2004 Ford Explorer
Problems, recalls and owner-reported issues
Power train is the leading concern among 1,408 owner complaints filed for this model year. This is the 7th highest complaint count among 26 Explorer model years with reports.
Of the 2004 reports, 75 involved a crash and 16 involved a fire. 105 people were injured.
What owners report most often
Recalls and investigations
Exterior lighting, headlightsMay 11, 2009
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Campaign 09E025000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Exterior lightingMay 24, 2006
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Campaign 06E049000 on NHTSA.gov
Exterior lightingMar 23, 2006
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Campaign 06E026000 on NHTSA.gov
Representative owner complaints: power train
477 reports, newest first. Show all
Power train, May 10, 2010
WHILE DRIVING NORMALLY, 'O/D OFF' LIGHT ON DASHBOARD COMES ON. UNABLE TO ACCELERATE AND/OR VEHICLE SHUTS OFF; THE REMEDY: HAVING TRANSMISSION REBUILT OR REPAIRED. THIS HAS OCCURRED THREE TIMES IN 3 YEARS. SAW ON A 6PAGE FORUM OF OTHER FORD OWNERS HAVING THE SAME PROBLEM. REPAIRING A TRANSMISSION IS COSTLY AND ITS NOT ONE REPAIR IT'S MULTIPLE OVER THE LIFE OF OWNING THE VEHICLE. *TR
Power train, Apr 21, 2010
I HAVE BEEN DRIVING A 2004 FORD EXPLORER SINCE DECEMBER 2004 WHEN MY DAUGHTER LEFT IT FOR ME WHEN SHE MOVED. IT HAD APPROXIMATELY 11,000 MILES. SHE HAD NOTICED A HARD SHIFT, ESPECIALLY WHEN GOING INTO REVERSE AND A ROUGH IDLE AND VIBRATION, BUT HAD NOT HAD A CHANCE TO HAVE IT LOOKED AT. EXCEPT FOR WHEN I HAVE BEEN OUT OF TOWN, I HAVE SERVICED THAT CAR AT A FORD DEALERSHIP RELIGIOUSLY. I COMPLAINED ABOUT THESE PROBLEMS BUT NOTHING WAS EVER FOUND. I WAS NOT EVEN TOLD ABOUT SOME OF THE THINGS I HAVE READ ABOUT ON YOUR WEBSITE WHICH SEEM TO INDICATE THAT FORD WAS AWARE OF THE PROBLEMS AND CAUSES. FINALLY, AT JUST UNDER 36,000 MILES, THE TRANSMISSION FAILED AND HAD TO BE REPLACED. NOW, 47,000 MILES LATER, THIS NEW TRANSMISSION IS LEAKING AND THEY HAVE TO TAKE IT OUT TO SEE WHERE IT'S LEAKING FROM. I READ HERE ABOUT THAT PROBLEM, TOO. TO ME, IT IS CLEAR THAT FORD IS USING MICKEY MOUSE TRANSMISSIONS WHICH, OF COURSE, POSE A SAFETY HAZARD DEPENDING ON WHEN, WHERE, AND HOW THE FAILURE MANIFESTS ITSELF, AND IS ALSO AN AFFRONT TO THE CONSUMER WHO IS BEING DEFRAUDED BY BEING SOLD A FAR MORE INFERIOR VEHICLE THAN THE ONE FOR WHICH THEY BARGAINED. SO, HOW'S YOUR INVESTIGATION GOING? *TR
Power train, Apr 12, 2010, crash
WHEN I SHIFT FROM DRIVE OR NEUTRAL INTO REVERSE, THERE IS A LONG HESITATION BEFORE THE CAR THEN LEAPS BACKWARD HARD. DELAY THEN HARD REVERSE. WHEN I AM PARALLEL PARKING, I HAVE SOMETIMES HIT THE CAR BEHIND ME HARD BECAUSE OF THIS. THIS PROBLEM HAS BEEN EXTENTED SINCE I PURCHASED THE CAR NEW IN 2004. I HAVE BROUGHT THE CAR INTO THE DEALER AT LEAST TEN TIMES WHEN IT WAS NEW. THEY MADE MANY CHANGES, INCLUDING AN ENTIRELY NEW "BOX" OF A SORT I DON'T RECALL, ALL TO NO AVAIL, FINALLY TELLING ME THE PROBLEM WAS CAUSED BY INSTALLING THE WRONG TRANS FLUID AT MANUFACTURING. RECALL NECESSARY. *TR
Power train, Mar 24, 2010
2004 FORD EXPLORER V8 120000 MILES DRIVING DOWN ROAD AT 45MPH NO WARNING OVER DRIVE LIGHT STARTED FLASHING, CHECK TRANSMISSION LIGHT CAME ON & LOST ALL GEARS. PULLED OVER TURNED CAR OFF RESTARTED IT DROVE 5 FEET SAME PROBLEM. TOWED TO REPAIR SHOP THE PULLED CODES & SAID THE SOLINOID PACK INTERNALLY NEEDED TO BE REPLACED. THEY DID THAT PROBLEM IS STILL OCCURING. NOW LOOKS LIKE NEEDS A TRANI. I TOOK IT IN SEVERAL TIMES UNDER WARRENTY BUT THEY COULD NEVER DUPLICATE IT. NOW ITS NOT UNDER WARRENTY & FORD WONT TAKE CARE OF IT.
Power train, Mar 24, 2010
GEAR SHIFT LEVER ON THE STEERING WHEEL COLUMN BROKE OFF WHEN TRIED TO TAKE IT OUT OF PARK, ON MY 2004 FORD EXPLORER. CHECKING THE INTERNET FOR THIS PROBLEM I SEE IT HAS HAPPENED TO HUNDREDS OF PEOPLE WITH FORD EXPLORERS, NO HELP THROUGH FORD, A RECALL NEEDS TO BE DONE. TO MANY PEOPLE WITH THE SAME PROBLEM.
Power train, Mar 21, 2010
AUTOMATIC TRANSMISSION HESITATE WHEN GOING INTO GEAR THEN SHIFTS HARD INTO GEAR WHILE ACCELERATING,FORD IS WELL AWARE THERE IS A PROBLEM WITH THESE TRANSMISSIONS AND SHOULD BE RECALLED FOR REPAIRS. HAVE DONE RESEARCH ON THIS AND ITS A COMMON SAFETY PROBLEMS WITH THE FORD EXPLORER. *TR
Power train, Mar 19, 2010
TRANSMISSION CONTINUALLY FAILS TO ENGAGE PROPERLY. DELAYED RESPONSE AND HARSH SHIFT IN GEARS. FROM REVERSE TO DRIVE AND VICE VERSA, THERE IS A DELAY AND HARSH ENGAGEMENT. AT FIRST THE INCIDENTS WERE BARELY NOTICEABLE AND LESS FREQUENT. NOW THEY ARE A COMMON OCCURRENCE AND MORE PRONOUNCED. FEARFUL OF COMPLETE FAILURE WHILST ACCELERATING ONTO HIGHWAY/STREET. OFTEN TIMES THERE IS A DELAY SHIFTING INTO DRIVE WHEN REVERSING OUT OF A PARKING SPOT. HOLDING UP TRAFFIC, ETC. *TR
Power train, Mar 17, 2010
PURCHASED A USED 2004 FORD EXPLORER ON JULY 3, 2006 WITH 53823 MILES. THE CAR WAS MAINTAINED AS REQUIRED AND LOW AND BEHOLD, TO MY RECOLLECTION, AROUND 2008-2009 IT STARTED DRIVING A LITTLE STRANGE, IT STARTED VIBRATING HESITATING. THEN DURING THE BEGINNING OF 2009, CHECK ENGINE LIGHT CAME ON, OD LIGHT STARTED FLASHING, GEARS STARTED STICKING, HARD TO BRAKE AND I WAS TOLD THAT IT IA A TRANSMISSION PROBLEM AND THAT I WAS NOT ALONE WITH THE PROBLEM. A NEW OR REBUILT TRANSMISSION WAS NECESSARY AT A PRICE OF $3-4,000. IF YOU WOULD GO ON THE WEB SITE AT AUTOBEEF. COM, YOU WILL SEE ALL THE COMPLAINTS CONSUMERS ARE HAVING ABOUT THE SAME PROBLEM. I AM URGING YOU TO PLEASE INVESTIGATE THIS MATTER. FORD NEEDS TO STEP UP TO THE PLATE AND RECALL ALL EXPLORERS. I STILL OWE $9000 ON THIS CAR AND CAN NOT DRIVE IT. I BAILED THEM OUT AND THEY NEED TO TAKE RESPONSIBILITY FOR THEIR FAULTY TRANSMISSIONS. DISAPPOINTED AND CONCERNED CONSUMER. THANK YOU. *TR
Power train, Mar 17, 2010
VEHICLE PURCHASED WITH 78,375 MILES - IT WAS PREVIOUSLY A US GOV.'T VEHICLE. REAR-END NOISE NOTICED AND SELLER HAD FORD REPAIR AT A COST OF $1,387.50 - VEHICLE WAS DRIVEN LESS THAN 12,000 MILES AND BEGAN MAKING SAME NOISE IN REAR-END. DUE TO DISTANCE TO FORD DEALER, VEHICLE WAS CHECKED OUT AT A PRIVATE REPAIR SERVICE. DIAGNOSIS- REAR SEAL FAILED CAUSING SEVERE DAMAGE TO ALL REAR-END PARTS. REPAIRS INCLUDED RING & PINION GEARS AND DIFFERENTIAL BEARINGS AT A COST OF $1,429.54 WHEN CONTACTED, FORD STATED THAT ALTHOUGH IT WAS WITHIN THE 12,000 MILE, 12 MONTH WARRANTY PERIOD, THEY WOULD NOT COVER ANY OF THE COSTS BECAUSE THE SERVICE WAS NOT DONE AT A FORD DEALERSHIP. *TR
Power train, Feb 24, 2010
2004 FORD EXPLORER. OD LIGHT IS BLINKING, SERVICE ENGINE LIGHT IS ON, TRANSMISSION SHIFT STALLS AND LURKS. MECHANIC SAYS ALOT OF FORD EXPLORERS ARE HAVING THIS ISSUE AND THERE IS NO RECALL. *TR
Power train, Feb 15, 2010
PURCHASED A 2004 FORD EXPLORER IN 2006, NOTICED AFTER A COUPLE OF MONTHS THAT WHEN PUT THE CAR IN REVERSE WOULD DELAY A FEW SECONDS AND THEN IT WOULD MAKE A CLUNK SOUND AND THEN SPEED INTO REVERSE, THAT WAS AT ABOUT 50,000 MILES WHEN PURCHASED. IN APRIL OF 2009 CAR WOULD NOT GO INTO REVERSE, HAD A TRANSMISSION REBUILD. IT IS NOW LESS THEN A YEAR SINCE REBUILD AND IT IS STARTING TO SHIFT HARD AGAIN AND WHILE AT A STOP LIGHT TODAY WHEN I HAD MY ON THE BRAKE IT MADE A CLUNK SOUND AND JUMPED FORWARD? GOOD THING NO OTHER CAR WAS IN FRONT OF ME, I CHECKED MY REAR VIEW MIRROR AND THERE WAS NO CAR BEHIND ME, SO I WAS NOT HIT. ALSO CAR IS STARTING TO DELAY WHEN AT A STOPPED POSITION TO START DRIVING THE CAR HESITATES TO GO INTO GEAR. DOES IT TAKE SOMEONE TO GET SERIOUSLY INJURED OR DIE BEFORE THIS PROBLEM IS GOING TO BE RESOLVED BY AN OBVIOUS MANUFACTURER ERROR???? I HAVE TWO CHILDREN THAT GET DRIVEN AROUND ON A REGULAR BASIS AND I AM NOW WORRIED THAT SOMETHING IS GOING TO HAPPEN. I AM TAKING MY FORD BACK IN TO HAVE THE TRANSMISSION GUY THAT REPAIRED IT LOOK AT THE VEHICLE. UHAUL WILL NOT LET ANY FORD EXPLORERS TOW THEIR PRODUCTS. *TR
Power train, Feb 13, 2010
I BOUGHT MY 2004 FORD EXPLORER LIMITED FEB 2008. THE ONLY WORK DONE WAS OIL CHANGES, TIRE ROTATIONS ETC....AROUND 50,000 MILES SUDDENLY 1) THE CRUISE CONTROL STOPPED FUNCTIONING PROPERLY. WHEN USED IT CAUSES THE VEHICLE TO STALL..... 2) A CRACK APPEARED IN THE HATCH FOR NO APPARENT REASON. NO ACCIDENTS, NO WEATHER ISSUES.... 3) THE O/D LIGHT COMES ON AND THE TRANSMISSION SYMBOL LIGHTS UP. HESITATES WENT PUT IN REVERSE THEN JERKS INTO MOVEMENT. REPAIR SHOP SAYS THE TRANSMISSION NEEDS REPAIRS COSTING 2000+. *TR
Power train, Jan 22, 2010
I LEFT MY VEHICLE RUNNING IN PARK TO DROP OFF A GIFT TO A FRIEND. I ENDED UP STAYING LONGER THAN INTENDED, AND WAS TAKEN OUTSIDE BY A LOUD NOISE. AFTER IDLING IN PARKED FOR 20-30 MINUTES, MY EXPLORER HAD SMASHED INTO MY FRIENDS GARAGE DOOR CAUSING NEARLY $500 IN DAMAGES TO THE DOOR AND SCRATCHES TO THE VEHICLE. NOTHING HAS BEEN DONE ABOUT THE PROBLEM, EXCEPT WE WILL NOT LET THE EXPLORER IDLE IN PARK. *TR
Power train, Jan 19, 2010
THE TRANSMISSION WAS SLIPPING AND FINALLY ONE DAY I PUT THE CAR IN REVERSE AND THE CAR DID NOT EVEN MOVE. I HAD TO GET MY TRANSMISSION REBUILT AT 60,000 MILES. I ALSO AM HAVING A BIG PROBLEM WITH THE PAINT PEELING OFF THE ROOF OF THE CAR NEAR WHICH WAS NOT COVERED UNDER ANY WARRANTY WHICH IS CRAZY ESPECIALLY WHEN THE SERVICE DEPT AT MY LOCAL FORD DEALERSHIP SAYS THAT MY YEAR AND MAKE HAS PAINT PROBLEMS AND THEY HAVE SEEN IT HAPPEN MANY TIMES BUT NO RECALL WAS EVER ISSUED. *TR
Power train, Structure, Dec 18, 2009
THE BACK HATCH HAS A CRACK UNDERNEATH THE WINDOW IN THE MIDDLE AROUND THE FORD EMBLEM. JUST APPEARED....AS I'VE NOTICED SEVERAL FORD 2004 EXPLORERS IN THIS AREA HAVE THE EXACT SAME DEFECT. RECALL IS VERY MUCH NECESSARY. AS WELL AS THE CAR JOLTING INTO DRIVE AND REVERSE....I STILL OWE SEVERAL THOUSAND DOLLARS ON THIS LOAN AND REFUSE TO PAY FOR ANY REPAIRS....FORD SHOULD DO A RECALL ON BOTH...THEY NEED TO HIRE SOME JAPANESE WORKERS SINCE THEIR CARS SEEM NOT TO HAVE THESE TYPES OF ISSUES.....I BOUGHT THIS CAR IN FEB OF 2008 AND HAD THE TRANSMISSION PROBLEMS RIGHT AFTER THAT.....CAR ONLY HAD 48K MILES ON IT. *TR
Power train, Dec 16, 2009
TL* THE CONTACT OWNS A 2004 FORD EXPLORER. WHILE DRIVING THE TRANSMISSION WILL SLIP FROM SECOND TO THIRD GEAR. THE VEHICLE SHIFTS VERY ROUGHLY INTO THE REVERSE GEAR. ALSO THE GLASS FROM THE REAR WINDOW HAS LOOSENED FROM THE FRAME DUE TO THE CLIPS. THE MANUFACTURER WAS NOTIFIED, BUT NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 99,240.
Power train, Nov 29, 2009
WHEN SHIFTING INTO REVERSE, THE CAR JERKS (SHIFTS HARD) BACKWARDS EVERY TIME. EVENTUALLY, TRANSMISSION HAD TO BE REBUILT. THE PROBLEM NO LONGER EXISTS. *TR
Steering, Power train, Nov 27, 2009
WHEN SHIFTING INTO REVERSE THERE IS A HARD SHIFT ALSO HARD SHIFTS UP AND DOWN WHILE GOING FORWARD. *TR
Power train, Nov 17, 2009
EXPLORER JERKING AND BUCKING WHEN PUT INTO REVERSE. PROBLEM EVENTUALLY WORSENED WITH BUCKING ONCE PUT INTO DRIVE. BOUGHT USED AT 31,000 MILES. SYMPTOM EVIDENCED AT JUST OVER 33,000 MILES. TRANSMISSION REPLACED AT COST OF NEARLY $4,000. ADDRESSED THIS ISSUE WITH FORD . RESPONSE- SYMPATHETIC BUT NOTHING THEY CAN DO? OR IS THERE? DESIGN OR MANUFACTURER ERROR. EITHER WAY ACCOUNTABILITY SHOULD NOT BE AN ISSUE. LAST FORD I WILL OWN. *TR
Power train, Nov 13, 2009
2004 FORD EXPLORER-SERIOUS TRANSMISSION ISSUES WITH GEARS SLIPPING/FAILING. HUGE DELAY IN REVERSE THEN A LARGE JOLT BACK IS VERY DANGEROUS. *TR
Power train, Nov 11, 2009, crash
HAVE A 2004 FORD EXPLORER WITH BAD TRANSMISSION. DELAY IN SHIFTING IN REVERSE AND A JOLT INTO GEAR CAUSED BE TO SLAM INTO ITEMS IN MY GARAGE. ALTHOUGH NO ONE WAS HURT, IT CAN HAPPEN. FORD HAS KNOW OF THIS ISSUE AS WELL AS 2-3 GEARS SLIPPING WHICH CAN CAUSE A SLOWING OF THE VEHICLE IN TRAFFIC. *TR
Power train, Nov 11, 2009, fire
2004/FORD EXPLORER FIRE WHILE PARKED IN PARKING DECK,THERE WAS NO PREVIOUS WARNINGS ,OF ANY KIND. TRUCK WAS RUNNING WELL ,NO SERVICE LIGHTS EVER CAME ON. TRUCK ONLY HAS 40,000 MILES ON IT. NEVER HAD ANY SINGS OR SYMPTOMS,THAT ANYTHING WAS GOING TO HAPPEN. I HAVE A POLICE REPORT. FIRE DEPT. REPORT. ALSO VALET PARKING MANAGERS REPORT FROM 11/6/09.NOW TRUCK IS AT TOMS FORD ,HAZLET NJ. WE NEED TO KNOW WHAT WENT WRONG , THERE WAS NO PRIOR WARNING TO THIS EVENT. THANK GOD I WASN'T ON THE HWY WHEN THIS OCCURRED WITH MY GRANDDAUGHTER 27 MTHS . PLEASE HELP! *TR
Suspension, Power train, Electrical system, Structure, Vehicle speed control, Nov 5, 2009
TL* THE CONTACT OWNS A 2004 FORD EXPLORER. WHEN HE ACTIVATED THE CRUISE CONTROL WHILE DRIVING, IT DEACTIVATED ITSELF WITHOUT WARNING. HE HAD TO RESTART THE VEHICLE TO RE-SET THE ERROR CODE. THE FAILURE OCCURRED INTERMITTENTLY, AND MOSTLY ON THE INTERSTATE. ALSO WHEN HE WOULD TURN ON THE TURN SIGNALS, THE AUTOMATIC WARNING SYSTEM WOULD MAKE AN ALARM NOISE AND BLINK UNTIL THE TURN SIGNAL WOULD CUT OFF. THE AUTOMATIC TRANSMISSION APPEARED TO LOSE FLUID, WHEN HE SHIFTED INTO REVERSE. HE HEARD A ROARING NOISE NEAR THE TIRE AREA. HE WAS TOLD BY THE DEALER THAT THE HUBS NEEDED TO BE REPLACED. LASTLY, THE AESTHETIC PIECE ON THE LOWER HALF OF THE HATCH-BACK HAD CRACKED AND SEPARATED FROM THE VEHICLE. HE TOOK THE VEHICLE BACK TO THE DEALERSHIP AND WAS ADVISED THAT THERE WAS AN ELECTRICAL FAILURE. NO REPAIRS WERE MADE. THE MANUFACTURER REFERRED HIM TO NHTSA. THE CURRENT MILEAGE WAS APPROXIMATELY 68,000. THE FAILURE MILEAGE WAS APPROXIMATELY 52,000.
Power train, Oct 13, 2009
MY 2004 FORD EXPLORER AWD HAS A TRANSMISSION ISSUE. WHEN THE TRANSMISSION IS PLACED IN REVERSE OR INTO DRIVE, THE TRANSMISSION WILL OFTEN SHIFT INTO GEAR VERY HARD AND CAUSE THE CAR TO SUDDENLY MOVE BACKWARDS OR FORWARDS IN A VIOLENT MANNER. THE CAR WILL MOVE WHILE THE BRAKE IS APPLIED AND I FEAR THIS TRANSMISSION ISSUE WILL CAUSE SOME TYPE OF FAILURE IN THE FUTURE CAUSING THE CAR TO GO FORWARD OR BACKWARD WITH NO CONTROL. IT SHIFTS SO HARD FROM PARK INTO GEAR IT FEELS AS IF ANOTHER CAR HAS RAN INTO THE BACK OF MY CAR. I HAVE READ IDENTICAL REPORTS ONLINE FROM NUMEROUS OTHER PEOPLE INVOLVING FORD EXPLORERS AROUND THIS MODEL YEAR TIMEFRAME. *TR
Power train, Oct 8, 2009
ABOUT 75,000 MILES ON VEHICLE, PURCHASED NEW, REGULARLY SERVICED. ACCELERATING, THE O/D LIGHT CAME ON AND THE TRANSMISSION WENT "THUNK" AS IT TRIED TO SHIFT FROM 2ND TO 3RD. RESTARTING THE CAR THE O/D LIGHT WENT OFF AND THE CAR SHIFTED NORMALLY EXCEPT OCCASIONALLY THE CAR SHIFTS ROUGH. THE FORD DEALER WANTS $1800 TO $4200 TO REPAIR. *TR