2012 Ford Explorer
Problems, recalls and owner-reported issues
Steering is the leading concern among 827 owner complaints filed for this model year. This is the 12th highest complaint count among 26 Explorer model years with reports.
Of the 2012 reports, 10 involved a crash and 6 involved a fire. 13 people were injured.
What owners report most often
Recalls and investigations
Structure, body, roof and pillarsJan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Campaign 24V031000 on NHTSA.gov
Suspension, rearSep 22, 2021
Ford Motor Company (Ford) is recalling certain 2011-2013 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. These vehicles may be equipped with a cross-axis ball joint (CABJ) replacement part that could seize, and result in a fracture of the outboard section of the rear suspension toe link.
A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Dealer will inspect for the presence of a CABJ. If a CABJ of any design is found, the dealer will inspect the tightness of the CABJ, and replace the CABJ, knuckle, and/or toe link as necessary, free of charge. Interim notification letters were mailed November 10, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S43.
Campaign 21V746000 on NHTSA.gov
Suspension, rearJun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Campaign 19V435000 on NHTSA.gov
Wheels, hubAug 28, 2017
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
A loss of the wheel or wheel end can increase the risk of a crash.
Ford will notify the distributors of the hubs specifying that they are to only be used on drive axles. It is believed that none of the hubs were purchased from Ford dealers for the incorrect application. Owners may contact Ford customer service at 1-866-436-7332.
Campaign 17E048000 on NHTSA.gov
Structure, body, doorMar 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Explorer vehicles. In the affected vehicles, the interior door handle return spring may unseat, resulting in interior door handle that does not return to the fully stowed position after actuation.
If the interior door handle return spring is unseated, the door may unlatch in the event of a side impact crash, increasing the risk of personal injury.
Ford will notify owners, and dealers will inspect all four of the interior door handles and either repair or replace them, free of charge. The recall began on July 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S11.
Campaign 15V171000 on NHTSA.gov
Steering, electric power assist systemMay 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Ford Explorer vehicles manufactured May 17, 2010, through February 28, 2012. The affected vehicles may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting in a shut down of the power steering assist.
If the vehicle experiences a loss of power steering assist it will require extra steering effort at lower speeds, increasing the risk of a vehicle crash.
Ford will notify owners, and dealers will update the Power Steering Control Module (PSCM) software, free of charge. If a vehicle shows a history of a loss of motor position sensor signal when the vehicle is brought in for the recall remedy, its steering rack assembly will be replaced, free of charge. The recall began on July 23, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S06.
Campaign 14V286000 on NHTSA.gov
SteeringJan 6, 2014
Ford Motor Company (Ford) is recalling certain replacement steering gears installed on model year 2011-2012 Explorers as service parts in September 2013 and January 2014. The affected gears may lock, preventing the driver from being able to steer the vehicle.
The inability to steer the vehicle increases the risk of a crash.
Ford will notify owners and dealers will replace the suspect steering gears with new steering gears, free of charge. The recall began on January 29, 2014. Customers may contact Ford at 1-800-392-3673. Ford's number for this recall is 13S14.
Campaign 14E001000 on NHTSA.gov
Representative owner complaints
827 reports, newest first.
Steering, Dec 10, 2025
Failure of Power Steering A hard steering wheel on a 2012 Ford Explorer with electric steering (EPAS
Steering, Nov 24, 2025
The Power Steering pump (EPAS) when out on me yesterday while driving on the highway. I was switching lanes on the highway when the service advance trac light came on and the steering wheel became stiff really difficult to move putting myself in danger while driving in a higher speed limit zone.
Other or unspecified, Back over prevention, Oct 31, 2025
The rear back up camera is now displaying a message to contact dealership. It freezes up and stops working.
Other or unspecified, Back over prevention, Oct 30, 2025
My back-up camera has flipped images so the left appears on the right and the right appears on the left as well as the safety lines have disappeared. The two Ford dealerships want a diagnostic fee that doesn't even go toward the cost of the repairs.
Back over prevention, Oct 22, 2025
Faulty rear view camera. Says contact the dealership on the message.
Structure, Oct 7, 2025
The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that the passenger's side and driver's side windshield exterior A-pillar trims had separated and flown off the vehicle while driving. The local dealer was contacted several times and was notified of the failure. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown.
Steering, Oct 6, 2025
While driving, my 2012 Ford Explorer displayed a “Service Power Steering Now” warning message, and the steering wheel completely locked, making the vehicle impossible to steer safely. This happened without warning and rendered the car undrivable, creating an immediate safety hazard. This issue matches the conditions described in Ford Safety Recall 14S06 (NHTSA Campaign 14V286000) and Customer Satisfaction Program 15N01, both addressing Electric Power Steering (EPAS) system failures in 2011–2013 Explorers. Ford’s Defect Information Report to NHTSA (PE12-017) states that intermittent electrical connections in the steering gear’s motor position sensor can cause a total loss of power steering assist exactly what occurred in my vehicle. Despite this, Ford and the dealership (Tommie Vaughn Ford, Houston TX) have stated that my VIN is “expired” for program 15N01 and refused assistance. However, the failure mode and symptoms are identical to those covered by these safety campaigns.My Explorer was manufactured in December 2011, which falls directly in the affected build range. The Carfax report for my vehicle even lists program 15N01 EPAS Steering Efforts as an associated service campaign. This is a critical safety issue, and Ford’s refusal to assist due to expired coverage should not override the need to correct a known steering defect. I am requesting that NHTSA investigate whether Ford’s current handling of EPAS steering failures is sufficient, and whether Customer Satisfaction Program 15N01 should be reopened or extended to cover affected vehicles like mine that are experiencing the same safety defect.
Suspension, Sep 29, 2025
The contact owns a 2012 Ford Explorer. The contact stated that while driving approximately 35-45 MPH, the steering wheel started shaking abnormally. There were no warning lights illuminated. The contact became aware of NHTSA Campaign Number: 19V435000 (Suspension). The local dealer was contacted and provided a cost for the repair. The vehicle was not diagnosed or repaired. The contact called another local dealer, [XXX] [XXX] ) but no assistance was provided. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 71,000. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Electrical system, Sep 13, 2025
Hello I’m a concerned citizen and I have a question about the Ford recall on the back up cameras, I have 2012 Explorer and my camera has been acting up for a while the same way that ford has mentioned, so I was wondering why isn’t the Explorer not included in this recall.
Steering, Sep 12, 2025
The contact owns a 2012 Ford Explorer. The contact stated that while attempting to make a turn, the steering wheel seized. There was no warning light illuminated. The contact stated that the steering wheel became difficult to maneuver, and the steering wheel failed to return to center after making a turn. The vehicle was towed to the residence. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 220,000
Steering, Structure, Sep 11, 2025
The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The contact stated that upon purchasing the vehicle, the trim on the lower part of the windshield detached and was loosened. The local dealer was not contacted. The vehicle was not diagnosed or repaired. Additionally, the contact stated that there was an abnormal sound coming from the steering wheel, while driving, while making left and right turns, and even while the engine was turned off. The contact stated that the failure had persisted. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was approximately 125,000.
Electrical system, Sep 9, 2025
The contact's wife owns a 2021 Ford Explorer. The contact stated that while his wife was driving, on at least three occasions, the steering wheel became very stiff. The contact's wife was not able to turn the steering wheel, so the vehicle was stopped and restarted each time. The contact stated that an unknown message was displayed, and the power steering assist warning light illuminated. The vehicle was taken to a dealer, where DTC: U3000 was retrieved, and the tech was asked to check for bad connections. The failure was not duplicated, and the vehicle was not repaired. The vehicle was taken to a second dealer, where it was diagnosed and determined that the ground wire had corrosion around the grounding bolts and that the bolts needed to be cleaned a reinstalled. The vehicle was repaired. The manufacturer was notified of the failure. The failure mileage was 111,000.
Steering, Sep 8, 2025
Electric power steering system does not work
Steering, Sep 6, 2025
Loss of power steering occasionally, getting a power steering fault, but as of now, starts working again
Structure, Sep 4, 2025
The contact owns a 2012 Ford Explorer. The contact stated that while driving at 55 MPH, the A-pillar trim detached from the vehicle. There were no warning lights illuminated. The contact called the local dealer, where it was previously repaired under NHTSA Campaign Number: 24V031000 (Structure). The dealer informed the contact that the parts were being ordered. The manufacturer was not contacted. The failure mileage was approximately 150,000.
Traction control system, Engine, Sep 2, 2025
The contact owns a 2012 Ford Explorer. The contact stated that while driving approximately 45 MPH, the traction control and check engine warning lights illuminated. The contact stated that a minute and a half later, while attempting to make a right turn, the steering wheel became firm, and added effort was needed to turn the steering wheel. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 170,000.
Structure, Aug 26, 2025
The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (Structure). The contact stated that the A-pillar trim was loose. There were no warning lights illuminated. The contact called the local dealer, who confirmed that parts were not yet available. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the issue. The failure mileage was unknown.
Structure, Aug 26, 2025
Trunk liftgate isn't operating. Cannot open up the trunk. Interior driver sides armrest stitching is busted.
Steering, Aug 19, 2025
The contact owns a 2012 Ford Explorer. The contact stated that while driving on several occasions at various speeds, the steering wheel became extremely stiff and was difficult to turn. Additionally, the "Steering Fault" message was displayed on the instrument cluster. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 75,000.
Structure, Aug 19, 2025
The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000 (STRUCTURE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.
Structure, Jul 22, 2025
The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign number: 24V031000 (Structure); however, the part to do the recall repair was not yet available. The contact stated while driving 60 MPH, the driver's side A-pillar trim detached from the vehicle. The local dealer was not contacted. The vehicle was not repaired. The contact stated that on a separate occasion, while driving 60 MPH, the driver's side A-pillar trim detached from the vehicle. The local dealer was not contacted. The vehicle was not repaired after the most recent failure. The contact stated that the driver's side A-pillar trim had detached. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was unknown. VIN tool confirms parts not available.
Fuel system, Gasoline, Power train, Jul 21, 2025
The contact owns a 2012 Ford Explorer. The contact stated that while driving approximately 40-60 MPH, the vehicle hesitated while depressing the accelerator pedal. There was no warning light illuminated. In addition, the contact stated that there was an abnormal burning odor coming from the vehicle. Upon investigation, the contact discovered NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE) and linked the failure to the recall; however, the VIN nor the year, make, or model was included. The vehicle was not repaired. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 180,000.
Exterior lighting, Jul 18, 2025
The contact owns a 2012 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact pressed the hazard warning light icon on the display screen to pull over, but the hazard warning lights were inoperable. The vehicle was taken to the dealer, who determined that an unknown unit in the dashboard needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 87,000.
Structure, Jul 17, 2025
The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V0311000(Structure); however, the part to do the recall repair was not yet available. The contact stated while driving at an undisclosed speed, the vehicle made an unusual loud sound. The vehicle was driven to the shoulder of the road. The contact stated that upon inspecting the vehicle, the contact noticed that the front passenger's side windshield exterior A-pillar trim had separated from the vehicle and flown off. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was 147,012. VIN tool confirms parts not available.
Structure, Jul 17, 2025
The contact owns a 2012 Ford Explorer. The contact received notification of NHTSA Campaign Number: 24V031000(Structure); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.