2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints: vehicle speed control
181 reports, newest first. Show all
Vehicle speed control, Jul 8, 2005
DT: THE CALLER SAW AN NEW REPORT ON 48 HOURS ABOUT FORDS BURNING UP AND HAS CONCERNS ABOUT HIS VEHICLE. THE DEALER SAID TO CALL THE MANUFACTURER TO SEE WHAT THEY SAY. THE MANUFACTURER SAID THERE WAS NO RECALL ON IT. THE CONSUMER FELT THAT THIS WAS A MAJOR SAFETY ISSUE AND FORD SHOULD REPLACE THE PART BEFORE ANYTHING ELSE HAPPENS. *AK THE CONSUMER IS CONCERNED ABOUT THE CRUISE CONTROL SWITCH AND IT'S POTENTIAL TO CAUSE A FIRE. *SC *JB
Vehicle speed control, Jun 29, 2005
DT: THE CONTACT OWNS A 2002 FORD EXPLORER SPORT. OVER THE LAST COUPLE OF YEARS HE HAS BEEN HAVING PROBLEMS WITH CRUISE CONTROL. AND IF THE TRUCK WERE JUST IDLING ,AND IF CONSUMER DID NOT HAVE FOOT ON THE BRAKE THE VEHICLE WOULD REV UP ALL THE WAY FOR ABOUT 10-15 SECONDS. IF HE DID NOT HAVE FOOT ON THE BRAKE HE COULD HAVE HIT SOMEONE. DEALERSHIP STATED THAT UNLESS THEY COULD DUPLICATE THE PROBLEM THEY COULD NOT FIND THE SOURCE OF THE PROBLEM. ACCORDING TO THE REPORT IT SOUNDED LIKE THE PROBLEM WAS CRUISE CONTROL . *AK
Vehicle speed control, Jun 17, 2005
DT: CONSUMER STATES THAT AT APPROXIMATELY 3,500 MILES THE VEHICLE STARTED HAVING PROBLEMS. THE VEHICLE WILL GO FROM 60-3 MPH INSTANTLY. VEHICLE WAS TAKEN TO THE SERVICE DEPARTMENT THE FIRST TIME IT HAPPENED ,AND ON JUNE 6 AND 15, 2005. THEY COULDN'T FIND ANYTHING WRONG WITH IT.*AK
Suspension, Service brakes, Hydraulic, Engine and engine cooling, Power train, Electrical system, Vehicle speed control, Equipment, May 20, 2005
2002 FORD EXPLORER EXPERIENCING PROBLEMS WITH THE 4WD, THE OVER DRIVE LIGHT ILLUMINATES ON THE DASHBOARD AND THE VEHICLE IS GIVING OFF A ROTTEN EGG SMELL. *MR THERE WERE FRONT END PROBLEMS. THE 4WD MODULE WASN'T WORKING. THE DRIVESHAFT AND BOTH FRONT WHEEL BEARINGS WERE REPLACED. THE ROTORS WERE OUT OF ROUND. THE SERVICE ENGINE LIGHT ILLUMINATED ALONG WITH THE OVER DRIVE LIGHT. THE TRANSMISSION EXPERIENCED THE SAME PROBLEM ON TWO OCCASIONS AND POSSIBLY A THIRD TIME. A LARGE PUDDLE OF TRANSMISSION WAS FOUND UNDER THE VEHICLE. THE TORQUE CONVERTER WAS NOISY. THE ACCELERATION PEDAL WOULD PULL BACK. WHEN THE VEHICLE WAS ACCELERATED, IT WOULD WHINE. THE LEFT REAR WHEEL BEARING WAS GONE AND CAUSED DAMAGE TO THE AXLE, BRAKES AND THE TIRE WAS BARELY HOLDING ON. THE ERROR CODE FOR THE SERVICE ENGINE SOON LIGHT WAS DUE TO THE SOLENOID WHICH HAD BEEN CHANGED BEFORE. THE A/C WAS INOPERATIVE. *SC *JB
Vehicle speed control, May 19, 2005
2002 FORD EXPLORER CONCERNS REGARDING CRUISE CONTROL FIRES. *MR *SC *JB
Vehicle speed control, May 6, 2005, crash
WHILE PULLING INTO PARKING SPACE VEHICLE ACCELARATED AND CRASHED THROUGH WALL OF A DOCTORS OFFICE. VEHICLE STOPPED AFTER SHIFTING INTO PARK AND FRONT END WAS INSIDE BUILDING. HAD VEHICLE TOWED TO DEALER FOR INSPECTION. FOUND THROTTLE BODY STICKING WHICH MADE GAS PEDAL STICK CAUSING ENGINE TO ACCELARATE OUT OF CONTROL. DEALER FILED CLAIM WITH FORD. STILL WAITING FOR FORD TO RESPOND.
Vehicle speed control, Apr 6, 2005
WHILE THE CRUISE CONTROL WAS SET AT 72 MPH, THE VEHICLE WOULD NOT DECELERATE. THE CONSUMER PULLED OVER, RESTARTED THE VEHICLE, BUT THE CRUISE CONTROL WAS STILL ENGAGED. THE VEHICLE WAS TOWED. THE DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK THE VEHICLE WAS SHUT OFF AS THE MANUAL SUGGESTED IN ORDER TO RESET, BUT IT DID NOT. THE CONSUMER SAID THAT HER HUSBAND EXPERIENCED THIS PROBLEM NUMEROUS TIMES. *SC *JB
Vehicle speed control, Mar 19, 2005
VEHICLE IS A 2002 FORD EDDIE BAUER EXPLORER. VEHICLE WAS DRIVING ON EXPRESSWAY WHEN WILL CHANGING LANES TO PASS A SLOWER MOVING VEHICLE, OUR VEHICLE BEGAN TO UNCONTROLLIBLY EXCELLERATE AND CONTINUE TO EXCELLERATE PUSHING THE CAR TOWARD SPEEDS IN EXCESS OF 70 MILES PER HOUR. ENGINE CONTINUED TO RACE. AN EMERGENCY STOPPING OF THE VEHILCE WAS BROUGHT UNDER CONTROL AFTER PUTTING CAR INTO NEUTRAL, APPLYING BRAKES AND GETTING OFF OF THE ROAD. THE VEHICLE HAD TO BE TOWED TO WESTFILED FORD DEALER SHIP WHERE THEY ARE INSPECTING THE THRODDLE AND OTHER PARTS ESTIMATED COST TO REPAIR $400. HAVE NOT PICKED UP VEHICLE YET FOR FULL DESCRIPTION OF PROBLEM. *AK
Vehicle speed control, Mar 8, 2005
THE CONSUMER WAS STOPPED AT A LIGHT, REMOVED HIS FOOT FROM THE BRAKE PEDAL TO GO, WHEN THE VEHICLE ACCELERATED TO 50 MPH. DROVE HOME WITH BRAKES APPLIED TO SLOW THE VEHICLE DOWN. THE DEALER REPLACED THE THROTTLE CABLE.
Vehicle speed control, Mar 2, 2005, fire
THE CONSUMER'S 2002 FORD EXPLORER SPORT WAS PARKED WHEN IT SUDDENLY CAUGHT ON FIRE. *NM *NM
Vehicle speed control, Mar 1, 2005
WHEN APPLYING THE BRAKES TO DISENGAGE THE CRUISE CONTROL VEHICLE WOULD SPEED MORE INSTEAD OF DISENGAGING. DISENGAGED THE CRUISE CONTROL USING THE HAND BUTTON. DEALER CHANGED THE BRAKE LAMP SWITCH.
Vehicle speed control, Feb 11, 2005
THIS HAS BEEN A WONDERFUL VEHICLE! IT IS A 2002 FORD EXPLORER EQUIPPED WITH AUTOMATIC 4-WHEEL DRIVE AS WELL AS FULL 4-WHEEL DRIVE WITH HIGH & LOW TRANSFER CASE, 5-SPEED AUTOMATIC, 4.6L V8 WITH DOUBLE OVERHEAD CAMS, LIMITED SLIP REAR DIFFERENTIAL, TOWING PACKAGE, LEATHER SEATS, ETC. HOWEVER, THIS PROBLEM HAS THE POTENTIAL OF CAUSING HARM OR EVEN DEATH TO ITS PASSENGERS AND/OR THOSE IN OTHER CARS AND ESPECIALLY PEDESTRIANS. THE PROBLEM HAS BEEN EXTREMELY INTERMITTENT SUCH THAT THE TECHNICIANS CANNOT EXPERIENCE IT THEMSELVES. IT USUALLY HAPPENS ON A COLD DAY. THE FIRST TIME IT DID IT, I WAS PULLING A SMALL TRAILER AND I HAD DRIVEN A COUPLE OF MILES TO A PLANT NURSERY AND ON THE WAY BACK AS I NEARED MY HOUSE, I DROVE DOWN A LONG GRADE TOWARD A STOP SIGN. WHEN I BEGAN TO APPLY THE BRAKES, THE ENGINE ACCELERATED WITH SUCH FORCE THAT THE TRANSMISSION DOWNSHIFTED SO THAT I HAD TO STAND ON THE BRAKES WITH BOTH FEET TO KEEP FROM RUNNING CLEAN ACROSS THE ROAD INTO A TREE. IT HAPPENED 2 MORE TIMES THAT DAY. I THEN HAD IT TOWED TO THE DEALER AND THEY REPLACED THE IDLE VALVE. HOWEVER, THAT DID NOT FIX THE PROBLEM. IT HAS HAPPENED SEVERAL TIMES SENSE. IT HAS HAPPENED WHILE TRAVELING UP A HILL, DOWN A HILL, AND ON LEVEL GROUND. BUT IT ALWAYS HAPPENS WHEN YOU APPLY THE BRAKES. THE LAST TIME IT HAPPENED, IT THREW ME OUT INTO A BUSY INTERSECTION BUT FORTUNATELY I WAS NOT HIT. THE TIME BEFORE THAT IT TRIED TO RUN OVER THE LITTLE CAR IN FRONT OF ME BUT I WAS STILL ABLE TO STOP IT. I'M THINKING ABOUT NAMING THIS SUV CHRISTINE. MY BROTHER HAS AN EARLY 2002 EXPLORER EQUIPPED THE SAME AS MINE AND HIS HAS DONE IT ONCE. MY MOTHER HAS A 1998 CROWN VICTORIA WITH THIS SAME ENGINE AND IT HAS DONE IT TWICE. THERE'S NO TELLING HOW MANY "CHRISTINES" OUT THERE WAITING TO KILL AND THERE POOR OWNERS MAY NOT BE TOTALLY AWARE OF THE PROBLEM. *JB
Vehicle speed control, Jan 25, 2005
GAS PEDAL WENT TO THE FLOOR, AS A RESULT CONSUMER EXPERIENCED SUDDEN ACCELERATION ON ITS OWN. CONSUMER HAD TO TURN OFF THE VEHICLE IN ORDER TO STOP. THE VEHICLE WAS NOT IN CRUISE CONTROL MODE. DEALER SAID THAT THE THROTTLE CABLE SEIZED.JB...WHILE MAKING LEFT HAND TURN THROUGH AN INTERSECTION THE GAS PEDAL WENT TO THE FLOOR AND RPMS WENT TO THE TOP. USED BOTH FEET ON BRAKES TO STOP. HOWEVER, VEHICLE WON'T STOP. TURNED VEHICLE OFF IN DRIVE, THEN PUT IT IN NEUTRAL , RPMS LNCREASED. TURNED VEHICLE OFF, COULDN'T PUT VEHICLE BACK INTO PARK OR PULLKEY OUT OF IGNITION. CALLED AAA TO TOW VEHICLE TO DEALER. IT WAS FIXED WITHOUT CHARGE TO CONSUMER BECAUSE OF EXTENDED WARRANTY. *AK
Vehicle speed control, Dec 28, 2004
THE CONSUMER CAME TO A STOP AT A RED LIGHT. WHEN HE PULLED OFF, THE ACCELERATOR PEDAL JAMMED DOWN TO THE FLOOR. THE CONSUMER HAD TO PHYSICALLY PULL THE GAS PEDAL UP WITH HANDS. *JB
Vehicle speed control, Dec 16, 2004
WHILE DRIVING THE VEHICLE THE THROTTLE CABLE BECAME STUCK IN THE OPEN POSITION CAUSING THE VEHICLE TO INCREASE SPEED TO DANGEROUS LEVELS. APPLICATION OF THE BRAKES DID LITTLE TO SLOW THE VEHICLE DOWN. IMMEDIATELY STOPPED AT SERVICE STATION WHICH IDENTIFED THE PROBLEM AS THE THROTTLE CABLE, NOTING THE THERE WAS AN EXISITING SERVICE BULLETIN REGARDING THIS PROBLEM. NEW PARTS WERE ORDERED AND REPAIR WAS EFFECTED - COST APPROX $200.00. *AK
Vehicle speed control, Oct 18, 2004
WHILE DRIVING, THE VEHICLE ACCELERATED SUDDENLY WITHOUT WARNING. THE CONSUMER APPLIED THE BRAKES, BUT THE VEHICLE CONTINUED TO ACCELERATE. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
Vehicle speed control, Sep 22, 2004, crash
AT A STOP LIGHT, IN SLOW MOVING, STOP AND GO TRAFFIC, MY 2002 FORD EXPLORER ACCELERATED WHEN I APPLIED THE BRAKES (SPEED AT THE TIME I APPLIED BRAKES WAS UNDER 5 MILES PER HOUR). THE THROTTLE WAS OBVIOUSLY ENGAGED, A LOUD WHINING NOISE CAME FROM THE ENGINE. I PUT THE CAR IN PARK AND SHUT OFF THE ENGINE TO GET IT TO STOP MOVING. THIS VEHICLE VIRTUALLY ACCELERATED WHILE THE BRAKES WERE APPLIED TO THE FLOOR! I HIT THE CAR IN FRONT OF ME, WHO HIT THE CAR IN FRONT OF HER. ALL THREE CARS WERE DAMAGED AND ALL THREE DRIVERS HAVE BEEN TREATED FOR INJURIES. THE EXPLORER IS IN THE DEALERSHIP NOW BEING REPAIRED. I AM CONCERNED THAT A MECHANIC MAY NOT KNOW ENOUGH ABOUT THIS TO DIAGNOSIS THE PROBLEM CORRECTLY. THE VEHICLE IS NOT SAFE TO DRIVE BECAUSE OF THIS PROBLEM.*AK
Service brakes, Hydraulic, Vehicle speed control, Sep 8, 2004
MY ABS LIGHT CAME ON. WHEN SERVICED, THEY SAID A SPEED SENSOR NEEDED TO BE REPLACED. OF COURSE THIS OCCURERED ONE WEEK FOLLOWING THE EXPIRATION OF THE WARRANTY. TALKING WITH OTHERS, THIS SEEMS TO BE AN OFTEN OCCURANCE, AND SEEMS TO BE A DEFECT. SOME POEPLE HAVE HAD THEIR'S REPLACED SEVERAL TIMES WITHIN A YEAR.*AK
Vehicle speed control, Jul 15, 2004
WHILE DRIVING, THE GAS PEDAL SEPARATED FROM IT'S LINKAGE AND FELL ONTO THE FLOOR OF THE TRUCK. THIS RESULTED IN THE DRIVER NOT BEING ABLE TO ACCELERATE. THE DRIVER THEN PULLED OFF THE ROAD AND HAD THE TRUCK TOWED TO A DEALERSHIP. THIS OCCURRED BECAUSE THE GAS PEDAL CABLE HAD BROKEN AT THE CONNECTIONS. *JB
Vehicle speed control, Jun 14, 2004
WHILE DRIVING SPEEDOMETER WOULD BE OFF BY 6 MPH. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK THE VEHICLE WAS NOT IN COMPLIANCE WITH FEDERAL LAW 49 CFR CHAPTER III SECTION 393.82 FOR THE SPEEDOMETER WHICH STATES REASONABLE ACCURACY IS WITHIN +/- 5 MPH AT A SPEED OF 50 MPH. THE CONSUMER NOTIFIED FORD CUSTOMER SERVICE OF THE PROBLEM AND ASKED THEM TO COMPLY WITH THE ABOVE CODE. THE CUSTOMER WAS DENIED THIS SERVICE.
Vehicle speed control, May 27, 2004
WHEN THE BRAKES WERE DEPRESSED, THE VEHICLESURGED FORWARD. THIS ALSO OCCURS WHEN THE ACCEERATOR PEDAL IS BEING DEPRESSED. THE VEHICLE WAS SERVICED SEVERAL TIMES BUT THE TECHNICIAN WAS UNABLE TO DETERMINE THE CAUSE. PLEASE PROVIDE ANY ADDITIONAL INFORMATION. *NM
Vehicle speed control, Mar 17, 2004
I WAS GETTING ONTO I90, FLOORED THE ACCELERATOR TO CATCH UP TO SPEED. THE ACCELERATOR GOT STUCK IN THAT POSITION, AND I COULDN'T GET IT TO STOP. I HAD BOTH FEET ON THE BRAKE, AND MY TRUCK WAS STILL DOING 80 MPH. I COULDN'T GET IT TO STOP. I FINALLY PUT THE VEHICLE INTO NEUTRAL, PULLED OVER TO THE SIDE, AND FINALLY GOT MY VEHICLE TO STOP. WHILE I WAS IN THE STOPPED POSITION, MY SPEEDOMETER STILL WAS READING 80. FINALLY IT QUIT ON ITS OWN. I DEFINITELY DO NOT FEEL SAFE DRIVING IT ANYMORE. *NM
Vehicle speed control, Mar 17, 2004
WHILE DRIVING 50 MPH, THE THROTTLE PEDAL BECAME STUCK IN THE OPEN POSITION. THE DRIVER SLAMMED ON THE BRAKES BUT THE VEHICLE CONTINUED TO ACCELERATE UP TO 65 MPH. THE DRIVER TAPPED ON THE THROTTLE PEDAL UNTIL IT RELEASED AND WAS ABLE TO STOP THE VEHICLE WITHOUT INCIDENT. THE DEALER MECHANIC COULD NOT DETERMINE THE CAUSE OF THE PROBLEM BUT WILL FURTHER ASSESS THE PROBLEM BY TRYING TO DUPLICATE THE PROBLEM. *NM *JB
Vehicle speed control, Feb 29, 2004
WHILE TRAVELING AT ABOUT 45 MPH, THE THROTTLE ON MY 02 FORD EXPLORER SUDDENLY WOULD NOT RETURN TO IDLE. THE CRUISE CONTROL WAS NOT ON AT THE TIME. THE CAUSE WAS A PLASTIC SHEATHING BETWEEN THE THROTTLE CABLE AND THE EXTERIOR HOUSING OF THE CABLE. I BELIEVE THIS MATERIAL IS USED FOR LUBRICATION? THE MATERIAL APPEARED TO PULL OUT OF THE HOUSING AND BUNCHED UP INSIDE THE DRIVER FOOTWELL. WHEN MY FOOT WAS REMOVED FROM THE PEDAL, IT WOULD NOT RETURN FULLY TO IDLE BECAUSE THIS TAN MATERIAL BUNCHED UP AT THE BASE OF THE HOUSING WHERE THE CABLE COMES THROUGH THE FIREWALL. BY CUTTING THE EXCESS MATERIAL AWAY, I WAS ABLE TO GET THE PEDAL TO RESPOND PROPERLY. THE DEALER REPLACED THE THROTTLE CABLE UNDER WARRANTY.
Vehicle speed control, Feb 24, 2004
WHILE ACCELERATING PEDAL IS HARD TO PUSH AND IT MAKES A LOUD HISSING NOISE. DEALER ATTEMPTED TO REPAIR THE PROBLEM FOUR TIMES, BUT WAS UNABLE TO RESOLVE THE PROBLEM. *AK