2004 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 1,408 owner complaints filed for this model year. This is the 7th highest complaint count among 26 Explorer model years with reports.
Of the 2004 reports, 75 involved a crash and 16 involved a fire. 105 people were injured.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Representative owner complaints: power train
477 reports, newest first. Show all
Power train, Sep 26, 2019
MY 2004 FORD EXPLORER HAS RECENTLY AND QUICKLY BEGAN SHIFTING VERY BADLY. I ALWAYS COME TO A COMPLETE STOP AND SHIFT INTO NEUTRAL BEFORE SHIFTING INTO REVERSE OR DRIVE BECAUSE WHEN SHIFTING INTO REVERSE FROM P OR D, IT ALWAYS TAKES A WHILE, THEN CLUNKS AGGRESSIVELY INTO PLACE. WHILE DRIVING SOMETIMES DOWNSHIFTING WILL ALSO CLUNK INTO PLACE. THIS ISSUE HAS BEEN REPORTED BY COUNTLESS OTHER DRIVERS AND HAS CAUSED MANY POTENTIALLY DANGEROUS SITUATIONS. FROM ACCELERATING SLOWLY THEN BANGING GEARS AND TAKING OFF, TO STUTTERING WHILE TRYING TO ACCELERATE, OR EVEN SWITCHING INTO REVERSE WHILE PARKING, AND HAVING THE CAR TRY TO JUMP BACK A FEW INCHES IS ONLY A FEW ISSUES THIS PROBLEM HAS CAUSED MYSELF AND COUNTLESS OTHERS. PEOPLE ARE REPLACING TRANSMISSIONS LEFT AND RIGHT TO NO AVAIL, ONLY A FEW 10 THOUSAND MILES AFTER INSTALLING NEW TRANSMISSIONS, THEIR CAR STARTS TO EXPERIENCE THE SAME ISSUES AS BEFORE. AT LOW SPEEDS AND IN PARKING LOTS THIS BECOMES A GAME OF LUCK AS YOU ACCELERATE MORE THAN NECESSARY TO TRY TO GET GOING, THEN STOPPING AND WAITING A FEW SECONDS WHILE YOU SHIFT TO NEUTRAL BEFORE SHIFTING TO REVERSE AS FEAR OF IT BANGING INTO GEAR AS YOU TRY TO MANEUVER YOUR CAR AROUND PEOPLE AND OTHER PARKED CARS BECOMES A MORE DANGEROUS TASK THAN IT SHOULD BE. IN SUM, WHILE STATIONARY, SLOW SPEED, OR JUST CRUISING, THE TRANSMISSION WHILE SHIFTING GEARS, OR SHIFTING INTO REVERSE/DRIVE, SOMETIMES WANTS TO BANG INTO GEAR OR LOSE POWER, OR DELAY SHIFTING ONLY TO BANG INTO GEAR MOMENTS LATER. SOME ISSUES WHEN TAKING CARS INTO REPAIR IS FINDING METAL TRANSMISSION SHAVINGS WHERE THEY SHOULDNT BE! FINALLY, THE EXCESSIVE BANGING CAN ALSO DAMAGE THE ENGINE OVER TIME IN ADDITION TO THE TRANSMISSION. PLEASE REFERENCE THE FOLLOWING LINK TO GET A BETTER IDEA OF THE ISSUES: HTTPS://WWW.CARCOMPLAINTS.COM/FORD/EXPLORER/2004/TRANSMISSION/TRANSMISSION_SLIPPING_SHIFTS_HARD.SHTML THANKYOU
Steering, Suspension, Power train, Jun 20, 2019
MY STEERING COLUMN BROKE RIGHT OFF! TRYING TO PUT IT IN DRIVE @99,735 MI. HAD TO TOW IT TO SHOP, AND REPLACE THE STEERING COLUMN. I SEE OTHER PEOPLE HAD THIS SAME PROBLEM. THERE SHOULD BE A RECALL FOR THIS!!! I ALSO HAD TO REPLACE THE TRANSMISSION @ 103,000 MILES IT WOULD SKIP 3RD GEAR. SEEMS EVERYONE ELSE HAS TO REPLACE THE TRANSMISSION. ALSO BACK BEARINGS!! WHAT A DISGRACE. RECALL THIS DISGRACEFUL WORKMANSHIP! NO HONOR!
Power train, Dec 27, 2018
TL* THE CONTACT OWNS A 2004 FORD EXPLORER. WHILE DRIVING AND ATTEMPTING TO SHIFT GEARS, THE CONTACT'S SON PULLED TOO HARD AND FRACTURED THE GEAR SHIFTER. THE CONTACT STATED THAT THE GEAR SHIFTER WAS CURRENTLY TOO LOOSE AND WOULD NOT SHIFT INTO ANY GEAR. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE AND VIN WERE UNKNOWN.
Power train, Dec 28, 2017
WELL WE JUST BOUGHT THIS EXPLORER AND JUST AS I HAVE READ FROM OTHERS ON THIS WEBSITE OUR EXPLORER IS DOING SIMILAR THINGS. SUCH AS SHIFTING IN REVERSE TAKES 3-7 SECONDS TO TAKE HOLD, GOING UP THE MOUNTAINS THE SUV HAD MAJOR KICKBACKS AND JERKS. I HAVE NOT TAKEN TO DEALERSHIP AS OF NOW. WILL MAKE AN APT. AND PUT RESULTS LATER.
Steering, Power train, Electrical system, Nov 23, 2017
ALL FOUR SEALS WHERE LEAKING INCLUDING PINION SEALS. CLUNKING NOISE 40 TO 50MPH WHEN YOU LET GO OF THE GAS ,HOLDS BACK,HEATER GAUGE+MPH GAUGE DON'T WORK MOST.OF THE TIME.PAINT CHIPPING AWAY ALL OVER.REPLACED ALL SEALS 5 TIMES +YOKE CVHALF SHAFT. REPLACED FRONT DIFFERENTIAL STILL MAKING THE NOISE.POOR LIGHTING AT NIGHT.IT HAS A MISS FIRE GAVE IT A TUNEUP AND STILL IS DOING IT. RADIO VOLUME WON'T TURN DOWN IT GOES LOUDER WHEN TURNING DOWN.
Power train, Vehicle speed control, Aug 30, 2017
IT SLIPPES AND WON'T JUST TAKE OFF SOME TAKE OFFBUT THE SUV SITS AND WHEN IT DOES TAKEBODF YOU HAVE TO LET YOUR FOOT UP OFF THE GAS TO GET IT TO SHIFT
Suspension, Power train, Engine, Jun 27, 2017
TRANSMISSION SHIFTS HARDER AND SHAKES THE ENTIRE SUV. WHEN I PRESS THE GAS AND GET TO ABOUT 35-40 IT WILL START KNOCKING REALLY BAD AND FEELS LIKE IT'S LOSING POWER. WHEN I STOP THE EXACT SAME THING HAPPENS WITH THE KNOCKING. I WAS GOING 35 AROUND A SLIGHT CURVE ON I-45 FREEWAY BY LITTLE YORK SHEPARD GULF BANK AREA TO BE EXACT AND THE SUV WAS DRIVING FINE. I WAS JUST GETTING ONTO THE FREEWAY AT THIS TIME. HINTS THE REASON I'M NOT GOING SO FACE. WHEN I STARTED PICKING UP SPEED THE TRANSMISSION JERKED SO HARD I FLEW INTO THE NEXT LANE. LUCKILY NO ONE WAS AROUND ME BUT IMAGE IF I WAS IN TRAFFIC AND THIS HAPPEN.
Power train, Fuel/propulsion system, May 9, 2017, crash
HAVE HAD 2 OF THESE 2004 FORD SPORT TRAC TRUCKS. ONE WHICH WAS FLIPPED ONTO MY DRIVER SIDE AND TOTALED IN AN ACCIDENT WHERE I WAS HIT DOING 25MPH DOWN A BACK ROAD WHITH A STOP SIGN INTERSECTION, NO AIRBAGS WENT OFF THE ONLY THING THAT SAVED ME WAS MY SEAT BELT FROM WORSE INJURES. MY CURRENT TRUCK WHICH HAS BEEN WELL MAINTAINED AND I STILL HAVE ALL RECEIPTS FOR OVER 5000 WORTH OF WORK DONE, RECENTLY WITH OVER A QUARTER TANK OF GAS TURNING LEFT WILL CUT OUT AND DIE COMPLETELY IN TRAFFIC WHICH HAS ALMOST CAUSE ME TO BE HIT A COUPLE TIMES WITH MY CHILD IN THE CAR. ALSO MY TRANSMISSIONS WENT OUT AND LOST GEARS AT LOW MILEAGE. I TOOK MY CURRENT TRUCK TO RICHARDS TRANSMISSION WHERE THEY TOLD ME THE FORD SPORT TRACK TRANSMISSION NORMALLY DOESN'T LAST PAST 50,000 MILES THAT FORD DID NOT MACHINE THE TRANSMISSION CORRECTLY WHICH IS A KNOWN PROBLEM IN THE FORD SPORT TRAC. BEFORE THE TRANSMISSION STARTED TO SLIP MY O/D WOULD KICK ON AND CAUSE SEVERE JERKING OUT OF FIRST GEAR BUT ONLY WHILE THE O/D WAS ON. I COULD NOT GET IT TO TURN OFF UNLESS I SHUT OFF THE ENGINE. I'VE HAD MY COOLANT AND TRANSMISSION FLUID MIX AND HAVE HAD TO REPLACE THE RADIATOR TWICE BECAUSE OF THIS ABOUT 3000 MILES BEFORE THE TRANSMISSION COMPLETELY LOST SECOND GEAR. I BELIEVE FORD SHOULD FIX THIS, I ENJOY MY TRUCK BUT COULD HAVE BEEN CRITICALLY INJURED A FEW TIMES DUE TO MALFUNCTIONING THAT FORD SHOULD FIX.
Power train, Mar 6, 2017
TL* THE CONTACT OWNS A 2004 FORD EXPLORER. WHILE DRIVING 40 MPH, AN OVERDRIVE WARNING INDICATOR ILLUMINATED WHILE THE VEHICLE DECREASED IN SPEED. THE CONTACT STATED THAT THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 127,695.
Power train, Vehicle speed control, Engine, Mar 5, 2017
I HAVE ALREADY PUT A COMPLAINT IN ABOUT MY THROTTLE BODY ISSUE. THIS EVENING I WENT ABOUT A MILE AND A HALF, AND MY WRENCH LIGHT CAME ON AND MY TRUCK STARTED TO NOT TO BE ABLE TO MOVE. I PULLED OVER, TURNED IT OFF. WAITED A BIT AND RESTARTED IT. THIS TIME IT TOOK A BIT TO GET IT TO START UP. I THEN PROCEEDED TO GO BACK HOME BECAUSE OF HOW IT WAS ACTING A MILE AND A HALF AFTER DRIVING, NOT OFTEN TWO MINUTES LATER IT HAPPENS AGAIN, AND THE ENGINE STARTED CHUGGING, I COULDN'T MOVE, AND I ALMOST GOT REAR ENDED AGAIN! I THEN AGAIN TURNED IT OFF AND WAITED AND THEN STARTED THE TRUCK UP. IT TOOK SOMETIME ONCE AGAIN TO START. I FINALLY MADE IT BACK HOME IN TEARS. I WAS ABLE TO GET CODES OFF, SINCE I PICKED A UP A CODE RAFFIA FEW DAYS PRIOR. I GOT CODE P2104, P2111, AND P2112. THIS ISSUE NEEDS TO BE ADDRESSED. I WILL BE CALLING FORD TOMORROW!
Power train, Service brakes, Engine, Nov 12, 2016
TRANSMISSION FAILURE WITH OVERDRIVE LIGHT BLINKING .NO FIRST GEAR,SHIFTS HARD , SOMETIME IT WONT SHIFT WITHOUT LETTING OFF GAS .WITH CODESPO731,PO733,PO734,PO745 NEEDS TOTAL REBUILD THIS HAPPENED WHILE DRIVING DOWN THE ROAD AT 40 MILES A HOUR , ABS LIGHT IS ON . CODES SHOW WRONG LINE PRESSURE.ENGINE KNOCKING , TIMMING CHAIN ISSUES.
Power train, Sep 4, 2016
TRANSMISSION FAILURE. SHIFT SOLENOID "B" CIRCUIT FAILURE TRANSMISSION DOES NOT SHIFT INTO 2ND GEAR UNTIL VEHICLE REACHES 3000 RPM. O/D LIGHT FLASHES, SERVICE ENGINE SOON LIGHT ACTIVATES AND TRANSMISSION STAYS IN 3RD GEAR. DON'T USE VEHICLE AND IS OUT OF EXTENDED WARRANTY.
Power train, Electronic stability control (ESC), Service brakes, Jul 20, 2016
WHEN DRIVING MY 2004 FORD EXPLORER STARTED MAKING A GRINDING AND HUMMING NOISE ON THE LEFT FRONT OF DRIVER SIDE TIRE AREA. ABS AND 4X4 HIGH LIGHTS CAME ON INSTRUMENT PANEL. TRUCK FELT LIKE IT WAS GOING INTO 4X4 MODE ON ITS OWN AND BRAKING FELT LIKE ABS SYSTEM FAILED. TOOK IT TO A FORD DEALERSHIP AND I WAS TOLD THAT BOTH FRONT WHEEL BEARINGS NEEDED TO BE REPLACED AT A COST OF $1053. SINCE THIS TRUCK USES SENSORS AND TRACTION CONTROL THE SENSOR ON THE LEFT DRIVER SIDE HAD GONE OUT CAUSING THIS FEATURE NO LONGER TO WORK. IT IS A GOOD THING THIS DID NOT RESULT IN AN ACCIDENT SINCE THE VEHICLE WAS GOING INTO 4X4 MODE ON IT'S OWN AND THE BRAKES ABS NO LONGER FUNCTIONED. JUST A QUICK SEARCH ONLINE WILL RESULT IN MANY FOUND ISSUES REGARDING THIS THAT FORD HAS NOT DONE A RECALL ON YET. WHAT IS IT GOING TO TAKE TO GET FORD TO STAND BEHIND THE SAFETY OF TRUCKS THEY SELL?
Power train, Structure, May 18, 2016
PAINT PEELING ROOF HOOD DIFFERENTIAL REPLACED TWICE BEARINGS WEAR OUT REPAIRED TWICE BACK OF TAILGATE PANEL CRACKED REPLACED 3 TIMES
Power train, Other or unspecified, Nov 2, 2015
WHEN DRIVING AND YOU THEN SHIFTING FROM DRIVE TO REVERSE IT GOES INTO REVERSE HARD. SOMETIMES IT EASES INTO GEAR AND OTHER TIMES IT IS VERY HARD. I THOUGHT WELL MAYBE IT WAS ME DID MY FOOT SLIP OFF BRAKE OR SOMETHING?? IT WASN'T THAT I MADE A VERY CONSCIOUS EFFORT TO MAKE SURE I DID IT CORRECTLY AND STILL HAD THE SAME PROBLEMS. I ALSO NOTICED THAT THE VEHICLE DOESN'T SHIFT FROM DRIVE TO PARK CORRECTLY KIND OF STOPS YOU BEFORE ENTERING PARK THEN WILL GO IN AFTER YOU WERE DENIED THE GEAR THE FIRST TIME. CURRENTLY STILL DEALING WITH THIS WAS HOPING THERE WAS A RECALL FOR EITHER ISSUE.
Power train, Seats, Other or unspecified, Jul 29, 2015
OVERDRIVE LIGHT STARTING BLINKING CAR STARTED SHIFTING REALLY HARD AND JERKING. THIS IS A KNOWN ISSUE WITH FORD EXPLORERS AND NEED TO BE RECALLED. I DONT HAVE ANOTHER VEHICLEBI REALLY NEED HELP PLEASE
Power train, May 5, 2015
TRANSMISSION FAILURE, COMMON FOR FORD EXPLORER 2004. *TR
Power train, Engine, Mar 16, 2015
HAD MY USED 2004 FORD EXPLORER FOR A WEEK AND I NOTICED THE TRANSMISSION JERKING WHEN IT SHIFT INTO THE LAST GEAR. SOMETIMES WHEN I PUT IT IN REVERSE, I HAVE TO WAIT FOR A FULL MINUTE FOR IT TO FINALLY REVERSE. SOMETIMES IT JERKS HARD WHEN I PUT IT IN REVERSE OR DRIVE. I'M SURE THE DEALERSHIP KNEW ABOUT ALL THIS BUT NEVER REVEALED IT. OF COURSE WHEN YOU BUY AS IS, YOUR SCREWED. *TR
Power train, Mar 11, 2015
I WAS DRIVING INTERSTATE 64 GETTING OFF THE EXIST GOING AROUND THE RAMP AND A KNOCKING NOISE STARTED AS I ROUNDED THE CURB, THEN OIL PRESSURE DROPPED, MY POWER WAS GONE AND, I BARELY MADE IT OFF THE RAMP, BUT LUCKILY THE VEHICLE HAD ENOUGH SPEED TO COAST THE CURB TO GET TO A SAFE PLACE TO STOP. UPON HAVING IT CHECKED OUT BY A LOCAL MECHANIC HE SUGGESTED THAT THE ENGINE AND OIL PUMP NEEDED TO BE REPLACED? AS A SINGLE MOTHER I DON'T HAVE THE MONEY FOR THE REPAIRS, AND FROM OTHERS COMPLAINTS THAT I'VE SEEN IT MAKES ME WONDER IF ITS WORTH THE TROUBLE TO FIND ANOTHER ENGINE AND WILL IT HAPPEN AGAIN. I THOUGHT HAD FOUND A GOOD VEHICLE THAT ONLY LASTED A FEW MONTHS...FEELING IRRITATED...GET IT TOGETHER FORD BECAUSE THIS 2004 EXPLORER IS TROUBLE!! WAS THIS JUST A TEST DUMMY MODEL TO SEE WHAT PROBLEMS WOULD COME OF IT??? WE WANT AND NEED ANSWERS TO THESE PROBLEMS. WE'RE SPENDING SO MUCH HARD EARNED MONEY ON A VEHICLE THAT HAS MORE PROBLEMS THAT KEEPS HAPPENING OFTEN. *TR
Power train, Engine, Fuel/propulsion system, Feb 25, 2015
I'VE HAVE MY VEHICLE FOR 10 YEARS. PAID THE DEALERSHIP $450 TO HAVE A WARRANTY FOR THE POWER TRAIN AND WHEN I WENT TO THE DEALERSHIP FOR THEM TO FIX IT THEY WOULDN'T. I FIND OUT THAT MY MAJOR ISSUES ARE THE MECHANICAL DIFFERENTIAL. STILL HAVING THE THIS ISSUE TO THIS DAY AND CAN NEVER HAVE MY TRANSMISSION CLEANED OR FLUSHED BECAUSE OF THAT. ALSO, MY FUEL SYSTEM GETS CLOGGED A LOT AND GAS MILEAGE IS HORRIBLE. ALSO, MY ANTIFREEZE LEAKS AFTER I PAID MONEY TO HAVE THE CRACKED SEAL FIXED. THIS IS JUST SCRATCHING THE SURFACE. I HAVE MANY THINGS WRONG WITH MY VEHICLE I FEEL SHOULD BE COVERED BY THE MANUFACTURER BUT I WOULD LIKE TO KNOW WHAT DEFECTS ARE OUT THERE FOR MY VEHICLE. *JS
Power train, Jan 27, 2015
TL*THE CONTACT OWNS A 2004 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE TRANSMISSION SEIZED. THE CONTACT STATED THAT WHEN THE ACCELERATOR WAS DEPRESSED, THE VEHICLE HESITATED TO ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE IT WAS DIAGNOSED THAT THE GEARS FAILED TO SHIFT AND THE TRANSMISSION HAD TO BE REPLACED. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 65,000.
Power train, Jan 25, 2015
REAR PANEL CRACKED IN THE SHED. I HAVE HAD TO REPLACE MY TRANSMISSION A YEAR AGO REPLACE FRONT HUBS SEVERAL TIMES. AND JUST LAST WEEK I HAD TO REPLACE THE BACK WHEEL BEARING AGAIN. I DON'T UNDERSTAND WHY FORD HAS NOT DONE A RECALL ON THESE THINGS.I SEE A LOT OF FORDS WITH THE SAME CRACK ON THE BACK HATCH.THIS IS JUST CRAZY. IF I NEW WE COULDN'T CHECK TRANSMISSION FLUID I WOULD HAVE NEVER GOT THIS TRUCK.I WILL NEVER BUY A FORD AGAIN. WE ALSO HAVE A 1994 DIESEL THAT WE HAD TO PUT A TRANSMISSION IN AT 80,000 MILES IT SITS IN THE SHED AND NOW MY HUSBAND DRIVES A CHEVY.OUR FORD DIESEL ONLY HAS 134,000 ON IT WHAT ASHAMED. IT WILL NOT EVEN CRANK WHEN ITS COLD. BAD WORK FORD!!!! *TR
Power train, Electrical system, Dec 6, 2014
THE CAR IS IN PARKING CONDITION AT WORK AND AFTER A LONG AWHILE IT WOULD NOT START EVEN THE FULL BATTERY. I HAVE ATTEMPTED TO MAKE LOTS OF CHECKS FOR ALL COMPONENT LIKE RELAYS, FUSES AND WIRING CONNECTION THEY ARE ALL FINE, IN GOOD CONDITION. BUT FINDING OUT THE STARTER RELAY HAD NO POWER, NO CURRENT FLOWING THROUGH IT. I BELIEF THAT THE FAULTY IS ( PCM UNIT ) POWER TRAIN CONTROL MODULE THAT BLOCKED A CURRENT FROM THE STARTER RELAY. *TR
Power train, Engine, Dec 1, 2014
THE TRANSMISSION FAILED EARLY ON AT ABOUT 88000 MILES, WE PURCHASED AND REPLACED THIS. MY HUSBAND HAD BEEN IN AUTO REPAIR AND PARTS FOR OVER 20 YEARS, SO HIM AND MY SON DONE THE REPAIR, WITHOUT COUNTING ANYTHING FOR LABOR THE TOTAL COST FOR THE REPAIR WAS AROUND $2000.00. FROM THAT POINT ON WE HAVE HAD LOTS OF MAJOR PROBLEMS THAT HAD TO BE REPAIRED OR PARTS REPLACED. THE INTAKE AND PARTS COST US AROUND 700.00, NO CHARGE FOR LABOR. THE TIMING C+HAIN FAILED AND WE CHOOSE THIS TIME TO TAKE IT TO THE REPAIR SHOP WHICH COST US $1100.00!!! NOW AT 156000 MILES THE TRANSMISSION HAS FAILED, THIS ONE HAS AROUND 68000 MILES ON IT. WE HAVE NEVER HAD ONE DIME IN HELP FROM FORD ON ANYTHING. THIS IS THE THIRD EXPLORER WE HAVE OWNED IN THE PAST 15 YEARS. WE ALSO OWN 3 F-150'S AND A MUSTANG. WE HAVE NEVER HAD THIS KIND OF PROBLEMS WITH ANY OF THE OTHER VEHICLES. I CAN HONESTLY SAY WE ARE VERY DISAPPOINTED IN THIS 2004 EXPLORER AND I FEEL WE WILL MOST LIKELY NOT PURCHASE ANOTHER FORD VEHICLE IN THE FUTURE!!!!! *JS
Power train, Nov 20, 2014
THIS IS THE SECOND OCCURRENCE OF THIS EVENT. FIRST ONE FAILED AT 90,000 3 YEARS AGO. THIS WAS A REBUILD FORD TRANSMISSION INSTALLED BY THE DEALER. IT FAILED AGAIN, THIS TIME THE CAR WAS ABLE TO GET SAFELY TO THE SIDE OF THE ROAD, SAFETY WAS AN ISSUE AS IT WAS NOT A MOVABLE CAR AND STRANDED ON SIDE OF BUSY ROAD. *TR