2011 Ford Explorer
Problems, recalls and owner-reported issues
Steering is the leading concern among 1,196 owner complaints filed for this model year. This is the 10th highest complaint count among 26 Explorer model years with reports.
Of the 2011 reports, 30 involved a crash and 4 involved a fire. 15 people were injured.
What owners report most often
Recalls and investigations
Structure, body, roof and pillarsJan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Campaign 24V031000 on NHTSA.gov
Suspension, rearSep 22, 2021
Ford Motor Company (Ford) is recalling certain 2011-2013 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. These vehicles may be equipped with a cross-axis ball joint (CABJ) replacement part that could seize, and result in a fracture of the outboard section of the rear suspension toe link.
A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Dealer will inspect for the presence of a CABJ. If a CABJ of any design is found, the dealer will inspect the tightness of the CABJ, and replace the CABJ, knuckle, and/or toe link as necessary, free of charge. Interim notification letters were mailed November 10, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S43.
Campaign 21V746000 on NHTSA.gov
Suspension, rearJun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Campaign 19V435000 on NHTSA.gov
Wheels, hubAug 28, 2017
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
A loss of the wheel or wheel end can increase the risk of a crash.
Ford will notify the distributors of the hubs specifying that they are to only be used on drive axles. It is believed that none of the hubs were purchased from Ford dealers for the incorrect application. Owners may contact Ford customer service at 1-866-436-7332.
Campaign 17E048000 on NHTSA.gov
Structure, body, doorMar 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Explorer vehicles. In the affected vehicles, the interior door handle return spring may unseat, resulting in interior door handle that does not return to the fully stowed position after actuation.
If the interior door handle return spring is unseated, the door may unlatch in the event of a side impact crash, increasing the risk of personal injury.
Ford will notify owners, and dealers will inspect all four of the interior door handles and either repair or replace them, free of charge. The recall began on July 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S11.
Campaign 15V171000 on NHTSA.gov
Steering, electric power assist systemMay 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Ford Explorer vehicles manufactured May 17, 2010, through February 28, 2012. The affected vehicles may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting in a shut down of the power steering assist.
If the vehicle experiences a loss of power steering assist it will require extra steering effort at lower speeds, increasing the risk of a vehicle crash.
Ford will notify owners, and dealers will update the Power Steering Control Module (PSCM) software, free of charge. If a vehicle shows a history of a loss of motor position sensor signal when the vehicle is brought in for the recall remedy, its steering rack assembly will be replaced, free of charge. The recall began on July 23, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S06.
Campaign 14V286000 on NHTSA.gov
SteeringJan 6, 2014
Ford Motor Company (Ford) is recalling certain replacement steering gears installed on model year 2011-2012 Explorers as service parts in September 2013 and January 2014. The affected gears may lock, preventing the driver from being able to steer the vehicle.
The inability to steer the vehicle increases the risk of a crash.
Ford will notify owners and dealers will replace the suspect steering gears with new steering gears, free of charge. The recall began on January 29, 2014. Customers may contact Ford at 1-800-392-3673. Ford's number for this recall is 13S14.
Campaign 14E001000 on NHTSA.gov
SeatsFeb 2, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 EXPLORER VEHICLES MANUFACTURED FROM JULY 15, 2010, THROUGH DECEMBER 13, 2010, EQUIPPED WITH SECOND ROW 60% SEATS WITH MANUAL RECLINER MECHANISMS THAT MAY HAVE COMPONENTS THAT ARE OUT OF DIMENSIONAL SPECIFICATION. THESE SEATS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS."
IN THE EVENT OF A CRASH, THE SEAT BACK MAY NOT PROVIDE THE REQUIRED STRENGTH, INCREASING THE RISK OF INJURY.
FORD WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE SEATS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
Campaign 11V063000 on NHTSA.gov
Representative owner complaints: engine
100 reports, newest first. Show all
Engine, Jun 15, 2026
While stopped at a stop sign my engine suddenly died, before restarting a low oil pressure light came on but went out immediately. I was approximately 40 miles from home when I got to my destination. The car was showing no signs of issues, no warning lights or errors. When I went back out to start it and head home it would not start. I had to pay additional expense beyond my insurance road side coverage due to the distance. I have had an independent mechanic going over the vehicle since it died. Starter has been replaced because it appeared to be the issue. (the original was bad) Once replaced while attempting to start it he found out the engine had locked up. I bought the vehicle March 30, 2026 & this happened on June 10, 2026. The vehicle had 132,344 miles on it when bought and 135,716 when it seized up. After looking through other reports I have found this to be a reported issue.
Other or unspecified, Service brakes, Engine, Nov 20, 2025
Unknown
Steering, Engine and engine cooling, Mar 11, 2025
See attached document for complaint
Engine, Dec 24, 2024
Burnt exhaust smell in cabin after hard acceleration. The smell is overwhelmingly bad causing nose and eye burning and coughing. To remedy the smell the windows have to be rolled down to air out the cabin.
Engine and engine cooling, Jun 14, 2024
The contact owns a 2011 Ford Explorer. The contact stated that while his daughter was driving at various speeds, the engine overheated. The contact stated that the water pump was leaking, and the contact replaced the water pump himself. No warning lights were illuminated. The contact stated that the vehicle was scanned with an ODB scanner an engine overheating code was retrieved. The contact stated that the radiator cooling fan failed to turn on. The contact stated he had installed a new temperature sensor, but the vehicle was not repaired. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The failure mileage was approximately 200,000.
Engine, May 30, 2024
My son was on the highway and his Ford Explorer 2011 just stopped, he could have been killed! He was able to get off safely and had car towed. Our mechanic told us today it is the Water Pump leakage and we need to take to Ford. We called Ford and they said at least $5,000 to repair possibly more. This is a huge safety concern when the act can just stop dead on highway. There are no safety recalls on this water pump. My son was lucky to make it off the highway alive.
Engine, Mar 18, 2024
The internal water pump failed in my 2011 Ford Explorer without any warning signs and the coolant then leaked into my engine causing catastrophic engine failure. We were driving on a busy highway and the Ford Explorer simply started shutting down in the left lane. Nothing would happen when I pushed the gas petal and suddenly all the lights started flashing and heat went to above high. I was barely able to get over to the shoulder as smoke started to come out of the front of the engine. We were extremely afraid of getting hit since the car stalled on the highway only feet from the exit ramp. The car was towed and diagnosed at the Ford Dealership: Internal water pump failed causing engine failure - water mixed with oil. The car received state inspection and oil changed 17 days prior. Paid for engine replacement at the Ford Dealership with costs over $11,000.
Engine and engine cooling, Engine, Feb 6, 2024
The contact owns a 2011 Ford Explorer. The contact stated that the low oil pressure warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the engine block was cracked and the oil sending unit was damaged. The dealer informed the contact that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under warranty. The failure mileage was approximately 122,000.
Engine and engine cooling, Jan 24, 2024
The contact owns a 2011 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power. The contact was able to coast to the shoulder of the roadway, where the vehicle was able to be restarted. There was no warning light illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the water pump and determined that water had leaked into the engine and mixed with the engine oil, resulting in engine damage. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 113,000.
Engine and engine cooling, Engine, Oct 10, 2023
The contact owns a 2011 Ford Explorer. The contact stated that while driving approximately 35 MPH while turning right and exiting a ramp, then when idle a message stated "Low Oil Pressure" illuminated on the instrument panel. Shortly after the vehicle lost motive power. A certified mechanic inspected the vehicle and diagnosed that the camshaft sensor needed to be replaced. The vehicle was repaired. The failure reoccurred while test-driving the vehicle to determine if the repair was successful. The vehicle was re-examined and diagnosed that the water pump had failed causing the engine coolant and oil into the engine causing the engine to seize completely. The engine needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and referred them to the NHTSA Hotline. The approximate failure mileage was 152,000.
Engine, Aug 1, 2023
There are exhaust gases entering the vehicle cabin. This is primarily at startup, while sitting at idle in traffic and under acceleration. After visual inspection it appears to be coming from a cracked passenger side exhaust manifold. This is an obvious safety issue and I believe it should have been included in TSB 14-0130 but was told my VIN was not included.
Electrical system, Air bags, Engine, May 22, 2023
The dash lights go off then it's says starting rebot. Air bag lights stay on. Check engine light on says miss firng. All Carfax report was forged. Dealer said needs new engine but was not told by seller. No one will fix it they say not worth the price for car. I over paid big time. Got lied too.
Engine and engine cooling, Engine, May 1, 2023
The contact owns a 2011 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the vehicle stalled without warning. The contact’s wife notified the contact, and the contact was able to coast the vehicle off the road. The contact then stated that he allowed the vehicle to cool down, restarted the vehicle, then coasted the vehicle to his residence. The vehicle was then towed to the dealer where it was diagnosed that the water pump failed and caused the coolant to leak into the engine and damaged the engine and that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number, but no further assistance was provided. The failure mileage was approximately 173,000.
Engine, Mar 19, 2023
Was driving down the highway and my car lost power and put me in a very dangerous situation. Looking into the issue, i found out the waterpump was damaged in which is inside the engine and extremely expensive repairs (3000) dollars or more but the engine has been compromised with alot of coolant into the oil. My car is down and im still paying on it so im in very tough situation and believe the manufacturer should fix this situation.
Engine, Dec 13, 2022
The contact owns a 2011 Ford Explorer. The contact stated that while driving at an undisclosed speed, he heard a popping sound then the vehicle stalled. The contact then stated that he attempted to restart the vehicle; however, the vehicle failed to restart. There was no warning light illuminated. The vehicle was towed to the dealer where it was diagnosed that the engine failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but not assistance was provided. The failure mileage was approximately 147,000.
Engine, Sep 26, 2022
While driving on a busy road. My ford explorer suddenly died. I was driving with my children. The water pump suddenly went bad causing my engine to seize. This is the second time that I have had to replace the water pump and in which I have almost been part of an accident. The repairs have been very very costly.
Steering, Engine, Jul 20, 2022
The electric power steering continuesly Fails. The chain driver water pump failed while driving almost causing an accident with me and my son.
Engine and engine cooling, May 27, 2022
The contact owns a 2011 Ford Explorer. The contact stated that while a friend was driving approximately 45 MPH, the driver inhaled an excessive amount of carbon monoxide. The friend accidentally drove into a ditch. The vehicle was pulled out of the ditch by nearby residents. The driver was not injured. There were minor damages to the passenger’s side front of the vehicle. The vehicle was taken to the local dealer who diagnosed a failure with plugs underneath the engine. The plugs were not replaced. The manufacturer was notified of the failure. The approximate failure mileage was 168,000.
Engine and engine cooling, Apr 20, 2022
The contact owns a 2011 Ford Explorer. The contact stated that while driving at 45 MPH, the engine temperature hot warning light illuminated as the vehicle began to stall. The contact pulled off to the side of the road as a white smoke started coming from the vehicle. The contact waited for the vehicle to cool down before opening the hood and discovering that the coolant reservoir was empty. The contact added coolant in the reservoir; however, the vehicle failed to restart. The contact then called a family member who was able to jumpstart the vehicle; however, after several miles of driving, the failure recurred. The contact coasted the vehicle into a Walmart parking lot where she purchased more coolant; however, the coolant immediately leaked out of the vehicle. The vehicle was then towed to an independent mechanic and it was determined that the water pump had malfunctioned which led to the engine failure. The manufacturer was notified of failure but offered no assistance. The manufacturer referred her to the NHTSA to file a complaint. The vehicle was then towed to another independent mechanic where it remained in their possession and was not yet repaired. The failure mileage was approximately 185,000.
Engine, Apr 7, 2022
The contact owns a 2011 Ford Explorer. The contact stated while driving at an undisclosed speed, the vehicle stalled. The low coolant message was displayed. The contact was able to pull off to the side of the road. The contact called the local dealer but the vehicle was not diagnosed or repaired. The vehicle was towed to an independent mechanic and the contact was informed that the engine had seized. The manufacturer was not contacted. The failure mileage was approximately 113,000.
Power train, Engine, Mar 21, 2022
Every time we put the car in park, it would not register that it was in park and warning kept flashing that said shift to park. We had to just turn off the car most of the time and sometimes wiggling the shifter would work any time the "Not in Park" sign comes on when I know the gear is in park. I believe this can cause serious damage to property or cause death since the vehicle can roll. I believe Ford Motor Co should own up and recall all vehicles for service much for This is a known problem that has been know to happen to 2011 Edge and Explorers. The switch in the console shifter tends to fail prematurely. If the light does not light up the computer thinks the car is NOT in Park and alarms go off. THIS NEEDS TO BE FIXED BY FORD THIS IS A SAFETY ISSUE
Other or unspecified, Engine, May 12, 2021
THE INTERIOR OF THE VEHICLE SMELLS OF SMOG/GAS AFTER JUST A FEW MINUTES OF DRIVING AND CAUSES HEADACHES FOR ME AND MY KIDS
Steering, Electrical system, Engine, Mar 31, 2021
DRIVING AT 35+ ENTERING ON RAMP MPH THE CAR LOST ALL POWER AND JUST STOPPED. THE ENGINE SHUT OFF. NO WARNING LIGHTS OR ALARMS WENT OFF BEFOREHAND. ONCE THE CAR STOPPED, THE ENGINE LIGHT CAME ON, THE LOW PRESSURE LAMP TOO AND AN ALARM SOUNDED. I CALLED A TOW TRUCK AND HAD IT TOWED TO (TOLD ME MY ENGINE WAS MILKY DESTOYED)TWO DEALEARS THEN TO FORD. THEY CALLED THIS MORNING AND SAID THE WATER PUMP WENT OUT CAUSING CATASTROPHIC DAMAGE TO THE ENGINE. THE ENGINE HAS TO BE REPLACED. THEY QUOTED $8,000.00. HAD TO GET A $10,000 LOAN. [TO REPLACE STEERING AND ENGINE] THIS IS THE FIRST ONE (IT SEEMS TO BE HEADED IN THE SAME DIRECTION BUT ONLY SOONER) *PLEASE HELP ME I CAN'T AFFORD THIS AGAIN**WHILE DRIVING ON THE HIGHWAY, MY POWER STEERING WENT OUT WITHOUT WARNING. I LOST ALL POWER STEERING AND THEN THE POWER STEERING ALARM CAME ON. TOOK IT TO FORD AND HAD THE POWER STEERING REPLACED AT A COST OF $1800.00. THEN, LESS THEN 2 WEEKS LATER WHILE DRIVING AT 40 MPH, THE POWER STEERING WENT OUT AGAIN. AND AGAIN, NO WARNING LIGHTS UNTIL THE POWER STEERING WEN OUT. FORD SAID IT WAS BECAUSE MY TIRES HAD LOW TREAD AND I NEEDED TO REPLACE MY FRONT TIRES, WHICH WE HAD THEM DO. 8 MONTHS AGO, THE TRANSFER CASE WENT OUT AND HAD TO BE REPLACED ALSO WHEN PLACED IN PARK VEHICLE SHUT OFF COMPLETELY SHOWING A LOW PRESSURE OIL LAMP. HAPPENED IN MY FIRST ENGINE NOW IT'S HAPPENING IN THIS NEW ONE AND ITS NOT 2YRS OLD YET JUST GOT THE NEW ENGINE MAY/ JUNE OF 2019. THE FIRST ENGINE WASN'T 10 YEARS OLD . THE FIRST ENGINE ALL THIS HAPPENED APPROXIMATELY BETWEEN 2016 AND 2019 ONGOING UNTIL 2019 I GUESS THE WATER PUMP GAVE UP.O1 O1 2020 FOR THE SECOND ENGINE ON THE SAME COURSE AS THE FIRST
Engine, Feb 15, 2021
DRIVING AT 35 MPH THE CAR LOST ALL POWER AND JUST STOPPED. THE ENGINE SHUT OFF. NO WARNING LIGHTS OR ALARMS WENT OFF BEFOREHAND. ONCE THE CAR STOPPED, THE ENGINE LIGHT CAME ON AND AN ALARM SOUNDED. WE CALLED A TOW TRUCK AND HAD IT TOWED TO FORD. THEY CALLED THIS MORNING AND SAID THE WATER PUMP WENT OUT CAUSING CATASTROPHIC DAMAGE TO THE ENGINE. THE ENGINE HAS TO BE REPLACED. THEY QUOTED $8,000.00. 8 WEEKS AGO, WHILE DRIVING ON THE HIGHWAY, MY POWER STEERING WENT OUT WITHOUT WARNING. I LOST ALL POWER STEERING AND THEN THE POWER STEERING ALARM CAME ON. TOOK IT TO FORD AND HAD THE POWER STEERING REPLACED AT A COST OF $1800.00. THEN, LESS THEN 2 WEEKS LATER WHILE DRIVING AT 40 MPH, THE POWER STEERING WENT OUT AGAIN. AND AGAIN, NO WARNING LIGHTS UNTIL THE POWER STEERING WEN OUT. FORD SAID IT WAS BECAUSE MY TIRES HAD LOW TREAD AND I NEEDED TO REPLACE MY FRONT TIRES, WHICH WE HAD THEM DO. 8 MONTHS AGO, THE TRANSFER CASE WENT OUT AND HAD TO BE REPLACED.
Engine, Aug 11, 2020
WHILE DRIVING WITH MY 3 YOUNG KIDS ON A BUSY ROAD, MY WATER PUMP FAILED AND CATASTROPHICALLY DAMAGED MY ENGINE. MY CAR TURNED OFF WHILE DRIVING, WITH NO WARNING. WE WERE ALMOST INVOLVED IN A HORRIBLE CAR ACCIDENT BECAUSE OF THIS. THE CAR BEHIND ME HAD TO MAKE AN ABRUPT STOP. HAD HE HIT MY CAR, WE WOULD HAVE SPUN BECAUSE OF THE FORCE. THE WATER PUMP FAILS AND BECAUSE IT'S INSIDE THE ENGINE, IT DAMAGES THE ENGINE IN SECONDS WITHOUT PRIOR WARNING. THIS TYPE OF PROBLEM PUTS PEOPLE'S LIVES IN DANGER, ESPECIALLY THOSE OF KIDS. LEAVES YOU STRANDED IN THE MIDDLE OF A HIGH TRAFFIC STREET. WITHOUT WARNING THERE IS NO WAY WE CAN PREVENT PUTTING OUR LIVES IN DANGER THIS WAY. FORD STATES THAT WATER PUMPS SHOULD LAST THE LIFE OF THE ENGINE AND ITS MANUAL DOESN'T STATE THAT THE WATER PUMP NEEDS TO BE REPLACED AFTER CERTAIN MILES. REPAIR SHOP IS QUOTING 6,000 FOR A NEW ENGINE.