2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints: suspension
445 reports, newest first. Show all
Suspension, Engine and engine cooling, Apr 14, 2003
TWO PROBLEMS. THERE IS A STRONG ROTTEN EGG SMELL IN MY EXPLORER. I HAD THE VEHICLE CHECKED WHILE UNDER WARRANTY, BUT WAS TOLD THERE WAS NO PROBLEM. SINCE THE WARRANTY EXPIRED THE SMELL HAS BECOME STRONGER. I HAD IT CHECKED, AND THE FORD SERVICE DEPARTMENT SAID IT WOULD COST $600 TO REPAIR. THE OTHER IS A SHIMMY AT 40 MILES PER HOUR. THE SERVICE DEPARTMENT JUST ROTATED AND BALANCED MY TIRES. I HAD THIS DONE A MONTH EARLIER AND IT DID NOT SOLVE THE PROBLEM. THE VEHICLE STILL SHIMMIES BADLY AT 40 MPH. *NLM
Suspension, Electrical system, Structure, Apr 7, 2003
THE VEHICLE'S TAILGATE GLASS EXPLODED WHILE THE CONSUMER ATTEMPTED TO CLOSE IT. THE DEALER WAS NOTIFIED. *NLM BROKEN LIFTGATE GLASS AND WIPER MOTOR AND ARM WERE REPLACED. THERE WERE SQUEAKS WHEN GOING OVER BUMPS. SWAY BAR BUSHINGS REPLACED. IGNITION SWITCH HARD TO INSERT KEY AT TIMES. CYLINDER AND TUMBLER REKEYED. BOTTOM DOOR MOLDING (PASSENGER SIDE) PEELING OFF. RUBBER GROMMET ON ANTENNA BASE OFF. RESECURED RUBBER GROMMET FOR ANTENNA BASE. *TT PE04045_PCO
Suspension, Mar 26, 2003
A THUMPING NOISE COULD BE HEARD FROM THE REAR OF THE VEHICLE WHILE DRIVING. *NLM *TS
Suspension, Mar 7, 2003
THE ENGINEERING OF THE SUSPENSION IS SUCH THAT THE TRUCK IS UNSAFE TO DRIVE ON ANYTHING BUT A STRAIGHT PERFECTLY SMOOTH ROAD. ANY DIPS, BUMPS, OR CURVES MAY CAUSE LOSS OF CONTROL.*JB
Suspension, Feb 20, 2003
THE LIFT GATE ON THE RIGHT SIDE SHOCK BROKE. *JB
Suspension, Engine and engine cooling, Electrical system, Latches/locks/linkages, Seats, Jan 20, 2003
I BOUGHT A 2002 EXPLORER ON MAY 23,2002. IN THE PAST 8 MONTHS, THE VEHICLE HAS BEEN TOWED IN BECAUSE IT WOUDN'T START--ACOMPUTER CHIP WAS REPLACED. MY A/C MADE A HIGH PITCH SQUEAL AND AFTER AT LEAST FIVE TIMES OF TRYING TO REPAIR THE EXISTING A/C CLUTCH, A NEW ONE WAS FINALLY PUT ON. MY FRONT END SUSPENSION HAS BEEN FIXED. MY MIDLIFT GATE CRACKED IN NOVEMBER AND A NEW ONE WAS PUT ON. I HAVE HAD DAILY PROBLEMS WITH THE DRIVER'S SIDE SEAT NOT FULLY GOING INTO POSITION WHEN I START MY TRUCK AND THIS PROBLEM HAS NOT BEEN FIXED AS THE SERVICE DEPT. THAT I DEAL WITH NEVERS SEEMS TO BE ABLE TO SEE THE PROBLEM. FUNNY HOW IT DOES IT EVERY DAY FOR ME, THOUGH. MY BLINKERS WILL SOMETIMES STICK AND STAY ON WITHOUT BLINKING--THIS ALSO HAS NOT BEEN FIXED. AT THE BEGINNING OF JANUARY,2003, ON THE WAY HOME FROM A TRIP, MY HUSBAND AND I NOTICED THAT EVERY TIME WE SLOWED THE TRUCK DOWN, THERE WAS A BLAST OF AIR FROM THE UPPER VENTS IN THE VEHICLE. THIS HAPPENED NO MATTER WHAT SETTING WE HAD IT IN (IE. DEFROST OR FLOOR VENTS). THIS PAST THURSDAY, JAN.16, THE SUSPENSION WAS REPAIRED AND SUPPOSEDLY THE HEATING SYSTEM WAS AS WELL. NOW THE AIR DOESN'T SEEM TO LEAK OUT THE TOP VENTS, BUT CONTINUOSLY COMES OUT OF THE FLOOR VENT, NO MATTER WHAT SETTING THE HEAT IS ON. I HAVE A RENTAL VEHICLE ONCE AGAIN, WHILE THEY KEEP THE VEHICLE OVERNIGHT TONIGHT TO SEE IF THEY CAN HOPEFULLY FIX THIS PROBLEM. NEEDLESS TO SAY, WE ARE CURRENTLY CHECKING INTO THE LEMON LAW FOR OUR STATE!!!
Suspension, Nov 21, 2002
MY VEHICLE HAS CRACKING NOISES BEHIND DASH THAT UNCOVERED 15 PLUS BOLTS LOOSE, IN ADDITION THE DEALER NOTICED THE FRAME LOOKED RACKED. THE TAILGATE AND FRONT END ASSEMBLY SHOW SIGNS THAT POTENTIAL STRUCTURAL PROBLEMS PER SERVICE MGR. FORD CONTINUES TO NOT RETURN CALLS AND GIVING A RUN AROUND TO DEALER. ENGINEER FROM FORD DISAVOWED PROBLEMS STATING WITHIN SPEC'S. DEALER HAS CONTINUED TO ARGUE BACK DUE TO VISUAL EVIDENCE OF DEFECTIVE VEHICLE. DT
Steering, Suspension, Oct 23, 2002
THE OWNER STATES THE TRUCK VEERS SIDE TO SIDE NOT KEEPING A STRAIGHT DIRECTION. TRUCK HAS BEEN IN THE SHOP (8) TIMES FOR PROBLEMS WITH THE FRONT END OR STEERING. THE PARTS WERE REPLACED FROM THE STEERING TO A COMPLETE RACK AND PINION WITH DEFECT NOT CORRECTED. AN ENGINEER FROM FORD HAS ALSO INSPECTED THE TRUCK AND HAS DETERMINED THAT THERE IS NO PROBLEM. THE DEALERSHIP IS INSISTING THAT THE OWNER COME PICK THE TRUCK UP IN THE SAME CONDITION. PLEASE DESCRIBE DETAILS. MR
Suspension, Aug 9, 2002
THE TRUCK SEEMS TO HAVE A TIRE OR SUSPENSION HOP/CHATTER AFTER GOING OVER ALL TYPES OF BUMPS SMALL/LARGE, DOES NOT SEEM AFFECT THE DRIVING ABILITY BUT IT IS ANNOYING. ANY OTHER COMPLAINTS ON THIS? ALSO COULD NOT LOCATE DOT # ON TIRES, MADE IN CANADA.*AK
Suspension, Jul 24, 2002
WHEN DRIVING AT 50MPH AND HIGHER VEHICLE VIBRATES UNCONTROLLABLY. DEALER HAS INSPECTED VEHICLE SEVERAL TIMES, AND PROBLEM STILL EXISTS. *AK CONSUMER STATES THAT FORD BOUGHT BACK VEHICLE AND REFUNDED HIS MONEY. *SLC
Suspension, Jul 14, 2002
WHILE MAKING A RIGHT TURN OR DRIVING OVER BUMPY ROAD, STEERING COLUMN AND ENTIRE CAR BEGINS TO SHAKE SIGNIFICANTLY AT SPEEDS OF 55MPH AND CONTINUE UNTIL PULLING OFF THE ROAD OR SLOWING TO 20MPH.SHAKING CONTINUED FOR 2 MILES UNTIL BEING ABLE TO SAFELY PULL OFF THE HIGHWAY.STEERING WHEEL SHAKING IS SIGNIFICANT ENOUGH TO SHAKE DRIVERS ENTIRE BODY! THIS HAS HAPPENED ON 3 OCCASIONS. STEERING COLUMN SHAKING HAPPENS FREQUENTLY( DAILY) WHILE MAKING L AND R TURNS AT LOW SPEEDS.COLUMN NOISE IS HEARD ALSO. AT
Suspension, May 9, 2002
WHEN STOPPED AT LIGHT VEHICLE MAKES A LOUD HUMMING NOISE. TOOK TO DEALER, AND DEALER COULDN'T IDENTIFY PROBLEM. *AK
Suspension, May 7, 2002
WHILE DRIVING VEHICLE IS MAKING A LOUD NOISE IN THE REAR DUE TO SUSPENSION PROBLEMS. DEALER CONTACTED. PLEASE ADD VIN. *AK
Suspension, Mar 15, 2002
CONSUMER STATES THERE IS A SQUEAKING NOISE ORIGINATING POSSIBLY FROM THE SUSPENSION WHEN DRIVING OVER SPEED BUMPS OR UNEVEN ROAD SURFACES AT HIGHWAY SPEEDS ESPECIALLY DURING WINDY CONDITIONS. ALSO THERE IS VIBRATION OCCURRING IN THE FRONT END OF THE VEHICLE AT 55 - 60 MPH. THE VIBRATION CAN ALSO BE FELT FROM UNDER THE SEAT WITH THE WINDOWS ROLLED UP. *TT
Suspension, Mar 4, 2002
WHILE DRIVING, VEHICLE WOULD SWAY LEFT TO RIGHT. TOOK TO DEALER AND DEALER INDICATED REAR AXLE TUBE WAS CROOKED.*AK CONSUMER TEST DROVE VEHICLE PRIOR TO PURCHASE AND HAD MENTIONED TO DEALER THAT THE VEHICLE SWAYED AT HIGHWAY SPEEDS. *TT
Steering, Suspension, Feb 3, 2002
THIS VEHICLE HAS BEEN IN THE SERVICE DEPARTMENT 3 TIMES SINCE SEPTEMBER 2001. THE STEERING COLUMN HAS BEEN REPLACED, THE WHEEL BEARINGS HAVE BEEN REPLACED(THIS WAS SUPPOSE TO ELIMINATE STEERING COLUMN RATTLE) AND THE LOWER CONTROL ARM HAS BEEN REPLACED. I STILL HEAR AND FEEL A METALLIC RATTLE COMING FROM THE STEERING COLUMN. IN MY REVIEW OF YOUR WEBSITE OTHER 2002 EXPLORER OWNERS ARE EXPERINCING THE SAME PROBLEM. I HAVE TALKED TO AT LEAST THREE OTHER OWNERS THAT HAVE THE SAME PROBLEM. MY DEALER HAS DONE EVERYTHING RECOMMENDED BY FORD, BUT NOTHING HAS SOLVED THE PROBLEM. FORD IS "WORKING ON IT". THEY HAVE BEEN WORKING ON IT SINCE SEPTEMBER 2001. MY SAFETY CONCERN IS THIS. IF SOMETHING IS LOOSE THAT IS CAUSING THIS NOISE IT HAS TO BE PROGRESSING. WHAT WILL HAPPEN AFTER MORE MILEAGE BUILDS ON THIS VEHICLE? WILL I BE DRIVING DOWN THE HIGHWAY ONE DAY AND LOSE CONTROL DUE TO STEERING FAILURE? THERE IS TO MUCH SMOKE HERE FOR THAT NOT TO BE FIRE SOONER OF LATER BY MY EXPLORER OR SOME OTHER OWNER. HOW LONG DOES IT TAKE FOR A COMPANY THE SIZE OF FORD TO SOLVE A PROBLEM?*AK
Suspension, Jan 23, 2002
WHILE DRIVING AND MAKING A LEFT TURN THE VEHICLE VIBRATES VIOLENTLY AS IF IT WAS NOT IN GEAR. DRIVERS FEELS VERY UNSAFE DRIVING. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
Steering, Suspension, Dec 11, 2001
WHILE DRIVING, CONSUMER WOULD HEAR POPPING NOISES COMING FROM LEFT FRONT END. DEALER CHECKED AND REPAIRED STEERING COLUMN SHAFT. PROBLEM NOT RESOLVED. TOOK BACK TO DEALER AND STEERING COLUMN ASSEMBLY WAS REPLACED. HOWEVER, PROBLEM WAS NOT RESOLVED. TOOK VEHICLE BACK AGAIN AND LEFT FRONT WHEEL HUB ASSEMBLY WAS REPLACED. NOTHING SOLVED THE PROBLEM. MECHANIC COULD NOT RESOLVE IT. MANUFACTURER IS WORKING ON SOLUTION.*AK *JB
Steering, Suspension, Dec 5, 2001
THE VEHICLE HAS BEEN IN THE SERVICE DEPT 3 TIMES SINCE PURCHASE ON 8/01. UPPER & LOWER STEERING SHAFT HAS BEEN REPLACED ON 9/14/01. THE FRONT END RATTLES WHEN I AM OPERATING THE VEHICLE OVER NORMAL TERRAIN. STEERING WHEEL HAS A POPPING FEEL WHEN I GO OVER A BUMP OR TURN RIGHT, FEELS LIKE TH E CAR IS GOING OUT OF CONTROL (AT SLOW SPEED). THE VEHICLE WILL BE BACK AT FORD ON 12/6/01 FOR FURTHER TESTING TO DETECT/CORRECT THESE PROBLEMS. AFTER LOOKING AT YOUR WEBSITE, I HAVE DISCOVERED SIMILAR COMPLAINTS EXIST. I WILL TAKE COPIES WITH ME TO THE DEALERSHIP SUPERVISOR TODAY.*AK
Suspension, Tires, Jul 3, 2001
WHENEVER VEHICLE HITS A BUMP IT'S HARD TO CONTROL, GOES ALL OVER ROAD. CONTACTED DEALERSHIP, BUT DEALER REFUSED TO LOOK AT VEHICLE.*AK CONSUMER HAS REPLACED THE MICHELIN TIRES AT THEIR COST, P235/70R16, DOT E20291511, VEHICLE AND TIRES ONLY HAD 470 MILES. *SLC