2004 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 1,408 owner complaints filed for this model year. This is the 7th highest complaint count among 26 Explorer model years with reports.
Of the 2004 reports, 75 involved a crash and 16 involved a fire. 105 people were injured.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Representative owner complaints: power train
477 reports, newest first. Show all
Power train, Jan 15, 2007
PURCHASED THE 2004 FORD EXPLORER IN SYRACUSE, NY IN THE FALL OF 2004. WE RECEIVED THE RECALL NOTICE ABOUT THE TRANSMISSION AND HAD THE SERVICE PERFORMED. THE VEHICLE HAS BEEN IN TO THE DEALER TO FIX A CONTINUING PROBLEM ABOUT THE TRANSMISSION. THE TRANSMISSION HAS TROUBLE SHIFTING INTO REVERSE AND WHEN GOING UP HILL, ON OCCASION. THE VEHICLE'S TRANSMISSION ALSO CONTINUES TO MAKE A "CLUNKING" NOISE AND PHYSICALLY LURCHES ON OCCASION WHEN TRAVELING AT SPEEDS BETWEEN 40 - 60 MPH. THE VEHICLE IS WITHIN A COUPLE HUNDRED MILES OF THE FACTORY WARRANTY EXPIRATION AND FORD HAS STILL NOT REPAIRED THE PROBLEM. WE HAVE SPOKEN TO THE FORD MANUFACTURER DIRECTLY AND THEY HAVE ONLY OFFERED TO SELL US AN EXTENDED WARRANTY. THE LOCAL DEALER SERVICE MANAGER DID INDICATE THAT HE IS AUTHORIZED TO OFFER AN EXTENDED WARRANTY UP TO 75,000 MILES AT NO COST, BUT WE HAVE NOT RECEIVED THAT IN WRITING. WE FEEL THAT THIS WAS A PROBLEM CAUSED IN THE PRODUCTION OF THE VEHICLE AND ALL REPAIRS SHOULD BE COVERED BY FORD, BUT THEY ARE NOT TAKING CARE OF THE PROBLEM. *NM
Power train, Jan 15, 2007
WITHIN A WEEK OF BUYING MY 2004 EXPLORER I EXPERIENCED PROBLEMS WHEN SHIFTING OUT OF REVERSE. I ALSO EXPERIENCED A LOUD "CLANG" WHILE DOING STEADY INTERSTATE DRIVING (OVER 200 MILES). OVER TIME TRANSMISSION SHIFTING BECAME SLUGGISH, UNTIMELY, AND LOUD. A RECALL WAS RECEIVED AND A TRANSMISSION ADDITIVE WAS ADDED. PROBLEMS CONTINUED WITH THE TRANSMISSION (SAME AS NOTED ABOVE). IN JUNE '06- DEALERSHIP REPLACED SOME PARTS OF THE TRANSMISSION (UNDER WARRANTY). FIVE MONTHS LATER, I'M CONTINUING WITH PROBLEMS. LOUD "CLANG" DURING LONG ROAD TRIP. JERKY, HESITANT SHIFTING CONTINUES. TOOK CAR TO DEALERSHIP AND NO PROBLEMS WERE FOUND WITH THE TRANSMISSION AND DEALERSHIP WAS NOT ABLE TO DUPLICATE DURING 30 MILE TEST DRIVE. CAR STALLED IN PARKING LOT THIS WEEK, JERKY MOTION CONTINUES GOING UP STEEP INCLINE AND LOUD "CLANG" EXISTS ON LONG ROADTRIP. WARRANTY IS ABOUT TO RUN OUT IN ABOUT 400 MILES. I HAVE CONTACTED CUSTOMER CARE CENTER RESULTING IN NO HELP. ALSO HAVE REPEATED PROBLEMS WITH FUEL GAUGE NOT REGISTERING PROPERLY. *NM
Power train, Jan 13, 2007, crash
THE TRANSMISSION IN OUR 2004 FORD EXPLORER XLT AWD REQUIRED A SIGNIFICANT REPAIR IN 7/05 AT 11,311 MILES BECAUSE THE TRANSMISSION WOULD NOT ENGAGE AFTER SHIFTING INTO REVERSE. DEALER REPLACED SHIFT SOLENOID AND REFILLED FLUID. DEALER ESTIMATED THAT COST TO REPLACE SHIFT SOLENOID WAS $3,500 BUT IT WAS COVERED UNDER WARRANTY. PROBLEM RECURRED AND IN DECEMBER 2006 AT APPROXIMATELY 32,000 MILES, MY DAUGHTER WAS INVOLVED IN AN ACCIDENT WHEN SHE BACKED INTO A PARKED CAR BECAUSE THE TRANSMISSION FAILED TO ENGAGE. WE TOOK IT TO THE DEALERSHIP AND THEY REPLACED THE SHIFT SOLENOID A SECOND TIME. *JB
Power train, Jan 10, 2007
2004 FORD EXPLORER GEAR SHIFTER LEVER BROKE IN MY HAND WHILE VEHICLE WAS IN DRIVE. THE VEHICLE IS AN AUTOMATIC. THIS IS A HUGE SAFTEY ISSUE BECAUSE THE VEHICLE WAS ENGAGED IN DRIVE AT THE POINT OF THE LEVER BREAKING. THE LEVER WAS NOT A STEEL PIECE AND WAS DEFECTIVE. FORD IS UNRESPONSIVE TO THIS ISSUE. *JB
Power train, Jan 2, 2007
TRANSMISSION/DIFFERENTIAL/REAR-END PROBLEMS, PURCHASED 2004 FORD EXPLORER XLT IN MARCH OF 2006, FIRST COMPLAINT WAS THAT THE PRNDL INDICATOR WOULD NOT MOVE INTO THE RIGHT GEAR,REPORTED THE DEFECT IN MAY, PROBLEM STOPPED BUT THEN STARTED AGAIN. BROUGHT THE VEHICLE BACK TO THE DEALER AND HAD TO PAY TO GET THE PROBLEM REPAIRED. BUT ALSO FOUND THAT THE REAR-END IS SHOT THE DRIVE SHAFT KEEPS TURNING AND THE VEHICLE KEEPS ROLLING WHILE IN PARK. THE VEHICLE ALSO LURCHES WHEN BRAKE IS DEPRESSED. DEALER STATES THAT THE REAR-END AND DIFFERENTIAL IS BAD HOW CAN THIS BE ON A VEHICLE THAT HAS ONLY 49000 MILES ON IT . *JB
Power train, Equipment, Dec 29, 2006
WHEN THE EXPLORER IS PUT IN REVERSE IT TAKES UP TO 5 SECONDS TO ENGAGE AND THEN JERKS BACKWARDS AFTER MAKING A LARGE CLUNKING NOISE. U JOINTS AND WHEEL BEARINGS HAVE BEEN REPLACED, BUT PROBLEM STILL OCCURS.
Power train, Nov 26, 2006, crash
WE HAVE A 2004 FORD EXPLORER WITH 41,000 MILES. IN THE PAST 3 MONTHS WE HAVE HAD TO HAVE THE TRANSMISSION OVERHAULED, UNIVERSAL BALL JOINT REPLACED, WHEEL BEARINGS REPLACED, PARKING BRAKE REPLACED. ALL WORK HAS BEEN DONE BY THE DEALER. ON THE EVENING OF 11/21/06, WE WERE LEAVING MY DAUGHTER'S SCHOOL AND I GOT IN THE VEHICLE TO BACK THE CAR UP A FEW FEET SO THAT MY WIFE WOULD NOT HAVE TO STEP IN THE MUD. I STARTED THE CAR, PUT THE CAR IN REVERSE (FOOT ON BRAKE), AND WHEN I TOOK MY FOOT OFF THE BRAKE TO MOVE THE CAR A FEW FEET, IT SURGED BACKWARDS, LIKE A CANNON BALL IN REVERSE; IT CRASHED INTO A NEON, WHICH WAS PARKED 6 FEET FROM OUR CAR, SENT THE NEON FLYING ABOUT 15 FEET INTO ANOTHER CAR; (THE NEON'S FRONT END WAS CRUSHED). I FELT I HAD NO CONTROL OVER THIS VEHICLE WHATSOEVER. WE ARE THANKFUL THAT IT HIT A PARKED CAR, RATHER THAN TRAFFIC COMING FROM BEHIND. WHAT WOULD HAVE CAUSED THIS? THE POLICEMEN THAT RESPONDED TO OUR CALL SUGGESTED THAT WE NOT ATTEMPT TO DRIVE THE VEHICLE, SO WE PUSHED IT TO THE SIDE OF THE ROAD AND HAD IT TOWED TO THE FORD DEALER. THE OTHER CAR IN THE INCIDENT WAS NOT DRIVABLE AND ALSO HAD TO BE TOWED. ONE OF THE POLICEMEN THAT RESPONDED TO OUR CALL SAID THAT THEY HAD A SIMILAR ACCIDENT HAPPEN WITH ONE OF THEIR POLICE CRUISERS (ANOTHER FORD PRODUCT); WHEN THE CAR WAS PUT INTO REVERSE IT SHOT BACKWARDS AND HIT ANOTHER POLICE CAR, BUT THEY DID NOT SUSTAIN DAMAGE BECAUSE THE CARS WERE PARKED SO CLOSE TO EACH OTHER. PLEASE HELP US FIGURE THIS OUT. WE ARE AFRAID TO GET BACK INTO THE VEHICLE. AS OF THIS DATE, FORD HAS NOT FIGURED OUT WHAT COULD HAVE HAPPENED TO THE VEHICLE. WE ALSO FOUND ON THIS WEBSITE SIMILAR INCIDENTS WITH THIS MODEL OF THE EXPLORER. WE ARE ALSO WAITING FOR OUR INSURANCE ADJUSTER'S REVIEW OF THE INCIDENT BEFORE THE COLLISION WORK TAKES PLACE. *NM
Power train, Nov 21, 2006
DT*: THE CONTACT STATED WHILE SHIFTING THE TRANSMISSION INTO GEAR, THE VEHICLE JUMPED. THE PROBLEM PROGRESSIVELY WORSENED AND THE VEHICLE DID NOT RESPOND PROPERLY TO THE DEPRESSION OF THE ACCELERATOR PEDAL. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, WHERE DIAGNOSTIC TESTS DETERMINED THE TRANSMISSION NEEDED TO BE REPLACED.
Power train, Nov 15, 2006, crash
2004 FORD EXPLORER. TRANSMISSION SHIFTS ROUGHLY INTO REVERSE AND THIRD GEAR. CAR WAS PUT INTO REVERSE IN JUNE, 2004 AND DID NOT MOVE UNTIL A FEW SECONDS LATER, AND THEN LUNGED BACKWARDS, HITTING MY WIFE AND BREAKING HER ARM. STILL SHIFTS ROUGHLY TO THIS DAY. *JB
Power train, Nov 7, 2006
SHIFTING FROM "DRIVE" TO "REVERSE" TRANSMISSION ENGAGES HARSHLY. *NM
Power train, Nov 3, 2006
DELAYED HARSH REVERSE ENGAGEMENTS
Steering, Service brakes, Hydraulic, Power train, Visibility, Latches/locks/linkages, Oct 30, 2006
2004 EXPLORER HAD PROBLEMS WITH BRAKES AND WINDOWS. *TS THREE MONTHS AFTER THE VEHICLE WAS PURCHASED THEE WAS A RECALL ON THE TRANSMISSION. THE ABS MALFUNCTIONED AND THE POWER WINDOWS WOULD NOT GO DOWN. THE REAR HATCH DOOR WOULD NOT OPEN. THE TRANSMISSION BEGAN TO SLAM INTO GEAR. THE ROTORS VIBRATED IN THE REAR. CONSUMER HEARD A HOWLING NOISE AT 40-55 MPH. THE DEALER REPLACED THE RING AND PINION. NM
Power train, Oct 30, 2006
WHEN MOVING GEAR SELECTOR FROM PARK TO REVERSE AND SOMETIMES DRIVE, THERE IS A LAG OF ABOUT 3 TO 5 SECONDS AND THEN A LOUD CLUNKING NOISE FOLLOWED BY A POWER SURGE OF VEHICLE GOING INTO GEAR. WORRIED TRANSMISSION IS FAILING AGAIN. TOOK IN FOR REPAIRS SAME ON SAME INCIDENT THEY SAID IT WAS FIXED. AND GUESS WHAT, I BELIEVED THEM. *JB
Power train, Oct 23, 2006
DURING THE ACCELERATION FROM A STOP LIGHT THE VEHICLE WOULD NOT SHIFT FROM 2ND TO 3RD. THE OVERDRIVE OFF LIGHT THEN BEGAN FLASHING. THIS CAUSED UNEXPECTED POOR ACCELERATION AND IN TRAFFIC COULD RESULT IN POSSIBLY BEING REAR ENDED BY TRAFFIC BEHIND YOU. *NM
Power train, Oct 16, 2006
THE TRANSMISSION STARTED HAVING PROBLEMS AFTER JUST A COUPLE OF MONTHS. THE FIRST TIME I WAS TOLD THEY HAD TO ADD AN ADDITIVE TO THE TRANSMISSION. IT HAS BEEN IN 2 MORE TIMES FOR THIS AND THIS FRIDAY I JUST GOT IT BACK FROM TRANSMISSION REPAIR ONLY TO GO OUT AND FIND TRANNY FLUID ALL OVER MY GARAGE (70 MILES AFTER THEY FIXED IT AGAIN) I ALSO HAD THE STARTER GO OUT IN IT AND NOW THEY STILL CANT FIND WHAT IS CAUSING IT...(LIKELY STORY). *NM
Service brakes, Hydraulic, Power train, Oct 12, 2006
MULTIPLE PROBLEMS WITH MY EXPLORER. WHEN SHIFTING INTO REVERSE CAR JOLTS WITH A CLUNKING NOISE. WHILE DRIVING CAR JOLTS OCCASIONALLY. WHEN BRAKING CAR SHAKES. ABS LIGHT IS ON AND 4X4 HIGH LIGHT FLASHES. EXPLORER WAS TAKEN IN DECEMBER 2004 AND FIXED FOR THE TRUCK JOLTING INTO REVERSE. TRUCK NOW HAVING THE SAME PROBLEM. TRUCK TO BE TAKEN BACK TO THE DEALER NEXT WEEK. *NM
Power train, Oct 3, 2006
WE HAVE A 2004 FORD EXPLORER V8 SPORT. WE HAVE HAD TWO MAJOR TRANSMISSION PROBLEMS AND NOW WE HAVE A SHAKING IN THE FRONT END AFTER THE LATEST REPAIR TO THE TRANSMISSION. *JB
Power train, Sep 20, 2006
I AM HAVING PROBLEMS WITH THE AUTOMATIC TRANSMISSION ON MY 2004 FORD EXPLORER (44,000 MILES). I WAS HAVING MY AC FIXED AT MY LOCAL DEALERSHIP WHEN THEY INFORMED ME THERE WAS AN OIL ADDITIVE THAT NEEDED TO BE PUT INTO MY TRANSMISSION TO PREVENT HESITATION AND SLIPPING DUE TO A MANUFACTURING PROBLEM. 6 MONTHS LATER I BEGAN EXPERIENCING HARSH ENGAGEMENT WHEN SHIFTING INTO REVERSE AS WELL SLIPPING IN THE TRANSMISSION WHEN SPEEDING UP AND SLOWING DOWN. I BROUGHT THE CAR BACK TO MY LOCAL DEALERSHIP (WORLD FORD) WHERE THE WORK WAS DONE AND THEY EXPLAINED I MIGHT NEED TO INSTALL A SOLENOID INTO THE TRANSMISSION AND THAT WOULD COST ME $900.00. KNOWING THAT THIS IS A PROBLEM FROM THE MANUFACTURER I CONTACTED FORD CORPORATE HEADQUARTERS AND EXPLAINED EVERYTHING. FORD CORPORATE RAN ME AROUND FOR ABOUT TWO WEEKS (HANGING UP THE PHONE, PLACING ME ON HOLD FOR A LONG TIME AND PROMISING TO CALL ME BACK BUT IT NEVER HAPPENS). I HAVE DONE QUITE A BIT OF RESEARCH ON THIS MATTER ONLY TO FIND OUT THAT THERE ARE THOUSANDS OF PEOPLE WITH THE SAME PROBLEM. I FOUND OUT THAT DURING THE MANUFACTURING OF MY VEHICLE AN IMPROPERLY FORMULATED TRANSMISSION FLUID WAS USED IN THE TRANSMISSION. I ALSO SPOKE TO SEVERAL PEOPLE WITH THIS PROBLEM AND I WAS TOLD THE $900.00 SOLENOID DOES NOT HELP THE PROBLEM AT ALL. I WOULD LIKE TO KNOW WHAT ACTIONS I CAN TAKE TO GET MY CAR REPAIRED. THANK YOU IN ADVANCE FOR ALL YOUR HELP. *NM
Power train, Sep 12, 2006
I HAVE A 2004 FORD EXPLORER XLT 4X4 WHICH RECENTLY HAD TO BASICALLY HAVE THE TRANSMISSION REBUILT. I FEEL THAT THIS IS A MANUFACTURER DEFECT SIMPLY BECAUSE THE VEHICLE IS ONLY 2 YEARS OLD. SINCE THE WARRANTY IS EXCEEDED IN MILEAGE I WAS RESPONSIBLE FOR REPAIRS, WHICH TOTALED $1652.78. THE VEHICLE HAD JUST UNDER 56,000 MILES WHEN THIS OCCURRED. I WOULD GREATLY APPRECIATE ANY HELP WITH INVESTIGATING THIS PROBLEM. JUST A LITTLE PIECE OF INFO, I ALSO HAVE A FRIEND THAT HAS A 2002 EXPLORER THAT HAD THE SAME IDENTICAL PROBLEM. I DO NOT FIND THAT TO BE COINCIDENTAL! AND HER VEHICLE HAD ABOUT 70,000 MILES ON IT WHEN THIS HAPPENED TO HER. *NM
Engine and engine cooling, Power train, Sep 8, 2006
DT*: THE CONTACT STATED THE AUTOMATIC TRANSMISSION WAS SLIPPING BETWEEN GEARS AND MADE CLUNKING NOISES. THE VEHICLE ALSO MADE HUMMING SOUNDS FROM THE ENGINE WHILE ACCELERATED OVER 55 MPH. THE VEHICLE HAS NOT BEEN TO A SERVICE DEALER.
Power train, Sep 7, 2006
MY 2004 FORD EXPLORER WAS TAKEN IN FOR REPAIR IN 8/12/05 BECAUSE THE AC STOPPED WORKING. WHEN I BROUGHT THE CAR INTO WORLD FORD OF KENDALL IN MIAMI, FL ONE OF THE SERVICE EMPLOYEES ASKED ME IF HOW MY TRANSMISSION WAS WORKING AND AT THE TIME IT WAS FINE. UPON RECEIVING MY CAR BACK ON 8/16/05 THE AC WAS FIXED AND MY RECEIPT STATED THE AC WAS FIXED BUT IT ALSO MENTIONED SOMETHING REGARDING A RECALL IN MY TRANSMISSION. THE RECEIPT SAID THERE WAS AN OIL ADDITIVE PLACED IN MY TRANSMISSION. 1 YEAR AND 1 MONTH LATER MY TRANSMISSION HAS BEGUN SLIPPING AND HESITATING. WHEN I BROUGHT MY CAR BACK TO WORLD FORD OF KENDALL IN MIAMI, FL TO SPEAK TO THEM REGARDING MY TRANSMISSION I WAS TOLD THAT THEIR SERVICE WORK IS GUARANTEED UP TO 12 MONTHS SO THERE WAS NOTHING THEY CAN DO FOR ME. UPON DOING MY OWN RESEARCH I FOUND THAT THE OIL ADDITIVE THAT WAS PLACED IN MY FORD WAS TO PREVENT THE SLIPPING AND HESITATION OF MY TRANSMISSION. I CALLED THE CORPORATE HEADQUARTERS OF FORD AND THEY TOLD ME THAT THERE IS NOTHING THEY CAN DO FOR ME. IT IS OBVIOUS THAT FORD KNEW ABOUT MY TRANSMISSION PROBLEMS OR A RECALL SERVICE WOULD NEVER HAVE BEEN DONE. THEY NOW WANT TO CHARGE ME TO FIX THE TRANSMISSION ON A CAR THAT WAS BROKEN WHEN IT LEFT THE MANUFACTURING PLANT. MY CAR HAS 45,000 MILES AND NO WHERE IN MY PAPERWORK OR MY CAR MANUAL DOES IT STATE I WOULD HAVE TO PUT AND OIL ADDITIVE IN MY CAR BY 45,000 MILES. WHEN I SPOKE TO FORD CORPORATE HEADQUARTERS THEY TOLD ME IF THE OIL ADDITIVE DOES NOT WORK ANOTHER PROCEDURE WOULD HAVE TO BE DONE BUT IT WOULD NOT BE COVERED. THIS IS UNACCEPTABLE ESPECIALLY FROM A LARGE CORPORATION SUCH AS FORD. MY FAMILY DRIVES THIS CAR AND I BELIEVE WE HAVE AN UNSAFE CAR RESULTING FROM A RECALL IN MY TRANSMISSION. I ADDITION TO THE TRANSMISSION RECALL, THE AC IN MY CAR HAS ALSO BROKEN TWICE AND NOBODY WANTS TO EXPLAIN TO ME WHY THERE ARE SO MY PROBLEMS WITH A 2 YEAR OLD CAR. I WOULD APPRECIATE A RESPONSE OR AT LEAST SOME GOOD ADVICE. THANKS AGAIN. *NM
Power train, Sep 6, 2006
BOUGHT IN FEB. 2006 WITH 12,000 MILES - THE 2004 EXPLORER XLS WHEN PUT INTO REVERSE HESITATED, THEN JERKED HARD AT FIRST -- THEN AS TIME WENT BY -- APPROXIMATELY 2-3 MONTHS THE JERKING WAS WHILE AUTOMATICALLY SHIFTING WHILE DRIVING. THE JERKING MOTION OCCURRED 17 TIMES WHILE DRIVING 35 MILES. IT SEEMS TO BE GETTING WORSE OVER TIME. I'VE BEEN TO THE DEALER AND THEY REPROGRAMMED THE COMPUTER. THE DEALER MANAGER SAID THAT IT STILL JERKS IN REVERSE AFTER THE 3RD TIME AND OFFERED NO REMEDY OF ANY KIND, JUST $79.00 AND THERE YOU GO. ALL THIS WITHIN 20,000 MILES. I DON'T FEEL SAFE DRIVING - WHAT IF I NEED THAT REVERSE QUICK TO AVOID AN ACCIDENT AND THERE IS A HESITATION IN TRANSMISSION SHIFTING???*JB
Power train, Aug 29, 2006
PURCHASED A NEW 2004 FORD EXPLORER IN AUGUST OF 2004. BROUGHT SUV IN FOR RECALL OF TRANSMISSION FLUID ADDITIVE/REPLACEMENT. SUV STARTING TO HESITATE AND JUMP INTO REVERSE. WHEN STOPPED AT A LIGHT OR STOP SIGN ON A HILL THE VEHICLE ROLLS BACKWARD WHEN MOVING MY FOOT FROM THE BRAKE TO THE GAS PEDAL. BROUGHT BACK TO DEALER IN JULY OF 2006, REPLACED SOLENOID AT APPROXIMATELY 16,000 MILES. WHEN VEHICLE IS STARTED REVS A LITTLE HIGH THEN BALANCES OUT. LEATHER SEATS ALSO CRACKING AND DEALER WILL NOT REPLACE THEM STATING THAT IT IS SIMPLY WEAR AND TEAR. *JB
Power train, Aug 24, 2006
DT*: THE CONTACT STATED THE AUTOMATIC TRANSMISSION DID NOT ENGAGE GEARS IN A TIMELY MANNER. THE PROBLEM STARTED AFTER 41000 MILES AND WAS NOT TAKEN TO A SERVICE DEALER.
Power train, Aug 17, 2006
2004 FORD EXPLORER WHEN SHIFTED INTO PARK WILL SHOW IT IS IN PARK BUT IS REALLY STILL IN REVERSE. THIS IS A MAJOR SAFETY ISSUE WHICH HAS NOT BEEN RECALLED. IN ADDITION THERE WAS A RECALL FOR IMPROPER TRANSMISSION ADDITIVE BEING USED AND NOW THE TRANSMISSION SOLENOID ON THESE MODELS ARE GOING BAD CAUSING THE TRANSMISSION TO SHIFT ERRATICALLY. *NM