2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints: vehicle speed control
181 reports, newest first. Show all
Vehicle speed control, Jul 31, 2023
The contact owns a 2002 Ford Explorer Sport Trac. The contact stated that after parking the vehicle, the following day it was discovered that the cruise control switch located on the steering wheel had overheated and melted. The cause of the failure was not yet determined. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in NHTSA Campaign Number: 09V399000 (Vehicle Speed Control). The contact stated that the vehicle had experienced the failure listed in the recall. The local dealer was not contacted. The failure mileage was 120,000.
Vehicle speed control, Mar 30, 2022
The contact owns a 2002 Ford Explorer. The contact stated while entering the highway at approximately 45 MPH and accelerating to overtake the next vehicle, the accelerator pedal went to the floorboard however, the vehicle did not respond. The contact was able to pull over safely off the highway. There were no warning lights on the instrument panel. The contact stated that the failure was related to NHTSA Campaign Number: 00V422000 (Vehicle Speed Control). The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure but did not assist. The approximate failure mileage was 115,000.
Power train, Electrical system, Vehicle speed control, Nov 27, 2020
THE ISSUES THAT I'M HAVING IS THE EXHILARATION (PICKING UP SPEED) ON A PUBLIC STREET AS WELL AS IN THE EXPRESSWAY IT HESITATES TO DO SO. WHEN THE VEHICLE IS PARKED AND I GO TO SWITCH GEARS IT DOES NOT WANT TO SWITCH. THE GAUGE INDICATOR COMES ON AND THE GAS IDLE BE STUCK ON EMPTY WHEN IT HAS A FULL TANK OF GAS. WHILE THE VEHICLE IS IN MOTION THE RADIO VOLUME GOES UP AND DOWN ON ITS OWN. AND THE VEHICLE DID NOT WANT TO START FOR ME ONE DAY THE VERY NEXT DAY IT STARTED RIGHT ON UP (LIKE IT WANT TO START BUT DIDN'T CATCH). ALL OF THIS STARTED HAPPENING AT THE BEGINNING OF OCTOBER 2020
Vehicle speed control, May 29, 2018
VEHICLE ACCELERATED TO MAXIMUM RPM'S ON A CITY STREET AND WOULD NOT STOP, EVEN AFTER BRAKE APPLIED. TRIED DOWNSHIFTING, WOULD NOT WORK. RAN THROUGH A RED LIGHT, FORTUNATELY NO ONE WAS IN FRONT OF US OR GOING THE OTHER DIRECTION. HAD TO PUT IT INTO NEUTRAL AND TURN THE KEY OFF TO GET IT TO STOP. MERGED OVER AND PARKED. WHEN RESTARTED, RPM'S STILL AT MAXIMUM UNTIL HOOD WAS OPENED AND THROTTLE CABLE WAS MOVED AROUND. SCARY SITUATION AS WON'T DRIVE IT UNTIL IT IS FIXED. APPOINTMENT SCHEDULED WITH MECHANIC. SHOULD HAVE BEEN A RECALL ON THIS WITH AS MANY COMPLAINTS AS I HAVE READ ABOUT WITH THIS VERY SITUATION. WE COULD HAVE KILLED SOMEONE OR BEEN KILLED.
Power train, Vehicle speed control, Sep 20, 2017
OD LIGHT FLASHING, REBUILDS TRANSMISION AND NOTHING CHANGE, I SEE A LOT OF COMPLAINS ABOUT THIS PROBLEMS ON EXPLORERS, RANGERS AND MUSTANGS
Vehicle speed control, Jul 6, 2017
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. ON SEVERAL OCCASIONS, WHILE DRIVING, THE 4WD AUTO HIGH OR LOW FAILED TO OPERATE. WHILE ACCELERATING, THE CONTACT ATTEMPTED TO USE THE CRUISE CONTROL AND, ALTHOUGH THE GREEN CRUISE CONTROL INDICATOR ILLUMINATED, THE VEHICLE FAILED TO ENGAGE. A DEALER WAS NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 108,742.
Vehicle speed control, Jun 5, 2017
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE INDEPENDENTLY ACCELERATED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Vehicle speed control, Dec 1, 2016, crash
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE DRIVING 50 MPH, THE ACCELERATOR PEDAL SEIZED WITHOUT WARNING. THE VEHICLE'S SPEED INCREASED UP TO 90 MPH AND CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DEPLOYED. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED INJURIES TO THE HEAD AND NECK, WHICH DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS TOWED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 139,514.
Vehicle speed control, Jun 14, 2016
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 50 MPH WITH THE CRUISE CONTROL ACTIVATED, THE VEHICLE WOULD NOT DISENGAGE FROM THE CRUISE CONTROL WHILE DEPRESSING THE BRAKE PEDAL. THE VEHICLE SPONTANEOUSLY ACCELERATED TO 70 MPH, THE EMERGENCY BRAKE DID NOT WORK, AND THE CRUISE CONTROL WAS STILL ACTIVE. THE VEHICLE WAS SHIFTED INTO PARK AND PULLED INTO A PARKING LOT. THE VEHICLE WAS LEFT THERE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.
Electrical system, Vehicle speed control, Electronic stability control (ESC), May 16, 2016, crash
MY POWER STEERING STUCK CAUSED A WRECK!!
Vehicle speed control, Dec 4, 2015, crash
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE PULLING INTO A PARKING SPACE AT A VERY LOW RATE OF SPEED, THE VEHICLE SUDDENLY EXPERIENCED UNINTENDED ACCELERATION AND SURGED FORWARD BEFORE CRASHING INTO A BUILDING. THE DRIVER SUSTAINED INJURIES TO THE LEFT ARM, HIP, HEAD, AND NECK. MEDICAL ATTENTION WAS NOT RECEIVED. A POLICE REPORT WAS FILED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 47,000.
Air bags, Vehicle speed control, Dec 3, 2015, crash
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. WHILE PULLING INTO A PARKING SPACE AT A VERY LOW RATE OF SPEED, THE VEHICLE SUDDENLY EXPERIENCED UNINTENDED ACCELERATION, SURGED FORWARD, AND CRASHED INTO A BUILDING. DURING THE CRASH, THE FRONT END OF THE VEHICLE SUSTAINED SIGNIFICANT DAMAGE; HOWEVER, THE AIR BAGS DID NOT DEPLOY. THE DRIVER SUFFERED INJURIES TO THE LEFT ARM AND HIP, HEAD, AND NECK. MEDICAL ATTENTION WAS RECEIVED AND A POLICE REPORT WAS FILED. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 47,000.
Air bags, Vehicle speed control, Jul 23, 2015, crash
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE TRAVELING LESS THAN 5 MPH, THE VEHICLE'S THROTTLE BECAME STUCK WITHOUT WARNING WHICH CAUSED THE VEHICLE TO ACCELERATE TO A SPEED ABOVE 40 MPH. THE VEHICLE CRASHED THRU A FENCE AND INTO THE REAR OF A MOTOR HOME CAUSING THE FRONT DRIVER'S SIDE TIRE TO FRACTURE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V399000 (VEHICLE SPEED CONTROL). THE CONTACT SUSTAINED WHIPLASH, NECK AND BACK PAINS FROM THE FAILURE. A POLICE INCIDENT REPORT WAS FILED AND THE VEHICLE WAS TO BE TOWED TO A YARD UNTIL IT WOULD BE ABLE TO GET INSPECTED AND DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE MILEAGE WAS 194,000.
Suspension, Vehicle speed control, Apr 6, 2015, fire
I GOT A KNOCK ON MY DOOR BY THE FIRE DEPARTMENT TELLING ME THAT MY CAR SET ON FIRE I FILED A CLAIM WITH MY INSURANCE AND THEY TOLD ME TO FILE A CLAIM WITH FORD BECAUSE THEY HAVE REASON TO BELIEVE IT WAS THE CRUISE CONTROL BUTTON THAT SET THE CAR ON FIRE . *TR
Vehicle speed control, Mar 23, 2015, fire
DISPATCHED FOR CAR FIRE INSIDE GARAGE. 1213 ARRIVED AND REPORTED THE CAR WAS OUTSIDE, NEXT TO THE HOUSE, AND THE SIDING ON THE HOUSE WAS MELTING. 1281 ARRIVED AND ASSUMED COMMAND AT [XXX]. FIRE WAS NOW EXTENDING UP THE EXTERIOR OF THE NORTH SIDE OF THE STRUCTURE. A 2ND ALARM WAS REQUESTED AND CONSUMERS ELECTRIC WAS REQUESTED TO THE SCENE. THE HYDRANT WAS DIRECTLY BEHIND 1213. 1213 CREW STRETCHED A 1.75" HAND LINE AND EXTINGUISHED THE FIRE ON THE EXTERIOR OF THE HOUSE AND THEN THE FIRE INSIDE THE VEHICLE. 1211 CREW ASSISTED 1213 AND ALSO MADE CONTACT WITH ALL OCCUPANTS AND VERIFIED THAT NO ONE WAS INJURED OR MISSING. 1212 CREW WAS ASSIGNED INTERIOR. VENTILATION WAS REQUESTED FOR THE INTERIOR. FM HENSON ARRIVED ON SCENE AND WAS ASSIGNED INVESTIGATION. COMSTOCK 911 CREW WAS ASSIGNED TO ASSIST 1213 WITH EXTERIOR OVERHAUL. 1212 CONDUCTED INTERIOR OVERHAUL AND REPORTED MINOR CHARRING AT PEAK OF ROOF ON THE INTERIOR BUT NO FURTHER EXTENSION. EXTERIOR OVERHAUL WAS COMPLETED. FM HENSON DETERMINED THAT THE FIRE STARTED IN THE ENGINE COMPARTMENT NEAR THE FIREWALL AND MORE TOWARDS THE DRIVER SIDE. THIS VEHICLE HAS AN OPEN RECALL FOR A SPEED CONTROL DEACTIVATION SWITCH FIRE HAZARD. *TR
Vehicle speed control, Jan 23, 2015
TL*THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.
Steering, Air bags, Vehicle speed control, Service brakes, Dec 16, 2014, crash, fire
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE IN REVERSE, THE VEHICLE ACCELERATED INDEPENDENTLY. ADDITIONALLY, THE BRAKE PEDAL WAS DEPRESSED BUT FAILED TO RESPOND AND THE STEERING WHEEL SEIZED. AS A RESULT, THE VEHICLE CRASHED INTO TREES THEN WENT FORWARD INDEPENDENTLY CRASHING INTO SHRUBS, A FENCE, AND A BUILDING. IN ADDITION, THE AIR BAGS FAILED TO DEPLOY AND SMOKE STARTED TO EMIT FROM THE FRONT OF THE VEHICLE. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED BRUISE AND NECK AND HEAD INJURIES THAT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.
Vehicle speed control, Dec 12, 2014, crash
DROVE CAR TO TIRE DEALER FOR WHEEL ALIGNMENT. PARKED AND LEFT FOR THEM TO WORK ON. THE NEXT DAY,DEC 10,2014, THE SERVICE TECH DROVE THE CAR FOR A TEST RIDE TO CHECK THE ALIGNMENT BEFORE HE ADJUSTED. HE THEN DROVE INTO THE BAY AND APPLIED FOOT PRESSURE TO THE GAS PEDDLE TO GET ONTO THE ALIGNMENT RAMP. THE PEDDLE STUCK AT HIGH RPMS , 4000+, . AS SUCH THE CAR RAN OFF OF THE RAMP , HE APPLIED BRAKES, TO NO AVAIL, SHUT CAR OFF AT SAME TIME. WHICH STOPPED THE CAR, BUT NOT BEFORE IT CRASHED INTO THE ALIGNMENT MACHINE AND TIRES. CAR WAS HUNG UP ON PART OF THE RAMP HAD TO BE JACKED OFF OF RAMP. FRONT BUMPER DAMAGED, CROSS MEMBER UNDER TRANS PAN BENT, LEFT RARE LOWER CONTROL ARM BENT..TIRE DEALER HAS SENT THE CAR TO FORD DEALER, ON DEC 11,2014 I SPOKE WITH FORD DEALER AND THE HAVE NEVER HAD A PROBLEM LIKE THIS BEFORE. TOLD HIM OF YOUR REPORT PE 05037 AND YOUR LETTER TO FORD. . SINCE YOUR LETTER TO FORD THE INTERNET HAS AT LEAST 25 REPORTS OF THIS SAME PROBLEM MOST WITH ACCIDENTS. THERE MAY ONLY BE 240,000 OF THIS CARS ,AS YOUR REPORT NOTES, BUT THIS PROBLEM CAN CAUSE A DEATH .THIS CAR WAS MADE WITH IN THE TIME PERIOD STATED IN YOU REPORT. THE FIX IS TO REPLACE THE CABLE. I TOLD FORD THAT I WOULD NOT ACCEPT THE CAR UNLESS THE CABLE WAS REPLACED. ON THE OTHER HAND I WOULD EXPECT YOU TO FOLLOW UP ON THIS DEADLY PROBLEM. *TR
Vehicle speed control, Oct 30, 2014
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL) AND THE CONTACT INDICATED THAT AN AUTHORIZED DEALER REPLACED THE WIRING HARNESS BUT DID NOT INSPECT THE ABS CONTROL MODULE CONNECTOR TO DETERMINE IF THE VEHICLE NEEDED TO BE REMEDIED FOR THE RECALL. THE CONTACT REPORTED THE SAFETY CONCERN TO THE MANUFACTURER AND THEY WOULD NOT COMPLY. THE VEHICLE WAS NOT FULLY REPAIRED UNDER THE RECALL REMEDY. THE MANUFACTURER WAS NOTIFIED OF THE SAFETY CONCERN AND PROVIDED NO REMEDY. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.
Vehicle speed control, Service brakes, Fuel/propulsion system, Oct 14, 2014
WHEN BRAKING VEHICLE ACCELERATES. COULD NOT STOP HAD TO PUT IN N AND IT STALLED BEFORE HITTING A STORE FRONT AND A SECOND TIME ON THE WAY HOME AT A RED LIGHT. *TR
Vehicle speed control, Mar 19, 2014, crash
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT WHILE AT A STOP, THE VEHICLE LUNGED FORWARD FORCEFULLY AND CRASHED INTO ANOTHER VEHICLE. THERE WERE NO PERSONAL INJURIES. A POLICE REPORT WAS FILED OF THE INCIDENT. THE VEHICLE WAS DESTROYED AND TOWED TO A COLLISION FACILITY. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.
Vehicle speed control, Jan 10, 2014
WHILE MERGING ONTO THE INTERSTATE THE ACCELERATOR CONTINUED TO ACCELERATE EVEN AFTER I TOOK MY FOOT OFF THE PEDAL. THE RPM'S WERE IN THE RED AND NOTHING I DID WOULD CORRECT THE PROBLEM. THE VEHICLE CONTINUED TO ACCELERATE. I HAD TO APPLY BOTH FEET TO THE BRAKE PEDAL AND PRESS AS HARD AS POSSIBLE TO SLOW THE VEHICLE DOWN. I WAS ABLE TO PULL OFF TO THE SHOULDER AND JAMMED THE TRUCK IN PARK AND THE ENGINE STOPPED. *TR
Vehicle speed control, Jan 3, 2014, fire
TL* THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT SMELLED A BURNING ODOR WHILE SITTING AT A TRAFFIC STOP, AND THEN NOTICED THAT THERE WAS SMOKE AND FLAMES COMING FROM THE ENGINE WITHOUT WARNING. THE CONTACT WAS ABLE TO EXIT THE VEHICLE WITHOUT INJURY. A FIRE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC BUT THERE WAS NO DIAGNOSTIC PERFORMED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V399000 (VEHICLE SPEED CONTROL ). THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 130,000. *TR
Vehicle speed control, Sep 24, 2013
APPROXIMATELY 30% OF THE TIME, THE COAST BUTTON ON THE CRUISE CONTROL WILL ACTUALLY FUNCTION AS THE ACCELERATE BUTTON. THIS CAN BE DISTURBING IF YOU HIT COAST TO INCREASE DISTANCE BETWEEN YOU AND ANOTHER VEHICLE. WHEN THIS DOES OCCUR, I AM ABLE TO HIT THE BRAKE PEDAL AND DEACTIVATE THE CRUISE CONTROL. *JS
Structure, Vehicle speed control, Aug 11, 2013
CAR LEAKING UNKNOWN FLUIDS .. THERE ARE OUTSTANDING RECALLS ON MY VEHICLE. RECALL ID 09509. *TR