2008 Ford Explorer
Problems, recalls and owner-reported issues
Electrical system is the leading concern among 148 owner complaints filed for this model year. This is the 21st highest complaint count among 26 Explorer model years with reports.
Of the 2008 reports, 6 involved a crash and 3 involved a fire. 3 people were injured.
What owners report most often
Recalls and investigations
EquipmentSep 3, 2010
MARATHON IS RECALLING CERTAIN SEAT COVERS, BRAND SUPERHIDES WITH PART NUMBERS 593, 594, 578, 960, 228, 228-09, 267-08, 333, 625, AND 630, SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE SEAT COVERS ARE MADE OF HEAVIER THREAD AND ARE NOT COMPATIBLE WITH SEATS CONTAINING SIDE AIRBAGS. THE HEAVIER SEAT COVER COULD INTERFERE WITH FULL DEPLOYMENT OF THE AIRBAG IN THE EVENT OF A CRASH.
AN IMPROPERLY DEPLOYED AIRBAG COULD RESULT IN SERIOUS INJURY.
MARATHON WILL NOTIFY OWNERS OF RECORD AND REPLACE THE SEAT COVER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 14, 2010. OWNERS MAY CONTACT MARATHON AT 1-800-735-2769.
Campaign 10E043000 on NHTSA.gov
Visibility, glass, side/rearDec 11, 2007
CERTAIN CURVED TEMPERED REPLACEMENT GLASS MANUFACTURED BY HANGZHOU SAFETY GLASS LTD AND SUPPLIED TO SAFELITE BY AUTO TEMP INC., IDENTIFIED AS DOT-430, AND SOLD FOR USE ON CERTAIN DOMESTIC AND FOREIGN VEHICLES MAY NOT BREAK INTO SMALL PIECES AS EXPECTED OF TEMPERED GLASS AND FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 205, "GLAZING MATERIALS."
IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT(S) MAY BE SERIOUSLY INJURED BY SHATTERED GLASS.
SAFELITE WILL NOTIFY ITS RETAIL CUSTOMERS AND REPLACE THE GLASS FREE OF CHARGE. RETAIL CUSTOMERS CAN CONTACT SAFELITE TOLL FREE AT 1-888-843-2906. SAFELITE WILL NOTIFY ITS WHOLESALE CUSTOMERS AND REIMBURSE WHOLESALE CUSTOMERS FOR CURRENT INVENTORY AND AT A SPECIFIED RATE FOR REPLACING THEIR CUSTOMER'S GLASS. WHOLESALE CUSTOMERS CAN CONTACT SAFELITE'S WHOLESALE DIVISION, SERVICE AUTOGLASS TOLL FREE AT 1-888-246-6298. THE RECALL BEGAN ON JANUARY 15, 2008.
Campaign 07E104000 on NHTSA.gov
Power train, automatic transmission, cooling unit and linesSep 26, 2007
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH THE 4.6L ENGINE AND 6R TRANSMISSION, THE BOLT SECURING THE TRANSMISSION OIL COOLER LINE FITTINGS AT THE TRANSMISSION MAY NOT HAVE BEEN SUFFICIENTLY TORQUED DURING VEHICLE ASSEMBLY. AS A RESULT, THE BOLT MAY LOOSEN AND THE TRANSMISSION OIL COOLER LINES MAY DISENGAGE FROM THE TRANSMISSION, CAUSING A TRANSMISSION FLUID LEAK.
IF LEAKING TRANSMISSION FLUID CONTACTS THE CATALYTIC CONVERTER, IT MAY POSE A RISK OF FIRE.
DEALERS WILL INSPECT AND HAVE THE TRANSMISSION COOLER LINE ATTACHMENT BOLT TIGHTENED FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 30, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Campaign 07V453000 on NHTSA.gov
Representative owner complaints: other or unspecified
11 reports, newest first. Show all
Other or unspecified, Engine, Apr 27, 2025
I got the car from my landlord, my husband never checked the oil or fluids even though I was on him, it died 2 months after we got it, the guy said before we purchased it that it still was under warranty for transmission, so when it died I thought ok it's covered, so the landlord said it was the motor it seized he said had no coolant and was 2qts of oil over I said well he never added anything & I said it never overheated, he said I don't know how it was done but it will cost $3800 to fix, so I was hoping that there might be a recall that can fix this or also he puts new rear in the car a week after I got it, does any of this sound like it is his side that is reliable to fix it?
Electrical system, Other or unspecified, Engine, Jul 13, 2019
MY FRIEND LET ME USE HIS VEHICLE BUT HE ALTERED IT AND IT IS MALFUNCTIONING . HE EXPLAINS AS IF WHEN I DON'T "BEHAVE" I HAVE REPERCUSSIONS. HE HAS ALTERED THE VEHICLE TREMENDOUSLY. IF WE GET AN ARGUMENT HE WILL TELL ME I HAVE X AMOUNT OF DAYS AND IN THOSE EXACT X AMOUNT OF DAYS THE CAR ENDS UP MESSING UP AND STOPPING. I WAS DRIVING FROM THE HOSPITAL ONE DAY AND ALL OF A SUDDEN THE VEHICLE STARTED SMOKING AND HE TOLD ME BECAUSE ITS HIS VEHICLE THAT HE WILL FIX IT HIM SELF. HE IS A CHEMICAL ENGINEER NOT A LICENSED MECHANIC TO TOUCH THE OBD ON THE CAR. HE CLAIMS HE IS BETTER THAN GENERAL MOTORS.
Other or unspecified, Oct 30, 2018
WHEN DRIVING THE VEHICLE THE CAR STOPS ACCELERATING. THE WRENCH LIGHT COMES ON BUT THE ENGINE IS STILL RUNNING BUT WHEN PRESSING THE ACCELERATOR, IT WILL NOT ACCELERATE. THE OPERATOR CAN STOP THE CAR AND TURN IT OFF AND BACK ON AND THIS SEEMS TO CLEAR THE FAULT. THE PROBLEM IS THAT IT STOPS IN TRAFFIC OR IN A TURN AND THIS CREATES A SAFETY HAZARD FOR THE OPERATOR. THE CODE DIRECTS ME TO REPLACE/REPAIR THE THROTTLE BODY. THIS HAS BEEN REPLACED ALONG WITH THE TPS AND THE PROBLEM IS STILL THERE. THERE SHOULD BE A FIX FOR THIS AS I HAVE READ SEVERAL COMPLAINTS IN REGARDS TO THIS AND THE OBVIOUS SAFETY RISK FACTOR ASSOCIATED WITH IT. I WOULD LIKE TO SEE IF THERE IS SOFTWARE CHANGE THAT CAN BE MADE TO THE CAR SO THAT IT WON'T ALLOW THE CAR TO SHUTDOWN LIKE THIS IF IT GETS A FAULT OR PROBLEM WITH THE THROTTLE BODY.
Steering, Other or unspecified, Apr 28, 2018
STIFFNESS IN STEERING WHEN YOU TURN THE WHEEL . NO SOUNDS COMING FROM POWER STEERING/BELT OR ANYTHING FOR THAT MATTER .. JUST WHEN YOU SLOW TO TURN IT'S STIFF
Power train, Other or unspecified, Jun 28, 2017
WHEN THE PROBLEM OCCURRED IT CAME FROM NOWHERE. I WAS DRIVING AS NORMAL THEN THERE WAS AN INITIAL LOSS OF POWER AS I NOTICED THE CHECK ENGINE LIGHT AND AN UNFAMILIAR ORANGE WRENCH WERE NOW ILLUMINATED. SEEMING AS I HAD NO POWER I CAUTIOUSLY GUIDED THE VEHICLE TO THE SHOULDER OF THE EXPRESSWAY. SINCE THEN I'VE TRIED HAVING THE PROBLEM FIXED TO NO AVAIL, BECAUSE IT'S INTERMITTENT AND FORD THEMSELVES HAVE NO REMEDY. ALSO, TOOK IT UPON MYSELF TO CONTACT FORD TO BE TOLD THE VEHICLE IS PAST WARRANTY SO GO THE DEALER AND HAVE THEM LOOK AT THE VEHICLE. THIS HAS BEEN AN ISSUE FOR THE PAST 2 MONTHS OF OWNING THIS VEHICLE AND STILL OCCURRING OCCASIONALLY.
Power train, Other or unspecified, Service brakes, Apr 18, 2017
TIRE SENSOR WAS ON AND TRANSMISSOIN IS LEAKING
Electrical system, Other or unspecified, Apr 4, 2017
CPSC:FORD EXPLORER 2008, IGNITION SWITCH IS MAJOR SAFETY CONCERN. THE KEY MECHANISM OVER TIME HAS COME LOOSE AND ALLOWS FOR MECHANICAL SEATS TO RETRACT OR ENGAGE DURING TRAVEL IF HITTING SMALL BUMPS. *BF BUMPS OR MINOR ADJUSTMENTS CAUSE THE SEAT TO RETRACT. *JS
Electrical system, Seats, Other or unspecified, Mar 21, 2017
KEY CYLINDER HAS LOOSENED INSIDE IGNITION HOUSING. THIS CONDITION WHILE DRIVING IS A MAJOR SAFETY CONCERN FOR SHORTER INDIVIDUALS AS WHEN A BUMP OR CERTAIN MOTIONS CAUSE THE AUTOMATIC SEATS TO RETRACT TO "OFF POSITION" CREATING A 4-6" GAP BETWEEN FOOT AND PEDAL FOR MY WIFE IS SHE WERE WILLING TO DRIVE THE VEHICLE. THIS HAS BECOME MORE FREQUENT AND DEALER SERVICING KNOWS OF THE PROBLEM AS WELL AS A LOCAL LOCKSMITH I HAD CONTACTED FOR POSSIBLE REPAIR OPTIONS. IT HAS BECOME MORE EVIDENT IN THE PAST 2 YEARS FROM THEIR KNOWLEDGE. NO CURRENT RECALL EXISTS AS NO MAJOR INJURY HAS RESULTED. THIS OCCURS IN STATIONARY POSITION OR IN MOTION OF THE VEHICLE ADDING TO CONCERNS. I WILL HAVE THIS REPAIRED AT LOCAL FORD IN THE NEXT WEEK. SEAT RETRACTS ON ITS OWN AND IF ANY BUMPS ARE HIT MAY ENGAGE OR DISENGAGE AT WILL. AND HAS BEEN OCCURRING OVER THE PAST 3 YEARS. I AM THE ONLY OWNER FOR THE VEHICLE AND LESS THAN 70K MILES CURRENTLY
Other or unspecified, Feb 26, 2016
WHILE I WAS DRIVING I FELT THE SEAT MOVE AND NOTICED THAT IF I WOULD HIT THE KEY WHILE IT WAS IN THE IGNITION THE DRIVERS SEAT WOULD MOVE BACK AND FORTH SPORADICALLY. ALSO THE DOME LIGHTS FROM FRONT TO BACK WOULD GO OFF AND ON SPORADICALLY WHILE THE SEAT MOVED. THE AMOUNT OF WEIGHT ON THE KEY RING DOES NOT MATTER IT HAPPENS WHETHER YOU HAVE JUST THE KEY OR A WHOLE BUNCH OF KEYS HANGING FROM IT.
Power train, Other or unspecified, Engine, Jan 1, 2015
TRANSMISION PROBLEMS GOING INTO GEARS SLIPPING POPING NOISE WHEN PUT INTO PARK FORD IS AWARE OF PROBLEMS WITH THERE TRANSMISIONS AND NO CARE TO HELP 1 BET THEY NEED THE GOV TO STEP IN NOW SO HELP US EXPLORER OWNERS. *JS
Other or unspecified, Apr 3, 2014
I HAVE A 2008 FORD EXPLORER, CALLED U-HAUL TODAY TO RENT A SMALL TRAILER TO TOW BEHIND IT TO MOVE SOME BOXES. U-HAUL DOES NOT RENT TRAILERS TO TOW BEHIND FORD EXPLORERS! I WAS SHOCKED AS I WOULD THINK THAT THE MINIMAL REQUIREMENT OF ANY SUV IS THAT YOU WOULD BE ABLE TO TOW A SMALL U-HAUL TRAILER. CHECKING ONLINE I FIND I AM FAR FROM THE FIRST WITH THIS ISSUE. CALLING U-HAUL THEY SITE SAFETY CONCERNS. CALLING FORD THEY ASSURE ME THAT THEIR IS NO ISSUE IN USING A SMALL TRAILER BEHIND MY FORD EXPLORER. PER CONSUMER REPORTS, ?THE REAL LESSON HERE IS IF YOU OCCASIONALLY NEED TO RENT TRAILERS, THINK TWICE ABOUT THE NEW FORD EXPLORER. IF YOU FAVOR A FORD, THE EDGE OR A FLEX ARE EXCELLENT CHOICES. BUT THE EXPLORER, WITH ALL THE PERFORMANCE, SAFETY, AND VERSATILITY OFFERED BY ITS MODERN, UNIBODY DESIGN, WON?T BE WELCOMED AT THE LOCAL U-HAUL FRANCHISE.? MY QUESTION? AM I AT RISK TOWING A TRAILER BEHIND MY EXPLORER?? OR IS U-HAUL CREATING CONCERNS OVER NOTHING? *TR