2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints
3,613 reports, newest first.
Service brakes, Hydraulic, Oct 17, 2003
2002 FORD EXPLORER XLS 4WD. AT 33,000 MILES ABS SENSOR WARNING LIGHT CAME ON & REAR ABS UNIT WAS REPLACED. SINCE THEN THE ABS UNIT HAS FAILED EVER 2,500 TO 8,000 MILES. I NOW HAVE 87,000 MILES ON VEHICLE. *LA
Service brakes, Air, Air bags, Oct 15, 2003
ANTI-LOCK BRAKE LIGHT COMES ON AND YOU LOSE ANTI-LOCK BRAKES. THE BRAKE PEDAL PUSHES TO FLOOR WAS REPAIRED 4 TIMES ALREADY. IN ADDITION, THE AIRBAG IS NOT OPERATING, 2002 FORD EXPLORER XLS. *LA
Power train, Oct 15, 2003
I PURCHASED A 2002 EXPLORER NEW AND HAVE HAD THIS VEHICLE IN TO DEALER TWICE WITH SAME COMPLAINTS. VEHICLE GOES INTO NEUTRAL WHILE IN DRIVE AND BACK INTO DRIVE WITH A LOUD BANG AND CLUNG. VEHICLE ALSO TAKES ABOUT 30 SECONDS TO GO INTO GEAR FROM PARK TO DRIVE OR REVERSE AND ALSO A LOUD BANG & CLUNG WHEN IT FINALLY DOES GO IN. THERE IS ALSO A LOUD WHINING SOUND ON THE HIGHWAY AT HIGHER SPEEDS. DEALER EACH TIME SAYS THEY CAN NOT FIND ANYTHING WRONG WITH VEHICLE AND UNLESS THEY CAN DUPLICATE THE PROBLEM THEY CLAIM THEY CANNOT FIX. IT DOES NOT MATTER THAT IT HAS BEEN HAPPENING WHILE I DRIVE IT. *LA
Equipment, Oct 15, 2003
THE SMELL OF MOLD IS COMING OUT OF THE A/C. ALL THE DEALERSHIP DID WAS DEODORIZE THE VENTS. THE MUSTY ODOR PERSISTS. I HAVE READ THAT OTHERS HAVE THE SAME PROBLEM WITH THEIR 2002 FORD EXPLORERS. *LA
Seats, Oct 14, 2003
THE PASSENGER SIDE SEAT ROCKS BACK AND FORTH WHILE DRIVING. CONSUMER BELIEVES SOME BOLTS ARE LOOSE. *AK
Structure, Oct 12, 2003
PROBLEMS WITH REAR WINDOW HATCH.*MR THE RIGHT AND LEFT REAR GLASS LIFT STICKS WERE REPLACED. THE REAR WINDOW FELL OUT WHEN IT WAS OPENED.*TS *JB PE04045.PCO PURCHASED 03/02. DOB 02/02, OLD STYLE DESIGN (THROUGH GLASS) STRUTS FELL/DETACHED (MOUNT ROTATED AND STRUT DETACHED) AND THEN FELL ON HER HEAD (BRUISE, HEADACHE). RECEIVED EMER. MED ATTANTION. DATE WAS 7/24/2003. FINALLY REPLACED ENTIRE GLASS ASSEMBLY (GLASS, WIPER MOTOR, TRIM, STRUT)
Tires, Oct 12, 2003
TIRE BLOW OUT ON 2002 FORD EXPLORER. *MR FORD REFUSED TO REIMBURSE THE CONSUMER FOR THE TIRE BLOW OUT ALONG WITH THE BODY DAMAGE THAT OCCURRED DUE TO THE INCIDENT. THE CONSUMER REQUESTED REIMBURSEMENT. *SCC *JB
Electrical system, Oct 9, 2003
TRAILER TOWING WIRING IS FUSED AT 40 AMPS TO THE TRAILER PLUG. A SHORT IN THE SIGNAL WIRING CAUSED THE TRAILER WIRING INSULATION TO MELT OFF BEFORE THE FUSE BLEW. I WAS FORTUNATE TO HAVE IT HAPPEN WITH MY BOAT TRAILER WHERE THE WIRING IS ENCLOSED IN THE IRON CHANNEL OF THE TRAILER. HAD THIS BEEN A CAMPER, IT COULD HAVE CAUSED A FIRE. THE WIRES GOING TO THE TRAILER PLUG SHOULD BE FUSED AT 7.5 AMPS AS IN PREVIOUS MODEL EXPLORERS. SEE THE EMAIL I RECENTLY COPIED YOUR DEPARTMENT FOR FULL EXPLANATION OF THIS INCIDENT. THIS PROBLEM EXISTS IN THE 2002 AND 2003 EXPLORERS AND POSSIBLE OTHER FORD PRODUCTS. *LA
Power train, Oct 8, 2003
THE STATED THE VEHICLE FELT AS THOUGH IT WAS GOING TO SHUT DOWN, AS IF THE TRANSMISSION WAS FAILING. AS DAYS WENT BY THE OVERDRIVE LIGHT STARTED TO BLINK DAYS LATER THE VEHICLE MADE A SUDDEN HALT IN THE MIDDLE OF THE ROAD, THE CONSUMER TURNED THE ENGINE OFF AND BACK ON, IT RAN FOR AWHILE AND THEN STOPPED AGAIN. *AK *JB *NLM
Power train, Oct 7, 2003
WHILE DRIVING APPROXIMATELY 35 MPH TRANSMISSION LOCKED UP IN 2ND OR 3RD GEAR. HAD TO MOVE VEHICLE TO SIDE OF ROAD, AND THEN HAD IT TOWED TO DEALERSHIP. MECHANIC CHECKED THE VEHICLE OVER AND COULD NOT RESOLVE THE LOCKED GEAR PROBLEM.*AK
Electrical system, Oct 2, 2003
CONSUMER CALLED COMPLAINING ABOUT STALLING PROBLEMS. VEHICLE COMPLETELY SHUT DOWN MORE THAN A DOZEN TIMES WHILE DRIVING AT MORE THAN 40 MPH. MANUFACTURER WAS CONTACTED AND STATED THAT THIS WAS THE FIRST TIME THAT THEY HEARD OF THIS PROBLEM. DEALER WAS CONTACTED, AND VEHICLE HAD BEEN AT THE DEALER FOUR DIFFERENT TIMES, AND THEY STILL COULDN'T FIND WHAT WAS WRONG WITH THE VEHICLE. *AK
Structure, Oct 2, 2003
SEATS ARE RUSTED UNDERNEATH, UNDER DASH METAL RUSTING. CONTACTED LOCAL DEALER WHERE PURCHASED, SAID THEY CONTACTED FORD, CONDITION NORMAL. I CONTACTED FORD, SAME ANSWER. CONCERN IS RUST IS A NEVER ENDING CONDITION AND IN TIME (WHAT EVER IT MAY BE) WILL CAUSE FAILURE. HAVING PAID QUITE A LARGE AMOUNT OF MONEY FOR VEHICLE, I FIND IT HARD TO UNDERSTAND THAT THIS PRACTICE IS SAFE AND NOT A CONCERN. *JB
Fuel system, Gasoline, Oct 1, 2003, fire
PROBLEMS WITH FUEL INJECTORS CAUSED VEHICLE FIRE.*MR THE CONSUMER STATED HE WAS SERVICING THE R.V WHEN ALL OF A SUDDEN THERE WAS A SOUND UNDER THE ENGINE COVER AND THE VEHICLE WAS ON FIRE. IT WAS DETERMINED THE FUEL INJECTORS WERE LEAKING. (CHATEAU MOTORHOME ON A FORD CHASSIS) *JB
Steering, Fuel system, Gasoline, Visibility, Oct 1, 2003
CONSUMER STATED THAT WHILE MAKING A LEFT TURN HE HEARD A LOUD HUMMING NOISE AND HAD DIFFICULTY TURNING VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN INDICATED THAT THE POWER STEERING ROD FAILED. THIS PROBLEM OCCURRED IN JULY. IN AUGUST THE CONSUMER MADE A TURN AND THE VEHICLE SHUT OFF IN THE MIDDLE OF AN INTERSECTION WHICH CAUSED THE STEERING WHEEL TO LOCK UP. THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE GLASS IN THE REAR HATCH RATTLED. THE VEHICLE WAS PURCHASED NEW AND THE CONSUMER BELIEVES IT SHOULD NOT BE EXPERIENCING THESE TYPES OF PROBLEMS. *AK *NLM
Visibility, Oct 1, 2003
WHEN THE CONSUMER OPENED THE HATCHBACK THE GLASS PORTION OF THE HATCH DETACHED FROM THE BACK OF THE TRUCK. THE DEALERSHIP INDICATED THAT STRESS CRACKS IN THE PANEL UNDERNEATH THE WINDOW CAUSED THE FAILURE. *AK *NLM
Service brakes, Hydraulic, Sep 30, 2003
CONSUMER STATED WHEN DEPRESSING THE BRAKES BRAKE PEDAL TRAVELED TO THE FLOORBOARD, CAUSING VEHICLE TO VIBRATE. *AK
Seats, Sep 29, 2003
DRIVER SIDE SEAT BOTTOM CRACKED AND THE BACK BROKE WITHOUT VEHICLE BEING IMPACTED OR EXCESSIVE FORCE BEING APPLIED. *AK
Latches/locks/linkages, Sep 29, 2003
MY 2002 FORD EXPLORER HAD IT'S REAR GLASS FALL OFF WHEN I ATTEMPTED TO OPEN IT 2 DAYS AGO. I CALLED FORD AND THEY SOUNDED SURPRISED. I CALLED THEM BACK WITH THE INFORMATION ABOUT THE 50,000+ VEHICLES RECALLED FOR THIS AND THEY REMAIN UNIMPRESSED. I'M LOOKING FOR SOME HELP. I CALLED WINCHESTER FORD, (WINCHESTER VA) 540 667 4434. ANY HELP WOULD BE APPRECIATED. THANKS VERY MUCH, BEN
Service brakes, Hydraulic, Sep 26, 2003
BRAKING FAILURE. SOFT PEDAL. ENTIRE VEHICLE APPEARS TO BE UNDER BRAKED. MULTIPLE ABS SYSTEMS FAILURE. REAR WHEEL LOCK UP AND DRAG. WATER ENTERING CONNECTOR FOR ABS WHEEL SENSOR AT DIFFERENTIAL. WATER ENTERING DIFFERENTIAL. COMPLETE DENIAL BY FORD MOTOR COMPANY SITUATION HAS POTENTIAL FOR INJURY. CAVALIER AND ARROGANT ATTITUDE OF FORD MOTOR COMPANY CUSTOMER SERVICE CENTER. ACTUALLY TOLD ME NOT TO WRITE THEM ANY MORE ABOUT THE PROBLEM. DEALER HAS DONE ALL IT CAN AND CONTINUES TO REPLACE PARTS. DEALER AGREES FORD HAS SOMETHING TO HIDE. DEALER CONFIRMS A VERY HIGH FAILURE RATE SPECIFIC TO WET CLIMATES AND THE PACIFIC NORTHWEST. THE ONLY GOOD NEWS DEALERS IN THE AREA STOCK LARGE QUANTITIES OF REPLACEMENT PARTS.
Power train, Sep 25, 2003
TRANSMISSION SLIPS WHEN STOPPED AT A INTERSECTION OR STOPLIGHT. SOMETIMES THE VEHICLE WILL STALL. THE DEALER HAS STATED THEY COULD NOTREPRODUCE THE PROBLEM DURING AND AFTER THE WARRANTY PERIOD. I HAVE FILED SAFETY COMPLAINT WITH FORD MOTOR COMPANY CONSUMER RELATIONS AND THE DEALER HAS ATTEMPTED TO REPAIR WITHOUT SUCCESS. THE DELAY IN THE TRANSMISSION ENGAGING IS A SAFETY HAZARD SINCE THE DELAY IN PULLING OUT INTO TRAFFIC COULD RESULT IN A SERIOUS ACCIDENT. THE PROBLEM IS BECOMING MORE FREQUENT, ALMOST DAILY OCCURENCE.
Wheels, Sep 23, 2003
DRIVER REAR TIRE SEPARATED FROM VEHICLE.*MR THE FAILURE WAS THE RESULT OF THE LUG NUT BREAKING. THE VEHICLE SUSTAINED A DENT HUB CAP, AND LIGHT DAMAGE TO THE LEFT REAR BUMPER AND PANEL. *PH *JB
Seats, Sep 23, 2003
CONSUMER RECEIVED RECALL# 03V281000 NOTICE CONCERNING HIGH BACK SEATS. CONSUMER TOOK THE VEHICLE TO THE DEALER WHO KEPT THE VEHICLE ALL DAY. UPON RETURNING TO DEALER TO PICK UP VEHICLE CONSUMER REALIZED THAT DEALER DID NO REPAIRS BECAUSE THE PARTS WERE NOT AVAILABLE.*AK
Engine and engine cooling, Sep 18, 2003
ENGINE STALLED AT 4683 MILES ON THE ODOMETER. DATE: 7 OCTOBER 2002. I NOTED THAT IT NOW IDLES AT 600 RPM. I DON'T KNOW WHAT THAT MEANS. *JB
Engine and engine cooling, Sep 18, 2003
4405 MILES, 9:05 A.M., SEPTEMBER 1, 2002, CAR STALLED AGAIN. *JB
Electrical system, Sep 18, 2003
FORD EXPLORER SPORT TRAC, 2002. AT 4,122 MI BATTERY LIGHT FLASHED THREE TIMES, AND TRUCK NEARLY STALLED. *JB