2002 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 3,613 owner complaints filed for this model year. This is the highest complaint count among 26 Explorer model years with reports.
Of the 2002 reports, 163 involved a crash and 71 involved a fire. 213 people were injured and 6 people died.
What owners report most often
Recalls and investigations
Vehicle speed controlOct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Campaign 09V399000 on NHTSA.gov
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Exterior lightingApr 7, 2009
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.
Campaign 09E012000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Structure, body, hatchback/liftgate, hinge and attachmentsSep 13, 2004
ON CERTAIN SPORT UTILITY VEHICLES, THE LIFTGATE GLASS STRUT MAY BECOME DISENGAGED OR THE HINGE MAY FRACTURE ALLOWING THE GLASS TO FALL AND POSSIBLY BREAK.
IF THE HINGE SHOULD FRACTURE, THERE IS A POTENTIAL FOR THE GLASS TO FALL AND ULTIMATELY BREAK AND PERSONAL INJURIES COULD OCCUR.
DEALERS WILL HAVE THE LIFTGATE GLASS STRUT BRACKETS AND GLASS HINGES REPLACED. FOR THE VEHICLES BUILT FROM AUGUST 1, 2000 THROUGH MARCH 3, 2002, THE DEALERS WILL REPLACE THE HINGES AND LIFTGATE STRUT BRACKET. ON VEHICLES BUILT FROM MARCH 3, 2002 THROUGH JUNE 23, 2003, THE DEALERS WILL ONLY REPLACE THE HINGES. THE RECALL BEGAN ON SEPTEMBER 30, 2004. A POSTCARD WAS SENT TO OWNERS ON DECEMBER 27, 2004, ADVISING THEM THAT PARTS ARE NOW AVAILABLE. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 04V442000 on NHTSA.gov
StructureMar 7, 2003
CERTAIN PICKUP TRUCK, VAN, AND MINI VAN CONVERSIONS EQUIPPED WITH SOUTHERN COMFORT BUILT RUNNING BOARDS THAT CONTAIN CERTAIN COURTESY LIGHTS MANUFACTURED BY AMERICAN TECHNOLOGY COMPONENTS, INC. THESE UNITS CONTAIN A COURTESY LIGHT OR LIGHTS THAT MIGHT OVERHEAT WHEN THE WIRE HARNESS IS EXPOSED TO EXCESSIVE MOISTURE AND ROAD SALT.
THIS OVERHEATING CONDITION CAN CAUSE THE RUNNING BOARD TO MELT OR CAUSE A FIRE.
DEALERS WILL REPLACE THE WIRING HARNESS ON THESE RUNNING BOARDS. OWNER NOTIFICATION BEGAN MARCH 7, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHERN COMFORT AT 1-800-745-6096.
Campaign 03V094000 on NHTSA.gov
Tires, sidewallMay 24, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE RIGHT SIDE TIRES MAY HAVE HORIZONTAL CUTS ON THE EDGE OF THE TREAD THAT COULD HAVE OCCURRED DURING VEHICLE ASSEMBLY.
OVER TIME, THE TIRE COULD FAIL, INCREASING THE RISK OF A CRASH.
DEALERS WILL INSPECT THE TIRES AND, IF ANY SLICES ARE FOUND, THE CUT TIRES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JUNE 7, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Campaign 01V171000 on NHTSA.gov
Visibility, glass, side/rearApr 10, 2001
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 2002 FORD EXPLORER AND MERCURY MONTAINEER SPORT UTILITY VEHICLES. THE BRACKETS CONNECTING THE LEFT CYLINDERS TO EACH SIDE OF THE LIFTGATE GLASS COULD ROTATE OUT OF POSITION IF EITHER THE URETHANE BOND OR TORQUE ARE NOT SUFFICIENT.
ROTATION OF THE BRACKETS COULD POTENTIALLY CAUSE THE LIFT CYLINDERS TO DETACH FROM THE GLASS OR, IN SOME CASES, COULD POTENTIALLY CAUSE THE LIFTGATE GLASS TO BREAK. EITHER CONDITION IS MOST LIKELY TO OCCUR WHEN THE GLASS IS BEING CLOSED.
FORD DEALERS WILL INSPECT THE VEHICLES FOR THE POSITION OF BOTH THE LEFT AND RIGHT LIFTGATGE GLASS LIFT CYLINDER BRACKETS. IF THE BRACKETS ARE IN THE PROPER POSITION, THE BRACKET RETAINERS WILL BE TIGHTENED TO A HIGHER TORQUE. IN CASES WHERE THE BRACKET IS NOT PROPERLY POSITION, THE BRACKET MUST BE RE-ALIGNED.
Campaign 01I010000 on NHTSA.gov
Representative owner complaints
3,613 reports, newest first.
Power train, Dec 8, 2007
WAS DRIVING MY 2002 FORD EXPLORER WITH ONLY 55K MILES, OVERDRIVE LIGHT SUDDENLY STARTED FLASHING AND NOW THE TRANSMISSION WILL NOT SHIFT FROM SECOND GEAR INTO THIRD GEAR. THE RPM`S REV VERY HIGH AND THEN IT CLUNKS INTO THIRD GEAR. I UNDERSTAND THERE HAVE BEEN A LOT OF PROBLEMS WITH THIS TRANSMISSION. SOMETHING NEEDS TO BE DONE ABOUT THIS IMMEDIATELY. *TR
Power train, Dec 6, 2007
THE TRANSMISSION IN MY 2002 FORD EXPLORER BEGAN TO SLIP AT 57,000 MILES. FROM FIRST GEAR INTO SECOND IT WOULD REV HIGH AND THEN WITH A CLUNK AND A GRINDING NOISE RELUCTANTLY GO INTO SECOND GEAR. *TR
Steering, Dec 5, 2007
I WAS LEAVING WORK..CRANKED MY CAR AND WENT TO SHIFT FROM PARK INTO REVERSE AND THE GEAR SHIFT LEAVER "BROKE" LOOSE FROM THE STEERING COLUMN. IT WAS JUST "FLOPPING AROUND". I CALLED MY DEALERSHIP AND THEY SENT A TOW TRUCK SINCE I COULDN'T SHIFT INTO GEAR AND DRIVE IT. I ALSO COULD NOT GET THE KEY FROM THE IGNITION SINCE THE CAR COULDN'T TELL IT WAS IN PARK. THE TOW TRUCK DRIVER SAID IN 20 YEARS HE HAD NEVER SEEN ANYTHING LIKE IT. THIS MORNING THE SERVICE DEPARTMENT AT MY DEALERSHIP SAID "YOU SURE EXERTED A LOT OF FORCE ON THE SHIFT HANDLE BECAUSE YOU BROKE THE STEERING COLUMN". I EXERTED NO FORCE...IT WAS VERY EASY. AND MY COMMENT TO THE SERVICE COORDINATOR WAS "I'M A 60 YEAR OLD WOMAN...I COULDN'T POSSIBLE EXERT ENOUGH FORCE TO BREAK THE STEERING COLUMN!". THEY ARE NOW TELLING ME IT WILL COST IN EXCESS OF $1700.00 TO FIX IT AND THEY CAN'T TELL ME HOW LONG IT WILL TAKE BECAUSE "WE DON'T STOCK STEERING COLUMNS, AND SINCE YOU USED ENOUGH FORCE TO BREAK IT, WE HAVE TO HAVE ONE SHIPPED IN. WHEN WE KNOW HOW LONG IT WILL TAKE TO GET THE PART, WE'LL TELL YOU WHEN YOU CAN GET YOUR CAR BACK." *TR
Air bags, Dec 4, 2007
2002 EXPLORER XLT PURCHASED 1/03 WITH 37,995 MILES. NOW ONLY 39,996 I AM DISABLED AND DON'T DRIVE MUCH. HAD VEHICLE IN DUE TO WARRANTY OVER 11/26/07 TO CHECK THINGS OVER. WHEN I PICKED UP CAR AIR BAG WARNING LIGHT FLASHING. THOUGH IT WAS DUE TO THEIR WORK BECAUSE IT STOPPED. NEXT TIME USED VEHICLE LIGHT FLASHING THEN STAYED ON PERMANENTLY. TOOK TO DEALERSHIP AND THEY CLAIM IT THROWS A CODE #B2292, THEY ALSO SAID A BULLETIN OUT FROM FORD ON THIS #TSB03-11-03 ISSUED TO ALL MECHANICS - THAT THE PRETENSIONER SAFETY HARNESS BOTH NEED TO BE REPLACED (DEFECT). I ADVISED THEM I WILL DISPUTE THIS DUE TO THE FACT THEY ALSO STATED FORD MAY BE DOING A RECALL. I CLAIM VEHICLE FINE TILL THEY WORKED ON IT. PART COMES IN TOMORROW, THEY SAY IT SHOULD BE READY IN A FEW HOURS, AND COST IS AROUND $295.. PLUS TAXES. ALSO HAD TO HAVE A REBUILT TRANY DONE LAST YR. ON THE AIR BAG LIGHT - I READ ALL THESE COMPLAINTS AND I AM SHOCKED THAT FORD HAS NOT ISSUED A RECALL. THIS IS NUTS. WHAT IS SCARY IS ALL THE FIRE REPORTS. *TR
Power train, Dec 1, 2007, crash
MY 2002 FORD EXPLORER TRANSMISSION FAILED. O/D OFF LIGHT BLINKS CONSTANTLY. HARD SHIFTING AND SLIPPING IS CONSTANT. DEALER WANTS $3,000 TO REPAIR. THIS HAS HAPPENED TO HUNDREDS / THOUSANDS OF EXPLORER OWNERS. SOMEONE CAN GET KILLED IF THE TRANSMISSION SLIPS ON THE HIGHWAY AND THE DRIVER LOSES CONTROL THE WAY I DID. I WAS LUCKY. SOMEONE ELSE MAY NOT BE. FORD IGNORES THE ISSUE ALTOGETHER. *TR
Engine and engine cooling, Nov 29, 2007
2002 FORD EXPLORER 4.6 V8, APPROX. 78000 MILES. WHILE DRIVING MY SPARK PLUG (UNKNOWN NUMBER - SECOND IN ON DRIVERS SIDE), BLEW OUT. WAS ABLE TO REPLACE IT. NO MORE THEN 30 MINUTES OF DRIVING SAME PLUG WAS SPIT OUT AGAIN. THIS TIME UNABLE TO REPLACE IT. *TR
Suspension, Nov 29, 2007
ALL FOUR WHEELS BEARINGS ON A 2002 FORD EXPLORER WITH ONLY 70,000 MILES HAD TO BE REPLACED. ONE INCIDENT INCLUDED A WHEEL FALLING OFF DUE TO THE FAILURE OF THESE BEARINGS. *TR
Vehicle speed control, Nov 28, 2007, fire
VEHICLE PARKED IN PARKING LOT AT 9:30P.M. SHERIFF WOKE US UP 2:00 A.M. BANGING ON WINDOWS STATING SUV WAS ON FIRE. 3 OTHER VEHICLES WERE DAMAGED BECAUSE OF FIRE. I AM BLESSED MYSELF AND MY CHILDREN WERE NOT IN SUV AT THAT TIME. ALSO DAMAGED PARKING AREA. *TR
Suspension, Nov 28, 2007
I BOUGHT AN 02 EXPLORER. WAS DRIVING AND STARTED MAKING WEIRD GRINDING NOISES. TOOK IT TO THE MECHANIC AND ITS COSTING ME 1000! DOLLARS TO REPLACE THE WHEEL HUBS AND BEARINGS. HE SAID THE WHEEL ON THE BACK WAS READY TO FALL OFF! *TR
Power train, Nov 28, 2007
I DRIVE A 2002 FORD EXPLORER XLT 4.0 V6 . MY OVER DRIVE LIGHT BEGUN FLASHING AND SHORTLY AFTER THAT MY TRANSMISSION FAILED. I OWN MANY FORDS AND THIS IS AN ISSUE THAT DEFIANTLY NEEDS TO BE RECALLED. PERFECT MAINTENANCE. *TR
Visibility, Equipment, Nov 27, 2007
AIR CONDITIONING/FAN CONTROLS KNOBS & FACE OF CD PLAYER ON DASH GETS INCREASINGLY HOTTER AS THE VEHICLE RUNS. THE PANEL WITH THE CONTROL KNOBS IS VERY, VERY HOT TO THE TOUCH AND BEGINS TO SMELL VERY HOT WHEN VEHICLE IS RUNNING. I AM CONCERNED OF A FIRE AS MY SON IS A PARAPLEGIC AND I HAVE READ THAT THE FORD EXPLORER HAS FIRES. I ASKED THE DEALER ABOUT THIS POSSIBLE ELECTRICAL PROBLEM AND THEY DON'T SEEM CONCERNED. *TR
Electrical system, Nov 26, 2007, fire
ON 11/22/2007 MY 2002 FORD EXPLORER BURNED, IT IS A TOTAL LOSS. THE FIRE ORIGINATED INSIDE THE CENTER CONSOLE. VEHICLE WAS RUNNING WHEN SMOKE FIRST APPEARED, ENGINE WAS IMMEDIATELY SHUT OFF. FLAMES ERUPTED WITHIN 3-5 MINUTES FROM THE TIME SMOKE FIRST APPEARED. *TR
Vehicle speed control, Nov 25, 2007
I OWN A 2002 FORD RANGER XLT PICK-UP TRUCK. IN AUGUST OF THIS YEAR, 2007, I RECEIVED A RECALL NOTICE FOR A SPEED CONTROL DEACTIVATION SWITCH. WITHIN TWO WEEKS I CALLED THE LOCAL FORD DEALERSHIP AND THEY REQUESTED ME TO BRING THE VEHICLE IN. I DID, AND UPON ARRIVAL I WAS TOLD THAT THEY DID NOT HAVE THE PART TO FIX/COMPLY WITH THE RECALL. I HAD A FEW CHOICE WORDS WITH THE DEALERSHIP AND WAS TOLD TO WAIT FOR A CALL CONCERNING THE PARTS ARRIVAL. I WAITED, WAITED AND WAITED, AND STILL NO CALL. I HAVE CONTACTED THE LOCAL FORD PLACE THREE TIMES SINCE AUGUST OF 2007. I STILL, AS OF NOVEMBER 25, 2007, DO NOT HAVE A REPAIRED TRUCK IN ACCORDANCE WITH THE RECALL. ALL OF THE NUMBERS ON THE RECALL SHEET POINT TO THE LOCAL DEALERSHIP AND NOTHING ELSE. I HAVE NO OTHER AVENUE EXCEPT THIS ONE. I JUST WANT MY TRUCK REPAIRED FOR THE SAFETY OF ME AND MY FAMILY. PLEASE ASSIST ME IN RESOLVING THIS ISSUE, AS SAFETY SHOULD BE PRIORITY ONE IN ANY AUTO MAKERS MIND. THIS IS MY FIRST FORD PRODUCT AND I AM NOT PLEASED WITH THEIR CAPACITY TO HANDLE SUCH A CRISIS AS A FIRE WITHIN THE VEHICLE. I HOPE THAT THEY UNDERSTAND THE MAGNITUDE OF THIS AND THE AVENUES THEY HAVE PROVIDED SHOW ONLY A FALSE SENSE OF SECURITY WITHIN ALL FORD PRODUCTS. PLEASE CONTACT ME AS SOON AS POSSIBLE WITH HELP IN THIS AREA. THANK YOU IN ADVANCE. *TR
Power train, Nov 24, 2007
OPERATOR APPROACHED THE ENTRANCE TO A PARKING LOT AND PLACED AUTOMATIC TRANSMISSION IN PARK. WHEN THE OPERATOR ATTEMPTED TO SHIFT OUT OF PARK, THE GEAR LEVER BROKE OFF OF STEERING COLUMN, IMMOBILIZING THE VEHICLE IN THE ENTRANCE; BLOCKING TRAFFIC FLOW. THE VEHICLE HAD TO BE TOWED. THE FAILED PART IS A COMPONENT OF THE STEERING COLUMN THAT CONNECTS THE GEAR SELECTOR LEVER TO THE TRANSMISSION SHIFT CABLE. THE PART IS DIE-CAST ALLOY. THE PART THAT FAILED IS NOT SOLD SEPARATELY NECESSITATING THE REPLACEMENT OF THE ENTIRE STEERING COLUMN ASSEMBLY. THE MSRP OF THE COLUMN ASSEMBLY IS APPROXIMATELY $600.00. *TR
Structure, Nov 23, 2007
AT THE BOTTOM OF THE LIFTGATE UNDERNEATH THE BACK WINDOW, RIGHT NEXT TO THE FORD EMBLEM. I HAVE A CRACK FROM THE TOP OF THE FRAME TO THE BOTTOM. I HAVE HAD THIS CRACK ON MY VEHICLE FOR A COUPLE OF YEARS. I TOOK IT TO THE NEAREST FORD DEALER AND WAS TOLD THAT IT WASN'T COVERED UNDER WARRANTY, OR WAS NOT ON RECALL. SINCE THEN I HAVE SEEN SEVERAL OTHER VEHICLES JUST LIKE MINE WITH THE SAME CRACK IN THE BACK UNDERNEATH THE BACK WINDOW NEXT TO THE FORD EMBLEM. *TR
Suspension, Nov 22, 2007
FRONT AND REAR BEARING FOR THE 2002 FORD EXPLORER FAILS WHILE DRIVING. FORD IS AWARE OF THE PROBLEM BUT WILL NOT RECALL UNTIL YOUR APPROVAL, REPAIRS ARE MADE AT THE OWNERS COST....PLEASE HELP. *TR
Power train, Nov 21, 2007
2002 FORD EXPLORER XLT TRANSMISSION FAILURE AT 45,000 MILES. HAD TO HAVE A NEW ONE INSTALLED FOR $3,000.00. *TR
Steering, Nov 21, 2007
MY WIFE WAS STARTING THE VEHICLE AND ATTEMPTED TO SHIFT INTO DRIVE WHEN THE GEAR SHIFTER BROKE OFF. HAD VEHICLE TOWED TO REPAIR SHOP WHERE MECHANIC STATED THAT HE HAD NEVER SEEN THIS BEFORE. HE ATTEMPTED TO FIND PARTS BUT FORD HAD NO PARTS NATIONWIDE TO REPAIR DUE TO CHANGE IN MANUFACTURERS. MUST HAVE BEEN A DEFECT WITH THE ORIGINAL MANUFACTURER WHICH FORCED THEM TO FIND A NEW MANUFACTURER FOR THIS PART. HAD TO REPLACE ENTIRE STEERING COLUMN ASSEMBLY. TOOK OVER 1 MONTH TO GET PART AND COST OVER $900 TO REPAIR. *TR
Power train, Nov 20, 2007
I FIRST NOTICED A GRINDING WHEN I WOULD TURN SHARPLY WITH MY 2002 FORD EXPLORER. I TOOK IT IN AND IT WAS NOTED THAT I NEEDED TO HAVE MY REAR DIFFERENTIAL REBUILT TO REPLACE TO RING AND PINION GEARS AND CLUTCH PACKS. AFTER 1 DAY OF HAVING THE VEHICLE I WAS NOTIFIED THAT A BEARING HAD FUSED TO THE AXLE ASSEMBLY AND COULD RESULT IN MY REAR AXLE SEIZING UP WHILE DRIVING. THE TOTAL REPAIR IS GOING TO COST $1500. *TR
Power train, Nov 19, 2007
PURCHASED THE VEHICLE NEW AT 2002. IT ALWAYS HAS A LITTLE BIT OIL ON THE PARKING LOT BUT I DID NOT PAY ATTENTION. NOW I FOUND OUT IT IS THE REAR DIFFERENTIAL LEAKING. APPARENTLY IT HAS BEEN LEAKING FOR A LONG TIME. *TR
Electrical system, Nov 16, 2007
TL*THE CONTACT OWNS A 2002 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE ALARM SOUNDS THROUGHOUT THE NIGHT WHILE THE VEHICLE IS PARKED AND SHUT OFF. WHILE DRIVING, THE DOORS LOCK AND UNLOCK, THE CEILING LIGHTS FLICKER ON AND OFF, AND THE DOOR AJAR BUZZER CHIMES INTERMITTENTLY. THE DEALER HAS NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS APPROXIMATELY 150,000 AND FAILURE MILEAGE WAS APPROXIMATELY 147,0000.
Structure, Nov 13, 2007
THE FIBERGLASS PIECE ON THE HATCHBACK OF THE VEHICLE IS CONSTANTLY CRACKING AND FALLING OFF WHILE THE VEHICLE IS MOVING. THIS IS A ROAD AND SAFETY HAZARD, AS MY PIECE CAME OFF WHILE DRIVING 55MPH. I AM CONTINUOUSLY SEEING OTHER EXPLORERS OF THE SAME MODEL AND YEAR THAT HAVE THE SAME ISSUE. FORD NEEDS TO TAKE RESPONSIBILITY FOR THEIR DEFECTIVE PRODUCT AND CONDUCT A RECALL. FURTHERMORE, THIS FAULTY PIECE IS OFFERED AT A FORD DEALERSHIP FOR REPLACEMENT AT OVER $300! *TR
Power train, Nov 13, 2007
VEHICLE TRANSMISSION FAILED AT 75,000- WE HAD TAKEN THE VEHICLE IN 2 SEPARATE OCCASIONS THE FIRST YEAR OF OWNERSHIP CONCERNING THE TRANSMISSION BUT WAS ADVISED NOTHING WRONG. *TR
Power train, Nov 12, 2007
WENT TO SHIFT INTO DRIVE AND GEARSHIFT LEVER SNAPPED OFF. $900.00 FOR NEW STEERING COLUMN. *TR
Power train, Nov 11, 2007
I HAVE A 2002 FORD EXPLORER XLT 4L 6CYL. WILL NOT SHIFT INTO 3RD GEAR SMOOTHLY. O/D LIGHT FLASHES. *TR