL WAS REPLACED AFTER A MONTH OF WAITING. BUT WE ARE NOT FULLY SATISFIED WITH THE REPAIR. FORD IS SENDING REPLACEMENT PARTS THAT HAVE A BULDGE IN THE BOTTOM PANELS. SO WE ARE ON OUR SECOND DOOR AND STILL WAITING FOR A NEW PART. IT IS FUNNY HOW YOU CAN BUY A VEHICLE THAT LOOKS PERFECT BUT WHEN YOU GET REPLACEMENT PARTS YOU GET LESS THAN PERFECT. MAKES ME WONDER IF THEY ARE REALLY FORD PARTS. THE PROBLEM WE ARE HAVING NOW IS NOT A SAFETY HAZARD, BUT IT IS A VALUE PROBLEM IF WE SELL OR TRADE IN THIS SUV. WE ARE VERY DISAPPOINTED THAT AFTER BUYING THE VEHICLE WE WHERE NEVER TOLD OF THE RECALL. THIS PROBLEM WAS RECALLED IN APRIL OF 2001.*AK PE04045.PCO
Structure, Aug 22, 2002
WHILE OPENING THE REAR TOP HATCHBACK, THE REAR WINDOW EXPLODED IN MY WIFE'S FACE WHILE MY 4 YEAR OLD SAT IN THE REAR SEAT. MY WIFE RECEIVED MINOR SCRATCHES FROM THE FLYING GLASS. MY SON WAS SHAKEN BUT NOT INJURED AS THE SHATTERED GLASS FLEW APPX 15 FEET OUTWARD AND TO THE LEFT AND RIGHT. SINCE THE BOTTOM PANEL OF THE TOP HALF OF THE REAR GATE IS ONLY ATTACHED TO THE CAR BY THE GLASS AND THE DEFOGGER CABLE, THIS FOUR FOOT BY SIX INCH METAL PANEL SLAMMED TO THE GROUND JUST MISSING MY WIFE'S LEGS. I WAS IN THE HOUSE AT THE TIME AND HEARD WHAT SOUNDED LIKE A SMALL EXPLOSION WHEN IT BURST. IT WAS TERRIBLY FRIGHTENING TO MY WIFE AND SON. I BROUGHT THE CAR TO THE DEALER WHO AT FIRST TOLD ME THAT IT WAS NOT A WARRANTY ISSUE AND I SHOULD GO TO A GLASS REPAIR SHOP. I REFUSED AND ASKED THEM TO FIX IT AND INPECT THE WORK. THEY TOLD ME THEY HAD "ONLY" THREE OR SO REPORTED INCIDENTS OF BREAKAGE IN PAST YEAR AND THAT THE PREVIOUS RECALL NOTICES I RECEIVED FOR THE REAR WINDOW HAD NOTHING TO DO WITH WHAT HAPPENED. THEY SAID MY CAR WAS FINE AFTER IT WAS CHECKED FOR THE RECALL NOTICE TWO PREVIUOS TIMES PRIOR TO THIS INCIDENT. I AM WAITING FOR THE CAR TO BE REPAIRED.*AK PE04045.PCO
Structure, Aug 15, 2002
WHILE PARKED WITH REAR WINDOW OF LIFTGATE RAISED FOR ABOUT 30 MINUTES, IT WAS SHATTERED. OCCUPANT DID GET CUT BY PIECES FLYING OF GLASS. TEMPERATURE THAT DAY WAS ABOUT 70 DEGREES. A WITNESS SAW THE INCIDENT, AND TOLD THE OTHER PARTY THAT THE YOUNG LADY DIDN'T DO ANYTHING TO CAUSE THIS. GLASS/ASSEMBLY IS BEING ORDERED AND GLASS HAS BEEN MODIFIED. A FORD DEALERSHIP TOLD HER THAT THEY HAVE NEVER HEARD OF AN INCIDENT LIKE THIS. PLEASE DESCRIBE DETAILS. *AK PE04045.PCO
Power train, Electrical system, Visibility, Structure, Jul 24, 2002
MAIN COMPUTER MODULE MALFUNCTIONS, CAUSING OTHER MAJOR COMPONENTS, SUCH AS TRANSMISSION/ POWER WINDOW, AND DOORS NOT TO WORK. *AK
Electrical system, Structure, Jul 17, 2002
MOUNTING BRACKET ON GLASS LIFTGATE BECAME DETACHED FROM STRUT-LIFT MECHANISM JOINT UPON REACHING MAXIMUM EXTENSION CAUSING GLASS TO FALL ONTO MY HEAD. REPORTED TO DEALER BUT NOT REPAIRED/REPLACED DUE TO PARTS N/A. OFTEN HAVE DIFFICULTY TURNING IGNITION SWITCH AFTER INSERTING EITHER OF THE FACTORY KEYS. IT REQUIRES A "JIGGLING" MOTION TO ENGAGE AND TURN IGNITION. PE04045.PCO
Structure, Jun 6, 2002
WHILE OPENING MANUAL TAILGATE WINDOW GLASS EXPLODED, GLASS WAS THROWN INSIDE VEHICLE WITH SUCH FORCE THAT INTERIOR PANELS WERE SCRATCHED. PLEASE PROVIDE ADDITIONAL INFORMATION.*AK RE-EVAL TO BE VALID SINCE PE OPENING_PCO PE04045_PCO
Structure, May 10, 2002
CONSUMER STATES ATTEMPTED TO OPEN LIFTGATE TO UNLOAD GROCERIES WHEN THE LIFTGATE BLEW OUT CRASHING ON THE TOP OF THE ROOF OF THE TRUCK, SHATTERING THE GLASS TO THE LIFTGATE WINDOW. VEHCLE HAS BEEN SHOP FOR 14 DAYS. BODY ROOF WAS BADLY DAMAGED. *TT PE04045.PCO
Structure, Nov 20, 2001
COLLAPSE OF TAILGATE WINDOW/STRUCTURE ONTO MY HEAD WHILE I WAS IN THE PROCESS OF REMOVING GROCERIES FROM THE VEHICLE. I HAVE SUFFERED CERVICAL INJURIES AS A RESULT. *AK PE04045.PCO
Structure, Sep 3, 2001
THE REAR WINDOW PISTON SHATTERED THE GLASS IN BACK OF SUV. MY PASSENGERS STANDING BY WERE HIT WITH FLYING GLASS. SUPERFICIAL CUTS ONLY. THE DATE OF THIS INCIDENT WAS AUGUST 8TH. I'M WRITING THIS ON SEPTEMBER 3RD. WE STILL DON'T HAVE OUR CAR BACK.*AK PE04045.PCO
Structure, Aug 30, 2001
THE LEFT STRUT ON THE GLASS SECTION OF THE TAILGATE BROKE FREE AND SHATTERED THE REAR WINDOW. THE BROKEN GLASS COVERED MY HAIR AND MY CLOTHING, THIS IS POTENTIALLY VERY DANGEROUS AS THE GLASS COULD SHATTER INTO THE EYES OF SOMEONE CLOSING THE TAILGATE. *AK PE04045.PCO
Structure, Aug 20, 2001
01 1 010 000/LIFTGATE GLASS BRACKET; WHILE CLOSING TAILGATE BOTH BRACKETS BROKE AND CAUSED GLASS TO FALL ONTO CONSUMER. CONSUMER SUSTAINED CUTS AND BRUISES. DEALER WAS NOTIFIED, AND GIVEN APPOINTMENT FOR REPAIRS. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION ON THIS MATTER.*AK PE04045.PCO
Structure, Aug 14, 2001
WHILE OPENING REAR WINDOW, AND WITHOUT ANY INDICATION WINDOW POPPED OFF HINGE AND SHATTERED. DEALER HAS BEEN CONTACTED. *AK LEFT HAND HINGE APPEARED TO BE MISSING THREADS TO ENGAGE WITH BOLT FOR MOUNTING REAR WINDOW ASSEMBLY TO VEHICLE. *YH PE04045_PCO
Structure, Jul 28, 2001
FOUR HOURS AFTER NEW VEHICLE WAS COLLECTED FROM DEALER, GLASS TAILGATE EXPLODED ON BEING CLOSED GENTLY. COMPLETE REAR WINDOW SHATTERED WITH SUCH FORCE THAT METAL COMPONENTS OF THE DOOR WERE BADLY BENT AND SCRATCHED. GLASS WAS SCATTERED OVER A RADIUS OF 20 FEET, INCLUDING INTO THE BACK SEATS AND ONTO THE ROOF. MY RIGHT LEG WAS CUT IN THREE PLACES. LUCKILY, MY CHILDREN WERE NOT IN OR AT THE BACK AT THE TIME OF THE EXPLOSION. THE ENTIRE DOOR WAS REPLACED BY THE DEALER WITHIN FOUR BUSINESS HOURS. UNLESS RECALLED, THIS APPARENTLY COMMON DEFECT WILL RESULT IN SERIOUS INJURY. *AK PE04045.PCO
Structure, Jul 16, 2001
LEFT HYDRUALIC SUPPORT BRACKET FOR REAR WINDOW HAS BROKEN OFF THREE TIMES.*AK *SLC PE04045.PCO