2012 Ford Explorer
Problems, recalls and owner-reported issues
Steering is the leading concern among 827 owner complaints filed for this model year. This is the 12th highest complaint count among 26 Explorer model years with reports.
Of the 2012 reports, 10 involved a crash and 6 involved a fire. 13 people were injured.
What owners report most often
Recalls and investigations
Structure, body, roof and pillarsJan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Campaign 24V031000 on NHTSA.gov
Suspension, rearSep 22, 2021
Ford Motor Company (Ford) is recalling certain 2011-2013 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. These vehicles may be equipped with a cross-axis ball joint (CABJ) replacement part that could seize, and result in a fracture of the outboard section of the rear suspension toe link.
A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Dealer will inspect for the presence of a CABJ. If a CABJ of any design is found, the dealer will inspect the tightness of the CABJ, and replace the CABJ, knuckle, and/or toe link as necessary, free of charge. Interim notification letters were mailed November 10, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S43.
Campaign 21V746000 on NHTSA.gov
Suspension, rearJun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Campaign 19V435000 on NHTSA.gov
Wheels, hubAug 28, 2017
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
A loss of the wheel or wheel end can increase the risk of a crash.
Ford will notify the distributors of the hubs specifying that they are to only be used on drive axles. It is believed that none of the hubs were purchased from Ford dealers for the incorrect application. Owners may contact Ford customer service at 1-866-436-7332.
Campaign 17E048000 on NHTSA.gov
Structure, body, doorMar 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Explorer vehicles. In the affected vehicles, the interior door handle return spring may unseat, resulting in interior door handle that does not return to the fully stowed position after actuation.
If the interior door handle return spring is unseated, the door may unlatch in the event of a side impact crash, increasing the risk of personal injury.
Ford will notify owners, and dealers will inspect all four of the interior door handles and either repair or replace them, free of charge. The recall began on July 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S11.
Campaign 15V171000 on NHTSA.gov
Steering, electric power assist systemMay 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Ford Explorer vehicles manufactured May 17, 2010, through February 28, 2012. The affected vehicles may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting in a shut down of the power steering assist.
If the vehicle experiences a loss of power steering assist it will require extra steering effort at lower speeds, increasing the risk of a vehicle crash.
Ford will notify owners, and dealers will update the Power Steering Control Module (PSCM) software, free of charge. If a vehicle shows a history of a loss of motor position sensor signal when the vehicle is brought in for the recall remedy, its steering rack assembly will be replaced, free of charge. The recall began on July 23, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S06.
Campaign 14V286000 on NHTSA.gov
SteeringJan 6, 2014
Ford Motor Company (Ford) is recalling certain replacement steering gears installed on model year 2011-2012 Explorers as service parts in September 2013 and January 2014. The affected gears may lock, preventing the driver from being able to steer the vehicle.
The inability to steer the vehicle increases the risk of a crash.
Ford will notify owners and dealers will replace the suspect steering gears with new steering gears, free of charge. The recall began on January 29, 2014. Customers may contact Ford at 1-800-392-3673. Ford's number for this recall is 13S14.
Campaign 14E001000 on NHTSA.gov
Representative owner complaints: engine
92 reports, newest first. Show all
Engine and engine cooling, Engine, Apr 9, 2018
TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE OPERATING THE VEHICLE, THERE WAS AN ODOR BEING EMITTED FROM THE EXHAUST THAT CAUSED THE CONTACT TO FEEL NAUSEOUS AND DIZZY. THE VEHICLE WAS TAKEN TO BARBER FORD (640 E 8TH ST. HOLLAND, MICHIGAN 49423) ON THREE SEPARATE OCCASIONS TO HAVE THE VOLUNTARY FORD EXHAUST CAMPAIGN COMPLETED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT THAT THE FAILURE HE WAS EXPERIENCING WAS NOT PART OF THE VOLUNTARY FORD EXHAUST CAMPAIGN. THE FAILURE MILEAGE AND VIN WERE NOT PROVIDED.
Engine and engine cooling, Other or unspecified, Jan 25, 2018
TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING 72 MPH, THE CONTACT TURNED ON THE HEATER. APPROXIMATELY 15 MINUTES LATER, THE CONTACT BECAME TIRED AND SLEEPY. THE CONTACT ROLLED DOWN THE WINDOW AND FELT BETTER APPROXIMATELY SIX MINUTES LATER. THE CONTACT EXPERIENCED THIS ISSUE SEVERAL TIMES WITHIN THE PAST TWO YEARS, MAINLY DURING THE COOLER MONTHS DUE TO HAVING THE WINDOWS ROLLED UP. THE CONTACT STATED THAT THIS SEEMED TO BE A CARBON MONOXIDE FAILURE. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THERE WERE NO RECALLS ASSOCIATED WITH THE VIN. THE FAILURE MILEAGE WAS UNKNOWN.
Power train, Electrical system, Engine, Nov 1, 2017
TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS WITH THE ACCELERATOR PEDAL DEPRESSED, THE VEHICLE STALLED AND THE OIL PRESSURE AND POWER TRAIN WRENCH WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS UNABLE TO START ON THE FIRST ATTEMPT. THE FAILURE RECURRED OVER THREE TIMES. THE CONTACT NOTICED THE FAILURE AFTER SHE DEPRESSED THE ACCELERATOR PEDAL AFTER A COMPLETE STOP. THE LOCAL DEALER (GULF COAST FORD, N, 3000 STATE HWY 288, ANGLETON,TX, 77515) WAS CONTACTED SCHEDULED AN APPOINTMENT FOR TWO DAYS LATER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 155,000.
Engine, Sep 18, 2017
AN EXHAUST ODOR REPEATEDLY OCCURRED IN THE CABIN WHILE THE VEHICLE WAS ACCELERATING.
Engine, Sep 17, 2017
ROTTEN EGG/SULFUR SMELL INSIDE CABIN/OCCUPANT AREA COMING FROM VENTS WHEN ENGINE UNDER HEAVY LOAD SUCH AS GOING UP HILL OR COMING ONTO HIGHWAY AND RPM'S INCREASE, ACCELERATING AT HIGHER SPEEDS TO MERGE INTO TRAFFIC FROM OFF RAMP. NOTICED MORE WHEN AC IS ON. BOUGHT VEHICLE USED FROM A LOCAL CAR DEALER IN FEB OF 2017
Power train, Engine, Fuel/propulsion system, Aug 29, 2017
(RE)STARTING AUGUST 1, 2017, WHILE DRIVING, THE VEHICLE WOULD SUDDENLY AND WITHOUT WARNING DECELERATE, WITH NO RESPONSE FROM THE GAS PEDAL. FORD CALLS THIS THEIR "LIMP HOME MODE." THE WRENCH ICON WARNING WOULD DISPLAY AND THE ENTIRE VEHICLE WOULD SHUDDER UNTIL IT WAS PUT IN PARK AND TURNED OFF. USUALLY, IT WOULD RESUME NORMAL OPERATIONS AFTER BEING RESTARTED, HOWEVER, ON ONE OCCASION, IT TOOK THREE ATTEMPTS TO RESTART. AFTER TWO SUCH INCIDENTS OCCURRING IN LESS THAN A MILE, I DON'T FEEL SAFE DRIVING ON THE HIGHWAY (OR, REALLY, ANY OTHER PLACE) AS THERE IS NO INDICATION TO OTHER DRIVERS AND THE VEHICLE ACTIVELY DECELERATES, RATHER THAN COASTING. DURING ONE SUCH INCIDENT, THE DECELERATION WAS SO PRONOUNCED THAT PASSENGERS JERKED FORWARD IN THEIR SEATS AND A CANINE PASSENGER LOST ITS FOOTING, FALLING INTO THE BACK OF THE SEATS. WE PREVIOUSLY EXPERIENCED THIS SAME ISSUE IN 2015, LEAVING ME AND A SMALL CHILD STRANDED WHEN THE VEHICLE DID NOT RESTART AT ALL. AS PART OF A "GOODWILL" REPAIR DUE TO THE VEHICLE BEING JUST OUT OF WARRANTY, THE ETB (ELECTRONIC THROTTLE BODY) AND PURGE VALVE WERE REPLACED BY FORD. I FILED COMPLAINT 10787972 WITH THE NHTSA ON 10/25/2015. IN 5 YEARS, THIS WILL BE THE SECOND REPLACEMENT OF A PART THAT'S EXPECTED TO LAST WELL OVER 6 YEARS. FORD IS AWARE OF THE PROBLEM, IS AND HAS BEEN SUED, AND IS BEING INVESTIGATED.
Engine, Aug 23, 2017
PURCHASED THIS CAR IN AUGUST 2015. EVERY TIME I ACCELERATE QUICKLY TO PASS SOMEONE OR GO UP HILL FUMES ENTER THE CAR. VERY STRONG ODOR AND I HAVE TWO YOUNG DAUGHTERS WHO ARE UNABLE TO TELL ME IF THEY FEEL FUNNY FROM THE FUMES. PURGE VALVE SENSOR REPLACED DUE TO ENGINE LIGHT COMING ON REPEATEDLY.
Engine and engine cooling, Aug 4, 2017
TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT SMELLED AN EXHAUST ODOR COMING FROM THE VENTS. THE CONTACT BELIEVED THAT THIS WAS THE RESULT OF THE CARBON MONOXIDE ISSUE IN THE NEWS. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 18,613. ... .UPDATED 11/16/17 *BF THE FAILURE AFFECTED THE CONSUMER'S ASTHMATIC CONDITION. *JS
Engine and engine cooling, Aug 2, 2017
TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT THE EXHAUST SYSTEM FAILED AND CAUSED AN ODOR TO PENETRATE THROUGHOUT THE VEHICLE. THE ODOR CAUSED THE CONTACT TO HAVE NAUSEA SYMPTOMS AND HEADACHES. THE CONTACT DID NOT SEEK MEDICAL ATTENTION. THE VEHICLE WAS NOT TAKEN TO A DEALER OR MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 100,000.
Engine, Fuel/propulsion system, Jul 15, 2017
TURBO GONE BAD - CAR BEGAN MAKING LOUD RATTLE NOISE WHEN STARTED. NOISE WOULD SUBSIDE SOME AFTER A FEW MINUTES. CAR HAS BEEN VERY SLOW TO ACCELERATE, WHENEVER IT'S BEING DRIVEN, OVER THE LAST FEW MONTHS. HAVE TO REALLY PRESS DOWN ALL THE WAY ON THE GAS IN ORDER TO KEEP IT GOING. THE MPG HAVE BEEN STEADILY DECLINING AS WELL OVER THE LAST FEW MONTHS. DEALER TOLD ME IT'S A "TURBO PROBLEM". WAS TOLD THAT 180 OTHER 2012 EXPLORERS ARE ALSO AFFECTED, PARTS ON BACK-ORDER FOR SIX WEEKS. CAN'T DRIVE CAR. REPAIR COST APPROXIMATELY $3500. FORD OFFERING NO RELIEF AT THIS POINT.
Other or unspecified, Engine, Jun 26, 2017
I AM EXPERIENCING THE EXHAUST FUMES SMELL IN MY VEHICLE WHEN ACCELERATING UP HILLS OR WHEN MERGING INTO TRAFFIC. MY FAMILY HAS SUFFERED SYMPTOMS SUCH AS HEADACHES AND LIGHTHEADEDNESS DUE TO THE SMELLS. THE SMELL IS A VERY STRONG EXHAUST FUMES SMELL AND LASTS FOR AT LEAST 30 SECONDS TO A MINUTE.
Engine, Jun 15, 2017
TURBO FAILURE WHILE DRIVING, LARGE LOSS OF POWER AND POTENTIAL FOR AN ACCIDENT. TURBO CHARGER FAILED ON MY 2.0L ECOBOOST ENGINE AT 58,000 MILES. TURBO FAILED WHILE IN TRAFFIC AND CAUSED VERY POOR PERFORMANCE AND COULD HAVE EASILY CAUSED A WRECK. TURBO FAILURE DOES NOT CREATE A CHECK ENGINE LIGHT OR GIVE ANY INDICATION THAT IS HAS FAILED OTHER THAN A LARGE LOSS OF POWER AND THE ENGINE CONTINUES TO RUN. TURBO FAILURE IS SUDDEN AND THERE IS NO INDICATIONS PRIOR TO IT FAILING. THE TURBO WAS NOT COVERED BY WARRANTY DUE TO VEHICLES AGE EVEN THOUGH UNDER 60K.
Other or unspecified, Engine, Fuel/propulsion system, Jun 12, 2017
I ABRUPTLY ACCELERATED AROUND A CAR THAT MANEUVERED INFRONT OF ME AND MY INTERIOR CABIN WAS FILLED WITH AN NAUSEATING EXHAUST SMELL. I GOT A HEADACHE, LIGHT HEADED, AND PULLED OVER, BECAUSE I WAS STARTING TO GET DIZZY AND DEVELOP HEADACHES. THIS OCCURRED ON A HIGHWAY, AND NEARLY KILLED ME. I AM FURIOUS.
Engine, Jun 12, 2017
OUR 2012 FORD EXPLORER HAS A HEAVY FUEL SMELL IN THE CABIN AFTER DRIVING FOR MORE THAT A FEW MINUTES. IT SEEMS TO BE GETTING WORSE AS TIME PASSES.
Electrical system, Engine, Feb 21, 2017
MY VEHICLES AIR TURNS ON ON IT'S OWN AS YOU DRIVE. THIS IS NOT THE AC NOR HEATER. AS YOU DRIVE YOU CAN HEAR YOUR AIR VENTS TURN ON AND YOU SMELL A FOUL SMELL AND THE AIR PUSHING THROUGH THE VENTS IS MUGGY STICKY AIR THAT MAKES YOUR SKIN FEEL CLAMMY. THIS HAS BEEN REPORTED TO THE DEALERSHIP BEFORE AND HAD BEEN "REPAIRED" HOWEVER, THE AIR CONTINUES TO PUSH THROUGH THE VENTS WHETHER YOU HAVE THE SWITCH SET TO ON OR NOT.
Engine, Feb 16, 2017
WE HAVE NOTICED INTERMITTENT ODORS IN THE CABIN. SULPHUR SMELLING ODOR AFTER ACCELERATING QUICKLY (FOR EXAMPLE PASSING, MERGING). IT HAPPENS WHEN THE HEAT IS ON, OR OFF. IT HAS HAPPENED INTERMITTENTLY FOR AS LONG AS WE CAN RECALL HOWEVER THE SMELL IS NOW (APPROX. THE LAST YEAR) NOTICEABLE JUST ABOUT ANY TIME WE DO HIGHWAY DRIVING. IT ALMOST EXCLUSIVELY HAPPENS ON THE HIGHWAY. ON THE INFREQUENT OCCASION THAT I NEED TO MAKE A QUICK ACCELERATION WHILE DOING AROUND-TOWN DRIVING, THE SMELL CAN BE NOTICED. I AM CURRENTLY RECEIVING MEDICAL ATTENTION FOR SEVERE SYMPTOMS OF, WHAT I BELIEVE TO BE, CARBON MONOXIDE EXPOSURE. SYMPTOMS INCLUDE EXTREME FATIGUE AND HEADACHES.
Engine and engine cooling, Feb 15, 2017
TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE HAD AN EXHAUST ODOR IN THE VEHICLE CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000.
Engine, Fuel/propulsion system, Feb 14, 2017
TL* THE CONTACT OWNS A 2012 FORD EXPLORER. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR WHILE OPERATING THE VEHICLE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL ODOR COULD NOT BE DIAGNOSED; HOWEVER, THE CHECK ENGINE INDICATOR FAILURE WAS DIAGNOSED AS AN AIR FILTER NEEDING TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
Engine, Feb 13, 2017
DROVE VEHICLE WITH AIR CONDITIONING ON AND RECIRCULATION CLOSED FROM TEXAS TO VIRGINIA AND BACK AT NORMAL HIGHWAY SPEEDS. THERE WAS AN EXHAUST SMELL IN THE CAR MOST TIMES. HAD TO BE TAKEN TO EMERGENCY CARE WITH RESPIRATORY DISTRESS A COUPLE OF DAYS AFTER RETURNING. WAS ON TREATMENT FOR COPD FOR THE NEXT FIVE YEARS.
Power train, Engine, Feb 6, 2017
MY 2012 FORD EXPLORER WOULD ALL OF A SUDDEN SOUND LIKE IT WAS SLIPPING OUT OF GEAR WHILE DRIVING. I WOULD LOSE ALL CONTROL OF THE ACCELERATOR & VEHICLE WOULD IDLE VERY ROUGH. THE "WRENCH" LIGHT WOULD APPEAR ON THE DASH DISPLAY. I WOULD HAVE TO DRIFT OVER TO THE SIDE OF THE ROAD, TURN THE VEHICLE OFF, & THEN RE-START THE VEHICLE. THIS HAPPENED WITHOUT WARNING & BECAME MORE FREQUENT. DEALERSHIP REPLACED THE THROTTLE BODY (AT MY COST) & EXPLAINED NO RECALL HAD BEEN DETERMINED YET, BUT EXPECTED IT TO BE ISSUED IN THE FUTURE DUE TO THE NUMBER OF COMPLAINTS. I ALSO HAD TO PAY TO HAVE MY SELECTOR LEVER ASSEMBLY REPLACED AGAIN SINCE I WAS AGAIN HAVING THE ISSUE OF VEHICLE PROBLEM OF "SHIFT TO PARK" APPEARING ONCE AGAIN. THE FIRST TIME THIS PART WAS REPLACED IT WAS COVERED UNDER TSB 15-0047, BUT THIS TIME IT WAS AT MY EXPENSE.
Steering, Electrical system, Engine, Nov 8, 2016, fire
DROVE ABOUT 2 MILES IN THE MORNING WHILE TURNING ONTO THE INTERSTATE RAMP THE STEERING LOCKED UP WOULD NOT GO OVER 30MPH, SUV STARTED TO SMOKE WHILE THE TEMPERATURE GAUGE NEVER CHANGED INSIDE OF THE VEHICLE. LUCKY TO NOT HAVE CAUSED A MAJOR ACCIDENT. AFTER HAVING VEHICLE TOWED, PER THE MECHANIC THE COMPUTER SYSTEM IS FRIED, MOTOR VALVES MELTED, AND ALL SPARK PLUGS NEED TO BE REPLACED. THIS SUV IS ONLY A 2012 AND SHOULD NOT HAVE THIS MAJOR OF PROBLEMS WHEN IT HAS BEEN WELL TAKEN CARE OF. FORD REALLY NEEDS TO LOOK FURTHER INTO THIS SO THIS DOES NOT HAPPEN TO SOMEONE ELSE.
Engine, Fuel/propulsion system, Nov 4, 2016
TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING 35 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE PURGE VALVE WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 53,128.
Power train, Vehicle speed control, Engine, Nov 2, 2016
WHILE DRIVING THE VEHICLE SUDDENLY POWER WOULD BE LOST. WHEN APPLYING MORE PRESSURE TO THE ACCELERATOR, NO USABLE POWER WAS PRESENT AND THE VEHICLE COULD NOT EXCEED 30 MPH. AFTER THIS OCCURRED ON THE 4TH TIME ON A SUBSEQUENT DAY, THE "ENGINE" SYMBOL WAS DISPLAYED. CURRENTLY THE VEHICLE IS AT A FORD DEALERSHIP TO TROUBLESHOOT THE PROBLEM. ON TWO OCCASIONS THIS DISCREPANCY WITH ACCELERATION AND FUNCTIONALITY OF AVAILABLE POWER NEARLY CAUSED AN ACCIDENT WITH SMALL CHILDREN IN THE VEHICLE. THIS SHOULD CAUSE A MAJOR CONCERN TO OTHER OWNERS AND FORD MOTOR COMPANY AS A WHOLE DUE TO THE POTENTIAL DAMAGE, INJURY, OR DEATH THAT COULD OCCUR DUE TO COMPLETELY LOSING ACCELERATION AND/OR POWER WHILE DRIVING. *TR
Other or unspecified, Engine, Sep 26, 2016
STRONG EXHAUST (BURNING OIL SMELL) COMING INTO CABIN UNDER MEDIUM TO HIGH ACCELERATION THROUGH VENTILATION ( AC ON) . THE SMELL PERMEATES THE CAR AND BURNS YOUR NOSTRILS. I COULD SMELL IT FOR QUITE SOME TIME EVEN AFTER EXISTING THE VEHICLE (AS THE SMELL REMAINS IN MY NOSE). EVEN FELT A BIT LIGHTHEADED AFTER EXISTING THE VEHICLE. I HAVE HAD PASSENGERS NOTICE THIS SMELL ON SEVERAL OCCASIONS ALSO.
Visibility, Engine, Sep 22, 2016
TL* THE CONTACT OWNS A 2012 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT OBSERVED AN ABNORMAL ODOR THROUGH THE AIR CONDITIONING UNIT WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 27,000.