2016 Ford Explorer
Problems, recalls and owner-reported issues
Structure is the leading concern among 2,452 owner complaints filed for this model year. This is the 2nd highest complaint count among 26 Explorer model years with reports.
Of the 2016 reports, 39 involved a crash and 14 involved a fire. 59 people were injured.
What owners report most often
Recalls and investigations
Structure, bodyJul 14, 2026
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Campaign 26V448000 on NHTSA.gov
Equipment, electrical, engine block heaterOct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
An electrical short circuit can increase the risk of a fire.
Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Campaign 25V685000 on NHTSA.gov
Structure, bodyMay 23, 2025
Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.
Dealers will repair the B-pillar trim, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2025. A second notice will be sent once the final remedy is available, anticipated November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S53.
Campaign 25V347000 on NHTSA.gov
Structure, body, roof and pillarsJan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Campaign 24V031000 on NHTSA.gov
Suspension, rearJul 15, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.
Campaign 21V537000 on NHTSA.gov
Structure, bodyMay 5, 2021
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Campaign 21V316000 on NHTSA.gov
Suspension, rearMar 12, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.
Campaign 20V675000 on NHTSA.gov
Power train, axle assembly, axle shaftNov 10, 2020
Ford Motor Company (Ford) is recalling certain 2014-2016 Explorer, 2014-2015 Taurus and 2014 Edge vehicles equipped with 2.0L or 2.3L engines and front wheel drive. The support bracket for the front drive axle halfshaft may fail.
The failed bracket could result in a loss of park function which can cause unintended vehicle movement, and loss of motive power while driving which increases the risk of a crash.
Ford will notify owners, and dealers will replace the link shaft bracket, free of charge. Parts are not currently available. Owners received an interim notification detailing safety risk December 8, 2020. A second letter will be mailed when parts become available in January 2021. The recall began February 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S63.
Campaign 20V692000 on NHTSA.gov
Suspension, rearJun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Campaign 19V435000 on NHTSA.gov
SeatsNov 29, 2017
Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.
In the event of a crash, a seat occupant that is not properly restrained has an increased risk of injury.
Ford will notify owners, and dealers will inspect the tightness of the power seat track upper pivot link bolt, either applying threadlocker or replacing the lift link and hardware, free of charge. Interim letters are expected to go out January 15, 2018. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S40.
Campaign 17V767000 on NHTSA.gov
Wheels, hubAug 28, 2017
Ford Motor Company (Ford) is recalling certain Wheel Hub Bearing assemblies, part number HB5Z-1104-C, incorrectly listed as being for installation on the rear axles of 2011-2017 Ford Explorer 4X2 vehicles. These bearings assemblies were manufactured without a self retention feature, possibly resulting in the separation of the wheel or wheel end.
A loss of the wheel or wheel end can increase the risk of a crash.
Ford will notify the distributors of the hubs specifying that they are to only be used on drive axles. It is believed that none of the hubs were purchased from Ford dealers for the incorrect application. Owners may contact Ford customer service at 1-866-436-7332.
Campaign 17E048000 on NHTSA.gov
Seats, front assembly, reclinerJun 28, 2016
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
The seat back may not adequately restrain the occupant during a crash, increasing the risk of injury.
Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall begin on August 18, 2016. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 16C11.
Campaign 16V475000 on NHTSA.gov
Engine and engine cooling, engineMar 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Lincoln MKC vehicles manufactured November 25, 2013, to January 25, 2016, and 2016 Ford Explorer vehicles manufactured October 20, 2014, to January 28, 2016. The affected vehicles are equipped with 2.3L GTDI engines and engine block heaters. These engine block heaters have elements that may overheat while plugged in.
Overheating of the engine block increase the risk of a fire.
Ford will notify owners, and dealers will replace the engine block heater, free of charge. Dealers will also inspect and replace the electrical cord, as necessary. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S14. Note: Owners should not use the engine block heater until the vehicle has been remedied.
Campaign 16V183000 on NHTSA.gov
Fuel system, gasoline, storage, tank assembly, mountingSep 28, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Lincoln MKS, and 2016 Ford Explorer vehicles manufactured on July 24, 2015. During vehicle production, the fuel tank attachment bolts may not have been properly tightened. As a result, the fuel tank straps may fracture and the fuel tank could separate from the vehicle.
If the fuel tank separates from the vehicle, a fuel leak may occur, increasing the risk of a fire.
Ford will notify owners, and dealers will tighten the fuel tank attachment bolts, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S26.
Campaign 15V605000 on NHTSA.gov
Parking brakeJul 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
If the parking brake does not fully engage and the transmission is left in a gear other than 'Park' while on a slope, the vehicle may roll away, increasing the risk of a crash.
Ford will notify owners, and dealers will test the operation of the parking brake system, and if necessary, replace the parking brake control assembly, free of charge. The recall began on September 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C07.
Campaign 15V464000 on NHTSA.gov
Representative owner complaints: electrical system
125 reports, newest first. Show all
Power train, Electrical system, Other or unspecified, Jun 15, 2019
PROBLEM FIRST APPEARED ON JUNE 3, 2016 WITH ABOUT 10,000 MILES. I WAS DRIVING ON INTERSTATE 95 PAST PHILADELPHIA AIRPORT ABOUT 9:30 AM AT ABOUT 60 MPH. THE VEHICLE HAD BEEN DRIVEN FROM A COLD START FOR ABOUT 20 MINUTES. IT WAS RAINING MODERATELY. THE BACKUP CAMERA SUDDENLY APPEARED ON THE SCREEN IN THE CENTER CONSOLE AND THE TRANSMISSION SHUDDERED SLIGHTLY. I ALSO NOTICED THAT THE DASHBOARD DRIVE INDICATOR, WHICH NORMALLY IS LIT RED WHEN IN DRIVE, WAS WHITE, AS WERE ALL THE OTHER INDICATORS (R, N, ETC). I JIGGLED THE SHIFTER WITHOUT PRESSING THE SHIFTER BUTTON BUT THAT DID NOT FIX THE PROBLEM. THE TRANSMISSION APPEARED TO BE STILL IN DRIVE SINCE THE CAR STILL HAD POWER AND WAS NOT SLOWING DOWN. IT LASTED FOR ABOUT 15 SECONDS AND THEN THE DISPLAY RETURNED TO NORMAL AND THE D INDICATOR RETURNED TO ITS NORMAL RED MODE. ABOUT 30 SECONDS LATER THE PROBLEM RETURNED AND STAYED FOR 10 TO 15 SECONDS AND THEN AGAIN REVERTED BACK TO NORMAL. THIS BEHAVIOR REPEATED ONE OR TWO MORE TIMES IN THE NEXT COUPLE OF MINUTES. AFTER THIS SERIES OF EVENTS THE CAR SEEMED TO BE NORMAL FOR THE REST OF MY 1.5 HOUR TRIP AND HAS BEEN FINE UNTIL AUG 13, 2016 WHEN THE SAME BEHAVIOR HAPPENED AGAIN. THIS COULD BE A SERIOUS SAFETY PROBLEM IF IT GETS WORSE IF FOR NOTHING ELSE THAN IT IS CERTAINLY A DISTRACTION AND MAY RESULT IN TRANSMISSION DAMAGE AND LOSS OF CONTROL. I DID TALK TO THE SERVICE MANAGER AT MY FORD DEALER (SHERIDAN FORD, RT 2 KIRKWOOD HIGHWAY, WILMINGTON DE) ON JULY 21, 2016 WHEN I WAS GETTING AN OIL CHANGE AND I DESCRIBED THE FIRST INCIDENT. HE DID NOT SEEM VERY CONCERNED. HE SAID THAT THEY HAD NEVER HEARD OF THAT HAPPENING BUT DID NOT HAVE ME WRITE ANYTHING DOWN. I TOLD HIM THAT IF IT HAPPENED AGAIN, I WOULD CONTACT FORD AND THE DEALER. THE PROBLEM HAS OCCURRED 12 MORE TIMES. I HAVE TOLD THE DEALER ABOUT IT EVERY TIME. I HAVE FURTHER TEXT DOCUMENTATION.
Electrical system, Jun 12, 2019
1. RIGHT REAR PASSENGER HEATED SEAT SUDDENLY STOPPED WORKING. THE LIGHT TURNS ON BRIEFLY BUT SHUTS OFF. I HAVE SEEN MULTIPLE COMPLAINTS ABOUT THIS ISSUE BUT NOT ON THIS SITE. 2. FRONT CAMERAS BECAME FOGGED THIS WINTER AND ARE USELESS NOW SHOWING A CLOUDY SCREEN. 3. EVERY TIME I PUT THE VEHICLE IN GEAR I GET A MESSAGE STATING PARK AID FAULT CHECK PARK AID #1 AND #3 ARE KNOWN PROBLEMS AND HAVE HAPPENED TO MULTIPLE OWNERS OF 2016 FORD EXPLORERS.
Electrical system, Air bags, Seat belts, May 29, 2019
THE AIRBAG WARNING LIGHT HAS COME ON. IN TAKING THE CAR TO THE DEALERSHIP, THIS WAS TRACED BACK TO FORD'S ERROR CODE DTC B141B AND/OR B141C. THIS ERROR CODE HAS TO DO WITH FORD INSTALLING A DEFECTIVE WIRING HARNESS FOR THE REAR SEAT INFLATABLE AIRBAGS AND COULD CAUSE THEM TO FAIL TO OPERATE DURING A COLLISION. THE DEALERSHIP (SHEEHY FORD, MIDLOTHIAN, VA) REFUSES TO REPAIR THE VEHICLE. I ALSO CONTACTED FORD MOTOR COMPANY TWICE (5/29/19 AND IN APRIL 2019) AND THEY ALSO REFUSE TO REPAIR THE VEHICLE DESPITE IT BEING AN OBVIOUS SAFETY DEFECT THAT SHOULD BE COVERED UNDER THEIR SAFETY RESTRAINT WARRANTY. THE FACT THAT FORD IS REFUSING TO STAND BEHIND THE SAFETY OF THEIR VEHICLE HAS ME CONCERNED. *TR
Electrical system, May 29, 2019
2016 FORD EXPLORER. CONSUMER WRITES IN REGARDS TO INADVERTENT OPENING OR CLOSURE OF REAR CARGO DOOR. *LD THE CONSUMER STATED WHEN THE REAR CARGO DOOR INADVERTENTLY CLOSES IT STRIKES THE OCCUPANT ON THE HEAD OR BACK. *JS
Steering, Electrical system, Electronic stability control (ESC), Apr 25, 2019
LOSS OFF POWER STEERING AND STABILITY CONTROL
Electrical system, Air bags, Mar 9, 2019
THE AIRBAG CONTROLLER LIGHT IS ON ON THE DASH. I HAD A DIAGNOSED AND MY DEALERSHIP AND THEY COME TO SAY THAT THE WIRING HARNESS CONTROL IN THE REAR AIRBAGS IS DAMAGED AND NEEDS TO BE REPLACED. THE DEALERSHIP I SAID THIS IS A SIGNIFICANT ISSUE THAT HAS BEEN NOTICING IN 2016 FORD EXPLORE MODELS MORE AND MORE. I AM CURIOUS IF THIS IS A SAFETY RECALL THAT NEEDS TO BE TAKEN CARE OF BY FORD.
Electrical system, Jan 23, 2019
NAVIGATION AND RADIO SCREEN KEEPS GOING OUT OR TURNING BLACK REAR PASSENGER DOOR LOCK WON'T LOCK OR UNLOCK.
Electrical system, Air bags, Vehicle speed control, Oct 29, 2018
ON A CITY STREET EXPERIENCE LOSS OF ACCELERATING POWER WHILE COMING TO STOP AND CROSSING AN INTERSECTION THE VEHICLE WILL STAR AT A SNAIL PACE BRINGING UP THE SPEED TO 40 MPH ON LIMP MODE SINCE THE VEHICLE SERVICE WRENCH TOOL AND AIR BAG LIGHT UP ON THE DASH BOARD VEHICLE WILL NOT RESPOND PUSHING DOWN ON THE GAS PEDAL.
Electrical system, Engine, Oct 4, 2018
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING 35 MPH, THE VEHICLE STALLED WITHOUT WARNING AND LOST POWER. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO STEVE ROGERS FORD (LOCATED AT 9760 OH-64, WATERVILLE, OH 43566, (419) 878-8151) TO BE DIAGNOSED. THE MECHANIC WAS UNABLE TO RETRIEVE A FAULT CODE OR DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT AND PRIMARILY OCCURRED DURING HOT, HUMID WEATHER WITH THE AIR CONDITIONING ACTIVATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 72,400.
Electrical system, Engine, Sep 10, 2018
I WAS DRIVING ON THE NYS THRUWAY AROUND 70-75MPH AND THE CAR DECELERATED TO 55MPH THEN WAS LIKE IN A COAST MODE. THE WRENCH LIGHT CAME ON AND IT SAID SEE MANUAL. I PUSHED THE PEDAL ALL THE WAY TO THE FLOOR AND IT WOULD NOT GO ANY FASTER. I WAS ABLE TO COAST TO THE SIDE OF THE ROAD. I TURNED CAR OFF AND THEN TURNED IT BACK ON AND PUSHED OK TO THE SEE MANUAL. I WAS THEN ABLE TO DRIVE IT. WE COULD OF BEEN KILLED IF SOMEONE WAS BEHIND ME. I BROUGHT IN TO DEALER AND SAID THEY REALLY DIDN'T FIND ANYTHING WRONG OR SEE ANY INFO ON THE COMPUTER WHEN CAR WAS HOOKED UP. VERY SCARY AS I HAVE READ ONLINE MORE PEOPLE HAVE HAD THIS HAPPEN TO THEM.
Electrical system, Sep 8, 2018
THE CAR WAS WEAK TO START FOR 2DAYS.. DAY 3@ 5AM I PUSHED THE KEY 2XS TO START MY 2016 FOR EXPLORER FROM INSIDE MY HOUSE. IT DIDN'T START SO I GOT INSIDE THE CAR & PUSHED THE START BUTTON, IT MADE CLICKING SOUND THEN SAID SYSTEM SHUTTING DOWN! LATER THAT. AFTERNOON I LOOKED UNDER HOOD & BATTERY ACID WAS EVERYWHERE. THE MOTOR CRAFT BATTERY EXPLODED!
Steering, Electrical system, Jul 26, 2018
WHILE DRIVING ON THE FREEWAY (75 MPH), SEVERAL ALERTS POPPED UP OUT OF NOWHERE - HILL ASSIST ERROR, STEERING CONTROL ERROR, TERRAIN ASSIST ERROR, STABILITY ERROR. IT TOLD ME TO PULL OVER IMMEDIATELY. ONCE I STOPPED MY CAR AND RESTARTED IT, MY POWER STEERING WAS NO LONGER WORKING. THIS HAS HAPPENED TWICE NOW - BOTH TIMES ON THE FREEWAY. IT'S EXTREMELY DANGEROUS TO HAVE STEERING GO OUT - I'M CONCERNED FOR THE SAFETY OF THE VEHICLE. THE FORD DEALERSHIP IS TELLING ME THAT I NEED TO REPLACE THE ELECTRIC STEERING COMPONENT FOR $2,000. THE CAR HAS LESS THAN 50,000 MILES ON IT, SO IT DOESN'T MAKE SENSE THAT THE STEERING COMPONENT WOULD ALREADY NEED REPLACING.
Electrical system, Jul 20, 2018
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING VARIOUS SPEEDS, ALL THE WARNING INDICATORS ON THE INSTRUMENT PANEL INTERMITTENTLY ILLUMINATED. IN ADDITION, THE INSTRUMENT PANEL INDICATORS INTERMITTENTLY DIMMED. THE VEHICLE WAS TAKEN TO CHUCK COLVIN FORD NISSAN (1925 N HWY 99 W, MCMINNVILLE, OR 97128, (503) 472-6124) WHERE THE TECHNICIAN TEST DROVE THE VEHICLE, BUT COULD NOT DUPLICATE THE FAILURES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 38,000.
Steering, Electrical system, Jul 9, 2018
ORIGINALLY I HAD A LIGHT COMING ON WHEN DRIVING DOWN THE ROAD SAYING "STEERING FAULT SERVICE NOW" IT WOULD COME ON AND GO OFF OR OCCASIONALLY I WOULD HAVE TO PULL OVER AND RESTART MY TRUCK TO RESET. AFTER ABOUT A WEEK I STARTED HAVING MULTIPLE LINES COME ON AT ONE TIME FLASHING AT ME WHILE DRIVING SAYING "SERVICE ADVANCE TRAC, HILL START ASSIST NOT AVAILABLE, SERVICE ADVANCE TRAC AND STEERING FAULT SERVICE NOW". WHEN THESE LIGHTS COME ON I LOSE ALL POWER STEERING IN MY VEHICLE AND I'M UNABLE TO STEER AT ALL. THIS HAS HAPPENED MULTIPLE TIMES AND IT HAS BECOME EXTREMELY UNSAFE TO DRIVE. IT HAS ALWAYS BEEN WHILE DRIVING, BUT OTHER THAN THAT I SEE NO RHYME OR REASON OR OTHER FACTORS THAT ARE THE SAME WHEN THE LIGHTS HAVE CAME ON. I TOOK MY TRUCK TO MY MECHANIC TO LOOK AT AND HE FOUND ONLINE THAT THIS IS AN ISSUE MANY PEOPLE ARE BLOGGING ABOUT AND COMPLAINING ABOUT. HE HOOKED MY TRUCK UP TO THE COMPUTER BUT COULD NOT GET ANY TYPE OF ERROR CODE TO COME BACK AND SUGGESTED I FOLLOW UP WITH FORD TO HAVE THEM LOOK AT IT BUT ALSO SUGGESTED THAT I CONTACT SOMEONE TO SEE IF THIS HAS SOME TYPE OF RECALL BECAUSE IN HIS WORDS "THIS IS GOING TO KILL SOMEONE". I HAVE CHECKED BUT NO RECALLS HAVE BEEN MADE AS OF NOW BUT DID SEE THERE WAS A VERY SIMILAR PROBLEM IN THE 2011-2013 EXPLORERS AND A RECALL WAS MADE. I HAVE AN APPOINTMENT THIS WEEK FOR MY TRUCK TO GO TO THE FORD DEALERSHIP TO BE LOOKED AT BUT FEEL STRONGLY THAT THIS IS SOMETHING THAT NEEDS TO BE RECALLED NOW ON THE 2016 FORD EXPLORER. I HAVE 2 YOUNG DRIVERS THAT OCCASIONALLY DRIVE MY VEHICLE, IF ONE OF THEM WERE TO DRIVE IT WHEN THE STEERING WENT OUT, I DON'T WANT TO THINK WHAT COULD HAVE HAPPENED. THIS IS TO SERIOUS TO IGNORE AND I SEE TO MANY COMPLAINTS FROM OTHER PEOPLE ONLINE SO I KNOW THIS IS NOT SOMETHING THAT ONLY I AM GOING THROUGH. PLEASE RECALL THESE VEHICLES AND HAVE THIS CHECKED.
Electrical system, Visibility/wiper, May 12, 2018
THERE IS A DESIGN DEFECT IN THE FRONT PARKING SENSORS WHERE AFTER FREEZING, WATER CAN ENTER THE OPENING OF PARKING SENSOR AND SHORT CIRCUIT THE WIRING HARNESS CAUSING THE PARKING AID SYSTEM TO FAULT. THIS PREVENTS THE DRIVER FROM UTILIZING THIS KEY SAFETY FEATURE WHEN PARKING OR BEING ALERTED ON THEIR CLOSE PROXIMITY OF SURROUNDING OBJECTS.
Electrical system, Engine, May 5, 2018
I BOUGHT MY FORD EXPLORER 2 YEARS AGO BRAND NEW AND EVERYS SINCE I BOUGHT IT I HAVE HAD HEADACHES. DIZZINESS WHILE DRIVING AND ELECTRICAL PROBLEMS WITH IT. MY HUSBAND HAS ALSO BEEN TREATED FOR HEADACHES AND WE BELIEVE IT IS FROM OUR FORD, WE DON'T HAVE THESE ISSUES UNTIL WE ARE IN THE CAR FOR LONG PERIODS OF TIME. THE DASHBOARD GOES BLANK A LOT AND IT LOSES POWER.
Electrical system, Other or unspecified, Apr 2, 2018
DASH/SPEEDOMETER WENT BLACK - HEAT AND AIR SYSTEM INOPERABLE - NO TURN SIGNALS - POWER DECREASED AND POWER STEERING NOT FULLY FUNCTIONING. ALL OF THIS HAPPENED WHEN I PLACED THE CAR IN PARK AND REALIZED THE RADIO AND INTERIOR LIGHTS WERE NOT AUTOMATICALLY SHUTTING OFF SO I RESTARTED THE CAR AND STILL NOTHING. DEALERSHIP RECOMMENDED DISCONNECTING THE BATTERY - THIS DID FIX PART OF THE PROBLEMS BUT THE SYNCH HEALTH REPORT IS STILL NOT SHOWING COMPLETLELY CLEAR AND THE CHECK ENGINE LIGHT CAME ON THEN WENT OFF AFTER DRIVING A FEW MILES . CONCERNED IF IT IS SAFE TO DRIVE ESPECIALLY IF THIS IS A POSSIBLE ELECTRICAL PROBLEM - CAR IS JUST AT 23K MILES AND ALSO HAD TO HAVE THROTTLE BODY REPLACED AT AROUD ONLY 3K MILES. NOT FELING SAFE IN THE CAR AT THIS POINT.
Electrical system, Jan 26, 2018
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE INDEPENDENTLY STARTED ITSELF WITHOUT WARNING. WOODY SANDERS FORD (235 W MITCHELL AVE, CINCINNATI, OH) WAS CONTACTED AND STATED THAT THIS PARTICULAR FAILURE ONLY APPLIED TO THE POLICE CRUISERS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 13,000. THE VIN WAS NOT PROVIDED.
Electrical system, Jan 5, 2018
"SYSTEM OFF TO SAVE BATTERY" MESSAGE ON FORD EXPLORER 2016. I HAVE READ OVER 500 POST TO THIS PROBLEM WHICH MY WIFE'S SUV JUST STARTED TO SHOW. MOST OF THEM ARE SAYING IN SOME CASES THE SUV DIED WHILE IN TRAFFIC. THE DEALERS ARE SAYING ITS THE BATTERY BUT IN MOST CASES THE SUV HAS ONLY A COUPLE OF THOUSAND MILES ON IT OR IS ONLY A YEAR OLD. SOMEONE WILL BE KILLED IF THIS IS NOT ADDRESSED SOON. AS OF NOW, OURS HAPPENS WHEN EITHER IN PARK PRIOR TO RUNNING OR SHUTTING DOWN THE SUV HOWEVER IN RESEARCHING IT, THIS IS HAPPENING IN THE F150, EXPLORER, AND A NUMBER OF OTHER FORD CARS AND TRUCKS ALL OVER THE COUNTRY AND CANADA. SHE DRIVES APPROX 10 MILES EACH WAY TO WORK AND ON WEEKENDS MAYBE 20 OR 30 MILES. THIS IS NOT COUNTING NUMEROUS ERRANDS RUN SO ITS NOT LACK OF DRIVING.
Power train, Electrical system, Nov 17, 2017
POWER TRAIN CONTROL MODULE AND ENGINE CONTROL MODULE FAILED UNDER HIGH SPEED ON A 4 LANE ROAD. WE WERE ALMOST KILLED BY BEING REAR-ENDED TRAFFIC AS VEHICLE CAME TO A COMPLETE STOP, ENGINE OFF, AND COMPLETELY DEAD. NOT ABLE TO STEER OR BRAKE. VEHICLE HAS ONLY 12,854 ACTUAL MILES. PLEASE FIX THIS BEFORE OTHERS ARE KILLED AND/OR MAIMED.
Electrical system, Nov 1, 2017, fire
THE VEHICLE WAS PARKED, AND WHEN WE ATTEMPTED TO START THE VEHICLE BY PUSHING THE START BUTTON, THE VEHICLE DID NOT START BUT A LARGE AMOUNT OF SMOKE POURED OUT OF THE DASHBOARD. THE REPAIR FACILITY PERFORMED A SIGNIFICANT AMOUNT OF WORK WITH THE ELECTRICAL SYSTEM, BUT STATED THAT THEY DID NOT DISCOVER WHAT THE ROOT CAUSE OF THE ISSUE WAS.
Electrical system, Other or unspecified, Engine, Sep 11, 2017
I HAVE A 2016 FORD EXPLORER LIMITED EDITION UNDER MY DADS NAME AND MY WIFE IS THE PRIMARY DRIVER ON IT. AFTER GETTING OUR CAR I DROVE IT DAILY AS COMMUTER FOR 2 MONTHS AND SOMETIMES I SMELL SOMETHING BAD INSIDE LIKE BURNED TIRES BUT I JUST IGNORED IT BECAUSE I SAID MY CAR IS BNEW AND MAYBE ITS FROM OUTSIDE AND AFTER THAT MY WIFE START DRIVING IT BUT LAST DECEMBER 2016 WE WENT TO VEGAS AND I JANSSEN (HUSBAND) IS THE ONE DRIVING ON THE CAR AND SMELLED SOMETHING BURNED TIRES INSIDE THE CAR WHILE CRUISING ON IT, I CHECKED THE TIRES/BREAK OUTSIDE BUT I DONT SMELL IT FROM OUTSIDE, SO AFTER THAT WE WENT TO OUR DEALER AND CHECKED IT FOUND OUT THERES A CARBON MONOXIDE PRESENT INSIDE AND THEY FIXED IT BY COVERING THE HOLES OF THE CAR THAT MAY BE THE ENTRY OF SMOKE FROM OUTSIDE AND UPDATING THE SYSTEM AS PER SERVICE GUY TOLD ME "RENE" AND SAID EVERYTHING WORKS WELL NOW. AFTER FEW MONTHS IT WAS JUNE 2017 I SMELLED IT AGAIN AND CONCERNED ME MORE BECAUSE MY WIFE IS PREGNANT AND I KNOW CO2 IS REALLY BAD ON OUR HEALTH AND I KNOW THAT BECAUSE WE ARE BOTH NURSES AND WE SENT IT BACK TO THE DEALER AND MY SERVICE GUY "LUIS " TOLD ME THEY PUT SOME RUBBER IN THE REAR DOOR FOR THE PURPOSE OF SEALING THE DOOR THAT MAYBE THE SMOKE FROM THE EXHAUST IS THE ONE CAUSING IT AND TAKE NOTE " THE CAR STAYS 1 WEEK IN THE SERVICE DEPARTMENT". AND NOW SEPT 2017 THE SAME THING IS HAPPENING AND I CALLED MY DEALERSHIP, I SPOKE TO LUIS AND CASEY AND THEY TOLD ME THERE'S STILL WAITING FOR THE SERVICE MANAGER BECAUSE THEY ARE BUSSY, I TOLD THEM MY CONCERN THAT MY WIFE IS PREGNANT SHE'S ON 8 MONTHS NOW AND IT MAKES ME REALLY CONCERNED OF WHAT IS GOING ON WITH THE CAR BUT THEY JUST TOLD ME TO WAIT, AND MY WIFE DAILY CAR IS IT. SO INCASE SOMETHING HAPPEN WITH MY FAMILY THIS IS NOT REALLY SAFE FOR US, SO I REALLY NEED A BIG HELP FROM YOU NHTSA THAT WE CAN SOLVE THIS PROBLEM, I HEARD OTHERS TOO ESP POLICE. TY
Power train, Electrical system, Engine, Aug 7, 2017
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE LOST POWER AND THE SERVICE "WRENCH" WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD AND WAS TOWED TO THE DEALER (NORTHTOWN FORD IN MENOMONIE, WI) WHERE THE THROTTLE BODY WAS REPLACED. THE FAILURE RECURRED AND THE SAME DEALER REPLACED THE RETAINING CLIP, BUT THE FAILURE RECURRED. THE CONTACT MADE THE MANUFACTURER AWARE OF THE FAILURES AND REQUESTED A BUY-BACK. THE CONTACT WAS INFORMED THAT THE ISSUES DID NOT WARRANT A BUY-BACK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 9,000.
Electrical system, Jul 19, 2017
I WAS BACKING OUT OF A PARKING SPACE. THE REARVIEW CAMERA ON THE FORD SYNC SYSTEM WOUND UP SHOWING A FROZEN IMAGE. IT TOOK ME SEVERAL SECONDS TO REALIZE THAT THE IMAGE I WAS LOOKING AT WAS ACTUALLY AN OLD IMAGE! I WAS LUCKY I DID NOT RUN INTO SOMEONE SINCE I WAS ESSENTIALLY BACKING UP WITHOUT THE ABILITY TO SEE ANYTHING.
Electrical system, Electronic stability control (ESC), Fuel/propulsion system, Jul 6, 2017
I AM AN OWNER OF A 2016 FORD EXPLORER THAT WAS PURCHASED BRAND NEW AT A DEALERSHIP HERE IN AZ LAST YEAR IN JANUARY. IMMEDIATELY AFTER PURCHASE, I STARTED NOTICING FUEL LEAKAGE FROM THE VEHICLE AND VEHICLE USING A LOT OF GAS EVERYDAY. I TOOK MY TRUCK BACK TO THE DEALERSHIP AND WAS TOLD EVERYTHING IS OK. AS TIME WENT ON, I NOTICED THAT EVERY TIME I ACCELERATED ON THE GAS, THE TRUCK SLOWED DOWN. TOOK TRUCK TO DEALERSHIP AND WAS TOLD ONCE AGAIN NOTHING IS WRONG. A COUPLE OF MONTHS AGO, THE BATTERY DIED. I HAVE THE TRUCK TOOWED TO THE DEALERSHIP AND THEY REPLACED THE BATTERY. TWO WEEKS LATER, THE BATTERY DIES AGAIN. I HAD IT TOWED TO THE DEALERSHIP AGAIN. THEY REPLACED THE BATTERY AGAIN AND NOTICED A RECALL ON THE TRUCK. A WEEK LATER I'M DRIVING MY KIDS TO SCHOOL WHEN THE DASHBOARD GOES BLACK AND THEN LIGHTS UP AGAIN. ALL OF A SUDDEN IT HAPPENS AGAIN, THE DASHBOARD GOES BLACK AND THE SPEED STARTS DECELERATING. I HURRY UP AND GET TO THE SAFETY SIDE OF THE HIGHWAY. I CUT THE TRUCK COMPLETELY OFF, WAITED A FEW MINUTES AND IT STARTED RIGHT BACK UP. I TOOK THE TRUCK TO THE DEALERSHIP. ONCE AGAIN, I'M TOLD THAT NOTHING IS WRONG WITH THE VEHICLE. YESTERDAY THE TRUCK DASHBOARD STARTS GOING ON AND OFF. THEN THE TRUCK COMPLETELY DIES. I CALLED ROADSIDE ASSISTANCE AND HAD THE TRUCK TOWED TO THE DEALERSHIP. I WAITED FOR OVER 5 HOURS AT THE DEALERSHIP BEFORE THEY TOLD ME WHAT "MIGHT" BE THE PROBLEM. I WAS TOLD THERE MIGHT BE AN ELECTRICAL SHORTAGE BETWEEN THE MONITOR, RADIO, ODOMETER, AND CLIMATE CONTROLS THAT IS CAUSING THE VEHICLE TO SHUT DOWN. THE DEALERSHIP DOESN'T HAVE PARTS TO FIX IT BUT CAN ORDER THEM AND IT MIGHT TAKE A FEW WEEKS TO GET THEM. AS OF NOW I HAVE NO AIR CONDITIONER AND MY RADIO ISN'T WORKING. I HAVE SPOKEN WITH SEVERAL CUSTOMER SERVICE MANAGERS ABOUT THE VEHICLE AND WAS TOLD THERE ISN'T ANYTHING THAT CAN BE DONE EXCEPT WAIT FOR FORD TO FIX IT.