2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints
3,613 reports, newest first.
Power train, Structure, Feb 7, 2008
2002 EDDIE BAUER EXPLORER TRANSMISSION TRANSMISSION TYPE 5R55W STARTED TO SLIP AND THE VEHICLE HAS 110,000 MI. NEXT MY O/D DASH LIGHT STARTED TO FLASH AND THEN THE CHECK TRANSMISSION LIGHT WENT ON. DEALER STATED IT WAS JUST A BAD SOLENOID REPLACEMENT COST OF $1,000 OR WORSE? SECOND OPINION STATED THAT THERE IS A BURIED CODE IN THE DIAGNOSTIC ABOUT THE OVERDRIVE WASN'T WORKING AND THE TEST DRIVE BY MECH. NOTED THAT 5TH GEAR WASN'T WORKING. THE INDEPENDENT MECH. STATED THAT HE WAS SORRY WHEN HE FOUND OUT IT WAS AN EXPLORER BECAUSE HE HAS A LOT OF THIS WORK. THE TRANSMISSION WAS OVERHAULED TO THE SUM OF $2,710. SAFETY CONCERN? WELL YOU HAVE YOUR FAMILY IN THIS VEHICLE TRYING TO MERGE ONTO A HIGHWAY WHILE YOUR TRANSMISSION IS SLIPPING OR WORSE. TO ME THIS IS AS BIG AS A SAFETY ITEM AS THEIR BACK GLASS LIFT GATE THEY RECALLED. OR THEIR ROLL OVER ISSUE FOR THAT MATTER. SO I MAY BE ONE PERSON BUT YOU JUST HAVE TO TYPE IN THIS ISSUE ON THE INTERNET AND THE NUMBER OF COMPLAINTS ARE INCREDIBLE. OK SO MANY PEOPLE HAVE HAD THE SAME ISSUE. SO GO TO THEIR TSB AND THIS IS LITTERED WITH TRANSMISSION ISSUES. THIS IS CLEARLY A FAULTY TRANSMISSION FROM THE START BUT APPARENTLY CONSUMER COMPLAINTS HAVE NOT BEEN ENOUGH FOR FORD TO DO THE RIGHT THING HERE. I WOULD ASK THAT THE NHTSA DO WHAT IS IN THEIR POWER TO REQUEST FORD TO DO THE RIGHT THING HERE AND REIMBURSE US FOR FIXING AN OBVIOUS AND DANGEROUS DESIGN FLAW. *TR
Power train, Feb 7, 2008
FORD EXPLORER XLT 2002 WITH 61,000 MILES O/D LIGHT STARTED FLASHING RAPIDLY AND THE CHECK ENGINE LIGHT CAME ON. WAS TOLD THE TRANSMISSION WAS SLIPPING BETWEEN 1ST AND 2ND GEAR AND NEEDED REPLACING. REPLACED TRANSMISSION AND LESS THAN A YEAR LATER THE O/D LIGHT STARTED FLASHING RAPIDLY AND CHECK ENGINE LIGHT CAME ON AGAIN. HAD THE CODES READ AND NEEDED TO REPLACE PRESSURE SENSOR VALVE. WORKED FINE UNTIL LATELY AND NOW VEHICLE IS DOING THE SAME THING AGAIN. *TR
Power train, Feb 7, 2008
ONE OF MY CUSTOMERS CAME TO ME WITH 53,000 ON HER 2002 FORD EXPLORER. THE COMPLAINT WAS A MILE LONG. ENGINE LIGHT IS ON, ABS LIGHT IS ON, SPEED SENSOR,A/C PROBS, REAR AXLE SEALS ARE LEAKING ON THE IRS, POOR EXCUSE FOR A REAR AXLE SYSTEM IN MY OPINION. A PERSON CANT TELL IF IT IS THE DIFFERENTIAL OR THE REAR BEARINGS ARE BAD, READING ON HERE I THINK THAT THEY ARE BOTH BAD. DIFF IS FULL OF METAL SHAVINGS. I AM SORRY BUT IF FORD DON'T START STANDING BEHIND SUCH A POOR EXCUSE FOR A VEHICLE, THAT ONE ONE GENTLEMEN ON HERE IS GOING TO BE RIGHT SOMEONE IS GOING TO GET HURT FIRST. THANKS FOR ALL THE GREAT INPUT ON HERE AS A MECHANIC IT MEANS A LOT. I AM GOING TO LOOSE A BIG JOB GRANTED. UNLIKE OTHER CERTAIN PLACES HMMMMMMMMM DEALERS I CARE ABOUT MY CUSTOMERS AND VALUE THEIR LIVES. YOU SHOULD DO LIKE I AM GOING TO STRONGLY ENCOURAGE MY CUSTOMER TO GET RID OF THIS PIECE OF CRAP. THIS IS WHY THE FOREIGN CAR MANUFACTURER ARE KICKEN OUR BUTTS BECAUSE WE CANT BUILD ANYTHING DECENT AND THE STAND BEHIND IT. WHAT'S THAT. THAT'S HOW WE ARE, WE ALWAYS WAIT TILL ITS TOO LATE TO DO ANYTHING UNTIL SOMEONE GETS HURT, LIKE OUR CHILDREN. WHAT REALLY PAINS ME IS THAT FORD MOTOR CO USE TO BE AN AMERICAN ICON ALONG WITH ALL THERE COMPETITORS IN THE AMERICAN MARKET AND USE TO CARE ABOUT KEEPING A CUSTOMER FOR LIFE AND KEEP UP ON THINGS LIKE CUSTOMER SERVICE AND QUALITY, INS CO (DON'T EVEN GET ME STARTED). THE WORST PART ABOUT IT IS YOU CANT TELL ME THAT YOU SHOULD NOT BE ABLE TO 100,000 MILES WITHOUT MAJOR DEFECTS OTHER THAT NORMAL MAINTENANCE. OK IM DONE. SIGNED: A GUY WORRIED THAT PEOPLE CANT FIND US HONEST MECHANICS KURT FROM GREEN BAY WI. *TR
Power train, Feb 7, 2008
TRANNY SLIPPAGE. O/D LIGHT/SERVICE ENGINE LIGHT FLASHING. ENGINE REVVING BUT NOT COMING INTO GEAR. THE TRANSMISSION SHOP SAID THIS IS A KNOWN ISSUES WITH FORDS. THE BANDS THAT WRAP THE 2ND & 5TH GEARS TO LOCK AGAINST THE DRUM ARE DEFECTIVE. FORD HAS UPDATED THE STYLE OF THE BAND AND ONCE REPLACED THIS ISSUE DOES NOT REPEAT. MY ESTIMATE SO FAR IS AT $2100-$2300. WE WILL NOT KNOW FULL EXTENT OF DAMAGE UNTIL HE REMOVES, DISMANTLES & INSPECTS IT ($595 TO DO THAT). AS THIS IS A KNOWN FORD ISSUE WITH THEIR DEFECTIVE PART, THERE SHOULD BE A RECALL AND OWNERS SHOULD BE REIMBURSED FOR THE COST OF REPAIRS. *TR
Power train, Feb 7, 2008
I HAVE A 2002 FORD EXPLORE V-8 XLT THAT HAS BEEN TAKEN CARE OF AND ALL THE SUDDEN I HAVE TRANSMISSION PROBLEMS, WHEN I AM IN DRIVE ALL SUDDEN OUT OF NO WHERE MY CAR WILL EITHER STALL OR IT WILL JOLT INTO GEAR. THEN IT WILL BE OK FOR A WHILE THEN IT STARTS DOING THE SAME THING AGAIN. I AM MORE MAD THAT MORE THAN 100 COMPLAINTS HAVE BEEN POSTED WITH THE SAME TRANSMISSION PROBLEM FOR THE SAME YEAR FORD VEHICLE ALL OF THEM ALMOST THE EXACT SAME AND THERE IS NO INVESTIGATION INTO THIS PROBLEM. I WAS ON A WEBSITE THAT LISTED THIS WEBSITE FOR VEHICLE COMPLAINTS AND THAT THERE WERE SEVERAL COMPLAINTS FOR THE SAME THING TRANSMISSION FAILURE FOR THE 2002 FORD EXPLORER. *TR
Suspension, Feb 7, 2008
THIS VEHICLE HAS BEEN MAINTAINED PER MANUFACTURES RECOMMENDATIONS. IT IS NOT USED OFF ROAD AND RUN UNDER NORMAL CONDITIONS. WITH NO WARNING AND NO PREVIOUS NOISE THE RIGHT REAR WHEEL HUB/BEARING FAILED. THE BEARING CAME APART AND THE WHEEL WAS SO LOOSE IT WAS WALKING 1-2 INCHES SIDE TO SIDE. HAD MY WIFE NOT BEEN DRIVING SLOWLY THERE COULD HAVE BEEN A HORRIFIC WRECK. LUCKILY SHE WAS CLOSE TO A SHOP WHEN IT HAPPENED. I HAVE NOT FIXED IT AS OF YET BUT AM IN THE PROCESS NOW. I KNOW I WILL NEED A HUB, BEARING AND THE BRAKES WERE KNOCKED OUT BY THE WALKING MOTION. THERE SHOULD HAVE BEEN A RECALL ON THIS. I SEE ON THE INTERNET WHERE A LOT OF INDIVIDUALS HAVE HAD THE SAME ISSUE. *TR
Power train, Feb 7, 2008
ABSOLUTELY NO WARNING SIGNS O/D OFF LIGHT BLINKING TRANSMISSION BANDS FAILURE, REQUIRING A COMPLETE REBUILD $2500-3500 FOR REPAIR AT 68,000 MILES. *TR
Structure, Feb 6, 2008
TL*THE CONTACT OWNS A 2002 FORD EXPLORER. IN MARCH OF 2007, THE CONTACT FOUND A CRACK IN THE CENTER OF THE LIFTGATE. THE VEHICLE WAS TAKEN TO THE DEALER AND WAS INFORMED THAT THE WARRANTY HAD EXPIRED. THE VEHICLE WAS TAKEN TO THE DEALER AGAIN ON JANUARY 6, 2008 AND THEY STATED THAT THE REPAIR WAS THE CONTACT'S RESPONSIBILITY. THE CURRENT MILEAGE WAS 16,000 AND FAILURE MILEAGE WAS 14,500. UPDATED 03-04-08 *BF
Power train, Feb 6, 2008
TRANSMISSION FAILURE. *TR
Structure, Feb 6, 2008
2002 FORD EXPLORER XLT. NOTICED A CRACK IN THE REAR PANEL LOCATED BELOW TAILGATE GLASS THE CRACK IS FROM TOP TO BOTTOM. *TR
Suspension, Feb 5, 2008
POTENTIAL LOST LEFT WHEEL DUE TO FAILING WHEEL BEARING. *TR
Suspension, Feb 5, 2008
I HAVE A 2002 FORD EXPLORER AND MY PROBLEM FIRST STARTED WITH THE 4X4 CASE. THE DEALERSHIP STATED IT WAS COVERED UNDER THE WARRANTY AND IT WAS FIXED. A MONTH OR SO LATER MY TRUCK BEGAN DOING THE SAME THINGS, WEIRD NOISE WHEN DRIVING NOW I HAVE TO GET THE WHEEL BEARING CHANGED ON THE LEFT SIDE AND THAT IS NOT COVERED BY WARRANTY. THE COST FOR THIS REPAIR IS ESTIMATED. $600.00. *TR
Suspension, Feb 5, 2008
2002 FORD EXPLORER XLT REPLACING 3RD WHEEL BEARING IN 2 YEARS. *TR
Vehicle speed control, Feb 5, 2008
FORD RECALL AUGUST 2007, FAULTY CRUISE CONTROL, 2002 EXPLORER SPORT TRAC. VEHICLE TAKEN TO DEALER. PARTS NOT AVAILABLE. DEALER MADE TEMPORARY REPAIR BY DISABLING THE CRUISE CONTROL. AS OF 2/5/2008 VEHICLE IS STILL WITHOUT CRUISE CONTROL. DEALER CLAIMS PARTS NOT PROVIDED BY FORD. *TR
Power train, Feb 4, 2008
TRANSMISSION ON MY 2002 FORD EXPLORER IS FAILING AFTER ONLY 40,000 MILES. EVEN THOUGH I HAVE MAINTAINED THE VEHICLE AND NOT ABUSED IT, I WILL HAVE TO REPLACE THE TRANSMISSION. *TR
Power train, Feb 4, 2008
1)NO PARTICULAR EVENTS LEADING UP TO FAILURE, ONE DAY O/D LIGHT CAME ON (FLASHING) 2)TRANSMISSION FAILURE, MUST REBUILD TO THE TUNE OF $3,400 3)TRANSMISSION REBUILD. *TR
Structure, Feb 4, 2008
I LIFTED MY REAR UPPER TAILGATE ON MY 2002 FORD EXPLORER, AND THE WINDSHIELD LITERALLY EXPLODED ON MY HEAD, INCLUDING DROPPING THE LOWER PART OF THE TAILGATE ON TOP OF ME. AFTER SEARCHING ON THE INTERNET IT APPEARS TO BE A VERY COMMON PROBLEM, AND MY LOCAL FORD DEALER CLAIMS THEY'VE NEVER HEARD OF SUCH A THING. MY LOCAL BODYSHOP HOWEVER WAS FAMILIAR WITH THE PROBLEM. THIS TAILGATE HAD A PREVIOUS RECALL RELATED TO THE HINGES I BELIEVE, WHICH I DID HAVE DONE, BACK IN 2005. MY CAR HAS 75,000 MILES AND IS USED ALMOST EXCLUSIVELY FOR HIGHWAY DRIVING. *TR
Power train, Feb 3, 2008
TRANSMISSION FAILURE AND REAR END FAILURE. *TR
Power train, Feb 3, 2008
I HAVE THIS 2002 EXPLORER EDDIE BAUER EDITION. IT ONLY HAS 79K ON IT, AND THE O/D STARTED FLASHING. I PULLED OVER AND SHUT IT OFF, AND STARTED IT AGAIN.....AFTER I RESTARTED NO PROBLEMS...LIGHT WAS GONE, AND STILL SHIFTED CORRECTLY. I PROCEEDED AND TOOK IT TO MY DEALER....WAS TOLD IT WOULD BE AROUND 5800 TO FIX THIS. THAT IS RIDICULOUS...WITH THAT LOW OF MILES ON IT...... *TR
Power train, Feb 1, 2008
REAR END NOISE ON A 2002 FORD EXPLORER. POSSIBLE REAR DIFFERENTIAL. *TR
Suspension, Feb 1, 2008
GRINDING NOISE FROM REAR ESPECIALLY DRIVER SIDE REAR HUMMING AND SWAYING BROUGHT TO DEALER REPLACED REAR HUB AND BEARING ASSEMBLIES BOTH SIDES REPLACED FRONT SWAY BAR LINKS AND BUSHINGS BOTH SIDES. *TR
Power train, Jan 31, 2008
TRANSMISSION WENT OUT ON MY EXPLORER 2002 ...EVERY SINGLE PERSON I KNOW THAT HAS 2002 EXPLORER HAD TO RE-BUILD THEIR TRANSMISSION ..FORD NEEDS TO TAKE CARE OF...I CANT AFFORD TO FIX IT EACH TIME ..ITS FACTORY DEFECT THAT SHOULD BE RECALLED. THERE'S ALOT OF NON SATISFIED COSTUMERS THAT I FIND ALL OVER THE WORLD. SOMETHING HAS TO BE DONE. *TR
Power train, Jan 31, 2008
TRANSMISSION FAILURE - KNOWN 2002 FORD EXPLORER ISSUE AND NOT A RECALL. HAVE TO REPLACE ENTIRE TRANSMISSION. *TR
Power train, Jan 31, 2008
TRANSMISSION WOULD NOT WORK BEYOND 2ND GEAR. THIS TRUCK HAD LESS THAN 60,000 MILES AND WAS A 2002 MODEL. THE TRANSMISSION HAD TO BE COMPLETELY REMOVED AND A NEW TRANSMISSION WAS PUT IN DURING 2007. *TR
Suspension, Jan 30, 2008
HEARD LOUD ROARING NOISE COMING FROM BACK REAR TIRES. HAD EXPLORER CHECKED TO FIND OUT THAT RIGHT REAR TIRE WAS ALMOST READY TO COME OFF EXPLORER. AFTER DOING SOME LOOKING AROUND ON THE WEB I FOUND OUT THAT MANY OTHER FORD EXPLORER OWNERS ARE ALSO HAVING THESE HUBS/BEARINGS WEARING OUT VERY EARLY (50-70K MILES). THIS IS A VERY DANGEROUS PROBLEM AND FORD NEEDS TO RECALL THESE EXPLORERS BEFORE SOMEONE GETS HURT. THANK YOU *TR