2013 Ford Explorer
Problems, recalls and owner-reported issues
Steering is the leading concern among 2,234 owner complaints filed for this model year. This is the 3rd highest complaint count among 26 Explorer model years with reports.
Of the 2013 reports, 44 involved a crash and 11 involved a fire. 61 people were injured and 1 person died.
What owners report most often
Recalls and investigations
Structure, body, roof and pillarsJan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Campaign 24V031000 on NHTSA.gov
Suspension, rearSep 22, 2021
Ford Motor Company (Ford) is recalling certain 2011-2013 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin. These vehicles may be equipped with a cross-axis ball joint (CABJ) replacement part that could seize, and result in a fracture of the outboard section of the rear suspension toe link.
A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Dealer will inspect for the presence of a CABJ. If a CABJ of any design is found, the dealer will inspect the tightness of the CABJ, and replace the CABJ, knuckle, and/or toe link as necessary, free of charge. Interim notification letters were mailed November 10, 2021. Owner notification letters were mailed on March 17, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S43.
Campaign 21V746000 on NHTSA.gov
Suspension, rearJul 15, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.
Campaign 21V537000 on NHTSA.gov
Suspension, rearMar 12, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.
Campaign 20V675000 on NHTSA.gov
Suspension, rearJun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Campaign 19V435000 on NHTSA.gov
Wheels, hubAug 28, 2017
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
A loss of the wheel or wheel end can increase the risk of a crash.
Ford will notify the distributors of the hubs specifying that they are to only be used on drive axles. It is believed that none of the hubs were purchased from Ford dealers for the incorrect application. Owners may contact Ford customer service at 1-866-436-7332.
Campaign 17E048000 on NHTSA.gov
Fuel system, gasolineDec 2, 2015
Ford Motor Company (Ford) is recalling certain model year 2013 Explorer, Explorer Police Utility, Taurus, Taurus Police Interceptor, Flex, Lincoln MKS, and Lincoln MKT vehicles. In the affected vehicles, the fuel delivery module may crack, allowing fuel to leak.
A fuel leak in the presence of an ignition source may result in a fire.
Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on December 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 13S04-S1.
Campaign 15V812000 on NHTSA.gov
Structure, body, doorMar 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Explorer vehicles. In the affected vehicles, the interior door handle return spring may unseat, resulting in interior door handle that does not return to the fully stowed position after actuation.
If the interior door handle return spring is unseated, the door may unlatch in the event of a side impact crash, increasing the risk of personal injury.
Ford will notify owners, and dealers will inspect all four of the interior door handles and either repair or replace them, free of charge. The recall began on July 23, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S11.
Campaign 15V171000 on NHTSA.gov
Steering, electric power assist systemMay 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2011-2013 Ford Explorer vehicles manufactured May 17, 2010, through February 28, 2012. The affected vehicles may experience an intermittent connection in the electric power steering gear, which can cause a loss of the motor position sensor signal resulting in a shut down of the power steering assist.
If the vehicle experiences a loss of power steering assist it will require extra steering effort at lower speeds, increasing the risk of a vehicle crash.
Ford will notify owners, and dealers will update the Power Steering Control Module (PSCM) software, free of charge. If a vehicle shows a history of a loss of motor position sensor signal when the vehicle is brought in for the recall remedy, its steering rack assembly will be replaced, free of charge. The recall began on July 23, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S06.
Campaign 14V286000 on NHTSA.gov
Latches/locks/linkagesJun 26, 2013
Ford Motor Company (Ford) is recalling certain model year 2013 Ford Explorer, Taurus, and Lincoln MKS vehicles manufactured November 29, 2012, through December 12, 2012. In the affected vehicles, with sufficient door openings and closings, the child safety locks may change from an activated position to a deactivated position without notice.
If the child lock is deactivated, the door could be unlocked and opened from the inside which could lead to personal injury to an unrestrained child.
Ford will notify owners, and dealers will test the safety locks. If necessary, the locks will be replaced free of charge. The recall began on August 2, 2013. Ford's recall number is 13S07. Owners may contact the Ford customer relationship center at 1-866-436-7332.
Campaign 13V270000 on NHTSA.gov
Fuel system, gasolineMay 31, 2013
Ford is recalling certain model year 2013 Explorer, Taurus, Flex, Fusion, Police Interceptor Sedan and Police Interceptor Utility vehicles; and certain model year 2013 Lincoln MKS, MKT, and MKZ vehicles. In the affected vehicles, the fuel delivery module may develop a crack, allowing fuel to leak.
A fuel leak in the presence of an ignition source may result in a fire.
Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on July 20, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332. Ford's recall campaign number is 13S04.
Campaign 13V227000 on NHTSA.gov
Fuel system, gasoline, storage, tank assemblyMar 27, 2013
Ford is recalling certain model year 2012 Taurus, Lincoln MKS, and model year 2013 Explorer vehicles manufactured July 19, 2011, through March 15, 2012. In the affected vehicles, the fuel tanks may have a marginally sealed seam in the side of the tank. As a result, the fuel tanks may not provide the expected strength in the event of an impact. The tanks may also leak.
A fuel leak in the presence of an ignition source may result in a fire.
Ford will notify owners, and dealers will inspect the fuel tanks and replace them as necessary, free of charge. The recall began on May 9, 2013. Ford's recall campaign number is 13S03. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332.
Campaign 13V109000 on NHTSA.gov
Representative owner complaints: engine
290 reports, newest first. Show all
Engine and engine cooling, Jan 24, 2017
STRONG EXHAUST SMELL IN THE CABIN OF THE VEHICLE MAKING DRIVER AND ANY PASSENGERS FEEL SICK. WORSE WHEN MIDDLE AND BACK SEATS ARE UP, LESS IF SEATS ARE FOLDED DOWN. HAPPENS IMMEDIATELY WHEN CARE IS STARTED AND CONTINUES WHEN DRIVING. *TR
Engine, Jan 19, 2017
OIL SUPPLY LINE TO TURBO LEAKING. NO PARTS AVAILABLE TO MAKE THE REPAIR THROUGH FORD. THIS IS THE SAME PART FAILURE AND HAS CAUSED A RECALL IN THE 2016 - 2017 FORD EXPLORER SPORTS. FORD NEEDS TO LOOK AT PREVIOUS YEARS TO DETERMINE IF A RECALL SHOULD BE DONE FOR ALL 2011 TO PRESENT. (FIRE HAZARD)
Electrical system, Vehicle speed control, Engine, Jan 16, 2017
WHILE DRIVING MY EXPLORER WILL LOSE ALL POWER AFTER 30-45 MINUTES IT WILL RESTART AND RUN FINE FOR A DAY OR SO AND THEN HAPPEN AGAIN. WHEN IT LOSES POWER ALL OF THE WARNINGS WILL APPEAR AND THE RADIO WILL STILL WORK. WHEN I RESTART THE VEHICLE IT TAKES A MINUTE FOR THE ENGINE TO TURN OVER. THIS IS VERY SCARY AND DANGEROUS WHEN I AM DRIVING DOWN THE HIGHWAY AT 70 MPH. I SEE THERE HAVE BEEN MANY COMPLAINTS ABOUT THIS BUT NO RECALL! THIS HAS ALSO HAPPENED WHILE DRIVING A BOTH 35-40 MPH ON CITY STREETS AND HAS HAPPENED A TOTAL OF ABOUT SIX TIMES. *TR
Engine and engine cooling, Jan 9, 2017
TL* THE CONTACT OWNS A 2013 FORD EXPLORER POLICE INTERCEPT. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED AN ABNORMAL EXHAUST ODOR AFTER EXTENDED OPERATION. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 30,000.
Vehicle speed control, Engine, Dec 5, 2016
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT'S VEHICLE SHUT OFF WITHOUT WARNING. THE VEHICLE WAS PULLED OVER TO THE SIDE OF THE ROAD. THE DEALER DIAGNOSED THAT THE THROTTLE BODY AND MOTOR ASSEMBLY FAILED. THE THROTTLE BODY WAS REPLACED AND THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 61,900.
Vehicle speed control, Engine, Nov 29, 2016
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS ON SEVERAL OCCASIONS, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE THROTTLE BODY HAD EXCESS DEPOSITS, WHICH CAUSED THE VEHICLE TO STALL. THE VEHICLE WAS REPAIRED. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.
Engine, Nov 15, 2016
MY TRUCK HAS ALMOST 120000 MILES. AND WE WERE DRIVING AND NOTICE THE CHECK LIGHT CAME ON. WE WENT TO ADVANCE AUTO AND HAD THE TRUCK SCANNED TO SEE WHAT CODE WOULD COME UP. IT SAID THERE WAS TWO CYLINDER MISFIRED. AND THAT IT PROBABLY CAME FROM BAD FUEL. AND THEN THE ENGINE STARTED JUMPING AND SKIPPING. WE FINALLY GOT IT TO FIRESTONE AND THEY SAID THERE'S TAPPING AND KNOCKING AT THE BOTTOM OF THE ENGINE. THEY CAME TO THE CONCLUSION THAT NOW THE TRUCK NEEDS A NEW ENGINE. THEY QUOTED ME A ROUGH ESTIMATE OF $10,000. WE'VE KEPT UP WITH ALL THE OIL CHANGES ALONG WITH HAVING THE A/C COMPRESSOR REPLACED BECAUSE IT WENT OUT AS WELL. THE WARRANTY COMPANY WILL ONLY REPLACE THE ENGINE WITH A USED OR REMANUFACTURED ENGINE FOR $3700. THERE IS NO WAY A 2013 FORD EXPLORER WITH LESS THAN 120,000 MILES NEEDS A NEW ENGINE. AND WE ALSO SMELLED EXHAUST FUMES THROUGH THE VENTS INSIDE THE VEHICLE.
Engine, Nov 8, 2016
EXHAUST SMELL IS EXTREMELY NOTICEABLE AND DISTURBING, ESPECIALLY BECAUSE I AM TRAVELLING WITH A 3 YEAR OLD. WHAT CAN BE DONE TO RESOLVE THIS ISSUE IMMEDIATELY? I HAD A SIMILAR ISSUE WHEN THE GAS LINE HAD A LEAK AND THAT IS ALL I COULD SMELL.
Other or unspecified, Engine, Nov 6, 2016
DURING HEAVY ACCELERATION ... FOR EXAMPLE WHEN I'M ENTERING A HIGHWAY... REALLY STRONG SMELL OF ENGINE FUMES ENTER THE CABIN... EVERY TIME. I HAVE A 2013 FORD EXPLORER XLT - VERY HAPPY WITH MY FORD OTHERWISE.
Engine, Oct 21, 2016
EXHAUST LEAK IN CABIN
Engine and engine cooling, Oct 18, 2016
SOON AFTER THE PURCHASE, THERE WAS A BURNT METAL/EXHAUST SMELL IN THE INTERIOR OF THE EXPLORER WHEN THE DRIVER ACCELERATED TO PASS A CAR, GET ONTO THE INTERSTATE, OR SOMETHING SIMILAR AND THEN LET OFF THE ACCELERATOR. THE FIRST TIME IT HAPPENED, WE THOUGHT THE VEHICLE WAS ON FIRE AND PULLED OFF ONTO THE SIDE OF THE INTERSTATE AND GOT OUT OF THE VEHICLE. WE HAVE TO OPEN WINDOWS TO FLUSH OUT THE SMELL. AT FIRST, IT SEEMED THAT "RECIRCULATE" WOULD HAVE TO BE ON, BUT IN TIME IT DID NOT MATTER WHETHER IT WAS ON OR OFF. WHEN DRIVING IN TRAFFIC, WE DETECT EXHAUST SMELL AT ALL TIMES. TURNING ON "RECIRCULATE" HAS NO EFFECT. I HAVE ASTHMA, AND IT HAS BEEN WORSENING SINCE WE BOUGHT THE EXPLORER. I AM NOT A SMOKER. I NOW REFUSE TO RIDE IN THE EXPLORER AND AM DEMANDING THAT WE GET RID OF IT. *TR
Engine and engine cooling, Latches/locks/linkages, Oct 12, 2016
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. WHILE OPERATING THE VEHICLE AND DEPRESSING THE ACCELERATOR PEDAL WITH THE AIR CONDITIONER ACTIVATED, EXHAUST FUMES EMITTED FROM THE AIR CONDITIONING VENTS. ALSO, THE FRONT DRIVER'S SIDE DOOR AJAR SENSOR ILLUMINATED ALTHOUGH THE DOOR WAS SECURED. EVENTUALLY, THE DOOR COULD NOT BE LOCKED AT ALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DOOR LATCH MODULE WAS FAULTY AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 36,000.
Engine, Oct 6, 2016
I HAD AN INCIDENT IN JULY 24, 2016 WHEN I CAME TO A STOP AT A HIGHWAY TOLL BOOTH THE VEHICLE STARTED STALLING THE LOW OIL PRESSURE MESSAGE CAME ON AND STALLED I RESTARTED THE VEHICLE THE MESSAGE WENT AWAY AND RAN NORMAL THOUGHT IT WAS A CLUTCH SO I LEFT IT ALIGN. CHECKED OIL LEVEL AND IT WAS NORMAL. WELL TODAY 10/06/2016 MY MOTHER IN LAW THE VEHICLE BELONGING TO HER WAS DRIVING ON THE HIGHWAY TO WHERE SPEED LIMIT IS 70MPH. TRAFFIC CAME TO A SLOW DOWN ALMOST A STOP VEHICLE DID THE SAME LOW OIL PRESSURE MESSAGE CAME ON AND STALLED WITH MY KIDS ON BOARD. SHE HAD TO PUT IN PARK AND RESTARTED THE VEHICLE IN THE MIDDLE OF THE HIGHWAY POSING DANGER TO OTHER MOTORIST AND MOST IMPORTANT MY FAMILY. SOMETHING NEEDS TO BE DONE BEFORE SOMETHING BAD HAPPENS TO SOMEONE THAT COULD HAVE BEEN PREVENTED BY A RECALL AND FURTHER INVESTIGATION. THANK YOU FOR YOUR COOPERATION. *TR
Engine and engine cooling, Sep 21, 2016
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, EXHAUST FUMES EMITTED INSIDE THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE GRILL ASSEMBLY/VENT AIR, MOLDING, VALVE ASSEMBLY, AND AUTO DRAIN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 57,897. ..UPDATED 10/13/16 *BF UPDATED 10/18/16.*JB
Engine, Sep 19, 2016
WHILE DRIVING AN ERROR MESSAGE WITH WRENCH SYMBOL CAME ON AND CAR WOULDN'T MOVE. I PRESSED GAS PEDAL AND STILL WOULDN'T GO. I WAS DRIVING ON A CITY STREET IN HEAVY TRAFFIC..
Engine, Fuel/propulsion system, Sep 6, 2016
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. THE CONTACT STATED THAT THERE WERE STRONG FUMES EMITTING INTO THE CABIN OF THE VEHICLE, WHICH CAUSED NAUSEA AND HEADACHES. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.
Engine and engine cooling, Sep 1, 2016
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. WHILE DRIVING AT ANY SPEED, EXHAUST FUMES EMITTED INTO THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 34,000.
Engine, Aug 11, 2016
EXHAUST SMELL IN CABIN DURING HEAVY LOADS ON ENGINE. I HAVE HAD THE TSB COMPLETED BY FORD AND STILL HAVE THIS PROBLEM.
Power train, Vehicle speed control, Engine, Aug 8, 2016
THE THROTTLE BODY FAILS CAUSING MY VEHICLE TO ENTER "LIMP" MODE REGARDLESS OF LOCATION OR CURRENT SPEED. WILL GO 70 ON A HIGHWAY THEN ALL OF THE SUDDEN LOSE SPEED AND SPEED CONTROL. THIS ISSUE CAN ALSO HAPPEN WHEN ACCELERATING, SLOWING DOWN, ETC. THE BIGGEST WORRY IS LOSING SPEED CONTROL REGARDLESS OF LOCATION. THIS ISSUE HAS BEEN IDENTIFIED IN OTHER FORD MODELS AND IS BEING VOLUNTARILY REPAIRED (BY FORD). HOWEVER, FOR SOME REASON THE 2013 FORD EXPLORER WAS NOT INCLUDED IN THIS. OBVIOUSLY LOSING THROTTLE CONTROL WHILE DRIVING, HENCE FORDS VOLUNTARY REPAIR OF THE ISSUE. THE ISSUE STARTED TWO WEEKS AGO AND RANDOMLY HAPPENS. LAST HAPPENED ON 05 AUG 2016.
Power train, Engine, Fuel/propulsion system, Aug 3, 2016
ON TWO SEPARATE OCCASIONS, THE CAR STALLED AFTER DE-ACCELERATING TO A STOPPED POSITION AND MADE A "CLUNK" SOUND FROM THE TRANSMISSION AREA. DURING THE FIRST EVENT AT A TRAFFIC LIGHT, A VERY NOTICEABLE "CLUNK" WAS HEARD THAT SOUNDED LIKE THE TRANSMISSION. THE CAR WAS RE-STARTED AND SEEMED TO DRIVE NORMALLY. TO BE ON THE SAFE SIDE, WE BROUGHT THE CAR TO THE DEALERSHIP TO HAVE IT CHECKED BUT THEY COULD FIND NOTHING WRONG. DURING THE SECOND EVENT AT A STOP SIGN, ANOTHER VERY NOTICEABLE "CLUNK" WAS HEARD FROM THE UNDERSIDE OF THE CAR AND THE CAR ACTUALLY SHIFTED SO THAT IT WAS FELT BY THE BODY. AFTER RE-STARTING THE CAR THIS TIME AND PLACING IT INTO DRIVE, THIS TIME THE CAR DID NOT MOVE WHEN PRESSING DOWN ON THE GAS PEDAL. INSTEAD, ONLY THE ENGINE REVVED UP. IN ADDITION, WHEN PUTTING THE GEAR INTO THE REVERSE OR DRIVE POSITION, THAT LOUD "CLUNK" SOUND AND THE PHYSICAL SHIFTING OF THE VEHICLE ALSO HAPPENED. BECAUSE THE CAR WOULD LITERALLY NOT GO, WE CALLED FOR A TOW-TRUCK AND TOOK IT TO THE FORD DEALERSHIP. AT THE DEALERSHIP, A CUSTOMER CARE REP AND A TECHNICIAN CAME OUTSIDE TO LOOK AT THE CAR. WHEN PUTTING THE CAR INTO REVERSE AND DRIVE, THE SAME "CLUNK" AND SHIFTING OF THE VEHICLE WAS OBSERVED AND ACKNOWLEDGED BY BOTH MEN. HOWEVER, AT THIS POINT THE CAR WOULD MOVE FORWARD WHEN APPLYING THE GAS. WE LEFT THE CAR AT THE DEALERSHIP FOR EVALUATION. WHEN FOLLOWING UP EARLY THE NEXT WEEK, ,WE WERE INFORMED THAT THEY HAD DRIVEN THE CAR ABOUT 100 MILES OVER THE COURSE OF THREE TRIPS AND THE CAR WAS RUNNING NORMALLY. ALSO, WE WERE TOLD THAT THE DIAGNOSTIC/EVALUATION OF THE PCM AND TRANSMISSION DID NOT SHOW ANYTHING WAS WRONG. IN MY OPINION, THERE ARE TWO PROBLEMS HERE: #1, THE STALLING/TRANSMISSION PROBLEM AND #2, THE INABILITY TO IDENTIFY THE PROBLEM FOR SUCH A MAJOR EVENT
Engine, Aug 2, 2016
I PURCHASED A NEW 2013 FORD EXPLORER IN PUERTO RICO ON NOVEMBER 2014. SINCE THE FIRST DAY IT LEAKED EXHAUST FUMES INTO THE CABIN WHEN ACCELERATING. AFTER MORE THAN 10 SERVICE VISITS TO THE DEALERSHIP, I WAS TOLD BY FORD FIELD SERVICE ENGINEER CARLOS J. DOMINGUEZ "THERE WAS NOTHING MORE THEY COULD DO ABOUT THE PROBLEM BECAUSE IT WAS CAUSED THE VEHICLE'S DESIGN, THE ANGLE AND HEIGHT IT STANDS FROM THE ROAD AND THE VACUUM THAT CAUSED WHEN THE VEHICLE ACCELERATED". I WAS DIAGNOSED WITH LYMPHOMA - CANCER A YEAR AND A MONTH AFTER I PURCHASED MY 2013 FORD EXPLORER. I TRADED IT IN FOR A NEW 2016 FORD EXPLORER LAST MAY IN THE HOPE THE NEW MODEL DID NOT HAVE THE SAME ISSUE, BUT IT DOES. AFTER DEALERSHIP CONSULTED FORD, THEY ASKED ME TO BRING THE UNIT IN TO PERFORM THE SAME REMEDIES AS MY PREVIOUS 2013 FORD EXPLORER UNIT. CONSULTED MY ONCOLOGIST AND WE ARE LOOKING INTO THE POSSIBILITY THAT MY 2013 FORD EXPLORER MIGHT HAVE CAUSED MY LYMPHOMA CANCER.
Engine, Fuel/propulsion system, Aug 1, 2016
EXHAUST SMELL IN INTERIOR OF VEHICLE. I TYPICALLY DRIVE WITH A/C OR HEAT ON (SEASONALLY) AND ALWAYS USE OUTSIDE AIR (NO RE-CIRCULATION). SMELL IS MORE NOTICEABLE WHEN IDLING AT A STOP LIGHT OR OTHERWISE NOT IN MOTION. HAVE TRIED TWO SERVICE CALLS RECENTLY WITH NO RESOLUTION. AN ADDITIONAL RELATED ISSUE IS AN EVEN STRONGER FUEL SMELL IN MY GARAGE. THIS IS MORE OF A PRE-COMBUSTION SMELL. THE DEALER REPORTED THAT THIS IS NORMAL AS A RESULT OF THE CAPLESS GAS TANK FILTER SYSTEM. DEFINITELY A HEALTH HAZARD FOR ANYONE ENTERING THE GARAGE, AND THE SMELL GETS INTO THE HOUSE. THESE ISSUES HAVE PERSISTED FOR THE PAST 6-12 MONTHS, GETTING WORSE OVER TIME. TO DATE, THE DEALER HAS NO RESOLUTION FOR EITHER ISSUE. PLEASE HELP.
Engine and engine cooling, Jul 26, 2016
TL* THE CONTACT OWNS A 2013 FORD EXPLORER. WHILE DRIVING 55 MPH, EXHAUST FUMES ENTERED THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS A VENT LEAK THAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 76,718. UPDATED 10/07/16*LJ *CN
Power train, Other or unspecified, Engine, Jul 19, 2016
BOUGHT A USED FORD EXPLORE XLT WITH 32K MILES. AS I HAVE BEEN DRIVING THE SUV I AM NOTICING THAT WHENEVER I FULLY PRESS DOWN ON THE GAS PEDDLE TO INCREASE MY ACCELERATION WHETHER I AM MERGING ONTO THE FREEWAY, CHANGING LANES OR SCALING A HILL, THE CABIN IS FILLED WITH A STRONG EMISSIONS ODOR. WHICH WORRIES ME BECAUSE I NORMALLY HAVE CHILDREN IN THE VEHICLE. AS I LET UP ON THE GAS PEDDLE THE ODOR DISSIPATES. I HAVE NOTICED THIS ODOR WHEN I HAVE MY MAX A/C FUNCTION ON WHICH IS USING RECIRCULATED AIR.
Power train, Vehicle speed control, Engine, Jul 12, 2016
DELAY OR LAG UNDER HEAVY ACCELERATION, WAS MAKING A LEFT ONTO INCOMING TRAFFIC FROM A COMPLETE STOP, SHOULD HAVE HAD ENOUGH TIME UNDER NORMAL CIRCUMSTANCES TO MAKE THE TURN BUT THERE WAS ABOUT A 3 SECOND DELAY BEFORE THE ENGINE REALLY KICKED IN AND STARTED ACCELERATING AND ENDED UP ALMOST CAUSING AN ACCIDENT, I'VE NEVER FELT SO POWERLESS TO DO ANYTHING OTHER THAN VEER OUT OF THE LANE TO AVOID GETTING HIT