2016 Ford Explorer
Problems, recalls and owner-reported issues
Structure is the leading concern among 2,452 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 Explorer model years with reports.
Of the 2016 reports, 39 involved a crash and 14 involved a fire. 59 people were injured.
What owners report most often
Recalls and investigations
Structure, bodyJul 14, 2026
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Campaign 26V448000 on NHTSA.gov
Equipment, electrical, engine block heaterOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
An electrical short circuit can increase the risk of a fire.
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Campaign 25V685000 on NHTSA.gov
Structure, bodyMay 23, 2025
Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.
Dealers will repair the B-pillar trim, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2025. A second notice will be sent once the final remedy is available, anticipated November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S53.
Campaign 25V347000 on NHTSA.gov
Structure, body, roof and pillarsJan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Campaign 24V031000 on NHTSA.gov
Suspension, rearJul 15, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.
Campaign 21V537000 on NHTSA.gov
Structure, bodyMay 5, 2021
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Campaign 21V316000 on NHTSA.gov
Suspension, rearMar 12, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.
Campaign 20V675000 on NHTSA.gov
Power train, axle assembly, axle shaftNov 10, 2020
Ford Motor Company (Ford) is recalling certain 2014-2016 Explorer, 2014-2015 Taurus and 2014 Edge vehicles equipped with 2.0L or 2.3L engines and front wheel drive. The support bracket for the front drive axle halfshaft may fail.
The failed bracket could result in a loss of park function which can cause unintended vehicle movement, and loss of motive power while driving which increases the risk of a crash.
Ford will notify owners, and dealers will replace the link shaft bracket, free of charge. Parts are not currently available. Owners received an interim notification detailing safety risk December 8, 2020. A second letter will be mailed when parts become available in January 2021. The recall began February 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S63.
Campaign 20V692000 on NHTSA.gov
Suspension, rearJun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Campaign 19V435000 on NHTSA.gov
SeatsNov 29, 2017
Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.
In the event of a crash, a seat occupant that is not properly restrained has an increased risk of injury.
Ford will notify owners, and dealers will inspect the tightness of the power seat track upper pivot link bolt, either applying threadlocker or replacing the lift link and hardware, free of charge. Interim letters are expected to go out January 15, 2018. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S40.
Campaign 17V767000 on NHTSA.gov
Wheels, hubAug 28, 2017
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
A loss of the wheel or wheel end can increase the risk of a crash.
Ford will notify the distributors of the hubs specifying that they are to only be used on drive axles. It is believed that none of the hubs were purchased from Ford dealers for the incorrect application. Owners may contact Ford customer service at 1-866-436-7332.
Campaign 17E048000 on NHTSA.gov
Seats, front assembly, reclinerJun 28, 2016
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
The seat back may not adequately restrain the occupant during a crash, increasing the risk of injury.
Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall begin on August 18, 2016. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 16C11.
Campaign 16V475000 on NHTSA.gov
Engine and engine cooling, engineMar 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Lincoln MKC vehicles manufactured November 25, 2013, to January 25, 2016, and 2016 Ford Explorer vehicles manufactured October 20, 2014, to January 28, 2016. The affected vehicles are equipped with 2.3L GTDI engines and engine block heaters. These engine block heaters have elements that may overheat while plugged in.
Overheating of the engine block increase the risk of a fire.
Ford will notify owners, and dealers will replace the engine block heater, free of charge. Dealers will also inspect and replace the electrical cord, as necessary. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S14. Note: Owners should not use the engine block heater until the vehicle has been remedied.
Campaign 16V183000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 28, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Lincoln MKS, and 2016 Ford Explorer vehicles manufactured on July 24, 2015. During vehicle production, the fuel tank attachment bolts may not have been properly tightened. As a result, the fuel tank straps may fracture and the fuel tank could separate from the vehicle.
If the fuel tank separates from the vehicle, a fuel leak may occur, increasing the risk of a fire.
Ford will notify owners, and dealers will tighten the fuel tank attachment bolts, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S26.
Campaign 15V605000 on NHTSA.gov
Parking brakeJul 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
If the parking brake does not fully engage and the transmission is left in a gear other than 'Park' while on a slope, the vehicle may roll away, increasing the risk of a crash.
Ford will notify owners, and dealers will test the operation of the parking brake system, and if necessary, replace the parking brake control assembly, free of charge. The recall began on September 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C07.
Campaign 15V464000 on NHTSA.gov
Representative owner complaints: electrical system
125 reports, newest first. Show all
Steering, Suspension, Electrical system, Jan 20, 2022
My rack and pinion steering column and power steering pump went out causing a hefty cost to replace and it is starting to fail again creating hazardous conditions while driving. I do believe there is a steering issue in these models. Also my power lift gate in the back closes without stopping automatically while I’m loading the rear or unloading. There is NO STOPPING SAFETY SENSOR, I HAD THE BACK CLOSE ON ME MULTIPLE TIMES AND ALMOST CRUSH ME. there is no safety sensor to stop the power lift gate from closing on you, I have had to crawl in my rear end to avoid being crushed by my liftgate! This is not safe!
Electrical system, Air bags, Seat belts, Jan 11, 2022
The airbag light comes on due to the connectors in the wiring harness used for the airbag and seatbelt restraint system. When the light is on the airbags will not deploy, making this a safety related issue. Ford has a technical service bulletin Ford TSB 16-0001 showing the issue. This is not covered for repair and the cost is $900.00 to $1100.00 per side (there are two sides) to replace the wire harness and connectors. https://www.tsbsearch.com/Ford/16-0001
Electrical system, Air bags, Aug 5, 2021
Vehicle displays airbag warning light. Dealership diagnostic test determined there is a faulty connection to the 2nd-row inflatable seatbelt sensor. Ford issued a service bulletin to replace the wire harness pigtail connection. When the airbag light is illuminated due to this faulty connection, all of the airbags in the vehicle are deactivated. Directly from site: Https://Ford.oemdtc.com/1203/air-bag-warning-light-illuminated-with-dtc-B141B-B141C-2014-2016-Ford-Explorer tsb 16-0001 airbag warning light illuminated with diagnostic trouble code (dtc) B141B and/or B141C. This is not normal wear and tear but a safety item design by Ford that has failed in the vehicle. Ford dealership claims that this is not warranty failure. Cost to repair $1085 plus $230 diagnostic test charge.
Electrical system, Jun 29, 2021
The electronic door clocks are continuously failing where the door cannot be opened in an emergent situation. On 6/24/20 the front driver door latch had to be replaced and on 03/21/21 the left rear door latch had to be replaced. Presently the right rear door latch is not operating and the vehicle has been scheduled for service on 7/9/21.. When these locks fail you are unable to open the doors unless you can reach the lock to pull up. In an emergency such as a crash or fire this failure can be fatal. It appears that there is a design flaw or defect with these locks. Review of internet blogs reveal this may be a common unreported problem that needs immediate attention. In the event there are emergent circumstances requiring the removal of a child or elderly this may be tragic.
Electrical system, Structure, Apr 17, 2021
RADIO SPARKING AND SMOKING PLUS PEELING AND BUBBLES INSIDE THE HOOD PAINT
Electrical system, Air bags, Apr 15, 2021
AIR BAG LIGHT ON DASH. CAUSED BY DTC B141B. FOUND TSB RELATED TO CONNECTORS UNDER REAR SEAT MP 130. CAR WAS STATIONARY.
Electrical system, Air bags, Apr 13, 2021
THE 2ND ROW AIRBAG LIGHT CAME ON, AND FORD TOLD ME IT WAS A SHORTAGE IN THE WIRES AND IT WASN'T COVERED UNDER THE MANUFACTURERS WARRANTY. THEY STATED THAT SINCE THE AIRBAG LIGHT WAS ON, THE SHORT IN THE WIRING WOULD STOP THE AIRBAG FROM DEPLOYING, WHICH IN TURN IS A SAFETY ISSUE.
Power train, Electrical system, Feb 22, 2021
94000 MILES THE TRANSFER CASE BURST AND WHEN 70000 MILES CHARGING CYCLE DOES NOT WORK , THE VEHICLE SUDDENLY STOPS.
Electrical system, Air bags, Jan 18, 2021
AIRBAG LIGHT HAS BEEN COMING ON INTERMITTENTLY FOR OVER 1 YEAR. DIAGNOSTIC TEST DETERMINED THERE IS A FAULTY CONNECTION TO THE 2ND ROW INFLATABLE SEATBELT SENSOR. FORD ISSUED A SERVICE BULLETIN TO REPLACE THE WIRE HARNESS PIG TAIL CONNECTION. WHEN THE AIR BAG LIGHT IS ILLUMINATED DUE TO THIS FAULTY CONNECTION, ALL OF THE AIR BAGS IN THE VEHICLE ARE DEACTIVATED. THIS IS EXTREMELY DANGEROUS, AND MY FAMILY HAS BEEN DRIVING THE CAR IN THIS CONDITION FOR OVER A YEAR. UPON FURTHER RESEARCH, NUMEROUS CASES EXIST REPORTING THE SAME ISSUE. PLEASE ADDRESS THIS SAFETY ISSUE.
Electrical system, Air bags, Seat belts, Dec 18, 2020
THERE IS AN SRS AIRBAG WARNING LIGHT ON THE DASHBOARD THAT USED TO INTERMITTENTLY DISPLAY. NOW IT IS ON CONSISTENTLY WHEN THE VEHICLE IS DRIVEN. IT IS DUE TO A CIRCUIT FAILURE OR A BROKEN CORD LEADING TO THE DRIVER SIDE MIDDLE ROW SEATBELT AIRBAG. DIRECTLY FROM SITE: HTTPS://FORD.OEMDTC.COM/1203/AIR-BAG-WARNING-LIGHT-ILLUMINATED-WITH-DTC-B141B-B141C-2014-2016-FORD-EXPLORER TSB 16-0001 AIR BAG WARNING LIGHT ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) B141B AND/OR B141C THIS IS NOT NORMAL WEAR AND TEAR BUT A SAFETY ITEM DESIGN BY FORD THAT HAS FAILED IN THE VEHICLE. FORD DEALERSHIP CLAIMS THAT THIS IS NOT WARRANTY FAILURE. BUT SOUNDS LIKE AN ELECTRICAL AND SAFETY ISSUE TO ME...WHICH SHOULD BE COVERED UNDER WARRANTY. THE TRUTH TO THE MATTER IS...FORD DOES NOT CARE THAT A POTENTIALLY HIGH RISK PROBLEM HAS BEEN IDENTIFIED AS A FAILURE ON THE COMPANY'S END BUT THEY DON'T CARE ENOUGH TO DO ANYTHING ABOUT IT. WELL..OTHER THAN CHARGE THE CUSTOMER CLOSE TO $1000 OUT OF POCKET TO FIX FOR A POOR DESIGN ON FORD'S END. THE FORD DEALERSHIP SERVICE DEPARTMENT DOES NOT KNOW HOW THIS SAFETY FEATURE BROKE. IF WE WERE TO GET IN AN ACCIDENT WHILE THE AIRBAG IS IN THIS STATE, IT WOULD NOT DEPLOY AND THE LIVES OF ALL PASSENGERS IN JEOPARDY!
Electrical system, Air bags, Seats, Nov 11, 2020, fire
ON AUGUST 20, 2020, MY VEHICLE HAD LAST BEEN DRIVEN AROUND 12 NOON. IT SAT IN THE DRIVEWAY WITH ALL OF US HOME. MY SON WENT TO GET IN THE VEHICLE AROUND 6:30 PM. SMOKE POURED OUT, THE SEAT WAS SMOLDERING AND FLAMES CAME UP. WE COULDN'T PUT THE FIRE OUT WITH EXTINGUISHER. FIRE DEPARTMENT PUT HOSE ON SEAT. FIREMEN STATED THEY SEE THIS OFTEN WITH HEATED/AIRCONDITIONED SEATS THAT MALFUNCTION AND BURN UP OR CAUSE FIRE. FIREMEN STATED THEY COULD TELL THE WAY IT LOOKED "LIKE ALL THE OTHER HEATED /AIR CONDITIONED SEATS THAT IGNITE THAT THEY SEE OFTEN". INSURANCE COMPANY SAYS CAR IS TOTALED SINCE HOSE WAS PUT ON IT. FORD WILL NOT WORK WITH ME. NO ONE LEFT ANYTHING BURNING IN THE SEAT OR SMOKED IN THE CAR. I BELIEVE THE CAR HEATED/AIR CONDITIONED SEAT MALFUNCTIONED AND FORD SHOULD HELP. I HAD PURCHASED BUMPER TO BUMPER WARRANTY FROM DEALERSHIP. WARRANTY COMPANY SAYS IF A CAR CATCHES FIRE, WARRANTY IS VOIDED, EVEN IF CAR MALFUNCTIONED CAUSING THE FIRE. INSURANCE COMPANY IS TRYING TO PAY AS LEAST AMOUNT AS POSSIBLE. THIS WAS A WELL CARED FOR, VERY NICE CAR. I BELIEVE IT MALFUNCTIONED. FORD MOTOR COMPANY SENT ME A LETTER SAYING THEY HAD THE DEALERSHIP TAKE PICTURES, AND THEY FEEL IT HAD SOMETHING LEFT BURNING ON THE SEAT. NO ONE LEFT ANYTHING BURNING ON THE SEAT. IN THE LETTER FORD MOTOR COMPANY SENT ME BY EMAIL, THEY STATE THEY INSPECTED THE CAR. THEY NEVER CAME TO SEE THE CAR IN PERSON. THEY ONLY HAD THE SERVICE STAFF TAKE PICTURES. THE CAR WAS SITTING IN THE DRIVEWAY ALL AFTERNOON. I ALSO BACKED OUT OF THE DRIVEWAY IN MY SUBARU AT 5:00 PM AND DID NOT SMELL OR SEE SMOKE AS I LEFT.. THE PASSENGER SEAT THAT IGNITED ITSELF HAD A STACK OF BUSINESS PAPERS AND SOME SOCCER GEAR THAT COULD HAVE OVERHEATED IF THE SEAT WAS MALFUNCTIONING TOO. THE SEAT IGNITED BY ITSELF. AS A CONSUMER I DESERVE TO BE ASSISTED. I WOULD LIKE THE CAR REPAIRED OR REPLACED W/SIMILAR CAR.*DT CONSUMER STATED VEHICLE WAS TOTALED AND SETTLEMENT WAS OFFERED BY THE INSURANCE COMPANY. VEHICLE WAS TOWED TO THE DEALERSHIP. *JB
Power train, Electrical system, Engine, Nov 5, 2020
WITHIN 10 DAYS OF BUYING IT BRAND NEW I'VE HAD ELECTRICAL PROBLEMS. REPLACED BACK UP SCREEN WITHIN THOSE 10 DAYS EVEN THOUGH THEY DIDN'T FIND ANYTHING WRONG. STILL CONTINUES. MULTIPLE ISSUES WITH THE POWER TRAIN. NOW I'VE BEEN OUT OF A CAR FOR 2 WEEKS BECAUSE I MIGHT NEED A NEW TRANSMISSION AT 65,000 NO LONGER UNDER WARRANTY. HOW CAN I PAY $38,000 AND IT GOES BAD INSTANTLY? NO HELP FROM FORD OR DEALER. MY GEARS ARE STALLING AND NOT SHIFTING CORRECTLY OR PICKING UP SPEED. I DRIVE LIKE AN OLD LADY AND TAKE CARE OF THIS CAR LIKE IT'S BRAND NEW. I WILL NEVER BUY A FORD AGAIN AND WILL TELL ANYONE WHO WILL LISTEN NOT TO DO THE SAME.
Electrical system, Sep 16, 2020
PER FORD WEBSITE, I WAS TOLD THAT MY SYNC SOFTWARE NEED AN UPGRADE WHEN I TYPED IN THE VIN, THEN I FOLLOW THE INSTRUCTION ON WEBSITE BUT THE PROGRAM I DOWNLOADED MESSED UP MY APIM MODULE ON MY CAR AND RADIO, GPS, AND OTHER FUNCTION AE NOT WORKING. SO I TOOK MY SUV TO THE DEALER AND THEY SAID IT WILL COST ME $1050 TO FIX THE ISSUE.
Steering, Electrical system, Electronic stability control (ESC), Jun 22, 2020
SATURDAY JUNE 20TH 2020 THE HILL ASSIST MESSAGE CAME ON AS DID THE ABS AND TRACTION CONTROL LIGHTS CAME ON. THERE IS NO POWER STEERING AND BOTH AXLES ARE MAKING A CLICKING NOISE. I HAVE LEARNED THAT THIS IS THE RACK AND PINION ELECTRONIC POWER ASSIST SYSTEM. EPAS UNIT HAS FAILED. LUCKILY IT WAS IN MY CUL DE SAC TURNING AROUND AND NOT ON THE FREEWAY. MY WIFE PREDOMINANTLY DRIVES THIS VEHICLE. THE STEERING IS VERY DIFFICULT TO MOVE. THE VEHICLE ONLY HAS 64,000 MILES ON IT. IS THIS A PRIVATE RECALL? I HAVE SPOKEN WITH A COUPLE OF OTHER EXPLORER OWNERS THAT FORD "TOOK CARE OF IT" FOR THEM. I HAVE ORDERED THE PART, BUT IT WILL NOT BE THERE FOR A WEEK. THIS CAR IS WELL TAKEN CARE OF AND IS NORMALLY DRIVEN ON CITY STREETS AND OCCASIONALLY ON THE HIGHWAY. *TR
Electrical system, Seats, Feb 18, 2020
SEAT HEAT UNDER DRIVER SEAT KEEPS GOING BAD. ONLY THE SEAT BOTTOM, NOT THE TOP. I NOTICED AS THIS IS THE 3RD TIME IT HAS BEEN IN FOR THIS, THAT WHEN I HAVE THE SEAT IN THE FARTHEST BACK POSITION IT WORKS, BUT WHEN THE SEAT IS MOVED FURTHER IT PULLS ON THE WIRES. I WONDER IF THIS COULD BE CAUSING A SHORT IN THE WIRING, WHICH POTENTIAL COULD BE A FIRE HAZARD.
Steering, Electrical system, Nov 14, 2019
ISSUES STARTED WITH SEVERAL ELECTRICAL GLITCHES THAT OCCURRED AND STILL OCCUR CONSISTENTLY WITH NO RESOLUTION. BATTERY WAS "FRIED" AND REPLACED, SYNC MODULE WAS REPLACED, NOW THE GLITCHES INCLUDE A FROZEN STEERING COLUMN WHILE DRIVING AND A "CHARGING SYSTEM SERVICE NOW" LIGHT THAT COMES ON AND OFF WHILE STATIONARY AND DRIVING. ALSO PASSENGER SIDE VIEW MIRROR GETS STUCK OUTWARDS, INTERIOR ELECTRICAL MALFUNCTIONS. TRUCK IS NO LONGER UNDER WARRANTY AND I AM TIRED OF PAYING $150 DIAGNOSTIC FEES WITH NO RESOLUTION.
Electrical system, Air bags, Seat belts, Oct 30, 2019
AIRBAG WARNING LIGHT APPEARED ON INSTRUMENT GAUGE @ APPROX 65,000 MILES. THE CONCERN IS FOR THE REAR SEAT RESTRAINT SYSTEMS THAT HAVE AIRBAGS BUILT INTO THE SEATBELT SHOULDER STRAPS. THIS DESIGN FLAW BY FORD MOTOR CO HAS RESULTED IN FAULTY WIRE HARNESS SYSTEMS FOR THE SEAT BELT AIRBAGS. FORD IS NOT TAKING ACTION BECAUSE THERE IS NO OFFICIAL "RECALL" EVEN THOUGH THIS IS A WELL KNOWN DESIGN DEFECT. FORD IS LEAVING THE RESPONSIBILITY UP TO CONSUMERS TO PAY OUT-OF-POCKET FOR THIS REPAIR @ A $660.00 COST!!! THIS IS ABSOLUTELY UNACCEPTABLE AS WE ARE TALKING ABOUT ARGUABLY THE MOST IMPORTANT SAFETY FEATURE OF A MODERN AUTOMOBILE...THE AIRBAGS!!! FORD CLEARLY CANNOT STAND BEHIND THEIR OWN PRODUCTS FROM A SAFETY STANDPOINT, SO CONSUMERS SUCH AS MYSELF ARE FORCED TO PAY THE $660.00 CHARGE IN ORDER TO PROTECT THE PASSENGERS (OFTEN CHILDREN IN OUR SCENARIO) IN THE BACKSEAT OR TAKE THE DEATHLY RISK OF SAFETY AIRBAGS NOT DEPLOYING IN AN ACCIDENT SCENARIO? YOU'VE GOT TO BE KIDDING ME. EXTREMELY SHAMEFUL AND DISAPPOINTING THAT ONE OF THE BIGGEST AUTOMOBILE MANUFACTURERS IN THE WORLD CANNOT STAND BEHIND IT'S OWN SAFETY PRODUCTS. THIS NEEDS TO BE ISSUED A RECALL PRONTO...THIS IS PEOPLE'S SAFETY WE ARE TALKING ABOUT HERE!
Steering, Electrical system, Oct 17, 2019
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING 70 MPH, THE STEERING COLUMN SEIZED AND THE STEERING COLUMN WARNING INDICATOR ILLUMINATED. THE CONTACT PULLED THE VEHICLE TO THE SIDE OF THE HIGHWAY, PRESSED THE "OK" OPTION ON THE MESSAGE BOARD, AND WAS ABLE TO RESUME NORMAL DRIVING. ALSO, WHILE DRIVING 55 MPH AND HAULING A TRAILER, THE "HILL START ASSIST NOT AVAILABLE" WARNING INDICATOR ILLUMINATED. THE CONTACT PRESSED THE "OK" BUTTON AND THE WARNING LIGHT DISAPPEARED. IN ADDITION, THE ABS, STEERING FAULT SERVICE NOW, AND SERVICE TRACK WARNING INDICATORS ILLUMINATED AT VARIOUS TIMES WHILE DRIVING. DURING THE FAILURE, THE CONTACT PRESSED THE "OK" BUTTON AGAIN AND THE WARNING INDICATORS DISAPPEARED. THE CONTACT TOOK THE VEHICLE TO SUNNYVALE FORD (650 E EL CAMINO REAL, SUNNYVALE, CA 94087, 408-215-9949) AND WAS INFORMED THAT THE REPAIRS WOULD COST $400. AFTER A DIAGNOSTIC WAS PERFORMED, THE DEALER DETERMINED THAT THE WARNING INDICATOR ILLUMINATION WAS LINKED TO A FAULTY BATTERY. THE DEALER WANTED TO TEST THE VEHICLE'S TRAILER HITCH CABLE TO DETERMINE IF THAT CABLE WAS LINKED TO THE FAILURES. IT WAS DIAGNOSED THAT THE STEERING RACK WAS THE CAUSE FOR THE SYSTEM FAILURE AND THE DEALER PROVIDED AN ESTIMATE FOR THE REPAIRS. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 32,000.
Electrical system, Air bags, Aug 22, 2019
STANDARD DRIVING DRUG WITH NO CRASHES. AIRBAG LIGHT BEGAN COMING ON INTERMITTENTLY WHILE DRIVING IN EARLY TO MID OCTOBER OF 2018 (AROUND 45,000 MILES). AFTER A FULL WEEK OF THE LIGHT STAYING ON VEHICLE WAS TAKEN TO DEALERSHIP. THE HARNESS CONNECTOR WAS LOOSE. FIVE TO SEVEN DAYS AFTER REPAIR THE LIGHT BEGAN COMING ON INTERMITTENTLY AGAIN. A SECOND DEALERSHIP SAID THE GARDENS CONNECTOR WAS LOOSE. TWO TO THE WEEKS LATER THE LIGHT CAME ON AND PERSISTED. I WAS TOLD IN LATE MAY THAT IT WAS THE WIRING HARNESS BEFORE THE FRONT PASSENGER SEAT. AFTER SOME ISSUES WITH THE DEALERSHIP, IT WAS TAKEN TO THE DEALERSHIP THAT ORIGINALLY FIXED IT IN OCTOBER 2018. THIS TIME BOTH THE PASSENGER WIRING HARNESS AND AIRBAG WERE REPLACED. OVER $800 AND 3.5 HOUR APPOINTMENT FOR THE ACTUAL FIX. PICTURES FROM INITIAL SERVICE ARE ATTACHED.
Power train, Electrical system, Engine, Aug 10, 2019
REQUIRED A NEW TRANSMISSION. REPORTED INITIAL PROBLEM AT 58,000 MILES THE DEALER COULD NOT FIND A PROBLEM WHILE CAR WAS STILL UNDER WARRANTY. CAR WAS EXPERIENCING A HESITATION DURING ACCELERATION. AT 80,000 MILES THE TRANSMISSION HAD TO BE REPLACE (OUT OF WARRANTY). REQUIRE NEW BATTERY AND CABLES AFTER BATTER "EXPLODED" CORRODING THE BATTERY CABLES. (68,000 MILES). REQUIRED A NEW WATER PUMP AT 86,000 MILES.
Electrical system, Air bags, Aug 1, 2019
AT APPROX 48,000 MILES, AIRBAG LIGHT CAME ON. CAR WAS NOT MOVING, WAS PARKED FOR 9 HOURS AFTER A DAY OF WORK. NOTHING HIT, NO IMPACT. FORD DEALER DIAGNOSIS: AIRBAG HARNESS/CONNECTOR ISSUE TRACED BACK TO REAR PASSENGER SEAT BEHIND DRIVER. 1.5 DAYS WORK AND $478.93 CHARGE, NOT A WARRANTY OR RECALL REPAIR. AIRBAG CIRCUIT INOPERATIVE. FIX IS PER TSB16-0001. I AM KEEPING THE PARTS THE DEALER IS REPLACING. REQUIRES REMOVAL OF REAR SEATS/REPLACE/SPLICE CONNECTOR. DEALER NOT FORGIVING.
Electrical system, Electronic stability control (ESC), Engine, Jul 27, 2019
2016 FORD EXPLORER - THE BACKUP CAMERA WILL COME ON WHILE TRAVELING DOWN THE HIGHWAY AT 55-60 MPH. WILL CAUSE IT TO LOOSE POWER, THE RPM'S DROP RIGHT BELOW 1000, THE WRENCH SYMBOL COMES ON, AND IT WILL BARELY MOVE DOWN THE ROAD. A SCREEN WILL POP UP ON OCCASION SAYING HILL ASSIST IS UNAVAILABLE. YOU HAVE TO PULLOVER, TURN THE CAR OFF, OPEN THE DRIVER DOOR TO MAKE SURE THE RADIO AND ALL GOES OFF, WAIT EXACTLY ONE MINUTE, AND THEN YOU ARE ABLE TO CRANK THE VEHICLE UP TO BE ABLE TO MOVE. I HAVE TAKEN TO DEALERSHIP, AND ALL THEY SAY IS IT'S A SENSOR INSIDE THE TRANSMISSION, AND ALL THEY CAN DO IS CLEAR THE CODE OUT. THEY SAY THAT IT IS SAYING MY VEHICLE IS TRYING TO ENGAGE IN REVERSE WHILE GOING DOWN THE ROAD. THIS SOUNDS LIKE A HUGE SAFETY ISSUE ESPECIALLY WHEN I HAVE HAD OTHERS SAY THE SAME THING HAS HAPPENED TO THEM AS WELL. I HAVE REACHED OUT TO THE DEALERSHIP IN REGARDS TO MY WARRANTY, BUT I HAVE YET TO HEAR BACK FROM THEM, AND IT HAS BEEN OVER 2 WEEKS. I HAVE ALSO REACHED OUT TO THE SALES REPRESENTATIVE SEVERAL TIMES, AND I HAVE YET TO HEAR FROM HIM. I CONTACTED THEM BECAUSE WHILE LOOKING AT THE PAPERWORK IT SAID IT HAD A LIMITED POWER TRAIN WARRANTY, BUT IT WAS PURCHASED AS A PRE-CERTIFIED USED VEHICLE WITH AN UNLIMITED POWER TRAIN WARRANTY THEY WERE OFFERING FOR VEHICLES WITH LEST THAN 80,000 MILES. I HAVE NOT HAD IT A YEAR YET. I HAVE AN EMAIL FROM THE SALES REP HIMSELF STATING THAT IT IS UNLIMITED. IT WAS PURCHASE IN SEPTEMBER OF 2018.
Steering, Electrical system, Jul 9, 2019
THE STEERING FAILURE LIGHT CAME ON ABOUT 2 WEEKS AGO AND I BROUGHT TO DEALER. THEY SAID IT WAS NOT THE STEERING BUT THE BATTERY PUTTING OUT THE WRONG VOLTAGE AND CAUSED THE SENSOR TO COME ON. TODAY I ACTUALLY LOST STEERING ON THE VEHICLE WHILE DRIVING ABOUT 30 MILES ON A LOCAL STREET. THE STREET CURVED AND I COULD NOT TURN THE WHEEL. THE STEERING FAULT LIGHT CAME ON AND CAR SAID THAT THE TERRAIN ASSIST AND HILL ASSIST WAS DISABLED (WAS NOT USING). I WAS ABLE TO PUT MY HAZARDS ON, AND STRUGGLE WITH THE STEERING TO PULL OVER. I ONLY HAVE 42000 MILES ON THIS VEHICLE AND HAVE HAD NUMEROUS ELECTRICAL PROBLEMS WITH THIS CAR, INCLUDING REPLACING THE APIM. I HAVE A 16 YEAR OLD, THAT JUST STARTED DRIVING WITH ME IN THIS CAR, AND I DO NOT THINK IT IS SAFE. I TRULY BELIEVE THERE IS SOME WIRING PROBLEM OR ELECTRICAL PROBLEM THAT FORD IS IGNORING. I SEE MANY PEOPLE POSTING THIS SAME DANGEROUS STEERING FAULT ISSUE, AND IT NOT GETTING FIXED.
Electrical system, Jul 8, 2019
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING 20 MPH, THE INSTRUMENT PANEL LIGHTS FLASHED ON AND OFF. THE CONTACT ALSO STATED THAT THE REARVIEW CAMERA WAS NOT FUNCTIONING PROPERLY. THE VEHICLE WAS TAKEN TO DUBLIN HYUNDAI (LOCATED AT 6015 SCARLETT CT, DUBLIN, CA 94568, (925) 803-7700), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 53,000.
Electrical system, Jun 25, 2019
WIRING/BATTERY PROBLEM. POSITIVE POST ON BATTERY CORRODED ALONG WITH WIRING GOING TO POST. REPLACED POSITIVE WIRING AND ACCESSORIES WIRING ALONG WITH A NEW BATTERY. POSITIVE POST STARTED TO CORRODE AGAIN NOW THE BATTERY DIES RANDOMLY AND NEEDS JUMP START